1991 Ford Taurus complaints

THE CAR WOULD QUIT AND WOULDN'T START, A WRECKER SERVICE HAULDED IT IN TWICE. I HAD TO LEAVE IT WHERE IT WAS OVERNIGHT TWICE. I HAD IT HAULED TO BROWN'S AUTO IN PAINTSVILLE THE LAST TIME, WHERE IT STAYED FOR 1 MONTH. THEY DID A DIAGNOSTIC COMPUTER CHECK, TOLD ME THE IGNITION CONTROL MODULE WAS BAD, I HAVEN'T BEEN ABLE TO GET IT FIXED YET BECAUSE FORD ISN'T MAKING PARTS. THIS HAS BEEN OVER A YEAR. I LIVE IN KY. I HAVE TO PAY TAXES ON THIS TO LET IT SIT.*AK

VEHICLE STALLED AND WOULD NOT START . CONSUMER HAD A FRIEND PUT A FUEL PUMP IN, AND VEHICLE STILL WOULD NOT START. CONSUMER HAD VEHICLE TOWED TO DEALER, AND THEY PUT A MULTI FUNCTION RELAY SWITCH IN, AND VEHICLE STARTED. CONSUMER NOTICED THAT UPON RECEIVING VEHICLE INERTIA SWITCH POPPED OUT. THIS BUTTON STOPPED FUEL SUPPLY FROM GOING THROUGHT CAR. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

THE TRANSMISSION THAT FAILED IS A REPALCEMENT TRANSMISSION, INSTALLED BY A FORD DEALERSHIP, 3 YEARS AND LESS THAN 12,000 MILES AGO. IT HAS BEEN REPAIRED BY AN INDEPENDENT TRANSMISSION SPECIALIST. FORD REFUSES TO DO ANYTHING FOR US SINCE THE REPLACEMENT TRANSMISSION WAS OUT OF WARRANTY. IT HAS BECOME OBVIOUS TO US THAT FORD IS WELL AWARE THAT THESE TRANSMISSIONS ARE JUNK.

WHILE DRIVING, VEHICLE WOULD PULL AND THE STEEING WHEEL WOULD VIBRATE AND ONCE THE STEERING WHEEL WOULD VIBRATE, THE VEHICLE WOULD NOT GO ANY FASTER THAN 55-65 MPH, CONSUMER PURCHASED NEW TIRES, BUT THERE STILL IS A SLIGHT PULL IN THE VEHICLE.*JB

WHILE TRAVELING AT 45 MPH DRIVER AIR BAGS DID NOT DEPLOY, RESULTING IN INJURY TO DRIVER. FORD HAS BEEN NOTIFIED. ALSO RESTRAINTS DID NOT LOCK WHEN BRAKES WERE APPLIED. *AK THE VEHICLES CRASH IMPACT CAUSED THE TRANSMISSION TO SLIP AND DAMAGES TO WINDSHEILD,FRONT BUMPER AND OIL STICK HOLDER. *YH

VEHICLE WAS INVOLVED IN AN ACCIDENT IN WHICH FUEL AUTOMATIC SHUTOFF VALVE DID NOT ENGAGE. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER.*AK

VEHICLE WAS INVOLVED IN AN ACCIDENT IN WHICH DRIVER'S AIR BAG DID NOT DEPLOY. DEALER/MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

AFTER MAKING A STOP WHEN DEPRESSING GAS PEDAL TO GAIN SPEED VEHICLE WOULD NOT TRAVEL. PLEASE PROVIDE FURTHER INFORMATION.*AK

LATCH FOR HATCHBACK POPS OPEN. LIFTGATE LIGHT IS CONSTANTLY ON WHEN HATCH IS CLOSED, AND IF IT'S OPENED LIGHT STAYS ON. DEALER DISCONNECTED CABLE. OUT OF 3 REPLACED LATCHES NONE OF THEM WORKED CORRECTLLY. MANUFACTURRE DOESN'T MAKE THE PART ANYMORE, SO LATCH DOES NOT WORK THE SAME AS THE ORIGINAL MODEL FOR VEHICLE.*AK

