2020 Hyundai Santa FE complaints

The airbag light comes on intermittently when a passenger is sitting in the front seat. Took to a LaCrosse WI Hyundai dealer for OBD code. The dealer reported the following: “Body Elect Concern. ODS ECU and Seat Mat Failure. Inspected found code b149000 found code due to ECU failure. Tested seat mat and found mat also failed due to high resistance outside of spec range. Repair estimate given at $2,800.00.

I was backing out of a parking spot and suddenly the car accelerated backwards into a wall. The floor mat was NOT on the accelerator pedal. Obviously, I might have accidently pressed the gas pedal. But, I strongly believe I did not. For me to be mistaken, all three of the following would have to be true: 1) I would have had to put my foot on the accelerator by mistake, even though I am of sound mind and body, I was not distracted, and I have been driving for decades without having done such a thing. 2) I would have had to continue holding my foot to the gas pedal even as I felt myself racing backwards. 3) Having slammed into the wall, I would have had to be unaware that I had caused the accident. That all three conditions were true seems highly unlikely. (Not impossible. Just unlikely.) I can't imagine stepping on the gas when I meant to step on the brake and then not realizing that I was doing so and then not remembering that I had done so. Cars have computers and computers sometimes have bugs. It seems more likely that a computer glitch caused the crash. And, I suspect that, if it has happened to others, they did not report it because they assume they would not be believed. (When I told a friend of mine what had happened, he told me that, on two separate occasions, he applied the brakes on his Hyundai (a different model) only to have the engine rev up and "fight" his braking. He had to press harder on the brakes to stop his vehicle.) Question: does the onboard computer reco

Engine oil disappear at 2,000 miles. Car dead stop while driving without any warning ⚠️ break fails at 95 degrees curves. Steering wheel loose and make noise. Hyundai dealer refused to fix the issue.

High utilization of motor oil. Using 1 quart of oil every 300miles. Hyundai dealership (Gurnee Hyundai-Illinois) completed a "combustion system cleaning" but oil consumption continues unabated. Getting run-around from dealership and manufacturer. I am original owner. Care has 87K miles.

The contact owned a 2020 Hyundai Santa FE. The contact stated that after the vehicle was unoccupied and parked in the residential carport, she was in bed for the night and four bystanders stopped outside the contact's residence. One bystander knocked on the contact's door, the second bystander ran to the back of the house to search for a rear entrance to enter the home and the third bystander grabbed the water hose and attempted to extinguish the fire but was unsuccessful. The contact mentioned the parts of the vehicle exploded. The fourth bystander called 911 and the contact evacuated from the home. The contact did not sustain injuries. The contact mentioned the bystanders did not sustain injuries either. No medical attention was sought. No police report was filed. The fire departments arrived on the scene, and the firefighters extinguished the fire. The fire consumed the vehicle in the carport and the fire spread to the house causing damage. Fire department reports were filed but no report number was available. The vehicle currently remained on the scene. The insurance company deemed the vehicle and her home totaled. The manufacturer was made aware of the failure and an inspector from Progressive Insurance in addition to an inspector from American Modern Home Insurance out to the contact's residence after careful review they could not discover a product defect responsible for the vehicle incident. The failure mileage was 61,000.

Check engine light began flashing suddenly as I was driving. My vehicle went into limp mode on the interstate in 70 mph traffic, it was dark and pouring down rain. The check engine light was no longer flashing when I went the next day to take to the dealership to be checked. They stated nothing can be done unless it is flashing when I bring it in. This is the 3rd time it has happened in this vehicle, and I have taken in on other occasions with no resolution. This puts my family and I at risk. This appears to have same issues as my previous vehicle a 2014 sonata limited 2.0t.

Front passenger seat belt will no longer click and lock into place. When held in place by hand, the warning lamp turns off and the audible warning alert turns off. It has not yet been checked by any service department.

The backup camera will sometimes have black lines and flash off/on while in reverse. Other times, it will display a solid blue screen and the camera doesn't show an image at all. I took it to the dealer and since they weren't able to replicate the problem, they didn't look at it. I showed them a video I recorded, but that wasn't good enough. It's happening more often and seems to mostly occur after the vehicle has been parked outside.

