2021 Ford F-150 complaints

On June 17, 2022 while driving to work on highway in Nee York Stare, I put the adaptive cruise control on so I could adjust my drivers side rear view mirror. The truck suddenly lunged to the left striking a guard rail and overturned several times. Despite being a direct high speed impact to the guard rail and overturning , the steering airbag did not deploy. See police report attached. Due to this , I sustained major internal tissue damage including: a broken sternum, punctured lung bruised aorta, 4 fractures to the vertebrae in both my upper and lower spine and 4 broken ribs in my upper rib cage. I spent a total of 11 nights in the hospital including 4 nights in the ICU. I have not been cleared to return to work and instill under medical care. I understand there was a airbag/steering column recall on other F150s but I strongly suspect that the reveal needs to be expanded to mite vehicles such as mine. All the Doctors that treated me said my injuries were the direct result of the steering wheel airbag not deploying. The state trooper that reined me from my vehicle , as well as one of the witnesses both told me that my steering airbag did not deeply. I also have pictures as well.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced a failure. VIN tool confirms parts not available.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 21V986000 (Power Train, Structure) however, the part to do the recall repair was not yet available. The contact stated upon parking the vehicle, he noticed that the underbody heat and noise insulators had detached and was hanging on the ground. The vehicle was taken to the dealer who informed the contact that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and a case was opened. The vehicle was not repaired. The failure mileage was approximately 7,000. VIN tool confirms parts not available.

The windshield wiper arms are defective as pieces of metal from the splines have come off and I do have them. I asked the dealership to check it when I had the last recall and oil change and evidently they did not even check it. I called Ford customer service today and the customer service rep said that my particular vehicle was not covered under the recall as it did not apply. Evidently they don't understand that there are more vehicles with the problem as mine is very evident. Consumer's vehicle was not part of the recall as they did see and have the parts that have fallen out of the wiper arms. They said that they can replace it under warranty but are not able to get the parts as they are going to the recall vehicles.

My truck was parked in my driveway when i noticed a slight bulge like curve in my rear window. When I opened the door the rear window completely shattered. My local Ford dealership confirmed that the Ford f150's have had this problem for years. They sent pictures to Ford about covering the replacement of the window. Ford refused

The center retaining bolt on the rear 9.75” 3/4 floating locker axle sheared off after only a few thousand miles, requiring an axle replacement.

Have had squeeking breaks since receiving the truck a year ago. Brought in and was told to watch for a letter they don't have the part that my breaks are safe but the squeeking has gotten a lot worse. Also the dash board lights turn on and off when the car is off. The other day driving at speed on the expressway the whole dash board turned off all gages went to zero than rebooted. I was coasting trying to figure out what was happening so not sure if I lost power. 3 faults were sent to my phone. Restraint fault abs fault and tire pressure fault all showed up.

Seal - Valve - Ford (KL3Z-9U465-A) I have the same engine that is failing in all of the new Ford Broncos - Ford's 2.7L V6 2nd Generation, however, I have this engine in an F-150. My vehicle has been sitting at the dealership for over a month, diagnosed with a faulty valve (same issue that is in the broncos) Seal - Valve - Ford (KL3Z-9U465-A) Something needs to be done about this - Ford has offered me no loaner or rental vehicle AND I am still paying car payments while it is sitting up there at Ford! Help

The contact owns a 2021 Ford F-150. The contact stated that while driving approximately 55 MPH in a rainstorm, the front windshield wipers became inoperable, causing a visibility hazard for the driver. The vehicle was taken to the local dealer who diagnosed that the wiper motors were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The contact was informed that the vehicle was not included in the NHTSA Campaign Number: 22V250000 (Visibility). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 17,250.

