2017 Hyundai Santa FE complaints

At 70,000 miles the Santa Fe was consuming oil at 1.5 quarts per 1000 miles. It is a 2.4 engine. The Hyundai dealership did an oil consumption test and verified the consumption. They want to do a combustion chamber cleaning and have me run it 1000 miles. The vehicle is unsafe because this defective engine could seize up at any time. I am trying to have Hyundai USA replace the engine asap. I have all my maintenance records and two warranties.

My 2017 Hyundai Santa Fe suffered a crankshaft/bearing failure identical to NHTSA Recall 17V578000. Hyundai states my VIN was not included in the recall, but the vehicle has the same 3.3L engine, the same failure, and the same symptoms described in the recall bulletin. The engine has never been replaced. The defect appears broader than the recall VIN range. They are refusing to replace the defective engine.

On November 28, 2025 at approximately 2:20am, I was involved in a multi-car pile up crash on Interstate 85 south near Durham NC. At least 5 vehicles were involved and significantly damaged. At least two drivers were taken by ambulance to local hospitals. Fortunately I was not one of them. I was driving in the left lane of the 2 lane southbound interstate. It happened right in front of me and I had no chance of completely avoiding it so I veered to my left onto the shoulder to attempt to avoid a direct hit on the large Nissan SUV that was now straddling both lanes. I hit the front of the Nissan and the guardrail almost simultaneously at somewhere around 50 to 60mph which caused considerable damage to the front right quadrant and the entire drivers side of my vehicle, but my airbags never deployed and I sustained moderate to significant injury to my arms, shoulders, chest and neck, most likely due to how I was gripping the steering wheel in anticipation of the impact and from the seat belt. I did not require medical treatment at the scene but have since received treatment at home. I believe the airbags should have deployed given my speed at impact and where my vehicle came in contact with both the Nissan SUV as well as the guardrail. I believe this was a clear failure of the airbag system in my vehicle, which has since been deemed to be totaled by my insurance company.

While driving on the highway at normal speed, the vehicle suddenly lost power with no prior warning lamps or messages, placing me and other road users at immediate risk. The engine rapidly began knocking, lost acceleration, then stalled completely. I had to coast to the shoulder, which was extremely dangerous in high-speed traffic. The failure appears consistent with bearing wear and debris circulation described in Hyundai Recall 168 and TSB 17-01-071, which warn that certain Hyundai 3.3L engines can suffer internal metallic debris contamination during manufacturing. This can restrict oil flow, damage the bearings, and lead to sudden engine seizure without warning — exactly what happened in this incident. After the failure, the engine was inspected by a Hyundai dealership, but no oil sample, no debris test, and no photo documentation were provided, even though the recall procedure requires these steps when symptoms match knock/no-start failure patterns. The cause was not reproduced or confirmed by any independent mechanical test; the vehicle simply failed suddenly and has remained inoperable since. The incident created a major safety risk because the sudden loss of power happened at highway speed with no safe way to maintain vehicle control or speed. Based on known recall documentation, the symptoms match the described safety-related engine defect. The vehicle remains available for inspection. There were no injuries or police reports, but the situation definitely could have r

It sounds like the rod inside are hitting need a new engine. Auto shop said need a new engine. Engine has 125000 that all no oil leak no other problems.

The engine seized back in August 2025. The engine stopped working while I was driving on a Main Street and almost caused an accident. Unfortunately I put other drivers at risk when this happened. The engine issue was confirmed and inspected by the victorville Hyundai dealership in California. There was not any warning lamps prior to this.

