2006 Ford F-150 complaints

I TRIED TO START MY TRUCK, BUT IT WOULDN'T START. IT TURNED OVER PERFECTLY BUT WOULD NOT START. IT HAD STARTED TWICE EARLIER IN THE DAY. THE FUEL PUMP DRIVER MODULE, LOCATED ABOVE THE SPARE TIRE ON THE FRAME OF THE TRUCK, HAD CORRODED AND FAILED.

I BROUGHT MY TRUCK IN TO MY LOCAL FORD DEALER BECAUSE THE CHECK ENGINE LIGHT CAME ON. IT IS A 2006 F150 4.6L - AFTER HIS INSPECTION, THE MECHANIC STATED THAT THE BOTTOM OF THE #2 SPARK PLUG (MANUFACTURE INSTALLED) HAD DISINTEGRATED AND FELL INTO THE HEAD CAUSING SO MUCH DAMAGE TO THE #2 CYLINDER THAT I HAVE TO REPLACE THE ENTIRE ENGINE AT A COST OF OVER $6,000 PLUS TAX. IT WILL TAKE OVER A WEEK TO FIX AND I DO NOT HAVE ANOTHER VEHICLE. I WOULD LIKE FORD TO REIMBURSE ME FOR THE EXPENSE. I HAVE WRITTEN TO THEIR "CUSTOMER CARE"( [XXX]) DEPARTMENT, BUT HAVE HAD NO HELPFUL OR SATISFACTORY RESULTS. THIS IS A KNOWN ISSUE AS FORD HAS ISSUED A TSB AND DEVELOPED A TOOL TO ASSIST WITH THE REMOVAL OF FAULTY SPARK PLUGS. *TR

THE FRAME BROKE WHERE THE FRONT DIFFERENTIAL MOUNTS, THIS LET THE FRONT AXLE TWIST AND YOU CAN NOT STEER THE TRUCK!!! I THINK THIS IS VERY DANGEROUS, IF YOU WERE GOING OVER 5 MPH. YOU COULD NOT TURN.FORD FACTORY REP. SAYS THE TRUCK IS OUT OF WARRANTY SO NOT THERE PROBLEM, THEY WILL NOT DO ANYTHING ABOUT IT. FORD SHOULD FIX THIS AT THERE EXPENSE AS THIS A SAFETY CONCERN. HOW MANY OTHER FORD PICK UPS HAVE HAD THIS SAME PROBLEM BUT NOT REPORTED IT BECAUSE THEY DID NOT HOW TO OR WHO TO COMPLAIN TO. THE NTSB SHOULD LOOK INTO THIS VERY CAREFULLY TO SEE IF THIS IS A MAJOR PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS HESITANT TO ACCELERATION. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO HER RESIDENCE. THE FAILURE WAS NOT DIAGNOSED BY A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATELY FAILURE MILEAGE WAS 154,618.

WENT TO START TRUCK AND ENGINE WOULD CRANK BUT WOULD NOT FIRE. I TRIED THE STARTING FLUID TEST TO SEE IF IT WAS AN IGNITION PROBLEM OR FUEL PROBLEM. GAVE A LITTLE SHOT OF STARTING FLUID INTO THE INTAKE AND THEN TRIED TO START. MOTOR ACTED LIKE IT WAS GOING TO START BUT NEVER STARTED BEINGS I DIDN'T GIVE IT ENOUGH STARTING FLUID TO START BECAUSE I'M NOT A FAN OF USING IT. WITH THAT I ELIMINATED THE IGNITION HAD TO BE FUEL. I GOT ON THE INTERNET AND SEARCHED NO START PROBLEM FOR 2006 F-150 AND FOUND A YOU TUBE VIDEO OF THE FUEL PUMP CONTROL MODULE RUSTING OUT. WENT OUT AND DROPPED SPARE TIRE AND TOOK THE CONTROL MODULE OFF THE CROSS MEMBER AND NOTICED THE HOLE CORRODED THROUGH THE HOUSING JUST LIKE THE VIDEO. I GOT THE UPGRADED PART FROM A FORD DEALER FOR $163 AND INSTALLED. RUNS FINE NOW. MY BIGGEST COMPLAINT IS FORD KNOWS THERE'S A PROBLEM SINCE THE HAVE CAME OUT WITH AN UPGRADED CONTROL MODULE SO WHY ISN'T THIS A RECALL? I LIVE IN A STATE THAT TEMPERATURES IN THE WINTER MONTHS CAN BE BELOW 0 DEGREES FAHRENHEIT AND DRIVE AN HOUR ONE WAY TO WORK, THIS COULD HAVE HAPPENED WHEN I WAS ON THE ROAD IN EXTREME COLD, COULD OF HAD MY TWO CHILDREN WITH ME BROKE DOWN ON THE SIDE OF THE ROAD AND COLD OUT. LUCKILY IT HAPPENED AT HOME BUT STILL IT WAS 4 DEGREES OUT AND LAYING UNDER MY TRUCK TAKING THE MODULE OFF WAS NOT VERY PLEASANT. THINK THIS IS SOMETHING THAT FORD NEEDS TO DO SOMETHING ABOUT. *TR

