Freightliner LLC: Fuel System, Diesel
Freightliner LLC reported this defect to federal regulators on Apr 27, 2005 and put the number of vehicles at risk at 16,000. The repair is free for as long as the recall stands.
The defect
CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.
The risk
SHOULD THE ENGINE STALL WHILE THE VEHICLE IS IN USE, A POSSIBLE VEHICLE CRASH COULD OCCUR.
The remedy
CUMMINS WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER AND THOMAS BUILT AND REPLACE THE FUEL LIFT PUMP FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS.
36 model years covered
Newest firstWhat this page is, and what to do next
A recall is not an opinion. It is a Part 573 report a manufacturer is required by federal law to file once it decides a defect poses an unreasonable risk to safety, and it commits them to repairing the vehicle at no cost to the owner. The three passages above are the manufacturer’s own wording as published by NHTSA.
This page describes the campaign. It cannot tell you whether one particular car has already been through the shop — that is tracked by VIN, and only the manufacturer knows it. Check yours at nhtsa.gov/recalls or with a franchised dealer, quoting campaign number 05V205000.
Full record for the 2003 Freightliner FS-65 School Bus Chassis → · Recalls carrying a do-not-drive advisory → · Where this data comes from →