2011 Hyundai Sonata complaints

Warning light for airbag continues to stay on , and cruise control does not work at all.

Brake light housing has melted and deformed so that the bulb is stuck in the tail light assembly and cannot be changed. Without working brake lights the car is unsafe to be driven on the road. I’m assuming there is an electrical problem that caused the lights to overheat and melt the housing. This is a common complaint with this make and model based on my research. The socket also does not lock into the assembly due to the deformed housing. My daughter is the owner of the vehicle and made me aware of the issue today.

THE ALTERNATOR AND BATTERY OF THIS VEHICLE HAS BEEN SWITCHED AT LEAST 3 TIMES. PURCHASED NEW AND ALL, YET THE CAR KEEPS GETTING DRAINED AND LEFT POWERLESS. SOMETHING IS DRAINING THE ENERGY OF THE VEHICLE AND THE ROOT TO THE PROBLEM IS NOT KNOWN.

I have had replaced my taillight bulbs 8 times in the last year. They keep blowing out and getting so hot they melt the taillight assembly. I replaced the whole assembly a couple months ago and it is already melted so bad the light bulb will not fit properly or stay in place. This is a fire hazard and also a safety hazard as my taillights quit working at anytime.

The contact owns a 2011 Hyundai Sonata. The contact stated that the headlights ceased to operate as designed. The vehicle was taken to an independent mechanic, where the headlight bulbs were replaced three times within a month; however, the failure persisted. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 150,000.

The contact owns a 2011 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 18V137000 (Seat Belts, Air Bags). The vehicle was taken to the dealer where the recall repair was performed. Recently, the contact stated that the air bag warning light illuminated. The vehicle was taken to an independent mechanic where the warning light was cleared; however, the light returned soon after. The vehicle was then taken to the dealer and the contact was informed that the vehicle had to be repaired out-of-pocket. The manufacturer was notified of the failure and the contact was informed that the vehicle was out of warranty and a case was filed. The vehicle was not repaired. The failure mileage was approximately 262,000.

My engine was replaced under warranty due to the major Theta engine recall, after 20k miles on the new engine its failing too, burning oil, smoking, making loud valve train noise on acceleration, and at time operates very sluggishly and strangely no engine codes ,almost like my engine code system was programmed to ignore these issues. My new replaced engine seems to be failing again and they don't care. I'm afraid this car will catastrophically fail or catch fire like I've been reading about.. Because its past the 12k warranty they are declining to fix,12k warranty REALLY ???!! Here's my concern, I am hearing many many ,many stories from others and even the dealer people that Hyundai is replacing the recall engines with BAD faulty engines, some I've heard have received 3 engines. My dealer lied to me saying it was a PCV ,the PCV valve was replaced and my engine is still failing like the first engine. Please help, Hyundai is basically getting away with ignoring the recall settlement by replacing the engines with still known faulty engines !

I was accelerating from a county road onto a state road, and the engine quit. The dash board displayed a bunch of tiny colored symbols of which I hadn't seen before. I coasted and pulled into an Elementary School parking lot and braked to a stop. I attempted to restart but got nothing. I smelled something and got out and opened the hood. The bottom end of the motor was on fire! I flagged down a lady and described my situation. She was the principal and went to get a matinance man with a extinguisher. Soon, two guys with water bottles stopped and extinguisher the flames. The principal and matinance man arrived and the guys pushed my Sonata into a parking spot. The principal (nice lady) gave me a ride home. I bought it used, no warranty, from a used car lot. I still owe a lot on it. Up until that point, I liked the car as so did my friends. Having full coverage insurance on it, I'm waiting to see what Allstate is going to do. This happened this past Friday , first week of April in the evening.

Smell of fuel & starting issues. The car has been taken to the dealer multiple times regarding gas fumes and they could not find anything. And it is currently at a mechanic shop to for same reason. When you start the car it doesnt take long before the whole car smells like gas & the smell is so strong it is suffocating. The car is health & fire risk. Also the car sometimes doesnt want to start for days but the starter, battery, alternator all work & even the mechanic doesnt know whats wrong with it. Apperantly there is no recall & if you search online there are alot of people with same cars complaining about gas smell & starting issues..

The contact owns a 2011 Hyundai Sonata. The contact stated while driving 15 MPH and making a left turn, the vehicle lost motive power and stalled. The contact was able to coast into a parking lot. The engine, oil, air bag, traction control, and ABS warning lights were illuminated. The vehicle was towed to an independent mechanic who informed the contact that the engine had seized. The vehicle was towed to the local dealer who informed the contact that it would be four to five weeks before being serviced. The vehicle was not diagnosed or repaired. The contact stated that the engine was previously replaced in 2018. The manufacturer was notified and provided a case number. The failure mileage was approximately 50,000.

