2005 Jeep Wrangler complaints

WHEN I HIT SPEEDS OF 50MPH, MY JEEP WOBBLES TERRIBLY. I HAVE READ NUMEROUS REVIEWS AND COMPLAINTS THAT THIS IS NOT UNCOMMON AND IT EVEN HAS A NAME, THE "DEATH WOBBLE". WE ARE GOING TO PASS THE JEEP ONTO OUR 16 YR OLD DAUGHTER, BUT WOULD LIKE TO KNOW IF IT IS GOING TO BE RECALLED OR IF IT IS FIXABLE. I WOULD HATE ANYTHING TO HAPPEN TO OUR DAUGHTER, ESPECIALLY IF JEEP IS AWARE OF THIS PROBLEM,

WE PURCHASED THE VEHICLE USED WITH AROUND 12,000 MILES LAST YEAR. EVER SINCE WE BOUGHT IT, IT WILL RUN OVER WHEN PUMPING GAS. IT DOES NOT CUT OFF SO YOU JUST HAVE TO LISTEN TO STOP IT. I GOOGLED AND SAW THERE HAVE BEEN ISSUES WITH OTHER YEARS. IT WOULD BE GREAT IF THE PROBLEM COULD BE FIXED. *TR

I AM EXPERIENCING FUEL SPIT-BACK DURING EVERY REFUELING OF MY VEHICLE. I PURCHASED A REPLACEMENT TANK AND THE PROBLEM HAS AGAIN OCCURRED ON THE REPLACEMENT FUEL TANK. I AM CONSIDERING A CLASS ACTION LAWSUIT AGAINST CHRYSLER TO FIX THIS PROBLEM WITH 2005-2006 JEEP WRANGLERS AS WELL AS THE 2007-2008 JEEP WRANGLERS. I KNOW A RECALL FOR THIS SAME ISSUE IS IN EFFECT FOR THE 2007-2008 JEEP WRANGLERS. HERE IS A LINK TO AN EDMONDS ARTICLE: HTTP://WWW.AUTOOBSERVER.COM/2011/02/CHRYSLER-REPLACES-SOME-FUEL-TANKS-FOR-GAS-SPIT-BACK.HTML HERE IS A LINK TO A JEEP FORUM WITH NUMEROUS COMPLAINTS FOR THE SAME ISSUE AND IT IS NOT ISOLATED TO THE 2007-2008 JEEP WRANGLERS: HTTP://WWW.WRANGLERFORUM.COM/F19/OVERFLOW-AT-THE-GAS-PUMP-46693-2.HTML. *TR

WHEN FUELING THE JEEP THE GAS OVERFLOWS. EVEN THOUGH WE ARE VERY CAREFUL IT IS IMPOSSIBLE TO GAS UP THE CAR AND NOT HAVE GAS ALL OVER YOUR HANDS AND THE GROUND. THE GAS DRIPS DOWN THE SIDE OF THE CAR AND IS A SERIOUS SAFETY CONCERN. WE HAVE TRIED DIFFERENT PUMPS AND DIFFERENT ANGLES TO NO AVAIL. IT IS NOT HUMAN ERROR AS WE HAVE OTHER VEHICLES THAT WE NEVER HAVE A PROBLEM AT THE SAME PUMPS WITH ANY OTHER CAR. *TR

WHEN REFUELING AND FILLING UP GAS TANK, THE AUTOMATIC GAS PUMP NOZZLE DOES NOT SHUT-OFF IN TIME RESULTING IN GAS OVERFLOW/SPILLING. TYPICALLY A FEW CUPS OF GAS WILL SPILL OUT BEFORE NOZZLE SHUTS OFF THE GAS FLOW. HAVE TRIED FILLING AT DIFFERENT GAS STATIONS, WITH DIFFERENT PUMPS, AND POSITIONING NOZZLE IN DIFFERENT POSITIONS BUT RESULT IS THE SAME AND GAS OVERFLOWS. ONLY WAY TO PREVENT IS TO GUESS HOW MUCH GAS IS NEEDED -- THEN STOP PUMP BEFORE TANK IS FULL -- THEN FILL REMAINDER OF TANK WITH PUMP ON SLOWEST SETTING. *TR