MY FACTORY TIRES, BF GOODRICH LONG TRAIL T/A, ON MY FORD F-150 KING RANCH BOUGHT NEW IN 2006 LASTED ONLY 21,428 MILES. THEY GAVE ME A LOUSY $236. AND IT COST ME $708.TO REPLACE ALL 4. NOW, 18,270 MILES LATER THERE ARE LESS THE 4/32 LEFT ON THE TREAD. ON A RECENT OIL CHANGE, A DEALER WOULD NOT ROTATE MY TIRES BECAUSE OF THE WARE. NOW I AM BEING TOLD - SORRY NO WARRANTY LEFT! - I AM LIVID! CAN ANYTHING BE DONE? *TR

WHEN DRIVING HOME, CHECK ENGINE LIGHT STARTED FLASHING, IMMEDIATELY STOPPED AND HAD VEHICLE TOWED TO A WELL REPUTABLE SHOP FOR DIAGNOSIS AND REPAIR. WAS DIAGNOSED WITH TWO FUEL INJECTORS FAILING AND NEEDING REPLACED ALONG WITH ALL SPARK PLUGS NEEDED REPLACED. 6 OF THE 8 PLUGS SNAPPED IN HALF AND NEEDED TO BE BURROWED OUT ON TOP OF IT COSTING $90 PER PLUG DRILLING OUT. TOTAL FOR REPAIRS CAME TO $2300. BUT AFTER REPAIRS WERE COMPLETED I STILL DO NOT HAVE A RUNNING VEHICLE. THE ENGINE STARTS BUT OIL PRESSURE DROPS AFTER 5 MINS OF RUNNING. I WOULD LOVE TO FIND A SOLUTION TO THIS, IF THIS IS COMMON OR NOT. AND IF SO, WHY IS IT NOT RECALLED? *TR

VEHICLE BEGAN TO SMELL LIKE GAS IN THE CAB ON NUMEROUS OCCASIONS. TOOK IT TO FORD DEALERSHIP MECHANIC AND WAS TOLD THAT THE SOURCE OF THE GAS SMELL COULD NOT BE FOUND. A FEW DAYS LATER UPON STARTING THE VEHICLE, A VERY LOUD EXPLOSIVE SOUND WAS HEARD UNDER THE HOOD. THE VEHICLE WAS TURNED OFF AND TOWED BACK TO THE FORD DEALERSHIP WHERE IT WAS DETERMINED THAT THE ORIGINAL #2 SPARK PLUG HAD BLOWN OUT OF THE ENGINE AND DAMAGED THE HEAD. REPAIR EXCEEDING $700 WITH ABSOLUTELY NO RESPONSIBILITY TAKEN BY FORD. REPEAT INCIDENT LESS THAN ONE YEAR LATER WITH ANOTHER CYLINDER. *TR

TRUCK WAS AT DEALERSHIP FOR REPAIRS, WHEN I WAS TOLD NOT TO HAVE REPAIRS DONE BECAUSE THE FRAME IS CRACKED AND RUSTED THRU. THEY SAID THE VEHICLE IS UNSAFE TO DRIVE. THE TRUCK IS NOW WORTHLESS. IN MY 50 YEARS OF OWNING AND DRIVING NUMEROUS VEHICLES IN THE NORTHEAST, I NEVER HAD A RUSTED FRAME ISSUE. FORD WILL NOT HELP NOR INVESTIGATE THE SITUATION. *TR

I WAS INVOLVED ON A ACCIDENT ON FEBRUARY 17 2013 A CAR RUN IN TO MY TRUCK .DRIVER SIDE MY TRUCK SPIN AROUND AND I HIT THE DIVIDER IN THE MIDDLE AT THE STREET THE AIRBAG NEVER DEPLOY THE TOTAL DAMAGE ON MY TRUCK WAS $10,800 DOLLARS AND 2 MONTHS LATER A REVISE A LATTER FROM FORD COMPANY SAID THAT MY TRUCK HAS A RECALL ON THE AIRBAG ...SO I REVISE THE NOTIFICATION REALLY LATE ... SO I WAS THIS DRIVING A DEFECT TRUCK FOR YEARS REALLY I M REALLY UPSET ..WHEN I REVISE THE RECALL LATTER I TOOK MY TRUCK TO THE BIG VALLEY FORD DEALER SHIP AND THEY FIX MY AIRBAG ...SO THERE WAS A PROBLEM I TRY TO GET A HOLD OF THE FORD COMPANY AND THEY GIVE ME A CASE NUMBER BUT THEY DON'T DUE NOTHING ABUT IT I NEED HELP AND SOME INFO HOW CAN I GO AGAINST FORD COMPANY. *TR

