2019 Ford Ranger complaints

Owner, who had bought the truck new approx. 3 1/2 years earlier, had driven about three miles on dry, paved, residential, hilly, roads and was returning to where he was staying when he came upon a waiting line of cars. He turned around to go a different way. Coming to a slight curve the power steering (EPAS) went out. Struggling to make the curve, the power assist kicked in and jolted him off the right side of the road. Had the curve been to the left, the truck may have been thrust into the path of an oncoming vehicle. Owner then slowly soldiered on, with the truck making an intermittent noise as if trying to activate the power steering, which it sometimes did, causing the truck to swerve side to side. Owner did not mention any warning sign or alarm or message occurring during this episode. At his destination he called for help and the truck was towed to the dealer. The repair order (RO) indicates diagnostics first being done on 6-8-23, which verified the lack of power steering, and showed DTCs C1B00, U0415, and U3003. My research showed the first pertains to a steering angle sensor in the steering column, and the next two having to do with the ABS. The tech notes indicate he did pinpoint test BC1 (NO), BC2 (YES), and BC3 (YES). Next, the tech reported that the steering gear assembly had a malfunction and needed to be replaced. He added that he retrieved RVC code RA5VUMN131GXQ. Not having the steering gear assembly KB3Z3504A in stock, the replacement was not made until July.

See related steering problem report. After Electronic Power Steering Assist went out on vehicle without warning of any kind to owner, dealer's service department diagnostics as best as I can determine did NOT indicate a problem with the parts that were replaced. The parts replaced were: 1. steering gear/rack and pinion/EPAS (which seems to go by various names), and, when installing this new, expensive, and long-in-coming part didn't get the power steering to work, 2. the battery. The scenario suggests that the root problem was the battery, not the steering gear. A representative of another dealer has advised that the first thing they check in cases involving electronic components is the battery. He also advised that Ford does not have a standard operating procedure or service bulletin that says this is something that is to be done. Can this be? Apparently, at least for this vehicle, there was/is no system to check for adequate battery voltage or to warn that electronic components like the power steering may fail if the battery is not replaced. If my research results are correct, the Diagnostic Trouble Codes the Ford dealer repair tech found went to a steering angle sensor in the steering column, and things having to do with the anti-lock brake system. They weren't fixed, but the codes disappeared after the new battery was installed. The diagnostic tools seem to give more misdirection than direction. With so many critical electrical components in today's vehicles, the warning

Cruising at highway speed ,truck starting bucking and losing speed. Took a minute for it to stop. Then resumed normal speed. This has happened twice. First incident was shorter in length.

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the HVAC blower motor failed to blow cold or hot air as needed. The failure caused the defroster to be inoperable and failed to defrost the front windshield. The vehicle was taken to the dealer, where it was diagnosed that the climate control housing box needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and confirmed that there was no recall associated with the VIN. The failure mileage was approximately 26,662.

The contact owns a 2019 Ford Ranger. The contact stated that upon activating the air condition, the vents failed to blow cold or redirect airflow. The contact stated that due to the failure as a result, the defogger and defroster failed to operate as needed. There were warning lights illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the front pre-tensioner and air intake damper position sensor. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V726000 (Visibility). The vehicle was not repaired. The manufacturer was notified, and a case was opened. The failure mileage was 31,500.

2019 Ford Ranger air conditioning compressor failed. When compressor seized, the component smelt of burning. The compressor failure has been confirmed by the Ford dealership. There was no warnings prior to the problem occurring. Similar recalls have been made on other 2019 Ford Rangers.

Vehicle is a 2019 Ford Ranger mileage is 25700..just had to have all four rotors and brake pads replaced. rear axle rotors showed unaccepatable pitting causing premature wear on pads, while front showed evidence of intermittent pulsing, causing uneven wear . dealership informed me that their hands were tied, this was considfered a normal wear and tear. Ford Customer Care also informed me that there were no programs at this moment to address this problem. I have noticed on your site that there are consumer complaints about the brakes on this vehicle and it's my request that further investigation of the brakes and materials is warranted

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle hesitated. The contact then stated that the vehicle failed to shift while accelerating. As a result, the contact had to use the automatic shift to manually drive the vehicle. The power train warning light illuminated. The dealer was notified of the failure and the contact was informed that a technician was unavailable at the specific location and advised to take the vehicle to a sister dealer where the vehicle remained and diagnosed that the transmission had failed. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was offered half the cost of the repair, but no further assistance was provided. The failure mileage was approximately 62,000.

