2016 Kia Soul complaints

Vehicle paint(white) is peeling off 2016 Kia Soul

When car is turning a right, the car turns off. When car is parked & stearing isnt straight car wont turn on.

Kia Soul 2016 white color. The factory paint is peeling off completely.

SUBJECT: Engine → Stall → Loss of power while driving: While driving normally, the vehicle began losing power and could not accelerate properly. The engine warning light illuminated and the vehicle repeatedly entered a reduced-power condition where it could barely maintain speed. The vehicle would stall while driving and then restart after sitting. This occurred multiple times over a period of time and progressively worsened. The engine also began consuming large amounts of oil between oil changes. Eventually the engine suffered catastrophic failure and would no longer run. A dealership later stated internal engine damage was present, including a failed valve and spark plug damage. The vehicle is currently at a dealership and available for inspection. The loss of power and stalling created a safety hazard because the vehicle could not maintain normal traffic speed and could have been struck by other vehicles. The problem was confirmed by a dealership service department. Warning lights were present prior to final failure and appeared during the loss of power events.

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, while making a right turn, the right turn signal blinked extremely fast. The contact stated that while making a left turn, the left turn signal blinked normally. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The vehicle was scheduled for a diagnostic test. The manufacturer was not made aware of the failure. The failure mileage was approximately 73,000.

I have put my 3rd Catalytic Convertor on this car. It looses power going uphill. Which is not safe. Just had 3rd on replaced yesterday Feb. 9, 2026. The mechanic said there is too much oil going to the engine. Mechanic said next thing would be replacing the engine. Why does my 2016 not have a recall on the engine.

I paid almost 3,500 dollars and Kia kept my car two months and I’m still having transmission issues and now they are asking for service receipts. After I picked up my vehicle from the original transmission repair I was back in less than 7 days because transmission was roughly jumping in gear and shifting horribly with burning smell. The technician noticed the problem and immediately took my car to the back but they kept my car another 30 days saying that they did an update and now I’m stuck suffering with a struggling transmission. My mpg has drastically dropped on this vehicle to a 9.6 and that is not normal. I paid cash and Kia need to help me in any way. They are trying to wait until the 12,000 mile warranty runs out and leave me stuck and that’s not fair when I’ve been complaining since I picked up the car the second time but they won’t assist me now. My Vehicle experiences delayed transmission engagement, RPM increases without acceleration, hesitation, and loss of fuel economy. Dealer refuses diagnosis unless complete failure occurs. This creates unpredictable vehicle response and loss of power concerns. Transmission hard shifts and jerks violently during gear changes and acceleration, causing loss of smooth power delivery and unsafe vehicle behavior.

The vehicle is suffering from excessive oil consumption (over 1 quart per 1,000 miles) and a recurring P0420 (Catalyst Efficiency) code. This is a documented precursor to catastrophic engine failure and engine compartment fire in the 2.oL Nu GDI engine. The engine's oil consumption is poisoning the catalytic converter, causing it to clog. This creates extreme exhaust backpressure, leading to sudden loss of motive power (stalling) while driving. This defect poses an unreasonable risk of a high-speed collision and fire if oil comes into contact with the hot exhaust manifold. Due to current extreme winter conditions (-20F with wind chill), a sudden engine stall or seizure creates a life-threatening emergency. I no longer feel safe operating this vehicle, as an engine failure in these temperatures could leave me stranded without heat in sub-zero weather.

While driving on a road trip from Charleston, South Carolina to Florida in January of 2023 the factory installed catalytic converter failed (front facing) clogging the exhaust system and damaging the engine (engine now experiences blow by and pistons rings have been damaged). A recall for the overheating of the catalytic converter was marked as repaired before I bought the car. However, I believe that either the update was not done to the on-board computer or that a damaged catalytic converter was not replaced. This directly led to the subsequent failure in question and has since damaged my engine. At the time of the incident, an investigation of both catalytic converters revealed heavy sediment deposits and the core of the filtering component of the front facing unit had become so corroded that a chunck of it had broken loose and become lodged in the connecting hose that linked it to the rest of the exhaust system, leaving the entire system blocked. Because I bought the car used, I wasn't aware of the recall history at the time of purchase. Nor was I given a vehicle history report or receipts for any work that had previously been done. When I pulled a vehicle history report shortly after the incident I was unable to accertain what the actual repairs to the car were previous to my ownership, just that it had been taken to a Kia dealership for service with dates listed. The issues still remain and I am unable to afford the lengthy and very expensive repairs suggested by multip

Engine knock engine failure

They have a recall on the catalytic converters for the 1.6 engines but not the 2.0. I have had to have mine replaced two times in a year. There is definitely a problem. The second time it almost caught fire due to glowing red cause it got so hot. The same problem is happening to the 2.0 engines just like the 1.6 engines, but nothing is being done.

