2005 Jeep Wrangler complaints

I RECENTLY PURCHASED A 2005 JEEP WRANGLER. EVERY TIME I FILL GAS, WHEN THE PUMP SHUTS OFF GASOLINE COMES SPRAYING OUT OF THE VEHICLE'S TANK AND ALL OVER THE GROUND. APPROXIMATELY A CUP OR MORE COMES OUT OF THE JEEP'S TANK. I THINK THIS IS A POTENTIAL FIRE HAZARD AND SHOULD BE ADDRESSED BY THE NHTSA AS SOON AS POSSIBLE BEFORE SOMEONE IS HURT BY THIS DEFECT. A RECALL FOR THE ITEM SHOULD BE MANDATED BY THE GOVERNMENT AND JEEP SHOULD BE FORCED TO FIX THIS PROBLEM. I HAVE RESEARCHED THIS PROBLEM ON THE INTERNET AND IT SEEMS PRETTY WIDESPREAD. *TR

GAS TANK SPITS BACK OUT GAS AS SOON AS THE FILLING STOPS. THERE IS ENOUGH GAS LOST TO SPILL DOWN THE SIDE OF THE JEEP AND ONTO THE GROUND. I HAVE USED DIFFERENT PUMPS AT THE SAME STATION AND FINALLY WENT TO OTHER STATIONS AND THE SAME HAS HAPPENED EACH TIME I GAS UP MY VEHICLE. I JUST RETURNED FROM THE JEEP DEALERSHIP AND THEY TOLD ME THE PROBLEM WAS IN THE CHECK VALVE AND I WOULD NEED A COSTLY REPLACEMENT OF THE WHOLE TANK. I SEE NOW THAT THIS IS A COMMON PROBLEM WITH THIS GAS TANK. LOSING EVEN A SMALL AMOUNT OF GAS IS COSTLY NOT TO MENTION THE POTENTIAL DANGER OF FREE GAS SPILLING OUT. A RECALL IS NEEDED WHICH IS NOT LIMITED TO ONLY CERTAIN YEARS. *KB

WHEN FILLING THE FUEL TANK, GASOLINE SHOOTS OUT THE FILLER NECK BEFORE THE PUMP SHUTS OFF. THIS HAPPENS CONSISTENTLY AND AT ALL GAS STATIONS TRIED. MY UNDERSTANDING IS THAT THIS IS NOT AN ISOLATED INCIDENT AND OCCURS ON MANY JEEP WRANGLER VEHICLES. *TT

FUEL GUSHES OUT OF TANK DURING EVERY FILL UP. MAYBE 3-9 FL. OUNCES POUR OUT, MAYBE MORE. THIS HAPPENS IF THE PUMP IS SET ON AUTO FILL, THE PUMP CLICKS OFF, BUT A SPLIT-SECOND LATER FUELS COMES OUT FOAMING. IF THE PUMP IS MANUALLY OPERATED AND THE LEVER IS EASED SO THAT IT PUMPS ABOUT HALF SPEED OR LESS, IT DOES NOT GUSH OUT. THIS HAS HAPPENED SINCE I BOUGH THE CAR NEW, I'M THE ORIGINAL OWNER. I HAS NEVER NOT DONE IT ON AUTO FILL AND IT TAKES SKILL TO AVOID IT. *TT

EVERY TIME I FILL UP MY GAS TANK, THE AUTO SHUT OFF DOESN'T HAPPEN UNTIL THE TANK OVERFLOWS, THIS HAS CAUSED GAS TO SPILL OUT SOMETIMES ONTO THE PERSON FILLING UP THE TANK. THIS HAPPENS EVERY TIME AT ANY STATION I USE. *TR

WHEN FILLING WITH FUEL, THIS JEEP SPITS FUEL BACK OUT THE FILLER ON YOU WHEN IT GETS FULL. HAPPENS LIKE 95% OF THE TIME NO MATTER HOW SLOW YOU FUEL IT. THIS WILL GET SOMEONE BURNED SOONER OR LATER. COMMON JEEP PROBLEM LISTED IN ONLINE FORUMS. *TR

FUEL FILL SPITS OUT FUEL EVERY TIME I FILL THE TANK. IT IS A DANGEROUS SITUATION DUE TO THE VOLATILITY OF GAS. *TR

GAS OVERFLOWS / SPEWS OUT WHEN FILLING UP DUE TO BAD DESIGN OF FUEL TANK VENT SYSTEM.