TOTAL REPAIRS 3400.00 AT A TIME WHEN MONEY IS VERY SCARCE AS I AM RETIRED AND ON A VERY LIMITED INCOME. I EXPECTED TO MAINTAIN SMALL REPAIRS, BUT WITH TAKING CARE OF THE VEHICLE AND THE LOW MILEAGE, I BELIEVE THE AXELS/ BRAKES AND TRANSMISSION ARE VERY PREMATURE AND MAYBE THE A/C. AT 37168 MILES, THE CAR SHOULD BE RUNNING LIKE NEW.*AK

RECALL 98V323/ SUBFRAME BOLT CORROSION. CONSUMER RECEIVED RECALL LETTER, TOOK IT TO DEALER, AND BOLTS WERE REPLACED.ON JUNE 15TH, MOUNTING BRACKET BROKE, AND CONSUMER COULD NOT STEER VEHICLE/ LOST CONTROL. CONSUMER FELT THIS WAS A VERY SERIOUS MATTER. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK

REAR SUBFRAME BOLTS HAD CORRODED. THIS CAUSED THE FRAME TO DROP. PROBLEM HAPPENED WHILE PULLING AWAY FROM FUEL PUMP. NO RECALLS. *AK

BODY HAS SEPARATED FROM FRAME, THERE IS A RECALL 98V323000, BUT THIS VEHICLE IS NOT AFFECTED. *AK

3.8L ENGINE IS NOTORIOUS FOR HEAD GASKET FAILURE/FORD DENIES ANY PROBLEMS WITH 3.8L ENGINES.*AK

WHILE TRAVELING AT APPROXIMATELY 60 MPH AUTOMATIC TRANSMISSION FAILED. PRIVATE MECHANIC STATED THAT TRANSMISSION HAD TO BE REBUILT. APPROXIMATELY 15 MONTHS LATER, REBUILT TRANSMISSION HAD TO BE REPLACED. NO CAUSE FOR THIS DEFECT WAS GIVEN TO THE CONSUMER BY DEALERSHIP OR PRIVATE MECHANIC. PLEASE PROVIDE ANY ADDIITONAL INFORMATION. *AK

VEHICLE BEGAN TO LEAK ANTI-FREEZE INTO MANIFOLD CAUSING VEHICLE TO SMOKE VEHICLE HAS A 3.8 LITER ENGINE.*AK

CONSUMER WAS DRIVING AT APPROXIMATELY 25-30 MPH AND WAS PUSHED OFF ROAD BY AN AGGRESSIVE DRIVER, CAUSING CONSUMER'S VEHICLE TO RUN OFF ROAD AND HITTING A TELEPHONE POLE HEAD-ON, CAUSING HEAD INJURIES WHEN HITTING STEERING WHEEL. AIRBAG DID NOT DEPLOY. THERE WAS NO WARNING OR INDICATION OF INOPERATIVE AIRBAG. *AK *SLC

I JUST CRANKED IT UP AND SOMETHING POPPED UNDER THE HOOD AND THEN SMOKE CAME GUSHING OUT FROM THE TAIL PIPE. I WAS TOLD IT CRACKED THE BLOCK NOTHING BUT ANTIFREEZE WAS COMING OUT OF THE TAIL PIPE. IS THERE SOMETHING WRONG WITH THESE 3.8L ENGINES?*AK

THE TIRE WAS WARPED WITH PARTS OF THE STEEL BELT COMING OUT OF IT. THE TIRE WAS ALSO DRY AND CRACKED IN SEVERAL PLACES. THE TIRE WAS ONLY DRIVEN FOR APPROXIMATELY 18,800 MILES. THIS TIRE COULD HAVE BLOWN OUT AT ANY TIME IF IT WERE NOT FOR THE WABBLING OF THE CAR TO LET ME KNOW TO HAVE IT CHECKED. NO TIRE SHOULD BE IN THIS CONDITION AFTER ONLY 18,800 MILES OF WEAR.*AK (TIRESIZE: 205/70R14)( DOT NUMBER: TIRE SIZE: 205/70R14 )

