2016 Honda Pilot complaints

Connecting rod bearing Failure. stalled in traffic. Waring lights included. emissions system problem VSA Problem Hill Start Assist Problem Trailer Stability Assist Problem Road Departure System Problem Emissions System Problem Power Steering System Problem All Wheel Drive (AWD) System Problem. also getting DTC Coded P0303_Cylinder 3 Misfire U0401-68_ECM Failure F-Can Time Out_ EAT_40F (NG) Loud Knocking coming from engine while running. removed the oil pan and rod bearing. Found Metal Shavings in the oil pan. located the loose connecting rod and removed the bearing.

The contact owns a 2016 Honda Pilot. The contact stated while driving at an undisclosed speed, several unknown warning lights illuminated, and the vehicle went into LIMP Mode. The contact was able to get the vehicle to the side of the road. The vehicle was towed to the dealer for a diagnostic test, and it was discovered that the crank bearing lock had failed, and the engine needed to be replaced. The dealer was unable to repair the vehicle due to a staffing shortage. The vehicle was repaired by a local mechanic. The manufacturer was notified of the failure, however informed the contact the VIN was not included in a recall. The failure mileage was approximately 115,000.

The Honda stop-start system in this vehicle has a flaw. On this day the engine shut down as normal at a light, but failed to start when the foot was removed from the brake. The engine sputtered and shut back off. This should be a problem if a restart could have been attempted but this failure was so severe that the car had to be put in park and shut off completely. Almost like a reboot of the computer. Once the car was shut off and then powered up again the car could be started and move under it's own power. Even thought I was quick to turn on hazard flashers, cars behind me became angry at the inconvenience, honking and swerving to get around me when the light was green. Honda needs to make a way to attempt to restart after an unsuccessful attempt by the auto start system. The engine has run fine since the event so no issues with the engine can be found. It had to be something minor that prevented the successful firing of the engine.

The contact owns a 2016 Honda Pilot. The contact stated that while operating the vehicle a knocking noise was present coming from the engine compartment. The vehicle was taken to the local mechanic who discovered metal shavings in the engine oil and determined that the engine rod bearings had failed causing severe damage to the engine. The vehicle was not repaired. The mechanic informed us of a manufacturer's recall related to the failure. The local dealer and manufacturer were notified of the failure and informed that the VIN was not included in the NHTSA Campaign Number: [XXX] (Engine, Engine Cooling). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 95,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2016 Honda Pilot EX-L Connecting Rod Bearing Failure. I am the original owner of this vehicle, which has around 98,000 miles on it and now has a serious rod knock. My vin is not covered by the current recall, but I believe it should be. It is unacceptable that a manufacturer fault should not be addressed. Since my car is out of warranty I am on the hook for many thousands of dollars, not to mention the diminished value of a poorly built vehicle.

Connecting rod bearing failed and caused engine failure. Car began inoperable on the highway. Honda has issued recalls on this exact failure but has failed to recall my vehicle. Honda needs to be held liable to investigate my vehicle. This is a rare failure that is ONLY caused my manufacturer defects. This is the third inquiry I am sending and no one has done anything to demand that Honda issues recalls for ALL affected vehicle for the manufacturing defect. Please do your part so I don't have to hire an attorney. Thank you

Message is showing in instrumental panel KEYLESS START SYSTEM PROBLEM. I checked on line found Honda have found this problem with 2016 Honda Pilots. When I called Honda Woodbridge, VA dealer about it she (Customer Service agent) took my Vin and said no there is no recall. On line I found Honda Service Bulletin they do have recall. I am including Pic of vehicle and also Service Bulletin about it. Honda Dealers Should have this information.

After the most recent recall fix was applied, the keyless start system started acting up. It would start, but died after 1 second I have video of this happening. In this video, it fails twice and starts on the third attempt. 03/01

Car engine started knocking a few days ago and yesterday the engine light came on and the car started loosing power even stalling at one point driving. Looks like a connecting rod bearing on bank 2 can be heard clearly. I understand a service bulletin just came out yesterday for this same issue on my year vehicle but I don't see the vin on the list and it should be added to list having the same exact problem. Thank you

Sudden engine knocking noise. Mechanic said the rod bearing is going out.