WHEN FILLING GAS TANK, GASOLINE SPEWS FROM THE FILLER NECK PRIOR TO THE AUTOMATIC SHUT-OFF ON THE PUMP ENGAGING. THIS HAS BEEN AN ISSUE WITH THIS PARTICULAR VEHICLE SINCE 2008.

FUEL TANK OVERFLOWS EACH AND EVERY TIME THE VEHICLE IS FILLED WITH FUEL. I HAD A 2004 JEEP WRANGLER AND NEVER HAD THIS PROBLEM.

A LARGE AMOUNT OF FUEL VIOLENTLY ERUPTS FROM TANK MOUTH WHEN FILLING AND OVERFLOWS ONTO THE VEHICLE, GROUND & MYSELF. THIS OCCURS AT EACH COMPLETE FILL-UP. THIS 2005 JEEP WRANGLER SPORADICALLY TRIPS OBD-2 CHECK ENGINE CODES FOR EMISSION EVAPORATIVE COMPONENTS, IN THE P0440-P0456 RANGE. *TR

WHEN FILLING THE GAS TANK THE PUMP WILL NOT AUTOMATICALLY SHUT OFF AND THERE IS A HUGE SPRAY OF GASOLINE OUT OF THE TANK. THIS HAPPENS ALMOST EVERY TIME, YOU ARE FORCED TO LISTEN TO THE SOUND OF THE GAS AND JUDGE WHEN IT IS ABOUT TO SPILL OUT IN ORDER TO PREVENT IT. (NOTE: I NO LONGER OWN THIS VEHICLE, BUT I AM DOCUMENTING IT HERE SINCE I HAVE HEARD THAT IT IS A COMMON PROBLEM.) *TR

GAS IS OVERFLOWING WHEN I FUEL UP. THIS HAS HAPPENED 5 TIMES ALREADY. *TR

FRONT END SHAKES VIOLENTLY AFTER HITTING A BUMP AND WILL NOT STOP SHAKING UNTIL VEHICLE IS BROUGHT TO A STOP. DEALER HAS ATTEMPTED TO FIX IT 5 TIMES BETWEEN AUGUST 06 AND JANUARY 07. DEALER REPLACED STEERING DAMPNER IN AUGUST, 2006. REPLACED TRAC BAR IN DECEMBER, 2006. I HAD INDEPENDENT SHOP CHECK FRONT END. FOUND NOTHING OUT OF SPEC. AT ONE POINT DEALER CLAIMED THAT IT WAS CAUSED BY TIRES. NEW TIRES FIXED PROBLEM FOR A SHORT TIME. HAD TIRES BALANCED 4 TIMES IN 2009. REPLACED STABILIZER SHOCK AGAIN IN AUGUST, 2009 AND AGAIN IN DECEMBER OF 2011 WITH HEAVY DUTY ONE. PROBLEM PERSISTS TODAY IN JANUARY OF 2012. *TR

THE FUEL ALWAYS SPEWS OUT OF THE TANK WHEN ALLOWING THE AUTOMATIC SHUTOFF OF THE GAS PUMP. IT HAPPENS WITH EVERY GAS STATION I USE. I WOULD ESTIMATE ABOUT 1 TO 2 CUPS OF FUEL SPILL OUT AND ONTO THE GROUND EACH TIME I FILL UP. I HAVE BEEN INFORMED THIS IS AN ISSUE THAT INVOLVES A FAULTY VALVE IN THE WRANGLER GAS TANK. JEEP NEEDS TO TAKE OWNERSHIP OF THIS ISSUE. *TR

AFTER FILLING THE FUEL TANK, THE GAS PUMP STOPS BUT THE GAS COMES GUSHING OUT OF THE FILLER TUBE. THIS HAS NOW HAPPENED EVERY TIME I HAVE FILLED UP MY JEEP SINCE THE FIRST TIME IT HAPPENED IN JAN 2011. *TR

MY 2005 JEEP WRANGLER TJ WILL SPIT FUEL EACH TIME I FILL THE VEHICLE (OVERFLOW) AND IT WILL SPILL GASOLINE ALL OVER THE SIDE OF THE VEHICLE AND ON THE GROUND. *TR