The Instrument Cluster, the Speedometer and "NOW" the Odometer are not working--absolutely dead. "NOW" is in caps because to my surprise I noticed just recently that the Odometer is not working. In April 2021, after several weeks of waiting for the repairs to be finished, a Kia dealer, PEAK KIA in Colorado replaced the Instrument Cluster because of the faulty Speedometer. (This repair was done after several months of back and forth to more than one Kia Dealer about this problem. Unlike now where the Speedometer is dead, not moving at all, at that time it would stop working periodically, perhaps when my car was cold or not. It took several months of dealing with Kia dealerships to acknowledge that it was a problem.) Right after the replacement in 2021, I texted the PEAK KIA mechanics-representative, named Trevor, that it was still a problem, not working every now and then. He replied in a text "What?" and that he would check with his technician. He never got back to me with an answer, and would not return my phone calls.) Since that time, I've been dealing with this infrequent or sometimes-problem. Note, I work from home so I do not drive my car every day, only once or twice a week. However, just recently before and around the holidays, I noticed first that the Speedometer was dead, the needle was not moving at all during the entire time of driving, instead of every now and then. And closer to the holidays, I was shocked, noticing that the Odometer was NOW not moving. This had

I went into the store come out of the store and got in the driver seat shut my door and the rear windshield exploded. I looked it up online and there are other customer complaints of the Kia soul with the same issue of the rear window exploding I called Kia and they told me even if the warranty was still good on my vehicle that it would have to go under inspection and it still would be an if he situation because other factors could be making the windshield explode Kia was unhelpful rude and did not want to help with the problem

Greetings, I have a base 2016 kia soul manual transmission that I thought was under safety recall for its engine, but when I search it says 0 unrepaired recalls, when I look this up it does claim my vehicle had this problem, but I never had a dealer fix it, I did contact the one I got it from a couple of years ago and asked if my vehicle qualified for the recall since it already has 200,000 miles on it but they never got back to me, did they just claim to fix it, because it has not been worked on. Still runs great at 300,000 miles but if the engine has a safety issue that might catch on fire then I want to get it addressed regardless of its high mileage

A. Safety Defect and Failure Sequence I am filing this complaint because my Kia Soul, which is subject to the widespread engine defect and extended warranty under the Hyundai/Kia Class Action Settlement, suffered a catastrophic failure immediately following dealership intervention. Responsible Action: I brought the vehicle to the authorized Kia dealership on September 25th the instant the Check Engine Light illuminated for the very first time. The vehicle was driven to the dealership under its own power. Triggering Event: The dealership performed the required engine-related software update (Knock Sensor Detection System, KSDS) and routine service. Immediately following this service, the engine went into limp mode and ceased functioning, requiring a complete engine replacement. This sequence strongly suggests the failure was either caused by the known defect covered by the recall or was triggered by the software update itself. Manufacturer Denial: Kia is denying the claim under the Class Action Extended Warranty (which provides a lifetime or 15-year/150,000-mile warranty) using the unsubstantiated and unjustifiable excuse of "damage done prior to bringing the car in." B. Manager Misconduct and Manufacturer Bad Faith The Service Manager, Braden Anaya, has demonstrated calculated deception and bad faith, resulting in severe financial and logistical harm: Fraudulent Promise: The manager explicitly promised me the engine replacement would be approved if I titled, registered, and i

Several times in the past year the power steering has spontaneously failed requiring significant Force to stabilize the vehicle and creating an obvious Hazard while driving. The forward Collision system indicates there's a fault while this occurs. Sometimes this is cleared by cycling the power on and off. The vehicle has been inspected by the dealer who indicated they cannot locate the source of the problem. Even a casual search / look at Community Bulletinboards online indicates that this is a much larger problem that Kia refuses to address. https://www.kia-forums.com/threads/loss-of-power-steering-when-driving.84792/

When the steering wheel tilt is adjusted while driving, the vehicle experiences a complete electrical shutdown — dashboard goes black and the engine may shut off. Electrical power may return when the steering wheel position is changed again. Because this involves a total loss of power while the vehicle is in motion, I am concerned about driver safety and would like this addressed as soon as possible.

