2009 Mitsubishi Lancer Ralliart

Defect. Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2008-2011 Lancer, Lancer Evolution, and Outlander; 2009-2011 Lancer Sportback, Lancer Rilliart, and Lancer Sportback Ralliart; and 2011 Outlander Sport vehicles. The affected vehicles, manufactured with 4B1 engines, have an engine pulley and belt arrangement for turning the alternator, the cooling fan and the power steering pump (if equipped). These pulleys may experience unusual wear and allow for belt detachment.

Risk. If the drive belt detaches, the battery may discharge, resulting in an engine stall, increasing the risk of a crash.

Remedy. Mitsubishi will notify owners, and dealers will replace the drive belt with a rubber belt. Drive pulleys that are excessively worn will be replaced. These repairs will be performed free of charge. The recall began on October 15, 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-009.

Defect. MITSUBISHI IS RECALLING MODEL YEAR 2008-2009 LANCER EVOLUTION, RALLIART, AND SPORTBACK RALLIART VEHICLES EQUIPPED WITH TURBOCHARGED ENGINES. THE MANNER IN WHICH THE FUEL RETURN PIPE IS ATTACHED TO THE ENGINE, IN COMBINATION WITH FREQUENT VEHICLE OPERATION AT CERTAIN ENGINE REVOLUTIONS, MAY RESULT IN A RESONANCE THAT, IF CONTINUED OVER TIME, MAY CAUSE A STRESS CRACK TO DEVELOP AT THE FIXED PORTION OF THE FUEL PIPE.

Risk. IF THIS STRESS CRACK DEVELOPS, FUEL LEAKAGE MAY OCCUR. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy. THE FUEL RETURN PIPE WILL BE REPLACED WITH A NEW PART AND TWO ADDITIONAL ATTACHMENT BRACKETS WILL BE INSTALLED TO BETTER CONTROL FUEL PIPE VIBRATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 29, 2009. OWNERS MAY CONTACT MITSUBISHI AT 1-888-648-7820.

S-AWC PUMP HAS A CORRODIBLE HOUSING AND IS PLACED IN AN AREA THAT IS EXPOSED TO SALT AND WATER FROM THE REAR PASSENGER-SIDE WHEEL. THE PLACEMENT OF THE PUMP IS A DESIGN FLAW AND HAS LED TO SEVERE CORROSION OF THE PUMP HOUSING AND FAILURE OF THE PUMP. THE FAILURE OF THE PUMP COMPLETELY DISABLES BOTH THE ACTIVE CENTER DIFFERENTIAL AND THE ACTIVE YAW CONTROL SYSTEMS, BOTH OF WHICH ARE INTENDED TO ASSIST THE DRIVER IN CONTROLLING THE CAR UNDER ADVERSE HANDLING SITUATIONS.

MITSUBISHI LANCER DCT470 SST TRANSMISSION RECALL - MY TRANSMISSION LOST EVEN GEARS WHILE DRIVING HOME FROM WORK. THE CAR SELECTED A LOWER GEAR AND THE CHECK ENGINE LIGHT TURNED ON. I PULLED OVER TO TROUBLESHOOT AND EVENTUALLY MADE IT HOME. THIS COSTLY REPAIR FORCED ME TO BUY ANOTHER CAR AND HAVE SINCE LEFT THE REPAIR UNATTENDED. THIS IS A KNOWN MANUFACTURER DEFECT. THE PROBLEM IS SO COMMON THAT A PETITION WAS STARTED TO HELP THOSE OTHERS THAT WERE ALSO AFFECTED BY THIS ISSUE. THE PROBLEM IS A SHIFT FORK MAGNET BECOMES DISLOCATED FROM THE BRACKET AND WILL NOT ALLOW THE TRANSMISSION TO SELECT EVEN GEARS. IN ORDER TO REPAIR, A SPECIALIST MUST DISASSEMBLE AND REBUILD THE CASE. IT IS NOT CAUSED FROM ANY MAINTENANCE NEGLECT NOR DRIVING HABIT OR ABUSE. IT CAN OCCUR IN ALL MODELS WITH THIS SPECIFIC TRANSMISSION. IT IS A WORLDWIDE ISSUE INCLUDING CANADA & AUSTRALIA. I HAVE NOT YET REPAIRED MY PERSONAL TRANSMISSION AND HOPE TO DO SO IN THE FUTURE. THE CAR HAS BEEN PARKED SINCE THE INCIDENT OCCURRED. MAYBE WITH YOUR HELP MITSUBISHI CAN RECTIFY THIS PROBLEM FOR ME, ALL THOSE AFFECTED, AND PREVENT IT FROM HAPPENING TO FUTURE OWNERS. PLEASE NOTE I'M NOT ALONE IN THIS ISSUE AND MORE PEOPLE WILL COME FORWARD HTTPS://WWW.CHANGE.ORG/P/MIGUEL-MELENDEZ-ALL-MITSUBISHI-LANCER-SST-DCT470-W6GDA-TRANSMISSION-SHOULD-BE-RECALLED

