Owner reports filed with NHTSA about this vehicle, newest first and reproduced as filed. They are unverified accounts: one proves nothing, and a pattern across many is the thing worth reading. Back to the full 2005 record →
SOMETIMES STEERING IS HARD TO STEER AS IF IT HAS NO POWER STEERING. INSTALLED NEW POWER STEERING PUMP CLEANED ALL LINES & INSTALLED NEW FLUID. HAVE HAD FRONT END CHECKED TWICE. TWO DIFFERENT MECHANICS, CANNOT FIND ANY PROBLEMS. PROBLEM HAPPENS VERY OFTEN. *TR
I WAS ON MY WAY TO PICK MY KIDS UP AFTER SCHOOL AND AS I APPROACHED A RED LIGHT I PRESSED THE BRAKE PEDAL AND IT WENT COMPLETELY TO THE FLOOR. NO DASH ABS INDICATOR LIGHT OR WARNING LIGHT SHOWING ANY FAULT CODE CAME ON BEFORE OR SINCE. FORTUNATELY, I NEVER FOLLOW CLOSE IN TRAFFIC AND WAS ABLE TO STOP MY VEHICLE USING THE EMERGENCY BRAKE, WITHOUT ANY INCIDENT AND NOBODY GETTING HURT. SHORTLY AFTER THIS INCIDENT I SAFELY RETURNED HOME BY USING THE EMERGENCY BRAKE AND PARKED THE VEHICLE. SINCE IT WAS DARK OUTSIDE WHEN I GOT HOME I LEFT ALL UNTIL THE NEXT MORNING TO TAKE A LOOK. THE FOLLOWING MORNING BEHIND MY LEFT FRONT TIRE ON THE GROUND WAS A PUDDLE THE SIZE OF A SOFTBALL AND IT WAS BRAKE FLUID, I LOOKED UP AND TRACED IT TO A CORRODED/RUSTED/INFERIOR BRAKE LINE. I CALLED THE LOCAL GM DEALER AND WAS ADVISED THERE WAS NO RECALL ON MY PARTICULAR VEHICLE BY VIN FOR THIS ISSUE, SO I THEN CALLED GM CUSTOMER CARE AND EXPLAINED WHAT HAD TOOK PLACE AND GM HAD IT TOWED TO A LOCAL DEALER. CURRENTLY MY VEHICLE IS AT THE DEALERSHIP IN SERVICE AND AS I AWAIT WORD ON GM'S POSITION ON WHAT THEY INTEND TO DO TO CORRECT THE ISSUE I CAME ACROSS THIS SITE AND A COUNTLESS LIST OF OTHER GM CUSTOMERS THAT HAVE EXPERIENCED THE SAME PROBLEM. I SECURED A GM CASE NUMBER, TOOK PHOTOS OF THE CORRODED/RUSTED/INFERIOR LINES AND WILL AWAIT WHAT I HOPE WILL BE THE APPROPRIATE RESPONSE FROM GM, WHICH IS TO CORRECT THE PROBLEM FREE OF CHARGE. I'LL UPDATE THIS VEHICLE SAFETY COMPLAINT WITH THE RESPONSE I RECEIVE
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN UNRELATED REPAIR WHEN THEY NOTICED THAT THE REAR BRAKE LINE WAS RUSTED NEAR THE WHEEL WELL. IN ADDITION, THE FRONT DRIVER'S SIDE BRAKE LINE WAS REPLACED FOR THE SAME DEFECT. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 03/07/14*LJ UPDATED 03/13/2014 *JS
THE REAR SPEAKERS ON MY 2005 GMC SIERRA 1500 CREW CAB QUIT WORKING AND HAVEN'T CAME BACK ON. I HAVE BEEN TO DIFFERENT FORUMS AND THIS SEEMS TO BE A VERY COMMON OCCURRENCE. *TR
THE BRAKE LINE RUNNING FROM THE ABS MODULATOR TO THE REAR BRAKES FAILED CAUSING LOSS OF BRAKING ABILITY. I WAS ABLE TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. *TR