GAS TANK OVERFLOWS EVERYTIME I FILL UP. DOESN'T MATTER WHAT GAS STATION I GO TO, THE GAS ALWAYS SPITS OUT OF THE TANK AND ALL OVER THE SIDE OF THE CAR BEFORE THE PUMP STOPS. SOMETHING IS WRONG WITH THE TANK OR AN INTERNAL CHECK VALVE WHICH SHOULD PREVENT THIS. I CAN NEVER FILL THE GAS TANK UP FULL BECAUSE OF THIS ISSUE. THE ONLY FIX I HAVE FOUND THROUGH RESEARCH IS A BRAND NEW GAS TANK, WHICH IS RIDICULOUS. *TR

EVERYTIME I FILL THE GAS TANK THE GAS OVERFLOW ON TO THE GROUND AFTER THE GAS HOSE SHUTS OFF. *JS

AFTER I HAD MY TIRES ROTATED AND WAS TRAVELING ABOUT 45 MPH THE FRONT END BEGAN TO SEVERELY SHIMMY. IT OCCURRED SEVERAL TIMES. THE ONLY WAY TO GET IT TO STOP WAS TO DECELERATE. I HAD THE DAMPENER AND TIRES REPLACED (THEY WERE WORN UNEVENLY) TODAY. I HAVE MAJOR CONCERNS ABOUT THE SAFETY OF THE VEHICLE LONG TERM. THERE ARE MANY ANECDOTAL REFERENCES ON GOOGLE CONCERNING THIS BEING A MAJOR PROBLEM (GOOGLE SEARCH WRANGLER "DEATH WOBBLE." ) ONE STORY INDICATED THAT THERE WERE A LIMITED NUMBER OF FORMAL COMPLAINTS TO YOUR ORGANIZATION SO I WANTED TO MAKE SURE I ADDED A COMPLAINT AS THIS CONDITION COULD CAUSE AN ACCIDENT FOR AN UNSUSPECTING DRIVER. I WILL UPDATE THE RESULT OF THE REPAIR IN TERMS OF WHETHER IT RESOLVES THE INCIDENT OR NOT. *JS

THE VEHICLE GAS FILLER TUBE OVER FLOWS NEARLY EVERY FILL UP. GAS SPILLS OUT ONTO THE JEEP AND ONTO THE GROUND. *JS

APPROXIMATELY 1 YEAR AFTER PURCHASING MY USED 2005 WRANGLER, GAS STARTED TO OVERFLOW FROM THE FILLER TUBE UPON FUELING. THE FIRST TIME THIS OCCURRED, I THOUGHT IT WAS A DEFECTIVE PUMP SHUT-OFF AT THE STATION UNTIL IT HAPPENED THE NEXT TIME AND THE NEXT AND SO ON. I HAVE BEEN DEALING WITH THIS FOR AT LEAST 2 YEARS WITH NO RESOLVE. A GOOD AMOUNT OF GAS WILL SPILL OUT OF THE TANK ONCE THE TANK HAS REACHED CAPACITY, SPRAYING GAS ALL OVER THE VEHICLE AND THE GROUND. THIS CAN BE MINIMIZED BY SLOWING THE FLOW FROM THE NOZZLE, BUT THERE IS NO WAY TO TELL WHEN THE TANK IS GOING TO BE FULL OR NOT. THIS IS NOT ONLY A SAFETY ISSUE AS THERE IS NOW A VOLATILE SUBSTANCE ON THE GROUND, BUT AN ENVIRONMENTAL ISSUE AS THERE IS NOW GASOLINE THAT COULD EASILY ENTER THE GROUND WATER. IT IS UNACCEPTABLE THAT CHRYSLER IS AWARE OF THIS PROBLEM, HAS ADMITTED THAT IT AFFECTS OTHER MODEL YEARS YET REFUSES TO ACCEPT FURTHER RESPONSIBILITY. *TR