1) First and most annoying is the start button displays code on the screen "keyless start system problem ". Its done it for about two three now. There is no recall for my VIN. 2) Back wheels brakes make very loud kicking noise when car put in reverse and moves in reverse. It started 4 years ago. I took it to dealership and they said breaks are fine and they don't know why its kicking. In cold weather break sensor displays warning "apply break before putting in park" while breaks are applied. So it can't sense that breaks are applied. 3)blue ray DVD player quit working years ago. 4) Transmission is jerking when switches to third gear. This car has 56000 miles. 5) Roof molding in the front came off while driving. The clips somehow broke and it flew away. This car has been parked in the garage during the day and driven carefully with all needed oil changes and one owner. It should not have this problems. 6) the tires fell apart when car was 4 years old with about 25000 miles on it. The dealership said they don't know why and its was not normal. The top of the tires pilled off in chanks.

The car just stopped while being driven in the freeway around December 2022. It was towed to the dealership and they said that the engine "seized." We wrote a letter to Honda and they said that it was our fault (car has very little miles- it's a family car). The engine light was never resolved even after engine was replaced. Honda then came out with a recall for 2016 Honda Pilot for engine seizing but they said my VIN did not qualify although this was the exact same issue. I tried reaching out with them to no avail. I am afraid to transport my children in this vehicle and I have already spend over 10k fixing it. It also feels unethical to sell the vehicle knowing it's defective. If possible, please look into the VIN's that are part of the recall since I am afraid there are a lot more cars driving in the freeway from the manufacturer that has the same issue which pose a safety concern to the passengers and the cars around it.

Hood cracked due to excessive vibration over the years from late 2015 until latch was repaired by Honda in 2021. Due to the number of years prior to the repair, the hood has cracked and could potentially fall apart or fly up and block the driver's vision.

Getting intermittent exhaust fumes inside the cabin. co2 and other exhaust gasses getting inhaled by my family

I drive have a 2016 Honda Pilot. On a trip from Overland Park, KS to Denver, CO, I exited the interstate and noticed a ticking sound. Turned the radio down, shifted into neutral and accelerated the engine a little. The sound I was hearing accelerated with the engine. Before getting to my destination, the engine light illuminated and an emission warning. I inspected the engine at my destination and the noise is coming from the front of the engine. I took it to an independent repair shop in the morning. They gave me an estimate to remove & replace engine assembly complete - used $8,733.60 or remove & replace short block - New OEM $13,282.63 I did not feel comfortable pursuing repairs in Denver. With the vehicle being unreliable to drive home, I rented a moving truck, trailer and towed the Pilot home. I found in an online chat group, [XXX] that other Pilot owners have has the same issue and a Recall was being issued from Honda due to improper bearing clearance issue. Honda Service Bulletin [XXX] I took the Pilot into Honda Dealership and they said internal noise coming from the lower part of the engine, main bearing failure. Gave me an estimate for a used engine $8,924.70 or new short block $10,694.24 plus $250. Recall was released after the 1st of the year, NHTSA Recall No. : 23V-751 My Pilot fall out of recall being manufactured in February. Less than 7,000 miles ago. I had to replace a cam in this engine and Honda America assisted with repairs as it was abnormal for a cam to