My 2017 Hyundai Santa Fe experienced a sudden and complete engine failure without any warning signs. There were no warning lights, no check engine light, and no unusual noise before the failure. The engine stalled while trying to start, ran very rough for a second, and then completely shut off. After that, the engine would not start again at all. A certified independent mechanic inspected the vehicle and confirmed the engine suffered a mechanical failure consistent with rod bearing wear or crankshaft damage, which is the same issue described in Hyundai’s known engine safety recalls. I later took the vehicle to a Hyundai dealership. They also confirmed that the engine had failed, but said it could not be repaired under Hyundai’s programs because my vehicle was not listed in the specific recall. I was never notified of any safety campaigns or recalls. I am not the first owner, so the required recall inspections and updates were never completed on this vehicle before I bought it. The sudden engine shutdown created a serious safety risk, especially because there was no warning before it failed. This failure matches the symptoms described in Hyundai’s Theta II engine defect investigations. I am requesting that NHTSA investigate whether this vehicle should be included in the affected group, and whether this engine failure is part of the broader safety defect already identified in many Hyundai engines from the same model years.

Sunroof exploded It sounded like a bomb went off and had my inside cover been opened I don’t know if I would’ve veered off the road been injured or injured someone else in the process. As it is I don’t know where the big huge piece of glass went. I do have pictures I reported it to my insurance company and also to corporate Hyundai. I was shaken up until the next day.

For at least 14 months, the air bag light on the dash is on more often than not. The code that comes up on the OBD shows it's from the passenger side seat sensor. Occasionally, the seat belt indicator will flash when there is no occupant, as well. The car has never been in an accident, and the air bags have never been set off.

The contact owns a 2017 Hyundai Santa Fe. The contact stated that the tailgate and the hood unintendedly lowered after being raised and struck the contact. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was unknown.

Engine failure with no prior warning, such as oil pressure gauge,oil indicator light, or check engine light. Vehicle was at dealership for maintenance and this happened as tech was test driving. Found all oil was lost with no indications of a leak.

SPONTANEOUS PANORAMIC SUNROOF EXPLOSION - SERIOUS SAFETY DEFECT On October 12, 2025, at approximately 10:00 PM, while my 2017 Hyundai Santa Fe Sport was being driven on Interstate 85 near Greenville, South Carolina, the panoramic sunroof spontaneously exploded without any external impact or warning. What Happened: - My son was traveling at highway speed in normal driving conditions and he said it sounded a shotgun being shot at close range. The explosion created a period of dangerous distraction. - There was NO impact from road debris, rocks, or any external object - The sunroof suddenly and violently shattered, making a loud explosive sound - A few tempered glass fragments entered the passenger cabin, by the vast majority blew out of the vehicle. - The incident created an immediate safety hazard for vehicle occupants and for other vehicles who may have been following. - Visibility was not compromised, but due to glass exploding, my son had to drive on the shoulder of the Interstate at a slow speed with his hazard lights on in order to make it safely to an exit. Safety Concerns: - Sudden Loss of Structural Integrity - The sunroof exploded outward without warning - Glass in Passenger Cabin - Tempered glass fragments fell into the vehicle, endangering occupants - Driver Distraction - The sudden explosion and noise created a dangerous distraction at highway speed - Visibility Impairment - Glass debris and the sudden opening affected visibility - Weather Exposure - Immediate expo

I bought this car a 2017 in December 2023. The first time I got the oil change they told me there’s no oil on a stick and then couple months later again no oil on the stick so I took it to my personal mechanic. He said there is an oil consumption problem so you advise me to take it where I bought it from. I had to go up there for 1000 mile test and then a 500 mile which I was low. Seems like every two weeks I had to put oil in it so where I brought the vehicle from told me to go to Hyundai. Hyundai only did one oil consumption test. I have a records of oil changes from Valvoline, my personal mechanic, Tradition Ford and one from Hyundai. Tradition Ford, where I got the car from with disappointment because I had a lot of proof that I was burning oil. There was no leak. There was no smoke at all. Besides it being under 10 years old, I was under 100,000 mile warranty and I had an extended warranty. tradition Ford where I bought it from took that one back however I lost $7000 from the down payment. I bought new tires for it, new battery, remote starter, spark, plugs, and rain guards. I still have all my papers from that vehicle 2017 Hyundai Santa Fe sport 2.4 engine liter.