AROUND JUNE 2010, I PARKED THE VEHICLE IN A HOSPITAL PARKING LOT. UPON RETURNING TO VEHICLE, SHIFT LEVER JUST FLOPPED BACK AND FORTH. COULD NOT SHIFT OUT OF PARK. HAD JEEP TOWED TO JEEP DEALERSHIP. THEY REPLACED THE SHIFTER CABLE AT A COST OF OVER $300.00. TWO WEEKS AGO, JUNE 2012, WHILE DRIVING, JEEP SHIFTER BROKE AGAIN WHILE LOCKED IN DRIVE. SAME DEALERSHIP REPLACED THE SHIFT CABLE BUSHING. ANOTHER $100. I CALLED JEEP/CHRYSLER AND THEIR REPRESENTATIVE INFORMED ME THAT THEY HAD NO OTHER COMPLAINTS ABOUT THIS PROBLEM. FUNNY, SINCE THERE ARE MANY WEBSITES ABOUT THIS VERY, ONGOING, PROBLEM WITH JEEP SHIFTER CABLES. IN MY OPINION, THIS COULD BE A VERY DANGEROUS PROBLEM. THERE IS NO WARNING OF FAILURE. IF IT HAD OCCURRED A DAY PRIOR, I COULD HAVE BEEN BACKING DOWN THE BOAT RAMP! I FEEL A RECALL, OR AT LEAST, A NOTIFICATION TO JEEP OWNERS, SHOULD BE INITIATED BY JEEP/CHRYSLER. THANK YOU FOR YOUR TIME. *TR

WHEN FILLING UP THE JEEP WITH GASOLINE, GAS PUMPS WILL NOT CLICK OFF, AND THE FUEL TANK OVERFILLS, BUT SPRAYS OUT WITH GREAT FORCE SOAKING THE INDIVIDUAL PUMPING GASOLINE. *TR

WHEN REFUELING THE VEHICLE, THE AUTOMATIC SHUTOFF DOES NOT ENGAGE FROM THE VEHICLE ITSELF PROPERLY, CAUSING FUEL TO CONTINUE TO FLOW AND OUT AND ALL OVER THE SIDE OF THE VEHICLE. IT ALSO SPRAYS OUT AND ON THE OPERATOR FUELING THE VEHICLE. THERE IS A TECHNICAL SERVICE BULLETIN FROM JEEP ABOUT THE ISSUE, BUT ACTION HAS NOT BEEN TAKEN BY THE MANUFACTURER. I REQUEST THIS BE REPAIRED UNDER WARRANTY. MATERIAL SAFETY DATA SHEETS CLASSIFY GASOLINE AS A HAZARDOUS MATERIAL, KNOWN TO CAUSE HEALTH DEFECTS WHEN IN CONTACT WITH SKIN, AND ENVIRONMENTAL IMPACTS WHEN IMPROPERLY CONTAINED. *TR

FILLED UP FUEL TANK, WHEN IT GOT TO THE TOP IT DIDN'T SHUT OFF WITHOUT SPILLING OUT. NOW IT DOES IT ALL THE TIME. *TR

OUR 2005 JEEP WRANGLER HAS BEEN OVERFLOWING WHEN FILLING UP THE GAS TANK FOR TWO MONTHS NOW. THERE IS NO WARNING AND THE GAS SPEWS OUT OF THE NOZZLE/TANK. THE GAS OFTEN GETS ALL OVER MY SHOES, HANDS AND PANTS. WE ARE NOT IGNORING THE SHUT OFF CLICK, SINCE THIS PROBLEM BEGAN THERE HASN'T BEEN ONE. FOR OUR OWN SAFETY WE WAIT UNTIL THE GAS LIGHT IS ON TO GET GAS AND THEN ESTIMATE HOW MUCH GAS WE NEED IN ORDER TO STAY GAS FREE. WE HAVE RESEARCHED THE PROBLEM AND IT SEEMS TO BE A COMMON PROBLEM WITH JEEP AND CHRYSLER VEHICLES INVOLVING THE INLET CHECK VALVE, YET THEY HAVE DONE NOTHING. *TR

