2012 Hyundai Santa FE complaints

CAR ENGINE COMPLETELY DIED WHILE ON HIGHWAY WITHOUT ANY WARNINGS I AM CHOCKED MY CAR HAS BEEN PERFECT UNTIL NOW MY CAR BARELY PASSED 100,000 AND BOTH WARRANTIES EXPIRED ALSO BODY PANT IS CHIPPING OFF.

NHTSA REPRESENTATIVE, I AM WRITING TO INFORM THE NHTSA THAT OTHER HYUNDAI'S ENGINES OUTSIDE OF HYUNDAI'S 2012 AND 2013 ENGINE RECALL ARE EXPERIENCING THE SAME ENGINE FAILURE DUE TO ROD KNOCK, WHICH POSES A SEVERE SAFETY RISK AND THAT HYUNDAI IS NOT HELPFUL IN ANY WAY WHEN REPORTING THIS. OUR VEHICLE WHICH FAILED ON US 40 IN THE SMOKY MOUNTAINS IS A 2012 HYUNDAI SANTA FE VIN # #[XXX]. ON APRIL 10TH AT 6 PM WHILE TRAVELING ON US 40 IN THE SMOKY MOUNTAINS NEAR CHANDLER, NORTH CAROLINA IN OUR 2012 HYUNDAI SANTA FE TOWARDS OUR HOME IN DOWNERS GROVE, IL., WE BEGAN TO HEAR A KNOCKING IN THE ENGINE AT ANY SPEED GREATER THAN 65 MPH. SINCE WE WERE TRAVELING ON THE HIGHWAY WITH NO PLACE TO SAFELY PULL OFF SO WE SLOWED THE VEHICLE TO 60MPH HOWEVER THE KNOCKING SOUND BECAME WORST AND THEN THE CAR WOULD NOT GO ABOVE 55 MPH WITHOUT A TERRIBLE LOUD KNOCKING. THIS WAS OF COURSE VERY SCARY AND UNSAFE. WITH HAZARD LIGHTS ON, WE WERE ABLE TO EXIT US 40 IN CHANDLER NC ONLY ABLE TO DO <30 MPH AND THE VEHICLE DIED IN ENTRANCE OF THE SUNOCO GAS STATION IN CHANDLER NORTH CAROLINA. DURING THIS WHOLE TIME NO CHECK ENGINE OR ANY EMERGENCY LIGHT WARNED US OF THE ENGINE MALFUNCTIONING AND THE SAFETY RISK WE HAD ENCOUNTERED WITH THE ENGINE DYING. THE SANTA FE WAS TOWED TO THE HYUNDAI DEALERSHIP OF ASHEVILLE, NC AND DROPPED OFF AT 11PM WHERE IT WAS FOUND TO HAVE BAD ROD KNOCK AND NEEDING A NEW ENGINE. HYUNDAI SHOULD BE HELD RESPONSIBLE FOR THEIR ENGINES THAT PUT THEIR CUSTOMERS AT RISK AND 2012 SANTA FE ENG

TO WHOM IT MAY CONCERN ,I CURRENTLY OWN SANTA FE THE PROBLEM IS HYUNDAI IS NOT RECOGNIZE THE PROBLEM WITH THE VECHICLE I EXPIAIN TO THE SERVICE DPT,I ABSORB A JERK LOSES ACCELERATION POWER NEXT ESCINDICATOR DBC LIGHTS COMES ON TACHOMETER GOES 0.THE VECHICLE IS STILL IN MOTION .I TURN THE IGNITIONOFF RESTART THE VECHICLE THEVECHICLE RETURN BACK IN NORMAL STATE SERVICE REPLIED I HAVE TO WAIT FOR A SERVICE LIGHTS.IAM AWARE THAT SANTAFE FIRES BEGINS IN THE ENG ALSO IN THE REAR.HYUNDAI DONT HAVE AN ANSWER THEY WANT ME TO DRIVE IN DANGER.I DONT NEED A TRAGEDY.PLEASE HELP [XXX] THX YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

THE VEHICLE WAS STATIONARY IN A PRIVATE PARKING LOT AT A DOCTOR'S OFFICE. I TRIED MANY TIMES TO START THE VEHICLE. THE ENGINE SOUNDED LIKE IT WOULD KICK OVER BUT DID NOT. I THEN HEARD A KIND OF WHIRRING SOUND WHEN ATTEMPTING TO START THE ENGINE AND NOTICED SMOKE COMING FROM UNDER THE HOOD. I EXITED THE VEHICLE AND OPENED THE HOOD. A SIGNIFICANT AMOUNT OF SMOKE WAS COMING FROM THE LOWER PART OF THE ENGINE. THE SMELL WAS KIND OF ELECTRICAL IN NATURE. I WAS CONCERNED THAT THE ENGINE WOULD CATCH FIRE SO I WENT INTO THE DOCTOR'S OFFICE, ASKED FOR A BOTTLE OF WATER, THEN DOUSED THE LEFT SIDE OF THE ENGINE. I LEFT MY CAR IN THE PARKING LOT AND WAS PICKED UP BY MY FAMILY. I AM QUITE AFRAID TO EVEN ATTEMPT TO START THE CAR AGAIN. I WILL HAVE TO CALL A TOW TRUCK TO TAKE THE CAR TO A MECHANIC. THERE IS NO REASON FOR THE ENGINE TO HAVE SMOKED LIKE THAT.

ADD MY REAR TAIL LIGHT ASSEMBLIES FILLING WITH WATER AND CONDENSATION TO THE LIST OF COMPLAINTS. BACK UP AND BRAKE LIGHT BULBS MUST BE REPLACED AFTER ANY HEAVY RAIN EVENT.