Engine excessively burns oil. Failed oil consumption test. Hyundai denied warranty claim, citing maintenance neglect, despite oil change maintenance records and documentation.

The contact owns a 2017 Hyundai Santa Fe. The contact stated that the vehicle was consuming engine oil, and there was no indication of an oil leak. While a friend was driving, the vehicle stalled. The vehicle was pushed to the side of the road. The next day, while driving at unknown speeds with the hazard lights activated, the vehicle began making an abnormal sound and then stalled. The TPMS and ABS warning lights were illuminated. The contact stated that the failure was related to Technical Service Bulletin Number: 17-01-047-1. The vehicle was towed to the local dealer, where it was diagnosed with engine failure. The dealer submitted a claim. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 140,000.

Engine failed at 114,000 miles. Burned 2 holes through 3rd cylinder. was almost struck crossing intersection making left hand turn when vehicle stalled and would not accelerate to get back into normal driving lane.

The contact owns a 2017 Hyundai Santa Fe. The contact stated that the automatic power door locks failed to operate as needed. Due to the failure, the contact had to manually unlock and lock all doors inside the vehicle. In addition, the contact stated that the button to unlock the gas cap also failed to operate as needed. The vehicle was not yet diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 72,000.

Per our mechanic: Timing components blew a hole in the valve covers because they were so loose. It is burning massive amounts of oil. Could start with timing components and new valve covers, but it will most likely need a new engine because valve train damage is very likely.

We have continued to experience, over at least the past 6 months, and at least once a week and under all driving conditions, a stalling and unable-to-restart problem with this vehicle. Usually after waiting a short period of time it will restart, but in one case we had to have it towed to the dealer. The engine typically turns over just fine, so it's not a battery or starter issue. In a couple of instances it won't turn over. We've taken it to two different Hyundai dealerships and they haven't been able to diagnose the problem because they aren't able to replicate the problem when the vehicle is in their possession. The situation is becoming increasingly dangerous. The last time it stalled, my wife was in the middle of a very busy intersection. The problem doesn't produce any codes that the dealership can see; when it stalls and we attempt to restart, most of the dash lights that regularly come on when you start it are displayed. I am aware of a recall (uploaded PDF) for the make, model and year of my vehicle but apparently it only applies to certain VIN numbers. When I enter my VIN its shows no open recalls. However, the problem described in the recall is identical to the problem we are having.

At about 105,000 miles the oil ran dry after 800 miles of fresh oil change, it just started using oil no leaks no smoke from the tailpipe.now I have to add a qt every 200 miles and on start up the top of the engine rattles for a few seconds. A loud rattle. I have taken it to the dealership several times they did a engine cleaning and several other things but it didn’t help just cost about 800 bucks. Prior to that we changed oil every 5000 miles. Not always the same place, the dealership, Tess corners auto did quite a few of them. Some by jiffy lube. We don’t take the car on long trips anymore, afraid it will not make it. Karen n Chris

In May 2025, the vehicle (2017 Hyundai Santa Fe) developed severe sluggishness. The vehicle was taken to the dealer and I was told the engine would need to replaced due to a recall. Four months later (week of Sept 14 {exact date not known}), the engine was replaced and the vehicle made available for pickup. I drove it home (8.1 miles) and all seemed normal. It sat in the driveway for approx. one week. On Sept 22, 2025, I drove to the store (8.4 miles round-trip). On the way to the store, the engine light came on. I immediately called the dealership and reported the problem. The car was taken in that night (a trip of 8.1 miles) and left at the dealership. On Sept 23, 2025, I was informed that the intake manifold needed to be replaced (this had caused the engine light to come on) at my cost of approx $1000. The car remains at the dealership (unused by me). Online research revealed that if debris had been found in the manifold, it was to be replaced along with the engine (Hyundai TSB #22-EM-010H DATE JULY 2022). The following has been cut-and-pasted from the web: The issue of the intake manifold not being replaced or cleaned after an engine failure is a direct result of the core defect. When the old engine failed, it likely shed metallic debris and shrapnel. That debris could have traveled into other components, including the intake manifold. If the manifold is not cleaned or replaced, the new engine draws that old metallic debris back in, causing it to fail again almost immedia