The contact owns a 2016 Kia Soul. The contact stated that while driving at various speeds or while shifted into park(P), there was an abnormal knocking sound coming from the engine. The check engine warning light was illuminated. The vehicle had been taken to the local dealer, where it was diagnosed as needing a Product Improvement Code before the failure. The vehicle was not repaired due to the cost. The contact stated that a rental vehicle was paid for out of pocket. The contact related the failure to NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling); and the contact was informed that the vehicle was repaired prior to ownership in 2020. The manufacturer was made aware of the failure. The failure mileage was approximately 117,000.

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact became aware that there was oil leaking from the engine near the spark plugs while checking prior to the warning light being illuminated. The vehicle was taken to a local dealer who diagnosed the vehicle and determined that the head gasket needed to be replaced. The vehicle was repaired; however, the vehicle was still leaking oil, and the check engine warning light was illuminated. The contact was constantly adding oil to the engine. The contact had taken the vehicle back to the same dealer and was advised that the catalytic converter needed to be replaced, and a tune-up was needed. The catalytic converter was not replaced, and the contact stated that the engine was still leaking oil. The vehicle was not repaired. The contact had taken the vehicle to several independent mechanics and was advised that the engine needed to replace, however the vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 177,000.

Transmission failed when mileage was at 88,000 miles and is not opererational to drive. After taking car to a pirate auto shop the mechanic informed me it showed codes P0753 and P073, and informed me the transmission fluid had metal debris inside it. This is a known defect from this specific Kia model. Then took it to the Kia Dealership in Chula Vist, for diagnostic, they informed me P073 code shown up and recommended to replace the transmission. This is known defect that is associated with the Kia Soul manufacturer, and is related to the recall. My safety was put at risk when I was driving and after I stopped at a red light the car was in drive and would not accelerate when I pressed the gas, this problem was confirmed by the dealership with diagnosis paperwork. Their was no warning when this issue occurred, additionally Kia corporate refuses to accept responsibility for their manufacturer defect.

While driving my 2016 Kia Soul on the highway, the vehicle suddenly began shaking and immediately lost power. The check engine light came on and the car would not accelerate, even when pressing the gas pedal. This happened with no prior warning. I had to coast to the shoulder in moving traffic, which created a safety concern. The engine then stalled completely and would not restart. The vehicle was towed to Findlay Kia in Las Vegas. Their technicians diagnosed a major internal engine failure. The repair report shows zero compression in cylinder 2, a cracked intake valve, oil contamination, and extensive internal engine damage requiring a full engine replacement. Diagnostic trouble codes included P0300, P0302, P0303, and P0326. There were no earlier symptoms, no overheating, and the vehicle has been properly maintained. The failure was sudden and left the car completely inoperable. I opened Case #[XXX] with Kia Corporate. They reviewed all documents, service records, and the dealer’s findings. Although they did provide assistance in reviewing the case, the final outcome was not in my favor, and they declined to cover the repair. This is concerning given the history of engine-related issues and recalls involving Kia Souls from similar model years, particularly involving sudden engine failure and loss of power. My vehicle remains inoperable at the Kia dealership. The sudden loss of power while driving presents a clear safety risk. Based on my experience and the dealership’s find

AIRBAGS DID NOT DEPLOY

I was driving in the carpool line to Anaheim with my daughter, the car starts pulling and make a noise in the front part and start loosing speed, from 75 miles per hour to 40 miles per hours in 2 minutes. I drove to the safety zone but in high risk to a crash. All the sensor lights on in the front part. And the steering feels hard, no movement. We feel so stressed and unsafe. The police officer help us and The 511 towing help this was on October 16th. We pay $830 dlls to the AAA to bring the car to San Diego.

I was driving on Interstate I-40 when the closed sunroof spontaneously shattered. Nothing external or internal hit the sunroof. Due to the explosive noise, I was distracted and almost wrecked. Luckily, no one was injured, and no property was destroyed other than the shattered sunroof. This is an extremely unsafe issue and needs prompt attention to rectify before someone gets seriously hurt!

