2005 Ford F-250 SD complaints

THIS IS A FOLLOW UP TO A COMPLAINT I FILED ON 4/14/09 COMPLAINT # 10265310. I HAVE LOOKED INTO THIS MATTER AND FOUND OTHER CASES. THIS IS A SERIOUS PROBLEM THAT SHOULD BE ADDRESSED. HERE IS A LINK WITH MORE INFORMATION. HTTP://WWW.TOPIX.COM/FORUM/AUTOS/FORD-F-250-SUPER-DUTY/TOHP1M75VBFBFT9IL. *TR

I HAVE A 2005 FORD F-250 SUPERDUTY 4X4. I HAVE EXPERIENCED FRONT WHEEL SHIMMY 3 TIMES . I TOOK THE TRUCK TO A DEALERSHIP. THEY PUT ON A NEW FRONT STEERING SHOCK ABSORBER BUT IT OCCURRED AGAIN AFTER THE REPAIR. *TR

MY 2005 FORD F-250 SUPER DUTY POWERSTROKE DIESEL CREW CAB PICK UP TRUCK SHAKES AND SHIMMIES VIOLENTLY WHEN THE FRONT END HITS A POT HOLE OR TRAVELS OVER A ROAD SURFACE VARIATION. I HAVE HAD 4 INCIDENTS WHERE ON THE FREEWAY TRAVELING AT SPEEDS IN EXCESS OF 65 MPH THE VEHICLE BEGAN SHAKING AND SHIMMYING SO VIOLENTLY THAT THE TRUCK CHANGED LANES AND WAS BEYOND MY ABILITY TO CONTROL THE VEHICLE. I WAS FORCED TO TAKE EMERGENCY ACTION AND EXIT THE ROADWAY. ON ONE OCCASION THE TRUCK STRUCK A FENCE POLE ADJACENT TO THE ROAD WAY AFTER HITTING A GROOVE IN THE ROAD AT A SPEED OF 45 MPH. *TR

TL*THE CONTACT OWNS A 2005 FORD F250 SD. WHILE DRIVING 70MPH ON THE INSIDE LEFT LANE, THE VEHICLE DROVE OVER A SMALL BUMP IN THE ROAD AND BEGAN SHAKING UNCONTROLLABLY. THE CONTACT HAD DIFFICULTY STEERING THE VEHICLE AND WAS UNABLE TO DRIVE INTO THE EMERGENCY LANE. AFTER SHAKING FOR 3 TO 5 MINUTES THE VEHICLE BEGAN OPERATING NORMALLY. THE DEALER DIAGNOSED THE VEHICLE AND STATED THAT THERE WAS A TECHNICAL SERVICE BULLETIN TO PLACE A DAMPER IN THE SUSPENSION. THE VEHICLE WAS REPAIRED AND THE FAILURE NO LONGER EXIST. SHORTLY AFTER THE FAILURE OCCURRED, THE CONTACT RECEIVED A WARNING LETTER STATING THAT MAINTAINING THE PROPER TIRE INFLATION LEVEL WOULD AVOID THE FAILURE FROM RECURRING. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 80,000.

DRIVING ON HIGHWAY OVER 55 MPH, I HIT A SMALL HOLE IN THE ROAD AND THE TRUCK SHOOK TO THE POINT THE WHEEL CAME OUT OF MY HANDS. I SLOWED DOWN TO RE-GAIN CONTROL AND STAYED AWAY AS WELL AS I COULD FROM POTHOLES. I SPOKE WITH FORD A NUMBER OF YEARS AGO AND THEY DEALERSHIP RECOMMENDED AN ALIGNMENT WHICH DID NO GOOD. I HAVE JUST BEEN LIVING WITH THE PROBLEM UNTIL I RECEIVED A LETTER WITH THE EXACT PROBLEM. THEN I FIND OUT THAT A LOT OF YOU HAVE THE SAME ISSUE. WHAT IS IT GOING TO TAKE BEFORE THE GOVERNMENT OR FORD IS GOING TO TAKE ACTION A DEATH!!! *TR

LOSE OF STEERING DO TO POOR DESIGN OF FORD F-250 AND F-350 SOLID FRONT AXLE WITH SPRINGS. FROM 2005 TO PRESENT. I HAVE NEW TIRES AND RIMS,BALANCED,HAD FRONT END CHECKED FOR ALIGNMENT, MY TRUCK LIKE SO MANY OTHERS ARE HAVING SEVER FRONT END SHIMMY DO TO THE POOR DESIGN ON FORD TRUCKS. I HAVE CONTACTED LEGAL ADVICE FROM THE ADVICE OF OTHER GOVERNMENT AGENCIES. THE ATTORNEY GENERALS OFFICE,BBB, AND THE CONSUMER PROTECTION AGENCY. THIS IS MY SECOND COMPLAINT ABOUT THIS MATTER, AND IM A LITTLE UPSET TO KEEP GETTING THE ONLY RESPONSE YOU AND THE FORD CO. CAN COME UP WITH, TIRE PRESSURE!!! COME ON YOU KNOW ITS THE POOR DESIGN OF THERE FRONT ENDS. I'VE SPENT THOUSANDS TO HELP DEAL WITH MATTER TO NO BETTER RESULTS. SO FROM HERE I WILL SEEK LEGAL HELP TO PROTECT MY FAMILY AND MYSELF FROM POSSIBLE SEVERE INJURY OR DEATH. I HOPE FORD MOTOR CO. WILL FIX THE PROBLEM WITH THERE FRONT ENDS OF THERE F-250 AND F-350 SD PICKUPS FROM 2005 TO PRESENT. I HOPE IT DOESN'T TAKE SOMEONE GETTING KILLED BEFORE FORD SAYS THEY NEED TO FIX THERE TRUCKS. LIKE THEY DID WITH THERE BAD TIRE SITUATION ON FORD EXPLORER. *TR