WHEN FUELING THE VEHICLE, GASOLINE OVERFLOWS AND SPEWS OUT OF THE GAS TANK OPENING. THIS HAPPENS EACH TIME THE VEHICLE IS FUELED AND OCCURS AS THE TANK REACHES FULL. THIS IS AN EXTREMELY DANGEROUS AND UNHEALTHY SITUATION WHICH NEEDS TO BE ADDRESSED BY THE VEHICLE MANUFACTURER. I WAS SHOCKED TO FIND THIS IS A KNOWN AND WIDELY REPORTED ISSUE, BUT NOT YET RESOLVED BY CHRYSLER. *TR

WHEN REFUELING A SIGNIFICANT QUANTITY (ESTIMATED AT 8 OUNCES OR MORE) OF GASOLINE IS "SPIT BACK" OR DISCHARGED FROM THE FUEL FILLER OPENING AS THE TANK REACHES FULL. THIS DISCHARGE PRODUCES A PUDDLE OF GASOLINE AT LEAST 24" IN DIAMETER AND LEAVES THE EXTERIOR AND UNDERSIDE OF THE FENDER DRIPPING WITH GASOLINE AND DEPENDING ON THE FILLER HOSE CONFIGURATION MAY SOAK THE CLOTHING OF THE PERSON OPERATING THE PUMP. THIS EVENT OCCURS EVERY TIME THE VEHICLE IS REFUELED UNLESS CARE IS TAKEN TO STOP ADDING FUEL BEFORE THE TANK REACHES FULL CAPACITY. CLEARLY THIS CREATES A VERY DANGEROUS, ENVIRONMENTALLY HAZARDOUS AND POTENTIALLY LIFE THREATENING SITUATION!! *TR

WHEN I TRY TO FILL MY TANK USING THE AUTOFILL OPTION ON THE FUEL PUMP HANDLE, THE FUEL DOESN'T SHUT OFF WHEN THE TANK IS FULL AND WILL COME SPLASHING OUT IN FORCE. MY SOLUTION THUS FAR IS TO BE AWARE OF THE GALLON AMOUNT AS I FUEL THE VEHICLE, THEN WHEN IT GETS FAIRLY CLOSE, I TRY TO TRICKLE THE FUEL IN SO AS NOT TO SPLASH TOO MUCH FUEL OUT ON TO THE GROUND OR MY PANTS AND SHOES. *KB

WHEN FILLING THE FUEL TANK WITH GAS, THE GAS PUMP DOES NOT SHUT OFF WHEN THE TANK IS FULL. THIS CAUSES OVERFLOW OF GAS FROM THE TANK. AN INTERNET SEARCH INDICATES THAT THIS IS A COMMON ISSUE WITH JEEP WRANGLERS. *TR

FUEL SPILLS WHEN GAS TANK IS FULL EVERY TIME I FILL UP THE JEEP. MY FATHER HAS THIS SAME PROBLEM ALSO. *TR

WHEN FILING GAS TANK, GAS DOES NOT SHUT OFF BEFORE OVERFILLING AND CAUSING A SPILLAGE ON GROUND AT GAS PUMPS. ALWAYS RUNS OUT AND IS DAMAGING PAINT AROUND FILLER HOLE. *TR

WHEN FILLING THE GAS TANK THE PUMP WILL STOP PUMPING GAS BUT THE FUEL WILL SPLASH OUT OF THE FILL PORT ON MY JEEP. THERE ARE MANY YOUTUBE VIDS SHOWING THIS PROBLEM. GAS IS EXPENSIVE SO I WOULD LIKE TO KNOW WHY THIS IS HAPPENING. *TR

WHEN FILLING THE GAS TANK, THE SHUTOFF VALVE TO PREVENT FUEL OVERFLOW DOES NOT APPEAR TO WORK PROPERLY AND THE RESULT IS THAT FUEL OVERFLOWS FROM THE FILLER NECK AND RUNS ALL OVER THE VEHICLE AND GROUND. THIS HAPPENS EVERY TIME IT'S FILLED UP REGARDLESS OF HOW QUICKLY OR SLOWLY I REGULATE THE FLOW OF FUEL INTO THE TANK. *TR

WHENEVER THE VEHICLE IS FILLED COMPLETELY WITH GAS THE GAS PUMP WILL QUIT PUMPING FUEL BUT 1/2 - 1 CUP OF FUEL SPILLS OUT EVERY TIME AFTER THE FUEL PUMP SHUTS OFF. *TR

