2006 Ford F-150 complaints

FORD F150 XLT 2006 SHOULD HAVE A MANDATORY SAFETY RECALL FOR THE FUEL CONTROL MODULE. THIS IS CLEARLY A DESIGN DEFECT AND A MAJOR SAFETY CONCERN. I WAS DRIVING DOWN VT116 (A HILLY, WINDING 2 LANE COUNTRY HIGHWAY WITH NO SHOULDER) IN THE RAIN AT ABOUT 40MPH WHEN MY TRUCK STARTED TO BUCK AND LOSE POWER. THERE WAS NO PLACE TO PULL OVER, SO I PUT MY HAZARDS ON AND TRIED TO LIMP IT TO A SAFE PLACE TO PULL OVER. THE ENGINE STALLED AND I LOST STEERING AND BRAKING POWER ON A CURVE. I APPLIED THE BRAKES MANUALLY AND WRESTLED THE STEERING WHEEL (WHICH NO LONGER HAD ANY POWER ASSIST). WITH MAJOR DIFFICULTY, I WAS ABLE TO BRING THE TRUCK TO A CONTROLLED STOP. I WAS THEN ABLE TO RESTART THE ENGINE, LIMPED ALONG AT 15MPH, BUCKING AND STALLING 3 MORE TIMES BEFORE GETTING TO A SAFE PLACE TO PULL OVER. THIS IS THE SECOND TIME I HAVE HAD MY FCM REPLACED (PRIOR WAS 1/5/2013) AND THE SECOND TIME I ALMOST CRASHED MY TRUCK BECAUSE OF THIS DEFECT. THE PREVIOUS TIME WAS JANUARY 2013 ON A MOUNTAIN ROAD IN WINTER ON SNOW. IF I WAS TOWING MY BOAT ON THE INTERSTATE AND LOST ALL POWER, I WOULD PROBABLY HAVE BEEN KILLED ALONG WITH ANYONE AROUND ME. WHY IS IT A DESIGN DEFECT? BECAUSE THIS ELECTRONIC COMPONENT IS INSTALLED IN A WEATHER-EXPOSED AREA ABOVE THE SPARE TIRE AND IS NOT CORROSION-PROOF. IN ANY RUST BELT STATE (OR A PLACE EXPOSED TO SALT), THE CASE WILL CORRODE, EXPOSING THE CIRCUIT BOARD TO WATER, CAUSING THE UNIT TO FAIL. WHY IS IT A SAFETY CONCERN? BECAUSE WHEN THE FCM FAILS, THE ENGINE WILL STA

TL* TAKATA RECALL. THE CONTACT OWNED A 2006 FORD F-150. WHILE DRIVING DURING INCLEMENT WEATHER (DOWNPOUR), THE VEHICLE HYDROPLANED AND FLIPPED OVER SEVERAL TIMES. THE VEHICLE ALSO WENT INTO A DITCH, WHICH IMPACTED THE FRONT AND REAR OF THE VEHICLE. THE STEERING WHEEL BENT IN HALF AND FRACTURED INTO THE ENGINE OFF OF THE MOUNTING BOLTS. NONE OF THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED BACK PAINS, HEAD INJURY, AND LEG PAINS, WHICH REQUIRED MEDICAL TREATMENT. THE VEHICLE WAS TOWED BY THE INSURANCE COMPANY WHO INDICATED THAT THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE INSURANCE COMPANY PROVIDED NO REASON AS TO WHY THE AIR BAGS FAILED TO DEPLOY. THE DEALER STATED THAT THERE WERE NO AIR BAG RECALLS. THE MANUFACTURER WAS NOTIFIED AFTER THE CRASH HAPPENED TO DETERMINE IF THEY MAY BE ABLE TO INVESTIGATE THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

