2017 Ford F-350 SD complaints

WHILE DRIVING BETWEEN 55-70 MPH, THE STEERING WHEEL BEGINS TO SHAKE VIOLENTLY IN THE TRUCK IF YOU DRIVE OVER THE SLIGHTEST ROAD IMPERFECTION. I HAVE CALLED FORD WITH MY VIN NUMBER AND WAS TOLD THAT THERE WAS NO RECALL OR SERVICE BULLETIN FOR THIS PROBLEM. HOWEVER, THEY DID SAY THAT THIS WAS A WIDESPREAD ISSUE. I WAS ADVISED THAT THE STEERING COMPONENTS AND TRACK BAR WAS SUBJECT TO PREMATURE FAILURE.

MY VEHICLE CURRENTLY HAS 68,871 MILES. I PURCHASED IT LESS THEN ONE YEAR AGO WITH 57K MILES. I HAVE EXPERIENCED "DEATH WOBBLE" THREE TIMES WITH THE MOST RECENT BEING 11/17/19. THE MOST RECENT SENT ME ONTO THE SHOULDER AT INTERSTATE SPEEDS. EACH OF THE THREE TIMES HAS HAPPENED BETWEEN 70-78MPH ON THE INTERSTATE AFTER HITTING ROUGH ROAD OR A BRIDGE EXPANSION JOINT. THE VEHICLE IS COMPLETELY STOCK. I HAVE NO VIDEOS OF THE INCIDENTS DUE TO MY PRIMARY CONCERN BEING CORRECTING THE PROBLEM BY IMMEDIATELY SLOWING BELOW 45MPH. I HAVE CONTACTED A REPAIR SHOP WHO STATED THEY WANTED NOTHING TO DO WITH IT, AND I CAN'T GET IT INTO A FORD DEALER FOR A WHILE.

WITH JUST 20,000 MILES MY 2017 F350 HAS DEVELOPED THE "DEATH-WOBBLE" . AT HIGHWAY SPEEDS, ESPECIALLY IN A SLOW ARCHING TURN, IF THE TRUCK HITS A BUMP IN THE ROAD, THE STEERING WHEEL STARTS TO VIOLENTLY SHAKE. I BROUGHT IT BACK TO THE DEALER (2ND TIME) AND THEY TOLD ME THAT THIS WAS THE 4TH TRUCK BACK THIS WEEK FOR THE SAME ISSUE. ALL THE DEALER CAN DO IS REPLACE THE STEERING COMPONENTS WITH THE SAME ONES THAT WERE ON THE TRUCK. SEEMS LIKE FORD JUST WANTS TO GET OUT OF THE WARRANTY PERIOD.

DRIVING AT 60-65, WHEN YOU HIT A BUMP SUCH AS RAILROAD TRACKS, POTHOLES OR ROUGH ROADS, THE FRONT END WILL BEGIN TO WOBBLE AND THEN THE ENTIRE TRUCK SHAKES VIOLENTLY WITH VERY LITTLE CONTROL. ONCE YOU SLOW DOWN TO ABOUT 40, THE SHAKE GOES AWAY AND THE TRUCK DRIVES NORMAL.

HIT A BUMP IN THE ROAD AT 50MPH +, THE STEERING WHEEL BEGAN TO SHAKE VIOLENTLY MAKING THE VEHICLE IMPOSSIBLE TO CONTROL. I HAD TO HIT THE BRAKES HARD AND SLOW WAY DOWN TO REGAIN CONTROL OF THE TRUCK. THIS NEARLY CAUSED THE CAR BEHIND ME TO REAR END ME ON ONE OCCASION. THIS HAS HAPPENED TO ME 3 TIMES IN THE LAST MONTH. I HAVE ONLY EXPERIENCED THIS UNLOADED WITH NO TRAILER ON STRAIGHT ROADS, THUS FAR. THE VEHICLE IS RIGHT AT 19,000 MILES, STILL UNDER WARRANTY. IT SHOULD NOT BEHAVE THIS WAY. EVEN WHEN THE WOBBLE DOESN'T HAPPEN, THE VEHICLE WILL SOMETIMES JUMP TO ONE SIDE OR ANOTHER GOING OVER ANGLED JOINTS IN THE ROAD. IF YOU ARE NOT PAYING EXTREME ATTENTION, YOU WILL BE IN THE MEDIAN. THIS HAS HAPPENED MANY TIMES IN THE LAST FEW MONTHS. IT SIMPLY ISN'T VERY SAFE TO DRIVE WITHOUT A HIGH PAYLOAD. THE WOBBLE OCCURRED MULTIPLE TIMES AT THE SAME BRIDGE JOINT GOING IN TWO DIRECTIONS. THE JUMPING TO THE SIDE OCCURS ALMOST DAILY AT THE SAME JOINT. THE WOBBLE OCCURRED A SEPARATE TIME ON ANOTHER ROAD. BOTH ROADS ARE 2-3 LANE CITY THOROUGHFARES. NOT REALLY CITY STREET OR HIGHWAYS, BUT I SUPPOSED DIVIDED HIGHWAY IS THE BEST DESCRIPTION . I JUST REPLACED STOCK/ORIGINAL TIRES, HOPING THOSE HAVE SOMETHING TO DO WITH IT.

2017 FORD 350 SRW/CREW CAB/LONG BED/DIESEL, 31K MILES, STEER/BUMP RESONANCE / DEATH WOBBLE AS SOME REFER TO IT AS, HAPPENED FOR THE FIRST TIME ABOUT 2K MILES AGO. I WAS ON A STRETCH OF HIGHWAY THAT HAD A VERY WEIRD RIPPLE WHICH TRIGGERED THE FIRST INCIDENT, I THOUGHT IT WAS AN ANOMALY DUE TO CONDITIONS AND DIDN'T THINK ANYTHING MORE. SINCE THEN I HAVE NOTICED A SLIGHT VIBRATION IN THE STEERING WHEEL THAT IS PARTICULARLY PRONOUNCED WHEN IN A SLIGHT LEFT HIGHWAY TURN (UNLOADING THE STEERING DAMPER I ASSUME). WHILE TRAVELLING STRAIGHT AND LEVEL I WENT OVER A BRIDGE TRANSITION AND WENT INTO A STEER/BUMP RESONANCE WHICH FORCED ME TO THE SHOULDER AND SLOWING TO 30 MPH OR SO BEFORE IT DIMINISHED. THIS CAN BE DISTURBING ON AN EMPTY ROAD AND DOWNRIGHT DANGEROUS ON A BUSY ONE. I'M JUST LUCKY THAT IT WAS A RELATIVELY LOW TRAFFIC ENVIRONMENT DURING THE MOST CURRENT INCIDENT.