The contact owns a 2011 Hyundai Sonata. The contact stated while starting the vehicle, the Electronic Power Steering (EPS) warning light was illuminated and the steering wheel became difficult maneuver. The vehicle was taken to an independent mechanic, where it was diagnosed that the failure was related to NHTSA Campaign Number 161V190000 (Steering). The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 255,000.

The contact owns a 2011 Hyundai Sonata. The contact stated while driving at approximately 65 MPH, the vehicle started swerving in the lane to the right and the left. The contact heard an abnormal thumping noise from underneath the floorboard. The contact stated that the power steering and brakes functioned as needed. The contact stated no warning light was illuminated. The contact had taken the vehicle to an independent mechanic, where it was diagnosed and determined that the rear cross member needed to be replaced. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 13V354000 (Suspension). The failure mileage was approximately 162,000.

The NHTSA has filed a Consent Order (RQ17-004) for a Engine Replacement due to safety concerns while driving the vehicle on the road, Vehicle may stall and cause / be involved in a accident. Please make this recall public so the affected vehicles can be properly repaired as the Consent Order states I have reviewed the Consent Order and I will not continue to drive this vehicle, I will not risk being involved in a accident The Hyundai dealership in Alexandria Virginia has refused to repair this recall under the Consent Order, My vehicle Vin# is [XXX] My vehicle has been at this dealership location for over 3 weeks and I was told that they were not going to perform this recall and I noted that If I pick up my vehicle and drive it away and the engine fails, stalls or stops in the middle of the highway and I survive I will have to file a lawsuit in this matter and the dealership still told me to pick up my vehicle. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

While driving on highway gas pedal failed and engine turned off. Vehicle had to coast slowly. Attempts to start car worked but could not go faster than 10 miles per hour.

I'm smelling has from under the car and it's got a ticking sound and burning oil it looks like

I was driving my vehicle and a warning light indicating hybrid system charging failure warning. The vehicle had intermittent power problems and would not move appropriately in relation to the pushing the gas pedal. It would not go then would jerk forward. I was finally able to pull over to the side of the road safely. I turned my car off and when turned back on the error message failed. This happened on two other occasions. Later there was a whining noise when shifting into second gear. I took in for service and the hyundai dealership told me the transmission needed to be replaced. My safety and others were at risk due to loss of ability to drive the vehicle appropriately due to loss of power.

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and stalled. The vehicle was taken to an independent mechanic and was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.

Engine stalled and shut off and wouldn’t start again

The contact owns a 2011 Hyundai Sonata. The contact stated while driving 60 MPH, the vehicle started stalling without warning. The contact pulled over on the side of the road and the vehicle lost motive power and stalled. The contact attempted to restart the vehicle however, the vehicle failed to restart. The vehicle was towed to an independent mechanic and the contact was informed that the vehicle had experienced the failure listed in NHTSA Campaign Number: 15V568000 (Engine). The contact was referred to the dealer for assistance. The vehicle was towed to the dealer. The manufacturer was contacted and stated that the vehicle needed to be diagnosed by an authorized dealer. The vehicle was not repaired. The failure mileage was 62,000.

The contact owns a 2011 Hyundai Sonata. The contact stated while driving at various speeds, the power steering failed, causing the steering wheel to become very difficult to turn in either direction. The cause of the failure was not yet determined. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the NHTSA Campaign Number: 16V190000 (Steering). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer was not yet notified of the failure. The failure mileage was 115,000.

The car suddenly stopped idling while driving at around 40-45 mph and everything seemed normal until it would not drive but the car was on and then the steering was difficult to pull over to a safe area and the brakes were hard to brake and stop but when it came to a full stop the vehicle dash warning lights were flickering and shut off. When I tried to attempt and start the vehicle it would not start but everything turns on ike normal al the lights except the engine was not on. Also it started smelling like some sort of electrical components were burning or something but I couldn't see any smoke or anything coming from the engine area but it seemed like electrical burn somewhere in the car. The vehicle is very unsafe to drive since there was no kind of warning lights or sounds and just stopped working while driving. The vehicle is well maintained and up to date with maintenance services. It became inoperable and had to be towed home since I ended up stuck in a unsafe spot in the middle of a busy street and waited hours for someone to tow it back to my house because it was already about 1 or 2 in the morning. The next day had hired a mechanic to come and do the diagnostics and repairs and still doesn't start or drive and I had to hire another mechanic to diagnose the problem again and was told that the motor is seized and I would need a new engine and other work done on it as well and so me and my family are stuck without a car which is our only car and no more money to fix t

