2008 Ford F-150 complaints

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 182,000.

TRAVELLING APPROX 60 MPH ON AN INTERSTATE. THE SPARK PLUG POPPED OUT WITH A LARGE POP.

R R LEAF SPRING BROKEN. VEHICLE HAS NEVER BEEN ABUSED OR DRIVEN ROUGH. I FIRET NOTICED IT WHEN I WOULD HIT A BUMP IN THE ROAD, SOUNDED LIKE SPARE TIRE RACK WAS LOOSE. AFTER LOOKING ON THE INTERNET I FOUND THAT THERE WERE OTHERS THAT HAVE EXPERIENCED THE SAME PROBLEM. THE CENTER LEAF OF THE THREE SPRINGS BREAK GENERALLY IN THE MIDDLE OF THE LEAF.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE MAKING A LEFT TURN, ANOTHER VEHICLE FAILED TO YIELD FOR A RED LIGHT AND CRASHED INTO THE FRONT DRIVER SIDE OF THE CONTACT'S VEHICLE. THE FRONTAL AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE AMBULANCE TOOK THE CONTACT TO THE HOSPITAL WITH A CONTUSION AND BRUISES TO THE LEGS, LEFT ARM, ABDOMEN, AND NECK. THE VEHICLE WAS TOWED TO AN UNKNOWN LOCATION AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,855.

MAP LIGHTS AND DOME LIGHT STAY ON WHILE DRIVING. VERY DANGEROUS DRIVING AT NIGHT. AFTER PARKING 15 MIN LATER THE LIGHT WILL GO OUT. BUT AS SOON AS YOU OPEN THE DOORS THE LIGHT WILL STAY ON, DAY OR NIGHT.

BROKE 4 SPARK PLUGS IN BLOCK TRYING TO REPLACE

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING AT APPROXIMATELY 45 MPH, THERE WAS AN ABNORMALLY LOUD NOISE AND THE VEHICLE STALLED. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION COMPUTER FAILED. THE PART TO DO THE REPAIR WAS ORDERED; HOWEVER, WHEN THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, THE CONTACT WAS INFORMED THAT THE PART WAS RECALLED FOR TESTING PURPOSES AND UNAVAILABLE FOR AN UNKNOWN TIMEFRAME. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

STEERING IS HEAVY AND BINDS, ESPECIALLY DURING CORNERING AND BRAKING. FEELS LIKE POWER STEERING IS FAILING AND TRUCK IS DIFFICULT TO STEER, CONTROL AND MANEUVER AT ALL SPEEDS AND DIRECTIONS. STEERING SHAFTS AND JOINTS ARE COMPLETELY RUSTED AND SEIZING AND WILL NOT RELEASE WITH LUBRICANT. POWER STEERING FLUID AND LINES ARE FINE AND DEALER STATES THAT STEERING SHAFTS AND JOINTS MUST BE REPLACED. I WAS TRAILERING A BOAT AT 50 MPH AND STEERING WAS SEIZING, VERY HEAVY, AND SEEMED TO BE BINDING WHILE GOING AROUND BENDS IN THE ROAD AND THEN THE STEERING WOULD SUDDENLY RELEASE - OR UNSTICK - AND BECOME RESPONSIVE AGAIN. I CROSSED THE CENTER LINE AS THE STEERING SUDDENLY GOT VERY HEAVY, SLUGGISH AND UNRESPONSIVE, AND THEN RELEASED AND BECAME RESPONSIVE AGAIN. I ALMOST DROVE DIRECTLY INTO ONCOMING TRAFFIC. THIS STEERING ISSUE IS NOW A CONSTANT AND HAPPENS WHILE DRIVING OR TOWING, AT ALL SPEEDS, AND IN BOTH FORWARD AND REVERSE. THIS STEERING PROBLEM IS EXTREMELY UNPREDICTABLE, UNSAFE, AND VERY DANGEROUS. IT ALSO SEEMS TO BE COMMON PROBLEM WITH NUMEROUS COMPLAINTS AND REPORTS OF THIS ISSUE BEING REPORTED TO THE NHTSA, FORD, FORD DEALERS, AND DISCUSSED IN ONLINE FORUMS.