VEHICLE OWNER WAS TRAVELLING AT 65MPH ON FOUR LANE INTERSTATE. UPON CROSSING OVER AN EXPANSION JOINT AT AN OVERPASS THE STEERING AND FRONT END BEGAN SHAKING VIOLENTLY AND UNCONTROLLABLY. THE SHAKING PERSISTED UNTIL SPEED WAS REDUCED TO UNDER 45MPH. NO VEHICLES WERE PRESENT IN THE ADJACENT LANES. IF THERE WERE IT IS VERY LIKELY AN ACCIDENT WOULD HAVE OCCURRED.

AT APPROXIMATELY 24,500 MILES, WHILE TRAVELING ON THE INTERSTATE AT 70 MPH, I CROSSED A SMALL CREASE IN THE ROAD AT THE BEGINNING OF A BRIDGE, THE TRUCK WENT INTO A "DEATH WOBBLE", OR AS FORD CALLS IT "SUSTAINED STEERING WHEEL OSCILLATION". THIS IS A VIOLENT SHAKING OF THE FRONT END THAT CAUSES YOU TO TEMPORARILY LOSE CONTROL OF THE VEHICLE UNTIL YOU CAN REDUCE YOUR SPEED TO UNDER 45 MPH. I TOOK IT TO THE FORD DEALER AND THEY REPLACED THE STEERING STABILIZER. THIS SOLVED THE PROBLEM FOR APPROXIMATELY 11,200 MORE MILES. AT AROUND 35,700 MILES, THE DEATH WOBBLE RETURNED WITH A VENGEANCE. IT HAPPENED AGAIN ON THE INTERSTATE TRAVELING AT 70 MPH. REDUCING THE SPEED TO LESS THAN 45 MPH STOPPED THE WOBBLE. HOWEVER, SINCE YOU CANNOT DRIVE 45 MPH ON AN INTERSTATE, IT HAPPENED EVERY TIME I SPED UP AND HIT THE SLIGHTEST OF SMALL BUMPS IN THE ROAD. HAPPENED 6 MORE TIMES UNTIL I WAS ABLE TO GET OFF THE INTERSTATE. THIS TIME IT WAS WORSE THAN BEFORE. TRUCK IS NOW SITTING AT DEALER AGAIN FOR ALMOST 2 WEEKS WHILE THEY "LOOK" AT IT. ALL FORD IS WILLING TO DO IS SLAP ANOTHER POS STEERING STABILIZER ON IT AND PUSH ME OUT THE DOOR. THIS IS NOT THE FIX. FORD HAS A PROBLEM ON THEIR HANDS, BUT IS REFUSING TO LISTEN, OR SIMPLY CANNOT FIGURE THIS OUT. SOMEONE IS GOING TO GET KILLED. SOMETHING MUST BE DONE BEFORE THAT HAPPENS!! STEP UP AND FIX YOUR TRUCKS FORD!!!!

WHILE DRIVING HIGHWAY-SPEED ABOUT 65 MPH, THE TRUCK HITS A GROVE IN THE HIGHWAY ROAD AND STARTED TO SHAKE VIOLENTLY AND UNCONTROLLABLE. I SLOWED DOWN WHILE TRYING TO KEEP THE TRUCK IN ONE LANE AND IT STOPPED THE BUCKING/WOBBLE ACTION WHEN THE SPEED WAS REDUCED TO 20 MPH. THIS HAS HAPPENED TWICE IN THE PAST WEEK AND VEHICLE IS SCHEDULED TO BE LOOKED AT IN THE SERVICE CENTER.

WHILE DRIVING AT 65 MPH ON A HIGHWAY HIT A SMALL POTHOLE AND THE STEERING / FRONT SUSPENSION STARTED WOBBLING VERY VIOLENTLY, HAD NO MORE CONTROL ON THE THE STEERING. HAD TO SLOW DOWN AND PULL OVER ON THE SHOULDER. NO DAMAGE VISIBLE TO TIRES OR STEERING COMPONENTS SO I CONTINUED DRIVING AND THE WOBBLE WAS GONE. THIS HAPPENED BEFORE ON BRIDGE JOINTS IN A CURVE FOR A SHORT MOMENT, BUT NOT AS VIOLENTLY AS TODAY. TRUCK SEEMS NOT SAFE, WILL TAKE IT TO DEALER ON MONDAY.

I PURCHASED A NEW 2017 F-350 A COUPLE YEARS AGO. IT HAS ABOUT 22,000 MILES ON IT. I EXPERIENCED THE "DEATH WOBBLE" YESTERDAY FOR THE SECOND TIME. I NOW KNOW WHY IT'S CALLED THAT. I WAS GOING ABOUT 60MPH ON A TWO-LANE HIGHWAY WHEN THE TRUCK AND STEERING STARTED SHAKING VIOLENTLY. I ALMOST CRASHED TRYING TO SLOW IT DOWN AND DEFINITELY COULD HAVE KILLED ME! IT SOUNDS AS IF THIS IS BECOMING ALL TOO COMMON OF A PROBLEM WITH THESE TRUCKS. I'M SCARED TO DRIVE AGAIN!

