2013 KTM 500 Exc

Routine

Owners filed 2 complaints about this vehicle with federal regulators, most often about the service brakes. It has been recalled 1 time.

What fails

Component	Reports		Crashes	Fires	Injuries
Tires	1		0	0	0
Service Brakes	1		0	0	0

1 safety recall

Part 573 reports

Fuel System, Gasoline › Delivery › Hoses, Lines/Piping, and Fittings12V531000

Filed Nov 9, 20121,181 vehiclesKtm North America, Inc

Defect. KTM North America, Inc.'s (KTM) is recalling certain model year 2012 and 2013 350 EXC-F and 500 EXC motorcycles manufactured from September 2011 through August 2012. Due to the supplier's manufacturing inconsistencies, the preformed fuel hoses may develop cracks or holes at either end. During use, the fuel hoses, located between the fuel tank and the throttle body fuel rail, may allowing fuel to leak.

Risk. The fuel may leak onto the rear tire while the motorcycle is being ridden, increasing the risk of a crash. It is also possible that, in the presence of an ignition source, a fire can occur.

Remedy. KTM will notify owners, and dealers will replace the defective fuel hoses free of charge. The safety recall began on December 11, 2012. Owners may contact KTM Customer relations at 1-888-985-6090.

What owners reported

Newest filings

Tires

Filed Dec 15, 2014ID

TL* THE CONTACT OWNS A 2013 KTM 990 SMT (NA) MOTORCYCLE EQUIPPED WITH TWO CONTINENTAL CONTISPORTATTACK TL TIRES, SIZE 120/70ZR17 M/C (58W). THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14T009000 (TIRES). AFTER CONTACTING THE MANUFACTURER ON SEVERAL OCCASIONS, THE CONTACT WAS MADE AWARE THAT THE REPLACEMENT TIRES WOULD BE SHIPPED ON THE WEEK OF DECEMBER 8TH. AFTER NOT RECEIVING THE TIRES, THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE TIRES MAY BE SHIPPED OUT ON THE SECOND OR THIRD WEEK OF JANUARY 2015. THE TIRES HAD NOT EXPERIENCED A FAILURE.

Service Brakes

Filed Aug 18, 2014MT

TL-THE CONTACT OWNS A 2013 KTM 85 MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE REAR BRAKE FAILED WITHOUT WARNING. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS TEN HOURS. NE

2 of 2 complaints, reproduced as filed.

Across model years

Worst on record: 2013

Year	Complaints	Recalls	Assessment
2016	1	0	Routine
2013 — this page	2	1	Routine
2012	0	1	Routine

Compare every 500 Exc year →

Other KTM models

All KTM models →

790 Adventure R 49 300 Xc-W 37 690 Duke 35 790 Adventure 24 1290 Super Duke R 18 690 Enduro R 15 390 Adventure R 14 390 Adventure 12 690 Smc R 10 950 Supermoto 8

Reading this record

No unusual pattern of severe incidents in the complaint record.

Complaint counts track how many cars were sold and how long they have been on the road as much as they track quality. A common model from 2013 has had a decade to accumulate reports; a rare one from last year has not. The signal worth weighing is in the severity columns, in whether the same component keeps appearing, and in whether the manufacturer eventually opened a recall for it.

Recall repairs are free for as long as the recall stands. Check whether a specific car still has open work at NHTSA's VIN lookup.

Most recent recall on file: Nov 9, 2012. Source: NHTSA Office of Defects Investigation.