TAKATA RECALL SINCE I BOUGHT THE CAR THE ACD PUMP HAS BEEN FINE. BACK IN SEPTEMBER THE RED TRIANGLE CAME ON AND I DID SOME RESEARCH TO FIND OUT WHAT IT MEANT. I BARLEY DRIVE THE CAR BECAUSE OF THE ISSUE. IT SEEMS SEVERAL OTHER PEOPLE HAVE HAD THIS PROBLEM TOO. MITSUBISHI WANTS TO CHARGE ME $800-$1200 TO FIX IT. I REFUSE TO PAY THIS AMOUNT AFTER SEEING EVERYONE ELSE HAS THIS SAME ISSUE.

I WAS DRIVING TO WORK AND THE CAR STARTED ACTING STRANGE. IT WOULD ONLY SWITCH TO SELECT GEARS. I TOOK IT STRAIGHT TO A MITSUBISHI SERVICE WHERE THEY INFORMED ME THAT TRANSMISSION WAS FAILING. THEN THEY TOLD ME IT WOULD COST $12000 TO REPAIR. THEY ALSO SAID THE CAR NEEDS A NEW AWD DIFFERENTIAL PUMP BUT THAT WOULD BE FREE. UPON MY RESEARCH AND WHAT ONE OF THE TECHS TOLD ME AWD PUMP CAN SCREW UP THE TRANSMISSION. HOW CAN THEY NOT COVER THE COST OF REPAIR FOR TRANSMISSION IF A FAULTY PART CAUSED IT.

AS I WAS DRIVING MY CAR IT BEGAN TO JERK I PULLED OVER AND SHUT THE CAR OFF WHEN I STARTED IT AGAIN THE AWC LIGHT CAME ON AND WAS NOT FUNCTIONING AFTER WHEN PULLING OFF I NOTICED THE CAR DID NOT WANT TO SHIFT GEARS UNLESS IN MANUAL FOR SO THE SST HAD FAILED ON ME

4WD SERVICE REQUIRED LIGHT POPPED UP IMMEDIATELY WHEN ACCELERATING. ACD PUMP MAY HAVE FAILED. MITSUBISHI DOES NOT COVER THIS AS IT IS NOT "PART OF THE DRIVETRAIN". CAN BE DANGEROUS WHEN PUMP GOES OUT. *TR

I STOPPED AT A LIGHT, THE WHEN I WENT TO MAKE A LEFT TURN MY DASH BEGAN TO FLASH A "SERVICE REQUIRED" LIGHT AT ME. AFTER DOING SOME INVESTIGATION, IT TURNS OUT THAT IT IS AN EXTREMELY WELL KNOWN AND UNADDRESSED ISSUE WITH THE CAR'S ACD PUMP FAILING. IT'S A DESIGN FLAW THAT COSTS THOUSANDS OF DOLLARS TO FIX, BUT FAILURE OF THE PART IS PRACTICALLY GUARANTEED. WHY THERE'S NO RECALL YET IS COMPLETELY RIDICULOUS. *TR

TL* THE CONTACT OWNS A 2009 MITSUBISHI LANCER RALLIART. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN ID NUMBER: 14V562000 (ENGINE) AND STATED THAT THE PART WAS NOT AVAILABLE. THE DEALER GAVE A SPECIFIC DATE FOR WHEN THE PART WOULD BECOME AVAILABLE WHICH WAS UNREASONABLE. THE MANUFACTURER WAS CONTACTED BUT THE CONTACT WAS NOT ABLE TO SPEAK TO A REPRESENTATIVE TO DETERMINE ESTIMATED DATE FOR WHEN THE CONTACTS VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT DID NOT EXPERIENCE A FAILURE.