Unknown

I was driving my 2011 Hyundai Sonota and it felt like a truck had slammed into the back of my vehicle but it didn’t, the car was knocking and finally stopped and wouldn’t accelerate when pushing the pedal. I had to have it towed and the shop didn’t know what to do and I had it sent to Rick Case Hyundai and I explained the situation about the debris being washed out of the engine and they asked for $1700 just to look at the engine. I had a few recalls and they should have looked at the engine with no problems and no charges. They had my vehicle towed and it took me a few months to figure out what happened to my car? I have been denied EVERYTHING BY HYUNDAI CORPORATE AND TAMMY OFFERED TO LOOK AT THE ENGINE AFTER SENDING THE INFORMATION TO BBB AND SHE SAID SHE WOULD DO IT FREE OF CHARGE BECAUSE THERE IS A RECALL ON THE END

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving at an undetermined speed, there was an abnormal rattling and ticking noise detected. The air bag warning light illuminated. The vehicle was taken to the local dealer where it was diagnosed that an engine replacement was needed. The dealer requested the maintenance records but denied repair coverage due to old oil in the vehicle. The manufacturer was not contacted. The approximate failure mileage was 180,000.

My husband was accelerating onto a highway and the engine failed. He was able to pull to the shoulder and brake to a stop. He was not able to start the car. He had the car towed to our mechanic and the mechanic reported that the engine seized, the engine had oil in it, and we needed to bring the car to the dealer to have it looked at. There were no lights, sounds, or warnings that there was a problem with the engine. This is the second engine failure for this car. The first failure was a fire and the engine was replaced. The dealer stated that it would take 3 weeks before they could look at the car. We brought it in 3 weeks later, 12/19/22. No-one has looked at the car. We don't know what the problem is, because they still have not looked at it.

EPS and traction light came on when driving around 20mph making the wheel stiff and barely able to turn. Looked up 2011 Hyundai recalls and came across recall 143 regarding the steering column. Took car to dealer and they said no recalls found for my vehicle. I told them about what I found online and that I’m experiencing the same issues so I’m not sure why my 2011 wasn’t affected. They basically said too bad too sad. They still have my car so I’m hoping that they figure out my car should be apart of the recall campaign.

ENGINE SEASED UP OUT OF NO WHERE IN THE MIDDLE OF AN INTERSECTION NO SOUNDS NOTHING JUST STOPPED RUNNING

The contact owns a 2011 Hyundai Sonata. The contact stated while driving 65 MPH, the vehicle failed to accelerate and inadvertently decelerated to 10 MPH. The vehicle went into LIMP Mode. The check engine warning light was illuminated. The contact pulled over and had the vehicle towed to the dealer. The dealer diagnosed the vehicle and retrieved fault code: P1326 (Knock Sensor Detection System) and performed an engine bearing test, which the vehicle passed. The dealer updated the KSDS and ECM software; however, the failure recurred. The vehicle was towed back to the dealer, where the knock sensor and bolt were replaced. The contact stated that the engine was previously replaced in 2019. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 118,392.

2011 HYUNDAI SONATA. CONSUMER WRITES IN REGARD TO STEERING PROBLEM.

The airbags in my car did not deploy! I was hit so hard through my driver window that it knocked me out both speeds combined together was 110mph with me going 55mph the air bags should have went off the whole driver side back to the trunk is damaged and not even the door airbag had went off. This is a huge safety concern for myself.

I started smelling a strong fuel odor and my car just started leaking fuel while I was driving it.

My engine has failed, and my steering wheel column has locked. I had the software update on my engine with Napleton that qualified me for a lifetime engine replacement. I submitted maintenance records for my car and pictures of my valvetrain that are well maintained, and hyundai denied my engine claim for exceptional maintenance neglect on Dec8. On December 14th, after reviewing my oil changes, they still denied me for using low quality oil that's obscured. The problem I am having with my car is oil, not being able to get to the pistons inside my engine. It's not fair when the company know they engines have a manufacture defect. Then they blame the customers for lack of maintenance to have an excuse not to replace the engine. Knowing that with or without oil changes in the hyundai sonata 2011 -2012 models the engines will eventually seize anyway.I've reached out to their company over 300 times trying to resolve this matter and I'm still in the same place I started at a month ago. I want to sue for pain and suffering. I've been without a car since nov 9, and it's dec 20. Hyundai has put me and my family life in danger on numerous occasions, with their faulty and defected parts causing two near death experiences. Hyundai sonata has had a recall on every part, and I consider them unsafe and dangerous. I have seven different case reports with Hyundai motor company about excessive oil consumption, and the knocking whining vibrating and shaking. They are very much aware of everythi

2020 wiring harness overheated and melted - replaced taillight 6 times in 1 year. Hyundai fixed. 2021 tailight out again - Hyundai stated the taillight assembly melted, needs to be replaced (403.00) light bulb cannot be replaced (warped). Safety issue is what is causing things to heat up and melt. Many others reported same issue online - Hyundai is not taking ownership to fix whatever is causing this? No warning lamps.

