2019 GMC Sierra 1500 complaints

The contact owns a 2019 GMC Sierra 1500. The contact stated that while his wife was driving at an undisclosed speed and approaching a stop, the vehicle lost motive power. There was an abnormal exhaust odor and smoke coming from the exhaust pipe. The engine and fuel lights were illuminated. The vehicle was towed to the local dealer and was diagnosed with a misfire in cylinder #5, and the exhaust lifters and camshaft needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 50,000.

Rear sliding glass window is leaking water around the exterior frame. This is addressed in TSB 18-NA-383 but not covered under any warranty. My rear seats and carpet are becoming wet. I am concerned about the possibility of mold and an electrical short/fire resulting from water intrusion. There are many reports and discussions on the internet regarding this issue. Full window replacement estimated at $1300. Patchwork repair with caulk is estimated at $600 with no guarantees of success. I would expect GMC to cover the replacement of the rear glass in kind and remedy any other damage to my vehicle due to water intrusion into the cabin area.

I was driving back from getting breakfast and the truck started to smoke and the truck just shut off on the street. As soon as the truck shut off, I received an alert on the dash that told me not to exceed a certain speed, but the truck was not moving at the time. I tried to restart the truck and I received another alert that said to put the truck in neutral and I ended up having to push the truck to a safe space. I call a tow truck to take the vehicle to the dealership for evaluation. I later spoke with the representative at the dealership and she told me that my 6.2L V8 engine had seized up. She could not tell me why it happened.

While driving My 2019 GMC Sierra I heard a loud Bang And lots of Misfires. The vehicle immediately slowed on its own causing me to pull off the road and endanger myself and traffic around me. Engine light came on and the traction control light was flashing. The Vehicle was brought to Dealer where they Diagnosed the problem all lifter rods were frozen and the cam shaft was cracked. The Dealer has the affected parts.The vehicle was in the repair shop for over two weeks and close to 7,000.00 in repairs.

Rear powersliding window leaks on passenger side

I do not know if this qualifies as a safety concern, however based on everything I have read, I wanted to report the incident since you have 39 cases already. My 2019 GMC Sierra Denali w 6.2l engine, and 60,000 miles, starting tapping on April 10, 2025. I brought it to the local dealership the following day to diagnose. The dealer reported that they located metal in the oil pan/ filter and said the engine needed to be replaced. After more reading, it seems my truck is one of the vehicles with the 6.2l engine that is failing in countless numbers. In all fairness, I did not crash, the engine did not seize and it did not create a safety hazard in my incident, so i apologize if this reporting is a waste of your time. Now i have been given an invoice for over $10k to replace the engine which is on backorder nationwide I'm told due to the number of engine failures. Obviously it is out of 5 year 60K mile warranty so I have to eat the engine replacement.

WHILE TURNING INTO A BUISNESS FROM A HIGHWAY, THE LOW FUEL WARNING CAME ON EVEN THOUGH I HAD JUST FILLED THE TANK. UPON LEAVING THE BUISNESS, I STARTED THE TRUCK AND PUT IT INTO REVERSE AND THE ENGING STALLED. RESTARTED THE TRUCK AND PUT IT INTO REVERSE AGAIN AND IT STALLED AGAIN. RESTARTED AND TRIED GOING FORWARD AND IT RAN FINE. ABOUT 1 MILE DOWN THE ROAD THE LOW FUEL WARNING CAME ON AGAIN AND THE ENGINE STALLED WHILE TRAVELING APPROXIMATELY 35 MPH. AT THIS POINT I REALIZED THAT THE DOORS HAD UNLOCKED AND THE INSTRUMENT CLUSTER GAUGES KEPT SWEEPING UP AND DOWN. I TRIED TO RESTART THE ENGINE BUT IT WOULD NOT TURN OVER. IT ACTED LIKE THE BATTERY WAS DEAD. AFTER WATING SEVERAL SECONDS, I TRIED AGAIN AND THE ENGINE RESTARTED. I NOTED THE BATTERY VOLTAGE IN THE INSTRUMENT CLUSTER AND IT WAS NORMAL. NO WARNING LIGHTS ON IN THE INSTRUMENT CLUSTER. NO DTCS PRESENT WHEN CHECKED WITH A GENERIC SCAN TOOL. MY SAFETY WAS PUT AT RISK BECAUSE THE ENGINE STALLED WHILE DRIVING IN TRAFFIC. I HAVE NOT TAKEN IT TO THE DEALER YET AS THEY ARE NOT OPEN TODAY AND I WANTED TO REPORT THIS WHILE ALL THE DETAILS WERE FRESH ON MY MIND.