PASSENGER AIR BAG WARNING LIGHT COMES ON WHILE DRIVING WITH A PASSENGER SITTING IN THE FRONT PASSENGER SEAT.

The vehicle seat caught fire overnight, Sept 26th, and was discovered the morning of Sept 27th 2024. The fire was contained to inside the vehicle and melted parts of the driver seat and lower part of steering wheel. The vehicle interior was covered in orange dust and had extremely toxic smell inside. Insurance 3rd party inspected and declared it a total loss. A few weeks later, a neighbor and fellow Hyundai SantaFe owner mentioned that he had heard of an issue with the Santa Fe catching fire. With this new information, I called Hyundai to alert them. Hyundai opened an investigation, but closed the claim since the 3rd party that declared it a total loss had already sold it as salvage. They also denied any recalls pertaining to my specific vehicle or knowledge that electrical fire was a potential issue for this model and year. There was a recall for a tow hitch that lead to fires....but mine did not have a tow hitch. Obvious concern is that this could be a wider issue than just 1 vehicle and lives and property of those owners and others could be at significant risk.

Back up camera glitches. Causes driver assist to take control at times when not necessary. Have has this in for service at least 4 times since purchasing vehicle in 2020. Service states repaired each time bit eventually happens again. This last time is getting more severe cause multiple electrical short in Overhead lights, Panoramic roof failure to close at times and rear hatch sometimes only partially opens. I saw recent recall for 2021 and 2022 Santa fe's, I believe this problem is what is happening with my 2020 Santa fe and the scope of the recall should be expanded.

The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving at higher speeds, the vehicle experienced a momentary loss of motive power. The check engine warning light was illuminated. An unknown local dealer was contacted, but the vehicle was not diagnosed or repaired due to the cost. The contact stated that prior to the failure, the vehicle was taken to Auto Zone where a diagnostic scanner was used to diagnose the vehicle. The contact was informed that the MAP sensor had failed and needed to be replaced. The vehicle was taken to Advance Auto Parts where, the DTC code: P2565; was retrieved. The contact stated that the spark plugs, and the MAP sensor were previously replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,363.

While driving down the highway my car started slowing down and would not accelerate. All the lights came up on the dash board and would not let me accelerate. I had to merge 2 lanes to the shoulder on a busy highway where my car ended up dying and would not turn over. I was concerned for my safety and the speed limit was 70MPH and my car rapidly went down. After 5 minutes my car came back on and then immediately stopped working again. I had my car towed to the local Hyundai dealer where they said I would need a new engine on a 4 year old car. My make and model are in the recall for engine issues but my VIN # was not included. I spoke to Hyundai a few times and they stated there was nothing they can do and we needed to pay for the new engine.

Vehicle has developed excessive oil consumption. No leaks to be found. Using approximately one quart a week.

The park break keeps turning on by its self, rather I'm driving or sitting at a light or stopped at a stop sign. Putting me and my passengers as well as the other motorist on the road at risk for collision.There is an orange EPB light that never goes off that came on about two months ago, and the emergency park break started being engaged without me engaging it after last driving the car, every time I get back in the car. A red park break light comes on and continously blinks and that has been happening for the last month and a half. The breaks lock and I have to keep pushing the park break disengage button and turning the car off several times to get it to disengage at some point, while in traffic. I haven't had this problem checked out yet, because it is so costly, but I plan to.

Knock sensor failed while it was raining and at highway speed and caused the vehicle to slow and jerk. After further investigation this has been a recall issue for several years , but Hyundai still has a problem with their Knock sensor and no recall on the 2020 Santa Fe

I parked my 2020 Hyundai Santa Fe in a hospital parking garage on the morning of July 30, 2024. I was getting ready to leave after my doctor’s appointment. I slowly reversed my car and hit a pillar behind me. As I put the car into drive to come forward slowly, the car accelerated forward at a very fast speed. I took my foot off of the gas and kept pressing the brake pedal, but the car kept speeding forward on its own and I crashed headfirst into a concrete wall. The impact cracked the concrete barrier on the outside of the parking garage. The air bags deployed, causing fractures in my sternum and L1 vertebrae. This accident occurred near the elevators/stairs and cars were all around. IF a person had been walking in my path to get to their car, he/she would have been severely hurt or killed. I was able to frantically steer the accelerating car into a handicap parking space and crash into the concrete wall, thus avoiding other cars. If that space was not available, my car could have crashed into another car with people inside. We were just told that the car is going to be totaled. If necessary, it could be inspected before that happens. I thought that I was going to die… the car was out of control. I do not want this to happen to others with this type of car…or put others in its path at risk.

