2016 Ram 1500 complaints

The contact owns a 2016 Ram 1500. The contact stated that while the vehicle was parked, oil was leaking onto the ground. The vehicle was taken to the dealer where it was diagnosed with a cracked engine oil cooler housing. The dealer replaced the engine oil cooler housing. The manufacturer was not made aware of the failure. The failure mileage was approximately 154,000. The VIN was unavailable.

The truck lost steering power and I was able to stop without wrecking but I have no control of the steering at all

There is an open recall for certain vin#'s 20v-475 that happened to my vehicle and according to message boards a lot of other vehicles that have the failure of the tone wheel to the exact way the recall is listed but for some reason the vin does't fall under the recall. My vehicle had a complete shut down without warning or noises while driving at highway speeds on a windy narrow parkway with minimal shoulder. If I wasn't driving in the right lane at the time my situation could've been even more dangerous than it already was. I don't understand how a part that that is used in all ecodiesel engines from 2014-2018 and has a known failure is supposedly only affecting a small percentage of engines when they all have the same part. I have searched message board after message board and have found a lot of listings of this part failure all on vin's that for some reason aren't on the recall. As a SAFETY precaution letters should've went out to all ecodiesel vehicles within those years to at least alert drivers theres a potential for this failure. If it wasn't for the fuel pump recall that they do not have a fix for, I wouldn't have been as aware of m vehicle possibly shutting down without warning. Again I think as a SAFETY precaution letters should be sent to all ecodiesel owners alerting them of this possible engine failure that could endanger their lives and open an investigation to see why a part used in all of the vehicles only affects certain ones when it is obviously failing in

The contact owns a 2016 Ram 1500 The contact stated that while driving the vehicle stalled. The engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 22V-406000 (Fuel System, Diesel). However, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 200,000. VIN tool confirms parts not available.

While driving on the Garden State Pkwy in New Jersey I had a sudden braking event for traffic. After resuming highway speed the engine shut off and the dashboard lit up with warning lights. I coasted towards a narrow right lane shoulder and came to a stop. I was towing a tandem axle U-Haul trailer. The vehicle came to a stop and was blocking almost half of the right traffic lane. I had to be towed off the parkway. The Ram / Dodge dealership said a Tone Ring mounted between the engine and transmission failed causing the engine to suddenly stop. This resulted in a $210 tow and a $3400 repair bill. Research in this failure shows that FCI is aware of the problem and could possibly prevent the engine shutdown and hazards that followed.

The contact owns a 2016 Ram 1500. The contact stated while driving at 35 MPH, the vehicle stalled. An unknown warning message was displayed on the instrument panel. The vehicle failed to restart after several attempts and was towed to the dealer where it was diagnosed that the vehicle fuel system had failed. The vehicle was repaired. However, the failure persisted. The dealer then informed the contact that the crankshaft position sensor tone wheel was defective. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V475000 (Engine and Engine Cooling). The manufacturer was notified of the failure and informed the contact that they could not assist as the VIN was not included in the recall. The vehicle was repaired. The failure mileage was approximately 100,000.

While traveling at highway speeds on a narrow parkway with minimal shoulders, the vehicle without warning or noise shut down, almost causing a major accident and I wouldn't have been able to get to the shoulder if I wasn't in the right lane. The shoulder barely had room for my truck putting myself and other vehicles at risk. There was ABSOLUTELY no warning that my car was going to completely shut down, no lights illuminated on my dash until i was on the grass and the engine was dead. The dealership confirms the exact issue was a failure of the Magnetic tone wheel that has a NHTSA Recall# 20V-475, that is an identical symptom and diagnosis to my exact issue. The dealership Meadowlands of Carmel (845)225-8468 [XXX] in the service department quoted me $1,600.00 plus tax to replace the magnetic tone wheel. I am also a government employee and I am unable to get to work. My engine type and year (2016) is identical to this recall stated above (20V-475), but for some reason that no one at RAM Customer Service or the RAM Recall Department can identify why my VIN number is excluded from a recall that my VIN is clearly a part of. I had ZERO symptoms, warnings before I could have been potentially killed. My kids were thankfully not in the car with me. I feel this is well within the spectrum of my VIN number qualifying to participate in this recall coverage, as well as other RAMS who may not even be aware of this without doing their own research of the circumstances and symptoms. I feel i

The contact owns a 2016 Ram 1500. The contact received notification of NHTSA Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure. VIN tool confirms parts not available.