HANKOOK DYNAPRO AS P255/65SR17 SEPARATED AT APPROX. 10,000 MILES. POTENTIAL FOR ACCIDENT SINCE IT WAS A STEERING TIRE. PURCHASED AT PEPBOYS STORE # 661 TUCSON, AZ. *TR

MY 2006 FORD F150 FX4 HAS STALLED ON THE HIGHWAY AT TWO DIFFERENT TIMES IN THE LAST 9,000 MILES. I AM DRIVING AT NORMAL SPEEDS, WITH NORMAL WEATHER CONDITIONS, HALF TANK OF GAS, AND I WAS COASTING AS HIGHWAY SPEEDS SLOWED - AS I WENT TO HIT THE ACCELERATOR TO SPEED UP, I LOST THE ABILITY TO ACCELERATE. FIRST THE WRENCH DASH LIGHT CAME ON, THEN I NOTICED STEERING WAS SLIGHTLY DIFFICULT AND THEN THE BATTERY AND TRANSMISSION LIGHT CAME ON. I GOT THE VEHICLE TO THE SIDE OF THE ROAD, BUT I DID NOT LOSE HEADLIGHTS, RADIO, HEAT, OR POWER. I TURNED THE TRUCK OFF AND WAITED 2 MINUTES, THEN IT STARTED BACK UP - A LITTLE DIFFICULT ON THE STARTER, BUT IT WORKED. I HAVE READ NUMEROUS CHAT FORUMS ONLINE WITH USERS HAVING THIS SAME ISSUE WITH 2006 V8'S IN THE F150. WHAT IS FORD DOING ABOUT THIS? MY VEHICLE HAS BEEN METICULOUSLY MAINTAINED AND CARED FOR. FROM WHAT I READ THIS IS A FUEL PUMP CONTROL PANEL ISSUE WITH CORROSION OF DISSIMILAR METALS - WHERE IS THE RECALL? *TR

WHILE APPROACHING A STOP THE TRUCK GAUGES STARTED GOING CRAZY. TRUCK STALLED BUT RESTARTED WITH GAUGES STILL ACTING CRAZY. ALL GAUGES WOULD BOTTOM OUT AND COME BACK UP AND RADIO WAS TURNING ON AND OFF. REPLACED BATTERY BUT ONLY STALLING ISSUE WAS RESOLVED. TOOK TO LOCAL FORD DEALER BUT SINCE THE TRUCK ONLY DOES THIS RANDOMLY, THEY WERE NOT ABLE TO DIAGNOSE THE PROBLEM. TRUCK RUNS PERFECTLY BUT GAUGES AND RADIO STILL GO ON AND OFF MAKING IT EXTREMELY ANNOYING TO DRIVE. VERY FRUSTRATING TO KNOW THAT SO MANY OTHER FORD OWNERS HAVE THE SAME PROBLEM BUT NO SOLUTION HAS BEEN OFFERED FROM FORD. *TR

WHEN I STARTED THE TRUCK, A SPARK PLUG BLEW INTO THE HEAD. THE MECHANIC AT THE FORD DEALERSHIP TOLD ME THIS WAS A COMMON PROBLEM WITH THESE TRUCKS. THE REPAIR COST ME $3,448. TO REPLACE THE HEAD. IF FORD IS AWARE OF THIS PROBLEM, THE VEHICLES SHOULD BE RECALLED AND THE PROBLEM CORRECTED. MY FAMILY WAS LEFT STRANDED 7 HOURS AWAY FROM HOME, HAD TO RENT A VEHICLE TO GET HOME AND THEN TWO WEEKS LATER, HAD TO RETURN TO DEALERSHIP AND PICK UP THE TRUCK. SO STRESSFUL AND EXPENSIVE. JUST GLAD WE WERE IN A TOWN WHEN THIS HAPPENED! *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED DURING ROUTINE MAINTENANCE ON THE VEHICLE SHE WAS INFORMED THAT THE SPARK PLUGS WERE FRACTURED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO REPAIRED THE VEHICLE. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 71,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING SHAFT EXHIBITED EXCESSIVE RUST, MAKING THE VEHICLE DIFFICULT TO STEER AT ALL SPEEDS. THE CONTACT CLEANED AND LUBRICATED THE STEERING SHAFT BUT THE SERVICE ONLY REMEDIED THE ISSUE TEMPORARILY. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER. THE CONTACT CALLED THE MANUFACTURER AND OFFERED THE CONTACT A NEW PART TO PURCHASE. THE CONTACT DID NOT PURCHASE THE PART. THE FAILURE MILEAGE WAS 48,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS STARTED AND THE ENGINE EXHIBITED A LOUD NOISE. ADDITIONALLY, THE CONTACT SMELLED A BURNING ODOR. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC, WHO STATED THAT THE SPARK PLUG HAD MELTED DUE TO THE HEAT FROM THE HEAD GASKET. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 40,000.