WHILE MAKING LEFT OR RIGHT TURNS THE STEERING GETS HARD TO STEER THEN IT LOOSENS UP MAKING IT OVER STEER. I BELIEVE IT IS IN THE STEERING SHAFT U-JOINT BECAUSE IT IS ALL RUSTED.

SITTING IN MY TRUCK WITH THE KEY TURNED OR EVEN ON IDLE, THE ELECTRONICS ON MY DASH(RADIO ALLUMINATION, TRIP BOX, ETC.) WILL BE FADED ON ONE SIDE OR WILL BE COMPLETELY FADED AND I CANT SEE THE TIME, STATION, GAS MILEAGE, ETC. FROM TIME TO TIME WHEN IT DOES THIS, MY CRUISE CONTROL FIGURE WONT SHOW BUT AFTER A WHILE(10-30 MINUTES) IT WILL POP UP ON THE CLUSTER. IT DOESNT MATTER IF ITS COLD OUT OR HOT OUT, IDLE,RUNNING OR IGNITION SWITCHED OFF, IT WILL BE FADED. ITS BECOMING MORE OF A COMMON THING(DAILY).

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE JERKED FORWARD WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE ENGINE TEMPERATURE GAUGE REACHED HIGH LEVELS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE THE TECHNICIAN STATED THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE DRIVER SIDE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000.

AIRBAG STAYS ON ALL THE TIME DO NOT MATTER WHAT YOU DO IT HAS A CODE OF 1869

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SHIFTING CABLE BURNED THROUGH OR FRACTURED DUE TO THE CABLE RESTING ON THE EXHAUST MANIFOLD. THE DEALER REPLACED THE TRANSMISSION SHIFTING CABLE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 64,172. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE SHIFTING CABLE HAD BURNT THRU OR FRACTURED DUE TO THE CABLE RESTING ON THE EXHAUST MANIFOLD AND CORROSION. THE DEALER REPLACED THE TRANSMISSION SHIFTING CABLE AND REPAIRED THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 64,172.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO STOP. AS A RESULT, THE CONTACT CRASHED INTO THE REAR OF ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. EIGHTEEN MONTHS LATER, WHILE REVERSING AT 10 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO STOP. AS A RESULT, THE CONTACT CRASHED INTO THE DRIVER SIDE OF ANOTHER VEHICLE AND THE REAR OF A SECOND VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND NO INJURIES WERE SUSTAINED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 90,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WATER LEAKED INTO THE THIRD BRAKE LIGHT AND ONTO THE REAR SEATS OF THE VEHICLE. AS A RESULT, THE CONTACT STATED THAT THE LOWER REAR CAB CORNERS BECAME RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

TIRE TREAD SEPARATION ON FRONT DRIVE SIDE TIRE. I WAS ABLE TO CATCH IN TIME AND HAD TIRE REPLACED BUT WOULD LIKE COMPANY TO REIMBURSE ME BECAUSE THIS BRAND OF TIRE WAS RECALLED LAST YEAR FOR THE SAME REASON BUT DID NOT INCLUDE THE P265/70R17. THE BRAND OF TIRE IS CAPITAL PRECISION TRAC II, THE TIRE SHOP THAT REPLACE THE TIRE TOLD ME I WAS LUCKY THAT IT DID NOT BLOW ON THE HIGHWAY. *TR

TL*THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, AN ABNORMAL NOISE EMITTED FROM THE ENGINE. THE VEHICLE WAS TAKEN TO A DEALER MECHANIC, WHO DIAGNOSED THAT THE TIMING CHAIN, TIMING CHAIN SLIDE, TIMING CHAIN TENSIONER AND CAM PHASERS NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT UPON REMOVING THE KEY AND RE-ENTERING THE KEY TO START THE VEHICLE, THE IGNITION SWITCH CYLINDER FRACTURED. THE CONTACT MADE SEVERAL ATTEMPTS AND WAS ABLE TO MANEUVER THE SWITCH BACK INTO PLACE, BUT IT WAS NOT SECURELY CONNECTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR FURTHER INSPECTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. UPDATED 4/7/15*CN UPDATED 04/14/15