EVERY TIME I FILL MY 2005 JEEP WRANGLER, THE FULL HOSE WILL NOT SHUT OFF AND GAS SHOOTS OUT ALL OVER THE FENDER AND THE GROUND. THIS HAPPENS AT ALL GAS STATIONS AND IT DOESN'T MATTER WHETHER I USE THE AUTO SHUT OFF OR HOLD THE NOZZLE, THE GAS STILL SHOOTS OUT CREATING A SAFETY AND ENVIRONMENTAL HAZARD. *TR

WHEN I WAS AT A GAS STATION THAT DIDN'T HAVE A FUEL VAPOR RECOVERY SYSTEM ON THE FUEL PUMP HANDLE, FUEL WOULD SPIT BACK OUT WHEN THE FUEL TANK GOT FULL, GETTING FUEL ON THE PUMP HANDLE AND DOWN THE SIDE OF THE JEEP. *TR

WHEN FILLING THE VEHICLE WITH GASOLINE IT WILL NOT STOP THE PUMP AND BEGIN TO OVERFLOW. *TR

FUELING STOPPER ASSEMBLY DOES NOT TRIGGER GAS STATION PUMP NOZZLE TO STOP DISPENSING FUEL ON TIME. THE RESULT IS SPILLED FUEL EVERY TIME DUE TO FUEL OVER FLOW FROM FUEL TANK WHEN EVER A FUEL FILL UP IS ATTEMPTED. THIS HAPPENS 100% OF THE TIME. *TR

INCIDENT MILEAGE ON MY REPORT IS DUE TO BUYING THE VEHICLE USED, BUT HAS MOST LIKELY OCCURRED SINCE DATE OF ORIGINAL PURCHASE. DUE TO AN BAD CHECK VALVE IN THE FUEL TANK, OVERFILLING OCCURS AT ALMOST EVERY FILL-UP, CREATING BOTH ENVIRONMENTAL CONCERNS AND POTENTIAL HAZARDOUS CONDITIONS. *TR

WHEN TRYING TO PUT GAS INTO TANK THE GAS OVERFLOWS OUT THE FILL TUBE. *TR

EVERY TIME YOU FILL THE FUEL TANK, FUEL SPILL'S OUT ON THE SIDE OF THE VEHICLE AND ON THE GROUND CAUSING A VERY DANGEROUS FIRE PROBABILITY. *TR

2005 JEEP WRANGLER. WELL MAINTAINED. HIGHEST QUALITY OIL, SPARK PLUGS, AIR FILTERS, COOLING SYSTEM. CAMSHAFT FAILURE AT ROUGHLY 50,000 MILES. EXCESSIVE WEAR CAUSING KNOCKING. DIAGNOSIS FROM CHRYSLER: NEW ENGINE REQUIRED. NO OVERHEATING, NO ABUSE. THE OIL PUMP DRIVE ASSEMBLY GEARS ARE WORN DOWN SO OIL IS NOT FLOWING PROPERLY. THIS IS A POSSIBLE CAUSE FOR THE CAMSHAFT FAILURE. THE OTHER POSSIBLE CAUSE FOR THE CAMSHAFT FAILURE IS THAT IT IS A FLAT TAPPET CAMSHAFT FROM THE FACTORY. THIS SPECIFIC TYPE OF CAMSHAFT NEEDS THE ZDDP OIL ADDITIVE. MODERN OIL DOES NOT CONTAIN ZDDP BECAUSE IT CAUSES CATALYTIC CONVERTER FAILURE. WITHOUT ZDDP EXCESSIVE WEAR OCCURS. THIS IS COVERED IN SAE BULLETIN # 770087. SAE IS THE SOCIETY OF AUTOMOTIVE ENGINEERS. ONCE WEAR REACHES A CERTAIN LEVEL FURTHER WEAR IS RAPID AND CAUSES CATASTROPHIC ENGINE FAILURE.FURTHERMORE, MY JEEP IS STILL UNDER POWERTRAIN WARRANTY. HOWEVER, MY WARRANTY HAS BEEN UNLAWFULLY DENIED BECAUSE I HAVE SOME UNRELATED AFTERMARKET PARTS ON MY JEEP. LITIGATION IS PENDING ON THIS ISSUE. CHRYSLER HAS GONE AGAINST THEIR OWN WRITTEN WARRANTY, AND WELL AS FEDERAL LAW (MAGNUSON-MOSS WARRANTY ACT). *TR