I had engine failure two weeks after a schedule maintenance that included a tune up. When the engine failed all the components made the vehicle impossible to operate much less bring to a stop safely. I had to get the vehicle towed to the dealer. The dealer confirmed that the engine (6.2 V8) has a known documented issue. The vehicle is at my dealer with the engine being disassembled. There weren't any warnings as I stayed on the maintenance schedule that the dealer mapped out since my purchase. The problem began [XXX]. After researching the issue I found this online. That is how I found your web site. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2019 GMC Sierra 1500. The contact stated while the vehicle was parked, the driver's side tail pipe flange bolts connecting the tail pipe and the muffler snapped, causing the tail pipe to hang down. There were no warning lights illuminated. The contact had gone underneath the vehicle and saw that the muffler was disconnected from the tail pipe and that the exhaust bolts had snapped. The dealer was contacted, and an appointment was scheduled to have the vehicle repaired; however, the vehicle was not yet repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 107,105.

Engine oil coolant lines leaking at crimped fittings. Known problem on 2019 GMC Sierra Pickups 1500, under customer satisfaction program N212326940, known to affect in areas of very cold temperature weather, North Dakota where we live is extremely cold -45 deg F in winter. Risk of total oil loss and engine failure. Dealer replaced lines with no reduction in price for a known failure. Warning leaking oil on my driveway, filled engine, scheduled appointment and dealership replaced lines at full cost. This program to replace the lines at no charge should apply to all 2019 GMC 1500s that develop the leaks.

I bought this vehicle at 80k miles and I have had an on going issue with the transmission. I have done research online and found that GM had put the wrong fluid in the transmission from the factory that has caused internal issues with the transmission leading to hard shifting and transmission shuttering. On my dime I have changed the fluid twice already and also the torque converter as well. This issue has gotten better but still a problem. This has caused me to not be able to trade my truck with out being upside down because of the dealers telling me they would have to put a new transmission to sell it. So now my trucks value has dropped as well. Now I am stuck in a truck that is not safe to drive. Thanks GM for not helping me.

The contact owns a 2019 GMC Sierra 1500. The contact stated that the vehicle was taken to the local dealer for a routine oil change. The dealer informed the contact that the oil level was low. The contact stated while driving at 25-30 MPH, the low oil pressure message was displayed. The contact pulled over and there was oil on the ground. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Action Number: PE25001 (Engine and Engine Cooling). The vehicle was towed to the local dealer again, where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 127,000.

Transmission keeps skipping missing gears and hard shifting, as well as jolting forward. When attempting to switch lanes vehicle transmission skips. When being placed from Park to drive or any other gear vehicle transmission hard shifts. Vehicle radio and screen shut off intermittently every 30 to 45 minutes. Vehicle screen goes blank and black and resets itself after 30 to 45 minutes.

Transmission has been failing for the life of this vehicle. Shuttered shifting and hard shifting are the norm. It is available for inspection. Vehicle does not shift properly when vehicle is in motion. Shifting is often delayed resulting in temporary loss of power. I have had the vehicle in to a transmission shop they have been able to reproduce the events. There are no warning lights visible to indicate an issue.

The contact owns a 2019 GMC Sierra 1500. The contact stated while driving 75 MPH, the vehicle occasionally downshifted or unintendedly came to a stop. There were no warning lights illuminated. The vehicle was taken to a dealer and the vehicle was diagnosed and the contact was informed that the transmission software needed to be updated. The vehicle was repaired; however, the failure persisted. The contact stated that on another occasion, the vehicle started to turn off unintendedly at traffic lights. The vehicle was taken to a different dealer and the vehicle was diagnosed and it was determined that the valve body software needed to be updated. The vehicle was repaired; however, the failure persisted. The contact stated that on another occasion, the vehicle started to vibrate violently while driving on the highway. The vehicle was taken to the original dealer and the dealer replaced the transmission; however, the failure persisted. The vehicle was taken to a different dealer and the vehicle was diagnosed with torque converter failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 48,000.