WHILE DRIVING VEHICLE WILL START TO SHAKE, EVEN WORSE IF I HIT A BUMP IN A CORNER. HAVE TO STOP FOR IT TO GO AWAY. *TR

I OWN A FORD F-250 SUPER DUTY[2005] WITH 14,000 MILES ON IT. I HAVE HIT A SERIES OF SLIGHT BUMPS TRAVELING ON THE GARDEN STATE PARKWAY TRAVELING AT ABOUT 65 MPH. THE FRONT END OF THE TRUCK AND STEERING WHEEL SHOOK SO VIOLENTLY, I THOUGHT THE FRONT END OF THE TRUCK DIS-ENGAGED FROM THE REST OF THE BODY. THE STEERING WHEEL SHOOK SO VIOLENTLY I COULD HARDLY HOLD ON TO IT. I TOOK MY FOOT OFF THE GAS AND APPLIED THE BREAK VERY GENTLY. I MUST HAVE SLOWED DOWN TO 30 MPH BEFORE THE TRUCK BECAME UNDER CONTROL AGAIN. MEANWHILE THE CAR BEHIND ME HAD TO SLAM ON HIS BREAKS DO TO MY TRUCK BEING OUT OF CONTROL AND THE RAPID DE-ACCELERATION ON A MAJOR HIGHWAY. I HAD TO PULL OVER AS SOON AS I WAS ABLE TO CHECK WHAT I THOUGHT WOULD BE MAJOR FRONT END DAMAGE. AFTER ALL, WHAT COULD CAUSE SUCH A VIOLENT REACTION. ABSOLUTELY NOTHING TO BE SEEN. MY TRUCK WAS JUST SERVICED BY A FORD DEALERSHIP AS IT HAS BEEN SINCE I PURCHASED IT NEW. THIS HAS HAPPENED AT LEAST 4 TIMES TOTAL. I CANNOT STRESS TO YOU ENOUGH HOW VIOLENT THIS "SHIMMY" IS. THIS IS NO SHIMMY ! THIS IS LIKE RUNNING OVER A SERIES OF TELEPHONE POLES LINED UP IN THE ROAD. IT IS ALMOST IMPOSSIBLE TO HOLD ON TO THE STEERING WHEEL LET ALONE HAVE CONTROL OF THE TRUCK. THIS IS AN EXTREMELY DANGEROUS SITUATION THAT NEEDS TO BE CORRECTED ASAP OR SOMEBODY IS SURE TO DIE BECAUSE OF THIS FLAW. I WOULD BE AFRAID TO HAVE MY WIFE OR CHILDREN DRIVE THIS TRUCK AND HAVE THIS HAPPEN. THEIR LIVES WOULD SURELY BE IN DANGER. PLEASE DO SOMETHING TO CORRECT THIS SE

VERY SEVERE UNCONTROLLABLE FRONT END SHIMMY. VEHICLE WAS TAKEN TO DEALER AND NO TROUBLE WAS FOUND. SERVICE ADVISOR ADVISED TIRE BALANCING AND ALIGNMENT. I PAID FOR THAT SERVICE OUT OF POCKET AND PROBLEM STILL PERSISTED. I THEM REPLACE THE TIRES OUT OF POCKET. PROBLEM STILL PERSISTED. I THEN REPLACED THE SHOCKS AND STEERING STABILIZER OUT OF POCKET. PROBLEM IS 90 PERCENT BETTER BUT YOU MUST BE CAREFUL OF THE VEHICLE LIMITATIONS. IN MY OPINION THEIR IS A VEHICLE DESIGN FLAW. EXACT DATES CAN BE SUPPLIED IF NECESSARY. *TR

DRIVING AT SPEED. 2005 FORD F-250 VIOLENT FRONT END DEATH WOBBLE, DEALER SAID IT NEEDED ALIGNMENT, THEN SAID IT WAS MY TIRES,WITH NEW TIRES IT STILL DID IT. DEALER SAID THAT IT WAS OKAY. NOTHING WRONG. UNTIL YESTERDAY WHILE DRIVING TO INTER FREEWAY,AT 45MPH SLIGHT ROUGH ROAD SENT MY FORD TRUCK INTO VIOLENT DEATH WOBBLE ALMOST CAUSED AN ACCIDENT, BY HITTING CONCRETE BARRIER. LOST TOTAL CONTROL OF MY TRUCK. I'VE CONTACTED LEGAL COUNSEL TO SEE WHAT MY OPTIONS WILL BE, ALSO INFORMED TO MAKE CONTACT WITH DEALER SHIP TO SEE WHAT THEY INTEND TO DO. I HAVE EXTENDED WARRANTY ON MY TRUCK. DOES THIS FALL UNDER WARRANTY? OR LAW SUIT? *TR

FRONT END BOUNCES UNCONTROLLABLY AT HI WAY SPEEDS UNTIL YOU STOP , IF STILL ON THE ROAD. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. WHILE DRIVING 20 MPH, THE VEHICLE SHUT OFF IN THE MIDDLE OF THE ROAD. BOTH THE POWER STEERING AND BRAKES FAILED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER AND THEY KEPT IT FOR THREE WEEKS; HOWEVER, IT STILL HESITATES SLIGHTLY WHILE IN OPERATION. THE DEALER HAD OVER THREE PAGES OF DIFFERENT ISSUES WITH THE VEHICLE, WHICH WERE RELATED TO THE ENGINE. THE FAILURE MILEAGE WAS 60,000. UPDATED 04/24/09. *LJ THE BATTERY WAS REPLACED. UPDATED 04/28/09.*JB