MY VEHICLE SUDDENLY SHUT OFF WHILE TURNING DOWN A CITY STREET AT SLOW SPEED. NO SAFETY/WARNING LIGHTS CAME ON. I CRANKED IT BACK UP AND IT RAN FINE FOR A FEW WEEKS. IT SEEMS TO RUN FINE ON OPEN HIGHWAY BUT AT A STOP OR SLOWER SPEED IT WILL CUT OFF LEAVING ME IN DANGER OF A COLLISION AT BUSY INTERSECTIONS. WITH NO WARNING AGAIN IT DID THE SAME THING AT A RED LIGHT. I CANNOT DRIVE MY VEHICLE NOW BECAUSE OF THE SAFETY HAZARD. I HAD MY TRUCK TOWED TO A GARAGE-THEN WAS ADVISED THAT A HYUNDAI DEALERSHIP WOULD NEED TO FIX IT SO I HAD THE EXPENSE OF TWO TOWINGS. THE HYUNDAI DEALERSHIP HAS NOW INFORMED ME THAT THE COMPUTER CHECK SHOWS A TIMING TOOTH MAY BE OFF AND THAT WITH THE EXPENSE IN WILL INCUR I AM BETTER LETTING THEM PUT AN ENTIRE NEW MOTOR IN. I AM SO UPSET THIS IS HAPPENING DUE IT BEING MY ONLY MEANS OF TRANSPORTATION.

FOR THE SECOND TIME OIL PRESSURE SWITCH HAS FAILED AND NEEDS TO BE REPLACED CAR ONLY HAS 58456 MILES ON IT ANOTHER 420 BUCKS

CAME HOME 8 PM. SON CAME HOME SHORTLY AFTER 10 PM. JUST AFTER MIDNIGHT MY CAR ALARM STARTED GOING OFF (CAR LOCKED AND PARKED IN DRIVEWAY), I GOT OUT OF BED LOOKED THROUGH BLINDS AND SAW MY CAR WAS ON FIRE. I RAN TO KITCHEN GRABBED FIRE EXTINGUISHER ATTEMPTED TO PUT OUT FIRE AND CALLED 911. FIRE DEPT DETERMINED FIRE STARTED INSIDE CAR AT WIRING AREA.

I HAD JUST MERGED ONTO THE INTERSTATE I-90 AT RUSH HOUR, AT ABOUT 55-60 MPH WHEN THE STEERING FROZE AND THE CAR TOTALLY STOPPED. FORTUNATELY I WAS ABLE TO GET THE CAR INTO THE BREAKDOWN LANE AND GET OUT OF TRAFFIC. THE CAR WAS TOWED TO THE DEALER WHERE I PURCHASED IT & MAINTAINED IT REGULARLY. THEIR MECHANICS CHECKED IT OUT. I WAS TOLD THE PROBLEM WAS THE BEARING MATERIAL WENT FIRST, CAUSING A SEIZED CRANKSHAFT. NEED A NEW ENGINE AT 105,000 MILES !!! DEALER COST OF NEW ENGINE WAS STATED AT $8000. THEY ALSO GAVE ME THE ALTERNATIVE OF BUYING A USED ENGINE FOR $6000 BUT ONLY WITH A 3 YR WARRANTY. AT MY NORMAL USAGE, ASSUMING I CONTINUE TO DRIVE ABOUT 17,500 MI/YEAR, IT WILL COST ME $8000 PLUS REGULAR MAINTENANCE TO GET ANOTHER 52,500 MILES OUT OF THIS CAR. THIS IS A TOTALLY UNACCEPTABLE ISSUE THAT THE MANUFACTURER IS NOT HANDLING IN A PRO-ACTIVE MANNER. AT LEAST HYUNDAI COULD EXTEND THE WARRANTY FOR MY CAR TO ALLOW THIS FIX TO BE DONE AT NO COST TO ME. THEY OBVIOUSLY KEPT THE SCOPE OF THEIR RECALL TOO NARROW BECAUSE PAGES AND PAGES OF COMPLAINTS EXIST ON NHTSA WEBSITE ARE DESCRIBING THE SAME PROBLEM THAT I HAD. THIS IS A DANGEROUS PROBLEM THAT NEEDS TO BE ADDRESSED.

TL* THE CONTACT OWNS A 2012 HYUNDAI SANTA FE. WHILE DRIVING, THE TRANSMISSION DOWNSHIFTED INTO A LOWER GEAR ON ITS OWN AND THE VEHICLE STOPPED. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND STATED THAT IT WAS STILL UNDER THE 100,000 MILE WARRANTY AND REFERRED THE CONTACT TO THE DEALER. POHANKA HYUNDAI (1770 RITCHIE STATION COURT, CAPITOL HEIGHTS, MD 20743, (240) 788-4240) DETERMINED THE CAUSE OF THE FAILURE WAS NOT THE TRANSMISSION. THE DEALER INITIALLY FOUND CODES RELATED TO THE ABS SPEED SENSOR AND STATED THAT THERE APPEARED TO BE AN ELECTRICAL FAILURE WITH THE ELECTRONIC STABILITY CONTROL. THE DEALER FURTHER STATED THAT THE ABS MODULAR WAS ACTIVATING ON ITS OWN, WHICH CAUSED THE FAILURE. THE REPAIRS WOULD COST $2,900 AND THE DEALER STATED THAT IT WAS NOT COVERED UNDER THE WARRANTY; HOWEVER, THEY OFFERED TO COVER A PART OF THE LABOR COSTS. THE DEALER HAD THE VEHICLE FOR OVER A MONTH AND TEST DROVE THE VEHICLE. THE DEALER STATED THAT THE FAILURE RECURRED AFTER ALL THE REPAIRS AND CONCLUDED THAT THE TRANSMISSION MAY BE THE CAUSE OF THE FAILURE. THE DEALER STATED THAT THE ORIGINAL WARRANTY WOULD NOT COVER THE REPAIRS BECAUSE THE CONTACT'S MOTHER PASSED AWAY; THEREFORE, THE ORIGINAL POWER TRAIN WARRANTY WAS VOIDED. THE MANUFACTURER CALLED THE DEALER AND OFFERED TO CONTRIBUTE $630 TOWARDS THE REPAIR. THE FAILURE MILEAGE WAS 79,000.