I STARTED MY CAR THE AWC SELECTION LIGHT STARTED FLASHING. AS I DROVE IT STOPPED FLASHING. THEN THE AWC SERVICE REQUIRED LIGHT CAME ON I BROUGHT IT TO THE DEALER THEY TURNED THE LIGHT OFF SAID IT WAS A ECU UPDATE. AS IT GOT WARM OUT IT CAME ON PERIODICALLY BUT WOULD TURN OFF. EVERY TIME I BROUGHT IT TO THE DEALER THEY COULDN'T DUPLICATE THE PROBLEM. NOW THE LIGHT HAS COME ON AND STAYED ON. THE CODES ARE FOR PUMP FAILURE. *TR

AWC PUMP FAILED AFTER ABOUT 20,000 MILES IN THE CAR. PROBLEM SEEMS TO BE VERY COMMON FOR THE EVO X AND REALLIART MODELS 2008 AND AFTER. CAR DOES NOT HANDLE WELL WITH THIS SETTING AND IS NOT SAFE TO DRIVE IN THE WINTER BECAUSE CAN'T SET TO SNOW MODE. COST TO REPLACE IS AROUND $2K AND MITSU KEEPS STATING THIS IS NOT COVERED BY POWERTRAIN WARRANTY AND IS A MAINTENANCE ITEM. NEVER HEARD OF A $2K MAINTENANCE ITEMS. THERE ARE NUMEROUS REPORTS THAT STATE THE CAUSE OF THIS IS THE WRONG TYPE OF OIL USED AND THE FACT THAT THE PART IS NOT MADE OF DURABLE MATERIAL CAUSING RUST AND FAILURE. SEEMS TO BE A DESIGN FLAW. PLEASE HELP. *TR

I WAS TRAVELING AT APPROXIMATELY 45-50 MPH WHEN MY AWD SERVICE REQUIRED LIGHT CAME ON. STEERING /TRACTION ON THE CAR WAS IMMEDIATELY DIFFERENT AND NOT AS EASY AS NORMAL. *TR

I WAS PULLING OUT OF A PARKING SPOT AND MY AWC LIGHT CAME ON. I TOOK IT TO THE DEALER AND THEY TOLD ME THAT THERE WAS NOTHING WRONG WITH MY AWD PUMP. I HAD TO PAY A $45.00 DIAGNOSTIC FEE FOR THEM TO LOOK AT IT. I AM WORRIED THAT THE PUMP WILL EVENTUALLY FAIL COMPLETELY AND I WILL OUT OF LUCK. I KNOW THAT THE PUMP GOES BAD ON THESE CARS, AS I HAVE READ A TON OF DIFFERENT COMPLAINTS ABOUT THEIR RALLIART/EVO HAVING THE SAME ISSUE. *TR

AS I WAS DRIVING HOME FROM WORK I GOT A SERVICE REQUIRED ON SCREEN, SHUT MY CAR OFF IT WENT AWAY. NEXT DAY DRIVING TO WORK SAME THING. IT CONSISTENTLY COMES ON WELL DRIVING AND GOES AWAY ON START UP. HAD AN ALIGNMENT DONE, BALANCED ALL TIRES AND NO CHANGE. SHOP INFORMED ME OF A CODE C161E. ACD PUMP FAILURE. MITSUBISHI STATED AS ITS OVER 60K MILES I HAVE NO POWER-TRAIN COVERAGE AND A NEW PUMP AND REPLACEMENT WAS AROUND $2000. KINDA STRANGE A PART THAT SEEMS TO HAVE SO MANY ISSUES ALL OVER THE US AND CANADA THE CAN'T DO A RECALL? *TR