REAR END DOES A SKIDDING WHEN COMING FROM A COMPLETE STOP TO MOVING. LOOKS AS THOUGH THE BRAKES ARE NOT RELEASING LIKE THEY SHOULD, BUT SOUNDS LIKE THERE IS GRINDING FROM THE REAR DIFFERENTIAL. WHEN CALLING AUTO PART STORES ABOUT GETTING A REPLACEMENT, THEY HAVE ALL ADVISED THAT THIS YEARS (2008) FORD F-150S ALL HAVE THIS SAME PROBLEM. ALL STORES SAY IT IS THE DIFFERENTIAL CLUTCH PACKS IN THESE 2008 FORD F-150S BUT FORD WILL NOT TAKE RESPONSIBILITY OF THE MALFUNCTION OF THIS PART. *TR

WHEN I WAS MAKING A LEFT TURN OFF A HIGHWAY RAMP, THE STEERING WHEEL LOCKED UP & THEN SNAPPED BACK & SPRAINED MY WRIST. I DON'T CARE ABOUT MY WRIST,BUT I DO CARE ABOUT THE DEFECTIVE LOWER STEERING SHAFT THAT WAS ENGINEERED WRONG TO START WITH & YOU MADE FORD ISSUE A RECALL (BECAUSE OF THE DEFECT)IN ALL THERE MID SIZED & HIGHEND CARS ALONG WITH LINCOLN & MERCURY MODELS BECAUSE IT'S A MAJOR SAFETY PROBLEM. WHAT YOU DIDN'T DO IS, ORDER A RECALL FOR ALL FORDS THAT HAS THE SAME LOWER STEERING SHAFT! WHY? YOU SAY IT'S NOT A SAFETY PROBLEM IN THE F-150, WHY? JUST BECAUSE IT'S A TRUCK OR FORD PAID YOU OFF NOT TO ISSUE THE RECALL FOR THE F-150'S?? IF IT'S A DEFECTED PART IN THERE CARS,IT'S THE SAME PART PUT IN F-150'S,MADE BY THE SAME CO.. I PD $38,000 FOR A TRUCK THAT HAS THE SAME DEFECTED PART YOU MADE THEM ISSUE A RECALL. SOME LINCOLNS & MERCURY CARS RECALLED ARE HEAVIER THAN MY F-150,BUT THAT DOESN'T MATTER TO YOU. I ALMOST CRASHED THREW THE GUARD RAIL & IF I DID, I WOULD BE DEAD!! I WANT TO KNOW HOW YOUR AGENCY EXCLUDED THE F-150 IN THE RECALL?? ARE YOU PEOPLE ENGINEERS? HOW IN THE WORLD COULD YOU EXCLUDE ANY VEHICLE IN THE RECALL THAT HAS THE SAME DEFECTED PART IN IT? PLEASE E-MAIL ME THE REASON WHY A DEFECTED PART FORD MADE,IS ONLY A SAFETY ISSUE IN CARS, BUT NOT THE F-150"S THAT HAS THE SAME LOWER STEERING SHAFT'S. I REALLY WANT TO KNOW. THINK OF THIS, A MERCURY SABLE HAD THE SAME PROBLEM I HAD WHILE MAKING A LEFT TURN, THE MERCURY WOULD HIT THE GUARD RAIL & STOP, MY F-150 WOU

2008 FORD F150 TIRES, WITHIN THREE MONTHS AND 283 MILES ALL FOUR OF THE TIRES HAD TREAD SEPARATION AND WERE REPLACED. ..UPDATED 02/12/15*BF THE CONSUMER STATED THE TREAD SEPARATED ON THE REPLACEMENT TIRES, AS WELL. *JB