GAS SPILLS OUT WHENEVER I FUEL-UP. *TR

WHEN FILLING UP GAS TANK, GAS WILL SPILL OUT FOR FILL SPOUT BEFORE THE GAS NOSSEL SHUTS OFF. *TR

FUEL OVERFLOWS AND SPILLS ALL OVER THE EXTERIOR, GROUND AND SOMETIMES MY SHOES EVERY TIME I FILL MY GAS TANK. I KNOW THIS IS AN EXTREMELY COMMON ISSUE, AND AM HOPING FOR A RECALL. THANKS!!! *TR

GAS TANK SPILLS EVERY TIME I FILL IT UP. SQUIRTS OUT AND ONTO MY CLOTHES, GROUND, PAINT JOB AND FENDER. ME AND MANY OTHERS ARE HAVING THIS PROBLEM. RECALL!!!! *TR

WHEN I FILL MY 05 WRANGLER IT OVERFLOWS BEFORE PUMP SHUTS OFF,THIS HAPPENS EVERYTIME I FILL UP. *TR

GAS OVER FLOWS AND SOAKED MY PANTS. *KB

WAS DRIVING OVER 50 MILES PER HOUR WHEN I HIT A LITTLE BUMP AND MY WHOLE FRONT END OF MY JEEP STARTED TO SHAKE VIOLENTLY, I THOUGHT THE WHEELS WERE GOING TO COME OFF, I COULD BEARLY CONTROL THE STEERING WHEEL TO MAKE IT TO THE SIDE OF ROAD, I HAVE HAD LESS VIOLENT ONES BUT THEY ARE BECOMING MORE FREQUENT NOW, I JUST WENT TO DEALER AND THEY SAID MY STEERING DAMPER WILL HAVE TO BE REPLACED FOR 255.00 , I HAVE BEEN READING ALL THE COMPLAINTS ABOUT THIS " DEATH WOBBLE" AND ALL THE WORK THAT PEOPLE ARE HAVING DONE ONLY TO HAVE THE ISSUE COME BACK, I DO NOT WANT TO WASTE MONEY ON ALL THE THINGS THAT THEY WILL TRY AND REPLACE ONLY TO FIND ITS NOT THE REAL ISSUE. PLEASE HELP! *TR

I BOUGHT MY 05 JEEP LJ WRANGLER UNLIMITED WITH 20,600 MILES AND THE 1ST TIME I FILLED IT AT 20,800 AND EVERY SINGLE TIME IT WHETHER I HAVE THE HANDLE SET TO AUTOMATIC SHUTOFF OR HAND PUMP IT SLOW OR FAST DOESN'T MATTER WHAT GAS STATION IT SPEWS GAS ALL OVER BEFORE STOPPING TODAY AT 31K MILES I'VE HAD IT SLEW SO BAD I GOT SOAKED FROM THE WAIST DOWN HAVING MY LEGS FEEL A BURNING SENSATION ALONG WITH MY FEET DUE TO BEING SOAKED IN GAS!!!!!!!!!! I WANT A RECALL I LOOKED ONLINE MOST WRANGLER OWNERS COMPLAIN OF THIS ISSUE THIS ISN'T A SOLE COMPLAINT AS FAR AS IM AWARE WHY HASN'T IT BEEN RECALLED?? *TR