2006 FORD F-150. CONSUMER REQUESTS REIMBURSEMENT FOR VEHICLE REPAIRS. *SMD THE CONSUMER STATED HE WAS QUOTED A PRICE OF $447 TO REPLACE THE SPARK PLUGS. HOWEVER, WHEN HE RECEIVED THE BILL, THE PRICE HAD DOUBLED.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE BRAKES FAILED WHILE DRIVING 45 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE BRAKE BOOSTER FAILED. THE CONTACT SPOKE TO THE MANUFACTURER AND WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER:08V208000(SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 101,000.

THE RIGHT EXHAUST MANIFOLD STUDS HAD BROKEN APPROXIMATELY 5/5/2012, IN WHICH THEY DID NOT TELL ME THE FULL EXTENT OF THE DAMAGES. THEY JUST TOLD ME THE MANIFOLD WAS LEAKING AND THE COST TO REPAIR IT. THIS CAUSED THE MANIFOLD TO WARP AND LEAK. THE DEALER WOULD NOT REPAIR IT UNDER THE EXTENDED WARRANTY. APPROXIMATELY ONE YEAR LATER I CALLED THE WARRANTY COMPANY AND FOUND OUT IT WAS ACTUALLY COVERED. WHEN I HAD TAKEN IT IN, IN MAY 2012 THE DEALER WANTED TO CHARGE 1500.00 FOR THE REPAIRS. THE REPAIRS WERE FINALLY MADE IN MAY OF 2013 TO THE EXHAUST MANIFOLD, BUT NOT TO THE CATALYTIC.CONVERTER WHICH STARTED CAUSING PROBLEMS IN JANUARY OF THIS YEAR. THIS LEAK MAY HAVE CAUSED THE RIGHT CATALYTIC CONVERTER TO FAIL ALSO, BUT HAVE FOUND MANY FORUMS STATING THAT FAILURE OF THE CATALYTIC CONVERTERS ARE A COMMON PROBLEM ON THESE PICK UPS. AT THIS TIME I AM DRIVING THE PICK UP AND IT THROWS THE CODE P0420, FOR CATALYTIC CONVERTER BELOW EFFICIENCY THRESHOLD. THIS PROBLEM SHOULD ALSO BE FORWARDED TO THE E.P.A. BECAUSE PEOPLE CANNOT AFFORD TO REPLACE THEIR CATALYTIC CONVERTERS AT THE PRICE OF 1200.00 PER SIDE. IF THIS IS A COMMON PROBLEM WITH FORD F-150'S THIS NEEDS ADDRESSED. ALSO THE FAILURE OF THE EXHAUST MANIFOLD IS A SAFETY HAZARD THAT COULD CAUSE THE OCCUPANTS IN THE CABIN TO BE EXPOSED TO CARBON MONOXIDE. THE LEAKING MANIFOLD ALSO CONFUSES THE COMPUTER BY TELLING IT THAT THE OF BANK CYLINDERS IS RUNNING TO LEAN IN RESPONSE TO THOSE READINGS IT THEN ADDS FUEL TO THAT BANK WHICH CAUSES IT

WENT TO BACK UP AND NO REVERSE. *TR

SPARK PLUGS AND COIL PACKS HAVE FAILED ACROSS OUR ENTIRE FLEET OF 2005-2008 F-150'S. THE POTENTIAL FOR SEIZED SPARK PLUGS IS SIGNIFICANT DUE TO INCREASED HEAT FROM FAILED COIL PACKS. THE COIL PACKS SEEM TO FAIL APPROXIMATELY EVERY 25,000-75,000 MILES. THE REPAIRS HAVE BEEN VERY COSTLY - ESPECIALLY WITH A FLEET OF 200+ VEHICLES. FORD HAS NOT OFFERED ANY ASSISTANCE WITH ANY OF THE CLAIMS. SYMPTOMS - THE VEHICLE SPUTTERS OR BOGS DOWN UNDER LOAD WHILE TRAVELING UP A HILL OR UNDER HARD ACCELERATION. DANGERS - THE VEHICLE WILL NOT ACCELERATE WITH 100% POWER WHILE UNDER LOAD IN A DANGEROUS SITUATION. THE NEED TO QUICKLY ACCELERATE BECOMES ALTERED DUE TO POSSIBLE SPARK PLUG/ COIL PACK FAILURE. RISKS ARE ACCIDENTS, PERSONAL INJURY, OR EVEN WORSE. *TR

VEHICLES MISFIRING AND STUMBLING DURING MODERATE ACCELERATIONS AND CRUISING WHEN A LOAD IS PUT ON MOTOR. ( GOING UP A HILL, SLIGHT INCLINE AND PASSING). SPARK PLUGS WERE UNABLE TO BE REMOVED FOR REPLACEMENT. THE SPARK PLUGS WERE NOT OF GOOD QUALITY AND WOULD NEED TO BE REPLACED MORE OFTEN THAN USUAL. THE MANUFACTURER WAS MADE AWARE, HOWEVER NO ASSISTANCE WAS PROVIDED. $1249.00 TO CHANGE ONE SPARK PLUG. *TR

