2000 Pontiac Montana

Defect. DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Risk. A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Remedy. DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

Defect. CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Risk. FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy. DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

Defect. ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.

Risk. IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.

Remedy. DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.

Defect. VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.

Risk. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Remedy. DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Defect. VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.

Risk. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.

Remedy. DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Defect. VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Risk. IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Remedy. DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.

Defect. VEHICLE DESCRIPTION: MINI VANS WITH EXTENDED WHEELBASE. SOME OF THESE VEHICLES HAVE INOPERATIVE FUEL TANK ROLLOVER VALVES AND FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN A ROLLOVER TEST. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."

Risk. IN A VEHICLE ROLLOVER ACCIDENT, IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.

Remedy. DEALERS WILL INSPECT THE VEHICLES TO LOCATE AND REPLACE THOSE FUEL TANKS THAT COULD HAVE INOPERATIVE ROLLOVER VALVES.

TL* THE CONTACT OWNS A 2000 PONTIAC MONTANA. THE CONTACT STARTED THE VEHICLE AND THE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.

SHIFTING OUT OF PARK WHILE ENGINE NOT RUNNING WITHOUT THE BRAKE BEING ON/STEPPED ON, WHICH RESULTED IN THE VAN ROLLING IN REVERSE, THANKFULLY IT WAS IN THE DRIVEWAY WHEN THIS HAPPEN, WAS ABLE TO PUT IT BACK INTO PARK (THANK GOD).

TL* THE CONTACT OWNS A 2000 PONTIAC MONTANA. THE CONTACT STATED THAT WHEN THE VEHICLE WAS PULLED INTO THE DRIVEWAY, THERE WAS A LOUD NOISE UNDER THE VEHICLE. IN ADDITION, THE STEERING WHEEL BECAME LOOSE AND THE REAR AXLE SUPPORT BRACKET DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

I DID NOT REALIZE EVERY OWNER OF A PONTIAC MONTANA ALL HAD SAME PROBLEMS. EVERY OWNER. HERE IS ONE OF THE WEBSITES. HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/COMMENT/3340529. THE DEALER SOLD ME A PONTIAC MONTANA. THE SECOND DAY I DROVE IT, I RAN OUT THE GAS BECAUSE THE GAS GAUGE READ FULL, BUT ACTUALLY IT WAS EMPTY. I DID NOT REALIZE THE GAS GAUGE STOPS WORKING UNTIL EVERY OWNER HAD THE SAME PROBLEM. EVERY OWNER HAD A CONDENSER PROBLEM. EVERY OWNER. WHICH IN TURN MAKES THE HEAD GASKET GO. I AM A SINGLE PARENT AND DID NOT UNDERSTAND THAT NUMEROUS CALLS TO GMC WERE MADE AND NO RECALLS HAS BEEN DONE. IT IS SHAMELESS, HOW PEOPLE LIKE ME ARE STRUGGLING AND THESE CAR DEALERS MADE BILLIONS WITH FAULTY EQUIPMENT. IF YOU GOOGLE PONTIAC COMPLAINTS. EVERY OWNER HAD THE SAME PROBLEM. EVERY OWNER. I CANT AFFORD TO REPLACE A MOTOR BECAUSE OF THE HEAD GASKET. I AM STILL MAKING PAYMENTS ON THIS CAR LOAN. ISN'T THEIR A LAW THAT CAN HELP VICTIMS LIKE US. IT SHOULD BE SHAMEFUL HOW GMC HAS SOLD PONTIAC VEHICLES WITH SO MANY FAULTY EQUIPMENT. I NEED HELP. IF EVERY SINGLE OWNER HAD THE SAME CONDENSER, SAME, HEATING PROBLEM, SAME GAS GAUGE, SAME BLOWN HEAD GASKET AS A RESULT. PONTIAC GMC SHOULD BE FORCED TO PAY. *TR