RECENTLY, I SPENT THREE DAYS PERFORMING PREVENTIVE MAINTENANCE ON MY 2005 GMC SIERRA AND FOUND TWO PRIMARY ISSUES THAT SHOULDN'T BE OCCURRING ON THIS YOUNG OF A VEHICLE. THE FIRST WAS ROTTED SECTIONS OF BRAKE LINE (SUPPOSED TO BE STAINLESS STEEL) IN THE REAR OF THE VEHICLE (THE MAIN LINE THAT COMES BACK FROM THE MASTER CYLINDER) AND THE SECOND ISSUE WAS A LEAKING SEAL IN THE POWER STEERING PUMP. THERE IS A CONSIDERABLE NUMBER OF PEOPLE WITH THE SAME PROBLEM WHO HAVE QUALIFIED FOR A RECALL OR WORK TO BE DONE UNDER A TECHNICAL BULLETIN, BUT APPARENTLY MY VIN LIES OUTSIDE OF THE ACCEPTABLE RANGE. *TR
WHILE DRIVING FORWARD IN TRAFFIC WHEN CAR CUT IN FRONT FROM THE NEXT LANE TO THE RIGHT. THIS REQUIRED EMERGENCY BRAKING, BUT MY SPEED WAS SLOW AND TRUCK SHOULD HAVE STOPPED WITHIN THE SPACE AVAILABLE AND THE TRUCK BRAKES SEEMED TO FEEL AS IF THEY RELEASED ON THEIR OWN. DAMAGE OCCURRED TO THE CAR I REAR ENDED AND THEY REAR-ENDED A CAR IN FRONT OF THEM. DAMAGE TO ALL 3 VEHICLES WAS LIGHT ENOUGH THAT ALL WERE DRIVEN AWAY AFTER CRASH. ON THE WAY HOME I NOTICED THE BRAKES WERE NOT WORKING PROPERLY AND LOST STOPPING POWER SHORTLY AFTER DEPRESSING THE BRAKE PEDAL EACH TIME. AFTER A 2 MILE TRIP HOME LIKE THIS I CHECK THE BRAKE FLUID AND FOUND IT LOW. THEN I SAW FLUID ON THE GROUND AND FOUND THE BRAKE LINE WAS DRIPPING BRAKE FLUID. IT APPEARS TO HAVE RUPTURED FROM THE PRESSURE OF THE FLUID INSIDE. THE LINES WERE ALSO SERIOUSLY CORRODED. THIS APPEARS TO BE A PROBLEM IN MATERIALS AND MY 1985 SUBURBAN SHOWS ALMOST NO SIGNS OF CORROSION ON THE BRAKE LINES AND IS 20 YEARS OLDER. I WAS TICKETED FOR RECKLESS DRIVING FOR NOT STOPPING BECAUSE THE CAR THAT CUT IN FRONT MADE IT ALL THE WAY TO THE CENTER OF THE LANE BEFORE I STRUCK IT. THAT CAR WAS BEHIND ME AND WENT AROUND ME AND CUT IN FRONT BECAUSE I WAS ?DRIVING TOO SLOW? ACCORDING TO HER. I HAD LEFT TWO TO THREE FULL CAR LENGTHS IN FRONT OF ME AND THIS BOTHERED HER. I HAD A GOOD AMOUNT OF DISTANCE TO STOP THE TRUCK EVEN AFTER SHE CUT IN FRONT, BUT THE TRUCK WAS UNABLE DUE TO THE LINE BREAKING WHEN I PUSHED THE PEDAL HARD. THE LINE SHOULD BE
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT WAS DRIVING 10 MPH AND AFTER APPLYING THE BRAKES, BRAKE FLUID DISCHARGED FROM THE BRAKING SYSTEM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE BRAKE LINES WERE RUSTED. THE VEHICLE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 61,000.
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THE SENOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ABS ENGAGED WITHOUT MANUAL FORCE AS THE ABS LIGHT ILLUMINATED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 54,000.