MY ABS BRAKE SYSTEM FAILED. THE LIGHT FOR ABS CAME ON AND THE BRAKES FAILED TO INGAGE ON A DRY ROAD. I HAD TO VEAR OFF THE ROAD TO AVOID ANOTHER TRUCK MAKING A TURN. THIS HAPPENED AGAIN WITH A CAR INFRONT OF ME, BEFORE I GOT HOME AND PARKED THE TRUCK. THE BRAKES SHUTTER ON PRESSING THEM AND THEN FAIL TO INGAUGE. I HAD THE PROBLEM FIXED IN GOODYEAR AZ AT THE FIRD DEALER FOR OVER 800 DOLLARS AND NOW THE PROBLEM BEGAN AGAIN. I LIVE IN LAKESIDE ARIZONA AND CANT DRIVE THE TRUCK BACK TO THAT DEALER WITHOUT FEAR OF DYING ON THE SIDE OF A CLIFF IR IN A BAD ACCIDENT BECAUSE MY BRAKES FAIL TO STOP THE VEHICLE AND BRAKES ARE NEEDED TO GO THROUGH THE MOUNTSINS TO GET TO THAT DEALER. VERY UPSET THAT I BOUGHT THIS TRUCK FROM CACTUS JACKS IN PHOENIX AZ. 560 DOLLARS A MONTH FOR A TRUCK I CANT DRIVE FOR MY SMALL FARM. I WOULD LIKE TO TRADE IN TBIS TRUCK FOR ONE I CAN TRUST THAT WONT BE THE DEATH OF ME OR MY FAMILY.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 45 MPH, THE FRONT OF THE VEHICLE SHOOK VIOLENTLY, THE ENGINE NEARLY STALLED AND LOST POWER REPEATEDLY, AND THE CHECK ENGINE INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE ALSO BRAKED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN UNCERTIFIED MECHANIC WHO DIAGNOSED THAT THE ENGINE WAS HAVING MULTIPLE MISFIRES, AND DID NOT KNOW HOW TO REPAIR THE VEHICLE. THE CONTACT ALSO CALLED A DEALER WHO WAS EXTREMELY RUDE AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS INFORMED THAT THEY WOULD NOT ASSIST BECAUSE THE CLAIMS DEADLINE HAD BEEN MISSED. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE AIR BAG WARNING LIGHT ILLUMINATED. THE WARNING LIGHT FLICKERED INTERMITTENTLY AND THEN REMAINED ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

FUEL PUMP CONTROL MODULE CORROSION CAUSING ENGINE TO STALL AND NOT RESTART WHILE DRIVING ON SECONDARY ROAD. *TR

TL* THE CONTACT OWNED A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 5 TO 6 MPH AND TURNING LEFT, THE VEHICLE SLID ON WET PAVEMENT AND CRASHED INTO A WALL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT WAS INJURED AND REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

WAS DRIVING MY 2006 F-150 OVER A MOUNTAIN PASS IN CANADA. THERE WAS COMPACT SNOW AND ICE ON THE ROADWAY AND I WAS TRAVELING WITH OTHER VEHICLES AROUND ME AT APPROXIMATELY 40 MPH. THE VEHICLES AHEAD OF ME BEGAN TO BRAKE, I AS WELL TRIED TO BRAKE ONLY TO FIND MY TRUCK HAD LOST POWER AND WAS NO LONGER RUNNING. I HAD LOST POWER TO MY BRAKES AND STEERING. THIS CAUSED MY TRUCK TO BEGIN SLIDING ON THE SNOW AND ICE AND I WAS UNABLE TO CONTROL MY VEHICLE. THE CARS AROUND ME WERE SLOWING AND STOPPING AND I COULD NOT. I BEGAN TO FISH TAIL IN BOTH DIRECTIONS WHILE TRYING DESPERATELY TO CONTROL MY TRUCK WITH NO BRAKES OR POWER STEERING, I EVENTUALLY DID A COMPLETE 360 DEGREE SPIN AND SOMEHOW MANAGED TO GET THE TRUCK UNDER CONTROL WITH OUT ROLLING OVER AND INTO THE DITCH OR SMASHING INTO THE OTHER VEHICLES AROUND ME. WHEN I CAME TO A STOP MY TRUCK WAS NOT RUNNING AND THE DASH LIGHTS WERE ON. I PLACED THE TRANSMISSION INTO DRIVE AND RESTARTED THE TRUCK WITHOUT ISSUE AND CONTINUED ON WITHOUT ISSUE. THIS IS THE SECOND TIME THIS HAS HAPPENED WITH THIS TRUCK, THE FIRST TIME I WAS ON A RESIDENTIAL STREET AND I WAS ABLE TO JUST COAST TO A STOP AND RESTARTED THE TRUCK. THIS LAST INCIDENT ON THE MOUNTAIN PASS HAS CONFIRMED TO ME THAT I WILL NOT OWN ANOTHER FORD AS I HAVE RESEARCHED THIS PROBLEM TO FIND THAT THIS IS A COMMON ISSUE WITH FORD TRUCKS. I AM CERTAIN THIS HAS CAUSED MAJOR ACCIDENTS IF NOT DEATHS AND THE FACT THERE ARE NO ERROR CODES LEFT BEHIND FROM THE EVENTS TO VERIFY THIS HAS HAPPENED