DELAY WIPER STALK SWITCH IS DEFECTIVE. LOOSES CONTACT AND WIPERS FREEZUP. EVERY TAURUA OWNER I KNOW HAS THE SAME PROBLEM. REPLACEMENT SWITCHES FAIL PREMATURELY ALSO. I DRIVE FORDS IN A FLEET AND ALL SIMILAR SWITCHES FAIL.( VARIOUS YEARS AFFECTED). *AK

TRANSMISSION STARTED JUMPING INTO NEUTRAL, AND THEN STARTED DOWN INTO FIRST GEAR. DEALERSHIP IS AWARE OF THE PROBLEM.*AK

CAR STALLS INTERMITTENTLY. DEALER REPLACED PLUG WIRES, CAP & ROTOR, FUEL & AIR FILTERS, AND FUEL PUMP. TYPICALLY DOESN'T PRESENT COMPUTER FAILURE CODES. QUITS AT HIGHWAY SPEED, IN CITY TRAFFIC, WHEN COLD OR WARM. SOMETIMES RESTARTS IMMEDIATELY, OFTEN WON'T START FOR HOURS, OR UNTIL NEXT DAY. DEALER IS OUT OF SUGGESTIONS, AND I'M AT WIT'S END. VEHICLE UNSAFE/UNUSABLE IN THIS CONDITION. *AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

AFTER SHIFTING GEARS COULD FEEL A CLUMP ON VEHICLE. THEN, TOOK VEHICLE TO SHOP WHERE THEY FOUND THAT FRONT AND REAR MOTOR MOUNTS HAD TO BE REPLACED.*AK CONSUMER STATES THE RUBBER HAD GONE BAD IN ENGINE MOUNTS. *SLC

WHILE PULLING INTO A PARKING SPACE VEHICLE DIED AND WOULD NOT RESTART. DEALER CLAIMS THAT IT IS TFI MODULE. *AK

SUBFRAME TO BODY MOUNT BOLTS REPEATEDLY BECAME CORRODED AND RUST OUT. CONSUMER HAS HAD TO REPLACE SUBFRAME S ON ALL THREE OF FORD, TAURUS NO ACCIDENT HAS OCCURRED. HOWEVER ,THIS DEFECT COULD RESULT IN LOSS OF CONTROL. (VIN #'S FOR VEHICLES: [XXX], [XXX], AND [XXX].) PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVER'S SIDE DOOR STRICKER CAME LOSE, STRICKER HAS BEEN REPLACED. CJ

RIGHT REAR BRAKE WILL LOCK UP AND OVERHEAT WHEEL, CAUSING TIRE TO HEAT UP. *AK THE CONSUMER HAD BRAKES REPLACED THREE TIMES FOR LOCKING UP BRAKE PROBLEM, AND BELIEVES IT IS A SAFETY HAZARD. *YH

TRANSMISSION FAILED. GRINDING SOUND COMING FROM TRANSMISSION WHEN COASTING. DIAGNOSED AS PLANETARY GEAR FAILURE BY DEALER AFTER INSTALLING NEW OIL DISTRIBUTION TUBES PER FORD TSB (02/08/2001). DEALER UNWILLING TO DISCUSS REPAIR UNDER "OWNER NOTIFICATION PROGRAM". DEALER WILL NOT CONTACT ZONE MANAGER. *AK

AIR BAG LIGHT HAS BEEN ILLUMINATING ON DASH. CONSUMER HAS CONTACTED DEALER, DEALER NOTICED WIRING HARNESS HAD SHORT CIRCUITED, CAUSING LIGHT TO ILLUMINATE. ALSO, EXPERIENCED A PROBLEM WITH TOTAL LOSS OF STEERING POWER. CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

AFTER HAVING BALL JOINT REPLACED BY MIDAS MUFFLER, A DEFECTIVE BOLT ON MY VEHICLE CAUSED THE WHEEL TO DISENGAGE AND CV BOOT CAME OUT. IF THIS OCCURRED AT A HIGHER RATE OF SPEED. THE OCCUPANTS WOULD OF BEEN SEVERELY INJURED OR KILLED. *AK