LOOKED UNDER MY TRUCK AFTER MY BRAKES FAILED WHILE DRIVING TO WORK. WAS SURPRISED AT HOW RUSTY ALL THE LINES ARE. AAA TOWED MY TRUCK HOME. I SPENT THE NEXT 3 DAYS REPLACING BRAKE LINES. NOW I NOTICED THE LINES FROM THE MASTER CYLINDER ARE RUSTY AS WELL. NOW I WILL HAVE TO REPLACE THOSE AS WELL. I'VE NEVER HAD BRAKE LINES RUST OUT LIKE THESE HAVE. MY WIFE DRIVES A LITTLE 1999 ESCORT AND THE BRAKE LINES ON THAT ARE FINE. WHAT THE HECK THIS IS ALL THE USE YOU CAN EXPECT ON A GMC SIERRA? *TR
DRIVING THE TRUCK ON DRIVEWAY WHILE PLOWING. BRAKES FAILED DUE TO ROTTEN BRAKE LINES CAUSING TRUCK TO SLIDE OFF DRIVEWAY INTO AN EMBANKMENT. NEED TO BE TOWED OUT OF REVINE & TO MECHANIC. *TR
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE EXITING A RESIDENTIAL DRIVEWAY, THE BRAKES FAILED. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE STEEL BRAKE LINES AND THE CALIPERS WERE SEVERELY RUSTED AND WOULD NEED TO BE REPLACED. THE CONTACT WAS ALSO INFORMED THAT THE FRONT DRIVER'S SIDE BRAKE LINES WERE RUPTURED, DUE TO THE SEVERITY OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 67,772. *TR
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE BRAKE LINES FRACTURED DUE TO CORROSION. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 96,146.
SPEEDOMETER SHOWS INCORRECT SPEED BY APROX. 20 MPH LESS THAN THE ACTUAL SPEED AT TIMES. *TR
TL- THE CONTACT WANTED TO USE THE COMPLAINT THAT WAS SENT VIA EMAIL. JO I PURCHASED THIS USED GMC SIERRA P/U IT HAD GOODYEAR WANGLER ATS TIRES. I WAS DRIVING ON OUR HIGHWAY 3 IN IOWA AND I WAS PASSING A BUS, AT ABOUT 70MPH THE TIRE SIDEWALL EXPLODED I HAVE A PICTURE TO SEND YOU IF YOU WANT TO SEE IT. LEFT FRONT TIRE. THERE WERE PLENTY OF TREAD AND THE AIR WAS AT PROPER NUMBERS. I WON'T BUY ANOTHER WANGLER BUT THINK IT WAS IMPORTANT TO LET YOU KNOW. UPDATED 01/14/13 *BF UPDATED 01/17/2013 *JS
SPEEDOMETER READING ERRATICALLY. 20MPH WHEN PARKED, SOMETIMES 40 WHEN PARKED. UNABLE TO DETERMINE ACTUAL SPEED. APPARENTLY THIS IS AFFECTING THOUSANDS OF GM VEHICLES AND GM KNOWS ABOUT THIS ISSUE BUT WON'T DO ANYTHING ABOUT IT. MAYBE A CLASS ACTION LAWSUIT IS IN ORDER? A SILENT RECALL IS IN PLACE IF YOU HAVE LESS THAN 80K MILES, IF YOUR VEHICLE FALLS WITHIN THE RANGE OF VIN #'S, IF IT HAPPENED ON A DAY THAT DOESN'T END IN Y. GM NEEDS TO BE RESPONSIBLE AND STAND BEHIND THEIR PRODUCT. ESPECIALLY IF THEY KNOW ITS A SAFETY ISSUE. *TR
