2017 Hyundai Santa FE complaints

The back hatch does not stay up when you open it falls down with no warning

What I was told by the dealer my engine has failed / locked up due to the crankshaft being locked up. I was put at risk because as I was driving at 45mph on the road and the vehicle just shutoff no power, I was able to get to the side of the road and pull into a parking lot. I tried to start the vehicle while after waiting an hour and a half but all i got was a clicking noise. The vehicle is currently at the dealership where the technician has told me there was a recall on the engine of 2017 santa fe acouple years ago and this is exactly the same thing that happened then. waiting for approval for repair. There were not any warning lights prior to this happening. My vehicle only has around 86,000 miles on it

My dealer, Crain Hyundai, North Little Rock, AR, has not performed the recall notices on my 2017 Santa Fe (recall 961 Auxilary Canister Kit and recall 218 ABS system). I have taken the vehicle in three times and they say they don't have the parts. I would like to file a complaint in this regard. Michael Barron

The rear hatch closes automatically even if somebody is under the hatch putting items in the trunk without going back up. This is dangerous especially if children are near the hatch. It also at times opens when the button on the hatch is pushed but does not close automatically. The Hyundai Dealership Alexandria (1707 Mount Vernon Avenue) was uninterested in the issue and said they would charge $370 to look at the problem. Also for the safety recall of the ABS system, the earliest appointment at the same dealership was September 7 even though this sounded like a serious recall.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic). However, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time to complete the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available. The consumer stated was finally able to make an appointment and repairs were made on 01/04/2023.

The contact owns a 2017 Hyundai Santa Fe. The contact stated while the daughter was driving approximately 70 MPH, she heard an abnormal knocking sound coming from the engine compartment and the vehicle suddenly stalled. The vehicle was towed to the local dealer who diagnosed that an internal engine failure had occurred, involving the rod bearing and the crankshaft. The dealer diagnosed that the short block of the engine needed to be replaced. The contact was informed that the VIN was not included in NHTSA Campaign Number 17v578000(Engine And Engine Cooling). However, the contact indicated that the vehicle had experienced the failure listed in the recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 72,000.

From what I was told by the dealer my engine has failed / locked up due to the low bearings. I was put at risk because as I was driving at 45mph on a dry road and the vehicle acted as if I hit the brake and skid, luckily I was able to get to the side of the road and noticed lights on my dash, I tried to start the vehicle while parked and it sounded like marbles so I immediately turned it off. The vehicle is currently at the dealership, waiting for approval for repair. There were not any warning lights prior to this happening. My vehicle only has around 56,000 mile on it. I am aware of the open recall, I received 2 notices about it, but was never notified there was a remedy and to make an appointment. I don't think my recent issue has anything to do with the current open recall. I mentioned to the dealership I was aware of the open recall and I was told they would take care of it while working on my engine issue.

Car was in shop for recall on wheel sensor ,next day the engine stopped working properly .ran really ruff and hesitated .took back to dealer and told 2 cylinders were not running correctly. i was told they would submit the Hyundai for engine replacement. Hyundai denied its under warranty or there problem ,when there is a history or engines failing in the 2017 year .class action lawsuits against them for it.

I was driving the vehicle. Engine started pecking then a loud pop noise came from the vehicle. I stopped beside the road. I saw it was leaking engine oil. I drove it to the nearest mechanic. I was told the valve cover had a hole in it. When the valve cover came in. The mechanic took the cover off and checked the engine . He said a bolt or pin came lose on the crankshaft and broke off pieces of the engine on the inside. I was quoted for a new engine at 11,000 dollars. I said I can't afford that and I was would have it towed home. I had it towed to a hyundai dealer inside at the beginning of June. I told them what happened and left it there. I also filed a claim on the hyundai website. Mid July I got a call saying it was the timing chain and since I had no warranty, and hyundai was not going to cover it. The cost would be about 1,500. I asked them are you sure the mechanic took it apart and checked because I had it looked at already and I was told the crankshaft did it. Two days later I got a call back at was told it was the crankshaft that caused the problem. I needed a new engine. They quoted me a engine replacement from 14,500. I told them I can't afford that and had it towed home. I dont believe they sent the problem to hyundai to see it it would be covered. I bought that vehicle less than a year a go. I have been without that vehicle since May, and I have been out of town for 2 months unable to come up with a solution. I believe this is the same recall that is on the sport

