2022 Hyundai Santa FE Hybrid

Defect. Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk. A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.

Remedy. Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk. A fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2023 Genesis G80 Electric, 2021-2022 Santa Fe Hybrid, and 2022-2023 Santa Fe Plug-In Hybrid vehicles. In the event of a crash, the front driver-side and/or passenger-side seat belt pretensioners may explode upon deployment.

Risk. An exploding seat belt pretensioner can project metal fragments into the vehicle, strike vehicle occupants, and result in injury.

Remedy. Dealers will secure the seat belt pretensioners with a cap, free of charge. Owner notification letters were mailed December 14, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 238/011G. This recall is an expansion of recall numbers 22V-354 and 22V-458.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2022 Santa Fe HEV and Santa Fe PHEV vehicles. The instrument cluster liquid-crystal display (LCD) may invert the image on the screen upon vehicle startup, making the display illegible. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Controls and Displays."

Risk. An illegible instrument cluster will not show information such as vehicle speed or safety system warnings, which can increase the risk of a crash.

Remedy. Dealers will replace the instrument cluster, free of charge. Owner notification letters were mailed February 23, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 217.

Occasionally the cruise control will go off. Sometimes it will reset itself & other times, the driver has to initiate. I reported to the Hyundai Manuf. last yr. & also had 2 separate dealers take a look & problem has not been resolved.

The driver-side seat belt buckle on my 2022 Hyundai Santa Fe will not latch. This is a safety-critical failure under FMVSS 209/210. The vehicle has not been in a collision. The dealership and Hyundai Consumer Affairs bot stated that the seat belts are only covered under te 5 yr/60K warranty and refused to treat this as a safety defect. The buckle failure prevents proper restraint and poses a serious safety risk.

The vehicle has suffered a catastrophic structural manufacturing defect involving a transmission case half seal failure. The transmission is actively seeping/leaking fluid directly from the factory-mated case assembly line seal. This presents a severe, progressive safety hazard. Transmission fluid leaking from the case half migrates along the underbody of the vehicle and directly coats hot exhaust and powertrain components during highway operation. This creates an immediate risk of under-hood smoke, thermal degradation, component stalling, or a potential vehicle fire at high speeds. Certified diagnostic inspection confirms this is a factory assembly defect (defective RTV sealant application or improper factory bolt torque) and not mechanical wear-and-tear or driver neglect. The vehicle currently has 88,000 miles, but the structural failure was first physically documented by a licensed facility at 59,870 miles. The manufacturer (Hyundai Motor America) has currently refused to honor the powertrain failure, forcing the vehicle to remain on the road with an active powertrain fluid leak risk.

While accelerating at a light, the accelerator became unresponsive, only propelling the vehicle a couple miles per hour. I was not able to pull over, as I was in the left lane of a very busy road. After about 15 seconds of lack of acceleration, the accelerator responded enough for me to pull over. I’m glad this incident did not occur on a highway, during a turn, or other hazardous situations. Dash displayed, “Check hybrid system. Pull over safely”. There was no indication or issue with the vehicle prior to this. I haven’t had any issues since I bought it several months ago. I’ve read reports of this same issue happening with this same model. I have a scheduled date for inspection.

Oil leaking from engine dripping down to floor.

Ever since new this suv will periodically hesitate when trying to accelerate. I have almost been rearended numerous times over the last few years do to this issue. I have had the SUV into the dealer and complained about this issue every time and they cannot seem to do anything about the issue. The have update software (or at least said they have) and done other things and it has made NO difference. This issue almost caused a serious accident just this week when I was trying to merge into traffic on I5.

Vehicle will not change out of EV electric mode and return to gas power causing hybrid battery drains to zero, vehicle loses acceleration, you can push the gas pedal to the floor and you have no acceleration, very UNSAFE when you are in traffic, no power to maneuver or avoid other vehicles quickly if needed, potential for accidents, hybrid system warning lights and alarms go on, have to try and pull over safely, battery will not recharge or takes a very long time to do so, only recourse is to shut vehicle off and restart which seems to reset vehicle, which in turn does not leave any warning lights other than codes on to show dealer, very dangerous to lose all acceleration capacity while in traffic, this has happened multiple times with the latest being today 3/23/25, vehicle is available for you to inspect, have had other powertrain codes issues as well, dealer has replaced fuel pump and erg valve but it does not resolve this hybrid issue, this battery drain issue has occurred multiple times but no resolution, help!