TL* THE CONTACT OWNS A 2006 FORD F-150. AFTER TAKING THE VEHICLE TO A DRIVE THRU CAR WASH SERVICE, WATER ENTERED THE PASSENGER SIDE. THE INTERIOR OF THE PASSENGER SIDE BECAME WET AND THE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

I WAS DRIVING ON THE ROAD WHEN THE "ENGINE FAILSAFE WARNING' LIGHT CAME ON. THE ENTIRE ENGINE SHUT DOWN. NO POWER AT ALL. VERY HARD TO STOP AND STEER. I NEARLY GOT INTO AN ACCIDENT. ANOTHER TIME I WAS ENTERING PARKING LOT WHEN IT HAPPENED. I HAD THE THROTTLE BODY REPLACED TO FIX THE PROBLEM. BUT SHUTTING OFF THE ENGINE ON A WARNING WHILE DRIVING IS VERY DANGEROUS. SOME INTERNET RESEARCH INDICATES THIS IS NOT A LONE OCCURRENCE.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WOULD SHOOK WHENEVER THE VEHICLE WAS IDLING. THE SHAKING INCREASED DURING ACCELERATION. THE CONTACT TOOK THE VEHICLE TO A DEALER WHO WAS UNABLE TO IDENTIFY THE CAUSE OF THE FAILURE, BUT INFORMED THE CONTACT THAT THE SHAKING WAS A COMMON ISSUE WITH THE YEAR, MAKE, AND MODEL. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

TOOK TRUCK IN FOR ROUTINE 100,000 MAINTENANCE AND TUNE UP. SPARK PLUG STUCK IN THE CYLINDER HEAD AND ENDED UP GETTING CHARGED $3,500 FOR THE REPAIR. I AM READING ONLINE OF HOW WIDESPREAD THIS PROBLEM IS AND FORD SHOULD RECALL THESE SPARK PLUGS AND TAKE CARE OF THEIR CUSTOMERS. I WILL NEVER PURCHASE ANOTHER FORD IN MY LIFETIME IF THEY DON'T DO SOMETHING ABOUT THIS.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 8 MPH, THE VEHICLE STALLED WITHOUT WARNING AFTER A SHARP RIGHT TURN. THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO BE REPAIRED, BUT THE ISSUE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 158,818.

POWER STEERING HOSE RUST AND LEAKING-TRANSMISSION HOSES RUSTED AND LEAKING - SPARK PLUG BREAKING OFF WHEN HAVING THEM REPLACED