The contact owns a 2016 Honda Pilot. The contact received notification of NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The engine shut down while driving down the highway with no warning. We thought it was just a dead battery but found out from the dealer that the connecting rod in the engine shattered without explanation. The check engine light NEVER came on and there were no other sensory warnings that there was an engine issue. The car has only 81,000 miles and has a solid, documented service record with the dealer so this engine failure was a total surprise. The engine shut down while driving down the highway with no warning. We thought it was just a dead battery but found out from the dealer that the connecting rod in the engine shattered without explanation. The check engine light NEVER came on and there were no other sensory warnings that there was an engine issue. The car has only 81,000 miles and has a solid, documented service record with the dealer so this engine failure was a total surprise. It put the driver, my [XXX] daughter, in danger as the car shut down on a highway at night without warning. She safely pulled the car over to the side of the highway within a construction zone and waited alone in the dark for me to pick her up while cars were passing at highway speeds. This breakdown could have resulted in an engine fire again without warning. The Honda dealer inspected the engine and took photos of the broken connecting rod. I have sent a customer service request to American Honda with the pictures, maintenance records and diagnosis of the issue given by the dealer. INFORMATI

The contact owns a 2016 Honda Pilot. The contact stated while driving at 55 MPH, the engine made abnormal clicking sounds and was shaking while accelerating. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic. The independent mechanic recommended that the contact wait to see if the vehicle was included in an upcoming recall. The vehicle was then taken to the dealer, and it was recommended that the rocket oil pressure switch and an oil change be performed. The vehicle was previously repaired however, the failure persisted. The vehicle was not repaired due to the independent mechanic recommending that the contact wait for a recall. The contact referenced NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling) as a possible solution however, the VIN was not included in the recall. The manufacturer was notified of the failure and stated that assist might be provided under a Good Will Program. The failure mileage was approximately 85,000.

The contact owned a 2016 Honda Pilot. The contact stated while driving approximately 35-40 MPH and approaching the red traffic light, she depressed the brake pedal to come to a complete stop. The contact noticed smoke coming out of the cowl of the vehicle. The contact then turned on the AC and smoke came through the A/C vents. The contact opened the windows. The contact stated that the smoke became thicker and brownish while pulling into the parking lot of a nearby shopping center. There was no warning light illuminated. The contact parked and turned off the vehicle. The contact then noticed that there was a hole in the middle of the hood, and there was a flame coming through the hole. The contact stated that the hood and the windshield became engulfed in fire within 3 minutes even though it was raining. The fire department extinguished the fire, and police officers arrived at the scene, but the contact did not know whether a fire department report and a police report were filed. The vehicle was towed to a tow lot, awaiting to be totaled. The local dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 51,000.

I was driving my vehicle on the highway at approximately 70 kph when the engine seized and all of the warning lights in the dash went out simultaneously. The car would barely accelerate but I was able to pull over and get it towed to a shop. The shop diagnosed total engine failure as a result of tension rod shavings showing in the oil filter. I researched recalls for my model & year and found November 13, 2023 NHTSA CAMPAIGN NUMBER: 23V751000. Although my specific VIN is not yet included, both the model/ year and symptoms of the issue match exactly with what happened to me. I urge you to include my VIN in this recall.

Happening more if we left it on, as default, all the time. We have reported it to our dealer, they "cannot replicate" it and claim "that's unusual" despite knowing there is a massive recall for this exact issue. They claim it needs a tune up, and we fear that your 1% of cars effected estimate is off and not including many more cars being effected by this. This Auto Idle option needs an override that could save lives. Please re-open the investigation, press Honda for information they may not be sharing from their dealerships regarding the extent of this (they're probably not documenting each time someone complains about this, since they can't "replicate it.") Help. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When going a consistent speed, the engine RPM flutters up and down which jerks the car back-and-forth while going around 40 mph. Independent mechanic said there’s something wrong with the VTEC system and one of the cylinders is not getting enough air

I was driving and the engine was making noises and started losing power. I heard a loud noise and the engine died. There is a recall on these engines. and my car is the year make and model.