I WAS DRIVING DOWN THE FREEWAY TO WORK AT APPROXIMATELY 70 MPH WHEN MY TRUCK STARTED TO SHAKE SO BAD IN THE FRONT END I ALMOST TOOK OUT THE VEHICLE TO MY LEFT AND ENDED UP HALFWAY IN THE DITCH. I HAD 0 CONTROL OVER MY TRUCK

THE TAILGATE AT TIMES COMES UNLATCHED. I DO HAVE A CANOPY WHICH KEEPS THE TAILGATE FROM DROPPING DOWN ALL THE WAY. TRUCK ONLY HAS 10700 MILES ON IT AND IS STILL ON WARRANTY. I HAVE TAKEN IT TO THE DEALER TWICE, THEY CANNOT DUPLICATE THE PROBLEM, NOR FIND ANYTHING WRONG. I HAVE CALLED FORD CUSTOMER SERVICE 3 TIMES, AND HAVE DONE WHAT THEY TOLD ME TO DO, BUT THEY DO NOT FOLLOW THROUGH WITH WHAT THEY TELL ME THEY ARE GOING TO DO. VECHICLE IS IN MOTION, AND HAS HAPPENED WHEN PULLING MY CARGO TRAILER. DATE BELOW WAS THE LAST TIME THIS HAPPENED. I DO NOT DRIVE THIS VECHICLE MUCH.

I STARTED TO HEAR A CLUNKING IN THE FRONT END OF MY 2017 F350 WHEN GOING OVER BUMPS (LOW SPEED AND HIGH SPEED). I TOOK IT IN TO THE DEALER AND THE SAID I HAD EXCESSIVE PLAY IN MY TIE ROD ENDS, SO THEY REPLACED THEM ALONG WITH A LOWER CONTROL ARM. ABOUT A WEEK LATER, I STARTED HEARING THE NOISE AGAIN AND WHEN I WOULD GO OVER BUMPS IN THE ROAD, EVEN AT LOW SPEED, THE TRUCK WOULD WANT TO WANDER. I TOOK IT IN A SECOND TIME AND THEY FOUND THE ANTI SWAY BAR HAD EXCESSIVE PLAY, SO THEY REPLACED THAT. I ASKED WHY A NEW 1 TON TRUCK WOULD ALREADY NEED FRONT SUSPENSION COMPONENTS REPLACED AND THEY SAID THEY DIDN'T KNOW. THE TRUCK DID DRIVE BETTER FOR AWHILE, BUT SHORTLY AFTER I STARTED HEARING THE NOISE AGAIN. I HAD TO GET THE OIL CHANGE, SO I ASKED THEM TO CHECK ON IT WHILE IT WAS IN THERE. THEY SAID THEY DID THE OIL CHANGE BUT COULDN'T CHECK THE NOISE COMPLAINT BECAUSE THEY DIDN'T HAVE TIME. THEY DID HOWEVER DO ANOTHER 42 POINT INSPECTION AND SAID EVERYTHING WAS OK. I BROUGHT IT IN ABOUT A WEEK LATER BECAUSE THE NOISE WAS STILL THERE. THEY TOLD ME THAT THEY COULDN'T REPLICATE THE PROBLEM, BUT THE TECH SAID IT COULD BE COMING FROM THE REAR LEAF PACK BECAUSE, "SOMETIMES THE TRUCKS COME FROM THE FACTORY WITH THE REAR LEAF SPRINGS LUBRICATED AND THEY AREN'T SUPPOSED TO BE", SO HE SPRAYED DEGREASER ON THEM AND THEY COULDN'T HEAR ANY NOISE ANYMORE. I ASKED WHY THE FACTORY WOULD DO THAT, AND AGAIN, THEY HAD NO ANSWER. I DROVE IT WITH THE SERVICE MANAGER (AROUND THE CORNER) AND OF COURSE IT D

TRAVELING ON A PAVED HIGHWAY AT 60 MPH. THE ROADWAY HAD A BUMPY SECTION. WHEN DRIVING THRU THE BUMPY SECTION, THE FRONT END OF THE TRUCK BEGAN TO SHAKE VIOLENTLY AND NEARLY CAUSED A LOSS OF CONTROL. IT CONTINUED TO SHAKE UNTIL THE TRUCK SPEED WAS REDUCED BELOW 30 MPH.

DEATH WOBBLE. FRONT END SHAKES SO BAD YOU CANT CONTROL IT BETWEEN 50 AND 60 MPH ON HIGHWAY.

MY VEHICLE ALUMINUM RIMS ALL CORRODED AROUND THE VALVE STEM CAUSING THEM TO LOOSE AIR. FORD REPLACED ALL THE RIMS AT 10,000 MILES. THEY TOLD ME THEY WERE AWARE OF THE PROBLEM AND HAD CORRECTED IT. AT 39,500 MILES THE NEW RIMS DID THE SAME THING CORRODING AROUND THE VALVE STEM CAUSING THE AIR TO LEAK OUT. THE PROBLEM WAS NOT CORRECTED.FORD AGREED THE RIMS WERE DEFECTIVE AND WOULD ONLY REPLACE THEM IF I PAID OVER HALF OF THE NEW COST. I AM ALWAYS FEARFUL THAT THE TIRES WILL LOOSE AIR AT HIGH SPEED AND CAUSE A CRASH.

HAD TRUCK REPAIRED IN APRIL OF 2017 WITH DEATH WOBBLE. TODAY IT IS BACK IN FOR THE SAME PROBLEM. SERVICE PERSON SAID THERE IS NO 'FIX', JUST KEEP BRINGING IT BACK N. GUESS I WILL UNTIL IT KILLS ME IN AN ACCIDENT! SAME PROBLEMS AS BEFORE, FRONT END GOES CRAZY WHEN HITTING A BUMP OR BRIDGE XIAN'S ION JOINT AT FREEWAY SPEEDS.