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact heard an abnormal clunking sound coming from underneath the vehicle. In addition, the RPMs increased to 3,000 and the vehicle lost motive power. No warning lights were illuminated. The vehicle was driven to the shoulder of the road. The contact turned the vehicle off. The contact stated that while attempting to start the vehicle, the vehicle started. However, the accelerator pedal was depressed, and the RPMs increased to 3,000 again. In addition, the contact stated that the vehicle failed to accelerate above 20 MPH. The vehicle was towed to the dealer, where it was diagnosed with catalytic converter failure. The contact was informed that the catalytic converter needed to be replaced. The vehicle was not repaired. The contact was informed that the repair was not covered under any unknown recall repair. The manufacturer was made aware of the failure. The manufacturer was made aware of the failure. In addition, the contact referenced NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). However, the contact was informed that the repair was already performed on the vehicle and was not covered under warranty. The failure mileage was approximately 97,945.

Catalytic converter may become damaged due to overheating caused by and excessive increase of exhaust gas temperatures.

Had 3 oil consumption test 2 oil leak repairs, low to no oil each time, now car is stalling , Catalytitic Converter problem, yellow engine light is blinking, Kia of Newton New Jersey need to fix my car.

Car was purchased from dealership August 25, 2025 on September 19, 2025 at about 9:38 PM. Car experienced catastrophic engine failure due to an active recall/campaign that was not disclosed to buyer for an ECU problem. This problem caused total brake failure in the power brake system, forcing buyer to swerve across three lanes of traffic into breakdown lane.

The contact owns a 2016 Kia Soul. The contact received notification of NHTSA Campaign Number: 17V608000 (STEERING); however, the part to do the recall repair was not yet available. The vehicle was taken to the dealer. The vehicle remained at the dealer unrepaired. The contact stated that on a separate occasion, while driving at 40 MPH, the transmission seized and failed to function as intended. The vehicle stalled, and after several attempts, the vehicle was restarted. The contact continued to drive at slow speeds. The local dealer was contacted. The vehicle was diagnosed with catalytic converter failure. The contact was informed that the catalytic converter needed to be replaced. The vehicle was repaired under NHTSA Campaign Number: 19V120000 (ENGINE, ENGINE AND ENGINE COOLING), but the failure persisted. The contact was informed that the recall part for the steering was not available. The dealer informed the contact that the catalytic converter was still under the previous recall and there would be no charge. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that the catalytic converter was not covered and that there would be an out-of-pocket expense. The failure mileage was approximately 50,000.

Rcall SC176 I have tried multiple times to schedule the required recall repair for my Kia, but my local dealer has not responded to phone calls or emails. I cannot travel to another state to complete this recall. Kia has not provided a reasonable option to complete the safety repair. I am requesting assistance to get this recall completed safely and locally, and at no cost.

The engine makes a noise like a knock, when the car is running or the speed increases the noise becomes louder and it feels like a strong blow coming from the engine.

I was on my way home from work and the car just cut off .it wont move forward or backwords..the lights,radio all was on the car just wouldnt move ..i turned the key off and tried to start it up..it did nothing ..waited bout 10 minutes it started back up ..i looked up the recalls .SC176 sounds like what happen to it

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. No warning lights were illuminated. In addition, the vehicle hesitated while driving. The vehicle was taken to the dealer, where it was diagnosed with catalytic converter failure. The contact was informed that the catalytic converter needed to be replaced. The vehicle was not repaired due to the cost. The failure recurred, and the contact parked the vehicle. The vehicle was no longer being driven due to safety concerns. The manufacturer was notified of the failure. The failure mileage was 111,157.

Inhibitor Switch has to be replaced. 2017 vehicles had a recall, dealership wants 747.00 to fix same when a recall for same a year later?