I was driving on the highway going about 75 to 80. My vehicle will start warning me that a car was in front of me when the cars was about 3 to 4 car links ahead of me. The emergency brake will start for at least a mile down the road. Then shut off. It will happen at least 5 times on a 4 hour trip. This really need to be fix before someone get rear end.

While driving on the highway loss of power and all the light on the info area lit up had to pull over on shoulder and shut off car and restart. And on two separate occasion while on low speed local road brake pedal locked up and I could not stop the car using the brake it was like it was press down already and I was unable to stop.

Twice while driving in traffic my vehicle’s engine randomly shut off. This left me in very unsafe conditons as one as at a busy intersection which resulted in cars going around me while I attempted to restart my vehicle. The problem hasn’t been reproduced by a dealership. The vehicle hasn’t been inspected. No warning lights or dtc. First failure was 6ish weeks ago.

Prior to these occasions, the Hyundai Santa Fe was constantly needing oil added. On top of that, starting on [XXX], my 2020 Hyundai Santa Fe coded with a check engine light blinking in the upper right corner of the dashboard. I was on [XXX] in NW Indiana on my way to a meeting. The SUV would not accelerate past 2,000 rpm and bogged down on a national interstate sending me into a panic. I had my car towed back to my house. I called my brother in law, [XXX] , who sold me the vehicle in November 2020, to get advice on what to do next. I was told to have the vehicle towed to the nearest dealership. After having my car sit there for two weeks, Webb Hyundai finally looked at it. They upgraded the knock sensor software and had the knock sensor replaced. With the plethora of things that I asked to be repaired or looked at, they only fixed the knock sensor. Due to an extended warranty, I paid $100. Two days later, the SUV got a flat tire. The SUV sat for a week or week and a half due to a flat tire and the place not having it in stock. [XXX] driving back from getting my new tire put on in Valparaiso, Indiana, the vehicle coded again on [XXX]. It caused another very dangerous situation as the vehicle slows to 2,000 rpms. Once again, I had the SUV towed back to my home in Cedar Lake, Indiana. It sat for a few days while I was deciding my next move. This time, I had the vehicle towed to Gerald Hyundai, where my brother in law works and where the vehicle was originally purchased. The vehi

Front drivers side wheelwell cover come off on the highway, I could have had a wreck

On Interstate 95 in Virginia, multiple times, going ~68-70 MPH the vehicle automatically applied the brakes causing an unsafe situation with a momentary loss of control. Multiple times this has happened with no other vehicle or obstacle in front of, or beside me. It has happened now for no reason causing the loss of control of the vehicle. We have reported this to Hyundai and they cannot find any fault code, or record of the incident. Our understanding is that this is a widespread problem with this vehicle and system, but also includes other vehicles with the same technology. We are afraid this may end up causing serious damage, injuries or fatality(ies). We have asked Hyundai to turn the system off, and they have refused. They have no solution, and we have spent time and money on this.

The contact owns a 2020 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle suddenly lost motive power. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that one bolt on the fuel pump was sheared off and another was extremely loose. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 63,000.

Sunroof spontaneously exploded while driving on the highway. There were no other vehicles around and nothing visibly seen that hit the roof.

I purchased this vehicle in early 2023. I was driving on the interstate and received a TINY rock chip that immediately cracked across my entire windshield in April of 2023 resulting in my replacing the windshield. I have since received two TINY rock chips one on 11/25/23 and one on 01/03/24 resulting in immediate cracks. the rock chips are barely visible and as soon as it was heard each time, the windshield cracked considerably. The windshield is faulty and defective. I have driven the same interstate for the last 10 years and have never had this issue with any other vehicle.

La guagua a tenido problemas con el tren delantero. Comenzó con un sonido en el Guía. La Hyundai le reparo esa pieza y luego continuó con el mismo ruido. Ahora tienen que cambiarle el Rack and Piñogn. Mi guagua tiene solo 19,750 millas creo que vino mala de fábrica.

