2012 Lincoln Mkt

Defect. Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.

Risk. If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.

Remedy. Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.

The contact owns a 2012 Lincoln MKT. The contact stated while attempting to start the vehicle, the message "Power Steering Assist Fault" was displayed, the Service Advancetrac warning light was illuminated, and the steering wheel seized. The vehicle was taken to an unknown dealer, where it was diagnosed with steering rack and pinion failure. The contact was informed that the rack and pinion needed to be replaced. The contact was informed that the repair would be covered under NHTSA Campaign Number: 15V340000(Steering); however, the contact was later informed that the recall had expired. The vehicle was not repaired. The manufacturer was made aware of the failure. The manufacturer scheduled an appointment with the dealer on the contact's behalf; however, the dealer declined to perform the repair. The contact was informed that the repair was at the dealer's discretion because the recall had expired. The vehicle was not repaired. The failure mileage was approximately 200,000.

The contact owns a 2012 Lincoln MKT. The contact stated that while the vehicle was parked, the power steering system failure warning light illuminated. The contact was unable to maneuver the steering wheel as needed. The vehicle was taken to a dealer where it was determined that the power steering needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 15V340000 (STEERING); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 12,980.

The car had a recall, and they worked on it. A few years later the power steering went out while driving and almost had an accident. They did not replace the steering gear they only worked on the steering module. If they had replaced the steering gear, it may have solved the whole problem. They know there was a problem and did not do their best to solve it. There may be thousands of vehicles waiting for the time when there could be a serious accident due to Ford's negligence. I was moving slow when the steering quit and may have saved my life or others in over vehicles. I was told it is over $4,000 to repair. I cannot afford the repair. I am without a vehicle to drive. I need it for doctors' appointments.

The recall work was done on 10/27/2015. Ford Lincoln knows there is a problem with the power steering. They will not redo the work that needs to be done properly because of their faulty power steering module. They did not replace the module; they only made an adjustment to it. I almost had an accident because of the faulty power steering. When it went out it is almost impossible to turn the steering wheel. This problem could have created a serious accident with another vehicle, property or even a pedestrian. Anyone owning one of these vehicles could have the same serious problem. I am on limited income and cannot afford to have the problem repaired. I should not have to pay for the repair since Ford Lincoln knows it is a problem. What happened to me was when I was making a turn around a corner the power steering when out and I almost hit a car. I struggled to get it into a parking lot. The driver of the other car followed me in to curse me out. I told him what happened. He got in and checked it and saw it was not working properly. He was nice to offer to drive it to my home a short distance away. His wife followed us in his car. He was strong enough to turn the wheel. He told me to never drive it again that it was dangerous to drive. Ford should correct the problem since it is dangerous when it suddenly goes out.

The contact owns a 2012 Lincoln MKT. The contact stated that the twin-turbo became inoperable. The contact stated that oil was entering the exhaust and the contact was unable to see other vehicles. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the turbo needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was contacted and referred him to the NHTSA Hotline. The approximate failure mileage was 82,000.

The contact's grandmother owned a 2012 Lincoln MKT. The contact stated that when his grandmother was starting the vehicle, she experienced a loss of power steering assist. The power steering assist warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the steering column needed to be replaced. The contact was made aware of NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The vehicle remained at the dealer awaiting the repair. The contact's grandmother was then offered and agreed to a trade-in. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA hotline. The approximate failure mileage was 45,000.

The contact owns a 2012 Lincoln MKT. The contact stated while making a turn, the steering wheel became difficult to turn. The contact stated that the power steering assist warning light was illuminated. The contact drove at a slow speed to his residence. The contact took the vehicle to the local dealer and was informed that the vehicle was over 150,000 miles and NHTSA campaign number: 15V340000 (Steering) would not be honored. The vehicle was not repaired. The manufacturer was informed of the failure and stated that the recall letter was sent to the previous owner and since the vehicle was over 150,000 the repairs would be out of pocket. The failure mileage was approximately 151,566.

TL* THE CONTACT OWNS A 2012 LINCOLN MKT. THE CONTACT STATED THAT WHEN THE VEHICLE WAS TURNED ON AFTER REFUELING, THE POWER STEERING ASSIST WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO NAPLETON LINCOLN LOCATED AT 1610 WAUKEGAN AVE, GLENVIEW, IL 60025, (888)214-2155, WHERE IT WAS STATED THAT THE MILEAGE WAS EXCEEDED FOR INCLUSION IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE MILEAGE WAS EXCEEDED AND THAT THE VEHICLE WAS NO LONGER ELIGIBLE FOR THE FREE REPAIR. THE VEHICLE WAS REPAIRED AT THE OWNER'S EXPENSE. THE FAILURE MILEAGE WAS APPROXIMATELY 300,000.