The bolt that secures the hub to the semi float axle shaft sheared on the rear passenger side. At this point, the only thing holding the wheel/hub assembly on the truck is spline friction and brake caliper. I discovered the issue today during a tire rotation, but based on the condition of the bolt it appears that the bolt has been sheared for some time--possibly from the factory. More owners reporting the issue here: https://www.f150forum.com/f129/2021-powerboost-rear-rotor-axle-bolt-sheared-515460/

The contact owns a 2021 Ford F150. The contact had received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was not yet available. The contact stated while driving 65 MPH in the rain, the front windshield wipers became inoperable. The contact stated no warning light was illuminated. The contact took the vehicle to local dealer, where it was diagnosed with needing the windshield wiper motor and the blades to be replaced. The dealer replaced the blades but the windshield wiper motor parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 15,400.

Passenger wiper arm fell off during rain while driving on highway.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 21V986000 (Power Train, Structure) and 22V193000 (Electrical System) however, the parts to do the recall repairs were not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact had not experienced a failure. VIN tool confirms parts not available on NHTSA Campaign Number: 21V986000. Parts distribution disconnect on NHTSA Campaign Number: 22V193000.

The contact owns a 2021 Ford F-150 The contact received notification of NHTSA Campaign Number: 22V250000 (Visibility) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available. The contact stated that the recall was resolved by the Ford dealer.

The contact owns a 2021 Ford F-150. The contact stated while driving approximately 70 MPH, the hood was vibrating. The contact pulled over safely and noticed that the hood bolts were loose and one was missing. There were no warning lights illuminated. The vehicle was taken to a local dealer who diagnosed the failure with missing latches and bolts. The dealer repaired the vehicle. The manufacturer was notified of the failure. The approximate failure mileage was 8,000.

The contact owns a 2021 Ford F-150. The contact stated while driving 5 MPH, the brake pedal was depressed to the floorboard however, the vehicle failed to stop with several unknown warning lights illuminated. The contact stated that within several seconds, the brakes would engage and stop the vehicle. The contact took the vehicle to the local dealer to be diagnosed however, the mechanic was unable to determine the cause of the failure. The contact stated that the failure persisted. The manufacturer had not been informed of the failure. The failure mileage was approximately 6,000.

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed in the rain, the front windshield wipers stopped working without warning. The contact restarted the vehicle. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was notified via email but no response was received. The failure mileage was approximately 25,460.

Vehicle has malfunctioning backup camera module. Dealer replaced module and was unable to correct the issue. Dealer forced owner to pick up vehicle with inoperable backup camera even after owner expressed their concerns over the non-functional safety system. When the vehicle was picked up from the dealer, 8900 mileage was on the odometer, within the manufacturers warranty period. Consumer was told that the vehicle was in a drivable condition and that they would no longer be able to supply a loaner vehicle. The dealer also stated that the vehicle is equipped with mirrors and reverse imaging system should not be relied upon.

The contact owns a 2021 Ford F-150. The contact stated while driving approximately 65 MPH, the brake was inoperable. The contact stated that the trailer brake warning light was illuminated. The vehicle was diagnosed with software failure and repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number: 22V193000 (Electrical System) however, the VIN was not included. The approximate failure mileage was 4,600. The contact stated that the trailer brake controller was replaced and the issue with the vehicle no longer exists.

I was driving down the interstate, traveling around 70MPH and my check engine light came on as well as a notification to my phone. The phone notification from the Ford Pass app read: POWERTRAIN MALFUNCTION / REDUCED POWER What is Happening?: Illuminates when the system has detected a powertrain or a four-wheel drive fault. What should I do?: A powertrain or all wheel drive/four wheel drive fault has been detected. Contact your authorized dealer as soon as possible. The vehicle wasn't responding to me pushing down on the accelerator, as if the engine had just stopped working. I bought this truck new in October of 2021 - it is a 2021 F-150 and currently has only 9,500 miles on the odometer. As soon as this happened, I thought back to an article I saw recently about the Ford Broncos failing.. connecting the dots, the same engine that is failing in the new Broncos, the 2nd generation 2.7L V6 is the same engine in my 2021 F-150. It has not been diagnosed as of this moment, it will be diagnosed tomorrow; however, I am afraid this case is the same as the others reporting issues with the 2nd generation Ford 2.7L V6 - I may need a new motor!