2024 the lifters when out in the engine and were replaced 2025 the engine malfunctioned while driving on the highway. There were messages that came up of low oil pressure and the engine completely locked up The dealership is saying the engine needs to be replaced

The contact owns a 2019 GMC Sierra 1500. The contact stated that while his wife was driving 60 MPH, the engine seized, nearly causing a crash. The driver was able to veer to the side of the road. The check engine warning light was illuminated. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that the engine had seized and needed to be replaced. The dealer informed the contact that the upper part of the engine was previously rebuilt, and that the current failure was related to the lower part of the engine. The dealer informed the contact that there was a cost for the repair. The manufacturer was notified of the failure and offered a discount towards the repair. The dealer later informed the contact that the manufacturer would partially cover the repair cost. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: PE25001 (Engine, Engine and Engine Cooling). The failure mileage was approximately 100,000.

The contact owns a 2019 GMC Sierra 1500. The contact stated while accelerating from a complete stop, the vehicle hesitated and the transmission experienced a hard shift to first gear. Additionally, the contact stated that the vehicle was shuddering while driving at slower speeds. There was no warning light illuminated. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. The failure mileage was approximately 38,000.

On 04-03-2025 while driving southbound in DFW International Airport. My Vehicle losses power in the Construction zone at 2:20 pm. Had enough momentum to maneuver to Terminal A exit stopping Midway up ramp. Danger to public if vehicle stopped on highway during the start of heavy traffic in construction zone with no soft shoulders for emergency's. No warnings from the cluster panel ever came up. on attempting to restart, check engine light illuminated after the fact. No Help! Vehicle is at Dealership currently awaiting further info.

This incident happened without any warning at all on [XXX]. while driving 45mph on county road, the engine seemed to not be firing on all cylinders. Loss of power was immediate. accompanied by a rhythmic nocking that was felt and heard. I pulled off and called a tow truck. The engine is a 5.3 liter v8. At Pete Moore Chevrolet they said it was a failure of the number 8 cylinder valve lifters. that all lifters need replaced along with the camshaft due to scarring. Found through research that this is a frequent problem with engines 2014-2021. See - [XXX] , et al, vs General Motors LLC. (brought by Berger Montague) filed in the US District court of Eastern Michigan. Alleging defective valve lifters causing near or catastrophic engine failure. NHTSA has 39 active cases as well. Contacted GM Customer Satisfaction Program 3/27/25. Case #[XXX]. Goal to see with their prior knowledge of this issue could they help repair or replace the engine. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Transmission hesitates. Transmission jerks when shifting. Possible torque conversion issues. Mileage is 35,623.

I was driving down the road, got a quick message. It said something about lean and to pull over (on dashboard). And by the next stop light the engine stopped. The truck no longer turned on. It did put my life in danger because it left me stranded in between two lanes. The truck was inspected by one of my mechanic friends who owns a shop. He let me know my engine is seized.

While I was driving the engine started to lose power on the highway going about 70 mph with my four kids in the car. I had to quickly exit the highway and pull over. I was uncomfortable continuing operating the vehicle and had to get it to the closest GMC dealership which was in Killeen Texas. (Patriot Buick GMC). Upon diagnosis, I was informed that the lifters were damaged and needed to be repaired. Once the technician started the disassembly he noticed that the lifters caused damage to the cam shaft resulting in additional repairs which totaled approximately $8700 in damages/repairs required. I started to research this as the lifters typically do not fail in vehicles that are 80,000 miles or less. While conducting research I noticed that this is a common problem in the GMC Sierra 1500 to the point there is a lawsuit against GMC right now. I am frustrated because I believe that there should be a recall as the safety of my kids and I were put in danger for a part that is commonly failing in this vehicle.

When going to shut off vehicle, when you push the push start button the engine will turn off but the radio and all the instrument panel, gauge lights, and dinging noise are still on. It states on the screen to shift to park. The vehicle is in park and even sometimes has the parking brake on. It can stay on from 1 minute to numerous minutes, which is only running my battery and other things down on my truck. This has happened daily.

Transmission started fluttering around 60k miles. Per GMC Dealer - this is due to water getting into transmission from fluid put in at the factory. Even though dealer admitted that it's a defect from the factory, the warranty wouldn't cover the repair. This is a well known issue in the 5.3L 8 speed trans.

Engine keeps running out of oil I’ve taken it several times to the dealership sometimes there was no oil in it. Only has 80,000 miles problem started 2 years having it

The contact owns a 2019 GMC Sierra 1500. The contact stated while driving at approximately 20 MPH and making a left turn, the vehicle shook violently. The contact stated that no warning light was illuminated. The contact stopped the vehicle and turned off, and restarted the vehicle. The vehicle was restarted, but after shifting into drive(D), and depressing the accelerator pedal, the vehicle failed to exceed 30 MPH. The contact stated that the vehicle was making an abnormal "roaring" sound. The contact stopped the vehicle and had the vehicle to be towed to the dealer. The dealer diagnosed the vehicle and determined that the valve body on the transmission needed to be replaced; however, the part to complete the repair was on a national back order. The vehicle was not repaired. The manufacturer was informed of the failure. The contact stated that the failure was the second transmission failure. The contact had the transmission replaced in 2024 by the same dealer. The failure mileage was approximately 84,000.

