2022 Kia EV6 complaints

Car stopped and will not start. 2nd occurrence. 09-25-23 and 10-17-23

The car will cannot be charge as per advertised. It's stop charging after 45 min. and keeps repeating. Took the vehicle to dealership and they cannot solve the problem. I also wrote a letter to Kia of America via certified mail but no respond.

There is a component, the ICCU, that is failing in a number of early cars. Who knows about the later ones? The 12v battery drains and the car won’t start. If the use is lucky, a jump start will get it to run enough to get to the dealer. Otherwise, a tow is in order. This can happen while the car is under way as well. Look at the Reddit ev6 forum and the Facebook EV6/EV9 forum. There are many stories about this problem.

I was driving home when I heard a loud pop in the back of the car then warning symbols pop saying the there is a issue with electrical system. Then it told me to pull of the road due to low power. I've been reading around heard about the iccu not charging the 12v battery while driving and lost all function when it dies.

The contact owns a 2022 Kia EV6. The contact stated that while driving approximately 30 MPH, the message "Speed Limit System Failure" was displayed, and the instrument cluster screen start to flash on and off before going blank. The vehicle started to lose motive power and then stalled. The vehicle was restarted but after driving approximately one mile the failure reoccurred and the vehicle stalled. The vehicle was towed to the local service center the vehicle was diagnosed and determined that the 12-Volt battery was faulty and needed to be replaced. The 12-Volt battery was replaced, and the vehicle was repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 72,000.

Sometimes vehicle is not charging at 6.6Kw charging. it says unable to connect/not charging. I tried multiple times and multiple locations. Also, I informed the dealer (Kia Fremont) and they are keeping my vehicle from last 2 weeks and there is no communication about the status. [XXX] vin no. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When car is on HDA mode. Drive assist. And speed under 20 miles on Highway. Car make sudden stops and it is also called ghost stop. Very dangerous and will likely to cause rear end collision.

Car 12v battery keep on dying after car is only one years old. Kia can not figure out why. I have to carry an emergency battery jumper with me at all times. This is an electric vehicle and when 12v battery dies. Vehicle loose all power.

I continually have issues with the car not charging. I have taken it to the dealership and they "update the software" but I continue to have issues where my car only charges 10-15% at a time and continues to give me an alert "charge interrupted" but it does not tell me WHY the charge has been interrupted. I will set it to charge overnight but then wake up ready to go to work and my car only has 20% charge and I can't make my commute. I've had the same problem at public chargers. However, my partner has an electric Ford Mustang and his car has had no problems charging at home. I would say for the first 9 months of ownership this was not a problem with my EV6 it only began in the last 3-4 months but it happens almost every time I plug in.

Just like the Hyundai Ionic 5 issue with power loss, my Kia EV6 which has the exact same underlying system (e-gmp); I heard a loud pop followed by my vehicle immediately informing me to stop driving and pull over. It has since been in hobble or "turtle" mode and will not let me drive it for more than 1 minute before insisting I pull over. It has since been towed to the local Kia dealership.

On SEPT.8, 2023 The car was charging and then it stopped charging. There was no warning or indications. All power failed and the EV is now inoperable.

2022 EV6 Wind. For the first 10 months i had absolutely no issues charging the car at home. The car went in to the dealer in mid august for a number of service bulletins. Since those changes, the car no longer accepts level 2 charging at the 48amp speed that it is advertised at and documented to provide. The dealership is not capable of replicating it, because they only have a 32 amp charger, which is significantly less powerful. It is my understanding that this is a heat issue which makes me nervous about a fire. I can turn the charger down very low, but that defeats the purpose of why I bought this car as faster speed charging was one of its selling points.

The vehicle was delivered to me with Ring type anchors for the carpets and all of the US specific floor mats that Kia sells for the EV6 require Hook typos anchors. This is an identical issue to the existing KIA TSB 310 (Rev 1, 11/18/2022)

An error message started flashing on the dashboard. The car came to a crawl was able to turn off to a side road where the car shut down. Had to call roadside assistant and have the car towed to the nearest Kia dealership Two days later was told the iccu had burned out and there was no ETA on a part to fix the problem.