I have a 2016 ram 1500 big Ha and the other day that ignition switch went bad on the truck and I’m in New Jersey and I took it to my dealer and they said they can’t get any of the parts for about a month because no dealerships in New Jersey know dealerships on the East Coast or the West Coast have any of these parts the ignition switch that they have all trucks in the same year as me For the same problem and they can’t get the part till next month or two months they have to order it it’s on back order the park the only place that has the part is Clovis Mexico and they only had seven left in stock but if you look into the 2016 ram there’s no recalls on this On the ignition switch in the 2017 ram there is a recall on it and on a 2015 ram there is a recall on the for the ignition switch another 2016 why

The contact owns a 2016 Ram 1500. The contact received notification of NHTSA Campaign Number: 22V406000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The contact stated that the vehicle had been at the dealer for approximately two months. VIN tool confirms parts not available.

Steering is getting hard, worse at low speeds, electric power steering

I buy the vehicle with a altered odometer, in Puerto Rico. Have a lote of issuse. I have all the ividence to prove it. The place have 2 vehicle more to sale with the same millaje, a ford 150, and a chevrolet. White wiht 60,000miles. I want to know you send a investigation in the place or person. I think other People buy other vehicles whit the same dealer

I was in two separate major accidents and the airbags did not deploy. I got injuries due to this. They have been looked at by shops when repairs were made. No indication before or after of any kind regarding air bags.

Cruise control stops working. It is not a fuse per dealer maintenance services. It is the steering column wiring harness for the cruise control and they reported that they see this issue a great deal in the RAM trucks.

The Main as well as Connecting Rod Bearings prematurely failed at approximately 87,000 miles. Please note that the manufacturer warranty on the 3.0 Diesel engines from FCA/Stellantis is 100,000 miles. As the result, I was stranded on the road with horrible sounds coming from the bottom of the engine block and had to get towed. From my research, I found out that the 1st generation of this engine which I believe were installed on Ram 1500s from 2014 to 2016, had major issues with the above bearing failures well below 100,000 mile warranty period.

Remedy is not available

Abs module that controls abs, traction control, and few other areas dealing with brakes has become disabled since 11/21. Not sure what is going on but doesn’t seem to be of any importance to Chrysler and I’m not sure where else to turn. Seems that a safety issue would be of some kind of importance but apparently once you have driven the vehicle off the lot then it doesn’t pertain to them any more. Several attempts with the dealership to get repaired and attempted to contact Chrysler to no prevail…I am no a dealership so I am unable to obtain any information. Asking for assistance in why it’s so difficult for Chrysler to get parts in 8 months. After contacting dealer they are telling me it is no guarantee to get parts before 8/1/22. Brakes…vital for safety on highways wouldn’t you think?

Purchased my 2016 Ram 1500 Crew Cab 4x4 SLT Big Horn June 2019. At that point the previous owner had the truck in the shop and while there it was diagnosed that the fuel pump failed. About January 2020 I stated having the famous Hemi Tick but not all the time. I'm very ocd on all maintenance of my truck, witch I or my husband and son; both certified diesel mechanics. I only run Valvoline Full Synthetic 5w-20 oil and a K&N Oil Filter and is changed before the 5k mark. Fast forward to Oct 2021 truck starts not wanting to start, Tick is very very loud and does it warm or cold does not matter. At times would not even start. Send it to the local dealership, with CEI on, they diagnosis as 4 manifold studs are broken, 800 bucks later they are replaced. But only 4, supposedly two on each side. Get truck back, drive maybe 5 miles CEI back on. Truck running as if it has no power, getting no fuel. Was able to get it home, called dealership next morning took truck back. This happened mutiple times. Called the main dealership in Edmond, Oklahoma in an attempt to get someone to figured out why I kept getting told my truck was fixed and it was not. Come to find out after 3 months in the shop the fuel pump yet again failed. Now, there is a recall and my vin is not included but yet I have had TWO failed fuel pumps. And now June 2022 I have the famous Hemi Tick again. To witch I can only guess is the other manifold studs that they for some dumb reason did not replace when they should have.

