2003 Monaco Coach Knight

Defect. ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.

Risk. THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.

Remedy. DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.

Defect. ON CERTAIN MOTORHOMES, THE I-BEAM LEAF IMITATOR IN THE FRONT AXLE SUSPENSION COULD CRACK AND BREAK DUE TO AN INADEQUATE WELDING PROCESS.

Risk. THE I-BEAMS ON THE FRONT AXLE AND THE PANARD BRACKET ON THE REAR AXLE COULD CRACK AND BREAK CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy. DEALERS WILL REPLACE THE ORIGINAL I-BEAM. ALSO, DEALERS WILL WELD THE STIFFENERS FROM THE PANARD BAR BRACKET TO THE CENTER DIFFERENTIAL OF THE REAR AXLE HOUSING. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT MONACO AT 1-877-466-6226.

Defect. ON CERTAIN MOTOR HOMES, THE BATTERY CABLE THAT IS ATTACHED TO THE CIRCUIT BREAKER IS ROUTED TOO CLOSE TO THE FRAME OF THE COACH.

Risk. THIS COULD RESULT IN THE CABLE BECOMING WORN AND CREATING AN ELECTRICAL SHORT IN THE 12-VOLT SYSTEM THAT COULD DAMAGE THE BATTERY AND/OR CIRCUIT BREAKER.

Remedy. DEALERS WILL ROTATE THE EYELET ON THE CIRCUIT BREAKER TO ELIMINATE THE POSSIBILITY OF THE CABLE RUBBING ON THE FRAME. OWNER NOTIFICATION BEGAN AUGUST 22, 2003. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Defect. ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.

Risk. THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.

Remedy. DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

TL* THE CONTACT OWNS A 2003 MONACO COACH KNIGHT. WHILE DRIVING 55 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE AS THE REAR END VEERED. IN ADDITION, THE CONTACT NOTICED SMOKE AND A BURNING ODOR EMITTING FROM THE REAR WHEEL WELL AND TIRES. THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR WHEEL HUBS NEEDED TO BE REBUILT INCLUDING THE ROTORS, CALIPERS, WHEEL BEARINGS, FRONT SHIELD COVERS, PADS, AND MASTER CYLINDER. THE VEHICLE WAS NOT COMPLETELY REPAIRED DUE TO PART UNAVAILABILITY AND BECAUSE THE MANUFACTURER NO LONGER MADE THE PARTS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 02V278000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE WAS 85,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2003 MONACO KNIGHT. THE CONTACT WAS DRIVING 50 MPH WHEN WHITE SMOKE EMITTED INSIDE OF THE VEHICLE FROM THE TIRES. THE VEHICLE WAS THEN TAKEN TO A PRIVATE MECHANIC. THE MECHANIC STATED THAT THE BRAKE CALIPER FAILED AND NEEDED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THE BRAKE PADS AND THE ABS SENSOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 22,000 AND THE CURRENT MILEAGE WAS 25,000.