Ford failed to install a upper engine cover on Rangers with the 2.3 Eco Boost engine, this lets water to gather around the spark plugs causing misfires and stalling. This can cause vehicles to stall on the highway. This has been a on going problem with these vehicles. These covers were installed from the factory on Ford Explorers with the same engines from the factory. Ford service has used air to blow water from around the spark plugs. Then they tell the customer the need to buy the cover to prevent this from happening again.

The air conditioner blows hot air on the driver's side and cold air on the passenger side. No safety issues. It has not been verified by a dealer. We notified them a year ago. No warning lights.

The contact owns a 2019 Ford Ranger. The contact stated that the transmission was shifting roughly. While approaching a stop, there was an abnormal squealing sound detected from the tires, with the vehicle vibrating. The vehicle was randomly changing lanes while driving. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who test drove the vehicle and confirmed that the vehicle had abruptly downshifted, and the tires were squealing. The contact called the local dealer, but the vehicle was not diagnosed. The manufacturer was not contacted. The failure mileage was approximately 50,000.

With high outside temperatures A/C unit was on, but only the heating system was working. Air Conditioning system was not functuning and heating system would not go off. With windows down, inside tempearture was over 100 degrees and passing out due to heat was happening. Ford Dealer inspected the problem and said it was a manufacture malfunction. After repairing, the same issue developed again five days later. Ford dealer said it was another malfunctioning manufacture part.

In May of 2022 at approximatley 46,000 miles a family members 2019 Ford Ranger had the A/C unit on, but VERY hot air was blowing on drivers side. After inspection and Pin Point Test the Ford Dealership determined a manufactures Drivers Side Temp Blend Door was malfunctioning and was replaced at full charge of both parts and labor to the owner. A few days later after the manufactures malfunctioning part was replaced, the VERY same issue developed and caused a family member to pass out due to over 100 degress inside the vehicle. After OTHER inspection by the Ford Dealership it was determined the manufactures Blend Door Acuator, was malfunctioning and was replaced at full charge of both parts and labor to the owner. ON THE WEEK OF APRIL 10, 2023, THIS VIN'S FORD RANGER HAS EXPERIENCED THE EXACT SAME ISSUES AND HAS BEEN DETERMINED THE EXACT SAME MANUFACTURES PARTS ARE MALFUNCTIONING. THIS MUST BE DETERMINED AS A RECALL!

The contact owns a 2019 Ford Ranger. The contact stated while driving 45 MPH, hot air was entering through the vents. The contact stated no warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the air distribution box to be replaced. The vehicle was not repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 20V137000 (Visibility) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 42,000.

Climate control temperature system failed and would not adjust. A clicking/snapping noise was present under the dash when attempting to control climate and defrost. Ford verified the failure of the climate control system and stated that I the original owner, [XXX], must personally pay for labor and parts to replace the climate control housing assembly to resolve the failed climate control system and achieve functional defrost. The vehicle went in for inspection at Jim Click Ford (6244 E 22nd St; Tucson AZ 85711; +1-520-570-7301) on the March 29th, 2023 and the repair was completed on April 4th, 2023 (Ford Part Number 18478). The vehicle had 29,634 miles on it at the time of repair. The issue is identical to that described in “SSM 49264: 2019-2020 – Climate Control Temperature Will Not Adjust With Clicking/Snapping Noise From The Dash – Built On Or Before 30-Jul-2020”. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2019 Ford Ranger. The contact stated that while driving approximately 30-40 MPH, there was an abnormal burning odor detected. The contact stated that the front driver’s side heated seat had burned a two-inch hole into the seat, the upper back rest, and heating pad. The contact also noticed that the heated seat was inoperable. There were no warning lights illuminated. There were no blown fuses. The vehicle was taken to the dealer however, a service date was not available. The vehicle was not diagnosed or repaired. The contact repaired the seat himself. The manufacturer was notified of the failure and referred him to the local dealer for assistance. The failure mileage was approximately 54,000.

The contact owns a 2019 Ford Ranger. The contact stated while driving 70 MPH with the cruise control activated, the vehicle made an abnormal sound. The contact stated that he decelerated to 30 MPH, and then re-activated the cruise control. While at a stop sign, the vehicle lost motive power. The vehicle was not diagnosed nor repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

The contact owns a 2019 Ford Ranger. The contact stated that while driving at 70 MPH with the cruise control activated, the vehicle made an abnormal sound. The contact stated, he reduced the speed to 30 MPH and restarted the cruise control. In addition, while at a stop sign, the vehicle lost motive power. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, he heard a clicking and popping sound when attempting to operate the air conditioning unit. The vehicle was taken to an independent mechanic where it was diagnosed that the blend door actuator and air conditioning flow box failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but, no assistance was provided. The failure mileage was 27,682.

