2012 Kia Optima complaints

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Paint is peeling off top of my car and also along windshield and hood of my car.

When attempting to acceleate rapidly, as if passing someone, the car will decelerate and eventually die, leaving you stranded on side of road or in the highway.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, there was white smoke coming from the rear of the vehicle. In addition, the contact smelled burning fumes on the interior of the vehicle. The vehicle was taken to the dealer. The contact stated that the dealer cleaned up some spilled oil underneath the hood. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

While driving will will get “hybrid system. Warning check brakes”. Car will loose acceleration. After turning car off for five minutes, error goes away and car drives. Happens for no reason and has occurred 4 times in the last week

2012 Kia Optima snow white pearl paint. A few months ago the paint started bubbling and then flaking off. There are areas all over the car with bubbles and missing paint. This is a latent defect in the paint process, not a warranty issue. Every area of the car is affected. Kia needs to accept responsibility for their defect and fix this paint problem.

The contact owns a 2012 Kia Sorento. The contact stated that the air bag warning light was illuminated. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 129,000. VIN tool confirms parts not available.

The contact owns a 2012 Kia Optima. The contact stated while driving at approximately 55 MPH, the vehicle hesitated. The vehicle lost motive power and was slow to accelerate. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the high-pressure fuel pump was failing. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The contact stated that the failure was related to NHTSA Campaign Number: 18V907000 (Fuel System, Gasoline, Engine). The approximate failure mileage was 88,800.

It has started burning oil, we have to continually check it. There are no leaks but oil burns too fast, we check it almost daily.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The contact stated that while driving at approximately 80 MPH, the vehicle stalled. The vehicle was placed in neutral(N) and steered to the side of the roadway. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The contact stated that on several occasions while driving at various speeds, his wife observed a burning odor inside the cabin. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and the contact was advised that parts were not yet available. The failure mileage was 158,000.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power, stalled, and failed to restart. There was no warning light illuminated. The vehicle was towed to the residence. The vehicle was then taken to the dealer, but no assistance was provided. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 138,450. VIN tool confirms parts not available.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owned a 2012 Kia Optima. The contact stated while driving approximately 50-60 MPH with someone in the front passenger seat, she noticed smoke, and then fire coming from underneath the hood. There was no warning light illuminated. The contact immediately veered to the side of the road. Both the contact and her passenger exited the vehicle. The contact stated that the fire extended significantly and the vehicle burned from the front end to the rear seats. The fire department extinguished the fire. The contact could not confirm whether a fire department report and a police report were filed. There were no injuries sustained. The vehicle was towed to a tow lot, where it was totaled. The contact later received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) that she related to the failure. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 130,000.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated after pulling up to her residence and exiting the vehicle, the contact observed that there was smoke coming from the passenger’s side headlight. The contact drove the vehicle to a local dealer where it was diagnosed; however, the dealer could not determine the cause of the smoke. The failure mileage was approximately 113,000. VIN tool confirms parts not available.

When driving the vehicle the engine light is on & under the hood is smoking . It smells like burnt rubber or just burning something. This started happening right after the engine light came on. It’s not safe to drive my vehicle at this point

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I received a safety call notice my car was still working fine I’m waiting for the next notice according to this notice and my car breaks down still no notice said to call the number on it I did nothing, THE CAR STOPPED IN MIDDLE OF THE FREAKIN TRAFFIC ON A GREEN LIGHT ALL CARS GOING FAST BEEPING AT ME AND MY CAR WONT TURN ON ITS RAINING AND MY HUSBAND IS PASSENGER THANK GOD MY BABY WASNT W ME BUT WHAT IF SHE WAS , I expect Kia to answer and NOT CHARGE ME TO COME GET ME WHEN ITS THEIR FAULT THE CAR DOESNT WORK WHAT IF WE GOT HIT MY CHILD WOULD OF LOSTVHER PARENTS WE COULD OF REALLY BEEN HIRT SMOKE EVRYWHERE CAR STINKS LIKE ITS BURNING UP I REALLY THOUGH WE WHERE ABOUT TO EXPLODE THE WAY IT SMOKED UP AND SMELLED SO BAD CARS PASSING BY JUST THINKING YOU CANT GWT OFF AN HAVE TO STAY PUT UNTIL THEY STOP I COULD HAVE DIED

MDPS Flex Coupler worn out & caused play in steering wheel.