WAS SITTING AT A RESTAURANT DRIVE THRU WITH FOOT ON THE BRAKE WHEN THE BRAKE PEDAL SUDDENLY WENT TO THE FLOOR AND THE TRUCK STARTED MOVING. I WAS ABLE TO GET THE VEHICLE HOME AND BACK TO THE FORD DEALERSHIP THE NEXT MORNING VERY CAREFULLY AND BY PUMPING THE BRAKES TO GET THE VEHICLE TO STOP. WAS TOLD THAT THE BRAKE LINE HAD RUPTURED. LUCKILY, I WAS NOT TOWING MY 6000 POUND BOAT OR GOING DOWNHILL AT THE TIME OF THE FAILURE. I ASKED IF THIS WAS COMMON SINCE BRAKE LINES ARE NOT AN ITEM THAT ARE ROUTINELY INSPECTED OR REPLACED ON A NORMAL 17 POINT INSPECTION. I WAS TOLD THAT IT WAS UNCOMMON. I GOOGLED THE PROBLEM AND DISCOVERED THAT SEVERAL OTHER FORD F150 OWNERS OF VARIOUS MODEL YEARS HAD EXPERIENCED THE SAME ISSUE. LUCKILY, THERE HAVE BEEN NO REPORTS OF DEATHS OR SEVERE INJURY, BUT I AM REPORTING THIS TO HOPEFULLY PREVENT A DEATH FROM OCCURRING.

VEHICLE JERKED WHEN DRIVING DOWN HIGHWAY WHEN YOU REACH 45 TO 50 MPH. I WOULD LET OFF GAS AND THEN GIVE IT GAS AGAIN AND IT WOULD NOT JERK. CHECK ENGINE LIGHT APPEARED SO I TOOK IT TO FORD DEALERSHIP AND THEY RUN A CHECK . TOLD ME I NEED ANOTHER MOTOR. THIS TRUCK HAS 154000MILES. IT HAS NOT OVERHEATED.

I JUST HAD MY TRUCK SERVICED AT SAYVILLE FORD & THEY FOUND TWO BROKEN FRONT SPRINGS. THE TRUCK HAS 142000 MILES. I CANT FIND ANY RECALL INFO ON NHTSA. CAN YOU ADVISE ME IF THIS IS A CURRENT PROBLEM BEING INVESTIGATED?

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 15 MPH, THE VEHICLE MADE A LOUD POPPING NOISE AND THE INSTRUMENT PANEL BECAME INOPERABLE. IN ADDITION, THE REAR WINDOWS AND POWER LOCKS FAILED TO OPERATE AND THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 55 MPH, TWO DEER JUMPED IN THE MIDDLE OF THE ROAD. THE CONTACT SLAMMED ON THE BRAKE PEDAL TO AVOID THE ANIMALS. AS A RESULT, THE VEHICLE DROVE INTO A DITCH AND ROLLED OVER THREE TIMES. NONE OF THE FRONTAL AIR BAGS DEPLOYED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS TOWED AND WAS BEING EVALUATED BY THE INSURANCE COMPANY. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.

TOOK IN FOR A TUNE UP. BROKE OFF 7 SPARK PLUGS. GOT PIECE IN ENGINE. HAD TO TAKE ENGINE APART. TUNE UP WAS TO BE $535. NOW IT IS $2300.00

AFTER COUNTLESS HOURS SPENT DIAGNOSING A DASH BRAKE LITE WARNING. THESE VEHICLES FACTORY DEFECT IS THE ELECTRONICS BOARD OR SPEEDOMETER CLUSTER. COUNTLESS PEOPLE ARE DRIVING WITH A BRAKE LIGHT ON WITH NOTHING POSSIBLY WRONG.WHEN SOMETHING DOES GO WRONG THEY MAY NOT HAVE A CLUE UNTIL THE VEHICLE HAS NO BRAKES.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE THE VEHICLE WAS PARKED WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE SPONTANEOUSLY ACCELERATED WHEN PLACED IN REVERSE. THE ACCELERATION LASTED FOR APPROXIMATELY 30 SECONDS. THE FAILURE RECURRED, BUT WHILE IN FORWARD GEAR APPROXIMATELY THREE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 31,000.

ON NOVEMBER 16,2011 I WAS ON MY WAY TO SEE MY MOTHER WHO PASSED AWAY AND WHILE DRIVING IT SOUNDED LIKE A BOMB WENT OFF AND I HAD VEHICLE TOWED AND IT WAS SPARK PLUG ISSUE, THEN TWO YEARS LATER IT HAPPENED AGAIN, I CHANGED ON PLUGS AND COIL PACKS AT GARAGE, NOW TWO YEARS LATER ANOTHER 3RD PLUG BREAKS INTO ENGINE, NOW IN NEED OF NEW ENGINE. MILES ARE OVER CLASS ACTION SUIT BUT NOT BY MANY. MY TRUCK IS WORTHLESS FOR FORDS LACK OF FIXING THIS ISSUE. I DO HAVE DOCUMENTS TO SHOW. THIS PROBLEM IS A REPEATED ISSUE AND END RESULT FOR THEM NOT TO RECALL ISSUE SOONER HAS ENDED WITH A NONE WORKING TRUCK ENGINE.