THIS VEHICLE ON NORMAL ROADS, INTERSTATE OR BACKROADS, WILL GO INTO WHAT I WOULD CALL A DEATH WOBBLE. THIS "WOBBLE" IS VERY VIOLENT, AND IT USUALLY OCCURS AT 50MPH OR GREATER. AT THIS SPEED THE VEHICLE BECOMES BARELY GUIDEABLE TO THE POINT THAT IT IS VERY DANGEROUS. THE ONLY WAY TO MAKE THE VEHICLE STOP THE EVENT IS TO SLOW DOWN. MY EXPERIENCE HAS BEEN THAT IT WILL CONTINUE DOWN TO SPEEDS OF 35-40 BEFORE IT GOES AWAY. I STRONGLY FEEL AS THOUGH THIS EVENT, IF IT WERE TO HAPPEN AT THE WRONG TIME WILL COST A LIFE. IT DOES NOT TAKE A HUGE POT HOLE TO SET IT OFF, IT IS TYPICALLY A SMALLER IRREGULAR BUMP THAT WILL GET IT GOING. UNDER WARRANTY I HAVE HAD THE STEERING DAMPER REPLACED AS WELL AS BOTH FRONT SHOCKS AND NOTHING SO FAR HAS TOUCHED THE ISSUE.

WHEN TRAVELING AT 60-75 MPH AND HIT A BUMP IN THE ROAD LIKE A PAVEMENT TO BRIDGE DECK BUT NOT LIMITED TO THAT THE FRONT END GOES INTO A VIOLENT SHIMMIE AND HAVE TO HIT THE BRAKES HARD TO KEEP CONTROL AND SLOW TO 30MPH OR SO. MOSTLY HIWAY DRIVING SOME NO HIWAY. HAVE TAKEN IN TO FORD AND OTHERS AND WAS TOLD FORD CAN'T FIX THIS ISSUE. STARTED HAPPENING AROUND 36K AND I HAVE 42K ON IT NOW. HAVE INSTALLED A STEERING DAMPENER WITH NO FIX. THIS IS HAS DEFLATED THE VALUE OF MY VEHICAL IF I WAS ABLE TO SELL IT AT ALL WITH ALL THE BLOGS LIKE CARGURUS DEATH WOBBLE. FORD NEEDS TO BE FORCED TO MAKE A FIX FOR THIS ISSUE AND HOPE YOU WILL PURSUE THIS ISSUE. I DON'T HAVE THE KIND OF MONEY TO JUST BUY ANOTHER BRAND VEHICAL TO PULL MY 5TH WHEEL AND THIS ISSUE COULD KILL SOMBODY. THANK YOU

WHILE DRIVING THE FREEWAY AT 70 MPH HIT A BRIDGE EXPANSION JOINT IN THE ROAD AND THE TRUCK BEGAN SHAKING VIOLENTLY. IT WAS DIFFICULT TO MAINTAIN CONTROL AS I SLOWED TO ABOUT 20MPH BEFORE IT WOULD STOP. THEN AGAIN WHEN I HIT A SECTION OF GROUND PAVEMENT SAME THING HAPPENED. DEALER SAYS IT'S TIRE ONLY HAVE 20K ON FACTORY INSTALLED TIRES. THEY THEN REPLACED STEERING DAMPENER, DID NOT CORRECT STILL AT DEALERSHIP. 2017 F350 CREW CAB COMPLETELY STOCK. 27K MILES

STEERING OR SUSPENSION GOES INTO A VIOLENT SHACKING OFTEN REFERRED TO AS DEATH WOBBLE AFTER HITTING CERTAIN BUMPS ON A ROADWAY. BUMPS APPEAR TO INVOLVE BOTH FRONT TIRES POSSIBLY WHEN ONE TIRE HITS FIRST SIMILAR TO BRIDGE JOINTS OR PAVEMENT BREAKS. AT HIGHWAY SPEEDS ABOUT 55 OR GREATER, ONLY HAD HAPPEN WHEN DRIVING STRAIGHT. THE STEERING WHILE SHAKES BACK AND FORTH ABOUT 1-INCH EACH WAY WITH TRUCK BODY SHAKING. IT APPEARS TO WORSEN IF BREAKING HARD SO SLOW DECELERATION HAS BEEN MY PRACTICE. WHEN TOWING TRAILER HAVE USED MANUAL APPLICATION OF TRAILER BRAKES TO DRAG TRUCK SLOWER WHICH SEEMS BETTER. EXPERIENCED WHEN DRIVING TRUCK ONLY AND ALSO WHEN TOWING A FIFTH WHEEL 12K POUND TRAILER OR A 7K POUND HITCH PULL BOX TRAILER. TRUCK WEIGHS ABOUT 9K POUNDS. FORD DEALER HAS SERVICED UNIT ACCORDING TO SERVICE BULLETIN #18-2268. FOUR VISITED FOR REPAIRS AND A FEW ADDITIONAL VISITS FOR INSPECTION BEFORE ORDERING PARTS. FORD COMPANY ISSUED A CASE NUMBER CAS-17515150-L3W8H1. THIS CASE CASE CLOSED BY FORD FOLLOWING THE LAST REPAIR WITH OUT CONFIRMING WITH BE IT HAD BEEN FIXED. I PRESENTLY HAD FORD DEALER ORDER NEW TIRES FOR INSTALL ON 10/28/2019 THEN HOPE TO HAVE ALIGNMENT CHECKED AGAIN AS WELL LOOK FOR ANY NEW SIGNS OF WEAR ON COMPONENTS. LAST TRIP FROM EMINENCE , MO TO DIXON IL EXPERIENCED THIS DEATH WOBBLE 7 TIMES. COMBINED VEHICLE WEIGHT ABOUT 22K POUNDS.

TL* THE CONTACT OWNS A 2017 FORD F-350. WHILE DRIVING 65 MPH OVER A ROUGH, BUMPY ASPHALT ROAD, THE VEHICLE AND STEERING JERKED AND SHOOK VIOLENTLY. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE "DEATH WOBBLE". THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO BOZEMAN FORD LINCOLN (2900 N 19TH AVE, BOZEMAN, MT 59718, (406) 587-1221) WHERE IT WAS DIAGNOSED THAT A STEERING STABILIZER WAS NEEDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 36,000. THE VIN WAS NOT AVAILABLE.