THE VEHICLE WAS BEING DRIVEN AT 35 MPH AND SIMPLY STOPPED RUNNING. VEHICLE COULD NOT BE RE-STARTED. TOWED TO REPAIR SHOP. THE MECHANIC TESTED THE FUEL SYSTEM AND DETERMINED THE FUEL PUMP HAD BURNED OUT. THE FUEL PUMP WAS REPLACED AT A COST OF $552.05. ONE DAY AFTER REPAIRS WERE COMPLETED THE CHECK ENGINE WARNING LIGHT WAS ACTIVATED AND THE CODE REVEALED A FUEL SYSTEM ISSUE. THE VEHICLE WAS IMMEDIATELY TAKEN BACK TO THE SAME REPAIR SHOP. THE FUEL PRESSURE WAS OPERATING AT 90 PSI. AFTER SEVERAL UNSUCCESSFUL VISITS, IT WAS EVENTUALLY DETERMINED THAT THE FUEL PUMP CONTROL MODULE WAS SEVERELY CORRODED AND MALFUNCTIONING. THE "POT" METAL HAS BEEN COMPLETELY CORRODED AND THERE IS AN APPROXIMATE 1 INCH DIAMETER HOLE LEADING DIRECTLY TO THE ELECTRIC PANEL. THE CONTROL MODULE WAS REPLACED FOR AN ADDITIONAL $399.89. THE DESIGN OF THIS MODULE USING "POT" METAL AND SIMPLY BOLTING TO THE STEEL AXLE IS RIDICULOUS. THIS ITEM SHOULD BE AN IMMEDIATE RECALL WITHIN THE "SALT BELT" AREAS OF NORTH AMERICA. I HAVE DOCUMENTED RECEIPTS FROM THE REPAIR SHOP AND HAVE KEPT THE ORIGINAL FUEL MODULE AS WELL. FORD MOTOR COMPANY SHOULD RECOGNIZE THIS ISSUE AS AN OBVIOUS RE-CALL ITEM AND BE HELD RESPONSIBLE FOR ASSOCIATED REPAIR BILLS. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE SHIFTED OUT OF GEAR WHILE AT A STOP AND THEN LUNGED FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE TRANSMISSION HAD DEVELOPED A PLANETARY NOISE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 24,000. THE CURRENT MILEAGE WAS 35,800.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE INSTRUMENT CLUSTER SHUT OFF WHENEVER THE TEMPERATURE WAS ABOVE 70 DEGREES. THE CONTACT MENTIONED THAT IT WOULD RETURN TO NORMAL ONCE THE TEMPERATURE WAS COOLER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 114,000. *TR

WHILE REPLACING THE SPARK PLUGS, EVERY PLUG BROKE OFF AND WAS VERY DIFFICULT TO REMOVE. MY MECHANIC GOT OUT THE FIRST SEVEN, BUT THE EIGHTH WOULD NOT COME OUT. IT SUBSEQUENTLY FELL INTO MY ENGINE, CAUSING IT TO SEIZE. I SHOULD HAVE GOTTEN ANOTHER 100,000 MILES OUT OF THIS TRUCK! *TR

THE LED DISPLAY THAT INDICATES THE MILEAGE, GEAR SELECTOR AND WARNING INDICATOR IS NO LONGER OPERABLE. FROM A QUICK WEB SEARCH AND A DISCUSSION WITH THE LOCAL FORD SERVICE DEPARTMENT THIS IS A KNOWN ISSUE THAT IS NOT CURRENTLY COVERED BY A RECALL. INABILITY TO VIEW MILEAGE AND WARNING INDICATORS RESULTS IN UNSAFE DRIVING CONDITIONS. *TR