STEERING BECAME INTERMITTENTLY STIFF WHILE DRIVING. TRUCK HAD ABOUT 80000 MILES ON IT AND 9 YEARS OLD WHEN SYMPTOMS STARTED. STIFFNESS WOULD OCCUR SOMETIMES AT HIGHWAY SPEEDS WHEN I STARTED A LANE CHANGE, AND AT SLOW SPEEDS WHEN I WAS TURNING (FOR INSTANCE ON COMMUNITY STREETS). AS I WAS TURNING IT WOULD CYCLE FROM HARD TO REGULAR EFFORT, AS WOULD BE IF A UNIVERSAL JOINT WAS GOING BAD. MY NON-FORD MECHANIC DIAGNOSED IT AS A BAD LOWER STEERING SHAFT. I INSPECTED THE BAD SHAFT AND AGREED THAT ONE UNIVERSAL SHAFT WAS TIGHT AND THE OTHER WAS EXTREMELY TIGHT. $557 REPAIR.

TRUCK HAS ~116000 MILES. ENGINE RANDOMLY DIES WHILE IN MOTION (15 - 50 MPH) AND WHILE IDLING AT A STOP. NO POWER BRAKES OR STEERING UNTIL ENGINE IS RESTARTED. HAS OCCURRED DRIVING DOWN THE HIGHWAY AND IN THE CITY. MAINLY OCCURRED GOING STRAIGHT (NOT TURNING). IMMEDIATELY RESTARTS. NO ENGINE CODES OR CHECK ENGINE LIGHT. CAUSE UNKNOWN. THROTTLE BODY REPLACED WITHOUT FIXING CONDITION. "WRENCH" SYMBOL ON DRIVER DISPLAY HAS BEEN ON FOR A WHILE BUT CONDITION JUST STARTED.

ON 3 OCCASIONS MY VEHICLE ,OVER 4 MONTHS, HAS HAD A COMPLETE ENGINE FAILURE. THIS OCCURRED MOST RECENTLY WHILE I WAS EXITING THE INTERSTATE .WHEN THE ENGINE SHUTS DOWN SO DOES THE DASH AND BRAKE LIGHTS, IT ALSO STOPS POWER STEERING AND BRAKES. THIS TIME BY REACTING QUICKLY I WAS ABLE TO PUT THE VEHICLE IN NEUTRAL AND RESTART ,AFTER TURNING KEY TO OFF POSITION FIRST.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO LATCH THE FRONT DRIVER'S SEAT BELT. WHEN DRIVING ALONE, THE CONTACT WOULD LATCH HIS SEAT BELT INTO THE PASSENGER SIDE BUCKLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

THE STEERING WHEEL FREEZES UP IN COLD WEATHER. MY MECHANIC DIAGNOSED A FAILED LOWER STEERING COLUMN THAT IS EXPOSED TO ROADWAY SPLASH AND CORROSION. THIS IS ALSO A TELESCOPING SECTION OF THE STEERING COLUMN DESIGNED TO PROTECT THE DRIVER IN CASE OF FRONTAL CRASH. SO OVERNITE IT FREEZES UP AND SLOWLY LOOSENS. WHILE DRIVING BECOMES STIF AND RESULTS IN DIFFICULT STEERING. 45,000 MILES ON ODOMETER.