TL* THE CONTACT OWNS A 2012 HYUNDAI SANTA FE. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE SHUT DOWN WITHOUT WARNING. THE ENGINE WAS RESTARTED AND THE VEHICLE WAS TOWED TO AN UNKNOWN DEALER IN JACKSON, TN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THERE WAS NO RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 100,000.

2012 HYUNDAI SANTA FE PURCHASED AT 89,000 MILES FROM THE DEALER WITH CLEAN CARFAC. MAINTAINED WITH OIL CHANGES REGULARLY, EVERY 2-3K MILES. NO ISSUES. WENT TO START THE CAR 90 DAYS AFTER PURCHASING IT AND THE ENGINE FAILED, RUMBLED LOUDLY AND SHUT OFF. ENGINE LIGHTS CAME ON. MECHANIC TOLD ME IT WAS TENSION TIMING CHAIN & REPLACED IT FOR $2,000. 2 MONTHS LATER (NOW) THE SAME THING IS HAPPENING, ONLY NOW IT'S A LOUD KNOCKING NOISE AND BLUE INDIGO SMOKE COMING OUT OF THE EXHAUST. I HAVE NOT EVEN DRIVEN THIS CAR FOR 6 MONTHS AND I DO NOT DRIVE VERY OFTEN (LIVE AND WORK IN THE CITY). THIS SAME ENGINE IS IN THE 2013-2014 WHICH HAVE OFFICIALLY BEEN RECALLED, SO WE ALL NEED TO PLACE A LAWSUIT ON HYUNDAI FOR THE 2012 SANTA FE! MY MECHANIC TOLD ME THIS ENGINE IS DEFECTIVE AND THE MANUFACTURER DID NOT SEAL THE OIL PAN PROPERLY SO THE OIL LEAKS OUT CONSTANTLY WHILE THE CAR IS IDLE. I WAS TOLD IT NEEDS A NEW ENGINE, AND AM CURRENTLY FIGHTING WITH HYUNDAI CORPORATE TO GET THEM TO REPLACE IT FREE OF CHARGE! CAN ANYONE HELP!

WHILE DRIVING ON A BUSY STREET, I SLOWLY TURNED A CORNER AND SUDDENLY LOST MY POWER STEERING AND BRAKES AND THE ENGINE STALLED OUT. I IMMEDIATELY TURNED OFF THE ENGINE, SAT BRIEFLY BLOCKING THE HEAVY TRAFFIC, AFTER BEING SLIGHTLY SHAKEN IN THE INCIDENT, STARTED IT UP AGAIN AND PROCEEDED TO PARK AND GET LUNCH. AFTER LUNCH, THE CAR STARTED UP OK, I GOT ON THE ROAD AND SHORTLY AFTER, I NOTICED THE ENGINE LIGHT COME ON SO I IMMEDIATELY LIMPED INTO A NEARBY CAR REPAIR PLACE . THEY DETERMINED THAT THERE WAS VERY HEAVY SLUDGE CLOGGING THE OIL FILTER, EVEN THOUGH WE HAD REGULAR MAINTENANCE ON THE VEHICLE AND NEVER HAD ANY ENGINE INDICATORS EVER COME ON BEFORE. THEY CLEANED OUT THE SLUDGE IN THE ENGINE AND REPLACED THE FILTER AND PUMP. NOW THAT I AM READING ABOUT EVERYONE'S ENGINE PROBLEMS WITH OIL NOT GETTING INTO THE ENGINE, AND AFTER HEARING ON TV ABOUT HYUNDAI REFUSING TO RECALL MY PARTICULAR CAR, I AM VERY AFRAID TO CONTINUE DRIVING IT, SINCE RECENTLY I HAVE EXPERIENCED TWICE A CERTAIN SLUGGISHNESS/DRAGGING WITH A SLIGHT KNOCKING FEELING IN THE STEERING WHEEL. I NOTICED THIS EFFECT TWICE AFTER HAVING DRIVEN THE CAR AT SPEEDS OF 60-70 MPH FOR A LONG PERIOD OF TIME. EACH INSTANCE, I SLOWED TO THE SIDE OF THE ROAD, CHECKED TO SEE IF I COULD SEE ANYTHING OBVIOUS, WHICH I DIDN'T, STARTED UP AGAIN ONTO THE HIGHWAY. THE WEIRD DRAGGING AND SHIMMY CONTINUED, SO I DROVE AT OR UNDER 50 MPH UNTIL IT SLOWLY DISSIPATED AND WENT BACK TO WHAT FELT NORMAL. I WAS VERY DISAPPOINTED TO FIND OUT THAT

NOTICED MY VEHICLE WAS PULLING TO THE RIGHT AND JUST FELT WRONG WHEN I DROVE, TOOK IT TO A MECHANIC TO CHECK THE ALIGNMENT AND BRAKES (BECAUSE IT WAS TIME FOR PADS). THE MECHANIC WAS SHOCKED TO FIND THE STRUT ON THE PASSENGER SIDE HAD RUSTED AND BROKEN COMPLETELY. HYUNDAI WAS GOING TO CHARGE ME TO CHECK IT OUT AND REPAIR BECAUSE I WAS OUTSIDE OF MY WARRANTY. THE MECHANIC TOLD ME TO CHECK FOR A RECALL SINCE IT WAS NOT A COMMON ISSUE, THERE WAS NOT A RECALL SO HE SUGGESTED I FILE A COMPLAINT.

MY CAR IS SHAKING WHEN THE VEHICLE GETS UP TO AROUND 60 MILES AN HOUR.