Our vehicle continues to experience loss of power driving , on cold days below freezing. When driving normally this hybrid vehicle will be in hybrid mode at a stop, then when accelerating, the ICE engine will not start to assist the hybrid, causing a bare minimum of power to be available, just enough to pull over. On several occasions this has led to very near rear end collisions from the driver's behind. So far I've been able to avoid injury, as I recognize the condition and am hyper attentive to its possible happening. The vehicle handed shown any Check engine warnings until yesterday. As it was dying I pumped the accelerator to see if it would go, latching a TPS out of range code. The condition has been brought to Hyundai Corporate and dealerships with no repair, and no resolution, they say it's fine. This is well documented by others driving Santa Fe Hybrids, and Tucson Hybrids on forums. No one fix has been established, with some dealerships replacing parts, and others no work being done because their scan tool sees nothing. With dozens of recalls for minor inconvenience issues, I do not understand why a recall for this drivability safety issue has not been mandated! These vehicles are defective, and potentially very dangerous. Loss of power, acceleration when others are behind you anticipating you to go, is a real serious danger, not to mention you being stranded in frigid weather. This began happening at 23k miles and continues today with 48k miles on mine. If the vehi

When pressing the accelerator from a full stop, the car would either not move at all, idle/roll forward, or unsteadily jerk forward. In addition, the car would brake while driving despite not applying any pressure to the brake pedal. This issue persisted regardless of "drive mode" and no cruise control was in use.

Headed to my work ,outside temp 26 deg F, when on hiway entrance ramp, vehicle lost all acceleration. Vehicle is a hybrid, condition no warning lights on dash, vehicle was stuck in EV mode, which the ICE engine would not start to help as normally would do. Hybrid battery began draining very quickly. There was a semi truck right behind me accelerating hard to get on highway .This time I managed to pull over on the debris filled shoulder before the system fully shut down as it has done before with the warning ⚠️ HYBRID SYSTEM FAILURE, PULL OVER NOW ! and loud alarm going off. This is a serious loss of total motive power, which I've reported to Hyundai Corporate, and dealerships for repair before, to which they say " we can't duplicate, all systems are fine", and blame me for the problem. Hyundai has washed their hands of this dangerous situation and won't help me. This is the 5th occasion of this problem, I now know from my experience and reading Hyundai forums this issue is wide spread among Hyundai Tucson and Santa Fe hybrids, with some places replacing parts, that doesn't fix the issue. I know how to react by pulling over immediately, shut off the vehicle completely, wait... Then restart the vehicle, and so far ,it will drive normal with no codes or warnings after that, until the next random occasion it happens. This is extremely dangerous in cold weather and around other traffic posing a major collision hazard and stranding someone who knows less about this condition. Hundr

The contact owns a 2022 Hyundai Santa Fe. The contact stated that while driving on the highway at 80 MPH, the "power low" warning message was displayed, immediately after the contact vehicle proceeded to decrease in speed. The contact proceeded to pull over onto the side of the road to restart the vehicle. The vehicle was able to successfully restart, and the contact successfully drove to a local dealer where the vehicle was diagnosed however the failure could not be replicated. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.

On October 28, 2024 and again on November 26, 2024, a warning light appeared on the dash which said “ check hybrid system stop safely” Within 20 seconds both times , the car became inoperable . When I stepped on the gas nothing happened . The first time I was blocking major traffic , the second time I was on an interstate in the right lane and had time to pull over. In about 15 minutes the light went off and the car drove as normal. The dealer has had the car after both instances , currently for 28 days, and has not been able to replicate the problem .

Transmission faulty needed to be replaced by Hyundai dealership.