THREE MONTHS PRIOR I LOST POWER STEERING BECAUSE OF A METAL LINE LEAK. THEN COMING UP ON TRAFFIC I'M APPLYING THE BRAKES AND THE PEDAL WENT TO THE FLOOR, LUCKILY I WAS ABLE TO PULL ONTO THE SHOULDER OF THE ROAD TO AVOID AN ACCIDENT. HAD I NOT BEEN ABLE TO PULL ON THE SHOULDER MY GMC WOULD HAVE SLAMMED THE VEHICLE IN FRONT OF ME AND WOULD HAVE PUSHED THAT VEHICLE INTO THE CAR IN FRONT OF THAT ONE. HAVE NOT GOTTEN THE TRUCK BACK FROM THE SHOP YET BUT I COULD SEE BRAKE FLUID LEAKING FROM A METAL BRAKE LINE. 2005 GMC 88,000 MILES THIS IS MY FIRST GMC AND MY LAST. I THINK ALL GMC PRODUCTS SHOULD BE RECALLED AND FIXED!! *TR
AS I WAS LEAVING HOME MY HOME AND APPROACHING STOP SIGN, MY BRAKES GAVE OUT. I LOCATED AN AREA NEAR THE REAR LEFT AXLE WHERE THE BRAKE LINE WAS CORRODED AND BURST. INSPECTION OF THE BRAKE LINES SHOWS EXTENSIVE CORROSION ALONG THE ENTIRE LINES. *TR
I BOUGHT MY GMC USED IN 2008 AND I HAD NO PROBLEMS UNTIL A JUNE OF 2012 WHEN MY SPEEDOMETER STARTED TO GET MY SPEED TOTALLY WRONG. AT TIMES IT WOULD SAY I WAS DRIVING OVER 120 MPH OR WHEN IN IDLE IT WOULD EVEN SAY THE SAME THING. THE SPEEDOMETER PICKS A DIFFERENT SPEED DAILY. JUST A FEW WEEKS AGO IN JULY OF 2012 MY GAS GAUGE WENT COMPLETELY OUT SO I HAVE NO IDEA HOW MUCH GAS IT LEFT IN MY TRUCK. I HAVE TO GUESS BY MILEAGE NOW IN HOPES THAT MY ELECTRICAL DOESN'T GO COMPLETELY OUT NOW. *TR
I FOUND 2 BROKEN EXHAUST MANIFOLD BOLTS ON MY 2005 SIERRA (70, 717 MILES), 1 ON EACH SIDE, 1 WAS ACTUALLY MISSING & THE OTHER WAS JUST HANGING THERE, I THEN WENT TO CHECK MY WIFE'S VEHICLE, A 2003 CHEVY TAHOE ( 90,420 MILES) & THAT ALSO HAS 2 MISSING , 1 FROM EITHER SIDE, YOU CANT IMAGINE HOW SICK I AM AT THIS POINT, BOTH OUR VEHICLES ARE IN NEED OF MAJOR REPAIRS, PLEASE TELL ME THAT GENERAL MOTORS WILL NEED TO RECALL THESE VEHICLES & MAKE THE NEEDED REPAIRS, SICK TO MY STOMACH & CASH STRAPPED, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 45 MPH THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS. THE MECHANIC STATED THE AIR BAG SENSOR WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 51,800. ... UPDATED 08-07-12 *BF THE CONSUMER STATED HIS VEHICLE WAS REPAIRED. UPDATED 08/09/12
WHILE APPLYING THE BRAKE TO SHIFT INTO DRIVE, THE BRAKE PEDAL "WENT TO THE FLOOR". PUMPED BRAES ONCE AND STILL NO PRESSURE. WAS ABLE TO HEAR THE LEAK UNDER THE DRIVER SIDE AND BRAKE FLUID WAS OBVIOUS UNDER THE TRUCK. INVESTIGATION REVEALED THE ONE OF THE LINES RUSTED THROUGH AT THE PLASTIC CLIP TO SECURE IT TO THE FRAME NEAR THE DRIVERS SIDE FLOOR BOARD. *TT
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT NOTICED THAT THE SPEEDOMETER WAS NOT PROVIDING A READING. THE DEALER WAS MADE AWARE OF THE FAILURE AND THE TECHNICIAN STATED THAT THE INSTRUMENT CLUSTER WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 50,200.