WHEN DRIVING AT NORMAL ROAD SPEEDS, BETWEEN 45 AND 70 MPH, WHEN VEHICLE ENCOUNTERS A BUMP WHILE IN A SLIGHT TURN, THE STEERING WHEEL STARTS TO "SHIMMY", OR OSCILLATE, VIOLENTLY, MAKING VEHICLE DIRECTIONAL CONTROL VERY DIFFICULT. DEALER HAS STATED THEY CORRECTED THE PROBLEM BUT THE PROBLEM HAS RETURNED AND SEEMS TO BE WORSE.

FRONT TIRES OSCILLATE BACK AND FORTH WHEN HITTING POTHOLES AT HIGHWAY SPEEDS ABOVE 50MPH, BRIDGE OVERPASSES ANYTHING THAT IS ROUGH. KNOWN AS THE DEATH WOBBLE FOR MOST PEOPLE. TRUCK BECOMES OUT OF CONTROL SHAKING BACK AND FORTH, HAVING TO SLOW THE TRUCK DOWN ALMOST TO A STOP. THIS ISSUE STARTED AROUND 37K MILES AND HAS JUST GOTTEN WORSE. NOW THE DEALER SAYS MY TRACK BAR WITH BALL JOINT IS RUINED, STEERING STABALIZER, 2 DRAG LINKS 1 AT PASSENGER KNUCKLE AND 1 AT THE PITMAN ARM. THIS REPAIR IS CLOSE TO $1,000.

TL* THE CONTACT OWNS A 2017 FORD F-350. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE EXPERIENCED THE "DEATH WOBBLE" AND THE TIRES WOBBLED WITHOUT WARNING. THE FAILURE OCCURRED WHILE TRAVELING OVER BUMPS IN THE ROAD. THE CONTACT TOOK THE VEHICLE TO FALLON FORD-TOYOTA (1351 W WILLIAMS AVE, FALLON, NV 89406, (775) 423-2171) ON THREE SEPARATE OCCASIONS WHERE THEY INITIALLY PERFORMED AN ALIGNMENT DURING THE FIRST REPAIR. ON THE SECOND OCCASION, THE DEALER REPLACED THE STEERING LINKAGE DAMPER PER TECHNICAL SERVICE BULLETIN NUMBER: 18-2268. ON THE THIRD OCCASION, ANOTHER ALIGNMENT WAS PERFORMED AND THE CASTER WAS REDUCED AS LOW AS POSSIBLE. THE DEALER ALSO INFORMED THE CONTACT THAT THE TIRES WOULD NEED TO BE REPLACED. THE TIRES WERE REPLACED BY AN INDEPENDENT MECHANIC. THE SAME DEALER CALLED THE CONTACT'S SON AFTER THE THIRD REPAIR TO SEE IF THEY COULD FIND A REMEDY FOR THE VEHICLE. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER A FOURTH TIME. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THERE WAS NO RECALL OR REMEDY FOR THE "DEATH WOBBLE". THE CONTACT WAS INFORMED THAT A SUPERVISOR WOULD CALL HER FOR MORE INFORMATION. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 17,835.

TAILGATE OPENS ON ITS OWN UNEXPECTEDLY. IT SEEMS LIKE IT HAPPENS WHEN PUTTING IT IN GEAR. NEVER HAD IT HAPPEN AT MUCH SPEED. IT HAPPENS AT LEAST ONCE EVERY WEEK OR TWO. SEEMS TO HAPPEN A LOT WHILE BACKING UP. IT ALSO HAPPENS JUST SITTING THERE. HAVE IT HAPPEN WITH KEY FOB JUST SITTING IN THE CONSOLE AND NOBODY TOUCHING IT.

AT 17,000 MILES JUST STARTED THE DEATH WOBBLE. HIT A BUMP IN THE ROAD, IT HAPPENED PULLING A TRAILER GOING 62 MPH. HAD TO SLOW DOWN TO 30 MPH TO REGAIN CONTROL OF VEHICLE.

ANOTHER VICTIM OF DEATH WOBBLE. IT'S HAPPENED TWICE, ONCE WITH TRUCK ALONE (JANUARY 2019) AND ANOTHER TIME PULLING A 5TH WHEEL TRAILER (9/22/2019)...BOTH DOWNHILL IN THE MOUNTAINS. THE TRUCK JUST STARTED SHAKING VIOLENTLY UNTIL I WAS ABLE TO SLOW DOWN ENOUGH TO MAKE IT STOP. THE FIRST TIME THE DEALER INSTALLED SOME CASTER SHIMS, THE 2ND TIME THEY SAID EVERYTHING LOOKED FINE AND NO ISSUES WITH THE SUSPENSION.

WHEN TRAVELING AT HIGHWAY SPEEDS THE TRUCK VIOLENTLY SHAKES AND IS UNCONTROLLABLE AFTER HITTING BUMPS OR POTHOLES. IN ORDER TO REGAIN CONTROL OF THE VEHICLE, HARD BRAKING MUST BE APPLIED TO REDUCE SPEED RAPIDLY. THIS HAS HAPPENED SEVERAL TIMES WHILE DRIVING AT HIGHWAY SPEEDS. THE VEHICLE HAS BEEN TO THREE DIFFERENT FORD DEALERSHIPS AND HAD THREE DIFFERENT SUPPOSED SERVICE BULLETIN FIX REPAIRS PERFORMED. YET HERE WE ARE STILL WITH THE DEATH WOBBLE.

I WAS DRIVING ON I-25 IN COLORADO, MILE MARKER 255, THROUGH A CONSTRUCTION ZONE. MY SPEED WAS 50 MPH. THE TRUCK EXPERIENCED AN EXTREME STEERING OSCILLATION/DEATH WOBBLE AFTER DRIVING OVER A ROUGH SPOT IN THE CONSTRUCTION ZONE. I WAS IN THE RIGHT LANE AND WAS ABLE TO BRING THE VEHICLE TO A STOP ON THE NARROW SHOULDER. ATTACHED IS THE REPAIR DOCUMENT FROM THE DEALER. DEALER REPLACED PART #HC3Z 3E651 F :DAMPER ASSEMBLY PER TSB 19-2274.