When Driving the Alarms go off indicating a brake issue, my brake peddle goes to the the floor, car looses power and slows down to 5 MPH. Car will not accelerate past 5 MPH when i am trying to pull over or get off the freeway. Brakes are grinding as i try to use them, very dangerous while on the freeway. When I am able to pull over. I will turn off the car and turn it back on and the issue goes away. Now this may happen several more times before i am able to get some where safe. Dealership has no clue why its doing this after showing the video of the Alarms and describing it. No codes are found either. They just want to start replacing parts stating at 3k a round hoping it will fix the issue. This issue doesn't happen every day but it does happen while driving on the freeway. I have read online others having the same safety issue while driving and having thes same brake failures. Not sure where Hyundai is at with this issue and the fix for it? Yet does someone have to be in a serious accident before someone takes action with this issue?

The contact owns a 2011 Hyundai Sonata. The contact stated that while driving, the steering wheel locked, causing the vehicle to veer to the side of the road. The vehicle was taken to the dealer who replaced the steering coupler. Additionally, the contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that she needed to add 2 quarts of oil weekly. Additionally, the contact stated while starting the vehicle, the vehicle started shuddering. The contact stated that upon attempting to reverse, the vehicle shuddered increasingly and failed to respond. The contact stated that as she turned off and restarted the vehicle, the failure ceased, and she was able to drive the vehicle. However, while driving 50 MPH, she heard abnormal knocking and whining sounds coming from the engine. The check engine warning light was illuminated. The contact was able to continue driving; however, the contact stated while driving 45-50 MPH, she heard a clicking sound coming from the engine and the engine seized while in the middle of an intersection. The contact was unable to restart the vehicle. The contact contacted the Police Department who assisted her with pushing the vehicle to the side of the road. The vehicle was towed to the residence. The vehicle was then towed to the dealer where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The contact stated that a software update was previously completed on the ve

I was driving on the interstate when all of a sudden I heard a loud noise that terrified me. I quickly realized the glass of my sunroof was gone. There were no warning signs at all and the sunroof was not open when this happened. After inspection it was clear that only the glass was missing and no other parts of the sunroof assembly. I called Hyundai and was told I could bring it in but it would be an out of pocket expense and would be at least a week before they could get to it. I wasn't sure of the date so I put today's date. N

7am turn car on and let it. Warm up for a couple min then out of No we're car turns off . Another day another morning turn car on and seconds pass and car turns off repairs I did as u can see in invoices replaced enginee couple months ago took to dealer ship several times no help or. Any solution.

Hyundai has refused to get back to me about my car it's been months they don't return my phone calls or emails or anything. The motor recall had caused me and my children to be stranded in the busy highway after just shutting down 2 times. Amongst other things this is unacceptable

The contact owns a 2011 Hyundai Sonata. The contact stated that there was an abnormal sound coming from the vehicle while driving. The steering wheel was making an abnormal humming sound. The contact stated that the vehicle failed to start. The check engine warning light was flashing on and off constantly. The vehicle was taken to an independent mechanic who stated that the failure was due to the power steering. The local dealer was contacted, and the contact was informed that the vehicle was not covered under a recall. The vehicle was not diagnosed or repaired. The VIN was not included in NHTSA Campaign Number: 15V568000 (Engine) and NHTSA Campaign Number: 16V190000 (Steering). The manufacturer was not contacted. The failure mileage was approximately 129,000.

When I was driving on the highway there was a sudden knocking sound coming out from my engine. I dropped off from the highway and checked the engine and there was a smoke coming out from the engine it was scary. I took my car to the dealership and they took some time and they said I have to replace the engine. Even it is under a safety recall they decided not to replace the engine and they are saying that the engine is rebuilt. Please help me to get my engine replaced, I am a student I am not understanding what to do with this. NHTSA is my final hope to help me in this

I really don’t know what the problem is. I got my break lights change and they keep blowing out every two to three weeks. I have been changing the bulbs for more than a year now. Every shop I went to say it have wiring problems.

