2012 Ford F-150 complaints

The contact owns a 2012 Ford F-150. The contact stated that while driving at various speeds, the vehicle unintendedly downshifted with the drive(D) gear shift light flashing on the instrument panel. Upon investigation, the contact discovered that the vehicle was included in NHTSA Campaign Number: 19V075000 (Power Train). The vehicle was taken to a dealer where they initially informed him that due to the mileage on the vehicle, the vehicle did not qualify for the recall. The contact left the vehicle in the possession of the dealer and was informed that water was found in the transmission and the radiator; therefore, both parts needed to be replaced. The contact then took the vehicle to an independent mechanic where he had the transmission drained; however, the failure persisted. The manufacturer was notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 171,000.

My power steering assist light and my advance track light came on then my steering locked up and I had no control of my vehicle. Luckily I was pulling Into my drive so no one was hurt. I had my 7 year old gson with me too. It could of been fatal. I did some research there's a recall on this on vehicles before 2012 and after 2012 but not on my vehicle which is a 2012 my rack and pinion went out I don't have any backup lights this could have been a serious accident and if anything would have happened to my grandson oh boy Ford but I want to know why my truck doesn't have a recall hurt

The contact owns a 2012 Ford F-150. The contact stated while driving approximately 40 MPH, the transmission downshifted to first gear causing the rear wheels to lock up. The contact stated that the vehicle almost came to an immediate stop. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer where it was diagnosed that the Molded Leadframe (Part Number: AL3Z7G276D) needed to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was 73,368.

Our truck suddenly went into "limp-mode," for no reason. When we turned the truck off and back on, it was fine.

The contact owns a 2012 Ford F-150. The contact stated while driving 55 MPH, the contact attempted to accelerate however, the vehicle failed to respond. The check engine warning light was illuminated. The contact pulled over and turned off and restarted the vehicle. The vehicle drove normally however, the check engine warning light remained illuminated. The vehicle was taken to the dealer where an unknown calibration was performed however, the failure recurred. The manufacturer was contacted and informed the contact that the vehicle was out of warranty. The contact was referred to the NHTSA for assistance. The failure mileage was 139,501.

While driving at any speed, the vehicle unexpectedly downshifts into first gear causing a risk of losing control or crashing. This incident has occurred 3 times in the last week and has all the same symptoms related to Ford Recall # 19N01 & 19S19.

The contact owns a 2012 Ford F-150. The contact stated while driving 70 MPH with the defroster engaged, the contact heard a loud popping sound coming from the rear of the vehicle. The contact noticed that the rear passenger's side window had shattered. The contact was able to continue driving. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 149,000.

It appears the master cylinder is leaking into the large black vacuum piece. Parked and went into shop in Safeway. Then came out and loaded kids, wife and groceries. Started truck, started to back out of spot, then tried to stop and no brakes, low brake fluid then comes up. I threw it into park and tried to think what is going on. Check the brake fluid and it is empty. Then go to gas station and add 2.5 pints. Start truck and wife pulls brakes and gets back to working, but notice the brake fluid is decreasing from resivior but seemed to stop. I topped it off and started to drive because brakes were working. After driving about 10 blockes, the low brake fluid alarm comes up again and I pull over and no brakes. Finally investigate and still no leaks anywhere. Finally look up online and find this is a common problem and you have recalled 2014 through 2017, but not 2012 or 2013, but seems to be a problem with this year as well.

Wipers will not turn off, they will continue to wipe while driving for days even in the off position, had to pull the fuse in order to stop the intermittent wipe, when it rains i have to re install the fuse. After months of dealing with this problem I drilled a hole in the dash, mounted a switch and ran a wire to the fuse box so I didn't have to open the hood just to get the morning doo off, the switch works great.

The contact owns a 2012 Ford F-150. The contact stated that while driving at various speeds, the vehicle unintendedly downshifted upon the depression of the accelerator pedal. The contact stated that an unknown warning light was illuminated on the instrument panel during the failure. Upon investigation, the contact discovered NHTSA Campaign Number: 19V075000 (Power Train) which she linked to the failure. The dealer was contacted about the failure and the contact was informed that there were no open recalls on the VIN. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 240,000.

