2023 Hyundai Santa Cruz

Defect. Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk. A fire while parked or driving can increase the risk of injury.

Remedy. Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.

Defect. Hyundai Motor America (Hyundai) is recalling certain 2022 Tucson and 2022-2023 Santa Cruz vehicles. The roof moldings may detach.

Risk. A detached roof molding could become a road hazard, increasing the risk of a crash.

Remedy. Dealers will inspect and replace, or secure the roof moldings, as necessary, free of charge. Owner notification letters were mailed March 30, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 241.

Unknown. I have had a clunking in the rear and have come across a TSB TSB 25-SS-003H. Seems like a safety issue. Rear shocks could be defective.

The push-to-open fuel filler door repeatedly failed to release, preventing refueling. The door locks through an electronic actuator tied to the central locking system, and there is no interior lever or owner-accessible manual override. Beginning in August 2026, the door intermittently failed to open when pushed with the vehicle off and all doors unlocked. Cycling lock/unlock on the key fob while pressing the door sometimes freed it after several minutes; other times it would not open at all. No warning lamps or messages preceded the failures. A door that will not release means the vehicle cannot be refueled, which can strand the driver or cause a loss of motive power in traffic. Owners of other 2022-2023 Santa Cruz vehicles report the same failure online, including at least one tow after an owner could not refuel. An authorized Hyundai dealer inspected the vehicle twice. On 08/29/2026 (24,410 miles) the dealer could not reproduce the concern and lubricated the latch pins. The failure returned within days. On 09/09/2026 (24,520 miles) the dealer confirmed the concern, found the electronic release motor had failed and the door housing assembly seized, and replaced the housing (part 81595-K5500) under the 5-year/60,000-mile warranty, documenting the repair with photos per Hyundai's warranty policy. The failed component remained with the dealer; both repair orders are available on request. Hyundai already addresses this failure on the related Tucson: TSB 25-BE-021H covers the sam

My 2023 Santa Cruz had 7500 miles when purchased 4/25/26. I have had issues with the screen blackening/fading which cuts of electronics; ex; safety features. This was taken in twice. Then the truck loses power. Going 55 or 75, suddenly truck drops to 20mph. Car's honk, brake & swerve not to hit us. It has been at dealers three times now for same issue. Since I've owned vehicle, it has been at dealer for 29 days tomorrow and it is still there. The truck is a death trap, always something wrong.

Truck dash light would fade/blacken at which time none of safety features would work. This is an intermittent problem but seem like it has happened many times with the Santa Cruz's in general, so Hyundai was aware of problem. They don't seem to fix problems. This is a critical safety failure. No warning just happens. Had it happen to my truck about 7 times. When screen blackens, I have no safety features, can't see anything on dash, so I could get in a wreck

Driving/pulling on interstate speed only went to 20 miles per hour, no more. Pulled off and turned truck off, waited and restarted. all fine. No warning was given. Short time later engine light came on. Called and got appointment at dealers.

Sudden Unintended Acceleration: Coming to a stop in a driveway and planning to put vehicle in to reverse, the Santa Cruz suddenly accelerated and kept accelerating ... it would not stop moving, brakes were applied continuously and forcefully, but with no effect. Vehicle crashed through shrubbery and small trees into neighbor's yard, over a retaining wall and finally crashing into neighbors parked classic car, only stopping after it nose-dived downward. We live in Rapid City, this event happened at our daughter's residence in Black Hawk, South Dakota.

Oil leak the oil leak has be too the dealer twice for repair each time they said it was fixed it has now has happend again for the third time in less than 306 miles could cause engine failure at highway speed and engine lockup at such speed first time it was found by dealer after third oil change approx. 15000 miles second 12000 miles later and now 306 miles latter with this time the leak was larger to to the fact that it triggerd the low oil light first two times it told to me it was oil pan gasket and a small leak which at the time made sense it not show up on the dipstick i know this was da problem on other Hyundai santa cruz models in previous years0

At least two separate wiring harnesses have failed on my vehicle, affecting the tail lights. My vehicle cannot pass New York State safety inspection because of this issue. Safety of myself and other drivers is at risk, especially at night, since my vehicle is not properly illuminated. Occasionally, one tail light will go out or flicker. I had one trailer harness removed under a safety recall, but I don't recall the dealership ever replacing it. Then, a couple of years later, I got a ticket for a tail light being out. Paid the dealership to replace a (possibly second) trailer wiring harness, but they got the wrong one. When they finally got the "right" one, another (possible 3rd), much more expensive harness was found to be shorted due to corrosion, prompting me to look into trading the vehicle in instead of repairing it. All harness issues in question are related to corrosion from water infiltration. The technician working on my vehicle told me that this is a common issue with Santa Cruzes and Tucson's, but only certain vehicles have been recalled (of course, mine was not on the list). My vehicle is only 3 years old. This is all after having the dealership replace a harness under the seat that was causing an issue with the audio, including safety notifications, that started within weeks of owning the vehicle. No warning lights, messages faults, or other symptoms indicated there was an issue. Self diagnostics, as accessed via Hyundai's BlueLink app, has no record of issues sin

While driving on the highway at a speed of approx 35 mph, no traffic in front of me, I got an audile warning and the car started slowing down, and the message on the dash said EMERGENCY BRAKING, this has happened twice in the last month.