WHILE DRIVING THE ENGINE WOULD DECELERATOR THEN CUT OUT. I CAN BE ON THE HIGHWAY GOING SPEED LIMITS OF 70 OR ON A SIDE STREET GOING 30 OR UNDER. IT EVEN HAPPENED WHEN I PULLED OUT OF MY DRIVE WAY AND DROVE DOWN MY STREET (4 HOUSES DOWN) AND GOT TO MY CUL-DE-SAC AND ALL POWER SHUT DOWN. NEIGHBOR HAD TO STOP TO AVOID HITTING ME BECAUSE I WAS ROLLING AND COULD NOT STOP. ALL POWER TO STEERING WHEEL AND BRAKES WOULD BE NON OPERATIONAL. I HAVE TO MANUALLY PULL THE WHEEL TO ONE SIDE TO AVOID TRAFFIC, CAUSING AN ACCIDENT, OR FROM BEING HIT BY HEAD ON TRAFFIC. THE FIRST OCCURRENCE WAS IN FEBRUARY OF 2017 AND THE MOST RECENT WAS JANUARY 18TH ON MY WAY HOME FROM WORK. IT HAS HAPPENED TO US OVER A DOZEN TIMES AND FOUND BLOGS THAT STATE THAT HYUNDAI DENIES THAT THIS IS HAPPENING.

MY VEHICLE IS A 2012 HYUNDAI SANTA FE WITH 131,000 MILES. I WAS DRIVING ON THE HIGHWAY TRAVELING ABOUT 65 MPH AND LOST POWER STEERING, POWER BREAKS, AND SPEED CONTROL. MY CAR BEGAN TO SLOW AND WOULD NOT ACCELERATE AND WAS DIFFICULT TO STEER. FORTUNATELY I HAD ENOUGH POWER/SPEED STILL TO GET OVER INTO THE BREAKDOWN LANE. I WAS ABLE TO USE MY DIRECTIONALS AND HAZARD LIGHTS ONCE ON THE SIDE OF THE ROAD. I SHUT OFF THE CAR AND ATTEMPTED TO START IT AGAIN SEVERAL TIMES WITHOUT SUCCESS. THE CHECK ENGINE LIGHT WAS ON, AS WAS THE OIL LIGHT AND BATTERY LIGHT. THERE WAS NO DISCERNIBLE WARNING THAT WOULD HAVE INDICATED AN IMPENDING ENGINE FAILURE. I HAD ALREADY DRIVEN 75 MILES OF MY TRIP AND IT SIMPLY STOPPED RUNNING. IN THE MIDDLE OF THE HIGHWAY! THE CAUSE OF THE PROBLEM IS UNKNOWN TO ME AND CURRENTLY UNKNOWN TO MY MECHANIC. I HAD TO HAVE MY CAR TOWED 50 MILES TO THE MECHANIC. GETTING IT TO A DEALER WOULD HAVE BEEN EVEN FATHER.

DOOR LOCKS KEEP LOCKING AND UNLOCKING. HAS NOT STOP DOING THIS

MOTOR STARTED KNOCKING WHILE DRIVING, TOOK TO SHOP AND WAS TOLD MOTOR IS NO GOOD. NEEDS TO BE REPLACED. COST 6100.00

WAS TRAVELING ON INTERSTATE AT 70 MPH. EXITED AND SLOWED TO ABOUT 35 MPH, AT WHICH TIME THE ENGINE SHUT DOWN. ENGINE STARTED RIGHT BACK UP AND RAN OK REST OF WAY HOME. THE NEXT DAY WHEN DRIVING UP A HILL, ENGINE BEGAN TO KNOCK AND CHECK ENGINE LIGHT CAME ON. I CONTINUED ON TO AN AUTOZONE WHERE I HAD IT CHECKED WITH A CODE READER. CODE RETRIEVED WAS P0014 WHICH IS B CAMSHAFT TIMING OVER-ADVANCED OR SYSTEM PERFORMANCE BANK 1. REMOVED VALVE COVER AND FRONT COVER AND INSPECTED THE CAMSHAFT AND TIMING COMPONENTS. THESE CHECKED OK, REMOVED OIL PAN AND DISCOVERED THAT THE #4 ROD BEARING HAD SPUN ON CRANKSHAFT. I THEN FOUND THAT HYUNDAI HAD HAD THIS PROBLEM WITH MANY OF THEIR 2.4L ENGINES AND THAT THERE WAS ACTUALLY A RECALL ON SOME. I CONTACTED HYUNDAI BY EMAIL AND WAS INFORMED THAT MY VIN# WAS NOT INCLUDED. SO NOW I AM STUCK WITH A VEHICLE THAT I OWE ON AND THAT WILL COST ME AT LEAST $5,000 TO HAVE A NEW ENGINE INSTALLED, WHICH I CAN NOT AFFORD.

ON MONDAY, NOVEMBER 12, 2018 I WAS DRIVING AT 60 MPH ON INTERSTATE 64 IN NEWPORT NEWS, VA. I STARTED HEARING A CLANGING NOISE FROM THE FRONT OF THE CAR. I THOUGHT A FENDER HAD COME LOOSE. THE NOISE PERSISTED AND I REALIZED IT WAS COMING FROM THE ENGINE COMPARTMENT. MY VEHICLE, WITH 140,527 MILES ALSO HAD A BURNING SMELL ALTHOUGH THERE WAS NO FIRE. I PULLED OVER TO THE SIDE OF THE ROAD AND WAS TOWED TO WILLIAMSBURG HYUNDAI DEALERSHIP IN WILLIAMSBURG, VA. THEY CALLED ME LATER THAT DAY AND TOLD ME THAT "SOMETHING HAD COME LOOSE IN THE ENGINE AND MADE A HOLE IN THE ENGINE BLOCK". I WAS TOLD I NEEDED A REPLACEMENT ENGINE AT A COST OF $7,200 WHEN THE VEHICLE IS ONLY WORTH ABOUT THAT ON THE PRIVATE MARKET. THE DEALER DID NOT INFORM ME ABOUT THE ISSUES WITH THE THETA II ENGINES IN THE 2011-2014 HYUNDAI SONATAS WHICH HAS THE SAME ENGINE AND HAS BEEN RECALLED. I CALLED HYUNDAI CUSTOMER CARE AND OPENED A CASE WITH THEM ON NOVEMBER 15, 2018. THEY ADVISED ME TO HAVE THE DEALER SUBMIT A CLAIM REQUEST FORM CONCERNING THE INCIDENT AND THEY WOULD DETERMINE WHAT TO DO. NHTSA NEEDS TO RECALL ALL 2012 SANTA FE'S WITH THE THETA II ENGINE NOW BEFORE SOMEONE IS KILLED FROM A CRASH CAUSED BY AN ENGINE MALFUNCTION AT HIGH SPEED. MY HYUNDAI CASE NUMBER IS 12401191.