Approximately six weeks after purchase, my daughter drove the vehicle to a school event and back without issue—no warning lights, noises, or drivability concerns. Shortly thereafter, when attempting to leave for another event, the Santa Fe failed to start. I attempted a jump-start, only to discover that the engine had seized suddenly and without prior warning. It is available for inspection if needed. This sudden and unexpected malfunction could have happened while driving down the road and who knows what might have happened to include my daughter being seriously injured. The vehicle was towed to our local Hyundai dealer. where the service team confirmed catastrophic engine failure. The Engine has only been inspected by the local dealer. There were no warning lights, noises, or drivability issues prior to the engine failure. This engine failure happened on Aug. 16, 2025 References for Review NHTSA Recall Report 17V-578 – notes crankshaft pin and bearing wear issues leading to potential stall. NHTSA Federal Register (DP24-001) – acknowledges Hyundai’s 15-year/150,000-mile warranty extension via TSB 24-EM-003H. Hyundai KSDS Campaign Info & TSBs – detail warranty extension language for rod-bearing failures. Hyundai TSB 22-EM-006H-2 (TXXM) – illustrates Hyundai’s approach to extending coverage for engine failures. Consumer Reports/NHTSA Records – document similar sudden failures without warning lights in the 3.3L Lambda-II engine.

The engine suddenly seized up on me. Was told by my mechanic that that year and make once they get to a certain mileage gets premature engine failure. I looked it up and that year has a huge problem with this issue.

ABS doesn't work, traction control doesn't work, while it was raining the sensor lights came on and I began to hydroplane almost causing a wreck while driving on the highway. The sensors go off and on the emergency brake won't engage while this sensor is on also. Acceleration stall pulling out in traffic. I'm scared to even drive the suv

My engine failed. Dealership put it through an oil consumption test which it failed. They ended up keeping my car for 3 weeks to build a new engine, add new belts, new spark plugs and new filters to go with the repair. After completing this repair they told me they noticed my air bag light on. They recommended a new sensor to fix it. Which I was to pay $600 for. I agreed to this and had it done. I picked up the car and had it for 3 weeks before the airbag light came back on. I brought it back to dealership. They assessed it and told me the problem actually came from the seat and the total.to repair the whole seat would be $2500+ I am the only owner of this car. It has never been in an accident where the airbag deployed. It is in it's original state. I feel this is a huge safety concern that should be looked into.

This car has oil consumption issues due to a manufacturer defect, design of the engine 2.4L. This has been on going for the last three years and is getting worse. Now is affecting the catalytic converter because of it burning so much oil. The Hyundai dealership will do nothing for me. Now they want $4,500 for a new catalytic converter. I can’t afford a new car and this should be an expense of Hyundai. In my research I have found there are thousands of cars on the road with this issue. They knew about this years ago and just kept making the cars and selling them . They should be helping me and all they are doing is denying that this has a problem. What recourse do I have. Why hasn’t there been a recall?

What component or system failed or malfunctioned, and is it available for inspection upon request? Blown head gasket How was your safety or the safety of others put at risk? Engine overheated and coolant boiled in 110 degree weather. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes by Hyundai. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes by Hyundai. Hyundai states that engine needs to be replaced because the head gasket isn’t repairable on the 3.3L engine. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, engine overheated once and diagnosis was blown head gasket.

Rear camera stoped working

My vehicle we bought from carvana has been jerking/misfiring and now with no warning on freeway it wouldn't give power stalling. There was no warning nothing no lights came up. I drive my kids in this vehicle I've taken it to multiple mechanics they say they couldn't find why it's jerking and it must be a manufacturer issue. I looked online and yes lots of issues with the make and model recall about the crankshaft sensor cause these issues!!!