To the questions listed: 1) For the last number of months the car will not fully charge when using a Level 2 charger (note: it will charge using a Level 3 charger). When charging I will get a message that "Charge Interrupted". When I go out to the car the charging has in fact stopped, and the charging cable connector is very hot to the touch. 2) In addition to the inconvenience, I worry the car is a fire hazard putting my family at risk. 3) The Kia dealers have not been able to replicate the problem and insist it is a problem with my charger at home. (Note: I have tested my charging unit on my son's Nissan Leaf and it works fine.) Note: they did apply the "Voluntary Service Campaign" however that did not fix the problem. 4) The car has not been inspected by anyone other then two Kia dealers. 5) After the last software upgrade, we had some random warning lights that would appear, and then disappear. This however, does not appear to be related to the charging issue as far as I can tell. Thank you.

Just got a safety notice from KIA for my EV6 saying the the car would stop with little warning, so with safety I can not drive a car the will stop on a freeway, so I would like a rebate or another car

Car has a unresolved ICCU failure, which means the battery cannot be charged. Car is stuck in dealer for 6 months with the same issue. Meanwhile, I pay car payments.

2022 EV6 First Edition. Vehicle no longer accepts level 2 charging at the 11kWh window stick advertised speed. Providing car with any more than 9kwh and the charging port gets very hot and car will stop charging. Dealer is aware of the issue but as of now is unable to diagnose as none of their dealerships have power supplies that exceed 7kwh.

12-volt battery is not being properly charged while driving. once resulting in loss of power while moving (thankfully still in our driveway) requiring a jump start, and twice when parked which forced us to have to break into (airbag the door) the vehicle to get the trunk open and jump start. It seems to lose 12-volt battery charge if not driving for a few days requiring us to leave it unlocked if we are not using it over the weekend for example. There have been no warning indicators or other warning prior to this occurring. I was in an accident in February and my vehicle was in the shop for a month. I lost contact via my app twice so I assumed the 12v battery died while they had my car, but they didn't mention the issue upon returning the car to me.

The contact owns a 2022 Kia EV6. The contact stated that the vehicle was purchased new; however, upon attempting to unlock the vehicle to drive a week later, the vehicle failed to unlock. The vehicle was towed to the dealer, where the battery was replaced; however, the failure recurred a year later. The contact stated while driving 40 MPH, a message advising to pull over and to immediately stop the vehicle was displayed. The contact veered to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that unknown parts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. Additionally, the contact sent requested documentation to the manufacturer through mail. The failure mileage was approximately 87.

Inlet charging port overheats causing charging to be interrupted when using 40A or higher EVSE. This is dangerous because the charging port or the wiring harness behind it is overheating because of high electrical power which can cause a fire. Kia has acknowledged this problem by issuing a TSB which reduces the charging rate when the overheating is detected but this does not solve the actual problem with the port or wiring harness.

My system keep failing to charge keeps saying charging failure. Temp is 65 out side no sun and it's night time. I'm using charge point because kia said that was the best for home charging. It has become more and more each time

The vehicle is repeatedly shutting down its charging cycle during charging sessions. I am always getting “charging session interrupted” notifications.

The 12V battery on my Kia EV6 has died 5 times (May 9, May 23, Jun 18, July 3, July 5 2023). I bought the car in March 2022 and there were no issues until May 2023. Twice the 12V died when parked at home with the Lithium battery at 80% charge, twice when my wife was out and parked and the last time at the 'Serramonte Kia' dealership in Daly City, CA. It required us to call Kia Roadside assistance to jump start the car. It was reported to Kia all 4 times that it happened to us. They recharged the car and when it finally died at the dealership, they replaced the 12V battery. I suspect that it's going to happen again because there's a fundamental problem with the ICCU which prevents the Lithium battery from charging the 12V. I have read that it's already been reported to NHTSA and that it's been investigate. Kia needs to recall and fix the underlying issue. I am worried that it puts my family at risk if we are stranded in the middle of nowhere.