Still no remedy for fve safety recall and my car continues to smoke leaving it unable to be driven.

I contacted the Kia dealership in Wexford, PA on November 18 regarding the HECU safety recall and was told there is no fix available. The date of the notice was November 14, 2023 and I still haven't received an update from Kia. I haven't seen the MIL or ABS illuminated in my vehicle, but have experienced a slight burning smell over the past two days. My family's safety is paramount so I'm filing a formal complaint with the NHTSA. Kia America must address this issue and provide an immediate solution.

The MDPS steering motor flexible coupling on our 2012 Kia Optima has deteriorated and a metal to metal clunking noise is made when turning the steering wheel left or right. See Kia Technical Service Bulletin (XXX) dated August 2016. Stated in the Bulletin is warm ocean waters in high humidity areas from Texas to South Carolina causes the problem. Apparently, those warm ocean waters and humidity do not go further north carried by the Gulf Stream and the warmer spring ,summer and fall seasons ; up to Long Island in NY as well as up to Maine. Kia has extended the warranty from 5 years/ 60,000 miles to 10 years/unlimited mileage for vehicles in other states but not from the TSB year of 2016 when the issue was first documented. So our 2012 is not covered because 2022 is over. Please note , our car has 40,000 miles and has been garage kept. This mileage is 20,000 miles less than the 5 year warranty while the 10 year warranty mileage is unlimited. This steering part needs to be made into a mandatory recall by Kia. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Vehicle is under recall 23V652 for HECU short circuit issue. Vehicle was running fine, driven to local mechanic for routine oil change and inspection. MIL was on with P0445 indicating a short circuit on Purge control valve. Mechanic replaced Purge control valve which did not reset maintenance light. Mechanic investigated and found evidence of a thermal event (fire) within the wiring harness near the computer. Mechanic contacted me and I notified him of Interim Recall notice. Vehicle was towed to local Kia dealer where they will not honor recall as there is no current solution. They said they can not prove the incident was HECU without replacing wiring harness which I must pay for.

Door latches lock you in the vehicle, currently 67k original miles, both front door latches would not allow you to exit car, at 50-51k miles, the window must be down, and to get out, crawl out, or reach out, pull outside handle and open door, then put up window, reset latch so it aligns , close door. If cars on fire and window up from inside, you can’t get out! You will burn up w/car and passengers, because you’re trapped by door from getting out.

The transmission automatic, shifter somehow disconnected from transmission, while driving, once it happened, stepping in gas pedal only revved engine, on highway in traffic, glided to to side of highway, and brakes did work, no transmission, dealer later stated and have dealer report, the piece that engages the trans to the shifter was defective and broke or fell off during vehicle operation, put a new 1 on, and then I could use gears again, regardless when it happened, any driver lost all power to stay, go or keep w, traffic, only attempt could be to safely get off highway.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that while starting the vehicle, she noticed smoke coming from underneath the hood of the vehicle. Additionally, the contact stated that the taillights remained illuminated while the vehicle was turned off. There was no warning light illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, but no assistance was provided. The failure mileage was approximately 130,000. VIN tool confirms parts not available.

My car started losing its lights one by one. I lost the front right light first, then yhe right back side light, and now the brakes lights. I replaced all the bulbs and still does not work. Then my car just cut off while driving with no notification. I towed it in to Mavis. They checked and said the battery was not keeping charge. I paid to replace the battery ,belt and alternator. Four days later my check engine light, battery indicator, airbag indicator, door indicator came on and still is on.