I WAS DRIVING MY 2008 FORD F150 WHEN THE ENGINE SUDDENLY STARTED SEVERE JERKING/MISSING AND LOSS OF POWER. IT CONTINUED TO GET WORSE WHILE VEHICLE WAS UNDER LOAD THEN EVENTUALLY THE ENGINE STOPPED WORKING AND WOULD NOT START. I WAS ABLE TO DETERMINE THE ISSUE WAS A LOSS OF FUEL PRESSURE CAUSED BY A DEFECTIVE FUEL PUMP DRIVER LOCATED ABOVE THE SPARE TIRE ON A STEEL CROSS MEMBER. THIS PART WAS SEVERELY CORRODED DUE TO AN ENGINEERING FLAW REPORTED BY HUNDREDS OF F150 OWNERS PRIOR TO THIS INCIDENT. THIS ISSUE NEEDS TO BE ADDRESSED BY NHTSA WITH FORD AND A RECALL INITIATED TO REPLACE THIS COMPONENT WITH THE IMPROVED PART DESIGN NOW AVAILABLE. *TR

TL*THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THERE WAS A STRONG ODOR OF FUEL EMITTING THROUGH THE VENTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000. ...UPDATED 03/31/15 *BF THE CONSUMER STATED THE MANUFACTURER REFUSED TO OFFER ANY ASSISTANCE DUE TO THE VEHICLE BEING OUT OF WARRANTY. UPDATED 10/21/2015*JS

FUEL PUMP DRIVER CORROSION CAUSE TRUCK TO STALL AND NOT RESTART LUCKY I WAS IN SAFE LOCATION OR COULD HAVE BEEN A BAD SCEAN FORD SHOULD RECALL THIS PART CAUSE IN STATES THAT USE SALT CAUSES THIS PROBLEM DOES SOMEONE HAVE TO DIE BEFORE IT GETS FIXED CAUSE NEW ONES HAVE A SPACERS SO THEY DON'T RUST IM SURE THIS HAS BEEN BROUGHT UP MANY TIMES THANK YOU *TR

ON SUNDAY 12/14/14 AT 7PM MY 2008 FORD F-150 SHUT OFF WHEN I WAS GOING 65 MPH DOWN THE NEW YORK STATE THRUWAY. I WAS STUCK ON THE SIDE OF THE ROAD FOR HOURS WAITING FOR IT TO BE TOWED. TURNS OUT THE FUEL PRESSURE MODULE (FPM) THAT IS MOUNTED IN THE BACK OF THE TRUCK ON A CROSSMEBER OF THE FRAME UP ABOVE THE SPARE TIRE WAS THE CAUSE. FORD NEEDS TO RECALL THESE 2004-2008 FORD F-150 THAT USE THIS FPM BEFORE SOMEONE GETS KILLED ON THE SIDE OF THE ROAD! *TR

TL* THE CONTACT OWNS A 2008 FORD F 150. AFTER STARTING THE VEHICLE, EXHAUST FUMES EMITTED INSIDE THE VEHICLE, BUT THE FAILURE RECURRED DAILY. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE EXHAUST MANIFOLD KIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.

I WAS DRIVING MY TRUCK HOME ON THANKSGIVING AND IT BLEW OUT A SPARK PLUG (SECOND INCIDENT, DIFFERENT CYLINDER). I WAS LATER TOLD THAT AN ENGINE FIRE COULD OCCUR FROM THE FUEL/FUMES COMING FROM THE OPEN CYLINDER HEAD. *JS

DRIVERS SIDE SEAT BELT TAKES A FEW TRIES TO GET IT TO CLICK AND SOMETIMES IT DOESN'T ENGAGE ALL THE WAY AND THE LATCH COMES OUT. A MISFIRE IN CYLINDER 1 LEAD THE DISCOVERY OF KNOWN ISSUES WITH SPARK PLUGS AND REMOVAL. 3 OF THE PLUGS WERE LOOSE. *TR

MOTOR EJECTED SPARK PLUG PASSENGER SIDE THIRD ONE BACK. SHOULD BE A RECALL BECAUSE IT IS A FAULTY DESIGN. *TR

VEHICLE WOULD STALL AT SLOW SPEED AND SEVERE RATTLING AND LOSS OF POWER TO VEHICLE WHICH COULD EASILY RESULT IN ACCIDENT. FORD SERVICE INDICATED THAT IT WAS CAM PHASING OR OTHERWISE KNOWN AS INTAKE CAMSHAFT POSITION TIMING OVER RETARDED PROBLEM. VERY DANGEROUS CONDITION WHICH SHOULD BE ADDRESSED VIA RECALL. *TR