While driving the vehicle with the main propulsion battery charged to 85%, a battery failure warning light lit at the time the vehicle lost power, slowed down to a stop and lost all lighting. The fault was a failure of the 12 VDC auxiliary power system which resulted in a loss of vehicle speed, dash board buttons to not function, and vehicle controls including lights to be lost. The vehicle was unable to be locked. The vehicle lost power and speed in a remote location causing me to pull off of the road. The vehicle lost all lighting preventing me from warning other drivers of the hazard situation. The car was towed to the nearest Kia Dealership who has confirmed that the 12 VDC power system was de-energized, caused by a dead 12 VDC battery and failed charging module (Kia Part Number 36400-1XFA0) and is currently awaiting replacement under warranted repair when the parts become available.

The issue is essentially EXACTLY like this article: https://www.caranddriver.com/news/a44272155/2022-hyundai-ioniq-5-nhtsa-investigation/ We heard a semi-loud pop that appeared to come from the rear of the vehicle. Approximately 5-15 seconds later, we got a notice that the electric system needed to be diagnosed. We were only a block from the house, traveling at low speeds, and did not experience a complete loss of power. However, the system started giving additional alerts (I do not remember the exact phrasing) related to stopping the vehicle immediately.

On 5 May 2023 our 2022 Kia EV6 WIND AWD Automatic vehicle (~11,200 miles on the odometer) was being driven under normal conditions at approximately 30 mph in city traffic when the car lost motive power and a dashboard alerts appeared stating "stop vehicle and check power supply" and "check electrical vehicle system." The driver complied but the shutdown occurred on a heavily trafficked road and put the driver and other travelers at risk and caused the driver considerable distress. The incident was reported to the dealer and manufacturer via the Kia Access app, and the car was towed to the nearest Kia dealer and service center on May 8. The dealer diagnosed the problem as caused by a defective ICCU (a part of the electrical powertrain control system) requiring replacement. As of 12 July 2023, Kia has not provided a replacement part and it remains on backorder with no ETA for arrival. We have not been contacted by Kia and to our knowledge no one has inspected the vehicle other than the dealer service technicians.

The contact owns a 2022 Kia EV6. The contact stated while driving 35 MPH, the vehicle shut off and lost motive power. The vehicle rebooted and the message "Critical Electrical Failure" and "Stop Vehicle” was displayed. The low voltage message was also displayed. The contact was unable to stop the vehicle or restart the vehicle. The vehicle came to a complete stop independently. The vehicle was towed to the dealer for a diagnostic test however, no failure was found. The contact was informed that the vehicle needed to be diagnosed by a technician. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was 11,000.

HAD JUST CHARGED THE VEHICLE AT A LEVEL 3 CHARGER, RECEIVED BATTERY FAILURE WARNINGS ON THE DASHBOARD, BY THE NEXT MORNING THE CAR HAD LOST MOTIVE POWER DOWN TO 12 MPH MAXIMUM. THIS OCCURRED JUNE 19, 2023. THE CAR HAS BEEN AT THE DEALER EVER SINCE, WHERE THEY ADVISE THAT THERE ARE NO ICCU REPLACEMENT MODULES IN THE USA AS THEY ARE BACK ORDERED. THE DEALER IS NORTHSTAR KIA IN QUEENS, NY.

During Level 2, 48 amp charging the car continually stops and starts charging roughly every five minutes. After contacting the charging maker, their diagnostic showed nothing wrong with the charger or incoming power, and that the car was stopping the charge. My Kia dealer states it is a problem with the onboard charger. However, Kia support doesn’t seem to acknowledge it. I have seen multiple reports of this is happening including a potential lawsuit, so I’m reporting this as an issue as well.

