2012 Ford F-150 complaints

The contact owns a 2012 Ford F-150. The contact stated that while driving at various speeds, the transmission downshifted to first gear causing the vehicle to abruptly decelerate. After restarting the vehicle, the failure was corrected. The contact stated that the failure progressed, and the transmission would no longer shift gear as needed. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The contact was informed that the VIN was not included in NHTSA Campaign Number: 19V075000 (Power Train). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 50,000.

The contact owns a 2012 Ford F-150. The contact stated while driving 45 MPH, the vehicle downshifted into first gear. The contact stated that the wrench warning light was illuminated, and the speedometer and other gauges malfunctioned. The contact turned off and restarted the vehicle however, the failure persisted. The contact drove the vehicle to the residence and contacted the dealer however, no assistance was provided. The vehicle was not included in NHTSA Campaign Number: 19V075000 (Power Train). The manufacturer was not made aware of the failure. The failure mileage was approximately 199,000.

The contact owns a 2012 Ford F-150. The contact received notification of NHTSA Campaign Number: 19V075000 (Power Train). The vehicle was taken to a local dealer and the recall was serviced. The contact stated that while driving at 70 MPH, the vehicle unexpectedly downshifted without warning. The contact pulled over as certain parts of the instrument panel had gone blank. The contact restarted the vehicle and the vehicle resumed normal operation. The contact called a dealer and made an appointment to have the vehicle serviced; however, once the vehicle arrived at the dealer, the contact was informed that the vehicle could not be serviced for several weeks. The manufacturer was notified of the failure. The vehicle remained in the possession of the dealer. The failure mileage was approximately 172,000.

The contact owns a 2012 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle suddenly downshifted and lost motive power. The contact was able to pull to the shoulder of the roadway, where the failure persisted. The transmission warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V075000 (Power Train), but the VIN was not included. The manufacturer was notified of the failure but did not assist. The failure mileage was 200,000.

The contact owns a 2012 Ford F-150. The contact initially stated that while driving at low rates of speed, the vehicle would unexpectedly downshift without warning. The contact then stated that while driving at highway speeds, the vehicle downshifted as the indicator warning light appeared on the instrument panel. Soon after the failure, the instrument panel went blank. Upon restart of the vehicle, the vehicle resumed normal operation; however, the failure persisted as the contact stated that the failure would occur more frequently. The contact stated that the check engine warning light had appeared on the instrument panel. Upon investigation, the contact discovered NHTSA Campaign Number: 19V075000 (Power Train) which was linked to the failure. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000.

Highway traveling, transmission dropped into lowest gear from 65mph. no injury of myself or others in the vehicle. no accident occurred as result. I have not taken the issue up with the manufacturer or scheduled inspection. no other representatives police, insurance were contacted. no warning lights on dash when this happened two separate times since owning the vehicle in 2021.

Transmission down shifted to 1st gear at a high rate of speed.

Summary VIN [XXX] Airbag light continues to come on after beinig serviced multiple times by the dealer. 1)1-4-18 the airbag light turned on. The dealer completed $1,180.82 in repairs replacing the RCM. 2)11-6-18, a second issue occurred with the air bag light. Cost was $943.46 to replace the seat belt tensioner 3)11-12-18 CAS 16338506. On 11/23/18 the case was still under review. On 12/14/18 I was told the case was closed with no action taken. Escalated case CAS [XXX]was created. 4)4-30-19 – same issue as #2. 5)2-11-20 RCM replaced again. As the repair was 1 month out of warranty I paid $106.52 after negotiations with Ford Service Representative. 6)3-23-20 $635.88 (less ~ $200 for battery) Told by dealer a loose pin at a connector was the cause. 7)1-2-2021 Air bag light on again. (letter #5) 8)10-24-21 B1211 restraint control module code 9)11-16-22 B11D8 restraint control module code 10)1-28-23 B1211 restraint control module code 11) 11-27-2023 Codes B1211 and B0091 (Attached Airbag light on) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2012 Ford F-150. The contact stated that while driving at approximately 70 MPH, the vehicle unintendedly downshifted to first gear. The wrench symbol was illuminated on the instrument panel. The vehicle was taken to the local dealer, where it was diagnosed, and the mechanic retrieved DTC code: P0500. The mechanic related the failure to a wheel speed sensor failure. The vehicle was not repaired. The manufacturer was contacted and referred to the NHTSA Hotline. The failure mileage was approximately 161,000. The VIN was not available.