ENGINE FAILURE. CAM BEARINGS FAILURE. ENGINE SEIZED UP. SAFETY ISSUE: TRAVELING ON HIGHWAY TOWING A FISHING BOAT. PULLED OFF FOR FUEL. ENGINE COMPLETELY SEIZED UP WHILE AT GAS PUMP. IF IT HAD IT SEIZED UP BEFORE PULLING OFF HIGHWAY FOR GAS, GREAT RISK FOR A CATASTROPHIC CRASH, ESPECIALLY WHEN PULLING A BOAT TRAILER. ALL SYSTEMS INCLUDING STEERING SHUT DOWN. JOHN JONES CHEVROLET DEALERSHIP IN SCOTTSBURG INDIANA RAN DIAGNOSTICS AND CONFIRMED COMPLETE ENGINE FAILURE. FAULTY CAM BEARINGS SEIZED UP. ENGINE IS RUINED AND MUST BE REPLACED. INSPECTION BY JOHN JONES CHEVROLET DEALERSHIP. WE HAD BEEN ON THE HIGHWAY FOR 3.5 HOURS WHEN PULLED OFF FOR GAS. THERE WERE NO WARNING SIGNS. NO CHECK ENGINE LIGHTS, NO LIGHTS AT ALL ON THE DASH. NO UNUSUAL SOUNDS OR SMOKE. NOTHING UNUSUAL BEFORE THE ENGINE SEIZED UP.

The truck had been parked for about 4 hours, after a 250 mile trip. I cranked it and started driving to return home. I heard an intermittent squealing noise while driving. I had driven only about 2 miles when the engine suddenly shut down in heavy traffic on a four lane divided highway. I managed to get the truck into the median and stop. I was left stranded in the middle of the highway. It turns out the the engine bearing went bad and ruined the engine. I will now have to replace the engine at a cost of about $15,000.00. This is a safety concern when the engine suddenly failed and stalled while driving on a four lane divided highway, in heavy traffic.

Valve train/camshaft fairlure which damaged entire engine - happened at 99,650 miles

The passenger side lifters in my truck failed while at idle/5mph speed causing catastrophic engine failure. 2019 6.2L V8 from GM. From my own independent research, and the research/survey of others online, this appears to be a very common problem as a result of known defective parts that were installed on GM engines.

While attempting to accelerate to get onto the expressway with no warning, the vehicle went into limp mode. Traction control, front end warning collision, auto/stop start functionality was all disabled and the engine light warning light on came on. The vehicle locked out and reduced acceleration. An attempt to pull over and turn the vehicle off for a few seconds was made. Once restarted, the vehicle continued running on limp mode at reduced speeds with the same indicators mentioned still disabled and locked out.

I was driving down [XXX] near Harrisburg PA in an active construction zone when the truck shut off, the dash blinked a few things very rapidly then went black. I was barely able to coast to an area large enough to get my truck out of the highway traffic. I was stranded on the side of the highway for 4 hrs and due to the construction hardly able to get out of the truck safely as it was around a bend. I’ve had to have the truck towed to a few mechanics to learn that it has suffered a catastrophic engine failure as all cylinders have lost compression. It made no noise at all. There was no signs this was going to happen, just driving normally then a complete engine failure resulting in no compression in all 8 cylinders with no noise. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Lifters in engine failed at beginning of March 2025 and destroyed inside of engine. Transmission failed in summer of 2024 and had to be replaced

It blew a hole through the engine block. The engine is a 6.2 L 87

Cylinder 5 failure and cam shaft miles 78k. Have to replace full top end or brand new motor cost $10k up to $13k to fix at dealer

Bad torque converter with 56000 miles and a month out of warranty and GM says to bad.