Subject: Urgent Safety & Warranty Concern – 2017 Hyundai Santa Fe Sport (TSB #21-01-002H) Dear Hyundai Customer Care and NHTSA, I am reporting a serious safety and warranty concern regarding my 2017 Hyundai Santa Fe Sport (VIN: [XXX] , mileage:97,320). The vehicle is exhibiting excessive oil consumption after an initial Consumption test burning 3quarts of oil in 725 miles as well as causing damage to the intake manifold requiring it to be repaired and is consistent with the connecting rod bearing defect covered under Hyundai TSB #21-01-002H. This TSB extends engine coverage to 10 years/120,000 miles for precisely this issue. Despite this, my authorized dealer, Premier Hyundai of Moreno Valley has refused to take immediate corrective action and is requiring me to drive an additional 1,000 miles before performing the repair — a delay that increases the risk of catastrophic engine failure and endangers vehicle occupants and other motorists. Key points: This is a documented defect with a known history of sudden engine failure. TSB coverage and my warranty should apply immediately, without dangerous delay. The dealership’s requirement to continue driving the vehicle is unreasonable and unsafe. I am requesting: Immediate authorization for the engine diagnostic and replacement under TSB #21-01-002H. Confirmation from Hyundai that I am not required to continue operating a defective engine to “prove” the defect. NHTSA to log this complaint as part of the ongoing safety concerns regard

Motor replacement. I had taken my car several times into Hyundai for oil consumption issue. I replaced the recommended parts through Hyundai and ended up having to come right back after being stuck on the side of the interstate due to lack of compression two cylinder two I was told I needed to replace the motor. This has been a very expensive process and I haven’t had the car but 10 months.

My vehicle is a 2017 Hyundai Santa Fe Sport AWD with a GDI Theta II 2.4L 4 cylinder engine. We purchased it in Feb. 2024 with 120,310 miles. Since then we have only put approximately 8,000 miles on it in 17 months. On Aug. 1st 2025 while driving up a hill out in the country the engine suddenly quit. Of course the steering and the brakes failed to operate. However I was able to coast to the next road and barely able to turn the wheel but made the corner and coasted to a stop. Without a nearby corner I would have been stuck on a state highway with many semi-trucks traveling on it. Could have been much more dangerous for my wife and I especially since we had to have the car put on a flatbed to be hauled home. The person who came to haul it checked the battery which was fine. You could hear the starter engage and try to turn the engine but it would not turn one bit. Once home we had a mechanic with many years experience have a look and listen to it. He could not get the engine to move even when trying to turn it by grabbing the engine belts and pullies. By all appearances the engine is seized. No warning lights were one and the oil was checked that very morning before leaving home. The vehicle was using about 1 qt of oil every 200 miles or so. Always used a high quality oil of proper weight/viscosity. Had no visible oil leaks on ground where it was parked every night. Hesitate to spend hauling fees to take it to the dealer 40 miles away if they are not going to do anything but of

Hyundai knows about the excessive oil consumption of these 2.0 Turbo GDI engines. My engine went out while driving my daughter down the road. Had to tow it to the dealer. Dealer is saying no compression on cylinder 3. Also a known issue. There was a massive lawsuit over engines already. Hyundai is no help. Excessive oil consumption has led to my engine going out. This needs to be investigated by safely board and Hyundai.

I am reporting a sudden engine failure involving my 2017 Hyundai Santa Fe Sport 2.0T. At just 68,000 miles, the vehicle experienced catastrophic loss of power due to zero compression in Cylinder 1. The vehicle is equipped with the Theta II turbocharged engine, which has been the subject of previous investigations and safety recalls due to premature failure risks, including stalling and fire hazards. This failure occurred on [XXX], while I was driving on the highway. There was no warning. It put all drivers near me at risk as I had no power, was traveling in the left lane and had to navigate through 3 lanes of traffic to reach the breakdown lane. I request that this case be investigated further as a potential safety risk and recurrence of known issues with this engine type. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driving on main road , car came to complete stop while waiting on traffic light and vehicle loss power , and wouldn’t accelerate. No , dash lights nor sounds were on prior to it loosing power nor stalling .