EVERY-TIME I FILL UP MY GAS TANK IT OVERFLOWS AND SPILLS OUT VIOLENTLY. *TT

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED WHEN HE SHIFTED THE VEHICLE IN REVERSE, THE GEAR SHIFT LINK FELL OFF AND THE VEHICLE WOULD NOT MOVE. THE CONTACT ALSO STATED THAT HE HAD TO CLIMB UNDERNEATH THE VEHICLE IN ORDER TO SHIFT IT INTO GEAR; WHERE HE RAN THE RISK OF THE VEHICLE ROLLING OVER HIM. THE DEALER WAS NOTIFIED AND STATED THERE WERE NO RELATED COMPLAINTS RELATED TO THE FAILURE. THE MANUFACTURER STATED THAT IF HE TOOK THE VEHICLE TO THE DEALER, THEY WOULD PAY A PORTION OF THE REPAIR COST. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 25000.

RECENTLY PURCHASED THE WRANGLER USED. FUEL SPILL EVERY TIME YOU FILL THE GAS TANK. WHEN THE FUEL PUMP CLICKS OFF FUEL SHOOTS OUT THE FILL SPOUT. *TR

PURCHASE A USED 2005 JEEP WRANGLER (SPORT) WITH 103,000 MILES IN EARLY 2011. THE SIX SPEED MANUAL TRANSMISSION POPS OUT OF FIRST GEAR ABOUT ONCE A DAY WHEN ACCELERATING FROM A STOPPED POSITION. IT ALMOST SEEMS RANDOM, NEVER KNOW WHEN TO EXPECT THE EVENT. THE EVENT IS QUITE DISTURBING AND LOUD, WITH A LOUD "POP". THE JEEP ROLLS FORWARD BUT OUT OF GEAR. I MUST QUICKLY PUT IT BACK IN FIRST GEAR TO CLEAR THE INTERSECTION, RED LIGHT, ETC. WHAT IS GOING ON WITH THIS TRANSMISSION? IS IT NORMAL WEAR-AND-TARE, OR IS THERE A DESIGN DEFECT WITH THE TRANSMISSION? WHAT IS THE SOLUTION TO THIS UNSAFE DRIVING CONDITION? HAS THERE BEEN A RECALL? *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED TWICE UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V460000 (POWER TRAIN:AUTOMATIC TRANSMISSION). THE CONTACT STATED THAT THE VEHICLE WAS PARKED AND ROLLED BACKWARD UNTIL HE ENGAGED THE EMERGENCY BRAKE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS ADVISED TO CONTACT THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS AWAITING A RESPONSE. THE FAILURE MILEAGE WAS 58,000.

ON FEBRUARY 18TH 2012, I PURCHASED A USED 2005 JEEP WRANGLER RUBICON FROM A JEEP DEALERSHIP. EVERY TIME I'VE FILLED UP FOR GAS, THERE IS AN OVER SPILL OF ABOUT 1/8 OF A GALLON. THIS HAPPENED ON 2/27/12, 2/29/12 , 3/15/12, 3/25/12, AND 4/23/12. EVEN WHEN SLOWING DOWN TOWARDS THE END OF THE FILL UP, IT STILL SPILLS OVER, JUST LESS SEVERE. I TOOK IT INTO THE DEALER. THEY PERFORMED A FUEL SYSTEM SOFTWARE UPGRADE ON 4/06/12, BUT THAT DID NOT CORRECT THE PROBLEM. THIS IS A HUGE NUISANCE (NOT TO MENTION SAFETY/FIRE HAZARD) AND FROM WHAT LITTLE RESEARCH I'VE DONE, DOES NOT SOUND LIKE AN ISOLATED PROBLEM. *TR