GAUGE CLUSTER FOR MY 2005 GMC SIERRA IS NOT WORKING PROPERLY. SPEEDOMETER, ENGINE COOLANT TEMPERATURE & TRANSMISSION TEMPERATURE GAUGES STICK, FLUTTER, OR BECOME INOPERATIVE CAUSING INACCURATE READINGS. *TR
GAS GAUGE NOT WORKING ON 2005 GMC 1500 PICKUP. *KB
AIRBAG ALERT IS ON DASH OF MY SIERRA, AT 38,000 MILES--DEALER SAYS THEY HAVE TO CHECK IT OUR; NO IDEA WHAT COULD CAUSE THIS. I HAVE NEVER HAD SUCH A PROBLEM WITH ANY HONDA PRODUCT I HAVE EVER OWNED--MANY SINE 1985. *KB
TL* THE CONTACT OWNS A 2005 GMC SIERRA K1500. WHILE DRIVING 25 MPH, THE CONTACT STATED THAT THE VEHICLE LOSE POWER STEERING AND HE WAS UNABLE TO STEER THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT THE POWER STEERING LINE HAD RUSTED AND CAUSED IT TO LEAK POWER STEERING FLUID. THE DEALER OR MANUFACTURER HAD NOT BEEN NOTIFIED. THE VEHICLE WAS AWAITING REPAIRS. THE CURRENT AND FAILURE MILEAGES WERE 56,600.
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT THE INSTRUMENTAL PANEL FAILED AND THE GAUGES WERE NOT READING ACCURATELY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND THEY ADVISED THE CONTACT THAT THE INSTRUMENTAL CLUSTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT HE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
ODI #10403836, 2005 GMC 1500 SIERRA, VIN#, COMPLETE FAILURE OF DASH INSTRUMENTS, STARTED WITH THE OIL GAUGE, THEN THE RPM INDICATOR, NOW THE SPEEDOMETER, RUNS UP TO 120 MPH SEVERAL TIMES A WEEK ONLY GOING AT UNKNOWN, UNSAFE SPEED WHICH I CAN ONLY ASSUME TO BE THE LEGAL LIMIT OF 70 MPH, THIS IS A SAFETY ISSUE AS WELL AS A MONETARY LOSS FOR ACCIDENTS AND OR SPEEDING TICKETS. IN ADDITION THE INSTRUMENT LIGHT FOR THE TRANSMISSION DOES NOT WORK AND YOU CAN NOT TELL WHAT GEAR YOU ARE IN ANOTHER POTENTIALLY DANGEROUS SITUATION, ON TOP OF THAT THE CHECK ENGINE LIGHT COMES ON REPEATEDLY CAUSING MINOR REPAIR COSTS EACH TIME IT OCCURS. THERE HAS TO BE CUSTOMER RECOURSE, WHEN THIS ORIGINALLY STARTED THE DEALERSHIP STATED THAT NOT TO WORRY AS SOON A RECALL WOULD BE ISSUED AS IT HAD FOR THE PRIOR YEARS, AS YET NO OFFICIAL RECALL OTHER THAN THE TRANSMISSION PANEL LIGHT FAILURE WHICH CURRENTLY COVERS 7,194 VEHICLES BUT GMC STATES THAT MINE IS NOT COVERED? ONE WONDERS WHY WHEN THEY SAY QUALITY IT IS A JAPANESE AUTO! IF INDEED ALL OF THE CONSUMERS WITH A COMPLAINT FOR THIS PARTICULAR PROBLEM WOULD GATHER UNDER A LEGAL ACTION, I AM SURE THAT GMC WOULD HAVE TO COMPLY AND REPAIR AND SOME POINT IN TIME. I HAVE OWNED GMC AUTOS AND TRUCKS ALL OF MY LIFE, I CURRENTLY HAVE A 77 CHEV. PICK UP THE INSTRUMENTAL PANEL STILL WORKS, I HAVE A 1995 GMC SIERRA THE INSTRUMENT PANEL STILL WORKS, I HAVE LEFT INSTRUCTIONS WITH MY FAMILY THAT IF I AM IN A WRECK DUE TO EXCESSIVE SPEED AND OR MISTAKENLY PLACE THE VEH