The contact owns a 2012 F-150. The contact stated while driving approximately 40 MPH, the vehicle inadvertently downshifted and the speedometer went to zero. The check engine warning light was illuminated. The vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number: 16V248000 (Power Train). The approximate failure mileage was 118,000.

Vehicle lost its power in the power steering system, and you lose all control over the vehicle and you can't move left or right Making it very dangerous for me while it occurred, since I was unable to move the car towards any direction.

275/60/20 tire size. Driving home the other night started noticing my truck felt wobbly. Thought it was just the road until the truck started violently shaking at around 60mph. VIOLENTLY shaking. Pulled off immediately and looked at the front, sides, rear end, etc. Checked the tires, rear passenger side was stolen in 1 spot, and around that spot in a very isolated area the tire was completely bald and had a large lump in it. Other 3 tires seem ok right now. Contacted manufacturer who directed me to fill out a form on their website to "try for a replacement.". Can't find receipts from purchase so that's no good. Took to local mechanic/tire shop who stated that the "tread separated from the tire.". Separation is approximately 1 foot long and 2/3 of the tire width. Bald spot runs along this lump/separation.

Vehicle shifts from a high gear to a low gear. While driving 60 miles an hour on the expressway my F150 went from six gear to first gear with no warning locking my rear wheels causing my speed to drastically or abruptly be lower almost causing several other vehicles to crash into the back of my pick up. Vehicle stays on gear sometimes first third or fifth gear with no warning switching back-and-forth. While making a stop at 0 mph vehicle stays at a high gear for example he could stay at third gear or fifth gear so they takeoff will be in third or fifth gear not in first gear . Also losing speedometer reading. This has happened multiple times while driving at low speed or high speed. I am concerned that this could cause accidents in the roads. Ford motor company corporate advised me that is an auto pocket fix sensor customer satisfaction program has expired for my vehicle. I never received notification of this issue while on my truck was within warranty. Ford Motor Company stated that they extended their coverage until 10,000 miles or 150,000 miles whichever comes first. My vehicle has 165,000 miles and he’s 10 years old. I don’t believe this is a normal Tear and water failure. This is a manufactures defective part that has happened in thousands of vehicles is not an isolated incident.

On 22MAY2022 I started my vehicle and started pulling out of a parking space when I lost braking power. The failure resembled a similar issue I had in the past when the electronic vacuum pump failed and the brake pedal felt hard and required significant additional effort to bring the vehicle to a stop. The electronic vacuum pump and fuse has been replaced by the dealership previously. The unexpected brake failure caused me to roll farther than I wanted and hit the rock on my passenger side, rear door, causing minor body damage. Ford Customer Service said Customer Satisfaction Program 15N05 is a one time replacement and this vehicle is no longer eligible for the program since it has already been serviced. Additionally, they said any repair associated with this event is limited to 15N05 so body damage would not ne covered.

Over a couple years had several occasions where the air bag light came on. First time was in 2017 and several times through 2021. See repair reports. Sometimes the light went out on its own, sometimes the dealer couldn’t find anything and cleared the fault or just cleaned the contacts. Finally in August 2021 the light came on and stayed on and the dealer had to replace the Restraint Control Module. It was unclear if the air bag system was functional over these numerous faults and months. Very expensive repair.

The contact owns a 2012 Ford F-150. The contact stated that the brakes failed to function as needed at the initial start-up of the vehicle. After shifting to neutral(N) and waiting for a while, the brakes would function as needed. The contact stated that the previous owner had stated that the vehicle was included in a previous recall for the brake module. The vehicle had not been taken to the dealer by the contact nor had the vehicle been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 96,000.

Lug nut for wheel have swelled, unable to remove them with correct socket. Will need to replace all OEM lug nuts