The contact owns a 2020 Hyundai Santa Fe. The contact stated while attempting to drive from a complete stop, the accelerator pedal was depressed, but the vehicle failed to respond. The contact stated that he shifted to park(P), turned off, and restarted the vehicle, and the vehicle responded as needed. The contact stated that the failure had recurred 5 times while driving. Additionally, the contact stated that the immobilizer warning light was illuminated. The vehicle was taken to the dealer three times; however, the dealer was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 30,595.

The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the check engine warning light flashed on the instrument panel, prompting her to pull into a parking area and contact Roadside Assistance. The vehicle was towed to the dealer, who diagnosed a failure with the knock sensor. The vehicle was repaired, but the failure reoccurred. The vehicle was again towed to the dealer, who diagnosed a general failure with the engine, requiring a replacement engine. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 14,500.

My engine light came on December of 2022. I took it to Autozone and had them to a diagnostic text to read the code. They stated it was a misfire on 3. My vehicle was also burning oil. I took it to the dealer(Napleton). They changed the spark plug. That didn’t fix the issue. I took it back because the check engine light came back on. Napleton Downtown Chicago, IL, kept the vehicle for 5 months because they stated they had to replace the engine. About 2 weeks ago my check engine light came back on. I made an appointment to take it into to Napleton Downtown Chicago on November 27, 2023. Yesterday November 22, 2023, my vehicle cut off, started smoking and didn’t cut back on, I had to have it towed to Napleton in Urbana, IL. Clearly this vehicle is having engine problems. I been telling Napleton Downtown Chicago that there’s a defect with this vehicle and to replace it. Please look into for me.

On 01/21/2023 after exiting thr highway and pulling into a shopping center signals started popping up on my dashboard and ny car lost speed. I tried making it down the rd to a tire discounters but ny car lost complete power and would not turn on. A tow truck toad it to the tire discounters and once on the flat bed it was a puddle of oil and a trail of oil coming from my car. Once there tire discounters states that my car needed to go to a dealership. It set at kerry hyundai Alexandria until may 2023 waiting to be diagnosed. Once diagnosed it stated that ny car was missing the drain plug and that I needed a brand new engine. I had a oil change at car x on 12/10/2023 and hyundai blamed car x stating that they didn't tighten my plug. But car x denied. I got a lawyer n began to sue car x when car x lawyer responded stating that there were other people having the same problem and hyundai was being investigated. My car is currently still sitting at hyundsi because I don't have 7800 for a engine and hyundai will not cover the engine under warranty

The metal cable that holds the spare tire snapped off while the car was driving out of our driveway. And the tire flew off the car nearly causing it to crash.

After having a warranty repair for a valve cover gasket' at CENTEREACHHYUNDAI, I picked up my car. Only 8 minutes into my drive home the engine light went on and engine error code appeared. At that piont smoke was coming from the hood when I heard a pop and flames appeared at my passenger side window. I turned the car off removed my phone and exited the vehicle. No one else was in the car but within minutes the fire was totally involved. I also noted it took the fire department very long to arrive. If anyone was trapped in the car they would have peristed.

Oil leak from oil pan area. Took the car to the dealer twice to get it fix and the problem temporarily stop but now is continuing to leak again. All they did was retighten the oil plug the first time and then the second time replaced the oil plug with a new one. They said it was a bad oil plug washer and now it should stop the leak, but now it’s leaking again. Took notice of the leak when the car was parked in garage overnight and a pool of oil formed under the car again. This is scary because losing oil like this is not normal and if it continue it could seize the engine while the driver is driving it risking the safety of the driver and car.

Numerous different occasions since I bought the vehicle this year in March 2023 when on highway, side streets and even in parking lots with nothing, no cars no objects or humans in front or behind the vehicle my forward collision warning and rear end collision warning has came on which caused the car to break on its own and it is a safety concern. I have been to the dealer numerous times since I’ve bought the vehicle and currently have reached out to Hyundai Motors of America and pretty much got told to suck it up nothing they can do for me as the computer isn’t showing any codes or issues my car has now been at dealership where I bought it for 2 weeks now and no resolution besides come get the car and figure it out on my own and as a single mother with a child with disabilies I don’t know what else to do.