MY ABS LIGHTS ARE ON AND WON'T GO OFF. I HAD IT CHECKED FOR 80$ TO GET TOLD IT IS A SENSOR IN THE REAR HUB OF TIRE THAT IS NOT READING THE TIRE SPEED. THEY WANT 500$ TO REPAIR IT.

TL* THE CONTACT OWNS A 2012 HYUNDAI SANTA FE. WHILE DRIVING 55 MPH, THE VEHICLE STALLED AND SMOKE CAME FROM THE ENGINE COMPARTMENT. THE CONTACT ALSO MENTIONED THAT THE ENGINE MADE AN ABNORMAL NOISE. THE VEHICLE WAS TAKEN TO SOUTHTOWNE HYUNDAI (7665 US HWY 85, RIVERDALE, GA 30274, (770) 471-1000) WHERE THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 121,000. *TT CONSUMER STATED CAR IS UNDRIVABLE, ENGINE FAILURE OR SMOKE COMING OUT OF THE TAIL PIPE. IT SHOULD BE RECALLED. *JB

"TAKATA RECALL" MY ABS LIGHTS ARE ON AND WILL NOT GO OFF AS WELL AS THE DOWNHILL LIGHT MOVING AND STATIONARY. THE MECHANIC SAID IT IS A SENSOR IN THE LEFT REAR HUB THAT NEEDS TO BE REPLACED.

2012 HYUNDAI SANTA FE. CONSUMER WRITES IN REGARD TO SAFETY RECALL DUE TO FIRES AND MELTNG WIRES AND QUESTIONS IF VEHICLE FALLS UDER RECALL. *AS *JS *JS

WHILE DRIVING THE 2012 HYUNDAI SANTA FE TO TENNESSEE FROM ATLANTA, WITH MY WIFE AND DAUGHTER AS PASSENGERS, I FELT A HEAVY BUMP ON THE INTERSTATE, AND WONDERED IF A TIRE HAD GONE FLAT. SHORTLY AFTER THIS, I SAW HEAVY SMOKE IN MY REARVIEW MIRROR, LETTING ME KNOW THAT THERE WAS A PROBLEM WITH MY CAR. A PERSON DRIVING IN A LANE TO MY LEFT TOLD ME THE CAR WAS ON FIRE, SO I PULLED OVER IMMEDIATELY. I GOT MY WIFE AND DAUGHTER OUT OF THE CAR, AND WALKED THEM TO A SAFE DISTANCE ABOUT 150 FEET FROM THE CAR. I HAD THE CAR TOWED TO A REPAIR SHOP. THE MECHANIC TOLD ME THAT A PISTON (OR PISTONS) HAD BLOWN THROUGH THE BOTTOM OF THE ENGINE, AND I WOULD NEED TO REPLACE THE ENTIRE ENGINE. IT WAS TOWED BACK TO MY HOUSE, AND WILL NO LONGER START. THIS WAS THE FINAL FRIDAY IN APRIL 2018. THE VEHICLE WAS IN MOTION, AT A SPEED NEAR 60 MPH, ON I-75 NORTH FROM ATLANTA, DRIVING STRAIGHT AHEAD.

DRIVING ON INTERSTATE HIGHWAY THE ENGINE HAD A FAILURE AND A ROD WENT THROUGH THE ENGINE BLOCK AND THE OIL DUMP STARTED A FIRE.

WAS DRIVING ON THE HIGHWAY AND HEARD A RATTLING/CLUNKING, MY RPM'S SHOT UP AND I COULDN'T ACCELERATE PAST 60. THE CHECK ENGINE LIGHT CAME ON AND THEN SHUT OFF BRIEFLY. THEN ALL OF THE LIGHTS ON MY DASHBOARD CAME ON AND I PULLED OVER BUT HAD NO POWER STEERING. ONCE I PULLED OVER THE CAR BEGAN TO SMOKE SO I TURNED IT OFF. I THEN HEARD A LOUD POP AND SAW A THICK BLACK SMOKE COMING FROM THE HOOD AND WITHIN 30 SECONDS THE FRONT OF MY CAR WAS IN FLAMES. IT IS BELIEVED TO BE AN ISSUE WITH THE ENGINE AND THERE IS THE START OF A CLASS ACTION LAW SUIT ON THIS ENGINE.

IT STARTING SLOWING DOWN WHILE DRIVING AND A REALLY LOUD NOISE AND THEN SHUT DOWN.. HAD TO HAVE IT TOWED TO AUTO LENDERS THAT WHERE I PURCHASE THE TRUCK AND THEY SAID THE ENGINE WAS DONE... SECOND OPINION AND THE MECHANIC INDICATED THE SAME "NEEDS A NEW ENGINE"

THE AIRBAG LIGHT STAYS ON EVEN AFTER IT WAS RESET BY THE DEALERSHIP.

CATASTROPHIC ENGINE FAILURE ON THE HIGHWAY AT 112K MILES. CONNECTING ROD THROUGH THE BLOCK. THIS SAME ENGINE HAS BEEN RECALLED IN SONATAS AND KIA SORENTOS OF THE SAME YEAR, BUT FOR SOME REASON NOT THE SANTA FE. THE SONATA AND SORENTOS WERE RECALLED DUE TO MANUFACTURING PROCESSES LEAVING METAL DEBRIS IN OIL PASSAGES, WHICH EVENTUALLY BLOCKS OIL FROM REACHING THE ROD BEARINGS LEADING TO THE SAME FAILURE OUR SANTA FE EXPERIENCED. HYUNDAI NEEDS TO EXPAND THE RECALL TO ALL EFFECTED MODELS.