TRUCK IS NOW 6 YEARS OLD, JUST OVER 70,000 MILES. 3 TO 4 YEARS AGO (MAYBE MORE) THE #5 SPEED ON THE AIR SYSTEM BLOWER STOPPED WORKING. PERHAPS LAST SUMMER OR FALL, I CHECKED THE FUSES: ALL GOOD. I FINALLY FOUND THE WIRING HARNESS PLUG TO THE FAN AND FOUND THE #5 LINE HAD MELTED INSULATION AND THE SURFACE OF THE CONTACT PRONGS BLACKENED. I SANDED THEM AND REINSTALLED THE PLUG. ALL SPEEDS WORKED, FOR A WHILE, BUT SOON BECAME INTERMITTENT. THEN ALL SPEEDS STOPPED WORKING TOTALLY. AT LAST, I REMEMBERED THAT I STILL HAD AN EXTENDED WARRANTY WITH MASTERTECH, CHECKED IT AND WAS ABLE TO GET THE HARNESS REPLACED UNDER THE WARRANTY. THE WORKMAN WHO DID THE REPAIR SAID THAT THIS ITEM WAS A COMMON PROBLEM WITH THE 2005 SIERRA. WHILE I DO NOW HAVE A WORKING FAN CONTROL, I AM AFRAID TO USE THE #5 FAN SPEED. *TR
NOTICED VEHICLE VIBRATION FROM THIS FIRST WEEK I BOUGHT THE TRUCK. THE DEALER SAID THEY WILL LOOK AT IT AND FIX ANY PROBLEM..THEY LOOK AT THE TRUCK AND SAID THE VIBRATION WAS NORMAL. I WENT TO THE AUTOMOBILE COMPLAINT CENTER AND HAD A JUDGE LISTEN TO THE "LEMON" ISSUE. THE JUDGE ORDER A DIFFERENT MACHANIC TO EVALUATE THE TRUCK. HE DID AND SAID "YES IT VIBRATES TOO MUCH". THE JUDGE ASKED THE GMC COMPANY REP WHAT COULD BEEN DONE. HE SAID THE SAME THING THAT I HAVE READ BEFORE... THAT IS TO PUT 500 LBS IN THE REAR OF THE TRUCK. THAT DID NOT HELP. AT ABOUT 45 MPH LIKE TIRE OUT OF ROUND. AT 55 MPH AND GREATER, VIBRATION FELT LIKE TIRE OUT OF BALANCE. GM TELLS ME PROBLEM IS NORMAL, WILL NOT CORRECT. GM CALLS THE PROBLEM "BEAMING", AND SUGGESTS PLACING 500 LBS IN BED OF TRUCK. TRIED THIS AND VIBRATION STILL EXISTS. TRUCK SHAKES SO BAD AT 65 MPH THAT MY WIFE WHATED TO GET A HEAVY DUTY BRA. , . . THE VEHICLE NOW HAS DEVELOPED A HARMONIC NOISE AT 45 MPH AND LESS, WHICH THE DEALER TELLS ME IS ALSO NORMAL AND WILL NOT REPAIR. *NM *TR
SERVICE AIRBAG LIGHT HAS COME ON 3X IN THE LIFE OF THIS VEHICLE (AT 99,500 MILES CURRENTLY). FIRST WAS FOR RIGHT FRONT AIRBAG SENSOR. - REPLACED AT A COST OF 300+ DOLLARS AROUND 65K MILES. SECOND WAS SEAT SENSOR - RECALIBRATED IT, NO CHARGE. NOW AT 99,500 MILES MY LEFT FRONT AIRBAG SENSOR IS BAD. - REPLACED IT MYSELF AT A COST OF $100. AIRBAG ISSUES AT THIS LOW OF MILEAGE IS UNACCEPTABLE. *TR
SPEEDOMETER DOESN'T WORK CORRECTLY, READING 60 MPH WHEN WE WERE TRAVELING APPROX 40. ALSO BULBS BURNED OUT IN IT MAKING IT UNREADABLE AT NIGHT. BULBS ARE NON-REPLACEABLE IN THIS INSTRUMENT CLUSTER, SO YOU NEED TO REPLACE ENTIRE CLUSTER TO FIX BULB ISSUE. POOR DESIGN, EXPENSIVE, AND ANNOYING PROBLEM AT ONLY 99,000 MILES. *TR