EVERYTIME I FILL UP MY VEHICLE THE NOZZLE DOESN'T KICK OFF, GAS POURS OUT THE FILLER NECK, GAS IS EXPENSIVE THESE DAYS TO JUST POUR IT ON THE GROUND AND BAD FOR THE ENVIRONMENT, I TRY TO NOT LET IT HAPPEN BUT STILL IT DOES, I FEEL THAT JEEP SHOULD BRING OUT A RECALL ON THIS. I CANT FILL MY VEHICLE UP ALL THE WAY AS I LIKE TO BE ABLE TO. THE FENDER FLARE IS DISCOLORED BECAUSE OF THE GAS SPILLING OUT ON TO IT AND THEN I HAVE TO GO AND GET THE GAS OFF MY HANDS AND SHOES WHEN I SHOULDN'T HAVE TO. I KNOW THERE ARE MORE PROBLEMS OTHER THAN MINE AS YOU CAN GO TO HTTP://WWW.JEEPFORUM.COM/FORUM/F176/HAVE-FUEL-SPILL-PROBLEMS-LIKE-MANY-US-SUBMIT-COMPLAINT-FORCE-RECALL-974337/ AND SEE MANY ON THERE HAS HAD THIS PROBLEM ASWELL AND HAVE VIDEOS OF THIS HAPPENING. IM JUST AFRAID THAT STATIC ELECTRICITY MY SPARK ON IT AT THE TIME THIS HAPPENS AND CAUSES A BIG MESS. PLEASE HELP ME AND OTHERS MAKE JEEP SEND OUT A RECALL ON THIS. MY VEHICLE IS COMPLETELY STOCK NO MODIFICATIONS HAS BEEN DONE TO IT TO ALTER THE WAY GAS GOES INTO THE TANK. THANK YOU FOR YOUR TIME. *TR

FUELS SPRAYS OUT OF THE FILL POINT WHEN FILLING AT A GAS STATION. I HAVE HAD IT SPRAY INTO THE AIR AND INTO MY MOUTH AND CLOSE TO MY EYES. I HAVE THE NOZZLE IN THE HOLE AND ON AUTO STOP AND WHEN IT IS FULL, THE PUMP STOPS THE FUELING AFTER THE FUEL COME SQUIRTING OUT. THIS IS A KNOWN PROBLEM AND I AM SICK AND DANG TIRED OF GETTING FUEL ALL OVER MY HANDS, FACE AND CLOTHING! *TR

THE ACCELERATOR (GAS PEDAL) INITIALLY FELT AS THOUGH IT WERE STUCK, AS IF THERE WAS A BLOCK UNDER IT, WHEN DRIVING AT APPROXIMATELY 20 MPH. THEN SUDDENLY THERE WAS UNINTENDED ACCELERATION WITH THE ACCELERATOR STUCK AT FULL THROTTLE. ONLY AFTER THE VEHICLE HIT 2 PARKED CARS DID THE VEHICLE COME TO A STOP.

WHEN FUELING VEHICLE GAS SPLASHES OUT OF FUEL FILLER INTAKE. THIS HAPPENS ON JUST ABOUT EVERY FILL UP. IT DOESN'T APPEAR TO MAKE ANY DIFFERENCE IF YOU FILL UP SLOWLY OR AT NORMAL FILL SPEED. GASOLINE SPILLING ON THE SIDE OF THE VEHICLE AND SPILLING ONTO THE GROUND CAN'T BE A SAFE THING.

FUEL TANK OVERFLOWS AT EVERY FILL UP REGARDLESS OF THE GAS STATION. *TR

EVERY TIME I FILL UP MY 2005 JEEP WRANGLER UNLIMITED THE TANK WILL OVERFLOW. IT DOESN'T MATTER IF I LET THE AUTO STOP CLICK TO STOP THE GAS OR IF I SLOW DOWN WHEN I KNOW IT IS GETTING FULL, THE GAS WILL OVERFLOW AND LEAK EVERYWHERE. IT'S A DECENT SIZE PUDDLE TOO, NOT JUST A COUPLE DRIPS. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT WAS DRIVING 50 MPH WHEN THE FRONT OF THE VEHICLE BEGAN SHAKING EXTREMELY VIOLENTLY. THE CONTACT STATED THAT THE FAILURE WAS SO EXTREME THAT THE VEHICLE WOULD VENTURE OFF THE ROADWAY WHEN THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE AND WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 39,000.

WHEN FILLING THE GAS TANK ON MY 2005 JEEP WRANGLER, I GET A BACK SPLASH OF GAS MORE OFTEN THAN NOT. I'VE TAKEN THE PRECAUTION OF SLOWING THE PUMP DOWN WHEN CLOSE TO FULL, BUT STILL SPILL GAS. WHEN I SPOKE TO CHRYSLER ABOUT ANOTHER ISSUE, I MENTIONED THE OVERFLOW ISSUE. I WAS TOLD TO HAVE THE "FUEL TANK INLET CHECK VALVE" LOOKED AT THE NEXT TIME I WAS AT THE DEALERSHIP. *TR