THE CLEAR COAT PAINT IS PEALING OFF THE FRONT TRUCKER AROUND THE HEADLIGHT AND FRONT BUMPER. *TR

STARTED VEHICLE WITH NO ISSUES, DROVE FROM HOME TO LOCATION APPROXIMATELY 30 MILES AWAY. DURING THE DRIVE, I COULD FEEL A "HESITATION" DURING THE AUTOMATIC SHIFTING OF GEARS. HESITATION SEEMED TO PROGRESS DURING DRIVE TO LOCATION. ARRIVED AT LOCATION WITH NO FURTHER ISSUES. 3 HOURS LATER I LEFT LOCATION, IN ROUTE BACK TO MY HOME, AND NOTICED SAME HESITATION. ON THE WAY HOME THE "TRANS FAULT" CODE CAME ON AND THE "O/D OFF" INDICATOR LIGHT BEGAN BLINKING ON AND OFF. I ARRIVED AT MY HOME WITH NO FURTHER ISSUES. WHILE AT HOME, I ATTEMPTED TO PLACE THE VEHICLE IN REVERSE AND IT DID NOT SHIFT FOR ALMOST 3-5 SECONDS, THEN THE TRANSMISSION SEEMED TO ABRUPTLY SHIFT INTO REVERSE. AT THIS POINT MY VEHICLE IS NOT OPERABLE FOR FEAR OF CAUSING FURTHER DAMAGE. *TR

WHEN TURNING LEFT OR RIGHT THE STEERING GETS STIFF AND JERKING CAUSING OVERSTEER AND ERRATIC MOTION. ADDED POWERSTEERING FLUID BUT DID NOT HELP. *TR

WHILE MAKING A LEFT HAND TURN, NOTICED STEERING BECAME VERY TIGHT. HAD TO FORCE IT THEN IT "RELEASED" RESULTING IN AN OVER STEER AND ALMOST VEERING TO ONCOMING TRAFFIC. CENTERING THE WHEEL ALSO BECAME DIFFICULT AND RESULTING IN OVERSTEER THE OPPOSITE WAY. SAME PROBLEM - RIGHT OR LEFT HAND TURN. WAS INTERMITTENT BUT HAS BECOME CHRONIC NOW AND GETTING WORSE. HAVE NOT HAD IT IN THE SHOP YET. *TR

STARTED SHAKING AND SPUTTERING IN REVERSE AT LOW RPM. TWO TRANSMISSION SHOPS SAID IT WAS THE REVERSE BAND IN TRANSMISSION AND NEEDED REBUILD. HAD TRANS REBUILT (AT COST OF 2390.00). AFTER REBUILD, MECHANIC WAS DRIVING AND IT STILL HAD PROBLEM. AFTER RESEARCHING, HE THINKS IT IS THE CAM PHASERS CAUSING PROBLEM. HE HAD REPLACED MY PLUGS BEFORE TRANSMISSION WORK TO RULE THAT OUT (ALL 8 OF THE PLUGS BROKE WHILE TAKING THEM OUT, HE HAD NEVER SEEN ALL BREAK ON A F150 BEFORE). THIS ENGINE/TRANSMISSION IS A BAD DESIGN ALL AROUND AND FORD NEEDS TO STEP UP, ADMIT IT AND FIX AND OR REIMBURSE CUSTOMERS FOR REPAIRS. YOU CAN SPEND THOUSANDS CHASING PROBLEMS IN THIS POWER TRAIN! EVEN THOUGH THE TRANSMISSION REBUILD DID NOT FIX THE INITIAL PROBLEM, THE REAR BAND WAS WORN, AND THE PLATE IN THE TRANSMISSION HAD A SMALL DENT AND HAIR LINE CRACKS, SO IT WAS GOING TO FAIL EVENTUALLY! THE TRANSMISSION SHOP SAID THIS IS COMMON IN THESE. I WANT SOMETHING DONE! *TR