The contact owns a 2019 Ford Ranger. The contact stated that upon starting the vehicle, the power steering assist failed with several unknown warning lights illuminated. The contact called the dealer and was informed that the VIN was not under recall. The contact was given an estimate for the repair. The contact called an independent mechanic and was also given an estimate for the repair. Due to the failure, the vehicle was towed to the independent mechanic and the contact was informed that the rack and pinion steering assembly needed to be replaced. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 37,000. The contact stated that the vehicle was repaired.

This trucks rear brake pads have been wearing unevenly since it was new. The inside rear brake pads are showing heavy wear and the outside pads are not showing even wear. This truck has been into the Kendall Ford of Wasilla Alaska for service in early 2022 and this was first noted and repaired. Now this issues has been found again by owner/operator. There seems to be and issue with the slid pins/bolts for caliper are not allowing the outside pads to slide when pedal is active. This is not an isolated issue according to blogs I have found on this issue.

Very simple I believe this car fall into the recall discovered under Motor Company is issuing a safety recall for select 2019 Ford Ranger vehicles. Affected vehicles had the heating, ventilation and air conditioning, or HVAC, blower motor replaced from Oct. 9 to Nov. 22, 2019, per recall 19534. My car has only 27k miles and ac it’s blowing hot !!! Dealer would not repair it because vin did not “have” a recall but it’s the same exact issue above

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal cracking sound, and then the heating system became inoperable. The contact stated that he was freezing while driving in 20-degree weather. The contact was concerned that if he became stranded in traffic during a snowstorm, he would freeze. The vehicle was taken to the dealer, where it was diagnosed that the heating duct was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and agreed to cover a portion of the cost of the repair. The failure mileage was approximately 46,000.

The contact owns a 2019 Ford Ranger. The contact stated while driving 40 MPH with the heating system activated, the contact heard an abnormal sound coming from the vents. The contact stated that both cold air and heat was coming through the vents. The vehicle was not diagnosed or repaired. The manufacturer was contacted and stated that the vehicle was out of warranty. The failure mileage was 39,081.

Purchased this vehicle (2019 Ford Ranger XLT), in 2019. Over the last month or so, started developing a shimmy when starting out, bad shimmy when slowing down. Had the brakes checked, no issue. Continued it get worse, developing harder shimmy when starting and braking, began feeling a delay in shifting gears. Dropped it off where I purchased it, Priority Ford Norfolk, was told that the transmission needed to be replaced. 3 year old truck, transmission went bad. After during research, these particular transmissions (10 speed) was installed in Rangers, F150s, Explorers etc. This transmission issue poses a risk to safety when driving. When slowing down, it had major difficulty down shifting and coming to a smooth stop, it would feel like it was locking up.

The actuator motor is not working. This is a common complaint of the 2019 Ford Ranger and is noted in Ford's SSM 49264. Certainly a service bulletin identifying a need to replace the entire climate control housing assembly is worthy of a recall. This truck has 23, 000 miles on it and is just out of warranty.

It looks like on some 2019 Ford Rangers (mine included), there is a faulty blend door in the heater box assembly. Note this issue is not present in other model years due to Ford correcting the defective part. This defective part causes the switch between hot and cold air to fail. My truck got stuck on hot and the dealer replaced it under warranty. The replacement has now failed 6 months (3000) miles later. This issue can prevent the heat from functioning properly in cold weather, which means the defrost is ineffective - requiring the driver to manually clear the windshield. The issue is that Ford A) knows there is a defect that can impact the safe operation of the vehicle B) These vehicles would likely be covered under the manufacturer warranty due to low miles from 2020 (COVID) but has not made efforts to notify owners of the defect C) will gladly charge $3,000-$4,000 for this repair once the warranty expires (which has happened for many 2019 vehicles by this point). Profiteering on a known factory defect is unacceptable!

Back up camera is blurry unable to identify objects. I know there’s been a recall on many of the back up cameras but none on my vehicle since I have a back up camera that is blurry and unable to identify objects. Clearly, how do I go about getting it fixed?