After five months of flawless at home charging, sessions failed and charging sessions were shut down by car. Took EV6 in to local Kia dealer service which couldn’t find any issues with car or charging systems. Dealer recommended electrician investigate our home set up which all checked out fine. To rule out all possibilities, we decided to replace our at home charger and purchased third party system from dealer. This worked for about a month and charging failed again during a session this morning. Called Kia who said no recalls or campaigns on car.

ICCU or 12v system has failed and car died mid drive on the road. Car is currently at the dealership for repairs. With complete electrical failure the vehicle reduced speed and stopped on it's own. This happened at night and I didn't have lights in or on the car to see. Additionally, I was unable to activate emergency lights and put on hazards. The dealership is struggling to diagnose the cause of the issue. The car dying was proceeded by a 12v battery light indicator and the turtle light saying it was reducing power. This was followed by a flashing "pull over vehicle and stop now" message.

Vehicle repeatedly interrupt its own charging, no error codes are surfaced. The charger(EVSE)is in proper working order, confirmed with other cars, the area around the plug gets very warm but not alarmingly so? The issue developed after many months of error free charging. The issue is non limited to a single EVSE, it seems to be avoidable by greatly reducing charging rate.

Collision a avoidance warning randomly goes off while stopped a good distance behind cars at traffic light.

EV charging on Level 2 was overheationg the charging port, terminating the charging session. KIA released TSB ELE 283 software update. The software update throttled the charging so it only charges at half speed and does not overheat the port. To me this is a bandaid for faulty charging ports and that there is no guarantee there will be a failure of the port causing electrical failure and possibly even a fire. This was evaluated at the dealer and confirmed the charging speed is throttled. They could not do further evaluation unless I committed to leave the car for days, possibly weeks to work with KIA Tech Line to further diagnose. This is a known issue and others have had their charging port replaced after a lengthy stay at the service department. It appears this may be a bad batch of charging ports causing this overheating and failure

On June 3, 2023 I found out that my EV6 was no longer charging, and that I could not open my doors or my trunk with my key fob. Nor could I start the engine. It turned out that my 12v battery was drained. As I never left my headlights or doors open overnight, I had no clue why the 12v battery was suddenly inoperable. I called AAA roadside assistance to have my 12v battery jumped. On June 4, 2023 my 12v battery had drained again, and I had to call AAA roadside assistance once more to have my 12v battery jumped. The earliest I could take my car in to the dealership for warranty-covered repairs was June 14. There, I was advised of the issues regarding the integrated charge control unit (ICCU). The dealership could not tell me when the part would arrive so they could replace it. I am currently using a rental car provided by the KIA dealership. Until the ICCU is replaced, I fear my EV6 could stop in traffic and leave me vulnerable to danger.

Heard a loud pop from rear passenger side of vehicle followed by dash warning lights to check charging system, then pull vehicle over immediately. All power to the vehicle was subsequently lost immobilizing the vehicle. Dealer service department said ICCU board needs to be replaced, but is on national backorder. Car has been immobilized since.

Issue has been diagnosed by Kia and our dealership as a failed Integrated Control Charging Unit (ICCU). Parts are backordered indefinitely (we were told there's 106 on order nationally). Same issue as the Hyundai Ioniq 5 (which is built on the same platform): https://news.yahoo.com/highway-safety-agency-reports-power-162735107.html Car dash showed a "Check electric vehicle system" alert, followed shortly after by "Stop vehicle and check power supply" on a short city drive home. Was close enough to make it home without the car turning off, where I confirmed the car could also no longer be charged at home using AC charging. The ICCU manages AC to DC power conversion for home charging and also keeps the 12-volt battery charged. Per Kia's recommendation, had the car towed to the nearest dealership. The worst part is just the wait time for backordered parts that Kia and Hyundai; dealership can't even give us an estimate of when to expect the parts. 107 does not seem like a difficult number of components to come up with on short notice for a carmaker that sells 2.3 million cars annually.

