2003 Jayco Jay Flight

Defect. Jayco, Inc. (Jayco) is recalling various 2002-2016 recreational vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V746-9524.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Risk. In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy. Jayco will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Jayco customer service at 1-800-283-8267, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Defect. ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Risk. AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy. SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR JAYCO AT 1-574-825-0608.

DT*: THE CONTACT STATED THE MICROWAVE OVEN IN THE TRAILER IS DEFECTIVE. THERE HAS NOT BEEN AN ELECTRICAL SHORT INVOLVING THE MICROWAVE. THE CONTACT UNPLUGGED THE MICROWAVE TO AVOID AN ELECTRICAL SHORT AND IS THEREFORE UNABLE TO USE IT. THERE WAS A RECALL LETTER RECEIVED IN NOVEMBER 2005 CONCERNING RECALL, # 03V383000 ON THE VEHICLE REGARDING THE EQUIPMENT. THE PARTS NEEDED TO REPAIR THE VEHICLE ARE NOT AVAILABLE AT THE LOCAL DEALERSHIP. THE MANUFACTURER CONFIRMED THE PARTS ARE NOT AVAILABLE.

2003 JAY FLIGHT 27BH TRAILER BRAKES LOCKING UP. *BF THE CONSUMER TOOK THE RV BACK TO THE DEALER WHO STATED THE BRAKE LINES WERE TOO SHORT SO THEY HAD TO BE ADJUSTED. THE SCREEN HAD TO BE FIXED BECAUSE THE WERE NOT SEALED PROPERLY, THERE WERE GAPS BETWEEN THE SCREENS AND THE WINDOW FRAMES. THE CONSUMER ENCOUNTERED OTHER PROBLEMS SUCH AS THE SHOWER WALL SEPARATING FROM THE CORNER WHICH CAUSED THE WALL TO BULGE, THE FRESH WATER TANK WAS NOT PROPERLY TIGHTENED SO WHEN THE CONSUMER USED IT FOR THE FIRST TIME WATER LEAKED ALL OVER THE FLOOR AND SOAKED THE CARPET. THE MOUNTING WHICH HELD THE DRAWERS IN PLACE FELL APART, THE WATER HEATER STOPPED WORKING, ALL OF THE SCREWS WHICH HELD THE SEATING AROUND THE TABLE FELL OUT, HE WATER PUMP WAS VERY LOUD. *JB

CONSUMER DISCOVERED THAT THE RIGHT SIDE ELECTRICAL BRAKE LINE WAS NOT HOOKED UP ON THIS TRAVEL TRAILER FROM THE MANUFACTURER PLANT. DEALER WAS NOT NOTIFIED . *AK