Hi Sir/Madam, Wish you are going well. I own a 2016 Honda Pilot Touring AWD . Recently on [XXX] while i was driving in it with my family to New York airport the engine suddenly started making some noise and before we could pull over the car to the shoulder the engine got fire , fortunately we escaped by jumping out from the car as soon as we were on shoulder. The car was then towed to the service station and after inspection the service station informed that this is a case of engine failure due to crank shaft connecting rod failure. For repair the engine needs to be replaced and the estimated cost would be around $7000. I checked for 2016 Honda pilot recalls and saw this latest recall XG1 and GG0 which describes the same issue . However, my VIN No. does not show any recalls. Request your kind advice as i am not in a condition to afford the repair, the insurance does not cover this and i am stuck as i cannot to go anywhere without car. Is there any way i can get the car repaired free of cost by Honda ? Do i need to file a lawsuit for that? A Recall law suit is possible? Can I include claims for defective vehicle and negligence as I got the vehicle serviced from Honda Service station recently and they didn’t checked/informed for this issue causing fatal safety concern for my entire family. Looking back for your kind advice. Wish you a wonderful day. Thanks & Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle audio has a kind of its own, on/off/ up/ down all without touching the screen or buttons. Goes all the way to max volume without warning. Definitely a safety risk when you are not expecting noise at all.

Severe risk of carbon monoxide poisoning. At 5:00 am in the morning the alarm on my car went off by itself and there was no way I could turn it off or even start the car. I finally disconnected the battery to stop the car and later reconnected the battery assuming the issue was gone. When I went back to check on the car later, found that the car had started by itself and the garage was full of fumes. I installed a carbon monoxide sensor in all rooms and parked the car outside. The car now randomly tries to start itself(and all warning lights go on and dash indicates an error with all systems) and when it does start(by itself) there is no way to shut it off except for disconnecting the battery. The car is now at the dealership but a quick google search reveals that this is a frequent issue with 2016/2017 Honda Pilots and a part - 38320-TG7-A420 (remote control unit) needs to be replaced and that this part is under serious backorder nationally (indicating a serious problem). Requesting NHTSA to investigate this issue and part.

Had a indicator light for "Emission System" come on. Used fuel injector cleaner on next fill up and the light went out. Light came on again a few weeks later. Ran another bottle of injector cleaner and once again the light went out. A couple of months later the light can back on and the car gave an audible warning to pull over and shut off the engine and to make sure we were not near an ignition source. After a short time with the car off it was restarted. The "Emission System" light stayed on but the car drove ok. We took the car to the dealer. They checked everything and said that the issue was the fuel injectors needed to be replaced. They told us the parts are on a "National backorder" and they have no idea when they will become available. The car is undrivable and remains at the dealership.

The contact owns a 2016 Honda Pilot. The contact stated while driving at various speeds, an abnormal knocking sound was coming from the vehicle. There was no warning light illuminated. The vehicle was taken to a dealer where it was discovered that the engine was damaged due to excessive wear of the connecting rod bearing. Upon investigation, the contact discovered NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling) which was linked to the failure. The vehicle was also taken to an independent mechanic and the failure was verified. The manufacturer was notified of the failure and provided a case number. The vehicle was not repaired. The failure mileage was approximately 74,000.

The entertainment/audio/entire media system malfunctions after 25 minutes of driving, causing extremely loud static that gets louder and louder to the point that you can’t hear yourself think. After several minutes of static the system sound dissapears and cannot be turned on until the vehicle is left off for an underground amount of time.

My engine broke and the 2016 Honda Pilot awd engine locked up and the dealership is saying it’s the same issue as the 2016-2019 recall. Also I own a 2008 Honda element awd windshield cracked. The recall for every Honda Element year except 2008. 2003-2007, 2009-2011. That doesn’t make since either. Phone [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Honda Pilot. The contact stated that while his wife was driving at approximately 45 MPH, the vehicle stalled. The contact stated that there was an abnormal sound coming from the engine compartment before the vehicle lost motive power. The contact's wife continued to drive; however, the vehicle stalled. The vehicle was towed to a dealer where it was diagnosed and determined that the engine needed to be replaced. The contact believed that the failure was related to NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling). The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 101,000.