Excessive oil consumption since May 2022. Recently, stalling, misfiring, and engine light just came on. Yes it is available for inspection if needed. Safety risk - leaving me stranded on the side of the road, causing an accident which could possible end in injury or death of myself or someone else, engine fire. Yes, the dealer has identified there is an oil consumption problem by doing 4 oil consumption tests, which 2.5-3.5 quarts of oil have burned within 1,000 miles. No, corporate has not inspected anything, they tell me to contact the dealer. The dealer had performed oil consumption tests but nothing else has been planned. I have had this problem since May 2022, the engine light just came on August 1st, which is because the spark plug has heavy deposits of oil and ash on it from the oil consumption.

When I first purchased the SFS I noticed the shift change was always inconsistent. RPM would jump no matter what the speed was. It slowly started to lose MPG and power. The major issue began with a tapping sound coming from the engine. Shortly after, the CE light came on. Had the sensor replaced and soon after- engine stalls again. Days later, the car stalls while excelerating on the Delaware Memorial bridge. The most horrific detail about this incident is that my 5 year old was in the car and it was 5pm rush hour traffic. We were “lucky” enough to coast to the end of the bridge to be able to pull over. Without a proper place to pull over, we were almost hit by a semi who noticed my vehicle seconds before ramming into us. It was the most helpless feeling to not be able to get out of your vehicle and walk to safe location. I will not risk driving my vehicle even a mile. I fear that my vehicle will be the cause of an accident and I can’t bear to think of what would happen. I still do not have an answer to what is causing this issue. Scanners do not pick up any issues and the CE light is not on. All fluids are good and battery was replaced 6 months ago. I’m at a complete loss.

The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving approximately 25 MPH, the vehicle started losing motive power, then started jerking before independently accelerating. The contact also stated there were times when the vehicle inadvertently lost motive power and stopped. The contact would then restart the vehicle and continue driving. There were no warning lights illuminated. The vehicle was taken to the local dealer but was diagnosed with no failure being found. The failure reoccurred often. The vehicle was also taken to another local dealer who diagnosed the vehicle but also found no failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 73,399.

Sway bar and struts continuously malfunctioning causing brake system to fail quickly.Engine more than 5qts a biweekly causing the maintenance numbers to malfunction.Seat belt light keeps going on and off even when in use.These problems are causing a safety risk due to them failing and can cause harm to driver/drivers on the road.Electrical issue has the brake lights malfunctioning and cause harm to others as well.Vehicle has been inspected by Hyundai dealership .Seat belt light continuously come on and off.

This will be my second report to the NHTSA. I was originally told my car needed a new engine, but then it was confirmed that was not the issue since the car started and drove just fine, the recall for the ABS mod was brought up to two different Hyundai dealerships and their corporate office, I requested if it could not be fixed to buy back my car. It was denied. My car then caught fire while driving, resulting in my husband almost dying on the highway. Fire shot from the bottom of the car up into engulfed flames within seconds…and then blew. Determined it was an electrical engine fire. All could have been avoided if Hyundai had just listened to my concerns and checked my ABS. However due their refusal to do so, and refusal to inspect my engine for the recall, my family, kids included were put at risk. It seems to be happening all over the world with these cars and NOTHING is being done.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

When accelerating onto the freeway the vehicle made a clunk sound and lost speed by going into limp mode when the check engine light flashed. Thankfully I was close to my exit and was able to safely get off the freeway. I called the Hyundai dealer service and they said to have it towed to them at my cost. The dealership looked it over and said I need a new engine due to oil spilling into all the cylinders. It has 87,000 miles on a 2017. Regular oil changes and just did the 80,000 miles service and spark plugs with this dealer a month before. Hyundai is refusing to pay for the remanufactured engine replacement of $7,000. No loaner car is available either. It has been 3 weeks and still isn't done.