DRIVING EAST ON I90 (ABOUT 20 MILES WEST OF STEWARTVILLE, MN) DURING FREAK MAY BLIZZARD. DUE TO ROAD CONDITIONS, COULD ONLY DRIVE BETWEEN 15-40 MPH. SUDDENLY THE ENGINE STOPPED RUNNING. I WAS ABLE TO START IT UP AGAIN AND DRIVE ABOUT 3 MINUTES AND THEN IT WOULD DIE AGAIN. THERE WAS NO PLACE TO PULL OVER, AS THE SHOULDERS OF THE ROAD WERE NOT CLEARED AND THERE WAS 12" OF WET HEAVY SNOW. MY TRUCK IS NOT 4WD SO WE WOULD HAVE GOTTEN STUCK. WE HAD TO DRIVE WITH THE HAZARDS ON, BUT IT WAS LOW VISIBILITY AND WE COULD EASILY HAVE BEEN HIT FROM BEHIND. WE COULD NOT GET OFF ON THE EXIT RAMP BECAUSE A SEMI TRUCK JACKNIFED AND THE EXIT WAS CLOSED. WE HAD TO CONTINUE THIS HAZARDOUS JOURNEY TO THE NEXT EXIT, WHICH WAS ABOUT 12 MILES AWAY, TO STEWARTVILLE, MN. WE FOUND A AUTO REPAIR SHOP AND DESCRIBED THE PROBLEM. THE MECHANIC SUSPECTED IMMEDIATELY THAT IT WAS THE FUEL PUMP CONTROL MODULE. HE SAID THAT HE HAS BEEN INSTALLING A LOT OF THESE LATELY ON F150S, ESPECIALLY 2006'S. HE SAID HE FELT THERE SHOULD BE A RECALL, AS IT IS WELL-KNOWN AMONG MECHANICS THAT THESE ARE FAILING AT AN ALARMING RATE. THE PROBLEM IS THAT THE MODULE IS LOCATED TIGHT AGAINST THE FRAME, NEXT TO THE SPARE TIRE, AND THE METAL OF THE MODULE (ALUMINUM) REACTS ADVERSELY WITH THE STEEL METAL OF THE FRAME, CAUSING OXIDATION BETWEEN THE TWO. THIS CAUSES THE MODULE TO BREAK AND FAIL, THUS SHORTING OUT THE CIRCUIT BOARD. FORD KNOWS THAT THIS IS A PROBLEM, AS THE REPLACEMENT PARTS HAVE SPACER PLATES TO KEEP THE MODULE & FRAME S

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING AT 3 MPH, THE VEHICLE STALLED AND WOULD NOT RESTART. AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE AS HAVING A FAULTY FUEL PUMP AND/OR FAULTY FUEL DRIVER MODULE. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 103,000.

A DEER RAN OUT IN FRONT OF VEHICLE..ROAD WET AND IT WAS FOGGY..TRIED TO KEEP FROM HITTING DEER..BACK OF TRUCK FISHTAILED..LOSS CONTROL..HIT A DITCH AND EMBANKMENT...AIR BAGS DID NOT EMPLOY AND SEAT BELT DID NOT LOCK...HAD A FRACTURE IN L2 VERTEBRAE OF BACK..FORD HAS DENIED ANY FAULT IN AIR BAG OR SEAT BELT FUNCTION...TRUCK WAS TOTALED BY INSURANCE COMPANY..... *TR

I WAS WARMING THE VEHICLE TO GO TO WORK, MY TRUCK JUST SUDDENLY STALLED, HAD TO GET A TOW TO THE NEAREST FORD DEALER, THE MECHANIC SAID THE FUEL PUMP MODULE UNIT WENT OUT, THE PART IS ON BACK ORDER OR EMERGENCY ORDER, I HAVE NO VEHICLE TO GET TO WORK, I NEED MY VEHICLE, THIS PART SHOULD BE ON RECALL FOR FORD F150. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING 44 MPH, THE VEHICLE SHOOK VIOLENTLY THEN STALLED. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT CONFIRMED THAT THE FUEL PUMP HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 111,600. THE VIN WAS UNAVAILABLE.

DRIVING VEHICLE DRIVE AND OVERDRIVE WENT OUT THIS IS TWO TIMES THIS HAPPENED FORD NEEDS TO PAY FOR REPAIRS OTHER PEOPLE HAVE SAME PROBLEM THIS PROBLEM SHOULD BE LOOKED INTO. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE ENGINE RPMS INCREASED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. *TR

I RECENTLY PURCHASED THIS VEHICLE USED BUT THE BODY WAS IN GREAT CONDITION AND IT RAN GOOD ON THE TEST DRIVE. AFTER THREE DAYS I NOTICED A FUEL SMELL IN THE CAB AND WHEN OVERTAKING A VEHICLE IT STARTED MISS FIRE. FORTUNATELY THE DEALER I BOUGHT IT FROM HAD ME TAKE IT TO THE MECHANIC HERE IN TOWN WHO SAID THAT IT WAS THE NUMBER FIVE IGNITION COIL WHICH HE REPLACED. THE NEXT DAY THE PROBLEM CONTINUED SO I TOOK IT BACK AND IT WAS THE SPARK PLUGS WHICH HE REPLACED (400.00) BUT IT RAN WELL. I DROVE IT TO PA. AND BACK WITH NO PROBLEM BUT YESTERDAY THE SAME PROBLEM HAPPENED AND NOW IT IS COIL NUMBER 2 (73.00). THE MECHANIC WHO HAS BEEN IN BUSINESS FOR 28 YEARS IN OUR FARM TOWN IN WHICH HE SERVICES NUMEROUS FORD TRUCKS SAID THAT THIS IS A SERIOUS PROBLEM WITH FORDS FROM THE COILS TO THE ILL DESIGNED SPARK PLUGS. NOW THAT I HAVE READ THE NUMEROUS COMPLAINTS WHICH ARE SYNONYMOUS WITH MY PROBLEM INCLUDING THE FUEL SMELL MAKES ME WONDER IF THE NHTSA IS ON THE TAKE FROM FORD TO OVERLOOK CERTAIN PROBLEMS. I THINK THAT I WILL USE SOME OF MY WELL CONNECTED FRIENDS IN CONGRESS TO LOOK INTO THIS IF I DO NOT GET A SATISFACTORY ANSWER TO THIS ISSUE. *TR

