International Truck & Engine Corporation: Service Brakes, Air › Supply › Hoses, Lines/Piping, and Fittings
International Truck & Engine Corporation reported this defect to federal regulators on Sep 24, 2007 and put the number of vehicles at risk at 294. The repair is free for as long as the recall stands.
The defect
CERTAIN IC SCHOOL AND COMMERCIAL BUSES MANUFACTURED BETWEEN MARCH 29 AND AUGUST 28, 2007. THE ROUTING OF THE SERVICE AND PARKING BRAKE RUBBER DROP HOSES TO THE REAR AXLE'S BRAKE COMPONENTS MAY BRING THEM TOO CLOSE TO THE EXHAUST TAIL PIPE.
The risk
THE RUBBER HOSES MAY MELT IF ROUTED TOO CLOSE TO THE TAIL PIPE CAUSING EITHER OF THE TWO POSSIBILITIES: 1) AN AIR LEAK ON THE PARKING BRAKE HOSE MAY CAUSE THE PARKING BRAKES TO SLOWLY APPLY WHILE DEPLETING BOTH THE PRIMARY AND SECONDARY AIR CIRCUITS. EVEN THOUGH THE AIR PRESSURE GAUGE AND LOW AIR PRESSURE WARNING BUZZER WOULD SOUND, THESE CONDITIONS COULD CAUSE THE BUS TO SLOW DOWN OR STOP UNEXPECTEDLY WHICH MAY RESULT IN A VEHICLE CRASH. 2) AN AIR LEAK ON THE SERVICE BRAKE HOSE MAY RESULT IN EXTENDED STOPPING DISTANCES WHILE ALSO DEPLETING THE PRIMARY AIR TANK POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The remedy
DEALERS WILL INSPECT THE RUBBER BRAKE HOSES TO DETERMINE THEIR PROXIMITY TO THE TAIL PIPE. ANY HOSE FOUND TO BE CLOSER THAN 4" WILL BE REPLACED AND BOTH HOSES WILL THEN BE RE-ROUTED TO ENSURE PROPER DISTANCE FROM THE TAIL PIPE. THE INSPECTION AND REPAIR WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 16, 2007. OWNERS CAN CONTACT IC CORPORATION AT 1-800-843-5615 OR INTERNATIONAL AT 1-800-448-7825.
2 model years covered
Newest first| Vehicle | Complaints | Recalls | Fires | Crashes |
|---|---|---|---|---|
| 2008 Ic Fecb | 0 | 4 | 0 | 0 |
| 2008 Ic Bus Fesb | 0 | 9 | 0 | 0 |
What this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 07V447000.
Full record for the 2008 Ic Fecb → · Recalls carrying a do-not-drive advisory → · Where this data comes from →