On September 27, 2023 I was driving home at 50 mph on 41st & Lynn Lane in Tulsa, Broken Arrow, OK. The car just shut down right before I had to stop at a stop sign. Not being mechanical minded the only thing I could think of was to call a towing company (AAA). I was informed to also call 911 to have a police officer come and block traffic to keep me from getting hit. It was towed to the only garage there is close to my house as the Ferguson Dealership couldn't take it at the time. It was at a place called The Garage. They at the time told me they thought it was the fuel pump and replaced it. The work was done on October 2, 2023. On November 26, 2023 I was driving home on the Cimarron Turnpike when the car just lost power. I pulled over as best I could and did after a bit get it to start again. I called my brother to see if he would follow me home as the car jerked and would only do 60 mph. I put on my flashers and my brother did follow me home. I have researched the trouble and saw a recall #147 (Kia's # I believe. it is a recall for the engine and something to do with the KSDS. Kia Dealership ( Ferguson Kia) again couldn't take the car so I took it to The Garage again and received a call from the tech that I need another motor. I am calling Kia Corp to see if they will replace it.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced a failure. The contact stated that his wife was driving the vehicle at approximately 35 MPH when she was she flagged by another driver that her vehicle was emitting flames under the vehicle on the front driver's side near the wheel well. The contact stated his wife was not aware of any warning lights and pulled the vehicle over and stopped. The contact stated the fire department was on scene and extinguished the fire. The vehicle was towed to a local dealer, the contact had no information on the diagnosis by the dealer. The vehicle was repaired. The failure mileage was approximately 116,000. The contact related the fire to the current NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic). The contact stated that the vehicle was recently returned to the dealer due to engine failures. VIN tool confirms parts not yet available.

THE ENGINE QUIT WHILE ON THE HIGHWAY TO MY HOME. I WAS DOING THE SPEED LIMIT OF 75 MPH WHEN I HEARD A NOISE AND THE CAR STARTED LOSING SPEED. I COULD BARELY PULL TO THE SHOULDER OF THE ROAD. THERE WAS A LOT OF TRAFFIC AND THOUGHT I WAS GOING TO BE HIT BEFORE GETTING PULLED OVER. I THEN NOTICED THE ENGINE LIGHT WAS FLASHING. I HAVE HAD NO TROUBLE UNTIL YESTERDAY, NOV. 26, 2023. I HAD TAKEN MY CAR TO THE DEALERSHIP FOR RECALL #SC147. WHETHER IT HAD BEEN TAKEN CARE OF I WAS NOT TOLD. I ALSO WAS NOT TOLD THE ENGINE COULD BE REPLACED AT THEIR EXPENSE. THE REPAIR DATE WAS 11/22/2017.

A piece of carbon build up was caught on the exhaust valve not allowing it to close and causing no compression. The carbon build up is known in every kia engine as everyone knows they came out the factory with defects. With the exhaust valve burnt it scored the cylinder and none of it is covered under the extended warranty and I have seen many people with the same problem and all the dealership does is grind off the burnt oil on the exhaust valve and return it to the costumer while it is a ticking bomb. It is known to the dealership that this is a defect in the engine and which they told me on the phone while all calls are recorded. There was no sign that this was going to happened to the car. I was driving and the next second the car is shaking violently with the engine light on.

The contact owns a 2012 Kia Optima. The contact stated while driving 65 MPH, he noticed that there was smoke inside the cabin. The contact stated that while making a turn, a significant amount of smoke and heat was coming through the A/C vents, causing him to recline the seat. There was no warning light illuminated. Additionally, the brake pedal was depressed, but the vehicle failed to respond. The contact pulled to the side of the road and shifted from drive (D) to reverse (R) until the vehicle stopped. The contact then parked and turned off the vehicle, grabbed his belongings, and immediately exited the vehicle. The contact stated that the front end of the vehicle caught on fire, exploded, and collapsed as he was running away from the vehicle. The fire department extinguished the fire, and a fire department report was filed. There was no police report filed. There were no injuries sustained. The vehicle was towed to the dealer. The manufacturer was notified of the failure, and a case was opened. The manufacturer sent a field inspector, who inspected the vehicle and determined that the failure occurred due to a damaged serpentine belt. However, the contact stated that an independent mechanic had replaced the serpentine belt 11 days prior to the incident. The vehicle was towed to the contact's residence, where it remained. The independent mechanic inspected the vehicle and confirmed that the serpentine belt was not damaged. The contact later received notification of NHTSA Cam