The connecting rod bearing has gone bad resulting in slippage and engine rod knocking. The bearing has gone bad because the crankshaft was manufactured/machined out of proper specifications per Honda America. The problem in question is already posted on the NHTSA website. “Engine Damage from Connecting Rod Bearing Wear” The noise occurred while driving to North Georgia with seven people in the 8 passenger car. Once we heard the knocking we immediately pulled over, 115 miles from home. Further driving could have caused the engine to seize, slip, or explode. The problem has been confirmed by both a certified master mechanic at the Honda dealership as well as an independent mechanic who worked for a dealer for a number of years. Yes the 2016 Honda Pilot has been inspected by the certified master mechanic at the dealer. There were no warning lights that came on until the time of the noise. Once the noise was apparent the oil lamp, check engine light, and other warning lights began to flash.

Since 2021 the vehicle has stalled everywhere we go and has a gas/electrical burn fume. The vehicle had stalled in the middle of the highway and didn't allow us to shift it into any gears while flashing all dashboard lights. The vehicle was towed to Legend driven Honda where they couldn't find any issues and said they just reset the transmission code. For our peace of mind, we thought it would be best to have the full work up on the transmission since the dealership seemed incompetent with our vehicle's malfunction. The vehicle continued to stall and even had trouble starting up at times with the continued gas fumes. Well, it wasn't long before the issue returned and we were back to where we started, along with our A/C unit failing on us. We left the vehicle idle in the driveway for a bit as it was a safety concern for our families' wellbeing. We later received a recall notice on the auto-idle stop mechanism which we figured must have been the issue all along. We took it back to the dealership where they did their full inspection and came up with our transmission needing its regular full work-up which we had proclaimed that we already had done in the earlier months. After the alleged recall fix, the problem continued. We took the vehicle back and were told it was our battery and recommended our timing belt be replaced otherwise it would cause major issues down the road(it was concerning to us as these issues were never brought up the multiple times we had brought it in for th

While driving on the highway, the vehicle suddenly stalled, and many notifications came up on the dash. Some of the warnings include: emissions system warning, power steering system problem, trailer stability assist problem, power steering problem, hill start assist problem, vehicle stability assist problem, all wheel drive system problem. While driving on highway, the vehicle stalled, lost the ability to steer and brake, and had to roll to the side of the road. There was total engine failure. Dealership diagnostics indicate a problem with crank shaft/ connecting rod, and the entire engine needs to be replaced. There is an existing recall for my year, make, and model of vehicle 2016 Honda Pilot for this exact problem, but it has not been applied to my VIN yet. The recall needs to be extended to cover my vehicle. My family's safety was compromised by complete engine failure on a highway during rush hour.

I am reporting a problem with the 2016 Honda Pilot audio system. It sounds identical to the reported problems that have lead to a recall for the 2018-2022 models. The system works fine initially, but after 30 minutes of driving, the system becomes filled with static noise. The static noise starts out low, but quickly gets to the point where nothing else can be heard. This is across all input channels: AM/FM radio, Bluetooth, XM Satellite, etc.. The system then eventually shuts down and no sound can be heard.

While driving my car started doing a jerking motion as if it wanted to stall. Then all the warning lights the car could possibly have started flashing. All wheel drives engine warning came on as well as emissions systems problem warning light. I was able to park it for the night and made an appt to have it checked but by morning the warning lights were gone. A week later the emissions systems problem warning came back on but went away a fee days later before I could get it to the shop. This problem has happened twice already and I have had to have my fuel pump replaced, the sensor and the fuel injector. At this time my car has trouble starting as if not enough fuel is being injected and the transmission sounds not right.