The bolt holding the hub to the axle sheared off. THis truck is less than a year old with 95% highway miles so, not sure what the cause is other than negligence on Ford's end. Without this bolt, the wheel could separate from the axle while driving and cause a serious incident. There was no indication other than a slight rattling I could hear while driving slow with the windows down. It is possible there are many people out there with the same serious issue without knowing. This seems to be a common issue looking through forums of people with the same truck and Ford is giving everyone the run-around. This is too serious of an issue to be taken lightly and an official recall should be made.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 21V986000 (Power Train, Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and a case was opened. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2021 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle was shaking and jerking. The vehicle was taken to the dealer, and the dealer replaced all four tires; however, the failure recurred. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 2,000.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 21V986000 (Power Train, Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

While driving on the highway, the sunroof spontaneously exploded, sending small pieces of glass everywhere including at the vehicle driving behind us. Fortunately our sunroof screen was closed, otherwise the glass would have shattered into the truck on me and 2 kids as well. The loud “bang” caused us to duck and swerve as it sounded like a gunshot. This occurred on a new truck with only 5,000 miles on it. The dealership currently has the truck and upon replacing the sunroof noticed that no sunroof drains were ever installed on the vehicle. We don’t know if this is related to causing the sunroof to explode, but the dealership claims it does not have anything to do with the sunroof shattering.

The contact owns a 2021 Ford F-150. The contact stated that on three separate occasions, the windshield wipers failed to operate as needed without warning. After the second failure, the contact took the vehicle to an independent mechanic where a fuse was replaced; however, the failure returned despite the repair. The contact stated that only wiper fluid would release while attempting to clean the windshield. The contact then took the vehicle to a dealer where they acknowledged that the wiper failure was a known issue; however, replacement parts were not available. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 41,000.

This vehicle has a transmission problem relating to how it shifts gears at low speeds. This results in delayed shifts, missed gears, and sometimes a jerk and loud "clunk" when the shift occurs. This is not only distracting (the first time I literally looked back to see if I had hit something, or if something had broken off). This will likely contribute to premature wear and failure which could happen at an inopportune time.

The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle lost power steering assist and became difficult to maneuver. The contact stated that several warning messages appeared on the instrument panel as he had stopped the vehicle on the highway shoulder. The contact was able to drive to dealer where he was informed that the failure was a commonly known issue. He was informed that the wiring underneath the engine was soy based and had been eaten up by rodents and other outdoor creatures. The contact was given an estimate for the cost of the repair. The manufacturer had been notified of the failure and referred the contact to the NHTSA for assistance. The vehicle had yet to be repaired. The failure mileage was approximately 10,000.

The bolt on the end of the axle on the right side sheared off. When this happened the only thing holding the wheel on is the brake caliper. The oil from the broken axle seal leaked onto the brake pads and rotor which reduced their effectiveness. The vehicle is not safe to drive.

The contact owns a 2021 Ford F-150. The contact stated that while driving the vehicle suddenly began to shudder and vibrate. Later, the vehicle would not start and message "system failure" had displayed. A clicking noise and burning odor was present coming from the engine compartment had occurred and the contact exited the vehicle. The cause of the failure was not determined. The local dealer was notified of the failure. The manufacturer was not yet notified. The failure mileage was 4,000. 3/12 While spuddering would not start and dash panel system failure. clicking sound and burning odor coming from the motor.

The contact owns a 2021 Ford F-150. The contact stated while driving 55 MPH, the transmission suddenly downshifted into first gear, and the contact almost lost control of the vehicle. The contact pulled over and turned off and restarted the vehicle. The contact took the vehicle to an independent mechanic and the vehicle was diagnosed with a cracked oil pan. The vehicle was repaired however, the failure recurred. The manufacturer was notified of the failure. The failure mileage was 1,200.

The contact owns a 2021 Ford F-150. The contact stated that while driving at 40 MPH at night, the instrument panel light turned off intermittently. There were no warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed that an unknown software needed to be updated; however, the dealer informed the contact that the manufacturer advised that the remedy for repair was not yet available. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 2,700.