No heat only A/C and will not turn off. Engine light on and low tire light on but no other information is provided on screen.

In May 2022 the engine was recalled and replaced by Schomp Hyundai located at 100 Havan St, Aurora, CO 80010, and I purchased this car right after the engine recall. Since I bought the car vehicle the engine has been making noise and the AC and heater smell gas and burned fuel inside the vehicle through cabin air vents. I took the car to the Schomp Hyundai and asked them to fix the noise problem as the engine is not properly installed but they refused to fix it and asked me to pay $180 to diagnose the problem and to pay additional for the fix. The second time when I took the car for the gas and fuel fume and I was told that it is not part of the engine warranty; I have to pay $180 to diagnose the problem and pay additional for the fix. As the engine was replaced, the service may have resulted in damage to the high-pressure fuel pipe. While maneuvering the engine into place, the fuel pipe may have been crushed, poorly torqued, or simply not aligned properly. The dealer is not accepting any responsibility.

When driving randomly the cars engine will rev really high while pressing the gas pedal but the car doesn't move. After a little while the car eventually makes a loud clunking noise which shakes the car and typically causes the tires to spin. It seems to happen when the car is trying to decide whether to switch the gas engine or back to EV mode. This has been happening for a long time an even after the engine was replace under the recall. This is a safety issue that causes major concerns for myself an passengers. Also it happen when turning onto highways or exits which at high speeds there is a high likelihood of causing an accident. I have reported this to Hyundai several times but they cannot figure out the cause but rather keep trying different things an charging me. the car also seems to burn oil fast which doesn't make any sense being that its a newly installed engine.

I was driving home from work & out of NOWHERE the engine seized & power steering was very hard due to it being electric. Hyundai then denied my engine for "Lack of maintenance" AFTER they KNOWINGLY put my life & others t risk for even letting these cars be driving without proper caution or engine replacement.

I have had to replace my brake lights, sometimes, every few months. My third brake light only works intermittently. Recently, my brake lights and my door lights failed to shut off after I turned the engine off. Also, my abs light came on on the dash, but after turning the engine off and back on, that light went out. After re-starting my car and repeatedly, stepping on the brake, my lights finally shut off. I checked the internet for similar problems and found out that there had been a Hyundai recall for this issue. I phoned Hyundai customer support. They told me the recall had been repaired on my car by the dealer . Obviously, it had not. (The dealer also claimed to have corrected another recall regarding seat belts, but that too is a lie, since my seat belt dash light is on although I have never been involved in an accident) I believe that the dealer billed Hyundai, but failed to either deliberately or inadvertently failed to perform the recall work. The recall involved replacing the brake stopper pad which engages the brake light switch. Obviously, Hyundai considered this a safety issue since the brake lights are always on, so the driver behind my car never knows what I'm doing. This has also affected the interior overhead light which only intermittently goes off when I close the door, so I have to keep the light in the off position.

The contact owns a 2011 Hyundai Sonata. The contact stated that the dome light failed to deactivate and remained illuminated. The contact then stated that he had to manually deactivate to turn the light off. The vehicle was not diagnosed or repaired. The dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 63,500.

My vehicle should be covered under a recall for my engine, however Hyundai is denying the claim due to my title being branded as salvage, however according to my research a salvage title does not affect the recall. I believe my engine should be replaced, and Hyundai is refusing to return my calls at this point.

I have a lot of paint chips on car. I see a lot of 2011 same model have the same problem. Most of the paint chips are coming from top of my windshield. I have complained a few years ago also hoping that this issue can be solved.

The vehicle dash and center console lights flicker and/or dim between bright and dim lights while the headlights temporarily turn off at random intervals while driving. This random, but frequent occurrence happens often when applying the turn signal in either direction. The problem generally exist between 1 to 5 seconds, causing impaired driving during nighttime operation. The turn signal appears to work as expected during the electrical issue. The vehicle is available for inspection upon request. This safety issue can impair nighttime driving visibility which can result in an accident, distracted driving to the primary vehicle driver and other motorists, and false driving signals to other drivers. This issue has been reproduced by an authorized Hyundai dealer and other drivers with similar Hyundai Sonata GLS model years. The following online forum is 1 example that provides driver examples and descriptions of the same issue with the same model and year as well as other vehicle model years: https://www.carproblemzoo.com/hyundai/sonata/headlights-turn-off-while-driving-problems.php The vehicle has been used as a daily driver under normal driving conditions and has been maintenanced and inspected by an authorized Hyundai dealership for recalls, service, and the mentioned electrical issue. There are no warning lamps prior, during, or after the electrical issue occurence.