The contact owns a 2012 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The contact was able to drive to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 17,362.

Attempted to merge onto a highway and car stayed in first and not allowing for proper acceleration. Ended up not being included under a current recall. Replace the lead frame connector in the transmission.

Cylinder 2 had a stored code for misfire and oil and coolant mixture leaking from block. With the F150 raised up on the lift I removed the lower splash shields and continued inspection. Oil was found predominantly on passenger side with a mixture of oil and coolant leaking out drivers side. Using my lab scope I was able to locate the damage in the block. A large crack split down in a Y pattern. This split is located on cylinder #2 location. I would say #2 connecting rod has impacted block due to internal failure.

The contact owns a 2012 Ford F-150. The contact stated that the vehicle was taken to a dealer where it was being serviced for an oil change. The contact stated that the dealer observed condensation in the coolant reservoir and diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 158,000.

The contact owns a 2012 Ford F-150. The contact stated that after starting the engine, a rattling noise was present coming from the engine compartment and the vehicle would not properly accelerate. The vehicle was taken to the local mechanic who diagnosed that the engine cam phasers and engine timing system needed to be replaced. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure but no assistance was offered. The failure mileage was 150,000.

On a cold start, my truck will not go into first gear until the rpm’s get from 1500-2000 and then it slams into first gear. Other times it won’t have barely any power and will accelerate so slowly that I’ve nearly missed getting in an accident more than a few times. Also, it will slam down into lower gears when down shifting. All of the problems listed above will cause my truck to violently shake to where it feels like I got hit.

Back-up camera works sometimes then goes blank

While driving down the highway, a wrench appeared on the display, then the speedometer went down to zero and the truck wasn’t shifting or accelerating. I took it to the Ford dealership and the diagnosed it as an issue with the Leadframe sensor assembly. They also let me know this is a known issue and there was an extended warranty program that my vehicle is over mileage for. The repair cost estimate was $800 for parts/labor. They also stated that the part is on back order and may be a month before they could get it. When I asked about driving with the issue they said it won’t do damage to my transmission but may intermittently cause shifting issues and could result in loss of reverse. I don’t feel comfortable driving it like that but it is my only vehicle. I also contact Ford customer care directly but there was nothing they could do to assist and pointed me here.

My 2012 Ford F150 XLT truck goes from 6th gear going down highway 60 to 65mph and then it goes to 1st gear Intermittent... Safety wise very unsafe for my family and others....Problem was reproduced and confirmed by shop....Ford could not get part or help and they know about the problem.....Leed frame defective on transmission....

Unexpected downshift into first gear that caused the vehicle to slow down suddenly without warning and the rear tires slide and locked which could have caused me to crash

The contact owns a 2012 Ford F-150. The contact stated while driving 60 MPH, the vehicle unintendedly downshifted to first gear and the vehicle slowed to 20 MPH. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the wheel speed sensor had malfunctioned. The contact stated that there was a Customer Satisfaction Program and an Extended Warranty coverage for the failure; however, the VIN was not included. Additionally, the vehicle had exceeded the mileage limitation. The manufacturer was made aware of the failure. The approximate failure mileage was 149,960.

The contact owns a 2012 Ford F-150. The contact stated while driving approximately 70–75 MPH, the transmission downshifted into first gear. The vehicle became uncontrollable. The contact was able to swerve to avoid a crash. The contact pulled over and restarted the vehicle. The contact stated while driving at an undisclosed speed, the vehicle continued to downshift without warning. The vehicle was taken to an unknown local dealer but was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The contact stated that the failure was like NHTSA Campaign Number: 19V075000 (Power Train). The failure mileage was approximately 87,000.

The contact owns a 2012 Ford F-150. The contact stated while driving 45 MPH, the vehicle unintendedly downshifted. As a result of the failure, the vehicle briefly lost motive power before returning to normal functionality. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V075000 (Power Train) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 160,000.

The contact owns a 2012 Ford F-150. The contact while driving at an undisclosed speed and making a left turn, the steering wheel became firm. The "Power Steering Assist Failure" message was displayed. The contact pulled over and turned off and restarted the vehicle several times while driving to the residence. The vehicle was taken to an independent mechanic and the contact was informed that the vehicle had experienced the failure listed in NHTSA Campaign Number: 14V316000 (Steering). The contact was referred to the dealer for assistance. The dealer was not contacted. The vehicle was not repaired. The manufacturer was contacted that stated there was no recall on the VIN related to the failure. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 228,000.