This vehicle has experienced numerous serious failures, including two engine replacements, a transmission replacement, and persistent safety system malfunctions. The Downhill Brake Control (DBC) system remains stuck in the "on" position, and the traction control warning light stays illuminated. These issues directly compromise vehicle safety and stability, particularly on hilly or wet roads. Despite extensive service at Arapahoe Hyundai in Centennial, CO, these problems continue to return. The vehicle has been in the shop multiple times and was most recently in service for nearly 30 days. My wife was stranded at the dealership today due to the same unresolved safety system failure. Dealer communication has been poor, and repairs are often incomplete, requiring immediate return visits. The repeated failure of safety-critical systems, combined with the inability to resolve the issues long-term, presents a significant safety concern for both my family and others on the road. I am requesting NHTSA to investigate whether this is part of a broader defect pattern affecting 2017 Hyundai Santa Fe models and if a recall is warranted.

The contact owns a Safety 1st safety seat, Model type: Grow and Go All-In-One-Convertible, Model number: CC31-GYY, Manufacturer Date: August 01, 2023. The contact stated that the cloth part that covers the headpiece does not fit. In addition, the insulation part inside the cloth will detach. Most recently, the contact stated that the harness that goes across would become difficult to buckle. It would take several attempts to make it secure. The manufacturer was not notified of the failure.

The car has been consuming all the engine only after 700 miles. This has been a constant issue since December 2024 and the issue has been brought up with Hyundai dealership in Denville, NJ and Hyundai Corporate as well. Hyundai dealership in Denville, NJ performed 2 oil consumption tests, which the vehicle failed both test only after 700 miles as it consumed all the engine oil. They refused to do further investigation or recall the engine as it should be covered under Hyundai TXXI warranty given the Hyundai Engine II Class Action Settlement a few years ago. The vehicle has broken down on me on the highway a few times and has put my family at risk and danger due to the negligence of the Hyundai dealership in Denville, NJ and Hyundai Corporate refuel to resolve the issue. Now the car does not start at all some days thus it has impacted my work and my ability to provide for my family

My car had a thrown connecting rod-the problem described under TSB22-EM-006H-2 (TXXM/6G) which extends engine warranty to 150k miles/15 years for this exact issue my vin is listed my mileage is 113k and KSDS was completed (or I am exempt) please submit prior approval under the extended warranty for engine replacement. Hyundai is refusing to repair my car.

This modle has a serious oil consumption caused by a manufacturerer design issure with the engine. As time goes by the oil cosumption get wores potentially seizing the engine while driving. I have to constantly fill with oil. This is a major safety concern with many hyundai vehicles.

Twice my car's gear shifter went from Drive to the right hand side of the gear box. 90% or more of the power cut out immediately creating a massive safety issue. In both instances, i was pulling into traffic after making complete stops at stop signs. The first time, i turned left, the second time I turned right. The shift was untouched by me as it is not a stick shift car. Hyundai charged me close to $400 for the privledge of telling me that I or something bumped the shifter to the right. Also they claim that the shifter is designed to go into low gear if it does go to the right. a low gear should provide more power not cut it out. They refuse to fix the issue, but wanted me to bring it in so they could duplicate a problem that has occurred twice in four months.

Excessive oil consumption from metal shaving left in engine during production. causes accelerated engine wear and failure. Rod bearing failure. piston ring failure, high chance of fire in engine compartment.

Back up camera operates very erratically. some times it works properly, some of the time it is very slow to engage. other times it comes on after i have completed my rearward movement, and some times it comes on after shifting into drive. then there are times t never comes on. i spoke to a dealer tech and was told there are a lot of them like that. if i wanted to spend about $900, they might be able to fix it. this has been going on for a couple of years.

Excessive oil consumption leading to p420 codes every 2000 miles. vehicle is consuming a half a quart of oil every 100 miles. could cause engine to seize while driving.