The contact owns a 2016 Ram 1500. The contact stated while driving at an undisclosed speed and hauling a travel trailer, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was towed to the dealer where it was diagnosed with a non-reading crankshaft sensor tone wheel that had delaminated. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure. The contact related the failure to NHTSA Campaign Number: 20V475000 (Engine and Engine Cooling) however, the VIN was not included in the recall. The failure mileage was approximately 65,000.

Loss steering while Driving making turn on Freeway. No light indication on Dash ,of failure. Or engine light. No indication of any problem. But no steering. To hard to turn the wheel.

There is a current safety recall W58/NHTSA 20V-475 that covers certain ram trucks. My trucks vin didn't make the list. My trucked stalled on the interstate and the dealer diagnosed it has the tone wheel delaminated. I'm not sure how the vehicle manufacture or you came up with the VIN list but there are multiple vins that didn't make the list and having this exact failure.

The contact owns a 2016 Ram 1500. The contact stated while the vehicle was stationary at a traffic light, the vehicle stalled. The contact stated no warning light was illuminated. The contact was able to restart the vehicle after several attempts. The contact took the vehicle to an independent mechanic however, the mechanic was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 128,500.

ABS brakes and electronic braking system errors, The components and any error codes are available for inspection. When lightly holding the brake at a light I felt the abs activating in the pedal, again twice while driving within minutes from the first. I’m not a mechanic but I would think not having proper control of your brakes is a safety risk. I have not been to a dealer yet because it just happened and reading online forums it seems to be very common on my truck, hence my belief that a recall is needed. It has not been inspected by anyone yet. The warning lights came on for ABS and traction control along with a service ABS and a service electronic braking system messages. Prior to the messages a few sounds (like the seatbelt unbuckled sound) rang and a few seconds later the messages and the “pulling” feeling in the brake pedal.

The contact owns a 2016 Ram 1500. The contact stated while driving 35 MPH, the power steering assist failed to operate without warning. The contact stated that excessive force was needed to steer the vehicle while driving. The contact called the dealer and manufacturer and was informed that his vehicle was not included in NHTSA Campaign Number: 16V167000 (Steering). The vehicle was not repaired. The failure mileage was 51,000.

Loss of power steering almost impossible to turn the vehicle. I found this out at highway speed of 70 mph with no warning lights or indicators on the dash h.u.d. Even with certified pre-owned warranty and under 80,000 miles not covered under warranty and spoke with dealership and ram customer care and have been told even though they are aware of the common issue I’m stuck with the bill and they basically don’t stand behind their product.

The first sign of a problem was when my touch screen radio would randomly shut off and then turn back on again. As it would get hotter it would happen more often. Then the turn signals would have trouble flickering. The check engine light would show up and I've tried getting that figured out. When I was driving it would tell me "service transmission continue in D. Do not shift or turn engine off until you reach a desired location. You may not be able to shift again until serviced" with a blinking exclamation point. It would occasionally also say "service shifter" and sometimes when I would start it, it shuts off immediately. The worse part of all is when I was driving it doesn't automatically shift gears so I have to pull over and shut the truck off to be able to shift at the speel limit speed. This was all happening repeatedly 6 months ago before I dropped it off at the 2nd dodge dealership. The first one gave up on finding the problem. 1 year later and it's only gotten worse, aside from all the money spent.

The contact called on behalf of his son who owns a 2016 Ram 1500. The contact stated while his son was was driving approximately 55 MPH and making a turn, the steering wheel became difficult to turn. There were no warning lights illuminated. The vehicle was taken to a local dealer who diagnosed the vehicle with electric power steering assist failure. The vehicle was not repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number: 16V167000 (Steering). The approximate failure mileage was 89,000.

My 2016 RAM 1500 Laramie Crew Cab 5.7 Liter HEMI engine has an engine ticking sound that is most noticeable when the truck is first started when the engine is cold. The ticking sounds does start to go away after one to three minutes, when the engine temperature increases. The ticking noise happens both in the winter and summer when the engine is cold. This engine noise first became noticeable when the truck was two years old with approximately 30,000 miles. I purchased the RAM 1500 Laramie new on October 5, 2016. I am a former Nissan service technician. I am acutely aware of the importance of changing engine oil and oil filter at the manufacturer recommended intervals. I am VERY diligent about changing the engine oil and oil filter every 5000 miles with Mobil One synthetic or Pennzoil Platinum synthetic 5W-20 oil. As of May 20, 2022, my RAM 1500 Laramie has 76,040 miles. Other RAM 1500 5.7-Liter HEMI engine owners have reporting a ticking sound when the exhaust manifold bolts break. I inspected the exhaust manifold bolts on May 20, 2022, and they are not broken.