HAD MY 2012 SANTA FE TOWED IN TO A LOCAL REPAIR SHOP FOR A HORRIBLE NOISE, AND WAS ADVISED NOT ONLY DID I NEED NEW BRAKES AT ONLY 43,159 MILES (SEEMS EARLY FOR THIS TOO) BUT THAT BOTH FRONT COIL SPRINGS AND STRUT MOUNTS WERE EXTREMELY RUSTY AND COMPLETELY BROKEN. THESE SPRINGS ALREADY HAD THE 'BOOT' FROM THE FACTORY WHICH WAS THEIR 'FIX' FOR PRIOR MODEL YEARS WITH THIS SAME PROBLEM. THERE HAVE BEEN RECALLS FOR THIS PROBLEM UP TO 2011 MODEL YEAR - BUT NOT THE 2012. MY VEHICLE WAS JUST OUT OF WARRANTY. --- NOTE - I STILL HAVE THE BROKEN COIL SPRINGS AS PROOF.

TL* THE CONTACT OWNS A 2012 HYUNDAI SANTA FE. WHILE ATTEMPTING TO START THE VEHICLE, IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO CHAPMAN SCOTTSDALE HYUNDAI (6601 E MCDOWELL RD #3, SCOTTSDALE, AZ 85257, (480) 424-3558) WHERE IT WAS DIAGNOSED THAT THE STARTER CAUSED THE FIRE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,143.

I OWN A 2012 SANTA FE., MY ENGINE SEIZED OUT OF BLUE ON A WELL MAINTAINED VEHICLE. THE 2012 KIA SORENTO ENGINE WAS RECALLED (WHICH IS THE SAME ENGINE AS MINE), AND 2013 & 2014 SANTA FE ENGINES RECALLED. CAN YOU PLEASE TELL ME WHY THE 2012 SANTA FE WITH SAME ENGINE AS THE SORENTO AND THE 2013 SANTA FE, HAS NOT BEEN RECALLED. I HAVE FOUND MULTIPLE REPORTS OF SAME PROBLEM ON THE INTERNET AND ON THIS SITE!

WHEN DRIVING AT APPROXIMATELY 40 MPH, THE ENGINE SEIZED CAUSING THE STEERING WHEEL TO LOCK AND THE BRAKES BECAME EXTREMELY DIFFICULT TO PUSH IN. THE VEHICLE WAS ENTERING A TURN ON LAKE SHORE DRIVE IN CHICAGO IL. THE VEHICLE HAD TO BE TOWED OFF THE ROAD AND WILL NOT START.

TL* THE CONTACT OWNS A 2012 HYUNDAI SANTA FE. WHILE DRIVING 65 MPH, THE CONTACT HEARD AN ABNORMAL NOISE AND NOTICED BLACK SMOKE COMING FROM THE HOOD. THE CONTACT PULLED OVER, LIFTED THE HOOD, AND NOTICED FLAMES. THE CONTACT WAS ABLE TO EXTINGUISH THE FLAMES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER (MCGRATH CITY HYUNDAI, 6750 W GRAND AVE, CHICAGO, IL 60707) WAS CONTACTED AND STATED THAT NO OIL WAS GOING TO THE ENGINE. THE MANUFACTURER WAS ALSO CONTACTED AND UNABLE TO ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2012 HYUNDAI SANTA FE. WHILE DRIVING 45 MPH, THE VEHICLE INADVERTENTLY ACCELERATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO CAPITOL HYUNDAI (1050 CAPITOL EXPRESSWAY AUTO MALL, SAN JOSE, CA 95136, (408)-340-7321), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 61,429. THE VIN WAS NOT AVAILABLE.

ON MAY 12TH, 2018 I WAS DRIVING DOWN THE HIGHWAY WHEN THE CAR STARTED TO JERK, I KEEP MY FOOT ON THE GAS BUT COULD FEEL THE CAR SLOWING DOWN. I WAS PASSING A VEHICLE AT ABOUT 60MPH AND ANOTHER CAR WAS BEHIND ME. THIS CAR HAS ABOUT 140,000 MILES ON IT. AND NOW IT'S KNOCKING. I HAD IT TOWED TO TEXAN HYUNDAI IN ROSENBERG, TEXAS. I WAS TOLD I NEED A NEW MOTOR. THIS ONE HAS INTERNAL PROBLEMS. I WAS ALSO TOLD THESE MOTORS ARE NO LONGER MADE AND ONE WAS FOUND WITH 75,000 MILES ON IT. TOTAL REPAIRS WAS CLOSE TO $8000. I HAVE KEPT IT WELL MAINTAINED AND NEVER HAD PROBLEMS WITH IT.

WHILE DRIVING UP HILL YESTERDAY MY CAR JUST DIED. THE ENGINE LIGHT WENT ON AND THE CAR STOPPED. I AM NOW LEARNING THAT HYUNDAI ENGINES HAVE A DEFAULT. THEY DO NOT LET ENOUGH OIL IN THE ENGINE REGARDLESS OF OIL LEVELS AND THUS AS YOU DRIVE, THE ENGINE IS DISINTEGRATING. THE ENGINES USUALLY DIE A LITTLE AFTER 100000 MILES. MY CAR HAS APPROXIMATELY 116000 MILES. THIS IS DANGEROUS. LUCKY THIS HAPPENED ON A SMALL BACK ROAD SO NO ONE GOT HURT, BUT WHAT IF THIS HAPPENS ON A MAJOR HWY? ACCIDENTS/DEATH EVEN. WE OWN ANOTHER 2012 SANTE FE AND I AM SCARED TO DRIVE IT NOW.

DRIVING DOWN THE TOLLWAY AT 75 MPH THE ENGINE MADE A KNOCKING SOUND AND THEN COMPLETELY SHUT DOWN. MY HUSBAND WAS ABLE TO COAST IF OFF THE TOLLWAY . IT WAS TOWED TO THE DEALERSHIP WHERE THEY CAME TO THE CONCLUSION THAT THE ENGINE BLEW AND RECOMMENDED GETTING A NEW ENGINE. HOWEVER, WITH IT BEING JUST AT 102K MILES ITS RIGHT OUTSIDE OF WARRANTY. THE DEALERSHIP IS TELLING ME CORPORATE WONT COVER IT BUT I HAVE FILED A FORMAL COMPLAINT WITH HYUNDAI CORPORATE AND THEY ARE IN THE PROCESS OF REVIEWING THE CLAIM. AFTER READING ALL OF THE OTHER HORROR STORIES, I BELIEVE THEY WILL COME BACK WITH SOME EXCUSE. THIS HAS GOT TO STOP. THEY SAID IT WOULD BE 3-5K JUST FOR A NEW ENGINE ALONE... THIS IS OUTRAGEOUS.