I STARTED MY 2012 LINCOLN MKT 3.5L THE STEERING WAS HARD TO TURN AND THE DASHBOARD ERROR MESSAGE READS 'POWER STEERING ASSIST FAULT. I GOOGLE IT AND IT SHOWED THAT THE 'POWER STEERING ASSIT FAULT ERROR MESSAGE WAS ON RECALL ON JUNE 2015. I TOWED THE CAR TO LINCOLN ON 1610 WAUKEGAN AVE GLENVIEW IL, THE SERVICE MANAGER SAID AFTER THE DIAGNOSIS THAT THE STEERING GEAR SHOULD BE REPLACED. I SAID OKAY THINKING THAT SINCE THE ERROR MESSAGE WAS ON RECALL IT WILL BE FREE. BUT WHEN I WAS PICKING THE CAR I WAS CHARGED $2806.21. MY QUESTION IS SHOULD I PAY FOR THIS RECALL REPAITS?

TL* THE CONTACT OWNS A 2012 LINCOLN MKT. THE CONTACT STATED WHILE HIS WIFE WAS STARTING THE VEHICLE, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT STATED THE POWER STEERING ASSIST WARNING MESSAGE WAS DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE CONTACT STATED HIS WIFE CONTACTED KRIEGERS FORD LOCATED AT 3205 NORTH HIGHWAY 61, MUSCATINE, IA 52761, (563) 263-5324, AND WAS INFORMED THAT THE MILEAGE EXCEEDED THE 150,000 MILES LIMIT. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NO LONGER ELIGIBLE FOR THE FREE REPAIR. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 181,000.

MY 2012 LINCOLN MKT WITH THE 3.5L TWIN TURBO V6 ECOBOOST ENGINE IS HAVING THE SAME ISSUE WITH THE FUEL PUMP AS THE 2013-2015 MKT MODELS THAT WERE PART OF RECALL CAMPAIGN #16S31. MY CAR WAS ALSO MANUFACTURED AT THE SAME OAKVILLE ASSEMBLY AND WITHIN THE DATES SPECIFIED. I WAS DRIVING WHEN THE CAR STALLED AND THEN STOPPED SUDDENLY STOP AS I WAS MAKING A RIGHT TURN AND WOULD NOT TURN BACK ON. THERE WERE NO ALERTS OR INDICATORS ON THE DASH. WHEN I TRIED TO TURN THE CAR BACK ON, THE DASH LIT UP BUT THE CAR WOULD NOT TURN OVER. THERE WAS A LOT OF OIL UNDER THE CAR WHICH APPEARED TO SPILL OUT WHEN THE FUEL PUMP OVERHEATED WHICH CAUSED THE ENGINE TO OVERHEAT. I AM NOW BEING TOLD I NEED A NEW ENGINE AND TURBO CHARGERS. I HAVE ONLY OWNED THE CAR FOR 7 MONTHS AND HAVE DRIVEN IT ONLY 7500 MILES WHEN THIS HAPPENED. THE CAR HAD 2 FULL SYNTHETIC OIL CHANGES DURING THIS TIME. HOWEVER, THE LINCOLN MECHANIC TOLD MY WARRANTY COMPANY THAT THE ENGINE DAMAGE WAS DUE TO "OIL STARVATION" WHICH IS OBVIOUSLY INCORRECT. THE LACK OF OIL WAS DUE TO THE SPILLAGE AT THE TIME OF THE FUEL PUMP/ENGINE OVERHEATING. THIS WAS AN EXTREMELY DANGEROUS SITUATION TO BE IN BECAUSE THERE WERE NO ALERTS ON THE DASH AND THE CAR APPEARED TO BE DRIVING WELL PRIOR TO THIS. LUCKILY THERE WAS NOT A LOT OF TRAFFIC WHEN THIS HAPPENED. THE CAR WAS ON A CITY STREET AND WAS IN MOTION WHEN THIS SUDDENLY HAPPENED WHILE I WAS MAKING A TURN. SINCE MY CAR WAS MANUFACTURED IN SEPT 2011 IN OAKVILLE I AM CONVINCED THAT IT SHOULD HAVE BEEN

LOSS OF POWER STEERING WHILE ENTERING A HIGHWAY. BECAME VERY HARD TO TURN.