THE WHEELS AND VALVE STEMS ARE CORRODING AND LEAKING AIR. THE OEM WHEELS HAVE BEEN REPLACED UNDER WARRANTEE WITH NEW OEM BUT THEY HAVE STARTED LEAKING AGAIN. ON LONG DRIVES WHEN THE TIRES HEAT UP THE LEAK SEEMS TO GET WORSE. I HAVE TO AIR UP THE TIRES EVERY DAY BEFORE DRIVING THE TRUCK. I'M CONCERNED ABOUT THE AIR LOSS WHEN I'M HAULING HEAVY LOADS.

I HAVE SEVER SHAKING WHILE ON THE FREEWAY AFTER HITTING A BUMP OR THE ROAD CHANGES. I HAVE TAKEN IT INTO THE DEALER 4 TIMES NOW IN THE LAST FEW MONTHS TO TRY AND SOLVE THE PROBLEM. IT IS A SAFETY PROBLEM THAT HAS ALMOST MADE ME LOSE CONTROL OF THE VEHICLE. AS OF RIGHT NOW THE PROBLEM IS STILL THERE WITH NO FIX FROM FORD.

FIRST HAPPENED AT 7,000 MILES HAD IT WORKED ON NOW HAPPENED AT 13,000. FRONT SHAKES VIOLENTLY AFTER HITTING EVEN A SMALL BUMP, MUST SLOW DOWN OR WOULD LOOSE CONTROL. ACCURES ANYTIME AT HIGHWAY SPEEDS.

WHILE DRIVING ON THE FREEWAY I CROSSED AN EXPANSION JOINT WHERE THERE IS A BRIDGE, THE VEHICLE BECAUSE TO SHAKE AND BOUNCE ALL OVER THE LANE, IT IS SCARY AND DANGEROUS. I HAD TO SLOW DOWN TO ~30 MPH IN THE MIDDLE OF TRAFFIC ON THE FREEWAY TO BRING THE VEHICLE BACK UNDER CONTROL. THE VEHICLE ONLY HAS 26,000 MILES ON IT AND HAS ALREADY BEEN TO THE DEALER FOR SERVICE FOR THIS ISSUE IN THE PAST.

I HAD A CONTINUAL LOST OF AIR PRESSURE IN ONE OF MY TIRES DURING THE REMOVAL OF THE ORIGINAL EQUIPMENT TIRE AT DISCOUNT TIRES THE MANAGER INFORMED ME THAT THE CHROME WAS FLAKING OFF ON THE INSIDE OF THE RIMS WHERE THE TIRE SEALS TO THE RIM A POSSIBLE MANUFACTURE DEFECT THAT COULD CAUSE POOR SEAL AND DEFLATION OF MY TIRES OR WORST. IF NOT FOR THE NAIL PUNCTURING MY TIRE I WOULD NOT HAVE FOUND THE DEFECT IN THE MANUFACTURING OF THE 4 RIMS ON MY TRUCK. BECAUSE THE ONE TIRE WAS NOT REPAIRABLE I HAD TO BUY 4 NEW TIRES THAT HOW I FOUND THAT ALL 4 OF THE RIMS HAD THE SAME DEFECT. MY CONCERN IS MY TRUCK SAFE TO DRIVE ON THESE 4 RIMS OR COULD I HAVE A TIRE FAILURE BECAUSE OF A LOST OF TIRE SEAL FROM THE CHROME FLAKING OFF INSIDE THE RIMS. I DO HAVE PICTURE.

AT HIGHWAY SPEED (55 TO 65MPH) THREE TIMES NOW (9-13-19 WAS FIRST), AFTER CROSSING A ROUGH BRIDGE EXPANSION JOINT, THE FRONT OF THE TRUCK BEGAN SHAKING VIOLENTLY IN A SELF SUSTAINING VERY RAPID HARMONIC VIBRATION THAT MADE STEERING EXTREMELY DIFFICULT. THE LONGEST LASTED APPROX. 0.75 OF A MILE AS THE TRUCK WAS IN LEFT LANE AND NEEDED TO CROSS 5 LANES OF URBAN TRAFFIC TO GET TO RIGHT SIDE BREAK DOWN LANE. EACH TIME THE VIOLENT SHAKING ENDED WHEN BRAKING TO 37 TO 35 MPH. SEEMS TO OCCUR IF THE DRIVER SIDE WHEEL HITS THE BUMP FIRST. THE SECOND AND THIRD EVENTS WERE SIMILAR TO THE FIRST. TRUCK NOW HAS 10,800 MILES AND IS 27 MONTHS OLD.

THIS INCIDENT HAPPENED IN MAY 2019. WHEN WE'RE ON A HIGHWAY NEXT TO A RIVER TRAVELING ABOUT 60 MILES AN HOUR AND ALL OF THE SUDDEN THE TRUCK START TO VIBRATING VIOLENTLY (ALSO KNOWN AS DEATH WOBBLE).THERE WAS NOTHING I COULD DO TO CONTROL IT. MEAN WHILE MY 4 YEAR OLD SON WAS SO TERRIFIED HE COULD STOP ASKING MY WIFE IF WE WERE GOING TO DIE. WE WERE SO HELPLESS AND WE ALL FEARED FOR OUR LIFE LIVES. THAT'S TRULY THE WORST MOMENT OF MY LIFE. WE HAD THE VEHICLE TOW TO THE DEALERSHIP WHERE WE PURCHASED THE VEHICLE LITTLE OVER A YEAR AGO AND EXPLAINED TO THEM WHAT HAPPEN AND TOLD THEM NO IS NO WAY WE WERE GETTING BACK IN THAT TRUCK AND ASKED THEM TO BUY BACK. FORD DENIED OUR REQUEST AND ASSURE THE PROBLEM WAS FIXED AFTER WAITING ABOUT HALF MONTH FOR THEM TO FIX IT AND AFTER MULTIPLE ATTEMPTS. AND IN ORDER FOR THEM TO CONSIDER IT, WE MOST EXPERIENCES THE TRAGEDY REPEATEDLY. WITHOUT ANY OTHER OPTION, I DROVE THE VEHICLE FOR OVER A MONTH ON MY OWN TO MAKE SURE IT WAS SAFE BEFORE I ALLOW MY FAMILY BACK IN THE TRUCK AND FOR ABOUT 3 MONTHS EVERYTHING SEEM FINE. UNTIL YESTERDAY WHEN WE WERE ON OUR WAY TO THE AIRPORT AND THE DEATH WOBBLE CAME BACK. AGAIN, WE TOOK THE VEHICLE TO THE DEALER AND HAVE THEM SERVICE. AFTER WHAT HAPPENED, I CAN SEE WHERE THE DEATH WOBBLE TERM CAME FROM. IT WAS TRULY A LIFE AND DEATH SITUATION AND FORD DOESN'T SEEM TO CARE ABOUT THAT. I THINK WE'VE GIVING THEM PLENTY OF ATTEMPTS TO ADDRESS THE ISSUE AND I FEEL IT TIME TO REACH OUT FOR FURTHER ASSISTANCE.WE CURRENT