My vehicle's heater stopped working mid-drive. I heard a loud POP sound and then the air that came out of the vent was room temperature. I pulled over and stopped the vehicle. Waited a minute and restarted it. The temperature did not change. I was driving on Highway 80 over Donner pass in the Sierra mountains. The temperature was very cold and my window began fogging up. I then had to continue my drive by wiping my windshield from the inside with a rag every 15 seconds or so to maintain visibility enough to drive. As the snow was coming down and it was getting dark, I needed to keep going as it would have been too cold to stay in the vehicle and wait out the storm. Now, driving the vehicle is hazardous because I do not have proper defrosting capability. I took it to a dealership and they estimated roughly $4000 in repairs to fix the issue. The car is barely 3 years old.

The contact owns a 2019 Ford Ranger. The contact stated that they had received a notification on the main control computer screen and the vehicle's notifications app indicated that there was an electrical failure occurring with the steering. The contact then stated at the same time the vehicle began to self-direct causing an excessive amount of force required to steer the vehicle. The brakes became difficult to depress causing an excessive amount of pressure to be applied on the brake pedal in order to get the vehicle to come to a stop. The vehicle was taken to the dealer who was unable to diagnose the cause of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 16,000.

The contact owns a 2019 Ford Ranger. The contact stated while driving 50 MPH, the vehicle failed to accelerate properly. There was no warning light illuminated. The contact was able to pull over on the side of the road. The vehicle was taken to the dealer and the contact was informed that the spark plugs were blown out with the coil. The contact was informed that the spark plugs, and coil needed to be replaced. The vehicle was repaired. The manufacturer was contacted and stated that the vehicle was out of warranty. No further assistance was offered. The failure mileage was 17,000.

This truck we have had in the shop for the transmission 5 different times the truck at all different speeds jerks like the gear is not igniting in then starts to shake the shop has reported that it does not shift properly then yesterday Dec 24th, 2022 the trucks wrench came on the breaks locked up and the power train locked up I have all documents we purchased the truck in March 2022 and have been having this transmission issue since I have contacted Ford numerous times and also emailed numerous times the dealership we purchased the truck from has done nothing except keep reprogramming the computer in the system which is not the issue the transmission is under warranty to 60000 miles and we have been having this issue since June 2022. Now that everything locked up on the vehicle we are not safe to even take the truck out on the road we do not want to get injured no the defective issue causing an accident and someone else getting injured. Ford has done nothing to fix or solve the issue at this point the vehicle has 59105.3 miles on it should not be having these issues and the dealership automotive repair shop not fixing the issue at this point need to buy this vehicle back and not sell it it is to dangerous and can cause injuries. We have been trying since June 2022 to get this truck fixed. 3 months after purchasing it and sales rep that sold it to us at Parkway Nissan, Ford Chrysler just says have to take it to their shop which has not done a thing to fix the issue. 12/24/202

My brake lights, turn signals, running lights, and hazards don't work. The Ford dealership has inspected it. There were no warning signs or symptoms prior to failure.

Transmission clunk jerky and sifting not right. 10r80 transmission just like the f150. Took to ford dealer twice still with same issues. Driving is not safe for roads with traffic and I know others feel the same too

The drivers side seat heater short circuited and melted the seat cover and foam. The short circuit left an approximately 1 inch hole through the seat.

Both of my taillights no longer work, at first it was intermittent and they would come back on but after a while nothing worked. No turn signal, hazard, or brake lights for the rear taillights only. The overhead one above the bed still works. The vehicles behind me cannot tell whether I am braking, turning or driving. It appears this was a common issue on earlier vehicles in production. It has been reproduced by an independent service center. It has not been inspected by the manufacturer, and no there was no other symptoms prior to the failure other than the intermittent working and not working.

The contact owns a 2019 Ford Ranger. The contact stated that the heated seat overheated to the point where the contact received severe burns along the back down to the back of the legs. The contact had not taken the vehicle to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 40,000.

The failed component is a small wheel speed sensor on the rear axle. The sensor is designed in a way where it inserts into the axle and sits close enough to the gears that it can be hit by the gears during bumps/potholes/etc. The issue puts myself and others at risk as when the sensor malfunctions or breaks, it disables multiple safety features of the truck including: Antilock brakes, traction control, power steering, hill assist, and collision avoidance system. Other systems affected include cruise control. The problem has been reproduced with three separate speed sensors, two OEM sensors and one after market. I have had the vehicle inspected by a Ford dealership for the issue. Issues prior to the first replaced sensor was the sensors have issues with cold climate. When snow or ice is on the roadway, the sensors have issues and disable all the above features. Appears the design cannot withstand the cold weather.