Saturday June 25th: Driving on I-495 North in Middleboro, MA and heard a loud clunk. All dashboard lights went on and I immediately pulled off the exit. By the time I got off the ramp, my steering and brakes had locked up and I barely made it through the intersection and pulled to the side of the road. Immediately the car started smoking and a puddle of oil formed under my car. The car was towed to a local car lot. Saturday June 25th PM: I filed a claim with USAA Insurance. Monday June 27th - July 1st: USAA in touch and sending an adjuster to the lot. Tuesday July 5th: I signed a release for the car to be towed to Hyundai of Auburn, MA Wednesday July 6th: Car towed to Herb Chambers Hyundai in Auburn, MA Friday July 8th: Hyundai dealership calls and reports that accident was likely due to a rod being released from the engine and causing damage to the rest of the engine and oil pan. They report they have “100 cars on the lot with the same problem and anticipate 4-5 months at least until the car is diagnosed and fixed.” They report they have no cars to loan or rent to me. They suggest I call Hyundai USA.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated while driving 25 MPH, the vehicle stalled. The contact stated no warning light was illuminated. The contact was unable to restart the vehicle. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the rod bearings replaced. The vehicle was not repaired. The contact called a second local dealer, Pearson Hyundai (11701 Midlothian Turnpike, Richmond, VA 23113: (804) 276-0300) and made them aware of the failure. The vehicle was not repaired. The manufacturer had been informed of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 114,000.

LEAKED TANK OF GAS. GAS LINE RUPTURED

Oil consumption excessively after every few hundred miles; caused engine to stall. Engine knock heard. Caused engine to fail.

My Hyundai Santa Fe 2017 has an acceleration / pedal issue which has left me stranded in the middle of traffic several times. This is a safety concern as it has left my acceleration unresponsive on highway at times. It takes about 60-90 seconds for the acceleration pedal to respond again. The issue does not seem to be at cold/warm conditions of the engine. No check-engine code nor fault codes have been prompted. I have taken to the dealership 4 times in Long Island with multiple revisions of the vehicle and they advise they have not been able to reproduce. The issue keeps coming back unpredictably and my vehicle is still under full warranty with less than 40k mileage. All of my family members have attested to this safety issue and I am dumbfounded that this has not been prompted as a safety recall / concern by Hyundai.

The contact owns a 2017 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle made loud knocking noises. The vehicle was towed to an independent mechanic who diagnosed the vehicle and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to take the vehicle to the dealer for a diagnostic test. The failure mileage was approximately 100,000.

This last 07/08/2022, my car was for RECALL 218, in Kendall Hyundai, Miami Florida for ABS, my car never have problem before in 5 year. When I am driver for my home after work the light for warning is ON ABS line and other one too, when i go for the dealer the next Monday the dealer said me, i have to paid $ 1106.00 for the two rear sensor have problem, for each sensor is 42.00 dollar but the rate is the difference for repair my car, is unavailable for the same problem, i think about keeping my car and buying a new Hyundai Santa FE ,but i don't feel comfortable with this situation.

2017 HYUNDAI SANTA FE. CONSUMER WRITES IN REGARD TO PARTS BEING UNAVAILABLE TO PERFORM SAFETY RECALL 218

My vehicle has been consuming oil. I have had to put quarts of oil in my car weekly. The vehicle isn't leaking oil, but is burning oil. Contacted dealer and was informed that it's the type of engine and no redemdy. Car smells like it's burning. This has been an ongoing problem for the last two years.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Two attempts to have fuse replaced resulted in being told we have to leave car all day. We have one car, and live ten miles away. They said they shuttle only up to five miles. We are senior citizens and have purchased our last two cars from Hyundai. We cannot take advantage of the recall

Engine burns oil.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

Engine lost power while on freeway and a piston fired through the engine producing a hole and causing fire to travel through the exhaust system.