2005 JEEP WRANGLER. CONSUMER STATES WITHIN TWO WEEKS OF PURCHASE VEHICLE BEGAN EXPERIENCING ELECTRICAL PROBLEMS *TGW THE CONSUMER STATED THE HEATER/FAN SWITCH WAS REPLACED NUMEROUS TIMES. ON MARCH 22, 2010, SMOKE BEGAN EMITTING FROM THE VENTS INTO THE INTERIOR OF THE VEHICLE. WITHIN MINUTES, THE VEHICLE WAS FULLY ENGULFED IN FLAMES AND BURNED COMPLETELY TO THE FRAME. CHRYSLER DETERMINED THERE WERE NO MANUFACTURING DEFECTS DESPITE THE NUMEROUS PROBLEMS THE CONSUMER ENCOUNTERED WITH THE VEHICLE. *JB

I HAD BOUGHT A JEEP WRANGLER WITH APPROX 45000 MILES. RIGHT AROUND THE 55000 THE CHECK ENGINE LIGHT CAME ON AND THEN I STARTED HAVING GAS BLOW OUT OF THE GAS TANK DURING REFUELING. THE JEEP NOW HAS 85000 AND STILL HAS THE GAS BLOW BACK. I HAD TAKEN IT TO A JEEP DEALER AND THE MENTION THAT IT NEEDED A SMOKE TEST. I FOUND THAT I HAD A MAJOR EVAP LEAK IN THE FUEL SYSTEM, I HAD A MECHANIC REPLACE THE FUEL HOSES. AFTER THE REPAIRS. I STILL HAVE THE FUEL BLOW BACK. I LIVE IN THE VA BEACH AREA, WHERE FUEL ON THE GROUND CAUSES AN ENVIRONMENT PROBLEM ESPECIALLY WHEN I FUEL ON NORFOLK NAVAL BASE. I HAD FUEL SPRAYED ON ME AND ALSO CAUTIONED THE WIFE, WHO ALREADY HAD IT SPLASH ON HER FACE. LUCKILY, DID NOT SPRAY IN THE EYES. WHEN PUMPING GAS THE AUTOMATIC SHUTOFF DOES NOT KICK IN FAST ENOUGH BEFORE BLOW BACK OCCURS. IT HAPPENS WITH OUT WARNING. IS THERE A RESOLUTION TO THIS ISSUE WITH THE JEEP WRANGLERS? *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE DRIVER WAS REFUELING WHEN FUEL WAS SPEWED OUT FROM THE FILLER NECK AND ONTO THE DRIVER'S LEG. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS. THE MECHANIC STATED THE FUEL TANK WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

2005 JEEP WRANGLER UNLIMITED - THERE IS A BACK-SPLASH ISSUE WHEN FUELING THE VEHICLE, EVERY TIME! IF YOU DO NOT JUST STOP IT EARLY (BEFORE IT IS FULL) IT WILL SPLASH BACK EVERY TIME YOU FUEL, SOMETIMES QUITE A BIT OF FUEL SPILLED. I HAVE TALKED TO SEVERAL OTHER OWNERS OF THIS MAKE AND MODEL JEEP AND MOST OF THEM SAID THEY HAVE THE SAME PROBLEM. I CALLED CHRYSLER ABOUT THIS AND ASKED IF THIS WAS AN ONGOING ISSUE. THE REPRESENTATIVE SAID THEY WERE NOT AWARE OF THE ISSUE. I FIND THAT UNLIKELY. *TR

HELLO, I OWN A 2005 JEEP WRANGLER UNLIMITED. WHILE DRIVING ON THE HIGHWAY, TRYING TO "MAINTAIN" THE PROPER SPEED LIMIT, MY JEEP WILL DEVELOP A DEATH WOBBLE TO THE FRONT END. THIS ERRATIC AND ALMOST UNCONTROLLABLE BEHAVIOR OCCURS AT ANYWHERE FROM 55 TO 60MPH. AFTER TRYING TO RESEARCH THE SOLUTION TO THIS PROBLEM, I HAVE NOTICED MULTIPLE OTHER JEEP OWNERS HAVING THE SAME ISSUE. MY JEEP IS MY DAILY DRIVER, AND ALSO IS USED TO TRANSPORT MY 4 AND 5 YEAR OLD KIDS AROUND. DUE TO THE ECONOMY I CAN NOT AFFORD TO PURCHASE ANOTHER VEHICLE, NOR WILL I SELL THESE PROBLEMS TO SOMEONE ELSE. I AM SURPRISED THERE HASN'T BEEN MORE HIGHWAY RELATED INCIDENTS/FATALITIES DUE TO THIS ISSUE. ANY HELP WILL BE GREATLY APPRECIATED IN SOLVING THIS ISSUE. DEALERSHIPS ARE NO HELP AND I CANT AFFORD TO REPLACE THE WHOLE FRONT END JUST TO END UP WITH THE SAME PROBLEMS. THANK YOU FOR YOUR TIME IN THIS MATTER, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