I WAS DRIVING ON THE HIGHWAY NO ONE WAS ON THE HIGHWAY A LOUD EXPLOSION SOUND LIKE IT FELT LIKE SOMEONE SHOT MY CAR IN A CLOSE RANGE AND AM LUCKY TO BE ALIVE I STARTED SWERVING. PULLED OVER FRANTIC TO SEE WHAT IT WAS MY SUNROOF GLASS WAS SHATTERED ALL AROUND THE EDGES GONE. I COULDN'T BELIEVE THAT OUT OF NOWHERE. THE TEMPERATURE WAS LIKE 67 DEGREES NO HOT OR COLD OUTSIDE. AM JUST GLAD THAT THE HIGHWAY WAS EMPTY

TWICE I HAVE RECEIVED THE MESSAGE 'POWER STEERING FAULT' WHEN STARTING MY CAR. WHEN THIS HAPPENS THE STEERING WHEEL WILL NOT MOVE OR IS HARD TO MOVE. LUCKILY I HAVEN'T BEEN DRIVING DOWN THE HIGHWAY WHEN THIS HAS HAPPENED. I HAVE SEEN RECALLS FOR OTHER VEHICLES REGARDING THIS ISSUE.

TL* THE CONTACT OWNS A 2012 LINCOLN MKT. UPON STARTING THE VEHICLE, THE POWER STEERING WARNING INDICATOR ILLUMINATED AND THE CONTACT WAS UNABLE TO STEER THE VEHICLE. THE VEHICLE WAS TOWED TO ACTON FORD (76 POWDER MILL RD, ACTON, MA 01720, (978) 897-7000). THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING). THE DEALER STATED THAT THE VEHICLE EXCEEDED THE MILEAGE REQUIREMENT FOR THE RECALL; THEREFORE, THE CONTACT WOULD HAVE TO PAY OUT OF POCKET TO HAVE THE VEHICLE DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS 3,000 MILES OVER THE RECALL WARRANTY DEADLINE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 153,600. *DT *TR *DT CONTACT STATED SHE WAS NEVER NOTIFIED OF THE RECALL.*JB

WAS DRIVING HEARD ODD NOISES AND BURNT FLUID TRANSFER CASE WAS DEFECTIVE BOTH OF MY FORD AWD DID ECACT SAME THING.

WHILE DRIVING DOWN THE FREEWAY, THE FRONT PORTION OF THE GLASS PANORAMIC ROOF SHATTERED WITHOUT RECEIVING ANY IMPACT. THERE WAS A VERY LOUD "POP" AND WHEN I PULLED OVER I DISCOVERED THE GLASS WAS COMPLETELY SHATTERED. NOTHING TO MY KNOWLEDGE IMPACTED THE ROOF.

STEERING COLUMN MOTOR GRINDS AND CLICKS WHEN EXTENDING AND RETRACTING. THIS OCCURS WHEN STARTING AND TURNING OFF THE CAR. STEERING WHEEL CANNOT BE ADJUSTED. IT WON'T EXTEND FULLY, OR MOVE UP AND DOWN.

WAS DRIVING TO WORK AND THE OLD SISTEM SHUT DOWN WITH OUT WARNING MAINTENANCE ALMOST HIT TWO CARS BEGGING ME JUST THE TIME TO STOP MI CAR TURN ENGINE OFF AND ON I JUST FEEL INSECURE I USE THIS CAR TO DO UBER AND LIFT HOW I CAN WORK LIKE THIS WHEN I TAKE LOOK ON INTERNET FOUND THIS PAGE AND LOT COMPLAIN LIKE THIS TO FORD COMPANY

1) THE INSPECTOR REPORTED THE TIRES MOUNTED ON THE REAR OF YOUR VEHICLE ARE NOT THE MANUFACTURE'S RECOMMEND TIRE SIZE. THE INSPECTOR VERIFIED THE TRANSFER CASE FAILED INTERNALLY AND SNAPPED OFF OF THE TRANSMISSION. THE FRONT U-JOINT OF THE REAR DRIVE SHAFT IS BENT AND LEAKING GREASE (CAN NOT DETERMINE I. THERE IS TRANSMISSION AND TRANSFER CASE FLUID BLOWN BACK ON THE UNDERCARRIAGE OF THE VEHICLE AS A RESULT OF THE FAILURE.