After driving my vehicle for a few minutes on my way to work my car lost speed rapidly, going from 40 mph to 25 then seconds later to 22 mph. I tried to accelerate; the car was unresponsive and would not accelerate over 22 mph. Dropping speed rapidly and suddenly during rush hour on a secondary road with a limited shoulder was unnerving as the slow response required waiting for a gap in traffic flow to safely turn around to head home. Upon returning home a message appeared on right side of dash board in an orange circle "check vehicle system" with a small upside down triangle with letters EV also inside this circle and a "small orange battery" picture showed on the left. I called Kia Roadside Assistance and reported the above and was advised it would take about 90 minutes for a tow to dealer as I was unwilling to drive it. Once the tow truck arrived I tried to drive EV6 out of my driveway onto flatbed and it died halfway. Driver had to jump 12 volt to get car to start and maintain power to get up flatbed. He advised 12 volt had to stay connected to ensure power to deliver to dealership. After weeks of calling / emailing dealer, opening a case with Kia America and sending several unanswered tweets the dealer advised on 06/02 that tech determined the ICCU assembly and a new high voltage fuse would be required. The service manager advised this would take 7-10 business days but on 06/15 advised the parts had still not arrived and in following up with Kia America there was no avai

There exists a serious manufacturing defect in that the brake lights do not turn on when the car is used in one-pedal drive mode and even a rapid deceleration occurs due to regenerative braking. This was documented by Consumer Reports and it presents a critical safety hazard. https://www.consumerreports.org/cars/car-safety/brake-lights-can-fail-to-provide-fair-warning-on-some-evs-a9533519285/?EXTKEY=YSOCIAL_FB&fbclid=IwAR3N_MQOI4ZGHfHSf18eAJSE7Cx02eftIx2k8F_oKaVo19_YJKgYEn7yeOE

Vehicle suddenly showed warning for electrical failure and could not longer be driven. Towed to dealership. Main fuse was blown. After waiting a couple of weeks for that part to arrive, it was replaced, only to find out that another component had failed; the ICCU. Kia stating there is NO ETA on when this part will be available. Car had been at dealership for almost 5 weeks with their admission that no estimate exists for when the car will be repaired due to the unknown time to wait for the part.

The contact owns a 2022 Kia EV6. The contact stated while driving 65 MPH, the vehicle shut off with the check battery warning message displayed on the instrument panel. The contact pulled the vehicle off to the side of the highway shoulder and had the vehicle towed to an independent mechanic. The mechanic performed a diagnostic test that showed that the integrated charging control unit (ICCU) had failed and needed to be replaced. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 8,000.

The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the brake light, even coming to a full stop and not activating the light, if the driver's foot is not completely off the pedal. I have been told by other drivers that my brake lights were out when I expected that they were working. Testing this with a odb2 device and another driver following behind me confirmed that the Kia EV6 does not activate brake lights when it should. Additionally, there is a video on youtube titled "Electric cars prove we need to rethink brake lights", demonstrating this on a similar vehicle, the Hyundai Ioniq 5. https://www.youtube.com/watch?v=U0YW7x9U5TQ There is no indication in the vehicle that the brake lights are not functioning as a driver would expect. The lights do work when using the brake pedal and are not normally "malfunctioning". The nearest dealer has confirmed that the driver needs to take their foot off of the accelerator to actuate the brake lights. In my opinion, the vehicle should be recalled to apply a fix that signals braking and intent to slow down that is consistent with the deceleration of the vehicle.

When heavy regenerative braking is used, the car decelerates very quickly. Despite this, the brake lights do not turn on. This is very dangerous as the regenerative braking can be used to completely stop the vehicle. People driving behind me need to be aware that I am coming to a stop and are not currently warned. Technology Connections just released a very detailed video on the Ioniq 5 which uses the same drivetrain as the EV6. https://www.youtube.com/watch?v=U0YW7x9U5TQ