STEERING RACK WAS LOOSE AND FELL OFF. I HAVE HEARD THAT THIS MODEL HAS HAD A HISTORY OF PROBLEMS WITH THE STEERING RACKS.*AK

FRONT BRAKES AND BACK BRAKES; WHEN APPLYING BRAKES, THE FAILED, VEHICLE DIDN'T STOP. ROTORS/CALIPERS/ DRUMS SHOE PADS WERE DEFECTIVE. ALSO, RADIATOR/ OIL PAN, AND STEERING POWER ASSIST: HOSE: FLUID WERE LEAKING. AND DEALERSHIP HAD TO REPLACE THEM. *AK

CONSUMER WAS TRAVELING ABOUT 55MPH ON HIGHWAY, AND SUDDENLY SOMETHING INSIDE OF STEERING COLUMN LOCKED UP WITHOUT PRIOR NOTICE, AND CAR WAS STUCK. VEHICLE WAS TOWED TO DEALERSHIP. STEERING BELT BROKE AND A/C COMPRESSOR LOCKED UP THAT WAS WHY STEERING COLUMN WOULDN'T MOVE. *AK

WHILE MAKING A RIGHT TURN THE TIE ROD SNAPPED CAUSING LOSS OF STEERING CONTROL, THE CAR TURNED INTO A CURB AND STOPPED. NLM

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

THE VEHICLE EXPERIENCED SUDDEN ACCELERATION, THE DEALER REPLACED THE CV JOINTS AND BOOTS, HOWEVER THIS DID NOT REMEDY THE PROBLEM. *SLC

THE VEHICLE HAS HAD SERIOUS DEFECTS WITH THE 3.8 LITER HEAD GASKETS AND THE AXODE TRANSMISSION, CONSUMER HAS FILED A CLAIM IN THE SMALL CLAIMS COURT. *MJS

WHILE DRIVING VEHICLE STARTED TO OVERHEAT. THIS CAUSED THERMOSTAT TO BURN OUT. ALSO, HEAD GASKET BLEW OUT. SMOKE WOULD BE COMING FROM TAIL PIPE. TOOK VEHICLE TO DEALERSHIP & MECHANIC INDICATED THAT ENGINE & HEAD GASKET NEEDED TO BE REPLACED. *AK

THE VEHICLE CONTINUALLY STALLS DUE TO FAILURE OF THE FLAWED IGNITION MODULE (TFI). *MJS

REAR WINDOW WIPER SWITCH IF LEFT ON WHEN VEHICLE WAS TURNED OFF, WOULD RUN BATTERY DOWN. ALSO, WINDSHIELD WASHER FLUID RESERVOIR HAS TO BE SET IN A CERTAIN POSTION TO WORK. CONSUMER WAS WAITING FOR A CALL FROM DEALER.*AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