DROVE F-150 NORMALLY DURING WEEK. ON WEEKEND MORNING WHILE PULLING OUT OF DRIVEWAY STEERING WHEEL SUDDENLY AND SPORADICALLY BEGAN RESISTING EFFORT TO TURN CAUSING TRUCK TO SWAY UNPREDICTABLY DURING TURNS. RESISTING DRIVER INPUT. WAS TOO DANGEROUS TO DRIVE. AFTER REVIEWING BLOGS ONLINE I REALIZED A LOT OF OTHER PEOPLE WHO DRIVE THIS ERA F-150 HAVE THE SAME PROBLEM. IT TURNS OUT THE LOWER STEERING COLUMN SHAFT CONTAINING THE U-JOINTS USES DEFECTIVE MATERIALS OR HAS BAD DESIGN. THE U-JOINTS ARE BINDING UP DURING DRIVING CAUSING THE DRIVER TO LOSE PARTIAL CONTROL OVER DIRECTION OF VEHICLE. TEMPORARY FIX MAY BE TO SPRAY WITH ANTI-CORROSIVE SPRAY, THEN LUBRICATING SPRAY, WHICH I DID. THIS LASTS ONLY A SHORT TIME SO THE LOWER SHAFT WITH U-JOINTS MUST BE REPLACED. FORD KNOWS OF THE DEFECT FOR THIS ERA F-150 AND HAS REDESIGNED THIS LOWER SHAFT TO ELIMINATE THE BINDING. THIS NEW DESIGN IS WHAT THEY SELL YOU AS A REPLACEMENT, NOT THE ORIGINAL DESIGN. IF YOU TRY TO BUY ONE ONLINE IT COSTS AT LEAST $245 FOR THE O.E.M. PART. IF YOU BUY ONE OF THE 2 AFTERMARKET KNOCKOFFS IT'LL SET YOU BACK APPROX $125. THE AFTERMARKET SHAFT ADVERTISING TOUTS THE FACT THAT IT HAS A DESIGN THAT WILL NOT BIND LIKE THE ORIGINAL FORD SHAFT DOES. THIS TRUCK HAD APPROX 69,700 MILES ON IT WHEN THE SHAFT BEGAN BINDING UP.

I HAVE A 2006 F-150 V8 4.6 THE HEATER COIL IN THE TRUCK HAS FAILED. AND THE WATER PUMP ALSO

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE REAR PASSENGER AND DRIVER WINDOWS WERE LEAKING DURING INCLEMENT WEATHER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

LAST WEEK I STARTED NOTICING MY STEERING STARTING TO GET STIFF AND THE WHEEL DOES NOT RECENTER AFTER A STEER TO THE LEFT OR RIGHT. IVE HAD TO DO SOME QUICK MUSCLING TO RECENTER THE WHEEL. I'VE JUST FINISHED RESEARCHING SOME OTHER FORD FORUMS FOR THIS VEHICLE AND MANY OWNERS HAVE REPORTED THE SAME ISSUE WITH THE U JOINTS ON THE STEERING COLUMN RUSTING OR SEIZING. I WILL TRY SPRAYING SOME ANTI SEIZE ON THE U JOINTS TOMMOROW UNTIL I CAN GET IT TO A GARAGE.MY TRUCK HAS APPROXIMATELY 103,000 MILES ON IT . THIS IS DANGEROUS AND WITH THE AMOUNT OF COMPLAINTS ON THIS IT SHOULD BE RECALLED BY FORD TO CORRECT.

LAST WEEK TRUCK SUDDENLY BECAME VERY HARD TO TURN GOING AROUND CORNERS. STEERING WHEEL LOCKED UP AND I ALMOST WENT OVER AN EMBANKMENT. HIT OR MISS SO I NEVER KNOW WHEN IT WILL GO OUT. THANKFULLY DID NOT HAVE MY 2 YOUNG CHILDREN! A WEEK LATER (11/29/15), TRUCK SUDDENLY STARTS TO VIOLENTLY SHAKE IF I GO OVER 50 MPH! SCARED THE DICKENS OUT OF ME! HOPING TO LIMP IT TO A DEALERSHIP AND TRADE IT IN. NOT SAFE FOR ME TO DRIVE. I HAVE PUT 20K MILES ON IT IN 2 YEARS AND HAS BEEN REGULARLY SERVICED. WHAT GIVES?!?