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. SPORADICALLY, THE VEHICLE EXPERIENCES A NO START CONDITION. ON ONE OCCASION, WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER AND THEY STATED THAT THE FUEL PUMP, TANK, AND INJECTORS NEEDED TO BE REPLACED AT THE COST OF $4,000 DUE TO CORROSION. THE TECHNICIAN ADDED THAT THEY RECEIVED NUMEROUS COMPLAINTS AND FAILURES WITH THIS PARTICULAR MAKE AND MODEL VEHICLE. THE MANUFACTURER STATED THAT THEY WOULD NOT ASSUME ANY RESPONSIBILITY FOR THE REPAIRS AND REFERRED THE CONTACT BACK TO THE DEALER. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 23,000. UPDATED 04-17-09 UPATED 04/20/09.*JB

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. WHILE DRIVING 55 MPH, THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD AND WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE ENGINE COMPLETELY SHUT OFF, BUT THE BATTERIES AND OTHER LIGHTS IN THE VEHICLE FUNCTIONED NORMALLY. THERE WERE NO WARNING INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE VEHICLE IS STILL AT THE CONTACT'S RESIDENCE AWAITING REPAIR FROM THE DEALER. THE DEALER AND MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V270000 (ELECTRICAL SYSTEM:WIRING). THE FAILURE MILEAGE WAS 153,000.

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. THE CONTACT STATED THAT THE VEHICLE HAS A DIFFICULT TIME STARTING. THE FAILURE USUALLY OCCURS IN THE MORNINGS. ONCE IT STARTS, IT IDLES ROUGHLY. THE CONTACT TOOK THE VEHICLE TO A PRIVATE MECHANIC AND WAS INFORMED OF A RECALL FOR THE SAME YEAR, MAKE, AND MODEL VEHICLE. THE CONTACT CALLED THE FORD DEALER AND THEY STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT FEELS THAT THE VEHICLE IS UNSAFE BECAUSE HE COULD BE STRANDED. THE VEHICLE HAS NOT BEEN REPAIRED. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 108,000. UPDATED 11/17/09 *BF UPDATED 11/1/8/09

WHILE DRIVING ON THE HIGHWAY AT AROUND 60 MPH I HIT A SMALL BUMP IN THE ROAD, A NORMAL SEAM IN THE MACADMN. MY TRUCK STARTED TO SHAKE VIOLENTLY. I HAD VERY LITTLE TO NO CONTROL OF THE STEERING, AND THE BRAKING WAS ALSO VERY POOR. THE TRUCK SHOOK SO BAD THAT IT IMPAIRED MY VISION ALL I COULD DO WAS LET OFF THE ACCELERATOR AND HOLD ON TO THE STEERING WHEEL. THE TRUCK DRIFTED INTO THE LEFT LANE WHILE SLOWING. AROUND 35-40 MPH THE SHAKING WENT AWAY AND THE TRUCK ACTED NORMAL. I PULLED OFF THE ROAD AND INTO A MALL PARKING LOT AND CHECKED UNDER THE TRUCK FOR ANYTHING OBVIOUSLY WRONG AND FOUND NOTHING. I DROVE MY TRUCK HOME ABOUT 10 MILES NO MORE PROBLEMS. WHAT A VERY SCARY EPISODE. *TR

WHILE TRAVELING AT ABOUT 60 MPH I LOST CONTROL OF MY TRUCK DUE TO VIOLENT SHAKING OF THE FRONT END. I HAD TO PULL OVER AND LET SPEED DECREASE TO 20 MPH TO REGAIN CONTROL. THIS HAPPENED TWICE IN A 2 MILE PERIOD. I THEN DROVE ON SHOULDER OF THE ROAD AT 20 MPH TO GET HOME. THIS HAS BEEN A CONSISTENT PROBLEM SINCE I BOUGHT THE TRUCK NEW IN 2005 BUT IT HAS NEVER BEEN THIS BAD. I ORIGINALLY THOUGHT IT WAS BECAUSE IT WAS A 4 WHEEL DRIVE. I AM NOW NOT WILLING TO DIVE AT HIGH SPEEDS. THIS IS A SUPER DANGEROUS PROBLEM!!! *TR

I HAVE A 2005 F-250 THAT HAS A VIOLENT FRONT END SHAKE AT AROUND 60MPH AFTER HITTING A RUT OR SMALL POTHOLE, PROBLEM DOES NOT GO AWAY UNTIL I SLOW DOWN. TAKEN TO DEALER AND THEY: "INSTALLED UPDATED STEERING DAMPENER AND BRACKET PER 07-10-10 RETORQUED SUSPENSION FASTENERS.... R&R LONG AND SHORT DRAG LINK CHECK TOE RECENTER STEERING WHEEL. THE SAME PROBLEM DEVELOPED SHORTLY AFTER. I WILL BE TAKING TO DEALER AGAIN. *TR

SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AFTER HITTING UNEVEN ROAD SURFACE, DOING ABOUT 55MPH. THE SHAKING IS SO BACK IT THROWS THINGS OUT OF THE VISOR AND STUFF OFF OF THE SEAT ON TO THE FLOOR. TODAY WAS THE SECOND TIME THIS HAS HAPPEN. THIS IS A 2005 F250SD WITH 20789 MILES ON IT AND THIS IS JUST STARTING TO DO THIS. BOTH TIMES THIS HAPPEN HAD ENOUGH ROAD SHOULDER TO PULL OVER AND STOP. IF THIS HAPPEN ON A NARROW SHOULDER FREEWAY BRIDGE OR CONCRETE BARRIER I WOULD PROBABLY HIT SOMEONE OR SOMETHING. FORD NEEDS TO DO SOMETHING ABOUT THIS BEFORE SOMEONE DIES, THEN THERE WILL BE LAW SUITS. *TR

OUR COMPANY HAS 3 2005 F-250 WORK TRUCKS AND THE ALL HAVE THE SAME PROBLEM ,WHEN YOU REACH APPROX. 55MPH YOU GET A VIOLENT SHAKE FROM THE FRONTEND,AND OR IF YOU HIT A POTHOLE IT IS VERY DANGEROUS, LIKE YOUR GOING TO LOSE CONTROL DUE TO THE SHAKING AND NOBODY CAN FIND A TOTAL FIX TO THE PROBLEM,I THINK FORD SHOULD HAVE A RECALL OR SOMETHING! *TR

VIOLENT SHUDDER AND STEERING OSCILLATION. THIS FIRST HAPPENED AFTER DRIVING OVER A SLIGHT DROPOFF AT ABOUT 60MPH AND THE WHOLE TRUCK SHUDDERED SO VIOLENTLY I HAD TO BRAKE AND ATTEMPT TO STEER THE VEHICLE TO THE MEDIAN (THIS WAS HARD TO DO). THIS HAS HAPPENED FREQUENTLY SINCE AND HAPPENS AT LOW SPEEDS ALSO (40MPH) THE STEERING WHEEL HAS BEEN SHAKEN OFF CENTER DUE TO THIS. MY WIFE WILL NOT DRIVE THE VEHICLE AS ITS QUITE SCARY WHEN THIS HAPPENS AT RELATIVELY HIGH SPEEDS AND IS VERY SUDDEN AND UNEXPECTED, I ALSO WILL NOT ALLOW MY CHILDREN TO RIDE IN THE VEHICLE AS I FEEL A BAD EPISODE OF THIS SHIMMY/SHUDDER COULD EASILY CAUSE AN ACCIDENT. I HAVE ALSO GONE THROUGH 5 SETS OF TIRES (IN UNDER 70,000 MILES) DUE TO BEING UNABLE TO KEEP THE FRONT END ALIGNED. I WAS QUITE UPSET AFTER THE FIRST INCIDENT AND IMMEDIATELY BROUGHT THE TRUCK TO THE NEAREST FORD DEALER TO HAVE IT LOOKED AT. THEY SAID THEY HAD NEVER HEARD OF ANYTHING LIKE THIS AND LOOKED AT ME LIKE I WAS MAKING THIS UP. (AND I ADMIT IT SOUNDS CRAZY FOR A $40,000 TRUCK TO BEHAVE THIS WAY). THEY SAID THERE WAS NOTHING WRONG AND SAID I NEEDED MY FIRST SET OF NEW TIRES AND AN ALIGNMENT (AT 12,000 MILES). A FEW MONTHS LATER I CAME BACK INTO THE SAME FORD DEALER WITH THE SAME ISSUE AND WAS TOLD THERE WAS NOT MUCH THAT COULD BE DONE AS BASED ON MY PREVIOUS VISIT MY TRUCK APPEARED FINE. I WAS VERY DISSATISFIED WITH THIS LEVEL OF CUSTOMER SERVICE AND WALKED OUT. I AM NOW STUCK WITH A TRUCK THAT SHUDDERS VIOLENTLY SEVERAL TIMES A DAY, I A

MY 2005 FORD F-250 SUPERDUTY HAS HAD ON GOING PROBLEMS WITH THE TURBO AND INJECTION SYSTEM ON THE 6.0L DIESEL. INITIALLY THE DEALER "CLEANED" THE INJECTORS, THEN AT APPROXIMATELY 1000 MILES AFTER, AT 16K MILES THE FORD DEALERSHIP HAD TO REPLACE THE ENTIRE TURBO UNIT. I WAS TOLD I NEED TO DRIVE THE TRUCK DAILY, AND DRIVE IT HARD, ESSENTIALLY "BEAT ON" THE TRUCK IN ORDER FOR IT TO RUN WELL. I HAVE STARTED TO NOTICE A LOSS IN FUEL ECONOMY AGAIN AS WELL AS A DECLINE IN POWER. *TR

I WAS DRIVING ON I-64 DOING ABOUT 65-70MPH AND CROSSED OVER BRIDGE/ROUGH SPOT IN ROAD WHEN IT THREW THE TRUCK INTO A BAD SHIMMY. IT HAS HAPPENED AT LEAST 10 TIMES IN THE PAST YEAR. I TOOK THE TRUCK TO A FORD DEALER AND WAS TOLD THAT IT NEEDED A NEW CAMBER KIT THAT WOULD CHANGE BY 1 DEGREE. I HAD TO PAY FOR REPAIRS. THE PROBLEM STILL EXIST. *TR