Transmission downshifts during normal driving conditions on highway. There is a recall for this defect. Recall #1901(transmission). Called Ford on 9.6.23 and spoke to employee #219738 and Ford refused to correct known defects.

I was driving at approximately 30 mph when the transmission's OSS (Output Speed sensor) suddenly malfunctioned, causing an unexpected downshift into first gear. This abrupt shift led to a loss of control, resulting in a harrowing collision with a tree. What I witnessed next is etched into my memory forever: a scene of blood, fluorescent white bone fragments, and shattered glass strewn all around. Bones were even protruding through my skin at various locations, including my wrists, forearms, legs, and ankles, not to mention the dislocated shoulders. Thankfully, there were no other individuals present at the scene; otherwise, the outcome could have been equally disastrous, if not fatal, for them. Astonishingly, there were no discernible warning signs such as unusual sounds or dashboard warning lights prior to this incident. Following the accident, my pickup truck was towed to Cedar Park Wrecker, only to be swiftly claimed by the insurance company and subsequently sent to auction within a matter of days.

The contact owns a 2012 Ford F-150. The contact stated that while driving at 20 MPH, the vehicle collided head-on with another vehicle that failed to stop at a red light. The air bags did not deploy. A police report was filed, and injuries were reported. The contact stated that he had suffered minor injuries to his jaw but had not sought medical attention. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 320,000.

Truck has jumped time and or timing chain stretched will driving truck geared down and was like it went into limp mode I turn the truck off and back on it straightened out enough to get it home dealer said it was the timing chain after running scans on it

Electric assisted steering locks up traveling or parked. While traveling really have to strain muscles keeping in lane of travel, when steering turns it turns to far and I am trying to correct steering over corrects back in opposite direction. Cannot keep pickup in lane of travel.

Whilst driving, suddenly power steering assist fault light flashed on and steering became very difficult to turn. Was able to safely pull off the road. After several attempts, the fault cleared and steering was fully functional again. Had I been on interstate it most likely would have caused accident.

The contact owns a 2012 Ford F-150. The contact received notification of NHTSA Campaign Number: 19V075000 (Power Train) however, the dealer advised the contact that the vehicle mileage of 136,000 had exceeded the mileage limit for the software update to the transmission, which might cause severe damages if the update was performed. The contact stated that the dealer refused to perform the software update. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2012 Ford F-150. The contact stated while driving 30 MPH and depressing the accelerator pedal, the vehicle failed to respond and went into LIMP Mode. The check engine warning light was illuminated. The contact veered to the side of the road. The contact turned off and restarted the vehicle several times; however, the failure persisted. The contact stated that the vehicle failed to exceed 30 MPH. The contact was able to drive to the residence. The vehicle was taken to the dealer, where it was diagnosed that the timing chain had failed. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 145,000.

The contact owns a 2012 Ford F-150. The contact stated while driving 40 MPH, the vehicle inadvertently downshifted and was unable to upshift above 3rd gear. The contact was able to pull over to the shoulder of the roadway. After turning off and restarting the vehicle, the vehicle seemed to return to normal functionality; however, the failure had since become a regular failure. The check engine warning light was illuminated. The vehicle was taken to the dealer but was not diagnosed due to aftermarket parts being installed. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 19V075000 (Power Train) but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 148,000.

The contact owns a 2012 Ford F-150. The contact stated while driving 30 MPH, the vehicle downshifted from 4th gear to 1st gear. The power train warning light and the check engine warning light were illuminated. The contact veered to the side of the road. The contact turned off and restarted the vehicle; however, the check engine warning light remained illuminated. The contact turned on the hazard lights and continued driving 10 MPH. The contact parked the vehicle at the residence. The vehicle was taken to an independent mechanic, where it was diagnosed that the failure was related to the transmission. The contact stated that the PCM was reprogrammed in 2021 under NHTSA Campaign Number: 19V075000 (Power Train) however, the repair failed to fix the vehicle. The dealer was notified of the failure and informed the contact that recall repairs were a onetime free repair. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The failure mileage was unknown.