SIGNIFICANT FUEL SPILLAGE WHILE FUELING VEHICLE AT THE POINT OF GAS PUMP CUT-OFF. FUEL IS "BURPED" OUT OF THE FUEL FILLING PORT ON THE VEHICLE ONTO PUMP OPERATOR'S HANDS, ARMS, AND CLOTHING, IN ADDITION TO THE SIDE OF THE VEHICLE AND FILL NOZZLE. THIS HAPPENS EVERY TIME THE VEHICLE IS FUELED NO MATTER WHERE IT IS FUELED, WHAT SPEED FUEL IS PUMPED AND WHETHER OR NOT THE NOZZLE IS BEING HAND OPERATED OR "AUTOMATICALLY" OPERATED. ON RESEARCH, THIS IS AN ENGINEERING FAILURE KNOWN BY CHRYSLER THAT IS DUE TO NON-ETHANOL RESISTANT PLASTICS BEING USED IN A CHECK VALVE CONTAINED IN THE FUEL TANK ASSEMBLY, CAUSING THE VALVE TO SWELL AND GET JAMMED WHEN FUEL CONTAINING ETHANOL IS USED IN THE VEHICLE. I WOULD THINK THAT DRIVERS, THEIR VEHICLES, AND THE GROUND BEING DOUSED WITH SIGNIFICANT QUANTITIES OF GASOLINE AT EVERY FUELING STOP WOULD QUALIFY AS A SAFETY ISSUE. *JS

WHEN FILLING GAS TANK, FUEL SPLASHES BACK OUT OF FILL PIPE. IT DOESN'T MATTER HOW FAST OR SLOW THE TANK IS FILLED, OR WHAT POSITION THE FILL NOZZLE IS PLACED IN THE FILL OPENING, IT SPLASHES BACK OUT OF THE FILL PIPE, COVERING THE SIDE OF THE VEHICLE, AS WELL AS THE PERSON FILLING IF STANDING TOO CLOSE. I SEE THIS AS A VERY DANGEROUS SITUATION, AS STATIC ELECTRICITY COULD EASILY IGNITE THE FUEL IN THIS SCENARIO. I'VE READ ON JEEP BLOGS THAT THE CURE IS TO REPLACE THE FUEL TANK DUE TO A DEFECTIVE VALVE IN THE TANK AT THE COST OF OVER $900. BUT UNFORTUNATELY THE REPLACEMENT TANK IS JUST ANOTHER DEFECTIVE TANK, AS THERE IS NOT AN UPDATED UNIT AVAILABLE, THUS SETTING UP ANOTHER FUTURE FAILURE. THERE IS NOT RECALL ON THIS, I THINK THERE SHOULD BE. PLEASE KEEP ME ADVISED OF ANY ACTIONS TAKEN IN THIS MATTER. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TR

FRONT END STARTS INTO A VIOLENT WOBBLE BETWEEN 50 & 55 MPH. THE ONLY WAY TO STOP IT IS TO SLAM ON THE BRAKES. I HAVE TRIED DIFFERENT TIRES AND DIFFERENT TIRE PRESSURES AND THE WOBBLE STILL PERSIST. THE SUSPENSION HASN'T BEEN MODIFIED IN ANY WAY AND THE ENTIRE VEHICLE IS IN STOCK CONDITION. I THINK THAT THIS IS A WELL KNOWN PROBLEM THAT COULD RESULT IN LOSS OF LIFE AND THERE SHOULD BE A RECALL TO FIX IT. *JS