I was traveling north on interstate 95 and approaching my exit ramp. I was initially in the inside lane of travel. I accelerated to merge into the outside lane, between two other vehicles, and then onto the exit ramp. Once on the exit ramp, I let off of the throttle and the engine suddenly shut down. I noticed a message on driver information center instructing me to shift the vehicle into neutral and press "start again". The engine had shut down without any warning whatsoever. I complied with the instructions to no avail. The truck is over half full of fuel. I was within an hour of home after completing an approximately 8 hour, 500 mile, round trip over 2 days of driving. After this event, I connected an OBD2 scanner and the only code found was P25A2 brake system control module. I placed the truck in park and tried repeatedly to start the engine. It would not turn over, crank or start. I had power to all systems and no other codes. I had to have the truck towed from the scene. The truck's performance had previously been flawless during this entire trip and had given me no warning whatsoever of the sudden engine shutdown. This is extremely dangerous and a safety concern.

Driving on the highway, while accelerating, heard a mechanical failure from the front end of the vehicle and had immediate loss of power, and reduction in performance/handling. The engine light came on and three warning messages; Service ESC, Service Parking Brake & Steering Assist is Reduced Drive with Care. Fortunately, the local GMC dealer was the next exit which is where the truck is currently located. The truck was inspected by the dealer and determined the engine should be replaced. It is available for inspection upon request. I have pictures of the warning messages and the work order from the dealer of their findings to date.

While driving at low speed the power assisted steering quit working. I could steer but with great effort. Drove two blocks home. Shut it off and restarted. Everything was fine after restarting. I’m afraid to drive the vehicle after this experience.

While driving at 65 mph on a freeway, the engine failed and cracked a rod with fresh oil and all maintenance done regularly. Truck brakes would not work after engine failure. Truck was fully disabled and I was stranded on freeway @ 90,000 miles. Lights on exterior of the vehicle were dim after engine failed

The contact owns a 2019 GMC Sierra 1500. The contact stated while driving approximately 20 MPH, the vehicle came to a screeching stop. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the electronic brake control module had short-circuited and there was a miscommunication, which engaged the parking brake and locked up the rear wheels. The vehicle was not repaired. The vehicle was previously taken to the same dealer on two occasions and repaired under NHTSA Campaign Number: 19V889000 (SERVICE BRAKES, HYDRAULIC, SERVICE BRAKES, ELECTRONIC STABILITY CONTROL (ESC); however, the failure recurred. The manufacturer was contacted and opened a case, but no additional assistance was provided. The failure mileage was approximately 7,000.

Accelerating from a stop, 1st and 2nd gear hard shifts. gm previously changed program and type of fluid. said this was normal

Vehicle was having trouble accelerating, like the parking brake was on. Then received a message that the brake system failed, lane assist failed, and I couldn’t drive faster than 43 mph. Then a message about the trailer brake appeared

This morning, while driving to work, my truck was operating smoothly without any prior warning signs. Suddenly, the dashboard displayed a message indicating "Low Oil Pressure" and instructed me to turn off the vehicle. There were no preceding alerts, such as check engine lights or low oil pressure indicators. As I was preparing to follow the instructions, the vehicle dashboard displayed another message directing me to put the truck in neutral, and then the engine automatically shut off. Unfortunately, after this occurred, I was unable to restart the truck.

The transmission failed and GM will not provide parts to repair the truck. Only has 57000 miles

My transmission keeps on jerking all the time when we are driving

On a normal trip to work the dash light lit up then gave me these warnings. Service ESC, Service Trailer brake, Brake system Failure-62 mph top speed, steering assist reduced. Dashboard lights that were on, ABS Check Engine, Brake, Traction Control. When I tried to slow down the power assist was gone on the brakes, I had a little braking when I pushed the pedal all the way to the floor as hard as i could, when I went to turn the wheel was hard to turn. I have had no issues like this before. After I managed to stop and turn off then on the vehicle everything came back expect for a warning to service the trailer brakes and the check engine light was still on. It all cleared after a few more restarts. I got the truck to the dealer 4 days later and they said it was the battery going bad even though I was not having any problem starting the vehicle, I had them replace the battery. I am unsure if the problem is resolved, time will tell. What I am sure of is if my daughter had been driving the truck, she would not have had the strength to get the brakes to work or turn the wheel, she would have had a accident for sure.

I was driving to work on Saturday morning [XXX]. As I pulled out of the stop sign and approached 45 mph the engine stop. Making me a hazard within the road. I had to abruptly pull off into a road/yard in order to be safe. All while not having a power as the engine completely stopped. Upon investigation the dealership, Budd Baer in Washington Pennsylvania confirmed the engine had seized up due an issue in rotating assembly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Engine failure. Lifters failed causing internal engine damage. No previous warning. 160000 miles. Repair cost is $5000