TSB FRONT END OSCILLATION IIRC. OR AS KNOWN ON THE INTERNET AS THE DEATH WOBBLE (WHICH SEEMS VERY FITTING AS THE TRUCK GOES COMPLETELY OUT OF CONTROL, IT FEELS AS IF THE WHOLE FRONT END IS COMING APART!)? SEVERE SHAKING AT HIGH SPEEDS OR ON ROUGH ROADS-JUST DRIVING ALONG AND ALL OF THE SUDDEN SEVERE SHAKING OCCURS SO SEVERE THAT THIS COULD CAUSE AN ACCIDENT, ALMOST LIKE BOTH FRONT TIRES BLOW OUT AT THE SAME TIME, SEVERE STEERING DIFFICULTIES WHEN THIS HAPPENS, IF YOU COME TO A COMPLETE STOP AND THEN TAKE OFF IT STOPS?INTERMITTENT BUT INCREDIBLY DANGEROUS! HAS HAPPENED 3 TIMES WITHIN THE LAST 2 WEEKS?ONCE ON A GRAVEL ROAD, ONCE ON A ROAD WITH POTHOLES AND ONCE ON RT43 SMOOTH AS GLASS ROAD AT A SPEED OF 65MPH?THIS IS ALWAYS A SUDDEN ONSET- NO WARNING?THIS NEEDS TO BE ADDRESSED, MY CHILDREN WERE IN THE CAR WHEN WE WERE GOING ON RT43..THIS COULD HAVE KILLED US HAD IT BEEN A TWO LANE ROAD AS WE WERE JUST DOING THE SPEED LIMIT OF 65MPH AND ALL OF THE SUDDEN THE FRONT END IS ALL OVER THE PLACE AND OUT OF CONTROL! IT WAS ALMOST IMPOSSIBLE TO CONTROL...I HAD THE BRAKES TO THE FLOORBOARD AND THE FRONT END OF THE VEHICLE WAS JUMPING ALL OVER THE ROAD, HAD THERE BEEN A CAR BESIDE US WE WOULD HAVE COLLIDED WITH THEM! THIS IS ALL OVER THE INTERNET AS THE DEATH WOBBLE BUT HAD IT NOT HAPPENED TO US WE WOULD NOT KNOW ABOUT IT! THERE SHOULD AT MINIMUM BE A WARNING THIS COULD GET PEOPLE KILLED IF IT IS NOT ADDRESSED...PLEASE, INVESTIGATE THIS ON THE F250 OURS IS A 2005 BUT I HAVE READ THAT MANY

2005 F250 STEERING WOBBLES WHEN HITTING POT HOLES. THIS HAS HAPPENED 4-5 TIMES. WOBBLE IS SO BAD HAD TO PULL OVER TO COMPLETE STOP NEARLY CAUSED AND ACCIDENT. *TR

DRIVING SPEED LIMIT, ON HIGHWAY 241, ROAD BUMP/ASPHALT NEW VS OLD TRANSITION POINT, OTHER TIME MINOR POT HOLE, ONCE WHILE MAKING A RIGHT BANKED TURN ON THE 241, ANOTHER TIME WHILE DRIVING ON 57 WENT OVER A ROAD PATCH. SEVERE FRONT SHAKE UNTIL I STOP, CAUSES CARS AROUND TO DRIVE DEFENSIVELY AND I AM TRYING TO KEEP CONTROL. WIFE IS AFRAID OF DRIVING TRUCK AND IS CONCERNED FOR MY SAFETY, IT IS VERY SCARY WHEN IT HAPPENS, THE WHOLE TRUCK SHAKES LIKE A BLOWN TIRE UNTIL I STOP. CHANGED STEERING DAMPENER, ADJ STEERING BOX PLAY, CHECK TIRE PRESSURE. ONLY HAPPENED ONCE SINCE REPAIR, BUT I DRIVE VERY CAUTIOUSLY AND SLOWER THAN MOST TRAFFIC NOW. CAN'T SELL TRUCK BECAUSE I WOULD NOT DO THIS TO SOMEONE ELSE. *TR

I OWN A 2005 FORD F250 WITH 35X12.50X17 IN TIRES ON STOCK RIMS. I WAS TRAVELING NORTH ON ROUTE 8 WITH MY DAUGHTER OF 30 DAYS..YES 30 DAYS OLD AND MY DRIVERS FRONT TIRE FELL APART. THIS RESULTED IN A HORRIBLE CRASH. WE WERE TORN OFF THE ROAD IMMEDIATELY AND WENT THROUGH LOTS OF WIRE GUARD RAIL, DOWN A 40 FOOT CLIFF AND TOOK OUT DOZENS OF TREES, SOME OF THEM WERE 14" ROUND. WE ROLLED END OVER END AND AGAIN SIDEWAYS DURING THIS TIME. I WAS STRUCK IN THE HEAD WITH THE ROOF. THERE WAS SOME SERIOUS HEAD CUTS ON ME ALONG WITH SWOLLEN SORE BRUISED ETC EVERYTHING ELSE. MY 50,000 TRUCK IS TOTALED. ITS NOW JUNK AND I COULD HAVE KILLED MY DAUGHTER AND MYSELF DUE TO THIS DEFECTIVE TIRE. *TR

CRACKED TRANSMISSION CASE, TOOK INTO FORD DEALER FOR REPAIR, TRUCK IS UNDER EXTENDED SERVICE AGREEMENT FROM DEALER WE BOUGHT IT FROM, WITH A $100 DEDUCTIBLE. EXTENDED SERVICE CO WOULD SEND OUT INSPECTOR, HE INSPECTED IT AND SAID OK TO FIX, THE NEXT DAY HE SAID WE WOULD HAVE TO PAY $600. WE FINELY PAID $371.36. HE SAID THE DEALER WE BOUGHT THE TRUCK FROM WOULD NOT HONOR THE $100 DEDUCTIBLE. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT NOTICED CORROSION AND RUST AT THE LOWER REGION OF ALL FOUR WELDED DOOR SEAMS. IN ADDITION, THE TAILGATE'S LOWER INNER/OUTER SKIN WELD SEAM PANEL WAS SEPARATING, RUSTED, AND CORRODED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT THERE WERE NO RESOLUTIONS. THE FAILURE MILEAGE WAS 38,200 AND CURRENT MILEAGE WAS 39,500.