On December 21, 2023, at approximately 2:25pm, while driving approximately 63 mph on the freeway, my 2016 Honda Pilot suddenly stopped accelerating and I was unable to accelerate the vehicle. During this time, I received several dashboard warning notifications. These notifications stated the following: -Blind Spot Info System Problem. -Stop Driving When Safe. Transmission Problem. See Manual. -Transmission Problem. Apply Parking Brake When Parked. -All Wheel Drive System Problem. -Emission Systems Problem. I pulled over to the shoulder and parked my vehicle. While parked, I was still unable to rev the engine, and the warning indicators continued to flash on my dashboard. I turned off the vehicle. After a few minutes, I turned on the vehicle. At this this time, I was able to rev the engine by pressing on the gas pedal. All of the indicator warnings disappeared with the exception of the Emission Systems Problem. I drove home and parked the vehicle. For the remainder of the day, the vehicle was not used. On the following day, I turned on the vehicle and noted that there were no dashboard warnings. Additionally, I was able to rev the engine by pressing on the gas pedal. For the next 14 days, the vehicle operated normally with no issues. (PS. I attempted to upload the photos of the warning indicators but your NHTSA application is not working properly.)

My vehicle stalled and had a horrible noise while stalling. Dealership took it back to their shop as we thought if was due to yhe work they just finished and after inspecting they determined a rod bearing had spun. The safety issue is we stalled out on the highway in the middle of traffic, almost got into several wrecks with my child in the vehicle. Only light that came on while stalling was the check engine light.

The contact owns a 2016 Honda Pilot. The contact stated that the vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 21V932000 (Structure, Latches/Locks/Linkages). The contact stated that while driving at high speeds, the hood vibration was visible after the recall repair. No warning lights were illuminated. The vehicle was taken back to the dealer and the contact was informed that the hood needed to be replaced due to a crack. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 108,481.

These 4 warning lights keep coming on such as lane keep assist problem, adaptive cruise control problem, collision mitigation system problem, and road departure mitigation system problem. Many Honda Pilot owners report this ongoing issue with no real solution. This is a serious concern that needs to be looked into further.

All warning lights came on Vehicle stability assist (VSA) Problem, Hill Street Assist Problem, Trailer Stability Assist (TSA) Problem, Power Steering System (EPS) Problem, Emissions System Problem. Car was stalling and sometimes not starting at all. Took it in to the Honda dealer in mid November 2023 and they said it was reporting low fuel pressure but that it was probably low fuel in the tank that caused the issue and not to worry about it since the warning lights were off. After a month, the car stalled while diriving in the middle of the highway and all warning lights came on again. Had trouble starting car again but I was able to drive it my local mechanic which told me I had to replace both fuel pumps since they were the cause of my issues. I ended up getting both pumps replaced at a cost of $2,250.00. After reading about the Honda recall last week for 2017-2020 fuel pumps exhibiting the same symptoms, I dont think it's coincidence that my 2016 Pilot model is also having the same problem.

Components that failed: engine blew up on a Freeway; car experienced oil leaks; air conditioner stopped working; electrical problems- windows and sunroof suddenly open on their own. Facts: In Feb. 2019, I bought a certified preowned 2016 Honda Pilot with 40K miles. I drove it for less than a year before COVID-19 began and I started working from home. Shortly after I bought the car, it started leaking engine oil, which Honda later repaired. In summer 2021, the air conditioner system stopped working. On June 4, 2023, I was driving the vehicle on the 57 Freeway, Northbound, when my engine suddenly blew up and failed in the middle of the Freeway. The sudden engine failure put me and others at risk of serious injury. Since purchasing my car, I had my car regularly serviced by a Honda dealership. After inspecting my car, the Honda dealership said they did not know what caused the engine to blow up. There were no warnings, messages, or other symptoms before the engine failure.

There was a recall on the fuel injectors system and now this problem is causing the computer system to send false codes to the car and then the warning “fuel emissions problem signs turns on showing false code problems and then they go off and back on” In April I had fuel injections done and now in December I got the emissions system problem signal and was told at a honda service location that it was faulty Catalina converter problem but the emissions system problem signal tuned off on its own a day later, mean while the honda service place told me it would cost me $2287 to correct a problem that didn’t need to get repaired it’s this faulty emissions system computer system that needs to be updated on all these vehicles with this emission system problem. If they up date the program that they use on the emissions system we will not have to pay for false readings codes that are being generated because of this false reading by the emissions system soft ware.