MY ISSUE IS THAT MY 2012 SANTA FE DIED WHILE I WAS DRIVING AT ABOUT 55 MILES PER HOUR. I WAS SOMEHOW ABLE TO MUSCLE THE STEERING WHEEL A BIT TO THE RIGHT TO GET OUT OF HEAVY TRAFFIC AND GET TO THE SIDE OF THE ROAD. THIS TOOK PLACE ON SATURDAY, MAY 5TH, 2018. I CAME VERY CLOSE TO SUFFERING PHYSICAL HARM AND EVEN DEATH. I HAD THE CAR TOWED TO A MECHANIC. THE CHARGE WAS $800 AND THEY THEN TOLD ME MY ENGINE WAS BLOWN DUE TO A ROD LODGING OR GOING THROUGH THE ENGINE. I ALSO INCURRED ABOUT $50 IN UBER FEES TO GO BACK AND FORTH. I KNOW THAT THERE IS NOT A RECALL FOR THE SANTA FE IN 2012 THOUGH I ALSO KNOW THAT HYUNDAI LOST A CLASS ACTION SUIT COVERING THIS SAME ISSUE AMONG OTHERS FOR THE 2012 SANTA FE. I WAS ADVISED TO HAVE THE CAR TAKEN TO THE DEALER FOR EVALUATION AND THEN THE DEALER WILL CONTACT HYUNDAI. I WILL HAVE TO HAVE THE CAR TOWED AGAIN. THIS WILL BE THE 3RD TOW. EACH TOW COST ABOUT $50. I AM CONFIDENT THAT THE ISSUE WAS A TIMING CHAIN BEING LOOSE OR MALFUNCTIONING CAUSING THE DESTRUCTION OF THE ENGINE. I WOULD LIKE HYUNDAI TO PROVIDE ME WITH A REPLACEMENT ENGINE FREE OF CHARGE AND REIMBURSE ME FOR MY EXPENSES. I WOULD ALSO LIKE TO EXPRESS THAT THIS EVENT HAS BEEN VERY UPSETTING AND THAT IT WAS JUST GOOD FORTUNE THAT MY WIFE OR 2 DAUGHTERS WERE NOT DRIVING THE VEHICLE AT THE TIME.

FRONT SPRINGS RUSTED, CALL RECALLED DUE TO UNDERCARRIAGE RUST, RUB AGAINST TIRE, VERY DANGEROUS HYNDAI OF TURNERSVILLE HAS VEHICLE NOW WAITING TO SEE IF HYUNDAI CORPORATE WILL FIX THIS ISSUE FREE OF CHARGE

TL* THE CONTACT OWNED A 2012 HYUNDAI SANTA FE. WHILE DRIVING 28 MPH, AN ONCOMING VEHICLE INADVERTENTLY CROSSED INTO THE CONTACT'S LANE. AS A RESULT, A HEAD ON COLLISION OCCURRED. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A FRACTURED NECK, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT AND DEEMED DESTROYED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC TO DETERMINE THE CAUSE OF THE AIR BAG FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

FRONT COIL SPRING RUSTED AND BROKE; IT RUBBED AGAINST MY TIRE. NOT SURE HOW TIRE DID NOT RUPTURE WHILE I WAS DRIVING ON I-95. THE OTHER FRONT COIL SPRING WAS RUSTED, BUT IT DID NOT BREAK YET. CLEARLY THIS PART IS DEFECTIVE. COIL HAD PLASTIC SLEEVE ON IT, WATER MUST COLLECT UNDERNEATH AND RUST IT OUT. CREATED CASE NUMBER 11066195 WITH HYUNDAI, BUT THEY HAVE NOT ACKNOWLEDGED ANY RESPONSIBILITY, DESPITE MY REPEATED CONCERNS ABOUT SAFETY. THEY ALSO WOULD NOT REIMBURSE ME FOR REPAIR BECAUSE 'IT WAS OUTSIDE WARRANTY' AND THAT I WENT TO MY FAMILY MECHANIC (DUE TO LACK OF RESPONSIVENESS FROM HYUNDAI). I SAW ONLINE THAT HYUNDAI HAS HAD A HISTORY OF DEFECTIVE FRONT COIL SPRINGS (EVEN AS RECENT OF 2018), YET THEY HAVE NOT TAKEN MY COMPLAINT SERIOUSLY.

THERE HAVE BEEN NUMEROUS INCIDENTS THAT HAVE OCCURRED OVER THE PAST FEW MONTHS. IS INTERMITTENT - CAN HAPPEN 2 DAYS IN A ROW OR WEEKS APART. SYMPTOMS WHEN MOVING FORWARD AT A LOW RATE OF SPEED (STOP AND GO TRAFFIC ON EXPRESSWAY) STOP TO 10 MILES PER HOUR ... EVERY NOW AND THEN HEAR A "CLUNK" SOUND FROM THE REAR OF THE VEHICLE - FROM ABOVE THE SPARE TIRE AREA. INTERMITTENT - CAN HAPPEN MINUTES APART OR A WEEK APART. HAVE READ SAME TYPE OF COMPLAINTS ON INTERNET. TOOK IT TO MULTIPLE MECHANICS ( HYUNDAI & NON-HYUNDAI ) - NEITHER OF THEM COULD "REPRODUCE" THE PROBLEM.... WHICH IS THE "PROBLEM".... AS I TOLD THEM AND HAVE POSTED HERE.... THIS CAN HAPPEN TWICE IN ONE DAY AND THEN NOT RE-OCCUR FOR A WEEK OR TWO..... THE MECHANICS LOOK AT ME LIKE I'M NUTS AFTER THEY'VE DRIVEN IT AROUND AND NOT BEEN ABLE TO "REPRODUCE" THE PROBLEM... SCENARIOS #1 THE VEHICLE WAS IN MOTION; AT A VERY LOW RATE OF SPEED (0-7MPH); ON AN UPWARD INCLINE; STOP & GO TRAFFIC #2 THE VEHICLE WAS IN REVERSE, AT A VERY LOW RATE OF SPEED (0-7MPH); ON A DOWNWARD INCLINE WITH SHARP TURN TO THE RIGHT - BACKING OUT OF DRIVEWAY TO STREET #3 THE VEHICLE WAS IN REVERSE, AT A VERY LOW RATE OF SPEED (0-7MPH) STRAIGHT BACK