Brake Failure: The brake Vacuum Boost pump is failing which causes a loss of power assist brakes. This is a massive safety issue and can cause serious accidents. Oddly Fors no longer manufactures the Bracket to be able to replace the pump and there is no aftermarket alternative. My Dealer tells me their notes from ford say obtains from aftermarket but I have scoured the internet and nobody makes the bracket. IT's a terrible design and a huge safety issue that should be recalled completely . Ford watts to charge over $900 to fix it but cant even get the parts as described above. Transmission Lead Rail: Recently had the Transmission Lead rail fail whcih casued sudden downshiting at highway speeds and the shift indicator to not illuinate. THis again is a massive safetey issue that Ford issued sevral TSB on but never recalled. This almost got me killed on thehighway a few times. They charged me over $1500 to replace the LEAD rail when again this defcetive design and craftsmenship that is a massive safetey issue and should be fully recalled. Engine Stutter: My truck has almost always stuttered anytime you wne tover hal throtle, There are sveral TSB on this but FORD has not stepped up and taken care o fht eissue via recall. Apprnetly moisture build up in the inercooler and gets sucked into the intake due to poor design. Timing Chain Stretch: I now have Timing chain stretch, this also seems ot be quite common due to poor design. Rear Door Failure: I can no longer open my rear half d

In 2019, my power steering assist fault/service advance trac came on as i lost power steering... It's recalled on my year and model, but not my vin. Replaced the rack and pinion for the electronic power assist steering (EPAS) in September of 2019. Last week, so April 18,'22, my steering started getting stiff and binding. Last night, April 25,22, my power steering failed completely again. Ford refused to acknowledge it was the exact issue last time and it's extremely scary driving without power steering, esp when you don't know if it's going to go out while driving! This is a known problem and has not been addressed, outside the select vins.

Vacuum pump is bad again. This was previously recalled. The part has failed now for the third time. Only once was I reimbursed due to recall, but it has since failed twice more. Currently at 98,000 miles.

My 2012 Ford F-150 has 98000 miles on it right now. Right about when it reached 90000 miles on it, it started having this loud rattling sound during startups, coming from the engine compartment. Everywhere I looked, it stated it was a “timing chain” issue. I took it to 2 separate Ford dealerships, each numerous times, and neither would fix the issue, apparently because the issue did happened at the dealership. Note, the truck was still on the warranty at the time. Now, 8000 miles later, the issue has gotten worse. The noise is getting louder and last for almost 3-5 seconds. I don’t know what to do. I don’t feel I have to put out of my pocket to fix this problem.

The contact owns a 2012 Ford F-150. The contact stated while driving 20 MPH, the transmission unexpectedly downshifted into first gear. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 137,000.

I began to hear timing chain rattle upon cold start up around 100000miles. I had the motor replaced at 122,000miles and both turbos per dealer and extended warranty recommendation. Now after strictly following oil change intervals over the last 28,000miles I am in the same boat. I have horrible chain rattle upon cold engine crank on a new motor.

My truck when driving will shift into 1st gear temporarily until the truck is turned off. Check engine light comes on with p0721 code.

The contact owns a 2012 Ford F-150. The contact stated that upon taking the vehicle to an independent mechanic to replace all four tires, he was informed that the lug nuts on all four wheels were fractured and swollen. The contact stated that the lug nuts were replaced. Additionally, the contact stated that the tachometer and the speedometer needle had detached. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure but did not provide any assistance. The failure mileage was approximately 100,000.

The contact owns a 2012 Ford F-150. The contact stated while her son was driving approximately 70 MPH, the vehicle inadvertently downshifted and the driver was able to pull over safely off the highway. There were several unknown warning lights illuminated. The vehicle was taken to a local dealer but was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.

The contact owns a 2012 Ford F-150. The contact received notification of NHTSA Campaign Number: 19V075000 (Power Train). The contact took the vehicle to local dealer to have the recall remedy completed. The contact stated while driving 75 MPH and depressing the accelerator pedal, the vehicle inadvertently decelerated. The contact stated no warning light was illuminated. The contact was able to park on the side of the roadway. The contact called a local dealer and made them aware of the failure. The vehicle was not drivable. The contact towed the vehicle to the local dealer, where it was diagnosed with needing the transmission to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 98,000.

The contact owns a 2012 Ford F-150. The contact stated that the subframe of the vehicle was severely corroded and had disintegrated due to the severe corrosion started developing in 2018. . The dealer informed the contact that the vehicle was unsafe to drive. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the VIN was not under recall. A case was opened. The failure mileage was approximately 100,000.