The contact owns a 2021 Ford F-150. The contact received notification of NHTSA Campaign Number: 21V986000 (Power Train, Structure) however, the part to do the recall repair was not yet available. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. The manufacturer was made aware of the issue. VIN tool confirms parts not available.

My emergency brake engages in its own. It has done it more than 20times since I have owned the vehicle. The first time it happened was about a month after purchasing. The last time it engaged I was pulling into a parking spot a couple weeks ago. Sometimes it come on when parked and other times The brake light on the dash will flash at me if I am in motion as it engages. When I disengage the brake I can hear the noice as it retracts. I assume typically there is a safety if it engages at high speeds but If this can have a glitch it makes me nervous if it would engage at highway speed and cause an accident. I have small children that ride with me and makes me nervous. I have brought it to the attention of the dealership I bought the vehicle from and they could not find anything wrong. I plan on taking it to a Ford dealership closer to my home as I drove a distance to purchase my vehicle. I believe this to be a huge risk if it would lock up while driving.

Complete engine failure at 2,300 miles. The engine is a 2.7 V6 which has recently been documented as having potential engine problems per Motor Trend. The truck just stopped running with no warning.

The contact owns a 2021 Ford F-150. The contact stated while driving approximately 45 MPH at night, the low-beam headlights were very dim. The contact stated no warning light was illuminated. The contact took the vehicle back to his residence and noticed that both headlights were completely fogged over. The contact drove the vehicle to a local dealer, where it was diagnosed and the contact was informed that the fogging was normal. The vehicle was not repaired. The manufacturer had been informed of the failure and the contact was informed that the headlamp fogging was normal. The failure mileage was approximately 597.

The contact owns a 2021 Ford-150. The contact stated while driving 65 MPH, the under-body panel, power train malfunction, and engine malfunction warning lights illuminated. The contact then heard a scraping sound coming from underneath the vehicle. The contact was able to safely exit the highway. The vehicle was driven back to the residence with no further issues. On another occasion, while stopped in a parking lot, the check engine and power train warning lights illuminated. The contact’s daughter exited the vehicle and the vehicle lost motive power. The vehicle was restarted and driven back to the residence. The vehicle was then taken to the local dealer to be diagnosed. A multipoint inspection was performed and the contact was informed that the waste gate actuator needed to be replaced. The manufacturer was informed of the failure. The contact requested a buy back which was declined. The approximate failure mileage was 3,032.

The contact owns a 2021 Ford F-150. The contact received an email notification of NHTSA Campaign Number: 21V986000 (Power Train, Structure) however, the part to do the recall repair was unavailable. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. VIN tool confirms part not available.

1) Pre-collision assist not available---- when starting after vehicle has been sitting off for one hour. Service AvanceTrac----when starting after vehicle has been sitting off for one hour. Hill start assist not available-----when starting after vehicle has been sitting off for one hour. Check brake system-------when starting after vehicle has been sitting off for one hour. All these warnings appear when starting the engine after vehicle has been sitting off for one hour. Yes, it is available. 2) I don't know if I restart the vehicle and warnings do not reappear if the components at fault still work. 3) Don't think it was reproduced. Showed dealer photos of warnings displayed on my dash. Dealer said no fix currently available. 4) No 5) All these warnings appear on the dash when starting the engine after vehicle has been sitting off for one hour. First appeared after starting on multiple occasions.

DOOR LOCK In freezing temperatures, the door locking mechanism can become inoperable (the door will not unlock and you cannot enter or exit the vehicle using that door). The door fails to unlock using manual key, auto unlock with keyfob in hand, pressing the button on the handle or entering the security code. Sometimes after a few attempts, you will be able to open the door despite the lock pin at the top of the down frame is still down. However, once in the vehicle, you will not be able to get back out until the vehicle is warm. This is a risk in case of accident or fire. The issue is currently being diagnosed by dealership. No other warnings. Only happens in freezing temperatures (in my case temps in the mid-teens and below).