THIS IS A ADDON FROM THE PREVIOUS ONE I SUBMITTED JUST NOW. I WANT TO POINT OUT. I WAS ALMOST KILLED WHEN I RAN OUT OF GAS ON THE HIGHWAY, BECAUSE THE GAS GAUGE READ INCORRECTLY. WHEN THE ENGINE BECOME HOT, IT ALMOST STARTED A FIRE. I AM A SINGLE PARENT WITH A TEN YEAR OLD. DEALERS ARE STILL SELLING THESE PONTIAC MONTANA'S. WE DO NOT KNOW HOW MANY DEATHS IT MAY HAVE ALREADY CAUSED. OR HOW MANY WOMEN AND CHILDREN WERE STRANDED, BECAUSE THE GAS GAUGE READS INCORRECTLY, IT WILL SAY ITS FULL BUT IT IS ACTUALLY EMPTY. THE CONDENSERS GO, WHICH CAUSE A BLOWN HEAD GASKET. I CANNOT AFFORD TO REPLACE THE MOTOR, AND I ALREADY PUT OUT CLOSE TO A THOUSAND DOLLARS ALREADY. THE FIRST MONTH I BOUGHT IT FROM A DEALER. EVERY OWNER HAS HAD THE SAME EXACT PROBLEM. EVERY OWNER. HERE IS ONE OF THE WEBSITES I DID NOT REALIZE EVERY OWNER OF A PONTIAC MONTANA ALL HAD SAME PROBLEMS. EVERY OWNER. HERE IS ONE OF THE WEBSITES. HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/COMMENT/3340529. YOU CAN GOOGLE PONTIAC MONTANA COMPLAINTS AND THEIR ARE HUNDREDS OF WEBSITE COMPLAINTS ON THE SAME EXACT PROBLEM. BUT GMC REFUSED TO RECALL SINCE THE COMPLAINTS FIRST STARTED. *TR

THE CAR WOULD START MISSING, LIKE THERE WAS A SHORT IN THE ELECTRICAL AND THEN THE CAR WOULD SHUT OFF THE AND I WOULD HAVE TO SIT THERE FOR 1 TO 2 HRS AND THEN IT WOULD START AND RUN FOR A WHILE AND SHUT OFF AGAIN, THE LAST 2 TIMES THIS HAPPEN I HAD TO HAVE A TOW TRUCK PICK IT UP AND TAKE IT TO MY HOME WHERE IT HAS SAT EVER SEANCE 2008. *TR

IT HAS HAPPENED SEVERAL TIMES IN THE PAST, BUT WHEN IT RAINS THE WIPERS DO NOT WORK OR IF THEY DO, THE STOP AND START ON THEIR OWN. NOW THEY JUST WON'T WORK IF IT EVEN SPRINKLES. *TR

TL* THE CONTACT OWNS A 2000 PONTIAC MONTANA. THE CONTACT STATED THAT THE TAIL LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THE CIRCUIT BOARD WIRING WOULD HAVE TO BE REPLACED. AFTER THE REPAIR, THE FAILURE RECURRED TWICE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000. *TR

WHEN I STARTED THE CAR THIS MORNING AND STEPPED ON THE BRAKE PEDAL, IT WENT ALL THE WAY TO THE FLOOR. UPON INSPECTION, THERE WAS A PUDDLE OF BRAKE FLUID ON THE DRIVEWAY UNDER THE PASSENGER DOOR ON THE DRIVER'S SIDE. I INSPECTED FURTHER WITH A FLASHLIGHT AND MIRROR, AND COULD SEE THAT THE FLUID WAS DRIPPING FROM A BUNDLE OF BRAKE LINES ATTACHED TO THE CHASSIS, OF WHICH ONE WAS SEVERELY CORRODED.. *TR

SEVERE CORROSION OF BRAKE LINES. THERE IS A SHORT SECTION OF THE REAR BRAKE LINES JUST FORWARD OF THE REAR CONTROL ARM THAT RUSTS OUT. *TR

TL* THE CONTACT OWNS A 2000 PONTIAC MONTANA. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH AND CRASHED INTO A TREE WHILE ATTEMPTING TO AVOID HITTING AN ANIMAL. THERE WAS DAMAGE TO THE FRONT END OF THE VEHICLE AND DRIVER SIDE DOOR. THE AIR BAGS FAILED TO DEPLOY WITH THE SIGNIFICANT IMPACT. THE CONTACT SUSTAINED BRUISES ON THE BODY FROM THE TIGHTENING OF THE SEAT BELT. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 131,042.

ADDITION TO FILED AIRBAG ACCIDENTS NHTSA-FARM BUREAU-STILL INSURING THE UNSAFE VEHICLE. AS I DRIVE WITH A HEAD INJURY. OTHER INJURYS AND EXPECTED TO CARE FOR ADULT CHILD WITH TBI. FARM BUREAU STOPPED PAYING HER PIP BENEFITS. NHTSA ID-=MY ACCIDENT 11-11-2010 DAUGHTERS 3-18-2010 SEATBELTS DID NOT LOCK DOWN. 2 TBI ACCIDENTS SAME YEAR. NO AIR BAGS DEPLOYED. NO ONE ASKED IF SEAT BELTS LOCKED.DID NOT KNOW TO REPORT. *TR