FUEL TANK VENT SYSTEM PLUGS UP WITH DUST. - CAUSES FUEL TO SPILL WHEN USING AUTOMATIC FILLERS, ALSO SERVICE ENGINE SOON LIGHT. - HAD TO REPLACE CANISTER (FULL OF DUST) AND PURGE SOLENOID AT 95,000 MILES. *TR
WAS ON MAIN ROAD GOING 50MPH AND APPROACHING STREET THAT I LIVE AT, APPLIED BRAKES TO SLOW DOWN, AND PEDAL WHEN TO FLOOR. I THEN STARTED TO DOWNSHIFT INTO LOWER GEARS AND APPLIED EMERGENCY BRAKE TO STOP. I HAD VEHICLE TOWED TO REPAIR SHOP AND CAUSE WAS METAL BRAKE LINE TO RIGHT FRONT WHEEL WAS RUSTED OUT. ALSO ALL THE OTHER LINES WERE VERY RUSTY AND SHOULD BE REPLACED.....OTHERWISE OTHERS WILL GO SOON AND IT WILL HAPPEN AGAIN. IT WAS MENTIONED THAT GMC AND CHEVY TRUCKS IN A CERTAIN YEAR RANGE (SUCH AS THIS) HAVE THIS PROBLEM BECAUSE THE ANTI-LOCK SYSTEM IS LOCATED NEAR THE FRAME AND THUS ALL LINES ARE EXPOSED TO SALT ETC.......WHERE AS IN A CONVENTIONAL DESIGN THE ANTI-LOCK SYSTEM IS LOCATED ON THE FIRE WALL AND ONLY ONE LINE (THE LINE THAT GOES TO BACK) IS EXPOSED TO SALT ETC AND IS USUALLY MADE OF RUST PROOF MATERIAL. THE BRAKE LINE THAT IS USED ON THIS TRUCK IS MADE OF CHEAP STEEL WHICH WILL RUST.....NOT RUST PROOF LINES SUCH AS "ARMOR COAT TYPE BRAKE LINES". THIS REPAIR COST ME $700 2ND ITEM: WHILE ON THE SUBJECT OF BRAKE SYSTEM ON THIS TRUCK.....I HAVE FOUND THAT IN CERTAIN CONDITIONS THAT THE ANTI-LOCK BRAKE SYSTEM IS TOO SENSITIVE AND CAN ACTUALLY MAKE THING WORSE UNDER CERTAIN CONDITIONS. *TR
THE RIGHT FRONT AXLE STARTED ROTATING IN THE HUB ASSEMBLY, ABS LIGHT CAN ON AND IT STARTED TO MAKE GRINDING SOUND IN MY 2005 GMC SIERRA, THE REPAIR WAS DONE AT THE DEALERS; THE SERVICE MAN SAID THAT WAS THE SECOND ONE OF THESE FAILURES HE HAD SEEN. *TR
2005 GMC SIERRA TRUCK WITH 5.3L MOTOR. EXHAUST MANIFOLD BOLTS FAILURE. *TR
SPEEDOMETER FLUXUATE SPORADICALLY, WRONG SPEED SHOWING. TOOK TO DEALER, DIAGNOSIS AS COMPONENT FAILURE. GMC ACKNOWLEDGE PROBLEM, BUT REFUSE TO RECALL. DEALER WILL REPLACE ODOMETER IF LESS THAN 80,000 MILES. *TR
I DID NOT HAVE AN ACCIDENT WITH THIS VEHICLE. I AM FILING THE COMPLAINT BECAUSE I HAVE PREVIOUSLY TAKEN MY VEHICLE TO BOB JEANNOTTE PONTIAC-GMC TRUCK, INC., PLYMOUTH, MI 48170 (734) 453-2500 TO HAVE AN INSPECTION FOR RUSTED BRAKE LINES AS WELL AS RUSTED FRAME ON THE ABOVE LISTED INCIDENT DATE. MY INVOICE # IS GCCS189900 AND MY CUSTOMER ASSISTANCE PROVIDED CASE # IS 71-784-24265. I WAS TOLD IT WAS NORMAL FOR THE CONDITIONS BY THE DEALER REP. THIS VEHICLE IS HAVING CONTINUAL RUST PROBLEMS TO BOTH THE BRAKE LINES AND FRAME. I AM FILING THIS COMPLAINT AS I UNDERSTAND THERE IS AN ONGOING INVESTIGATION INTO THIS PROBLEM UP TO YEAR 2003 AND WOULD LIKE MY VEHICLE YEAR TO BE INCLUDED IN THESE INVESTIGATION ISSUES.
