2009 Micro Bird MB II School Bus

Defect. Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2003-2026 MB II, 2006-2026 G5, and 2015-2026 T-Series school buses. An installation error may prevent the wheelchair tie-downs from locking, leaving the wheelchair improperly secured.

Risk. An unsecured wheelchair can move during transit or a crash, increasing the risk of injury.

Remedy. Dealers will inspect and secure the anchor screw cap as necessary, free of charge. Owner notification letters were mailed April 28, 2026. Owners can contact Micro Bird Customer Service at 819-477-2012. Micro Bird's number for this recall is 26-120-AUS.

Defect. Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2008-2025 G5, 2008-2024 MBII, and 2015-2024 T-Series school buses. The rear emergency door exterior handle may unexpectedly break under applied force.

Risk. In the event of an emergency, a broken door handle can prevent or delay emergency responders from entering the bus, increasing the risk of injury.

Remedy. Dealers will replace the rear emergency door exterior handle, free of charge. Owner notification letters were mailed August 15, 2024. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 24-109-EUS.

Defect. Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2006-2021 MBII and G5 transit buses. An inactive electrical harness that is secured in an opening in the B-pillar may become damaged from sharp edges inside the opening.

Risk. A damaged electrical harness may short circuit, increasing the risk of a fire.

Remedy. Dealers will secure the electrical harness and remove the fuse linked to the main cable, free of charge. Owner notification letters were mailed on June 20, 2022. Owners may contact Micro Bird's customer service at 1-819-477-2012. Micro Bird's number for this recall is 22-092-HUS.

Defect. Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2006-2021 MBII and G5 school buses. An inactive electrical harness that is secured in an opening in the B-pillar may become damaged from sharp edges inside the opening.

Risk. A damaged electrical harness may short circuit, increasing the risk of a fire.

Remedy. Dealers will secure the electrical harness and remove the fuse linked to the main cable, free of charge. Owner notification letters were mailed on June 20, 2022. Owners may contact Micro Bird's customer service at 1-819-477-2012. Micro Bird's number for this recall is 22-092-HUC.

Defect. Corp. Micro Bird, Inc. (Micro Bird) is recalling certain 2003-2022 MBII, T-Series, and G5 school buses. The emergency release handle on the service door may bind, not allowing the door panels to open.

Risk. The service door may not open, preventing evacuation of the vehicle in case of emergency, and increasing the risk of injury.

Remedy. Dealers will provide instructions on how to correctly adjust the service door, free of charge. Owner notification letters were mailed on September 8, 2021. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 21-087-DUS.

Defect. Corp. Micro Bird Inc. (Micro Bird) is recalling certain 2004-2021 T-Series, G5, and MBII school buses. The emergency door retaining device may fail to keep the door in an open position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release."

Risk. If the emergency door won't stay open during an evacuation it can increase the risk of injury.

Remedy. Micro Bird will notify owners, and dealers will install a kit to repair the emergency door retaining device, free of charge. The recall April 24, 2020. Owners may contact Micro Bird customer service at 1-819-477-2012. Micro Bird's number for this recall is 20-084-RUS.

Defect. Corp. Micro Bird Inc. (Micro Bird) is recalling certain model year 2006-2014 MBII, G5, and T-Series school buses manufactured January 1, 2006, to December 31, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts built by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Risk. If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy. Micro Bird will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 11, 2015. Owners may contact Micro Bird customer service at 1-819-477-2012, or Ricon Customer Service at 1-800-322-2884. Micro Bird's number for this recall is 15-063-RUS.

Defect. Corp. Micro Bird Inc. (Micro Bird) is recalling certain model year 2006-2014 MB II and G5 school buses manufactured January 1, 2006, to January 9, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Risk. If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy. Micro Bird will notify owners and Ricon will supply supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began during December 2014. Owners may contact Micro Bird customer service at 1-819-477-2012 extension 401 or Ricon customer service at 1-800-322-2884. Micro Bird's number for this recall is 14-058-RIU.

Defect. CERTAIN MODEL YEAR 2006 THROUGH 2010 GIRARDIN G5 AND MBII AND MODEL YEAR 2010 AND 2011 MICRO BIRD G5 AND MB II SCHOOL BUSES MANUFACTURED FROM JANUARY 2006 THROUGH APRIL 5, 2011, FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 131, "SCHOOL BUS PEDESTRIAN SAFETY DEVICES." THE 4-WAY WARNING LIGHTS DO NOT HAVE AN ALARM TO ALERT THE DRIVER THAT THE STOP ARM DID NOT DEPLOY WHEN THE 4 RED LIGHTS ARE ACTIVATED.

Risk. THE DRIVER COULD ERRONEOUSLY THINK THAT THE SCHOOL BUS STOP ARM IS DEPLOYED WHILE THE FIRST SET OF 4 RED LIGHTS ARE ACTIVATED. THIS CONDITION INCREASES RISK OF INJURY TO PEDESTRIANS.

Remedy. MICRO BIRD WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE AFFECTED WARNING LIGHTS WITH WARNING LIGHTS THAT HAVE AN ALARM FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JUNE 2011. OWNERS MAY CONTACT MICRO BIRD AT 1-819-477-2012.

Defect. CORP. MICRO BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2009 AND 2010 SCHOOL BUSES MANUFACTURED BETWEEN OCTOBER 2008 AND MARCH 2010 FITTED WITH RICON PUBLIC USE S AND K SERIES WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFTS UP FUNCTION, IF THE SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

Risk. WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

Remedy. CORP. MICRO BIRD WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. CURRENTLY RICON IS DEVELOPING A SOFTWARE SOLUTION AND IS NOT AVAILABLE. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MICRO BIRD AT 1-819-477-2012.