Was driving on [XXX] (approximately 130 miles from home), when a loud clunking and metal on metal sound was heard, the causing power loss, slowing of vehicle and necessitated immediate pulling over to the side of the road. The was a catastrophic internal engine failure which caused the spark plugs to blow out. There were no warnings. The car was just inspected and had an oil change earlier in the month. The vehicle suffered sudden power loss and violent metal-on-metal destruction while transporting my child on [XXX] (130 miles from home). Certified diagnostics from Kennett Square Quick Lane Auto confirm: "Multiple spark plugs forcibly ejected due to severe internal engine damage – full replacement required". Quick Lane said they would not be able to replace the Engine. so the Vehicle was towed to Reliable Car Connection (West Chester, PA). I had tried to make an appointment at Piazza Hyundai, but the did not have appointments until Mid August. Result: Stranded overnight requiring hotel and towing/tolls at personal expense (receipts available). This traumatic event directly stems from Hyundai’s acknowledged Theta II defects. Hyundai’s Documented Failures: Recall Compliance: Recall 996 (Piazza Hyundai, 4/12/24) Recall 953 (1/31/19) Recall 163 (7/18/17) Maintenance: All services performed per Hyundai schedules (records available). Unresolved Defects: This failure matches: Recall 20VH4 (Lifetime Warranty Extension) Recall 20VH5 TSB 20-01-033H Current Status: Vehicle at Reliable C

The turbocharger failed on my 2017 Hyundai Santa Fe Sport 2.0T. It is still on the vehicle and available for inspection upon request. The turbo failure caused a severe loss of engine power, making acceleration dangerously slow and unpredictable, especially when merging onto highways or passing vehicles. This sudden reduction in power could have caused a rear-end collision or made it impossible to avoid faster-moving traffic. Yes. The failure was confirmed by two independent service centers: Mavis Tires and Brakes, and Tires and Trust in Pensacola, FL. Both observed loss of turbo boost and excessive oil consumption consistent with turbocharger failure. Yes. The vehicle was also inspected by Allen Turner Hyundai in Pensacola, FL. They did not detect the failure during their inspection, but the issue persisted and was documented by the other two shops. The check engine light came on around 118,000–119,000 miles. After that, the turbocharger lost significant power, making the vehicle unable to accelerate normally. At the same time, the engine began consuming oil at an abnormally high rate, requiring frequent top-offs between oil changes. This suggests internal oil seal failure in the turbo or related component issues. These symptoms are consistent with failed turbocharger bearings or seals, oil starvation, or blocked oil lines causing overheating and damage. Such failures can release oil and metal debris into the intake and exhaust systems, risking further engine damage or even f

The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving on the highway at 65 MPH, the contact heard a loud bang coming from the engine. The contact stated that immediately afterwards the vehicle started losing motive power with smoke coming from the front and the rear of the vehicle. There was no warning light illuminated. The contact pulled over and had the vehicle towed to a local dealer to be diagnosed. The contact was informed that additional diagnostic tests were needed to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage 152,530.

Engine oil excessive consumption. We bought (Sept 2024) this 2017 vehicle used at a Hyundia dealership, beautiful, loaded orange SUV, for my senior college student. We have to add quart after quart after quart of oil in-between oil changes. She hardly drives the car as she walks to class and works 1/2 mile from her Apt. We are scared for her to take even a 2hr road trip due to this issue. She is devasted and scared to drive it much and we are furious that we are stuck with this issue.

2017 Santa Fe, car had fire in 09/2024 and was with dealership until 05/2025. BSD, ABS, TRACTION, and Parking Brake lights on the dash when vehicle was picked up. Dealership not complaint to pay as the assume it is an Outside issue

Engine is consuming large amounts of oil in little mileage. Hyundai case reported but they will not assist. This has been affecting other 2017 Aanta Fe Sports reported on this website! These cars need to be included in oil consumption recalls from Hyundai.