FUEL PUMP MODULE, ENOUGH SAID FORD. TIME TO MAKE A RECALL. NO RECALL BUT THERE'S AN UPDATE TO MOUNT IT ON STUDS...THINK THERE'S AN ISSUE? *TR

2006 FORD F-150 HARLEY DAVIDSON HAS COIL MISFIRE PROBLEM. ALL EIGHT COILS HAVE BEEN REPLACED IN THE LAST 24 MONTHS AND THREE HAVE BEEN REPLACED TWICE. CAT CONVERTER HAS BEEN REPLACED TWICE IN THE SAME TIME PERIOD. ALL PLUGS HAVE BEEN REPLACED. THE CAR CONTINUES TO MISFIRE. AS A RESULT, THE VEHICLE HAS AN EXTREMELY STRONG ODOR OF FUEL RESONATING. THE DEALER STATES THAT THEY CANNOT DO ANYTHING TO FIND THE ROOT OF THE PROBLEM. THIS VEHICLE IS DEALER SERVICED. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE BRAKING TO A STOP, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE COULD NOT BE REPLICATED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 127,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING, THE ENGINE RPMS INCREASED EXCESSIVELY AND THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 34,000 AND CURRENT MILEAGE WAS 38,500. *TR UPDATED 5/7/13 *CN

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED HEAD-ON INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 76,624.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING 50 MPH, THERE WAS A LOUD BEEP AND THE SAFE MODE SIGNAL ILLUMINATED THEN THE VEHICLE STALLED. THE VEHICLE WAS MERGED TO THE SHOULDER AND AFTER WAITING FOR ABOUT 15 MINUTES, THE VEHICLE WAS ABLE TO BE RESTARTED. THE VEHICLE HAD NOT BEEN INSPECTED. THE FAILURE AND CURRENT MILEAGES WERE 50,100.

TRUCK KEEPS SHUTTING OFF. IF YOU WAIT 45 MINUTES TO RESTART IT WILL START AND IDLE FOR ABOUT 15 SECONDS AND SLOWLY DIE. OR YOU CAN DRIVE A SHORT DISTANCE AND IT WILL DIE. REPAIR IS FOR THE FUEL PUMP CONTROL MODULE. BECAUSE OF WHERE IT IS MOUNTED ON THE TRUCK IT CORRODES VERY FAST ESPECIALLY IN SNOW STATES DUE TO THE SALT ON ROADWAYS. FORD CAN YOU PLEASE DO A RECALL OF THIS PART AND REIMBURSE US FOR THE COST! *TR

MY 2006 FORD F150 HAS THE POSITRACTION REAR END. ITS WENT OUT AROUND 25000 TO 30000 MILES, WHILE THE TRUCK WAS STILL UNDER WARRANTY AND THE DEALER FIXED IT NO CHARGE. NOW THE TRUCK HAS A LITTLE OVER 62000 MILES AND THE REAR END HAS GONE OUT AGAIN. ALMOST EXACTLY THE SAME AMOUNT OF MILES ON THE REAR END. WARRANTY WAS UP AT 60000 MILES SO ITS NO LONGER COVERED. I THINK THIS SHOULD BE LOOKED INTO AS A RECALL BECAUSE THIS IS THE SECOND TIME ITS HAPPENED ON THE SAME TRUCK. *TR

WHILE TURNING TRUCK STARTED TO EMIT NOISES, SOUNDED LIKE AN EXHAUST PROBLEM, MANIFOLD ETC. NO SERVICE ENGINE LIGHT ON AND ALL GAUGES WERE NORMAL. THEN WHILE DRIVING, AS TRUCK SHIFTED DOWN TO OVERDRIVE, NOISE RETURNED, LOSS OF POWER, BUT AGAIN NO SERVICE ENGINE LIGHT, GAUGES ALL NORMAL. TOOK VEHICLE TO DEALER, HAVE BEEN TOLD, ENGINE NEEDS TO BE REPLACED,(81,250 MILES/130,000KM) FOR A MEAGER $6000. VEHICLE HAS BEEN DEALER MAINTAINED SINCE NEW, OIL CHANGED EVERY 3125, MILES/5000KM (BY DEALER) STILL NO SERVICE ENGINE LIGHT, GAUGES STILL READING NORMAL. MANUFACTURER WILL DO NOTHING. LOOKING FOR LAWYER WHO WOULD LIKE TO START CLASS ACTION SUIT AGAINST MANUFACTURER, CONSIDERING ALL THE ISSUES I HAVE FOUND ON THE 2006 F150 V8 TRITON SINCE STARTING RESEARCH YESTERDAY, THERE ARE A LOT OF US THAT FORD IS NOT WILLING TO ASSIST. *TR