The contact owns a 2016 Honda Pilot. The contact stated that while his wife was driving and stopped at a traffic light, the light turned green, and the contact's wife depressed the accelerator pedal however, the vehicle failed to respond as intended. The check engine warning light illuminated, and the engine seized. The vehicle became inoperable in traffic on a busy street. Additionally, the other drivers were honking horns. The contact's wife was able to restart the vehicle and drive the vehicle to her residence. The vehicle was taken to the dealer where it was diagnosed with a seized piston and a fractured rod. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 109,000.

I was sitting at a light. The car started idling funny. Then stalled. Never started again. Dealer is telling me something is loose in the engine. I saw a recall for honda pilots, but the vin numbers were XX1 and GG0. My vin is [XXX] , what is the difference. *The engine failed. Yes available for inspection. *If engine fails while driving on highway. Car completely shut down. * No dealer did not open up engine because I can't afford to pay for them to look and see what happened would cost roughly around 1,000.00. *Dealer looked at it just told me that something is loose in engine. Suggest I put in new or rebuilt engine. * Yes the engine light came on about 30 seconds before car completely shut down. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have a 2016 Honda Pilot Touring and just recently had to have the engine replaced at 135k miles due to crankshaft failing, causing damage to the engine. This happened before the recall for the crankshaft came out. Honda is trying to say my VIN is not covered. NHTSA recall report states production dates of May 2016-June 2016. Sticker on my Pilot says manufactured 05/16. Can't wait to see how Honda will try to wiggle their way out of reimbursing me for engine replacement.

All wheels are loosing air pressure because of corroded wheels. this can be a road hazard if the driver didn't notice the pressure all the time

My 2016 Honda Pilot Touring keeps stalling at traffic lights and randomly on the road. We just took it to the dealer last week and received the "we can't replicate the stalling, please bring it back when it happens again." They checked the battery and found it healthy. A couple times, the car has refused to restart until several minutes after the stall and sometimes it has taken several presses of the "Start" button before it finally engages the starter. The car completely shuts down when this occurs. Nothing works.

The dash began displaying 4 error codes EPS problem, VSA problem, Hill Assist problem, and TSA Problem. It began to jerk and lose power similar to running out of gas necessitating hazard lights and pulling off the road x3 after dark. 3 different shops ran a diagnosis code of P0369. The recommendation from Honda after having the car three days was to replace #2 cylinder head assembly at an estimate of $6400! There would also be no guarantee that this repair would fix the problem. The vehicle only has 83,000ish miles. After speaking with American Honda, they were aware of this problem but said my vin number wasn’t included in the pool of “faulty manufactured parts” but did say that didn’t mean that I didn’t get faulty parts though. The vehicle is no longer under warranty. I just paid this vehicle off in May. This certainly doesn’t support Honda’s reputation as being a manufacturer of reliable vehicles. I have never owned a used vehicle that required this depth and cost of repair. I am waiting on their Goodwill Review to see if they decide to help me with this. The two representatives including a case manager I spoke with didn’t seem as though it was likely going to happen.

ENGINE MADE NOISE. ENGINE STOPPED SUDDENLY ON HIGHWAY. VEHICLE WITH 3 OCCUPANTS HAD TO BE TOWED FROM HIGHWAY AND TRANSPORTED TO HONDA DEALERSHIP FOR REPAIRS. VEHICLE HAS BEEN INSPECTED AT GUNN HONDA, 14610 I-10 W SAN ANTONIO, TX ADVISED BY THE DEALER THE VEHICLE WILL REQUIRE EXTENSIVE (REPLACE ENGINE) REPAIRS. THERE IS A RECALL FOR 2016 HONDA PILOT (23V751000) FOR CONNECTING ROD BEARING HOWEVER THIS VEHICLE DOES NOT FALL WITHIN THE MFG WINDOW.