2002 Plymouth Prowler

Defect. CERTAIN TIGAS FUEL PUMP MODULES MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006, SOLD UNDER VARIOUS BRAND NAMES AND P/NOS. THESE FUEL PUMP MODULES ARE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.

Risk. FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy. TI AUTOMOTIVE WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 6, 2006. OWNERS MAY CONTACT TI AUTOMOTIVE TOLL-FREE AT 1-877-461-1834.

Defect. CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.

Risk. LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.

Remedy. AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.

Defect. ON CERTAIN PASSENGER VEHICLES, THE LOWER CONTROL ARM BALL JOINTS MAY EXPERIENCE A LOSS OF LUBRICATION THAT CAN RESULT IN ACCELERATED WEAR AND POSSIBLE SEPARATION FROM THE STEERING KNUCKLE.

Risk. A BALL JOINT THAT HAS SEPARATED MAY RESULT IN LOSS OF DIRECTIONAL CONTROL.

Remedy. DEALERS WILL REPLACE THE FRONT LOWER CONTROL ARM BALL JOINTS WITH MODIFIED ASSEMBLIES. OWNER NOTIFICATION BEGAN ON APRIL 4, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403 OR CHECK ON-LINE AT HTTP://WWW.CHRYSLER.COM/WEBSELFSERVICE/CHRYSLER/INDEX.JSP

TL* THE CONTACT OWNS A 2002 PLYMOUTH PROWLER. WHILE THE VEHICLE WAS BEING PULLED OUT OF THE GARAGE, THE BALL JOINT DETACHED FROM THE LOWER PASSENGER SIDE CONTROL ARM. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO FIRST CHRYSLER DODGE JEEP RAM (280 EAST WASHINGTON ST ROUTE ONE, NORTH ATTLEBOROUGH, MA) WHERE IT WAS CONFIRMED THAT THE BALL JOINT DETACHED AND THE BALL JOINT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFUSED TO COVER THE VEHICLE PER NHTSA CAMPAIGN NUMBER: 03V034000 (SUSPENSION) BECAUSE THE VEHICLE WAS PREVIOUSLY SERVICED PER THE RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 65,080. THE VIN WAS NOT AVAILABLE.

THE ORIGINAL CASE NHTSA CAMPING ID NUMBER 03V034000 HAS NOT BEEN COMPLETELY RESOLVE THE CAR'S CONTINUES TO LOOSE CONTROL BY THE LOWER CONTROL ARM JOINTS SEPARATE AND THE COMPLETE WHEEL SEPARATE FROM THE CAR CAUSING THE COMPLETE LOSS OF CONTROL AND CRASH OF THE CAR. IS THE ORIGINAL PROBLEM AGAIN! *TR

THE VEHICLE'S HOOD SHOCKS DO NOT SUPPORT THE HOOD'S WEIGHT. I HAVE HAD THE HOOD CRASH DOWN SEVERAL TIMES, INCLUDING ONCE ON MY HAND CAUSING INJURY. OTHER OWNERS OF PLYMOUTH/CHRYSLER PROWLERS HAVE REPORTED CHANGING THE HOOD SHOCKS SEVERAL TIMES WITH NO SOLUTION. SEVERAL OWNERS HAVE ALSO REPORTED BEING HIT ON THE HEAD WHILE LOOKING UNDER THE HOOD, HAVING INJURED THEIR WRISTS AND FINGERS FROM HOODS CRASHING DOWN. THIS IS A DEFECTIVE DESIGN WHICH RESULTS IN A DANGEROUS CONDITION THAT THE VEHICLE MANUFACTURER REFUSES TO ACKNOWLEDGE AND REMEDY VOLUNTARILY.