WHILE APPROACHING AN INTERSECTION, ABOUT TO MAKE A RIGHT AT THE LIGHT, (I WAS DRIVING ABOUT 20MPH) ON 12/24/12 (WITH MY TWO CHILDREN AND HUSBAND IN THE TRUCK) THE VEHICLE BEEPS AND IT DISPLAYS "ENGINE SAFE MODE...LOW OIL PRESSURE" THEN THE POWER STEERING CUTS OFF AND THE WHOLE VEHICLE SHUT DOWN! I AM FRANTIC AT THIS POINT BECAUSE I HAVE NO CLUE WHAT IS GOING ON! I WAS IN THE MIDDLE OF TRAFFIC AND HAD TO CUT THE CAR OFF AND CRANK IT UP AGAIN. LUCKILY I DIDN'T GET REAR ENDED OR IN AN ACCIDENT. THAT SAME DAY I WENT AND GOT MY OIL CHANGE BECAUSE IT WAS OVER DUE. WELL ON 1/4/13 THE SAME THING HAPPENS AS I AM TURNING INTO THE PARKING LOT OF MCDONALD'S. I GET THE SAME ERROR MESSAGE AS BEFORE, THE STEERING WHEEL LOCKS UP, AND TRUCK CUTS OFF! THIS SO EXTREMELY DANGEROUS. I LOOKED THIS ISSUE UP ONLINE AND SEE THAT IT APPEARS TO BE A COMMON ISSUE WITH THE 2006 F-150 AND THE EXPEDITION. MY BOTHER-IN-LAW, WHO ALSO HAS A SIMILAR F-150 TO OURS, SAID THE SAME THING HAS HAPPENED TO HIM TWICE. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE FAILURE RECURRED FIVE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE COIL PACKS WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 6,000.

2006 F-150 FUEL CONTROL MODULE SHOULD BE A MANDATORY SAFETY RECALL FOR FORD. THE 2006 F-150 HAS A POORLY DESIGNED FUEL MODULE THAT ABSOLUTELY WILL FAIL OVER TIME IN RUST BELT STATES, PRODUCING A LOSS OF POWER, INABILITY TO START OR A COMPLETE ENGINE STALL / LOSS OF CONTROL AT ANY SPEED, INCLUDING HIGHWAY SPEEDS. MY COMPLAINT STARTS AFTER THE FIRST SNOWSTORM THIS YEAR. THE TRUCK WAS SLUGGISH TO ACCELERATE ON THE HIGHWAY AND IT SEEMED TO NEED MORE GAS PEDAL JUST TO MAINTAIN SPEED. A FEW DAYS LATER I DROVE UP HEAVILY SALTED ROADS TO A SKI AREA. AT THE END OF THE DAY, THE TRUCK WOULD NOT START WITHOUT THE GAS PEDAL BEING FULLY DEPRESSED. (FIRST TIME I HAVE EVER HAD TO USE THE GAS PEDAL TO START IT.) I GOT IT RUNNING FOR ABOUT 2 MINUTES, THEN IT STALLED OUT WHILE STILL IN PARK. IT TOOK SEVERAL TRIES TO RESTART IT. I FINALLY GOT IT GOING AGAIN AND IT PERFORMED OK ON THE 60 MILE HOME TRIP, SOME OF THAT AT INTERSTATE SPEEDS. THE NEXT DAY THE TRUCK WOULD NOT START AT ALL. IT WOULD CRANK, BUT NOT TURN OVER. THE SHOP I TOOK IT TO DID THE DIAGNOSIS AND IT TURNED OUT THAT IT WAS NOT BAD GAS OR A CLOGGED FUEL LINE. IT WAS A FAULTY FUEL CONTROL MODULE LOCATED ABOVE THE SPARE TIRE. THIS MODULE IS FLAWED NOT ONLY IN DESIGN BUT IN PLACEMENT AS WELL. IT IS NOT WEATHERPROOF AND NOT EVEN THE RIGHT TYPE OF METAL TO BE EXPOSED TO SALT, SAND AND WATER. IT HAS DISSIMILAR METAL FROM THE TRUSS IT MOUNTS TO, DISINTEGRATED OVER TIME AND I ALSO QUESTION FORD'S SUPPOSED FIX TO THE PROBLEM (SPACERS). HTTP:/

THE DRIVER'S SIDE WINDOW REGULATOR ON MY 2006 FORD F150 HAS BROKEN THREE TIMES, I WAS ABLE TO GET TWO REPLACED UNDER WARRANTY, BUT THE THIRD TIME HAPPENED THIS LAST MONTH, I AM REPLACING IT TODAY. I BELIEVE FROM MY EXPERIENCE, AND FROM THOUSANDS OF FORUM ENTRIES CITING THE SAME THING, THAT FORD SHOULD RECALL THIS PART. THIS PART IS GOING TO COST ME APPROXIMATELY $400.00 TO REPAIR. *TR