WE HAVE CONTINUOUS ISSUES WITH THE SHIMMY AND UNCONTROLLABLE SHAKE IN THE FRONT END OF OUR 2005 F250 SUPER DUTY (GAS). AT SPEEDS OF 55 AND HIGHER, THE TRUCK WILL SHAKE UNCONTROLLABLY OFF THE ROAD AT THE SLIGHTEST UNEVEN OR BUMP IN THE ROAD. WE HAVE TAKEN IT TO DEALERSHIPS NUMEROUS TIMES AND THE ONLY THING THEY HAVE DONE IS TO REPLACE THE DAMPER ASSEMBLY ON JUNE 6TH. PROBLEM STILL EXISTS AND SEEMS TO BE MORE ERRATIC AND FREQUENT. *TR

FRONT END SHAKES VIOLENTLY AFTER HITTING POT HOLES OR BUMPS IN THE ROAD. TO THE POINT WHERE A COLLISION IS HIGHLY POSSIBLE. *TR

DRIVING ON HIGHWAY AT SPEEDS OF 65 MPH, GOING OVER A BUMP ON THE ROAD, THE FRONT END STARTS SHAKING VERY BAD UNTIL YOU GET BELOW 40 MPH, IT IS ALL YOU CAN DO TO KEEP IT UNDER CONTROL. *TR

I HAVE A 2005 F250 WHEN I HIT A BUMP ON THE HIGH WAY AT 50MPH OR HIGHER THE TRUCK FRONT END AND STEERING WHEEL SHAKE VIOLENTLY AND FEELS LIKE YOU ARE GOING TO LOOSE CONTROL OF THE TRUCK. VERY DANGEROUS. *TR

I OWN A 2005 SUPER DUTY POWER STROKE AND WHEN I HIT A POT HOLE OR WHEN I'M TAKING A TURN TO THE LEFT FROM 40 MPH TO 50 MPH MY TRUCK GETS THE DEATH WOBBLES UNTIL I HIT THE BRAKES AND GET DOWN TO ABOUT 15-20 MPH. I DON'T EVEN LIKE DRIVING IT CAUSE YOU DON'T KNOW WHEN IT'S GOING TO HAPPEN. IT'S KIND OF SAD WHEN YOU PAY SO MUCH FOR A NICE TRUCK AND YOUR AFRAID TO DRIVE IT. I THINK FORD NEEDS TO HAVE A RECALL ON THESE TRUCKS BEFORE SOMEONE GETS KILLED, IT REALLY IS THAT BAD! *TR

TWO PROBLEMS. SHIFTING LEVER WOULD NOT MOVE OUT OF PARK EVEN THOUGH BRAKE WAS DEPRESSED. ALSO, CRUISE CONTROL FAILED TO DEACTIVATE WHEN BRAKE WAS DEPRESSED. DEALER REPLACED NEW SWITCHES TO CORRECT PROBLEM. *TR

2005 F-250 SHORT BED 4X4 SUPER DUTY 5.4 V-8. TRUCK SHAKES OUT OF CONTROL AT HIGH SPEED WHEN ROUGH ROADWAY IS PRESENT. HAS DONE THIS SINCE 18,000 MILES AND GETS WORSE WITH AGE. FORD REFUSES TO FIND THE PROBLEM, AS THEY ONLY DRIVE TRUCK AROUND TOWN. HAVE ASK THEM TO TAKE ONTO INTERSTATE, BUT THEY DON'T HAVE TIME ! FORD REPLACED THE DAMPER AT 34,000, HELPED, BUT DID NOT FIX! HAVE HAD MY FRONT END MAN LOOK AT FRONT END, AND HE COULD ONLY FIND SLACK IN THE STEERING GEAR BOX, BUT THAT DIDN'T FIX THE PROBLEM EITHER. THIS TRUCK IS UNSAFE AND FORD NEEDS TO STEP UP TO THE PLATE AND FIX THE ISSUE BEFORE SOMEONE GETS KILLED! THE LAST TIME IT DID IT I HAD MY 5TH WHEEL TRAILER BEHIND ME AND IT TOOK ME ACROSS 2 LANES OF TRAFFIC INTO THE MEDIAN, AND SCARED ME TO DEATH, TO THE POINT I AM SELLING THE 5TH WHEEL AND TRUCK AS IT IS JUNK, AND WILL NEVER BUY ANOTHER FORD AFTER BEING A FORD MAN FOR OVER 35 YEARS. THE ONLY WAY TO STOP THE VIOLENT SHAKING IS TO SLAM BRAKES ON AND REDUCE SPEED TO UNDER 35 MPH. I HAVE PUT UP WITH THE PROBLEM FOR SOME TIME AS THE TRUCK NOW HAS 61,000 MILES ON IT! *TR

WHEN TRAVELING DOWN HIGHWAY FROM SPEEDS RANGING FROM 50-70 MPH IF UNEVEN ROAD IN ENCOUNTERED (POTHOLES, ROUGH ROADS, OBJECTS IN ROAD..ETC) VEHICLE GOES INTO VIOLENT FRONTEND SHAKE. WHEN THIS SHAKING OCCURS IT IS AN IMMEDIATE THREAT TO NOT ONLY PERSONS IN VEHICLE BUT IN ANY VEHICLES SURROUNDING OUR OWN. REDUCING SPEED AND BRAKING IS THE ONLY WAY TO REGAIN CONTROL OF VEHICLE. *TR