Catalytic converter is failing Lane collision warning failing driver side rear view mirror

Sitting in parked vehicle. Opened the rarely-opened panoramic sunroof. Heard unusual sound,. Looked next day and noticed a stationary glass panel forward of the sunroof had shattered all the way around but had not collapsed (yet--have tape on it to keep it intact until repairs can be made). Hyundai does not consider this to be a warranty issue. The warranty states in the "What is not covered" section: "- Action of road elements (sand, gravel, dust or road debris) which result in stone chipping of paint and glass." Dealer documented it and basically said "too bad". Since the issue being reported was NOT caused by road debris etc., This should be a warranty coverage matter. Similar instances have happened to others (entire sunroof) and has been reported. This glass should be LAMINATED--not tempered--but is not. This could be a major safety concern.

Intermittently when you turn the left turn signal, it will be a delay of 2-3 seconds to actually turn on the lights. Usually it happens in the morning when cold.

Oil pan cracked leaking oil

I had been driving my vehicle for about 5 minutes when I heard what sounded like a loud bang or gunshot followed by the sound debris falling. I realized the front piece of my panoramic sun roof had literally exploded. When I got out to look at it the glass around the hole was pointed upwards so it looked like it exploded from the inside out. The glass had no prior damage and nothing hit it before the explosion. I was on a paved road by myself.

I was driving and heard a sound like an explosion. When I was able to safely pull over, I examined my 2020 Sante Fe and noticed the panel of glass right before sunroof exploded. No rock hit it, just exploded.

235/60R18 Tire leak & brittle texture

The contact owns a 2020 Hyundai Santa Fe. The contact stated while driving out of the driveway, the vehicle unintendedly accelerated at high speed without warning. Additionally, while in traffic, the vehicle started to stall with a delay while accelerating. The contact attempted to shift into reverse however, the vehicle failed to respond with the transmission warning light illuminated. The contact turned off and restarted the vehicle, but the vehicle failed to operate as designed. The vehicle was taken to the dealer who stated that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 35,000.

I was pulling out of a sidestreet and realized a car was coming and used the brake. The Automatic Braking system activated and VIOLENTLY stopped the car. I was only going about 5 miles an hour but the tremendous force from the Braking system caused my rotator cuff and my bicep to tear. It cost me thousands to pay for surgery and physical therapy. I am very worried about all the injuries that this system causes. I have since had the dealership turn it off. I can not risk being injured like that because the car thinks that there will be a collision when I know that my manual braking was sufficient. There was no chance of any accident. I had Hyundai (case # 20962390) inspect the car & they claim (after 4 different inspections) that there is no issue with the system. They also claimed that it wouldn't activate at 5mph but I know that is not true. So if it works correctly, how many people are injured? Before you mandate that the car stop at 65mph, you need to gather more info on how many injuries have occurred.

******* DELETE VOQ ******* THIS COMPLAINT IS BEING MARKED FOR DELETION BECAUSE IT IS REQUESTED BY THE CONSUMER THAT THEY WISH TO HAVE IT REMOVED*DJR ******* DELETE VOQ *******

I was driving on an interstate highway at approximately 75 mph. I had cruise control activated. Suddenly the car dramatically slowed down, accompanied by rapid beeping noise. Luckily, there was no one close behind me.

The contact owns a 2020 Hyundai Santa Fe. The contact state that while driving into the driveway, the engine seized without warning. The vehicle was towed to the dealer where it was diagnosed that the oil drain plug had failed, and the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 43,000. The VIN was unavailable The vehicle was repaired at the owner's expense with no assistance provided from the manufacturer.

The vehicles oil was changed on 3/22/23 at 22,395 miles. Almost 3 months and 1500 miles later when driving the engine seized. No lights came on. Vehicle was towed to Hyundai dealership who said it is the fault of whoever did the last oil change as the drain plug came loose. After doing research it appears that this is a known issue with Hyundai. Also, fresh oil was all over the driveway which was not noticed when car was leaving the driveway.

Car stalling and don't move when it's in a complete stop

The contact owns a 2020 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number:23V181000 (Trailer Hitches) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.