WHEN FILLING GAS TANK NECK REPEATEDLY OVERFLOWS AT CUTOFF, SPILLING SEVERAL OUNCES OF GAS ON CAR AND GROUND. *JS

WHEN REFUELING THE VEHICLE, FUEL PUMP NEVER SHUTS OFF. THIS HAS BEEN A PROBLEM WITH THE VEHICLE NOW FOR A LONG TIME. THE FUEL SYSTEM ALLOWS THE PUMP TO CONTINUE RUNNING AFTER THE TANK IS FULL. IT DOES NOT MATTER WHAT GAS STATION I GO TO. GASOLINE ALWAYS OVERFLOWS AND SPILLS OUT ONTO THE GROUND. I WAS RECENTLY REFUELING MY AND THE VEHICLE AND THE PUMP DID NOT SHUT OFF. A SUBSTANTIAL AMOUNT OF GAS FLOWED OUT ONTO THE GROUND AND SOMETHING LIT THE FUEL VAPORS CAUSING A SMALL FIRE. I WAS ABLE TO PUT IT OUT WITH AN EXTINGUISHER. THIS COULD HAVE CAUSED THE ENTIRE GAS STATION TO CATCH FIRE/EXPLODE AND IS EXTREMELY DANGEROUS. *TR ..UPDATED 09/12/12 *BF UPDATED 09/12/2012 *JS

WHENEVER YOU FILL THE TANK IT OVERFILLS AND ENDS UP ON THE PAVEMENT. NO MATTER HOW SLOW OR FAST YOU FILL IT. *TR

GASOLINE SPEWS OUT OF TANK WHEN CLICKING OFF WHEN FULL. THIS CAN BE VERY DANGEROUS AND GETS GASOLINE ON MY TRUCK AND I HAVE HAD GASOLINE SPEWED ON ME BEFORE. IT'S NOT FUN GOING TO WORK SMELLING LIKE A GAS STATION. THERE ARE SO MANY COMPLAINTS ON THIS ISSUE, WHY ISN'T THE MANUFACTURER REQUIRED TO FIX THIS DANGEROUS PROBLEM? *TR

WHEN FILLING UP WITH GAS THE FUEL GUSHES OUT OF THE GAS HOLE WHEN THE PUMP CLICKS OFF. *TR

VEHICLE CONSISTENTLY SPEWS FUEL WHEN FILLING FUEL TANK REGARDLESS OF WHICH GAS STATION I USE. *TR

WHEN FILLING THE VEHICLE UP WITH GASOLINE AT A SERVICE STATION AN OVERFLOW CONDITION OCCURS WHERE A SIGNIFICANT VOLUME OF GASOLINE SPEWS OUT OF THE FILLER NECK. THE OVERFLOW OF GASOLINE IS ENOUGH TO DOUSE THE OPERATOR PERFORMING THE FILLUP, RUN DOWN THE SIDE OF THE VEHICLE, AND LEAVE A LARGE PUDDLE OF GASOLINE ON THE GROUND. *TR

FUEL SPILLS FROM FILLER NECK WHILE FILLING UP AND TANK IS FULL. GAS STATION PUMP DOES NOT TURN OFF. HAPPENS AT DIFFERENT GAS STATIONS 100% OF THE TIME. *TR

WHEN FILLING MY JEEP AT A GAS STATION GAS WILL OVERFLOW AND SPLASH OUT OF THE TANK WHEN THE PUMP STOPS. *TR

AS GAS TANK APPROACHES FULL WHILE FUELING, THE FUEL SPILLS OUT OF THE FILLER NECK AT A HIGH RATE WITHOUT WARNING. *TR

WHEN FULLING THE VEHICLE THE FUEL OVERFLOWS OUT OF THE GAS TANK SPILLING THE FUEL ONTO THE REAR OF THE VEHICLE AND GROUND. THIS HAPPENS EVERY TIME THE VEHICLE IS FUELED AND IT HAS HAPPENED AT DIFFERENT GAS STATIONS. *TR IT DOES NOT MATTER IF THE GAS HANDLE IS ON AUTO PILOT NOR MANUAL FUELING.

