2026 Peterbilt 579

Defect. PACCAR Incorporated (PACCAR) is recalling certain 2026-2027 Peterbilt 579 and 2027 Kenworth T680 tractors. The trailer air connection quick release (QR) valve in the air brake system may have been incorrectly installed, which can cause the trailer to become unstable after the driver applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Risk. An incorrectly installed quick release valve that does not function properly can increase the risk of a crash.

Remedy. Paccar inspected and reinstalled the valves, as necessary, free of charge. All affected tractors have been repaired and therefore no owner notification letters are necessary. Owners may contact Peterbilt's customer service at 1-940-591-4220 and Kenworth's customer service at 1-425-828-5888. PACCAR's number for this recall is 26PACC.

Defect. PACCAR Incorporated (PACCAR) is recalling certain 2024-2026 Kenworth T480, T680, T880, W990, Peterbilt 520, 536, 537, 548, 567, 579, 589, 2025 Kenworth T180, Peterbilt 535, 2025-2026 Kenworth T280, T380 and L770 vehicles. The tail brake light, upper and lower beam headlights, reverse light, and turn signal may not illuminate as intended. In addition, the lift axles, if lowered, may revert to a raised position, or oscillate up and down when the signal warning lights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Risk. Delayed and unsteady headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash. In addition, an unexpected position change of the lift axles may increase the risk of injury.

Remedy. Dealers will update the VCU software, free of charge. Owner letters were mailed August 19, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's number for this recall is 25PACF.

The contact was the operator of a 2026 Peterbilt 579 for an employer. The contact stated that whether driving 30 MPH or 65 MPH, after another vehicle entered the lane in front of the vehicle, the Forward Collision Avoidance: AEB and Lane Keep Assist systems erroneously activated and brought the vehicle to an unsafe and abrupt stop. The contact stated that the RADAR system had experienced a False Positive alert of a possible crash, even though the vehicle was at a safe driving distance ahead. The contact stated that the failure caused other driver’s behind the vehicle to run off the road or skid to a stop to avoid crashing into the rear of the vehicle. The contact stated that the failure also occurred with another vehicle approximately 100-feet ahead coming over into the lane, and the AEB activated, causing the wheels to lock up, bringing the vehicle to an abrupt stop. The contact stated that other drivers angrily honked at him. On one occasion, the contact was followed by an irate driver for ten minutes after the failure had occurred. The contact was concerned for his safety and the safety of the public because the system could not be overridden. The contact stated that on one occasion while his brother was driving the vehicle at a moderate speed, while the contact was asleep in the sleeping netting which the contact believes was not DOT approved, the AEB system activated and sent the contact’s body forward, causing his rib cage to strike a cabinet inside the sleeper berth, c