2017 Hyundai Santa Fe. While driving, the vehicle stopped accelerating. The vehicle operated appropriately until half way through the drive. At stops, it would take several seconds (30ish) for the car to go about 20 mph (rough estimate). The car would not go above 50mph, and this took a few minutes to reach with the gas pedal all the way down. I parked the car and had it towed. After approximately a month at the dealership, the dealership text that there was a hole in the valve cover and that the engine would also need to be replaced. They did not say what was wrong with the engine and later stated, also via text, that to do a diagnostic it would be $350. I purchased the car used with approximately 45000 miles 10 months prior. At the time of the incident, there were 62000 miles on the vehicle. They stated that it would not be covered under warranty because I was not the original owner. I purchased the extended warranty at the time of purchase. They then filed a claim with that policy and we are awaiting an inspector to look at the vehicle. There were no warning lights prior to the issue. My family, husband and 3 children were in the car and it was dangerous because we were on a busy road and the car would not go to the speed of traffic. We are awaiting an inspector to look at the vehicle. The vehicle is currently still at the dealership. If requested, I am willing to have the car inspected. The incident occurred 5/12/2022.

The contact owns a 2017 Hyundai Santa Fe. The contact received a notification for NHTSA Campaign Number: 22V056000 (Service Brakes; Hydraulics); however, the parts for the repair were unavailable. The dealer had been notified about the recall and confirmed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Vin tool confirms parts not available.

My wife was driving down Hwy 105 west in Montgomery, Texas on a 6 lane highway when all of a sudden our 2017 Hyundai Santa Fe lost power at 65mph. She could not accelerate or maintain speed and noticed several light quickly flash and then shut off. She steered into the center median and stopped in order to try and restart the car. There was no warning to this issue and the Santa Fe could not be restated and had to be towed to Weisner Hyundai in Conroe Texas to be diagnosed. It was revealed the knock sensor that was supposed to put the vehicle in safe mode so engine damage would not occur, failed with no warning which caused excessive bearing and rod wear causing the engine failure which could have caused an wreck on the road. The Weisner Hyundai in Conroe inspected the Santa Fe and mentioned the state of the engine showed it was well maintained and no signs of sludge in the engine. There were no warning lamps on the dash or symptoms with the engine leading up to this issue. This is a major safty risk is due to the immediate loss of engine power which other cars had to quickly swerve to miss my wife as she steered to the middle median. Weisner Hyundai elected to process a PA claim with Hyundai with photos and a full report. As of today, I have do not have the full report as the service center was still in the process to filing their report.

My family was driving down the interstate at approximately 78mph when the engine light came on and the vehicle began to rumble intensely. After letting off the gas to approximately 50mph and touching the gas once more we realized the vehicle was not operable. We pulled to the side of an active interstate and awaited towing. We were in this spot for almost an hour hoping my wife and children were not struck by a vehicle. Additionally, as the vehicle broke we were concerned about being hit on the active interstate. Oil had been recently changed, maintenance was always kept up-to-date, no dash lights were on, and we had experienced no prior problems with the vehicle or engine. Vehicle has been inspected by a mechanic shop and a warranty representative, both of which stated the engine was dead. It now sits with a Hyundai dealership for further diagnostics testing.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The dealer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. The VIN was not available.

Recall 22V056000 has been open and unresolved since Feb2022 and the recall remains incomplete four months later.

The check engine light came on one day and then before I could take it in to be checked, about two days, the light had turned back off again so I thought it was fine. Then, I was driving 2 hours from my home and on the way back the engine started to make a terrible knocking and screeching noise. It seemed like it was going to break down. I was on a country road so I quickly turned around and made my way back to a truck stop about a mile away. I had to pay to get the car towed to my local dealership an hour away. While at the dealership, after inspection, I was told it was a Rod Bearing Failure in my engine. This absolutely put me at risk as I was driving a far distance and an hour from my home. The dealership then got my service records and gave them to my extended warranty carrier- Assurant. They agreed to cover the over $10,000 cost with just my $50 copay. The car now has a different, used motor in it. My concern now is that I have had the same problem that other Santa Fe's have had in prior years but this one doesn't have a recall. Now, I'm driving with another one of these motors with worries that I'll have the same problem as before and be responsible for the fix. I asked the dealership and Hyundai USA case manager if they would warranty this new to me, used motor AND reimburse me for the 40 days that I had to pay for a rental vehicle and was told NO.