Transmission does not advance through its ranges fails to shift leaving stranded middle of intersection. Misses a whole range looses excelleration. You

Hyundai Santa Cruz with transmission problems. 5 attempts to repair and manufacture failed to. Last time, vehicle had a sudden transmission failure while driving. Car stop responding to acceleration and transmission was not switching gears, that could had cause loss of control, especially in high-speed or high-traffic situations. Luckily it was very early in the morning, not much traffic and before (0.3 miles) from taking a high-speed interstate. Vehicle is not safe to drive and according to a research I made, other vehicles of same brand, model and year are facing same issues.

The contact owns a 2023 Hyundai Santa Cruz. The contact stated that while hauling a trailer and attempting to accelerate at various speeds, the vehicle was bouncing, and the tires was losing traction before being able to accelerate. The contact stated that the vehicle failed to raise and lower as the shock absorbers needed to perform. The vehicle was taken to the dealer to be diagnosed, and it was determined that the rear shocks had failed to allow the vehicle to self-level. The rear shocks were replaced; however, the failure persisted. The contact reported the persistence of the failure and was advised to go to another dealer, Greg Hubler Hyundai (6200 W Hometown Blvd, Muncie, IN 47304) who also replaced the rear struts. The manufacturer was informed of the failure and opened a case. The failure mileage was approximately 7,000.

The contact owned a 2023 Hyundai Santa Cruz. The contact stated that while exiting the vehicle to go into a store, he looked back and noticed the vehicle was on fire. No warning lights illuminated. The contact mentioned he noticed the fire was coming from the rear driver's side quarter panel. The contact called 911. No injuries were sustained. No medical attention was required. A police report was not filed. The fire department extinguished the fire. The vehicle was taken to a savage yard, and the insurance will then have the vehicle towed to a body shop. The vehicle was not repaired. The manufacturer was notified of the failure, and they informed the contact that they would inspect the vehicle, and they also offered to buy back the vehicle. Recently, he got an email informing him that they are not going to buy back the vehicle. The failure mileage was 18,000.

On [XXX], I went out to start my 2023 Hyundai Santa Cruz (SC) to leave work to go home. It was difficult to start, however, it started. As I entered [XXX] , i was nearly rear ended by another car, because my SC lost all acceleration. I turned on my hazards for SAFETY and then began to try to accelerate again and was only able to get up to 45 MPH and then was turning 4,000 RPM. I limped my SC home where I had it towed to a local Hyundai dealer as it has roughly 38,000 miles. The dealership had it for 3 days, but couldn't duplicate the issue, so no repairs were done. The Hyundai Santa Cruz has KNOWN transmission issues and the fact I was nearly rear ended could've caused a nasty wreck, resulting in more damage or even a fatality. I reported the issue to Hyundai customer service on the 11th of September (Case #[XXX]). However, in the response from Hyundai, basically saying they "experiencing a high e-mail volume" and responses may be delayed. As of 9/13/2025, I have not received a call or email from Hyundai's customer service. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Car flashes transmission low fluid and gives a code of p193b-79. when trans downshifts upshifts will not happened. to clear the problem you have to turn car off and on , and then normal operation resumes, but shifting is now slower. and sluggish. this is the second transmission to have this problem. Seem hyundai has not fixed it from the 2022 recall.

1- Air bag light randomly comes on and off. 2- Today (5.20.25) I brought it to dealer. Dealer said they disconnected the sensor switch and cleaned it, then reconnected and light went off (covered under warranty). 3- I got in the truck, started it, and light was off. 4- I drove one block and airbag light came on again. 5- Returned to dealer, who asked me to leave the car with them. 6- Dealer called and said they will replace air bag (did not specify which one). I hope this solves the problem. 7- I checked a Santa Cruz forum: [XXX] and it looks like A LOT of people have the same problem. Some report it's the sensor assembly underneath the seat. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Received error code P030300 and the third cylinder fuel injector had to be replaced. There is approximately 36000 miles on the vehicle.

Oil filter cap oil leak problem. Typical problem with this vehicles that require attention. These defective oil leak caps are a safety and environmental concern. The engine almost starved of oil while driving on the highway. Manufacturer has been contacted and are not proactive in taking care of this defect.

The system that failed was electrical near or in the Tow Hitch which caused the vehicle fire. Vehicle is available for inspection at Auto Body Evolution Essex MD. The car caught fire in the back of the vehicle while parked in Owner's driveway and engine off. Neighbor pounded on Owner's door at 6:50 am. yelling for the residents to open the door that their vehicle was on fire in their driveway. Fire was dangerously close to the gas cap; parked vehicle was close to the owner's house, two boats in the driveway, and neighbor's house. After the incident, owner googled for any issues with Santa Cruz's. It was then and only then we learned that this vehicle had a fire recall on the Tow Hitch. We NEVER received a recall notice. In fact, we had this vehicle at the dealership approximately 6 weeks ago for another recall issue, thermostat, and the dealership NEVER checked for any additional recalls. Police and Fire Department were called to the scene by using 911. Officer Irwin who arrived on scene, Badge #6560, Police Report #[XXX], had to use his bully stick to bust the window to use a fire extinguisher before the fire department arrived. The car would not unlock and the windows would not operate. If we had been in the vehicle when the fire erupted or any other passengers in the vehicle, we would not have been able to get out of the car due to the electrical fire effecting the operation of the window and doors if the doors were locked. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I

The emergency brake system comes on while driving 60 - 70 miles an hour on freeway. It has happened twice. It does not happen every time I drive 60 - 70. The light comes on stating Emergency Braking and my vehicle slows down. It does not last for very long then goes away. I took it to the dealership and it did not do it for them. They kept it 3 days.