Vehicle accelerated while running several times. The transmission knocking when shifting when the transmission warming up in short and long travel. The front brakes comes mad after clean the truck.

The strap is fraying significantly for the main buckle. This part is not one that’s regularly retracted and extended as it’s a fixed size.

Automatic stop and go stopped working and dealer is unable to repair it. It has been to the dealer twice. It stopped working for the second time on October 25, 2021. The dealer has had the vehicle since December 30, 2021. As of today January 13, 2022 they still haven't found the problem

My brand new F150 2021 had a powertrain malfunction with power totally reduced. I had no ability to accelerate. I had to glide over to the side of the road. I restarted the car. It reset, i went to accelerate and again i had an error code and my car froze. I was able to restart again and drive over to my Ford dealership i purchased it from at 15 miles per hour. The problem was reproduced once and confirmed by the dealer. The dealer has contacted Ford and was told they have never seen that error code for a F150. The GM of Ford here in Montana told me if they cant reproduce the problem again, i can have the truck back. This truck is 3 weeks old. I am terrified.

The contact owns a 2021 Ford F-150. The contact stated while he was in a pharmacy drive-through, the vehicle accelerated independently. The contact stated no warning light was illuminated. The contact stated he was depressing the brake pedal to the floorboard but failed to stop the vehicle from driving over the landscape of the pharmacy and over a boulder. The contact stated the vehicle continued moving forward for half a block until he was able to regain control of the vehicle by pumping on the brake pedal. The contact stated he was able to make a left turn at a near urgent care parking lot and park the vehicle. The contact stated the front passenger hit her head and right shoulder on the front passenger door due to the seat belt not retracting and sought medical attention at the emergency room. A police report was not filed. The vehicle was not drivable. The contact towed the vehicle to a local dealer. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 4,133.

After driving the vehicle for 14,000 miles I was traveling out of state when my wife and I discovered that the passenger seat belt was not anchored to the floor. When we arrived home there was a recall notification in our mail. I immediately went to Serramonte Ford in Colma, CA and scheduled the required inspection for November 1. They assured me that any necessary repair would be done at that time. Later that day they called and told me that I needed a new part but they were required to order it from a special source because it was a recall item. (What)! They called two weeks later and advised that the part arrived and I made an appointment for November 16 and dropped the vehicle off. Later that day they called and told me that they needed a gasket so the repair couldn’t be done. I picked up the vehicle and they told me they would call me to reschedule the repair. It is now January 2022 and I have been driving this vehicle for eleven months without a seatbelt. They can’t tell me when to expect the repair.

Cluster will randomly shut off causing all gauges to act like the vehicle isn't on. Then it will turn back on. I notice that transmission temp gauge will be the only gauge that wouldn't go back to normal. It will take several minutes for gauge to reset. The risk is not knowing your speed and causing a distraction to what is happening while driving. No dealer could redo the problem.

The Pro Trailer Assist program won't load or work along with constant electrical lamp fault messages when trailering my boat. This is a safety concern because you can't tell if the trailer lights are really working or not while driving. I also experience the turn signals blinking really fast like a bulb is out - when none are actually out. The local dealer's electrical technician has reproduced and confirmed my issues. The manufacturer is aware of my problem and is currently offering to put me in a 2022 truck that will be built in February. The Pro Trailer Assist program never would load or work from day one. The electrical lamp fault messages started as soon as I trailered my boat. All the lamp fault messages and fast blinking turn signals only happen while trailering my boat. The local dealer had my new truck forty days and replaced the APIM Module twice with no success. Mileage then (328), mileage now 1,255.

Transmission is shifting very hard at different times, points, speeds, up shifting and down shifting. It jerks so hard at different times that my wife’s neck was sore, the dealer is taking 3 weeks before they will look at it!

After connecting my boat trailer, I had ZERO trailer brakes. The lights all worked, brake, running, signal-but no trailer brakes. I turned the integrated trailer brake gain to the highest setting-still zero trailer brakes.