My O2 sensor failed and is under my insurance investigation due to engine light that came on and upon inspection it was determined to have caught on fire under the vehicle. My safety and my children's were at risk potentially may have gone up in flames. Currently the insurance is pending review of any recalls for O2 sensor to determine if Hyundai is handling damages. At this time Hyundai has not taken responsibility.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The dealer had been notified about the recall and confirmed that parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

While on a road trip, the engine light came on. A further check at a Hyundai authorized mechanic showed the engine had suffered from high oil consumption and ran low on oil. There was no obvious oil leak. As a result, I must replace the engine and I am unsure if Hyundai will cover the cost.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The dealer had been notified of the issue and confirmed that parts were not yet available. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

Just received another letter from Hyundai (First one in Feb./March this one in June) telling me about the same problem with the ABS System and how it might short out and cause an engine fire. STILL NO REMEDY! The letter said I'd receive a second notice ...I guess they meant a third notice! What's taking so long to find a fix??? I'm supposed to be confident taking this vehicle on a trip knowing it may short out and cause a fire at any time while driving or parked!?? This is not acceptable.

My 2017 Hyundai Santa Fe with approximatelh 118,000 suffered a catastrophic engine failure. According to the dealer where the car was towed, CVVT on the camshaft caused further damage to the engine. Recommended solution is engine replacement. Dealer is quoting approximately $13,000 + taxes and fees for this replacement. I have opened a case with Hyundai and contacted my insurance company regarding possible recourse. The dealer has indicated the 10 year/100,000 mile Powertrain warranty will not cover the engine replacement as the care has 118,000 miles. There were no preliminary warning signs of engine failure. Just minutes before the car starting leaking a ton of oil, the Check Engine and Oil indicator lights went on. Car has been meticulauly maintained and serviced over the years. The car is currently at the dealer, and I have no replacement transportation provided for this vehicle. While there were no injuried, I can imagine that had I not been in a position to have the car towed, the engine failure may have resulted in dangerous driving conditions.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulics) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect. The contact has stated that the dealer addressed the recall issue and the vehicle works fine.

Losing about 1QT of oil every 1k miles. The local Hyundai dealer acknowledged the issue but has no remedy. Their suggestion is to add a QT of oil at every 3k and check the level every 1k mile. I do not feel safe driving this vehicle as the engine also makes loud noises

I was driving the vehicle at highway speeds, when I attempted to pass a vehicle, the engine started making a knocking sound. I had the vehicle towed to the Hyundai dealership. When they did their initial inspection, there was no oil in the engine. The engine oil had been changed by a reputable dealer within 3,000 miles. The vehicle is well maintained and regularly maintained. No warning lights came on to indicate low oil or any other warning light to indicate any problems with the engine at all. Manufacturer has 10yr 100,000 mile warranty for first vehicle owner, but the warranty for second owner is 5 yr 60,000 mile. There are known issues with this engine and other Hyundai GDI engines. Dealership gave me a repair bill for a used engine replacement with labor of $12,650. Manufacturer says they are not responsible for the engine since it is out of warranty (although within original manufacturer warranty). The GDI engine is faulty and dangerous. A 5 year old vehicle burning 4 quarts of oil within 3,000 miles is not user error, thats manufacturer fault and they should be held accountable for it.

The contact owns a 2017 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The contact had not experienced a failure. Parts distribution disconnect.

Engine failure due to "rod failing". Car lost power and RPMs. Mileage was 119325. Car always serviced at dealership. Dealership recognized the issue and referred me to customer service. Case File #1959318 was files with Hyundai Customer Service. They rejected any assistance in replacing engine citing that it was more than 10% over 100,000 miles. Replaced used engine cost $10,146.04. Thomas Cumberland Invoice 6035219 (Mar 28, 2022)