2015 Grand Design Solitude

Defect. Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.

Risk. An electrical arc increases the risk of a fire.

Remedy. Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.

Defect. Grand Design RV (Grand Design) is recalling certain model year 2015-2016 Momentum toy haulers and Solitude recreational trailers manufactured July 8, 2014, to August 31, 2015, equipped with certain aluminum black ladders manufactured by Christianson Industries. These ladders have retractable hinges, each with a welded 'top hat' that can separate from the hinge.

Risk. If the hinges separate from the ladder while in use, the ladder may fall from the vehicle, increasing the risk of injury.

Remedy. Grand Design will notify owners, and dealers will install a bracket over the back of existing hinges, free of charge. The recall began on December 16, 2016. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910008.

GREASE SEALS FAILED AND GOT GREASE OVER ALL THE BRAKES AND BACK PLATES AND WHEELS

WHILE DOING A ROUTINE INSPECTION WHILE TRAVELING FOUND I HAD LEAKING WHEEL SEALS WHICH ARE KNOWN BY MANUFACTURER TO LEAK. IMMEDIATELY TOOK TO REPAIR SHOP DURING TRAVEL FEARING GREASE WOULD GET ON MY BRAKES AS MANY OTHERS HAVE REPORTED. THE VERY NEXT DAY WHILE TRAVELING, UPON ARRIVING AT RV SITE REALIZED I HAD A BROKEN SPRING ON THE RIGHT REAR AXLE. VEHICLE COULD NOT BE MOVED UNTIL REPAIRS WERE MADE. THESE TWO ITEMS ARE NOT ONLY UNSAFE FOR THE DRIVER AND OCCUPANTS BUT COULD HAVE EASILY CAUSED AN ACCIDENT AND DEATH. I FEEL THE SPRINGS AND AXLES ARE OF VERY POOR QUALITY AND UNDERSIZED FOR WEIGHT OF VEHICLE. UPON INSPECTION OF BROKEN SPRING FOUND THAT THE SECOND LEAF HAD BEEN BROKEN FOR SOME TIME CAUSING THE TOP SPRING TO BREAK.

PURCHASED NEW IN 2015. FOLLOWING 4000 TO 5000 MILES OF TRAVEL, I EXPERIENCED BRAKE FAILURE ON TWO OF THE FOUR WHEELS ON THIS FIFTHWHEEL RV TRAILER. WENT TO MECHANIC AND REVEALED ALL FOUR SETS OF BRAKES SATURATED WITH GREASE FROM FAILED WHEEL BEARING GREASE SEALS. TWO OF THE BRAKE MAGNETS WOULD NOT FUNCTION DUE TO A HEAVY LAYER OF GREASE. THIS IS ALL FACTORY INSTALLED PARTS THAT WERE NOT DUE FOR SERVICE FOR ANOTHER 6000+ MILES. THIS TRAILER WEIGHS 15000 POUNDS. I WAS FORTUNATE TO CATCH THE PROBLEM BEFORE DESCENDING A STEEP GRADE WHERE DISASTER WAS SURELY WAITING.

ON CURB SIDE WHEELS THERE WAS EXCESSIVE GREASE LEAKAGE INTO BOTH ELECTRIC BRAKE ASSEMBLIES. OBVIOUS SEAL/GREASE FAILURE. IN ADDITION ON REAR WHEEL, THE MAGNET ASSEMBLY WAS ALSO NOT SECURED AND "FELL OUT" WHEN HUB WAS TAKEN OFF. WAS ABLE TO CLEAN UP AND REPACK FRONT WHEEL, BUT REAR WHEEL WAS DAMAGED BEYOND REPAIR. PICTURES OF REAL WHEEL DAMAGE INCLUDED. PROBLEM IDENTIFIED DURING ROUTINE MAINTENANCE, APPROXIMATELY 15,000 MILES ON RV. LIPPERT WAS THE MANUFACTURER OF THE AXLE/WHEEL ASSEMBLY THAT WAS INSTALLED ON THE SOLITUDE 379FL.

TOOK MY 5TH.WHEEL TO GENERAL RV TO HAVE WHEELS REPACKED WITH GREASE. RIGHT SIDE,BOTH WHEELS BRAKES FULL OF GREASE,NO BRAKES ON RIGHT SIDE . PHOTOS TAKEN AND SENT TO GRAND DESIGN SERVICE BECAUSE LESS THAN 1 YEAR OLD.