STEERING STICKS. *TR

MY TRUCK HAS 81K MILES ON IT AND THE TORQUE CONVERTER HAS GONE BAD. I HAVE NEVER IN THE PAST HEARD OF A BAD TORQUE CONVERTER FROM NORMAL WEAR AND TEAR. THE TOP OF MY STEERING WHEEL IS SHOWING MAJOR WEAR. MY WIFE'S 2000 MINI VAN HAS NO WEAR ON IT. WHY WOULD THE TOP OF MY STEERING WHEEL BE FALLING APART? *TR

I BOUGHT THIS TRUCK NEW WITH 26 MILES ON IT. I HAVE SINCE HAD BRAKES GO OUT...STEERING GO OUT, POWERTRAIN REPLACED WITH REFURBISHED ONE. I DON'T UNDERSTAND WHY THE STEERING ISSUE IS NOT A SAFETY ISSUE AND ALL THE MECHANICS AT FORD SAY IT SHOULD BE A RECALL. I DON'T UNDERSTAND WHY THE SPARK PLUGS CAN'T BE REMOVED WITHOUT BREAKING OFF AND FORD IS TOTALLY AWARE OF THIS PROBLEM. MY TRUCK STEERING ...I WAS TOLD A PART NEEDS TO BE REPLACED THAT HAPPENS TO ALL THESE TRUCKS...IT IS AT LEAST $1300.00...AND WHEN I ASKED FOR A TUNEUP AND WAS TOLD BECAUSE THE SPARK PLUGS BREAK OFF IT CAN BE OVER 800.00...I WAS ASTONISHED THAT WITH ALL THE TROUBLE WITH GM RECALLS YOU WOULD NOT TARGET THIS 2008 FORD F-150...THERE ARE MULTIPLE MAJOR SAFETY ISSUES. I ALREADY WENT UP AGAINST FORD ABOUT THE POWERTRAIN AND HAVE PAID $35,000.00 FOR THIS TRUCK, I OWE THOUSANDS MORE. CAN YOU HELP OR BE OF ANY ASSISTANCE FOR ALL FORD TRUCK OWNERS? OH, AND THE TRUCK STARTS SHAKING AND I HAVE TO STOP PUT IN 4WD AND THEN OUT AGAIN IN MIDDLE OF TRAFFIC TO GET IT TO RUN RIGHT, AND THE EMERGENCY BRAKES STICKS TOO. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

PURCHASED USED 2008 FORD F-150 5.4L V8 GASOLINE TRUCK A COUPLE OF YEARS AGO. LAST YEAR THE TRUCK STARTED TO SOUND LIKE A DIESEL ONCE THE ENGINE WARMED UP. THE CAM PHASER SENSORS WERE REPLACED. THIS DID NOT FIX THE PROBLEM. NEXT WE WILL HAVE A CAM PHASER LOCK OUT SYSTEM INSTALLED. THE MECHANIC SAYS THAT 50% OF THE TIME IT FIXES THE PROBLEM BUT THE OTHER 50% REQUIRES A BRAND NEW ENGINE. ALSO, KEYSTONE IS THE ONLY ENGINE THAT MY MECHANIC WILL USE FOR THE REPLACEMENT DUE TO THE ORIGINAL MANUFACTURER HAVING THIS PROBLEM WITH 2004 TO 2008 MODEL YEARS. ALL SEARCHES ONLINE AND DISCUSSIONS WITH VARIOUS PEOPLE (FRIENDS, FAMILY, FORD DEALERSHIP MECHANICS, PUBLIC FORUMS) HAVE FOUND THIS TO BE A COMMON PROBLEM THAT CAN COST UP $7,000 TO FIX YET FORD HAS NOT RECALLED THE ENGINE OR OFFERED TO MODIFY THE ENGINE BY INSTALLING THE LOCK OUT KIT. NOW THE TRUCK HASN'T BEEN DRIVEN MORE THAN A COUPLE OF MILES IN THE LAST YEAR SO THE ENGINE IS NOT DESTROYED. THE MOST COMMON COURSE OF THE BREAK DOWN IN THE ENGINE IS AS FOLLOWS: CAM SENSOR FAIL, CAM PHASERS BREAK IF NOT LOCKED OUT, FRAGMENTS OF THE PHASER GETS INTO THE OIL CAUSING THE ENGINE TO BE DESTROYED. *TR

