2023 Heartland Bighorn

Defect. Heartland Recreational Vehicles, LLC (Heartland) is recalling certain 2023 Elk Ridge, Lithium, 2024 Eddie Bauer, Corterra, 2023-2024 Big Country, Big Horn, South Fork, Fuel, Gravity, Mallard, North Trail, Sundance, Milestone, Pioneer, Prowler, Torque, and Trail Runner fifth wheels and travel trailers. The LED backlight circuit board in the cooktop range may fail, causing the board to overheat.

Risk. A circuit board that overheats increases the risk of a fire.

Remedy. Dealers will disconnect and cut the circuit powering the LED backlights and terminate the wiring, free of charge. Owner notification letters were mailed May 9, 2024. Owners may contact Heartland customer service at 1-877-262-8032.

Defect. Heartland Recreational Vehicles, LLC (Heartland)) is recalling certain 2023 Big Country and Big Horn fifth wheels. The federal certification label may have incorrect tire information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, " Wheels and Rims-Other Than Passenger Cars."

Risk. Incorrect tire size information can allow an incorrectly sized tire to be installed, increasing the risk of a crash.

Remedy. Heartland will mail owners replacement certification labels, free of charge. Owner notification letters were mailed May 31, 2023. Owners may contact Heartland customer service at 1-877-262-8032.

Defect. Heartland Recreational Vehicles, LLC (Heartland) is recalling certain 2022 Cyclone, Elk Ridge, Fuel, Milestone, North Trail, 2022-2023 Big Horn Traveler, Gravity, Lithium, Mallard, Pioneer, Prowler, Road Warrior, Sundance, Torque, and Trail Runner travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.

Risk. An awning that drops or extends beyond normal operation can increase the risk of injury.

Remedy. Dealers will inspect and repair, or replace the awning, free of charge. Owner notification letters were mailed by September 8, 2022. Owners may contact Heartland customer service at 1-877-262-8032.

Range is installed in our Heartland RV. Suburban put out a TSB to have silicone placed at wiring connections on stove knobs under stove top. Then they put out a recall to disconnected and cap the wiring for the illumination of the stove knobs and the oven lighting. The range has an issue with the temperature control that it doesn’t reach indicated temperature. The main issue is that when the pilot is lit and you set it to a temperature like 300 degrees it lights okay. But, after a few minutes the burner goes out and so does the pilot. You have to continually relate the pilot and each time turn the range to a higher temperature to keep the burner in the oven on to cook anything. Suburban has indicated that it is a manifold issue on the top of the stove but has not provided any corrective action or recall on any of this. The Range should be recalled and replaced.

The contact owns a 2023 Heartland Bighorn built on a 2019 Mercedes-Benz Sprinter chassis. The contact stated that while the awning was opened, the front passenger’s side the awning fractured. The contact stated that the water tank also filled up with water independently. On another occasion, while pulling the stairs, the screws to the handle detached. The RV was taken to the dealer and the RV was repaired. On another occasion, while turning on the water, the contact became aware that the water was not heated as needed. The vehicle was taken to the dealer and the battery was replaced; however, the lights inside the RV were low. The RV was diagnosed by an inspector sent by the manufacturer and stated that a ground wire was loosened. The contact was informed that the RV was unsafe to operate. The RV was not repaired. The manufacturer was contacted but did not provide any assistance. The failure mileage was unknown.