Was driving home from work on the highway at highway speeds and suddenly lost the ability to accelerate with a "Check Hybrid System" warning. At the time of loss of power, I was crossing a bridge and got stuck in the middle of the bridge. I also notice the oil indicator light come on. The engine remained on as far as I can tell but it wouldn't go with the accelerator pedal pressed. I placed the car in park and turned off the vehicle while blocking bridge traffic. 15 seconds later, I turned the vehicle back on, vehicle said ready to drive. I put the car in drive and everything worked normally as best I can tell. Still nervous driving the car for fear of it happening again. Called dealer service but they were closed. What I don't understand is there was 2 recalls for Hyundai Sante Fe hybrids 2022 but when I put in my VIN it said no recalls. Why is it only associated with a VIN?

Vehicle was being driven at highway speeds and suddenly lost the ability to accelerate with a "Check Hybrid System" warning. After pulling to the side of the interstate, car was shut off and restarted and brought back up to 40 / 50 mph when the same issue occurred with a lack of ability to accelerate and a "Check Hybrid System" warning. The issue appears to be related to some portion of the hybrid drivetrain. Car was then towed but two mechanics (one independent and one Hyundai dealership) could not replicate the issue and the vehicle system did not store any codes or history of the incident. The safety of the driver was put at risk by lacking the ability to accelerate on a major interstate, leaving the driver stranded for two hours waiting on a tow truck on the side of a busy interstate with traffic moving at speeds up to 75 mph.

Power loss with no warning or errors - hybrid system frequently fails to start gasoline engine when needed, resulting in sudden power loss and limited to 35 mph without warning. Serious concern at intersections and on major roads.

The contact owned a 2022 Hyundai Santa Fe Hybrid. The contact stated while coming out of a parking space and driving approximately 5 MPH, he got distracted and crashed into a parking lot light pole. The contact stated that the Forward Collision Avoidance sensors failed to operate as intended. The vehicle was towed and was deemed totaled. No injuries were reported. The contact also stated that the vehicle started leaking from the radiator after the impact. The manufacturer was made aware of the failure; however, no further assistance was provided. The failure mileage was approximately 50,100.

I was driving on the freeway when suddenly I heard a clunking sound. Suddenly I was unable to accelerate at all. My speed was 60 mph and I had the gas pedal pressed all the way to the floor. Nothing happened and my speed would not go over 60. Then a message began flashing on my dashboard. I cannot remember the exact verbiage, but something along the lines of Hybrid System Failure. My car began losing speed and I was unable to accelerate to make it go faster at all. I lost complete control of the speed control. I was in the middle lane of a 5 lane freeway and struggling to get over since I was unable to accelerate at all. It was an extremely dangerous situation as I could no longer control the speed of my vehicle on a freeway. Finally, I was able to exit to an off ramp. My car continued to lose acceleration and finally came to a complete stop on a side street. My car was then towed to the dealer and they are unsure what the issue is. On doing some internet research, I have found a lot of postings of people having this same exact issue with the Hyndai Santa Fe Hybrid 2022 and I think it's a dangerous defect in the car.

The contact owns a 2022 Hyundai Santa Fe. The contact stated while driving at various speeds, the vehicle hesitated upon depression of the accelerator pedal with the "Check Hybrid System - Stop safely" message displayed. The contact stated that the hybrid battery charge fell to zero during the failure but would regain enough of a charge upon restart to resume normal operation. The contact initially took the vehicle to a dealer; however, no codes or defects could be found upon inspection. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 8,000.

The contact owns a 2022 Hyundai Santa Fe Hybrid. The contact stated while shifting into reverse (R) and depressing the accelerator pedal, the vehicle hesitated and responded slowly. There was no warning light illuminated. The contact stated that she then shifted into drive(D) and was able to drive; however, the failure recurred while driving and depressed the accelerator pedal. Additionally, the contact stated that the vehicle failed to exceed an unknown speed while driving. The contact stated that she had parked the vehicle and allowed the vehicle to run for 20 minutes. The contact stated that she then turned off and restarted the vehicle, and the vehicle responded as needed while driving. The dealer was notified of the failure and informed the contact that the next availability for diagnostic testing was in a month. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 18,500.