WHEN FILLING UP WITH FUEL, THE FUEL TANK SYSTEM DOES NOT AUTOMATICALLY SHUT OFF UNTIL AFTER FUEL HAS SPILLED OUT OF THE FUEL TANK DOOR AND ONTO THE GROUND. *TR

GAS TANK OVER FLOWS EVERY TIME AT FILL UP. *TR

WHEN FILLING THE CAR WITH GASOLINE, THE AUTOMATIC SHUT OFF DOES NOT OCCUR AND FUEL BLOWS OUT OF THE JEEP AND DOWN ON THE GROUND AND ME IF I AM CLOSE. IT APPEARS THAT A SUBSTANTIAL AMOUNT OF FUEL SPILLS. THIS OCCURS AT ALL FILL UPS IT IS NOT GAS STATION SPECIFIC. THIS CAN BE A DANGER IF IT SPEWS ON SOMETHING HOT. ALSO I WOULD THINK THAT IT'S AN ENVIRONMENTAL CONCERN AND IT STINKS. VERY FRUSTRATING PROBLEM! *TR

DEATH WOBBLE VIOLENT SHAKING OF STEERING WHEEL WITH AFTER MARKET PARTS I HAVE SPENT THOUSANDS OF DOLLARS TRYING TO FIX THE PROBLEM AND IT STILL DEATH WOBBLES JEEP NEED TO REIMBURSE PEOPLE FOR THIS IF I WOULD HAVE BEEN TOLD THIS BY A DISCLOSURE OF SOME SORT WHEN I WENT TO PURCHASE THE JEEP I WOULD HAVE NOT PURCHASED IT. *TR

WHEN FILLING THE VEHICLE'S FUEL TANK, FUEL SPLASHES OUT OF THE TANK AND COVERS THE SIDE OF THE JEEP AND THE GROUND BELOW. THIS HAPPENS WITH EVERY FILL UP. *TR

THE AUTOMATIC FUEL SHUT-OFF DOES NOT WORK CAUSING FUEL TANK TO BE OVERFILLED. I HAVE FUEL SPILLAGE EVERY TIME AND IT DOESN'T A MATTER HOW FAST THE FUEL IS PUMPED. *TR

PUMP KICKS OFF EVERY 2/10THS OF A GALLON WHILE PUMPING FUEL. HAPPENS WHETHER YOU ARE AT FULL FLOW OR JUST LETTING IT TRICKLE. *TR

THE DESIGN OF THE FUEL TANK IN THE WRANGLER UNLIMITED EDITION MADE FROM 2004 TO 2006 CAUSES IT TO HOLD AN AIR BUBBLE AND BLOW A LARGE AMOUNT OF GAS OUT OF THE FILLER SPOUT WHEN PUTTING FUEL IN. THIS HAPPENS EVERY TIME THE JEEP IS FILLED UP WITH GAS. THESE SPILLS ARE AN ENVIRONMENTAL ISSUE AS WELL AS A SAFETY ISSUE. *TR

EVERY TIME THAT I REFILL THE TANK, GAS WILL OVERFLOW OUT OF THE TANK AFTER THE PUMP SHUTS OFF. SOMETIMES THE GAS WILL SPRAY OUT VIOLENTLY, OTHER TIMES THE GAS WILL JUST SPILL DOWN THE SIDE OF THE JEEP AND ONTO THE GROUND. *TR

THE OIL PUMP DRIVE ASSEMBLY (OPDA) UPPER BUSHING HAS NO WAY TO LUBRICATE DUE TO MANUFACTURING ERROR IN THE 2005 AND 2006 4.0 ENGINE. THIS CAUSES HIGH METAL TO METAL SCRAPING SOUND AND WILL RESULT IN ENGINE FAILURE. HAPPENED AFTER 38000 MILES IN A WELL MAINTAINED VEHICLE. TALKED TO MANY JEEP DEALERS AND SERVICE TECH'S AND THEY REFUSE TO GIVE ANY ASSISTANCE OR SUGGESTIONS FOR A FIX. *TR