There was frost on the rear window. While the car was in park and warming up I turned on the rear defroster. I started to smell a burning smell. There was a loud bang and back left window panel completely shattered. No one was injured thankfully, but if the glass would have blown out and we had our baby or passengers in the back there could have been injury. I am not only concerned about the glass shattering, but the fact that there was a burning smell. I have found several forums where people report the same issue across many years of F150s (2010-2019). Defroster is turned on and the back window shatters. I contacted Ford and they will not do anything because the vehicle is out of the warranty period. Sounds like there is something faulty that they need to fix or issue a recall. I reached out to my insurance company and after I get a few quotes I may file a claim depending on the replacement cost and my deductible amount. Only other "symptom" was the smell of burning right before the glass shattered.

Transmission shifts from fourth gear to first gear by itself.

I was told at the dealership they would not do tire rotation because the lug nuts were swollen all 24 needed to be replaced. I have read this is a common problem. Looks like ford should do something about this problem.

On multiple occasions, driving at highways speeds, the vehicle with go from 6th gear to 1st or 3rd gear, causing a lock up of the tires skidding till the engine speed slows to match transmission gear. Both times there have been vehicle behind me and have had to swerve to avoid. The first time it happened in 2019/05 and a PCM recalibration was done at a dealership, and I was not aware that there was a recall available for this specific problem, replacing the lead frame in transmission. Now that its out of the recall date that was issued by ford, it is now showing the exact same issues, 2022/01/30. After every time it happens, a warning lamp has not signaled on, and no error code results. I've talk to multiple dealerships and ford customer relations, and will not issue the recall.

My truck has been experiencing sudden downshifting. I took it to the dealership in June of 2021 and mentioned the CSB 19N01, they said because there was no codes stored that were related to this problem they couldnt replace the leadframe,but said they would reprogram the PCM ,this did nothing .Yesterday my transmission slammed really hard and check engine light came on. Code P0501 (VSS vehicle speed sensor) Truck was built in 5/2012 which means it is still within the CSB guideline of 10 years 150000 miles. Just because the error code isnt the one that is on the checklist that they use to determine if it qualifies for the CSB doesnt mean the problem isnt there. I have about 3 months before my 10 year extension is up, This needs to be repaired asap. Thank you

My wife had the steering lock up on her tonight and made her pull into oncoming traffic, head on. She was able to stop the truck in the oncoming traffic lane, narrowly missing being hit head on. The steering gave her no warning, and just locked on her when she wad attempting to veer into a turn lane. The truck immediately jumped a curb divider,landing her into on coming traffic on one of the busiest streets in town. Quick thinking of switching on the hazards and praying, is all that kept her safe. The steering on this 2012 Ford F150 ecoboost has become increasingly worse over the last 3 weeks. Started with the advance track light going off every time we turned left, and has now escalated to this...almost killing my wife. I know now, after doing extensive research that this is actually fairly common in these trucks. 2011-2014 seem to be the problem trucks. A Bulletin was finally made for the 2011 models. I think it's safe to say that the 2012, 2013 and 2014s should also be put on that list. There are countless people having a steering rack issue with these trucks. And when this issue comes to a head, it's usually when you are driving, and lose all control, because of the electronic steering mechanism.

Smacked a gard rail on the front, spun around and smacked the driver rear end no air bags deployed. 55 miles per hour

I turned on the rear defrost and my rear window exploded on the passenger side.

I have a 2012 F-150 that has a recall under 16N02, it has happened more and more frequently where the transmission will die and go into a sort of "limp mode" and will not shift out of first gear. Will show a wrench and engine codes on the instrument cluster. I have now taken it into my local ford dealership where they said they cannot find any codes nor will they fix the said recall unless the transmission actually fails. I talked to a service tech and manager and they both told me that there was nothing they can do and of course my warranty and recall warranty ends December 31st. They told me at first on the phone that they wouldn't cover it anyways for the simple fact that they couldn't get me in till February and my warranty would be over by that point. I made a big enough fuss and they allowed me to bring it today only to be told there was nothing they could do and I was told to leave with my truck. I find this very hard to believe and am at a loss of words.

Driver's side stationary rear window (three window w/slider) shattered while driving.

Ford is aware these trucks have a problem with their transmissions and are making repairs extremely difficult for me. I am very lucky not to have been in an accident in this truck as it will get stuck in gear when turning out into a busy highway because of their transmissions sensor and lead frame issues. The government has addressed this issue to some degree, but Ford has already once refused the repair because they couldn't replicate the problem. I almost got into a severe accident last week because of the problem they know the trucks have. These trucks should be fixed correctly and people on the road shouldn't have to worry about getting people severely injured or killed over a problem with their 6r80 transmissions that should have been fixed. Please do what you can to help Ford do the right thing and get these repaired quickly.