WHEN TRAVELING AT SPEEDS ABOVE 65MPH FRONT END OF TRUCK BEGINS TO SHAKE AND BECOMES ALMOST IMPOSSIBLE TO STEER UNTIL SPEED IS REDUCED TO 35MPH (WHICH CAN BE EXTREMELY DANGEROUS ON A BUSY INTERSTATE) THE FIRST TIME THIS OCCURRED I HAD THE TIRES BALANCED THINKING THAT WOULD CORRECT THE PROBLEM,BUT THIS HAS HAPPENED THREE TIMES SINCE. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. WHILE THE VEHICLE WAS IN A STATIONARY POSITION, THE BRAKE CONTROLLER DID NOT DETECT THE TRAILER BEING ATTACHED TO THE VEHICLE. THIS INDICATED THAT THE BRAKES WERE INOPERATIVE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURE WAS RELATED TO THE AFTERMARKET SEVEN PIN CONNECTER. THE VEHICLE WAS REPAIRED. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED BECAUSE WHEN WATER LEAKS INTO THE CONNECTER, THERE WILL BE A MALFUNCTION WITH THE BRAKES. THE FAILURE MILEAGE WAS 28,000 AND CURRENT MILEAGE WAS 31,000.

FORD F250 FRONT END SHAKING WHEN YOU HIT ROUGH SPOT ON FREEWAY AT 65 MPH IT 2005 F250. *TR

FORD SD F250 4WD - LIKE OTHERS, SEVERE SHIMMY, ESPECIALLY ON EXPANSION JOINTS ON FREEWAYS. CAN AND DOES SPOOK THE DRIVER. SCARY MOMENTS. DEALER CHECKED, AND SAID STEER STABILIZER SHOULD BE REPLACED?? AT 61,000 K - NO WAY. OTHERS ARE SAYING SAME THING, INCLUDING BALL JOINTS BEING WORN OUT??? *TR

WHILE TOWING OUR HORSE TRAILER THE ENGINE STOPPED RUNNING. IT WAS TOWED TO DEALER AND THE ENGINE PROBLEM WAS REPAIRED UNDER FORD WARRANTY. THEY TOLD ME THERE WAS A PROBLEM WITH THE TRANSMISSION. THE MECHANIC SAID THIS IS A COMMON FAILURE AND I SHOULD WRITE IN. AS I UNDERSTAND IT, THERE IS A SNAP RING LOCATED IN THE TRANSMISSION, FOR SOME UNKNOWN REASON, THIS SNAP RING POPS OFF , IS THEN SUCKED BETWEEN THE TOP OF THE TRANSMISSION CASE AND A GEAR, WHICH CAUSES THE TRANSMISSION CASE TO CRACK. THE MECHANIC SAID THE CASE IS CRACKED ON THE TOP. HE HAS SEEN MANY OF THESE FAILURES. BECAUSE I DIDN'T BUY THE EXTENDED WARRANTY, THIS REPAIR WILL COST APPROX $4,500.00. THIS TRUCK HAS LOW MILEAGE (41900 MI). I HAVE BEEN TOLD THIS HAS BEEN A COMMON PROBLEM OF FORD TRUCKS FROM 2002 - 2005. *TR

WHEN DRIVING ON THE HIGHWAY ABOVE 50MPH THE FORD 2005 F250 SUPER DUTY BEGINS TO SHAKE VIOLENTLY TO THE POINT OF LOOSING CONTROL. THEY ONLY WHY TO STOP THE SHAKING IS TO SLOW DOWN IMMEDIATELY AND FORCE ANY FOLLOWING TRAFFIC TO SLAM ON THEIR BRAKES TOO. THE ITEMS THAT BRING ON THIS SHAKE (OSCILLATION) ARE THE FOLLOWING. THE PROBLEM OCCURS WHEN: 1. ON A HIGHWAY GOING OVER 50 MPH 2.HIITTING A BUMP IN THE ROAD. ONCE A BUMP IS HIT ABOVE 50MPH, THE OSCILLATION (LEFT TO RIGHT) BEGINS. I HAVE BEEN IN SEVERAL INCIDENTS WERE THE CARS BEHIND ME MUST MANEUVER OR STOP AND RISK RUNNING INTO OTHER VEHICLES. *TR

MY FORD F 250 TRUCK SHAKES UNCONTROLLABLY AT HIGHWAY SPEEDS WHEN THE FRONT SUSPENSION IS UPSET ON HIGHWAY. NORMALLY OCCURS AT OR ABOVE 65 MPH, THE WAY TO RE-GAIN CONTROL IS SLOW CONSIDERABLY. THIS IS CONSISTENT WITH FACTORY AND REPLACEMENT TIRES. FORD STATED THAT THERE IS A PROBLEM, BUT THAT IT DOESN'T WARRANT A RECALL. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. WHILE DRIVING APPROXIMATELY 70 MPH OVER A BUMP, THE STEERING WHEEL BEGAN TO VIBRATE AND SHAKE. THE CONTACT LOST PARTIAL CONTROL OF THE STEERING AND THE VEHICLE SWAYED TO THE SHOULDER OF THE HIGHWAY. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A MECHANIC FOR THIS FAILURE AND WAS ABLE TO BE DRIVEN. THE FAILURE OCCURRED TWO ADDITIONAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THEY PERFORMED A SAFETY INSPECTION. THE TECHNICIAN STATED THAT THERE WERE NO MALFUNCTIONS WITH THE VEHICLE. THE FAILURE MILEAGE WAS 42,000 AND CURRENT MILEAGE WAS 51,000. UPDATED 07/29/08 *BF UPDATED 07/29/08