Power steering stopped working during operation causing for a Safety issue. Diagnosis is the Electronic Power Steering Control Module, requiring replacement of rack and pinion assembly. Recall 16V167000 from RAM acknowledges this exact issue for 2015-2016 RAM 1500's manufactured between Jan. 22, 2015 and Sep. 13, 2015. HOWEVER, even though my vehicle (VIN: [XXX]) meets these exact identifiers with a Mfg. Date of 9/10/2015 falling into the specified group, RAM is not including my VIN in the recall order. This leaves me paying out of pocket for a known manufacturer defect, rather than being covered by the recall. If this is RAM's position and unwilling to help, while this is my 7th RAM it will also be my last. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Broken exhaust manifold bolts which cause an exhaust leak between the engine block and the exhaust manifold.

Steering wheel or suspension.. I had truck aligned plus 4 new tires and still I can’t drive it straight. The back tires are trying to come around and it pushes me sideways toward on coming traffic so I can’t drive at all. Please help. It sounds like a current recall but my vin isn’t included. He very dangerous to drive it at all

I can’t steer the vehicle even after new tires,alignment , lots of play in steering wheel and it goes where it wants. I can not drive it anywhere

Header bolt has broken off and have exhaust fumes being released from the engine compart that should be going thru the header and out the exhaust pipes. The dealer is aware and wont repair due to out of warranty when this issue is hazard to the people and the environment

Front air suspension failed. This is a problem with these trucks and ram won't do anything....

The electric power steering assist is not working on my 2016 ram 1500 and there is a recall on certain 2015-2016 rams on this issue where the circuit board was contaminated which caused the failure (recall S19) I contacted Ram on this and they told me that my truck is not one of them as it was made in 2015 before they put in the faulty circuit boards. My truck is doing exactly what the recall says happened to the other trucks and how can Ram be absolutely sure my truck did not get one of the bad circuit boards. It was made in 2015 and is a 2016 edition which is what the recall covered. It may be Vin specific but as my truck has the same exact symptoms, I feel this recall should be expanded. The vehicle has not been checked yet but I am told that there are no open recalls on my truck so I feel they will charge me whether it should be recalled or not. there are no warning lamps on . In closing I believe that if my truck has the same symptoms as the recall then the board should be replaced no charge by Ram as it was in the "Vin specific models"

THE POWER STEERING STARTED COMING AND GOING IN LATE OCTOBER 2021. IN LATE JANUARY FIRST OF FEBUARY IT COMPLETELY WENT OUT/STOPPED WORKING. TOOK IT IN TO LOCAL DODGE DEALER, AND THEY DIAGNOSED THAT YES THE ELECTRONIC POWER STEERING HAD FAILED AND NEEDED TO BE REPLACED. I WAS ADVISED OF THE REPLACEMENT COST AND OK'D THE REPAIR AND PART WAS ORDERED. TODATE THE PART HAS NOT ARRIVED (1000 ACROSS NATION ORDERED BUT 18 SHIPPED IN LAST FOUR MONTHS LAST ADVISED) CALLED AND SPOKE TO DODGE AND FILED COMPLAINT 041322, BECAUSE, I'VE RECEIVED NO ANSWERS NO RESPONSE FROM DODGE/CHRYSLER SINCE. THIS PROBLEM IS NOT NEW TO THE MODEL YEAR OF THIS TRUCK. DODGE/CHRYSLER REFUSES TO ADDRESS AVAILABILTY OF PART OR ISSUE RECALL ON THE TOTAL NUMBER OF VEHICLES INVOLVED. THERE IS A RECALL THAT IVE FOUND ONLINE BUT DOES NOT ADDRESS MY VEHICLE THAT HAS LESS THAN 37000 MILES. THE DEALERSHIP HAS BEEN HELPFUL. I OWN AND HAVE OWNED SEVERAL DODGE/ CHRYSLER PRODUCTS AND JUST VERY DISAPPOINTED IN THE MANUFACTURER.

