No owner complaints are on file for this vehicle. It has been recalled 4 times.
4 safety recalls
Part 573 reports
Equipment › Appliance › Air Conditioner08V053000
Filed Feb 5, 2008431 vehiclesNew Flyer Industries Ltd
Defect. NEW FLYER IS RECALLING 431 MY 1996-2001 D60HF DIESEL TRANSIT BUSES EQUIPPED WITH A ROOFTOP AIR CONDITIONING EVAPORATOR. THE EVAPORATOR DRAIN LINES MAKE CONTACT WITH COMPONENTS (BALLAST ASSEMBLIES) WITHIN THE INTERIOR LIGHTING PANEL BELOW THE DRAIN LINE PORT. THIS CAN RESULT IN EITHER DAMAGE TO THE DRAIN LINE, WHICH INTRODUCES MOISTURE INTO THE LIGHTING PANEL, OR RESTRICTION OF THE LINE WHICH RESULTS IN A BACK-UP AND OVERFLOW OF MOISTURE THROUGH THE FRESH AIR RETURN VENT AND BACK INTO THE LIGHTING PANEL.
Risk. MOISTURE IN SUFFICIENT QUANTITIES WITHIN THE LIGHTING PANEL MAY RESULT IN A SHORTING OF THE ELECTRICAL COMPONENTS AND A VEHICLE FIRE.
Remedy. NEW FLYER WILL INCORPORATE AN ELBOW FITTING INTO THE DRAIN LINE WHERE IT ENTERS THE LIGHTING PANEL FROM THE ROOF, WHICH WILL PROMOTE CLEARANCE BETWEEN THE LINE AND THE BALLAST ASSEMBLY. THE RECALL BEGAN ON FEBRUARY 6, 2008. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4803.
Steering07V268000
Filed Jun 11, 20071,768 vehiclesNew Flyer Industries Ltd
Defect. ON CERTAIN TRANSIT BUSES, THE U-JOINT ASSEMBLIES HAVE INADEQUATE SPLINE ENGAGEMENT ON ONE OF THE TWO END YOKES.
Risk. EXCESSIVE PLAY IN THE STEERING SYSTEM COULD DEVELOP AND, IF NOT CORRECTED, CAUSE A LOSS OF STEERING CONTROL WHICH COULD RESULT IN A CRASH.
Remedy. THE U-JOINT ASSEMBLY WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JUNE 10, 2007. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.
Wheels04V042000
Filed Feb 2, 2004782 vehiclesNew Flyer Industries Ltd
Defect. ON CERTAIN TRANSIT BUSES, THE CENTER AXLE WHEEL END BRAKES MAY NOT RELEASE AFTER BEING PARKED FOR AN EXTENDED PERIOD OF TIME.
Risk. THE DRIVER COULD LOSE CONTROL OF THE VEHICLE WHEN DRIVING AWAY FROM A PARKED POSITION, WHICH COULD RESULT IN A CRASH.
Remedy. NEW FLYER WILL INSTALL AN ADDITIONAL AIR SYSTEM R14 RELAY VALVE, #4 NOTCH AUTOMATIC SLACK ADJUSTERS, AND TYPE 30 LONG STOKE BRAKE CHAMBERS ON THE CENTER AXLE; THE LOGIC CONTROL MODULE WILL BE REPROGRAMMED, ADD NEW ABS COMPONENTS (SENSORS, SPEED RINGS AND HARNESSES) IF NOT ALREADY EQUIPPED WITH ABS; AND WILL REVISE PLC PROGRAMMING. OWNERS MAY CONTACT NEW FLYER AT 1-204-982-8400.
Service Brakes, Air › Supply › Quick Release Valve03V248000
Defect. CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE SERVICE BRAKE RELEASE TIMING AND PARK BRAKE APPLY TIMING ARE OUT OF COMPLIANCE WITH THE STANDARD.
Risk. THESE VEHICLES DO NOT COMPLY WITH FEDERAL STANDARDS.
Remedy. TO RESOLVE THE ISSUE OF NONCOMPLIANCE WITH THE SERVICE BRAKE RELEASE TIMING, DEALERS WILL RE-ROUTE THE REDUNDANT SIGNAL LINE TO THE CENTER AXLE RELAY VALVE AND THE CENTER AND REAR RELAY VALVES WILL BE SWAPPED. OWNER NOTIFICATION BEGAN JULY 17, 2003. OWNERS SHOULD CONTACT NEW FLYER AT 1-204-982-8400.
No unusual pattern of severe incidents in the complaint record.
Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.
Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.
Most recent recall on file: Feb 5, 2008. Source: NHTSA Office of Defects Investigation.