I HAVE A 2008 FORD F-150 KING RANCH WITH A 5.4 L ENGINE. EXHAUST STUDS HAVE SNAPPED OFF CAUSING A LEAK FROM THE EXHAUST MANIFOLD AND CARBON MONOXIDE FILLS THE CAB OF THIS VEHICLE SETTING AT IDLE. FORD HAS A PROBLEM WITH THIS ENGINE FOR USING A NON CONFORMING GRADE OF STUD. ACCORDING TO FORUMS THAT I HAVE RESEARCHED SHOWED THAT FORD HAS CHANGED THE STUDS. THEY ARE NOW USING STAINLESS STEEL STUDS. IS THERE A POSSIBILITY OF A RECALL ON THIS VEHICLES ENGINE FOR A REPAIR TO CHANGE ALL STUDS TO STAINLESS STEEL. I PURCHASED THIS VEHICLE USED AND NOTICED THE PROBLEM AFTER THE 30 DAY WARRANTY HAD EXPIRED. BUYER BEWARE! PROTECT YOUR FAMILY FROM THIS PROBLEM. *TR

TL-THE CONTACT OWNS A 2008 FORD F150. THE CONTACT STATED THAT THE WINDSHIELD RUBBER COVER MOLDING WAS DEFECTIVE. THE RUBBER MOLDING FRACTURED AND CAUSED THE RUBBER TO BECOME TRAPPED IN THE WINDSHIELD DOCK AREA AND CAN BE RELEASED WHILE DRIVING AND CAUSED A CRASH. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE VEHICLE WAS NOT REPAIRED THE FAILURE AND CURRENT MILEAGE 36,000. LI

STEERING IS TIGHT AND HARD TO STEER ESPECIALLY WHILE DRIVING AROUND CURVES AND WHEN TURNING THE STEERING IS TIGHT AND THEN LOOSENS UP AND JERKS SUDDENLY . FOUND THE STEERING COLUMN KNUCKLES SCOLDED AND NO WAY TO LUBRICATE. *TR

2008 FORD F-150. CONSUMER WRITES IN REGARDS TO THROTTLE BODY SYSTEM MALFUNCTION. *SMD THE CONSUMERS WIFE WAS DRIVING THE VEHICLE, BUT WHEN SHE HIT THE BRAKE, THE VEHICLE SUDDENLY ACCELERATED AND CRASHED INTO A BUILDING. *JB

TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED WAS DRIVING 35 MPH AND NOTICED THAT THE ENGINE RPMS INCREASED AS SMOKE BILLOWED FROM THE EXHAUST. AFTER THE CONTACT ALLOWED THE VEHICLE TO COOL DOWN, IT WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEALS WERE LEAKING TO THE BEARINGS AND THE TURBO OF THE EMISSIONS SYSTEM HAD FAILED. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 34,000.

VEHICLE HAD INTERMITTENT STARTING ISSUE AND HAS LEFT ME STRANDED. AFTER RUNNING A DIAGNOSTIC CHECK WITH A SCANNER RECEIVED A P1233 CODE WHICH IS THE FUEL PUMP DRIVER MODULE OFFLINE. COMPONENT LOCATED UNDERNEATH BOLTED TO THE FRAME.CALLED AND EMAILED SPITZER FORD,LOCAL DEALER, AND THEY'RE UNSURE OR ACTED LIKE THE NEVER HEARD OF THE PROBLEM. WHY IS IT THAT FORD NORTH AMERICA IS SHORT HANDED OF THE FPDM?

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, THE HEADLIGHTS FAILED, THE AIR BAG ACTIVATED INDEPENDENTLY AND THE AIR BAGS DEPLOYED ERRONEOUSLY. ADDITIONALLY, SMOKE BILLOWED FROM UNDER THE DASHBOARD AREA AS THE FLOORBOARD BECAME ENGULFED IN FLAMES. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE OR POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS FOUND THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 111,383.

MALFUNCTION INDICATOR LAMPS, SPEDOMETER, TEMP GAUGE AUDIO BEEPER RANDOMLY GO ON AND OFF. SPEEDOMETER GOES TO ZERO, MILEAGE GOES TO DASHED LINES OR "CHECK GAUGES".