MY 2017 FORD F 350 XLT 4X4 SB HAS 30,000 MILES. ON TUES. MORNING MY WIFE AND I WERE DRIVING BACK TO MESA,AZ. FROM PANGUITCH, UTAH. A COUPLE MILES INTO OUR TRIP , WHILE DRIVING 55 MPH WE HIT A BUMPY AREA OF THE ROAD AND THE TRUCK STARTING SHAKING VIOLENTLY, LIKE HAVING A BLOWOUT. I HAD TO PULL OVER TO SEE WHAT WHAT WAS HAPPENING. I COULD SEE NO DAMAGE TO ANY TIRES , SO WE KEPT DRIVING AND IT HAPPENED AGAIN LESS THAN 10 MINUTES INTO THE DRIVE.. THIS TIME I SLOWED DOWN UNTIL I REGAINED CONTROL. WE DID NOT HAVE ANY MORE ISSUES THE REST OF OUR TRIP TO MESA. WE WERE PULLING A 40 FT. FIFTH WHEEL #13,500. AT THE TIME. WE WERE JUST FINISHING UP OUR SUMMER TRIP WHEN THIS HAPPENED. THIS HAPPENED ABOUT 45 DAYS EARLIER JUST OUTSIDE CHEYENNE, WY., AFTER READING A LOT OF SIMILAR INCIDENTS FROM OTHER FORD OWNERS. I FELT THAT I NEEDED TO REPORT THIS ISSUE

2017 FORD F-350 SUPERDUTY TRUCK EXPERIENCED SEVERE STEERING/SUSPENSION WOBBLE WHEN ENCOUNTERING BUMPS IN ROADWAY. FOUR INCIDENTS OCCURRED, WITH THREE OCCURRING IN THE SEPT. 18-26, TIMEFRAME IN 2019.WHILE TRAVELING AT 65 TO 70 MPH. VEHICLE WAS HARD TO CONTROL DURING THE WOBBLE, AND REQUIRED SLOWING TO 20-25MPH TO STOP THE SHAKING. OTHER VEHICLES FOLLOWING ME AT THE LISTED SPEEDS WERE REQUIRED TO BRAKE QUICKLY TO AVOID COLLISION WITH MY VEHICLE. ALL INCIDENTS OCCURRED ON INTERSTATE HIGHWAYS. VEHICLE MILEAGE WAS APPROX. 17000 MILES AT THE TIME.

ON MULTIPLE OCCASIONS WE HAVE HIT A BUMP/POTHOLE AND IT CAUSES A SEVERE DEATH WOBBLE. THE LAST TIME IT ALMOST CAUSED AN ACCIDENT. WE HAVE TAKEN IT IN 3 TIMES AND THEY COULDNT FIND ANYTHING WRONG. AFTER GOOGLING IT,IT IS APPARENT THAT THERE IS A ISSUE.

I WAS DRIVING APPROXIMATELY 70 MPH WHEN I CROSSED A SET OF RAIL ROAD TRACKS AND THE VEHICLE SHOOK VIOLENTLY ENOUGH TO CAUSE ME TO ENTER LEFT DITCH. AFTER APPLYING THE BREAKS AND SLOWING TO 15 MPH I REGAINED CONTROL. I GOT OUT AND CHECK THE TIRES AND ALL SEEMED FINE. STARTED TO SLOWLY DRIVE AND IT WAS FINE. A FEW MILES LATER I BEGAN TO SMELL DIESEL FUEL. WHEN I REACHED MY DESTINATION THE SMELL WAS VERY STRONG. OPENED THE HOOD AND THERE WAS FUEL LEAKING FROM THE TOP OF THE ENGINE AND STEAMING FROM THE INTER COOLER. DRIVE IT TO A FORD DEALER AND THEY REPLACED THE FUEL FILTER AS THE SHAKING HAD CAUSED IT TO CRACK.

2017 VEHICLE WITH 26,000 MILES. OUTSIDE DRW WHEELS, BOTH PASSENGER AND DRIVER SIDE HAVE PRESENTED CORROSION AND ARE LOSING AIR PRESSURE STATIONARY AND IN MOTION DUE TO INCOMPATIBLE METALS ON RIM AND VALVE STEM. RECALL NEEDS TO BE ENACTED AND RIMS NEED TO BE REPLACED.