I WAS IN AN ACCIDENT. HIT ANDRUN.ON 3-18-2010. INSURED BY FARM BUREAU. WHO STILL INSURES THE FAULTY VEHICLE. THE IMPACT WAS FROM A LARGE WHITE TRUCK. TRAVELING AT A HIGH SPEED RATE TURNING THROUGH A RED LIGHT AS I CROSSED AN INTERSECTION. NO AIR BAG DEPLOYED.REGISTERED ON11-28-2010.REALIZED THE SEAT BELTS DID NOT ACTIVATE EITHER. NO ONE ASKED.YES IT WAS CONNECTED.MOTHERS ACCIDENT ON 11-11-2010 REAREND COLLISION. STOPPED HIT BY A TRUCK TRAVELING 35MPG NO AIR BAGS. NO SEAT BELT LOCK DOWN. EMT SAID SAW HER GO OVER STEERING WHEEL IN FRONT OF MCLAREN HOSPITAL. THEY DID NOT ADMIT HER. NO INVESTIGATION. FARM BUREAU STILL INSURES FAULTY VEHICLE. STATE FARM INSURED. WAS ON DRUGS OR DRINKING. CITY POLICE LET HER GO. AND FOR MINE THEY HAD SEVERAL REPORTS OF WHITE TRUCK HIT AND RUNS NO INVESTIGATIONS. DONE IN CITY. LACK OF FUNDS. *TR

WE HAVE A 2000 PONTIAC MONTANA, MY LITTLE GIRL AND I WERE DRIVING HOME FROM THE STORE THAT'S 15 MIN FROM HOME I NOTICED A BURNING SMELL, THEN SMOKE CAME POURING OUT OF THE DASH BUY THE TIME WE GOT OUT THE SECURITY LITE WAS ON CHECK MOTOR LIGHT WAS ON AND IT WOULD ONLY GO TEN MILES AN HOUR, SO THE NEXT DAY I TOOK APART THE DASH AND FOUND THE WIRING BURNT UP, AND NOW I CANT EVEN START IT SO IM STUCK WITH A BROKEN DOWN VAN, THAT I JUST HAD A $600 DOLLAR FIX SO NOW IM OUT $600 AND A VAN. I CANT FIX IT BECAUSE I DON'T HAVE THE MONEY TOO SO ALL OLD PARTS ARE AVAILABLE FOR SOME $$. *TR

INTAKE MANIFOLD NEEDED TO BE REPLACED AT 84,000 MILES. VERY COSTLY REPAIR $1,500.00. *TR

AIR BAG LIGHT COMES ON EVERY FEW MILES. *TR

2000 PONTIAC MONTANA, DRIVING WESTBOUND IN THE RIGHT LANE WHEN THE HOOD OF THE VEHICLE CAME UP AND STRUCK THE WINDSHIELD OF THE CAR. UNIT 1 CAME TO FINAL REST ON THE RIGHT SIDE OF THE ROAD. *BF (OHIO TRAFFIC CRASH REPORT # 10-0831-90) *JB UPDATED 01/14/11 *BF

DAUGHTER-IN-LAW WAS DRIVING OUR 2000 MONTANA VAN AND REAR-ENDED A PICKUP TRUCK. CAUSED $3700 DAMAGE, BENT IN BUMPER, RADIATOR, A/C CONDENSER, HOOD AND BROKE HEADLIGHT. AIRBAGS DID NOT DEPLOY IN THIS INSTANCE. *TR

.A WHITE TRUCK TURNED LEFT INTO TRAFFIC. DROVE BETWEEN TWO VEHICLES HITTING THEM BOTH ABOUT 35 MPH..1 WAS A DODGE THE BUMPER AND PIECES WERE LEFT IN THE INTERSECTION.THE RIGHT FRONT END OF MY 2000 PONTIAC MONTANA WAS HIT AS THE TRUCK CONTINUED TURNING AND HEADED NORTH ON BALLENGER HWY.NO AIR BAG DEPLOYEMENT.DAUGHTER HAS A TBI. DAUGHTER WAS DRIVER. COMING HOME FROM COLLEGE.NO HELP.INSURANCE DENIES AN EVALUATION .DAUGHTER IS FAILING. WAS A COLLEGE STUDENT WORKED FULL TIME. TOLD THE IMPACT WAS NOT ENOUGH DAMAGE. PLPD INSURANCE FARM BUREAU. DISABILITY. TO DATE. *TR

I WAS STOPPED AT A RED LIGHT IN FRONT OF A HOSPITAL'S PEDESTRIAN WALKWAY. A WOMAN IN A 1994 SILVERADO TRUCK REAR ENDED ME. SHE WAS TRAVELING 35MPH. DID NOT SEE STOPPED TRAFFIC. MY STEERING WHEEL AIRBAG DID NOT DEPLOY NOR ANY OTHER AIRBAG. THE SECOND IMPACT THIS YEAR AND NO AIRBAG DEPLOYMENT INSURANCE,DEEMS VEHICLE STILL SAFE. THEY CAME AND LOOKED AT DAMAGE. KNOWING DAUGHTER SUFFERED A TBI IN MARCH FOR SAME DEFECT THEY ARE NOT RECOGNIZING. *TR