IN APRIL 1998, OUR 1991 FORD TAURUS STATION WAGON'S TRANSMISSION FAILED DESPITE HAVING ONLY 61,518 MILES ON IT AT THE TIME. WE INCURRED OVER $2,100 IN EXPENSES REPAIRING THE TRANSMISSION, WHICH WAS THEN OUT OF WARRANTY. OUR TRANSMISSION SHOP TOLD US THAT THIS CAR SUFFERED FROM A DESIGN DEFECT, IN THAT THE TRANSMISSION DID NOT HAVE A SUFFICIENT COOLING SYSTEM, AND THAT IF THE TRANSMISSION BECAME HOT IT COULD FAIL UPON HAVING TO SHIFT GEARS AT SLOWER SPEEDS. THIS WAS EXACTLY WHAT HAPPENED TO OUR CAR; MY WIFE HAD COMPLETED A LONG, HIGHWAY TRIP, AND THE TRANSMISSION SIMPLY FAILED AND LOCKED UP AFTER SHE EXITED THE INTERSTATE AND BEGAN STOP AND GO DRIVING. SHE WAS ACTUALLY PULLING AWAY FROM A STOP LIGHT WHEN THE FAILURE OCCURRED. IN AUGUST 1999, I DISCOVERED THAT FORD HAD ACTUALLY SENT OUT A LETTER IN 1995 ADVISING OF AN EXTENSION OF ITS WARRANTY ON THESE TRANSMISSIONS DUE TO REPEATED FAILURES. I SENT A LETTER ASKING FOR REIMBURSEMENT AT THAT TIME, SINCE OUR CAR HAD BEEN ONLY 1,518 MILES OVER THE 60,000 LIMIT AT THE TIME OF THE FAILURE, BUT I RECEIVED A REPLY FROM FORD REFUSING TO PROVIDE ANY REIMBURSEMENT WHATSOEVER. I TOOK NO ACTION AT THAT TIME, BUT RECENTLY, THE TRANSMISSION ON THIS CAR FAILED AGAIN, THIS TIME WITH ONLY 79,400 MILES (ABOUT 18,300 MILES SINCE PREVIOUS FAILURE) AND WE HAVE INCURRED ANOTHER $2,300 IN REPAIR EXPENSE, DESPITE OUR HAVING TAKEN MORE THAN ADEQUATE CARE OF THIS CAR. WE WOULD LIKE TO KNOW IF THERE IS ANY RECOURSE FOR THESE EXTRAORDINARY EXPENSES, GIVEN

I WAS ABOUT 75 MILES FROM HOME TRAVELING SOUTH ON INTERSTATE 87 @65 MPH.I HAD PASSED A SEMI. AND PULLED BACK INTO THE RIGHT LANE. THE TAURUS SHUDDERED AND SHOOK AND IMMEDIATELY DROPPED TO 45 MPH. I PUT ON THE 4WAY FLASHERS AND PULLED TO THE RIGHT SIDE OF THE HIGHWAY. I CALLED AAA AND HAD TO BE FLAT-BEDDED OFF THE INTERSTATE BACK TO MY HOME. THE FORD MOTOR CO. 'S PROBLEMS WITH THE SUDDEN FAILURE OF THE FORWARD CLUTCH PISTON IN THE AXOD-E TRANSMISSION HAVE BEEN WELL DOCUMENTED BEGINNING IN YHE 1986 MODEL YEAR. BUT THE 1991 SEEMS TO FAIL THE MOST . USUALLY IN THE 60-80K RANGE. JUST MY LUCK, I BOUGHT THE CAR WITH 76K ON IT AND ONLY GOT 6000 MILES OUT OF IT. THE TRANSMISSION WILL COST BETWEEN $900-$1200 TO REPLACE. FORD DID HAVE AN ONP ADDRESSING THESE FAILURES AND DID ,IN THE PAST,REIMBURSE FOR CORRECTING THEM.*AK

THE TRANSMISSION WAS DAMAGED BY LUBE TUBES PARTS WHICH WERE PREVIOUSLY UNDER RECALL, CONSUMERS VEHICLE WAS NOT COVERED UNDER RECALL DUE TO VIN. NLM

VEHICLE STALLS WITHOUT WARNING , MOSTLY IN THE SUMMER . MECHANIC HAS SERVICED VECHICLE , CHANGED STARTER, BUT DEFECT STILL OCCURS.*AK

BLOWN HEAD ENGINE GASKET. ENGINE HEAD GASKET BLEW AT 150,000 MILES. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

THE TIRES (NO MAKE OR SIZE) EXPERIENCE UNUSUAL TIRE WEAR. *SLC

THIS CAR DEVELOPED TRANSMISSION SLIPPAGE UPON SHIFTING INTO SECOND GEAR AT 112000 MILES. WHEN WE TOOK IT TO GET THE TRANSMISSION FIXED, IT BLEW A HEAD GASKET. THIS CAR IS A LEMON & FORD SHOULD TOTALLY RECALL IT. THERE ARE A LOT OF OTHER FORD TAURUS VICTIMS OUT THERE. YOU SHOULD LOOK UP THE FORDTAURUSVICTIMS.COM PAGE. *AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK