2006 Itasca Sunrise

Defect. WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Risk. THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy. WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Defect. WINNEBAGO IS RECALLING 2,331 MY 2002-2004 BRAVE AND ITASCA SUNRISE MY 2005 2006 WINNEBAGO VOYAGE, ADVENTURER, ITASCA SUNRISE AND SUNCRUISER MOTOR HOMES. THE PROPANE TANK MOUNTING BRACKET MAY HAVE AN INCOMPLETE OR IMPROPER WELD.

Risk. SHOULD THE WELD FAIL, THE PROPANE TANK CAN TIP OR FALL, POSSIBLY RELEASING PROPANE WHICH HAS THE POTENTIAL TO IGNITEA FIRE, RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy. DEALERS WILL INSPECT AND PROPERLY WELD THE BRACKET FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT WINNEBAGO AT 800-537-1885.

Defect. CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE STEERING COULD BECOME LOOSE AT THE STEERING BOX DURING TIGHT STEERING MANEUVERS.

Risk. THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Remedy. WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFT. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6883 OR WINNEBAGO AT 1-641-585-3535.

Defect. ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.

Risk. THE DEFECTIVE CONTROL UNITS COULD DEVELOP AN ELECTRICAL SHORT ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy. DEALERS WILL INSPECT THE KWIKEE STEP AND REPLACE THE STEP CONTROL UNIT, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 23, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

TL* THE CONTACT OWNS A 2006 ITASCA SUNRISE. THE CONTACT STATED WHILE IN A STORM THE ROOF OF THE RV DISLODGED FROM BODY. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000. ## VIN PASSED ## 2006 WINNEBAGO ITASCA SUNRISE ##

PURCHASED NEW 2006 WINNEBAGO ITASCA SUNRISE 38J MOTOR HOME (MH). I DON'T KNOW IF WORKHORSE AUTO PARK BRAKE ASSEMBLY WAS DEFECTIVE WHICH CAUSED THE ALLISON TRANSMISSION TO BLOW OR VICE VERSA. I KNOW OUR MH WAS ON FIRE AS WE WERE DRIVING, A MAN WAS INJURED & THERE WAS A CRASH. I KNOW THIS MH IS NOT SAFE TO BE ON THE ROAD. IT IS IMPERATIVE YOUR ORGANIZATION PERFORM AN UNBIASED, CONSUMER SAFETY ORIENTED EVALUATION. WINNEBAGO, WORKHORSE & ALLISON ARE POINTING FINGERS AT EACH OTHER. LESS THAN 2000 MILES ON MH, DRIVING APX 57 MPH, HEARD HUGE EXPLOSION, DASH WARNING LIGHTS STARTED FLASHING & CHIMES STARTED DINGING. DROVE LESS THAN ONE MILE TO GAS STATION. PULLED UNDER GAS PUMP CANOPY. MANAGER RAN OUT YELLING AT US TO MOVE MH AWAY FROM PUMPS. WE WERE ON FIRE. PULLED MH UP APX 30 FEET, TURNED ENGINE OFF. PUT FIRE OUT. MH BROUGHT TO WORKHORSE AUTH DEALER IN FAYETTEVILLE, NC. SERVICE MANAGER TOLD US SOMETHING IN AUTO PARK BRAKE ASSEMBLY HAD MALFUNCTIONED & HEATED UP INSIDE ASSEMBLY CANISTER CAUSING EXPLOSION & THE FLUIDS THEN SPILLED ONTO MANIFOLD CAUSING FIRE. AUTO PARK BRAKE ASSEMBLY REPLACED. ORIGINAL PART SENT TO WORKHORSE FOR EVALUATION. WE WERE SHOWN THE METAL CANISTER HAD HEATED UP SO MUCH THE METAL TURNED RAINBOW BLUE. WE WERE TOLD MH WAS REPAIRED & SAFE TO DRIVE. NOTICED TRANSMISSION WARNING LIGHT WAS ILLUMINATED ON DASH. HAD SERVICE MANAGER TAKE FOR TEST DRIVE SINCE WE DID NOT FEEL THE MH WAS SAFE TO DRIVE. HE DROVE IT & FELT TRANSMISSION WAS BLOWN. HE TOOK IT TO ALLISON TRANSM