Brake lights do not illuminate when using the Regenerative Braking System in the Kia EV6. The vehicle is fitted with a 'one-pedal-driving' system that allows the vehicle to slow down and stop without actuation of the brake pedal. When using this system, the vehicle can decelerate rapidly and to a complete stop, however the brake lights do not illuminate unless the drivers foot is completely removed from the accelerator pedal. Doing this causes rapid deceleration beyond what would be considered normal for a driver approaching a turn or any other scenario where a planned stop will occur. Because the vehicle does not illuminate the brake lights during normal deceleration when using the one-pedal-driving feature of the regenerative braking system this significantly increases the risk of a rear end collision. The vehicle has been found to be operating normally and matches the behavior of other EV6 models. Although I have not yet been involved in a collision, I have been advised by other drivers that my brake lights are not working, and have had multiple 'close-calls' where drivers behind me have been unable to correctly determine that my vehicle is decelerating and have subsequently caused them to brake erratically or harshly putting myself and others at risk.

The vehicle does not trigger brake lights when it is using Regen braking or the ipadel mode. This can cause a safety hazard for the person behind me to crash into me without the brake lights warnings

I was traveling on a neighborhood arterial road, when I heard a load thunk that seemed to come from beneath the rear seat. Moments later, I got a "Check electric vehicle system" warning, followed by "Stop vehicle and check power supply" in the dashboard. After another moment, the power was reduced to a maximum of 25 mph. I turned on the hazard lights because I was no longer able to match the flow of traffic (45 mph). No accident occurred. I was able to limp the car home on slower side streets. At home, I eventually got a "12v battery voltage low" message and the car was unable to move. I had to have the car towed to the dealership. The dealer service folks diagnosed the problem as a failed integrated charging control unit (ICCU). This same problem has been reported by others in the Kia EV forums. Kia Consumer Affairs says 87 of those parts are on backorder in the US with no ETA from Korea. Apparently, the part needs to be manufactured; they don't have them available in a warehouse.

I was driving my less than 1 year old, only 10,000 miles Kia EV6 First Edition when I got an error message to 'Check Vehicle Electric System'. After about another 2 miles I got a warning to "Stop Vehicle and Check Power Supply." As I attempted to find a safe place to stop, my vehicle started throttling my speed down to only 20mph (I was on a 55mph road). I was able to pull off and into a parking lot, but when I turned the vehicle off, it was completely dead and would not restart. Note, the battery was charged to 83% at the time of this incident. I had the vehicle towed the Kia Service Center at the dealership where I purchased the vehicle. After 5 days, they informed me that the ICCU had failed. Per their website, the Integrated Charging Control Unit, or ICCU, is a newly developed integrated charging system by Hyundai that charges both the high-voltage and spare batteries, essential to allowing for V2L (Vehicle to Load) feature. It has now been 20 days since the incident and Kia has no idea when a replacement part will be available.

On March 30, 2023 at 14k miles Integrated Charge Control unit failure of 2022 Kia EV6. Error message "Stop vehicle and check power supply." It was towed to the closest dealership. Kia customer care advised that the ICCU needed to be replaced, but the delivery date has yet to be confirmed.

On APRIL 23 2023. I GOT A CRITICAL WARNING MESSAGE ON MY CARS DASH PANAL. SAYING WARNING THERE IS A CRITICAL PROBLEM WITH YOUR CAR ELECTRICLA BATTERY. CALL ROADSIDE ASSISTANCE ASAP. ON APRIL 24 202E. I WAS ABLE TO GET MY KIA EV6 TO STOCKTON KIA FOR A DIAGNOSTIC TEST ON CARS ELECTRICAL BATTERY MALFUNCTION. THEY HAD MY CAR UNTIL 3:00 PM. THEY GAVE ME MY CAR BACK STATING THEY DONT KNOW WHATS WRONG WITH MY KIA EV6. THEY WOULD HAVE TO GENERATE A HIGHER LEVEL REPAIR REQUEST. BUT SINCE THERE COMPUTERS ARE DOWN THEY COULDNT REQUEST FOR REPAIR UNTIL SYSTEMS BACK UP AND WORKING. TODAY IS April 30 2023. Kia computer systems seem to still be down. I don't know if my car will explode, Burn, or just stop immediately in road Kia is not trying to fix my new kia problems. .