THERE IS AN ALL WHEEL TRACTION CONTROL PUMP FOR ONE OF THE CARS MAIN FEATURES. THIS PUMP IS LOCATED DIRECTLY BEHIND THE REAR WHEEL. WHEN YOU LIVE IN AN AREA THAT IS COLD AND THE ROADS ARE SALTED THE PUMP GETS SPLASHED WITH SALTY ROAD WATER AND CORRODES THE PUMP. THIS LEADS THE PUMP TO FAIL AND EXTREMELY LOW MILES. THE WORST PART IS THAT FOR SOME REASON MITSUBISHI DOES NOT COVER THIS UNDER ITS PUMPS OR POWER TRAIN WARRANTY. IT IS ALSO AND INCREDIBLY EXPENSIVE PART. MY PART FAILED BEFORE 40,000 MILES. *TR

AS I WAS DRIVING MY CAR TO WORK LAST WEEK A LIGHT CAME ON THAT LOOKS LIKE MY TIRES ARE UNBALANCED..?... THINKING I MIGHT NEED NEW TIRES, I BROUGHT MY CAR TO THE DEALERSHIP. THE DEALERSHIP ASSURED ME THAT I DID NOT NEED TIRES. I HAD MY OIL CHANGED AND MY TIRES ROTATED INCLUDING A FRONT END ALIGNMENT AND AN INSPECTION. WHEN I STARTED TO DRIVE AWAY FROM THE DEALERSHIP, A LIGHT CAME ON AGAIN. I TURNED AROUND AND BROUGHT IT RIGHT BACK.THE DEALER PUT MY CAR ON A MACHINE AND TOLD ME THE ISSUE IS "CODE C161E" -INTERMITTENT ISSUES WITH AWD CONTROL PUMP AND THIS PART ALONE WOULD COST $2000.00.MY CAR IS A 2009 WITH ONLY 31000 MILES ON IT. THE DEALER TOLD ME THAT MY THREE YEAR WARRANTY IS UP HOWEVER I STILL HAVE 5000 MILES. HOW COULD THIS HAPPEN WITH SUCH MINIMAL MILES? I DRIVE MY CAR TO WORK AND HOME MOSTLY AND TAKE GOOD CARE OF IT. WHEN I RESEARCHED THIS ISSUE ONLINE I FOUND MULTIPLE PEOPLE WITH THE SAME ISSUE AND HAVE REPORTED THE ISSUE. HOWEVER, NOTHING SEEMS TO BE GETTING RESOLVED EXCEPT BAD FEELINGS. IF THIS IS SUCH A HUGE ISSUE (AS IT SEEMS TO BE ONLINE) WHY DOES MITSUBISHI NOT DO SOMETHING ABOUT THIS. HOW CAN THEY JUST GET AWAY WITH A MALFUNCTIONING AUTO PART THAT NORMAL EVERYDAY PEOPLE, STILL MAKING CAR PAYMENTS, CAN NOT AFFORD. I WOULD REALLY APPRECIATE ANYTHING YOU COULD DO TO HELP ME GET THIS ISSUE REPAIRED AS I DO NOT WANT TO GET RID OF MY CAR. I DO NOT FEEL THIS SHOULD BE THE CONSUMERS PROBLEM BUT THE MANUFACTURERS. THANK YOU VERY MUCH FOR YOUR TIME. *TR

ALL WHEEL CONTROL PUMP UNITS CONTINUE TO FAIL WITH OUT MITS... ATTEMPTING TO RESOLVE THE ISSUE. COSTING MIN $2000 FOR REPAIRS. THEY MOST OF THE TIME REFUSE TO REPLACE A POORLY ENGINEERED AWC PUMP. UNDER A SUPPOSED AWESOME WARRANTY. THESE UNITS ARE FAILING ALL OVER CANADA & US. WITH MITS KNOWING ITS A PROBLEM. BUT NOT RESOLVING IT. HELP US OWNERS PLEASE. I DON'T WANT TO OR SHOULD HAVE TO REPLACE A $2000 PUMP EVERY 10,000 KMS. *TR

TL* THE CONTACT OWNS A 2009 MITSUBISHI LANCER RALLIART. THE CONTACT STATED THAT ONLY CERTAIN GEARS COULD BE ENGAGED WHEN DRIVING AT VARIOUS SPEEDS. WHEN SHIFTING INTO REVERSE, THE INDICATOR MODULE WOULD INDICATE THAT THE VEHICLE WAS IN REVERSE BUT THE VEHICLE WOULD NOT ENGAGE IN REVERSE. WHEN ATTEMPTING TO REVERSE, THE TRANSMISSION WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THEY ADVISED HIM THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 25,000.