Wrench light comes on and down shifts without warning. Very scary when on the highway at 70mph

Goodyear wrangler kevlar LT 275/65R18 Bought 4 from Sullivan tire in bridgewater ma in 2019. Has normal average treadwear. Noticed my drivers side front tire kept losing air didn't notice any nails so i removed for inspection and noticed the inside sidewall peeling apart. I took pictures and took it into Sullivan where they tried to say it was my fault due to tire shine. Im still dealing with sullivan I wanted to report because this can kill somebody.

Electronic Power Assist System failure while driving down the road. It became very difficult to operate the vehicle. If anyone but myself were operating the truck it would have resulted in an accident.

The contact owns a 2012 Ford F-150. The contact stated that while his son was driving 30 MPH, the vehicle downshifted independently. The contact stated that the power train warning light was illuminated. The contact was able to park on the side of the road and restart the vehicle however, the vehicle continued to experience failure. The vehicle was taken to the local dealer and the dealer was made aware of the failure. The vehicle was not diagnosed or repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 16V248000 (Power Train) however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 105,000.

The contact owns a 2012 Ford F-150. The contact’s husband stated while driving approximately 60 MPH, the vehicle unexpectedly downshifted from 6th to 3rd gear. The contact stated that the power train warning light was illuminated. The vehicle was towed to a local dealer and diagnosed with needing the Powertrain Control Module (PCM) replaced. The vehicle was not repaired. The manufacturer was informed of the failure and informed the contact that they were unable to assist. The failure mileage was approximately 156,543.

The contact owns a 2012 Ford F-150. The contact stated while using the defroster, the rear windshield shattered. The contact stated no warning light was illuminated. The contact took the vehicle to a glass repair shop and was informed that the rear windshield needed to be replaced. The contact called and notified the local dealer of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 91,000.

Throttle body - Truck stalls, reduced power

On Friday, October 29, 2021, at about 6:30 PM, I was driving my 2012 Ford F150 Super Crew 4WD Platinum PU down a two lane highway at about 60 MPH, when I heard a distinct, loud "pop" or "bang", so loud it scared me. I initially thought I had been shot at or a decent sized rock had struck the roof of my PU with some good velocity. After the initial shock, I didn't notice anything being different. It was dark outside. After a few moments, I had no idea what had happened, but moved on. The next morning, I got in my truck and immediately noticed the passenger side of the back window was shattered. I inspected the window and clearly saw a heat signature deformation in the lower left corner of the right pane. This was also the initial spot of the shattering.The rear window defroster system had shorted out and burned up. From Photo #4 I am not convinced there was not an actual fire at some point. I quickly found forums that document reports of Ford vehicles doing this for well over 10 years. I added my story to the top one. https://fordauthority.com/2017/12/another-ford-f-150-owner-claims-the-rear-window-shattered-despite-no-impact/ https://www.f150forum.com/f118/another-rear-window-shattered-426302/ I went to the Ford dealership and had them look at it. I also had the local Sheriff's Office look at it. I chatted, emailed and called Ford HQ twice. I sent them these links. I was repeatedly told, "I'm sorry. There are no programs (Recalls or TSBs) to help you." My glass repair place d

The contact owns a 2012 Ford F-150. The contact stated that he received a notification for NHTSA Campaign Number: 19V075000 (Power Train) and had the software reprogrammed. Upon return of the vehicle, the contact stated that the vehicle inadvertently downshifted while driving at various speeds. The service engine warning light was illuminated on the instrument panel. The dealer and the manufacturer had been notified of the failure and informed him that the parts to repair the vehicle were on backorder. The contact stated that due to the parts not being available, the failure had worsened. The vehicle had yet to be repaired. The failure mileage was approximately 99,000

1. Speed sensor failed 2. When driving, speedometer stops working and the truck slows down all of a sudden which could cause someone to rear end me. 3. Yes the problem has been reproduced and confirmed by independent service dealer 4. No the vehicle has not been inspected by anyone other than the independent service dealer 5. No warning lamps,etc prior to the failure