RUSTED BRAKE LINES AND FRAME. *TR
2005 GMC SIERRA WITH 68,000 MILES HAD WHEEL BEARING FAILURE ON PASSENGER SIDE. VEHICLE HAD TO BE TOWED TO THE REPAIR SHOP DUE TO MY FEAR OF POSS LOSS OF STEERING CONTROL. *TR
THE SPEEDOMETER HAS STARTED ACTING ERRATICALLY ON MY 2005 GMC SIERRA WITH 70,000 MILES. IT WILL READ 20 TO 30 MPH LESS THAN ACTUAL SPEED. THIS HAPPENS ERRATICALLY SO I HAVE TO MONITOR THE TACH TO MAKE SURE I AM CLOSE TO THE POSTED SPEED, MAYBE. *TR
SPEEDOMETER FAILED AT 68,000 MILES. IT STICKS ALL THE WAY PAST 120 MPH. CAN'T SEE HOW FAST I'M GOING, DEALER REFUSES TO FIX IT. TRIED THREE DEALERS. *TR
FOUR WHEEL DRIVE FUNCTIONS INTERMITTENTLY. REPLACED SWITCH AND TRANSFER MOTOR. EVERY 6 MONTHS FOUR WHEEL DRIVE BECOMES INOPERATIVE OFTEN AFTER A HIGHWAY RUN. COSTS TO REPAIR HAVE EXCEEDED $1000. CONVERSATIONS WITH OTHER OWNERS OF SIMILAR VEHICLES, INCLUDING SILVERADOS, EXPERIENCE SIMILAR ISSUES. *TR
TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN HE NOTICED THAT THE REAR TAIL LIGHT ASSEMBLY WAS HANGING ABNORMALLY FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE DEALER REPLACED THE TAIL LIGHT ASSEMBLY. THE FAILURE MILEAGE WAS 78,500 AND THE CURRENT MILEAGE WAS 81,000. UPDATED 02/02/11 *CN
ANTI-LOCK BRAKE FEATURE ENGAGES AT LOW SPEEDS (APPROX 5 MPH AND BELOW) WHICH CAUSES INCREASED STOPPING DISTANCE. THIS IS A CONSTANT PROBLEM AT THESE SPEEDS. NO REPAIR HAS BEEN MADE YET. THIS PROBLEM IS THE SAME AS REPORTED BY THE NHTSA PRIOR TO THIS MODEL YEAR. REFERENCE RECALL NUMBER--05V379000. *TR
ABS ACTIVATES AT LOW SPEED ON DRY PAVEMENT. *TR
MY 2005 GMC SIERRA 1500 4X4 PICKUP'S SPEEDOMETER WILL NOT GO BELOW 45 MPH AND PEGS OUT AT 120 MPH. THIS HAPPENED SUDDENLY, IT HAS BEEN THIS WAY FOR OVER 1 WEEK. I HAVE TRIED TURNING ON AND OFF, LEAVING OFF AND RESTART. DEALERSHIP SAYS NO RECALL; NOT THEIR RESPOSIBILITY.. ANOTHER SHOP WILL CHARGE OVER $600.00 TO REPAIR IN WHICH I DO NOT HAVE. I READ ON LINE THAT THERE ARE THOUSANDS OF GMC'S WITH THIS ISSUE. WHERE IS HELP FOR THE CONSUMER???? *TR
AIRBAG LIGHT INDICATOR LIGHT DOES NOT TURN OFF. SERVICE AIR BAG INDICATOR IS ON WHEN THERE HAS BEEN NO ACCIDENT OR BUMP TO THE VEHICLES. *TR
NHTSA publishes every complaint as the owner wrote it and investigates only a fraction. Spelling, capitalisation and judgement are the filer’s own. What carries weight is repetition: the same component failing the same way across many filings, and whether the manufacturer eventually opened a recall for it.
Full record for the 2005 GMC Sierra 1500 → · Every Sierra 1500 year → · How the figures are calculated →