2005 FORD F-250 TRUCK FRONT END WOBBLE. HAS DONE IT SINCE ABOUT 20,000 MILES. DRIVING 55+ MILES PER HOUR, TURNING TO THE LEFT, FRONT END AND STEERING WHEEL SHAKES VIOLENTLY. *TR

2005 FORD F250 4X4, 4 DOOR, AUTO, 5.4L GAS, APPROX. 39K MI. TRAVELING AT INTERSTATE HIGHWAY SPEED, IN A SWEEPING LEFT HAND CURVE, CROSSING ROUGH PAVEMENT, A SEVERE STEERING WHEEL SHAKE AND FRONT WHEEL SHIMMY COMMENCED, CAUSING LOSS OF STEERING CONTROL, INVOLUNTARY RAPID LANE CHANGE AND NEAR ACCIDENT. I SLOWED TO 25 MPH IN ORDER TO REGAIN CONTROL OF THE TRUCK. LIVING IN FL AND WORKING IN SC AT THE TIME, I WAS FORCED TO DEAL WITH DIFFERENT FORD DEALERS IN THE COLUMBIA, SC AND BARTOW, FL AREAS. ON THE ADVICE OF VARIOUS FORD SERVICE DEPARTMENTS, I REPLACED TIRES, WHEELS, BALL JOINTS, SHOCKS (TWICE), STEERING STABILIZER, HAD MULTIPLE ALIGNMENTS AND WHEEL BALANCES PERFORMED. AS I WAS STRANDED OUT-OF-TOWN WITH A TRUCK THAT WAS HANDLING PROGRESSIVELY WORSE, I SPENT APPROXIMATELY $4,500 IN PARTS REPLACEMENTS BEFORE THE PROBLEM WAS REMEDIED. THREE FORD DEALERSHIPS ACKNOWLEDGED THAT A SERIOUS PROBLEM EXISTED AND THAT THE VEHICLE WAS IN WARRANTY. FORD CUSTOMER RELATIONSHIP CENTER PERSONNEL, 800-392-3673, EMPLOYED BLATANT STALLING TACTICS UNTIL MY ODOMETER HAD PASSED 40,000 MILES, THEN REFUSED TO RENDER ANY ASSISTANCE. MORE THAN ONE YEAR LATER, I AM WAITING FOR A CALL FROM A REGIONAL FORD SERVICE MANAGER, SUPPOSEDLY ARRANGED THROUGH A COLUMBIA, SC FORD DEALER. I HAVE RECEIVED HIGH SPEED DRIVING INSTRUCTION AT TWO DIFFERENT POLICE ACADEMY COURSES. I HAVE DRIVEN DOZENS OF DIFFERENT VEHICLES AT VERY HIGH SPEEDS OVER HUNDREDS OF THOUSANDS OF MILES. I KNOW A DANGEROUS VEHICLE DEFECT WHEN I SEE

WHEN TRAVELING AT HIGHWAY SPEED AND TRAVELING OVER UNEVEN SURFACES OR BRAKING FROM HIGHWAY SPEED OVER UNEVEN SURFACES THE FRONT END BEGINS TO SHIMMY/OSCILLATE AND THE STEERING WHEEL BEGINS TO SHAKE VIOLENTLY. THIS IS OCCURRING MORE FREQUENTLY. *TR

TL*THE CONTACT OWNS A 2005 FORD F-250 SUPERDUTY. WHILE DRIVING APPROXIMATELY 45 MPH, THICK SMOKE APPEARED FROM THE REAR EXHAUST PIPE. THE VEHICLE BEGAN STALLING WHILE EN ROUTE TO AN AUTHORIZED DEALER. THERE WERE NO WARNING INDICATORS PRIOR TO THIS FAILURE. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER. THE MECHANIC REPLACED THE 2, 6, AND 8 FUEL INJECTOR COMPONENTS; HOWEVER, THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN TO THE DEALER TWO ADDITIONAL TIMES, BUT THE FAILURE WAS NOT CORRECTED. THE FIRST REPAIR WAS COVERED UNDER WARRANTY AT THE COST OF $106.50. THE TOTAL REPAIR COST WAS $506.70. MOST RECENTLY, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE PREVIOUS FAILURES WERE RELATED TO THE EGR COOLER SYSTEM. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 95,246 AND CURRENT MILEAGE WAS 120,000.

2005 FORD F-250 SD SHAKING VIOLENTLY AFTER GOING OVER UNEVEN SURFACES ON HIGHWAY. WE WERE OUT OF THE STATE WORKING FOR 10 DAYS AND DEPENDED ON THIS VEHICLE SO THE FOLLOWING DAY WE TOOK IT TO A FORD DEALER AND ALL THEY HAD TO SAY WAS THE TIRES NEEDED 80 POUNDS OF AIR. AS SOON AS WE RETURNED HOME WE TRADED IT OFF AND GOT A 2006 AND IT IS DOING THE SAME THING AND A COMPLAINT HAS BEEN FILED ON IT AS WELL. DONE WITH FORD TRUCKS, IF FORD DOESN'T THINK ANY BETTER OF ITS CUSTOMERS THAN TO PUT AN UNSAFE VEHICLE ON THE ROAD WE ARE GOING TO CHEVROLET. *TR