The contact owns a 2012 Ford F-150. The contact stated that while driving approximately 65 MPH, the vehicle unintendedly downshifted from 6th to 1st gear. The contact shifted the vehicle into neutral and coasted to the side of the roadway. The vehicle was turned off and restarted and regained proper function. The contact stated that the turn signal was also blinking abnormally. Additionally, the speedometer failed while making a left turn at slow speeds. The vehicle was restarted to remedy the failure. The contact also stated that the check engine warning light was illuminated. The contact took the vehicle to a certified mechanic and was informed that the vehicle had been producing incorrect DTC codes. The vehicle was diagnosed, and it was determined that the molded leadframe had failed and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 138,000.

Service Advance Trac warning light comes on when backing while steering wheel turned. Multiple instances. Clears after a few minutes, but researching issue seems to be widespread across the Ford community, and has resulted in steering locking up while vehicle is in motion. Scheduled for maintenance visit to local dealership to diagnose. Codes read were C1963 & U0428

The contact owns a 2012 Ford F150. The contact stated while driving 60 MPH, the vehicle downshifted, and the powertrain malfunction warning light illuminated. The contact stated that several minutes later the vehicle started operating normally. The vehicle was taken to the dealer and the transmission control module was reprogramed; however, the failure reoccurred. The vehicle was taken to the dealer, but the vehicle was not diagnosed. The dealer stated that the VIN was not under recall. The vehicle was not repaired. The manufacturer was contacted but provided no assistance. The contact was referred to the NHTSA Hotline. The failure mileage was 177,000.

Today, My 2012 Ford F150 would crank, but would never start. The vehicle had gas and no issues with the battery. When this occurred today, I found out online that the 2009-2014 Ford F150s have a common issue associated with Fuse 27. In 2015, Ford issued a Technical Service Bulletin (TSB 15-0137) related to this issue, but according to Ford’s Customer Service I was never informed of this TSB because it did not include my truck’s VIN number. None the less it appears to be the same issue as noted in that TSB. After the truck wouldn’t start today, I inspected the Engine Compartment Fuse box. It appears the Fuse 27 which provides power to the Fuel Pump has a commonly known issue of burning up. For my instance today this did appear to be the problem. Fuse 27 was completely burned up on the side of the fuse closest to the engine. Fortunately, I was parked in this instance and my safety or the safety of others was not put at risk, but my big concern is if the fuse were to go out while driving down the road or highway. The sudden loss of fuel due to this common electrical issue could have greatly put my safety and the safety of others at risk. The only warning message that I noticed prior to this issue was a battery warning, but when the vehicle was taken by an auto parts store to pull the code and check the battery, there was not issue with the battery. Note: The battery was replace 5 months ago. I believe this common issue that I and other Ford F150 owners have experience should be

Turbo booster are causing the wastegate to be stuck in the open position and then causing the gas pedal to accelerate on its own.

The gasses inside the gas tank are building up and causing a farting noise.

Vehicle started to downshift while driving at highway speeds a few months ago. Also a loss of power and acceleration with instrument failure. Later learned this was a common problem with the 11-13 f-150s that Ford knows about. They did give everyone a 10 year, 150k warranty but my truck is just barely out being a 12 with 151k miles. I took it to dealer where it cost me around a $1000 to fix. Was told by service manager there were many more people with the same issue. The transmission leadframe assembly was bad in thousands of trucks. There is a back order of over 12000 of these parts I was told. I think there should be a recall on all of these transmissions and be fixed by Ford. Also, refunds for those of us who already paid out of pocket. Thank you for your attention in this matter.

Vehicle died when driving (and has continued to die when driving). Seems to sputter as if downshifting and then totally stalls out, causing safety concern when driving in traffic and randomly dying. Luckily had somewhere to pull off of the road and not cause an accident. Have confirmed with auto repair shop that the main concern is the powertrain control module. Shop has been able to replicate this happening as they have driven it as well. No warning lamps/lights/etc present prior to this happening.

The contact owns a 2012 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. The restraint warning light was illuminated. The vehicle was towed to an independent mechanic, who informed the contact that the steering gear assembly needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 209,000.

Driving on freeway and truck downshifted and almost control, orange wrench was on display, speedometer stopped working and I could barley get to 30 mph...finally was able to pull off freeway...turned -off...waited and turned back on...engine light was on...it drove alright for alittle bit, than it downshifted to first and would shift had to pull over and shut it down again and restart...made it home...next day took to AUTO ZONE...Code reads P0720 OSS SENSOR FAULT...Ford had a SAFETY RECALL19S07 for trucks 2011-2013 ...I did not receive any letter for that or the Customer Satisfaction Program 19N01...same issue and cannot drive my truck, it is unsafe...had to drop-off at FORD Dealership to repair and update software on transmission...it should be repaired at no charge, having to pay for Rental.