INTAKE MANIFOLD RUNNER CODE P200A MAKES CAR BOG DOWN WENT TO DEALER THE PART IS NOT AVAIL FOR 8 WEEKS SEEMS TO BE A BIG PROBLEM THEY HAVE SEVERAL CARS AT DEALERSHIP THAT DONT RUN NOW MINE DOES NOT WARRANTED PART BUT CANNOT GET PLEASE HELP BOGS DOWN CANT GO OVER 20 MPH

FAULTY THETA II ENGINE. DRIVING ON THE FREEWAY,HEARD KNOCKING NOISE IN THE ENGINE. TOOK THE CAR DIRECTLY TO THE DEALER, SERVICE ADVISOR HEARD THE SAME NOISE,SAID THE CAR WAS UNSAFE TO DRIVE. HE SAID SOME OF THEIR ENGINES HAVE THIS KNOWN PROBLEM & HE'D CHECK FOR A RECALL. SAID MINE WAS NOT RECALLED, I'D HAVE TO PAY FOR A NEW ENGINE. HE SENT THE CAR BACK TO THE MECHANIC WHO PUT IT ON A LIFT,HEARD THE NOISE,BROUGHT IT RIGHT BACK DOWN, AGREEING IT WAS THE KNOWN PROBLEM. THE SA SAID HE WOULD SUBMIT A REQUEST TO CORPORATE TO PAY FOR THE ENGINE. THE FACT THAT HE RECOGNIZED THE PROBLEM IMMEDIATELY AND KNEW TO DO A CORP. APPROVAL REQUEST TO PAY TO REPLACE THE ENGINE PROVES HE KNEW IT WAS A FAULTY ENGINE & HMA SHOULD PAY FOR IT. I RENTED A CAR TO DRIVE THE 2 HOURS HOME.MY CAR HAS BEEN THERE 10 WEEKS. HMA DENIED MY CLAIM 3 TIMES (ONCE AFTER THE DEALER ESCALATED THROUGH HIS DISTRICT MANAGER). AFTER MUCH RESEARCH I REALIZED THIS ENGINE HAS BEEN RECALLED FOR MILLIONS OF CARS - HYUNDAI & KIA, DIFFERENT MODELS, DIFFERENT YEARS. MINE IS NOT RECALLED - YET. THE ENGINE WAS MANUFACTURED SO THAT SHAVINGS DROP ON TO THE ENGINE AND EVENTUALLY CAUSE THE FAILURE (IT IS MUCH MORE DETAILED & TECHNICAL THAT THAT). IF I HAD CONTINUED DRIVING, THE RESULT WOULD HAVE BEEN THE ENGINE SEIZING WHILE DRIVING OR THROWING A ROD OUT OF THE ENGINE WHILE DRIVING. HYUNDAI HAS THIS ENGINE ON THE ROAD RIGHT NOW IN MILLIONS OF CARS, IT IS EXTREMELY DANGEROUS , THEY REFUSE TO TAKE RESPONSIBILITY (EXCEPT IN THE LAWSUIT TH

THIS VEHICLE HAS A PROBLEM WITH STALLING AND HESITATION WHEN COMING OUT OF TURNS AND AT SPEEDS BETWEEN 60-80 MPH. I HAVE MENTION THIS TO THE DEALER SEVERAL TIMES AND THEY CONTINUE TO SAY THEY CANNOT FIND ANYTHING WRONG. BECAUSE THERE IS NEVER ANY LIGHTS ON AND NO CODES. THIS IS A VERY BAD PROBLEM SOMEONE IS GOING TO GET HURT FROM THIS OR DIE FROM THIS. BUT NO ONE WILL KNOW BECAUSE THE SYMPTOM WILL NOT SHOW UP AS A CODE ON THE SYSTEM, IF THEY DIE THE STORY CANNOT BE TOLD. PLEASE LOOK INTO THIS, I BET IF YOU CHECK WITH OWNERS OF THIS VEHICLE YOU WILL FIND THE SAME PROBLEM NOT ONLY THE SAME YR OF MINE BUT NEWER ONES. THIS PROBLEM HAS BEEN HAPPENING EVER SINCE I HAVE OWNED THIS VEHICLE. I HAVE NOW A 109,000 MILES ON IT NOW. ON 01/28/2018 IT DONE IT SEVERAL TIMES ON THE HIGHWAY.

DRIVER TAIL LIGHT ASSEMBLY IS COLLECTING CONDENSATION IN IT, CAUSING TAIL LIGHT BULBS TO CRACK AND BLOW OUT. SEVERAL YOUTUBE VIDEOS SHOW FIXES, SO THIS IS OBVIOUSLY AN ISSUE.

I WAS AT A FOUR WAY-YEAR-OLD AND STOP WHERE I HAD TO YIELD AS I WAS DOING THE SANTA FE CUT OFF AND I LOST ALL POWER STEERING WHEEL LOCKED UP AND I COULDN'T CONTROL VEHICLE TURN THE KEY OFF AND THEN TURN THE KEY BACK ON THE TRUCK STARTED 20 MINUTES LATER THE TRUCK WOULD NOT START IT WHEN YOU RETURN ON THE ANTITHEFT ALARM KEEPS BEEPING