I always smell like something burning and melting at the engine And the engine light sign appears and the maintenance light also

The contact owns a 2012 Kia Optima. The contact stated while driving at various speeds and driving over a bump in the roadway, there was an abnormal rattling sound coming from underneath the front end of the vehicle. Additionally, the front end of the vehicle and the steering column vibrated significantly, and the vehicle was pulling to the right. There was no warning light illuminated. The contact stated that she was able to steer the vehicle back into the lane. The contact stated that the failure had been recurring while driving. The vehicle was taken to an unknown dealer several times, and unknown repairs were completed; however, the failure persisted. Additionally, the vehicle was taken to several independent mechanics who informed the contact that the failure could be related to the tie rod and to unknown bushings. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 22V560000 (Structure) however, the part to do the recall repair was not yet available. The local dealer and a secondary dealer, Boomer Kia (339 W I-240 Service Road, Oklahoma City, OK 73139), and third dealer, Kalidy Kia (14205 Broadway Extension Hwy, Edmond, OK 73013) were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

THE CAR JUST SHUTS DOWN FOR NO APPARENT REASON AND WILL NOT RESTART. IT JUST DIES IN THE ROAD WITH NO WARNING. MECHANIC SAID THERE IS A WIRING ISSUE AND NOONE CAN SEEM TO FIND IT BECAUSE IT STARTS AND THEY CANT FIGURE OUT WHY AND MOST OF THE TIME IT WONT START

The white Pearl paint on my 2012 Kia optima ex is peeling all over the car. There are 4 spots that are peeling and getting worse. I’ve read numerous online forums about this issue and there is a latent defect with the paint

The contact owns a 2012 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and stalled. The contact stated that she was able to restart the vehicle and proceeded to her destination. The vehicle was taken to the dealer. The vehicle was diagnosed, and the contact was informed that there was contamination in the fuel system. The contact was informed that the fuel system needed to be replaced. The vehicle was not repaired. The contact stated that the fuel system had been replaced less than three years ago. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,000.

While driving down the highway the cars Hybrid warning system came on causing the car to lose all breaks and lose power. The component of the vehicle that failed is the HECU. Kia already did a recall for this but did not include the hybrids for the recall. This is very unsafe losing all breaking power, driving 65 mph down the highway with my children in the car! There was absolutely no warning, no check engine lights nothing. I had it towed to the dealership and upon them driving it, it also cut completely out and did it to the person at the dealership. This is going to cause someone to lose their life and when you call Kia, it’s the same run around that your year wasn’t included in the recall yet there was a whole lawsuit about this.

The steering wheel has a loud clicking sound when I drive on the highway as well as when I turn the wheel left or right. It is so loud that I have to turn my radio volume high to somewhat drown it out. The flex coupler is the issue. Apparently this was a recall in the past. Since mine just started acting up, I just found out there was even a recall on this part. Tried to get Kia to replace the part, but was denied. Currently escalating the issue as I do not agree with the decision, waiting on answer. I drive a total of 150 miles to and from work daily. When I hit normal bumps/dips in the road, the steering wheel shakes horribly. The sound is a major distraction to my abilities on the road. I don't think I should have to pay out of pocket for a part Kia knew was defective. It literally feels as though the steering column is going to fall off eventually.

The contact owns a 2012 Kia Optima. The contact stated that while his granddaughter was driving approximately 60 MPH, the vehicle stalled. The contact stated that his granddaughter was not aware of any warning lights being illuminated. The contact stated that he had the vehicle towed to his residence. The contact stated that the vehicle had not been diagnosed by a dealer or independent mechanic. The vehicle had not been repaired. The contact researched online and related the failure to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling). The manufacturer had not been informed of the failure. The failure mileage was approximately 90,000.

The contact owned a 2012 Kia Optima. The contact received notification of NHTSA Campaign Number: 22V560000 (Structure) and requested to be removed from the recall distribution list because the vehicle was totaled. The local dealer and manufacturer were not contacted.