The contact owns a 2012 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission warning light illuminated, and the transmission inadvertently downshifted. Additionally, the vehicle would not accelerate above 30 MPH while driving. The contact restarted the vehicle to correct the failure; however, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who diagnosed that the output speed sensor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 136,000. The contact wants to reimbursed for the cost of the repairs.

The contact owns a 2012 Ford F-150. The contact stated while driving 60 MPH, the vehicle lost electronic functions. The vehicle then shifted abnormally before downshifting into first gear, causing the vehicle to come to a sudden stop. The contact stated that he was able to maneuver the vehicle to the shoulder of the roadway before the vehicle went into LIMP Mode. After restarting the vehicle, the electronic functionality returned. The vehicle was taken to the dealer, who diagnosed a failure with the powertrain control module. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 16V248000 (Power Train). The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 127,000.

The problem with this vehicle is the body control module has gone out. It controls everything from the safety functions to back up cameras and engine function and starting. My truck first, lost its back up camera within the first year of purchase, then the driver side, turn signals, stopped working, the battery drains overnight, and the latest issue is that the truck will turn off while driving down the road. Three months ago, the engine cut off and all systems locked up while I was driving 45 mph in town. There are no issues with any other system in the truck. Mechanics have tested everything and state. It is only the body control module. I am unable to purchase a body control module from Ford and my mechanic, the Ford mechanics, the Ford distributor for this region, nor Carmax, where I bought the car can get the part because Ford says that all of their shelf held parts for this vehicle type are defective. They state is a known issue and there is no date for resolution at all. The date on the shelf hold is zero month zero day zero year meaning no date. The body control module in this series of Ford F1 50s is a “known issue” to Ford. Due to their semi conductor manufacturer contract that has lapsed for this older technology, they state that the 4000 vehicle’s that currently require this part are not they’re greatest concern. They stated that there is an indefinite “shelf hold” on this part due to their only being less than 50 of them available for anyone to purchase. Those pa

The contact owns a 2012 Ford F-150. The contact stated that on several occasions while driving at approximately 70 MPH, the vehicle unexpectedly downshifted to third gear. The contact also stated that while driving at various speeds, the vehicle downshifted to first gear with the service vehicle warning light illuminated and DTC code: P0720 (Powertrain Control Module) was illuminated on the instrument panel. The contact veered to the side of the road. The contact stated that after several attempts, she was able to restart the vehicle. The vehicle was taken to the dealer where the contact was informed that the vehicle had exceeded the timeframe for Customer Satisfaction Program: 19B05,19S19, 19S07. The contact was advised to call the manufacturer for assistance. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 167,000.

The contact owns a 2012 Ford F-150. The contact stated while driving 65 MPH, the vehicle lost power steering functionality with the traction control warning light illuminated. Due to the failure, the vehicle was towed to an independent mechanic where it was discovered that the power steering angle sensors were defective, and the rack and pinion needed to be replaced. An unknown dealer was notified of the failure and the contact was informed that there were no recalls on the VIN. The manufacturer was not notified of the failure. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 141,000.

The contact owns a 2012 Ford F-150. The contact stated that while driving at various speeds on several occasions, the transmission down shifted inadvertently, and the tires locked up and the vehicle skidded. The contact veered over to the side of the roadway and turned off and restarted the vehicle. Additionally, the contact stated that when the brake pedal was depressed, the brake lights failed to illuminate as designed. The wrench warning light was illuminated. The vehicle was turned off and restarted and the wrench light disappeared. The contact stated that after driving for a few miles, the transmission downshifted, and the wheels locked up. The vehicle was taken to an independent mechanic to be diagnosed and it was determined that the transmission range sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000. The consumer stated the failure mileage is incorrect, it was 142,000.

Automatic transmission dropped out of gear while driving on the Interstate going around 60-65mph today. The wheels locked up and the vehicle just reved like it was in neutral. From other Ford owners (Unintended downshift into first gear can cause an abrupt wheel speed reduction, which could cause the rear tires to slide until the vehicle slows down. This condition could result in a loss of vehicle control, increasing the risk of a crash) My truck shows no mileage and the airbag light is on.No inspection has been performed as of today. Recall # 19507