This 2019 Ranger is experiencing jerky and erratic shifting. At low RPM’s (parking lots) it requires excessive RPM’s and resulting speeds to shift between gears. It also clunks when downshifting, feeling like the vehicle was hit by another car.

The contact owns a 2019 Ford Ranger. The contact stated while driving 50 MPH and approaching traffic, while depressing the brake pedal the vehicle failed to slow as needed. The contact stated no warning light was illuminated. The contact stated that the Forward Collision Avoidance Emergency Automatic braking activated and stopped the vehicle. The contact took the vehicle to a local dealer however, the mechanic was unable to duplicate the failure. The contact stated that he had experienced the failure a second time. The contact took the vehicle back to the local dealer who was unable to duplicate the failure. The manufacturer had not been informed of the failure. The failure mileage was approximately 11,000.

As I was driving down the road I began I started to smell something unusual - in a way it smelled like burning plastic and/or anti-freeze. I then began to feel quite a bit more heat than usual on my lower back, so much I knew something was wrong. I pulled my truck over, got out and as soon as I got out my heated seat started producing smoke where I believe the main heated seat coil is. Within seconds a flame burst out from the seat. I luckily had a drink in my cup holder that I reached over to grab & pour out on the flame. It kept smoking after I dumped the liquid on it. I then grabbed a water bottle from my back seat & was able to put the fire out completely. In conclusion, my 2019 Ford Ranger Lariat Crew Cab heated seat caught fire while it was turned on, on 9/15/2022 at approx. 9:00a.

The contact owns a 2019 Ford Ranger. The contact stated that the driver’s side rear taillight intermittently failed to illuminate while depressing the brake pedal. The contact also stated that the horn failed to operate as needed. The contact took the vehicle to a dealer where he was informed that his vehicle was not included in NHTSA Campaign Number: 19V839000 (Exterior Lighting). The manufacturer was notified of the failure and referred him to the dealer for assistance. The vehicle remained at the dealer unrepaired. The failure mileage was approximately 41,000.

The contact owns a 2019 Ford Ranger. The contact stated while driving approximately 65 MPH, the vehicle inadvertently lost motive power and stalled. The check engine warning light was illuminated. The vehicle was towed to the local dealer and diagnosed with water absorption in the engine. The dealer replaced the boot cover, spark plugs, and engine cover. The manufacturer was notified of the failure. The approximate failure mileage was 35,599.

My rear camera stopped working and I think the front collision alert is affected as well. I understand there was/is a recall for this issue but not my vehicle. I do not understand why.

The 10r80 10 speed Transmission will slip, shutter, stall, jump in and out of gear, slam into gear, and often times will wait till you are at a complete stop to downshift into 1st gear which makes the entire truck lunge forward almost like you’ve been rear ended. I’ve been to 2 different ford dealerships, had my truck in the shop multiple times and all I hear is them telling me that it’s normal and they get these complaints a lot. Long Lewis ford of prattville Alabama will play dumb and hold my truck in their parking lot for a few days then say they found nothing wrong. Collier ford of wetumpka Alabama told me over the phone that the symptoms I’m experiencing are normal and they they will not touch my truck unless it has a wrench light on. A $36,000 truck should not have these issues and it be deemed “normal” or even “acceptable”.

The front passenger door mechanism failed. the actuator that grips onto the metal latch on the truck's frame is locked in the up position, preventing the door from closing. That creates a safety problem because the door will not close or latch.

Vehicle is visibly lower or has a lean on the rear driver side bed. Was brought to ford and measured to be lower on right rear side by .5”inch from the left, fuel tank was at less than a 1/4 tank.

Unknown, My vehicle seems to stall in low gear. I already informed the dealership several times, and they stated that everything was fine. The stalling appears to be getting more frequent as time goes on, and worried that this could cause further damage to the vehicle. This is a safety concern as well.

Drive truck and park in garage and garage smells like gas. Only happens when parking truck in garage right after driving it. This has happened about 3-4 times now. I don't drive it that often. Just had an oil change at Ford and drove home. Then the next day i took it out and parked it in garage and gas smell again. Smell will last 2-3 days if truck stays parked. Have an appt. this coming week at Ford.

The contact owned a 2019 Ford Ranger. The contact stated that while driving approximately 50 MPH, the vehicle crashed into a cow. During the incident, the vehicle was destroyed and severe front-end damage had occurred but no airbags deployed. No injuries were reported. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 54,000. Vehicle has been totaled State Farm with Claim number [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).”