My 2016 Kia Soul is now consuming oil excessively and emitting smoke from the exhaust. These symptoms only began after a dealership performed recall-related work (knock sensor replacement and KSDS software update). The vehicle is covered under Kia’s Technical Service Bulletin ENG222 (Rev. 7, Feb. 2025), which lists the Kia Soul (2012–2024) as eligible for evaluation and repair of oil consumption due to piston oil ring failure. This bulletin requires that a sealed oil consumption test be performed when customer complaints of oil consumption or smoke are verified. Despite this, Kia America has denied warranty coverage, stating the vehicle passed the rod bearing clearance test (BCT) and therefore does not qualify for an engine replacement under the class action settlement. This is misleading and incomplete because: The oil consumption issue is a separate covered defect under TSB ENG222. My vehicle is within the mileage (94k) and time limit (15 years/150k miles). Kia has refused to authorize the required oil consumption test. The smoking and oil consumption symptoms only began after the dealer performed recall service. This denial leaves me with a vehicle that is unsafe to drive due to risk of sudden engine failure, increased emissions, and potential fire hazard from oil burning. Kia is not following its own published service procedures, leaving consumers without protection despite official warranty extensions. I request that NHTSA investigate Kia’s handling of oil consumption cl

The check engine light has come on multiple times, indicating an engine failure defect, a known and recurring issue among this vehicle’s model. The problem first occurred on [XXX], again on [XXX], and is ongoing since [XXX]. The vehicle has been inoperable since [XXX], and remains at the dealership. The defect puts the safety of the driver and others at risk because the vehicle can become inoperable without warning while driving. The issue has been inspected and documented by the dealership each time it occurred, but repairs under warranty have failed to resolve the defect. Prior to the failures, the check engine light illuminated as a warning. The recurring nature of the problem and its continued presence despite recommended maintenance indicate a systemic engine defect that has not been adequately repaired or addressed by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2016 KIA SOUL- While driving, vehicle lost power, check eng light came on and vehicle would not accelerate, engine started making noise- pulled over and shut car off. Had vehicle towed to independent shop and was diagnosed with bad catalytic (manifold) convertor- they changed oil and filter and also found metal in oil, which I never experienced till this incident- upon research i found that there was a recall on that convertor, i called dealer, had towed there- diagnosed as convertor, was told covered one day, then called next and told it was not. Evidently, looking at reviews and complaints, there are many people driving 2016 kia souls that were not covered under this catalytic recall. Seems that Kia never fixed the original issue. Warning DON'T BUY A KIA- I have contacted Kia customer care, case [XXX] and they have said car did not have recall and are not giving any assistance. To edit, this is [XXX] vehicle INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Check engine light came on. 4 new engine coils and spark plugs. Carb cleaner in gas. Check engine light on again then while driving car jerked and check engine light blinking. Code 420 catalytic converter. This vehicle was under recall for same issue but was ok at time of recall. Was checked at Kia dealership u see recall time.

My 2016 Kia Soul is experiencing severe oil consumption, piston ring failure, and smoke from the exhaust. The vehicle is covered under Kia’s engine warranty extension (Product Improvement Campaign PI2002B and subsequent updates), which extends coverage to 15 years/150,000 miles on the engine short block/long block assembly. The dealership confirmed the failure is due to piston oil rings, but Kia America has denied warranty coverage, stating that because the rod bearing clearance test passed, the repair is not covered. This denial contradicts Kia’s own documentation, which defines the covered “short block assembly” as including pistons and piston rings, in addition to bearings and connecting rods. By refusing coverage, Kia is effectively narrowing the warranty in a way that leaves consumers unprotected, despite the campaign language. This issue raises a safety concern because excessive oil consumption and piston ring failure can lead to: Engine smoke and emissions problems, Sudden power loss, and Increased risk of engine failure while driving. I am requesting that NHTSA investigate Kia’s handling of piston ring and oil consumption failures under the engine warranty extension, as Kia appears to be limiting coverage only to rod bearing failures, despite covering the entire short/long block assembly on paper. Summary: VIN covered under PI2002B/KSDS update. Engine is consuming oil and smoking due to piston ring failure. Kia refuses coverage because rod bearings passed the clearanc

The vehicle when coming to a stop to park I press the engine off button and a car with a key symbol stays on and won’t go off and there is a beeping with screen not turning off. Have to turn car on and off numerous times to get it to turn off

While driving my 2016 Kia Soul Plus on the highway, smoke began coming from the rear of the vehicle. Within seconds, flames were visible. Other drivers flagged me down, and I was able to pull over. I evacuated three dogs from the car, but the vehicle quickly became engulfed in flames and was a total loss. The fire department responded and extinguished the fire. There were no warning lights or unusual performance issues immediately before the fire started. The vehicle had not been modified and was in regular use. This incident posed a severe risk to my safety, the safety of my pets, and others on the road. My VIN currently shows no active recalls, but Kia has issued recalls for engine and electrical fire risks in other Soul models. The fire appears related to engine, electrical, or fuel system malfunction. I strongly believe this defect should be investigated for inclusion in Kia’s fire-related recalls.

Kia 2016 died in mid traffic, would not switch out of 1st gear as an automatic, on a major road in Texas, no warning lights etc. Could be Transmission or Catalytic convertor.

The paint of my white Kia Soul 2016 has been peeling on the cars hood, roof, doors. It gets worst every day. I checked for paint recalls but there is no recall at this time.

Unknown

The vehicle started losing power and then stalled just as we pulled onto our road to our home, no light indicators were on and it started back up, but the traffic behind us causing slowing and potential risk to us and others. When restarted it would not accelerate appropriately and at that time we were able to put it in neutral and push it the remaining way, again causing a VERY dangerous situation. Upon inspection it was noticed that the oil was barely readable. We added 4 quarts (the vehicle has routine oil changes and is not due for another month or 1,000 miles) and let it sit for about 20 minutes. Upon restarting, the engine started making a loud pinging sound and oil was noticed coming out around the butterfly valve. At that time the cabin air filter and engine air filter was changed, butterfly valve cleaned and another quart of oil with valvoline stop leak added. Engine started and ran decent. Used car next day after rechecking oil, after about 15 minutes of driving it stalled once again, in traffic and pinging was tremendous, black smoke from the exhaust. The vehicle is the only vehicle we have, ONLY transport to work and have now lost out on 4vdays. We need this addressed. This is ridiculous that our VIN isn't included in the recalls that are experiencing the exact issues in the exact year makes and models. Help please!!!

4 29 23 at 101091 miles the catalytic converter was replaced. The car sucks up oil before even the 3000 .mark..kia performed. Then on7/8/25 wg baker replaced catalytic converter again. Also coding of abs brakes now and why would catalytic converter need replacing? Because car is eating off oil. Yes my car stopped on the interstate and I had to pull over. I've already done two tune ups.

Engine has lower end knocking noise,internal failure

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light was illuminated. The contact stated that while the vehicle was accelerating, an abnormal sound could be heard coming from the engine. The vehicle was taken to an independent mechanic, where it was diagnosed, and the contact was provided with DTC: P0014 and P0013. The contact stated that the check engine light was turned off, and the camshaft was replaced; however, the failure persisted. Additionally, the contact stated that the horn had failed to function as intended. The vehicle was taken to a different independent mechanic, where it was diagnosed with electrical failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 19V120000(Engine, Engine and Engine Cooling); however, the VIN was not included in the recall. The failure mileage was unknown.

On our way to Florida, our car broke down on the highway. When we were able to get our car towed to a mechanic, the mechanic stated that the issue was a rod bearing went out which matches the kia recall reasons for the same vehicle as ours. We took the car to Kia and they tested it and the rod bearing was the issue. We had no warning lights prior to our car breaking down and it was taken for an oil change just 5 days before. See below for more info on the recall: The 2016 Kia Soul, specifically models with the 1.6L GDI engine, was included in a Kia product improvement campaign related to connecting rod bearing wear. This campaign involved a software update for the Engine Control Unit (ECU) to implement a Knock Sensor Detection System (KSDS). The KSDS is designed to detect early signs of bearing wear and alert the driver via a blinking Malfunction Indicator Lamp (MIL) and Limp Home Mode. This prevents severe engine damage, including potential engine failure. Some 2016 Kia Souls with the 1.6L GDI engine experienced excessive connecting rod bearing wear, potentially leading to engine damage.

Component/system failed: Engine and Power Train. Available for inspection: Yes, the vehicle is currently at the dealership. After a loud ticking/knocking noise from the engine began, the car lost power while driving. It matches symptoms associated with Kia’s known connecting rod bearing failure issue (covered under Recall SC176 and Campaign PI2002A). There were no warning lamps at first, but later the oil pressure warning light began to flash intermittently. A Kia dealership confirmed the issue and completed the PI2002A ECU update. However, they denied the extended engine warranty coverage under the campaign, saying that the vehicle was purchased at an auction, even though this issue stems from a known manufacturing defect and recall that should apply to the vehicle, regardless of ownership history. This creates a serious safety concern, as the engine could seize while driving. This issue has been reproduced and confirmed by the dealership and documented under Kia Case #25414628 and #25331856. This denial contradicts the campaign terms and puts drivers and others at risk.