TL* THE CONTACT OWNS A 2009 MITSUBISHI LANCER RALLIART. THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING . THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE SERPENTINE BELT WAS SEVERED. THE SERPENTINE BELT WAS REPLACED BUT THE FAILURE WAS NOT CORRECTED. THE SERPENTINE BELT CONTINUED TO FRACTURE AND THE TIRES WERE WEARING PREMATURELY DUE TO A DEFECTIVE TIRE CHAMBER. THE FRONT OUTER TIE ROD AND THE BUSHINGS WERE REPLACED BUT THE FAILURE WAS NOT CORRECTED. THE FRONT TIRES CONTINUED TO WEAR PREMATURELY. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE AND THE DEALER ADVISED THE CONTACT THAT THE TECHNICIAN COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 97,178.

2009 MITSUBSHI LANCER RALLIART PULLS HARD TO RIGHT AT ALL TIMES. TOOK TO DEALER THEY SAID THERE'S NOTHING THEY CAN DO ABOUT IT. TOOK TO A SUSPENSION SHOP SAID MANUFACTURE SET CAMBER IS OFF. I HAVE WENT THRU MY THIRD SET OF FRONT TIRES IN ONLY 45,000 MILES. I BELIEVE THIS SHOULD BE INVESTIGATED FOR SAFETY. *TR

I WAS DRIVING FROM DALLAS, TX, TO EL PASO, TX IN MY 2009 MITSUBISHI RALLIART. AROUND 3PM AND WITH AN OUTSIDE TEMPERATURE OF APPROX 99 DEGREES FARENHEIT (BASED ON THE DISPLAY READOUT ON THE CAR). I NOTICED A VERY VERY STRONG RAW FUEL OR GAS SMELL COMING IN FROM THE VENTS. THE AIR CONDITIONER WAS ON, SO I TURNED IT TO RECIRCULATING AIR, IT PERSISTED, SO I TURNED THE AIR CONDITIONER OFF, BUT THE VERY STRONG GASOLINE SMELL, TO MY AMAZEMENT, PERSISTED. 2 PASSENGERS (MY ELDERLY DAD 76, AND MY LITTLE SISTER, 18) ALSO NOTICED THE SMELL. THE SMELL LASTED AROUND 5 MINUTES, AND WE WERE FORCED TO OPEN ALL THE 4 WINDOWS, EVEN STILL THE SMELL WAS STRONG ENOUGH AND KEPT ON GOING. I STARTED FEELING LIGHTHEADED, SO I TOLD MY DAD, THE PASSENGER THAT I HAS TO PULL OVER (I LITERALLY FELT LIKE I WAS GOING TO FAINT). WE WERE ABLE TO PULL OVER SAFELY AND STEP AWAY FROM THE CAR. LATER I TURNED THE CAR ON AND THE STRONG GAS SMELL DIDNT RETURN FOR THE REMAINDER OF THE DRIVE. ONE OF MY PASSENGERS REPORTED A HEADACHE THAT SAME NIGHT. THIS INCIDENT HAS HAPPENED 2 OR 3 TIMES BEFORE (LAST SUMMER). PLEASE LOOK INTO IT ASAP. THANK YOU. SINCERELY. AND FURTHER INFORMATION AT THIS FORUM THREAD POST, WHICH I HAVE BEEN READING AND FOLLOWING : HTTP://FORUMS.EVOLUTIONM.NET/EVO-X-ENGINE-TURBO-DRIVETRAIN/501950-RAW-FUEL-SMELL-WHEN-DRIVING-5.HTML#POST9479325 I'M NOT THE ONLY ONE EXPERIENCING THIS... *TT