I OWN A 2017 F-350 SUPER DUTY WITH 28,000 MILES. EXPERIENCING "DEATH WOBBLE" MULTIPLE TIMES PER WEEK, TYPICALLY AT SPEEDS BETWEEN 50-70 MPH AND HITTING EVEN THE SLIGHTEST BUMP OR UNEVEN-NESS IN THE ROAD. THE SHAKING IN THE FRONT END IS SO VIOLENT THAT THE VEHICLE IS NOT CONTROLLABLE AND IS EXTREMELY DANGEROUS TO THE POINT THAT MY WIFE REFUSES TO DRIVE IT. THE ONLY WAY TO REGAIN CONTROL IS BY SLOWING DOWN TO APPROX 30-40 MPH UNTIL THE SHAKING SUBSIDES. YESTERDAY, WHILE DRIVING ON THE HIGHWAY, THE WOBBLE STARTED AND PULLED ME INTO THE NEXT LANE, NEARLY CAUSING AN ACCIDENT. SLOWING DOWN IN ORDER TO REGAIN CONTROL CAUSED ANOTHER NEAR MISS AS CARS WERE HAVING TO SWERVE TO AVOID ME AS I TRIED TO REGAIN CONTROL FROM THE WOBBLE. THIS WAS AN EXPENSIVE VEHICLE AND IT IS PRACTICALLY NEW WITH VERY LOW MILES - THIS SHOULD NOT BE HAPPENING AND IN DOING RESEARCH ITS APPEARS THIS IS A VERY PREVALENT ISSUE WITH THESE TRUCKS AND FORD IS AWARE OF THE DEFECT AND IS NOT DOING MUCH TO ADDRESS IT. I NEED TO BE ABLE TO DRIVE THIS VEHICLE AND I NEED IT TO BE SAFE AND THIS DEFECT DOES NOT ALLOW THAT. THERE HAVE BEEN NO MODIFICATIONS TO THIS VEHICLE - IT IS 100% FACTORY STOCK.

WHEN HITTING A BUMP BETWEEN 50 TO 60MPH, THE TRUCK FRONT END STARTED BOUNCING WILDLY AND BECAME DIFFICULT TO CONTROL ON ANY TYPE OF ROAD. THIS HAPPENED SEVERAL TIMES MILES ON THE VEHICLE WAS BETWEEN 27,000 AND 30,000. FORD DEALER DESCRIBED THIS AS THE "DEATH WOBBLE", LITERALLY. WAS FIXED BY REPLACING STEERING DAMPER. THIS EVENT ALMOST CAUSED ME TO LOSE CONTROL OF THE VEHICLE AT HIGHWAY SPEEDS. VERY DANGEROUS.

VEHICLE DEVELOPED KNOCKING IN FRONT END AT 5,000 MILES. AT AROUND 10,000 MILES BEGAN UNCONTROLLABLE SHAKING IN THE STEERING WHEN HITTING A BUMP AT 75 MPH ON HIGHWAY. THIS WOULD STOP BY SLOWING DOWN TO 40 MPH. THIS CONTINUED UNTIL THE FRONT STABILIZER WAS REPLACED BY FORD AT AROUND 15,000. VEHICLE NOW HAS 20,000 MILES ON IT AND HAS AGAIN STARTED SHAKING UNCONTROLLABLY AS STATED BEFORE. FORDS FIX IS TO REPLACE IT AGAIN WITH THE SAME PART THAT HAS ALREADY FAILED TWICE. I HAVE HEARD OF THE SAME ISSUES FROM OTHER PEOPLE IS SIMILAR MAKES AND MODELS.

DEATH WOBBLE SYMPTOMS AT HIGHWAY SPEEDS, VIOLENT SHAKING IN STEERING AND SUSPENSION. HAD TO REPLACE TRACK BAR, STEERING STABILIZER, ALIGN FRONT END TO REDUCE/ELIMINATE POTENTIAL DANGER. POOR RESPONSE BY FORD ON THIS ONE. HAPPENED NUMEROUS TIMES, DIFFICULT TO DUPLICATE, POSSIBLE SERIOUS INJURY IF AN I EXPERIENCED DRIVER OF THIS VEHICLE IS BEHIND THE WHEEL.

AT 1700 MILES DEVELOPED FAIRLY VIOLENT DEATH SHAKE. DEALER TOLD ME TIRES ONLY AFTER MUCH DEMANDING REPLACEED STEERING DAMPER. DEVELOPED A VIOLENT WOBBLE ON INTERSTATE AT 20000 MILES WITH TRAILER AT 70 MPH THAT COULD HAVE CAUSED A CRASH. THEY THEN CHANGED CASTER WHICH HELPED BUT IT IS STILL THERE FAIRLY BAD. NOT SURE WHAT TO DO NEXT AS THEY ARE NOT OFFERING ANY FIX, TRUCK HAS 30000 MILES CURRENTLY.

TRUCK GOES INTO DEATH WOBBLE. WAS RETURNED FOR REPAIR UNDER WARRANTY AT 35,091. THE WOBBLE CAME BACK AND IS A DANGER. WE HAVE 3 F350, 17 AND 18 MODELS AND THEY ARE ALL HAVING DEATH WOBBLE PROBLEMS. THESE PROBLEMS POSE A DANGER AND SHOULD BE RECALLED, IT IS A DESIGN FLAW. WE HAVE CONTACTED FORD (REF# CAS24123991) TO MAKE THE AWARE OF THE ISSUES AND TO GET THEM TO REPAIR.

WHILE TRAVELING AT 65 MPH ON I-80 TRANSITIONED FROM TAR TO CONCRETE AND EXPERIENCED SEVERE DEATH WOBBLE. ALMOST LOST CONTROL OF VEHICLE. STEERING WHEEL WAS ALMOST RIPPED FROM MY HANDS. WAS ABLE TO GET ONTO SHOULDER OF HIGHWAY AND STOP VEHICLE. RESUMED TRAVEL AND WENT DIRECTLY TO FORD DEALER IN RENO,NV. THEY WERE UNABLE TO IMMEDIATELY INSPECT VEHICLE SO I TRAVELED BACK TO FALLON,NV. TO DEALER. RAN 55MPH 60 MILES WITH NO FURTHER INCIDENT. I DO FEEL THAT IF I HAD NOT BEEN TRAVELING IN THE INSIDE LANE ON I-80 I WOULD HAVE BEEN INVOLVED IN A DEADLY ACCIDENT. THIS IS A SAFETY ISSUED THAT NEEDS TO BE REMEDIED IMMEDIATELY!