Front differential housing, passenger side half shaft fractured

The contact owns a 2016 Ram 1500. The contact stated while driving approximately 45 MPH, he attempted to change from the left lane to the right however, the steering wheel did not respond. The contact applied more force to the right and the steering turned in the opposite direction. The contact stated that a red steering wheel warning light was illuminated. The contact stopped in the middle of the roadway due to the loss of steering functionality. The contact had the vehicle towed to his residence. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 124,000.

Air suspension cuts in an out while driving. Causing my vehicle to have zero suspension at highway speeds. Without suspension any little bump in the road is causing the back end of my vehicle to jump around sending me into other lanes. This is a serious issue according to many forums and complaints I have read after purchasing the vehicle.

The contact owns a 2016 Ram 1500. The contact stated that while driving at 40 MPH, the engine seized and the vehicle lost motive power. The vehicle was towed to the dealer but was not yet diagnosed nor repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 33,000.

79,000 miles on 2016 Ram 1500 eco 4x4 has differential problems and the back axle. Makes the transmission over heat. Brakes also go to the floor have to double tap on the brakes to stop.

The contact’s friend owns a 2016 Ram 1500. The contact stated that mechanism securing the driver’s side seat belt to the floor would occasionally seize and detach from the floor causing the seat belt to become unsecured. The cause of the failure was not determined. The manufacturer and local dealer were not notified of the failure. The approximate failure mileage was 60,000.

I noticed about 2 weeks ago that my steering was becoming difficult. I brushed it off at first, but certain cold mornings, it is becoming harder to steer. My steering wheel also requires force to turn it straight after engaging in a turn, it does not assist. I took it to a National Tire and Battery and they confirmed that my Ram 1500 needs a new rack and pinion. They also informed me that no where around has any in stock, or even know if/when they’ll get one. So I am stuck driving a truck where I could lose my steering at any moment. I believe my truck should be a part of 16V-167 recall.

I received a recall letter from FCA for SAFETY RECALL Y63/NHTSA 21V-632 approximately SEVEN months ago. As of today 3/25/2022 a fix is not available according to FCA!!! How can FCA have a recall when they don't have a fix? And how can NHTSA allow FCA to drag their feet on a SAFETY RECALL? I am very disappointed in FCA and MOST of all with NHTSA, to allow a SAFETY problem to exist with out a fix for such a LONG period of time.

Truck vibrates between speeds of 60 and 70 mph. Put new tires on and it made no difference.

While driving, gas gauge dropped to "E", despite having nearly a full tank of gas. Gas light began flashing, check engine light came on, and a "fuel sensor fail" message displayed on the panel. After much research, this seems to be an ongoing problem with Ram 1500 models from 2014-2017.

Was involved in a crash where an SUV ran a red light and out in front of me, I was driving 40mph she was going faster and when we hit her SUV flipped and all her airbags deployed but none of mine did and the whole front was pushed back about a foot also both frame rails were bent and cracked from the impact but none of my airbags deployed and I just bought this truck one month ago and the dealership said everything checked out good and there were no service lights on at the time prior to or after the wreck.

While Driving and power steering quit.

I took the vehicle to the local dealer and they diagnosed a Delaminated Tone Wheel, the same exact issue as described in Safety Recall W68 / NHTSA 20V-475. The claim that my vehicle is not included in the recall. There seems to be no question that the issue of Tone Wheel Delamination is broader in scope that described in W68 and I am petitioning an expansion of that recall to include all vehicles that potentially have this issue.

I took my 2016 Ram 1500 Hemi 5.7 truck in for a frontend alignment to a dealer that has always service my truck since I purchased it in 2017. While there I was informed that I had a exhaust manifold leak and bolts were broken in the block and the cost to repair is 1600.00. After coming home and doing research I have learn this is a common problem in the Ram 1500 Hemi 5.7 that is well documented here on NHTSA as well as the Manufacture and Dealers . If carbon monoxide is escaping into the cab of the truck and you have your windows up and a/c on you are inhaling those fumes. There is no recall and the manufacture has known these bolts breaking causing a exhaust leak for years. This is a major defect that needs to be addressed, No one should be paying $40,000 to 75,000 dollars for a vehicle that has this type of defect that is also health hazard if the fumes are leaking in the cab.