MY STEERING STARTED TO BIND WHILE DRIVING . COULD NOT MAKE FULL RIGHT OR LEFT TURNS. VERY UNSAFE. THE TRUCK HAS LEFT THAN 30,000 MILES. RARELY DRIVEN.

WHILE DRIVING INSTRUMENT PANAL SHUTS DOWN, RADIO SHUTS OFF, AIRBAG INDICATOR COMES ON, WINDOWS DON'T WORK, IF SHUT OFF LASTS MORE THAN 5 MINUTES SEAT BELT CHIME GOES OFF, TWICE WORD TEST CAME ON IN MILEAGE INDICATOR WINDOW. SOMETIMES GOES ON AND OFF WHILE TURNING OR HITTING BRAKES, OTHER TIMES JUST WHILE DRIVING.

CYLINDER #4 BLEW THE SPARK PLUG OUT, STRIPPING THE THREADS AS IT WENT. THIS IS THE 2ND CYLINDER TO DO THIS IN 6 MONTHS. WHILE DRIVING AT 45 MPH.

WHILE MY VEHICLE WAS IN THE SHOP FOR A FOUR WHEEL ALIGNMENT THE MECHANIC NOTED THAT THE U-JOINT IN INTERMEDIATE STEERING SHAFT IS GOING BAD AND THEREFORE THE REASON THERE IS SOME PLAY IN THE STEERING WHEEL. COST TO REPAIR IS GOING TO BE APPROXIMATELY $700

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE BRAKE PEDAL EXCESSIVELY ABNORMALLY TRAVELED TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS INFORMED THAT THE VEHICLE WAS FUNCTIONING AS DESIGNED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200. UPDATED 1/12/2016 *CN THE CONSUMER STATED WHEN HE ATTEMPTED TO BRAKE, HIS FOOT ALSO HIT THE ACCELERATOR PEDAL. THE CONSUMER STATED THE BRAKE AND ACCELERATOR WERE TOO CLOSE TOGETHER. UPDATED 05/04/16

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 35 MPH AND COMING TO A COMPLETE STOP, THE REAR DRIVER SIDE TIRE SEPARATED AND ROLLED INTO TRAFFIC. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR ROTOR AND STUDS FAILED AND NEEDED TO BE TIGHTENED. THE CONTACT ALSO STATED THAT HE HAD TO ALSO REPLACE THE STEERING RACK AND PINION DUE TO THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.

SPARK PLUGS ON THE 5.3 LITER ENGINE WHEN REPLACED BREAK--IN RETURN THE BOOK SAID PULL ENGINE AND PULL HEADS TO REPLACE SPARK PLUGS. THE LAW SUIT FILLED FORD ADMITS TO BAD DECISION ON SPARK PLUGS AND WILL REIMBURSE SOME OF THE COST. THE COST IS VERY HIGH--THE BOOK AND FORD'S SHOP SAID THE ENGINE NEEDS TO BE PULLED TO PULL THE HEADS TO REPLACE THE SPARK PLUGS. THERE WAS NEVER ANY SOFTWARE UPDATES, AND NOW THE VEHICLE REQUIRES THEM. THE ERROR IN THE CLUSTER SOFTWARE RECALL WAS SUPPOSE TO BE REPAIRED AND I READ FROM THE EXPERTS ALL SOFTWARE SHOULD HAVE BEEN UPGRADED WITH THE CLUSTER ERROR. THERE ARE 42 P.M. FORD AND NHSTA KNEW OR KNOWS ABOUT ON MY VEHICLE AND NOTHING HAS BEEN DONE, I AM A 100% DAV AND MY VEHICLE HAS BEEN BROKEN DOWN. THE 2006 HARLEY DAVIDSON F-150 THAT COST SO MUCH WITH IT'S ON BOARD COMPUTER SYSTEM DOES NOT WORK. I HAVE READ MANY COMPLAINTS ABOUT THE F-150 ENGINE CUTTING OUT, I PULLED OUT TO PASS ON A TWO LANE ROAD AND ALMOST GOT KILLED WHEN MINE CUT OUT SO BAD. A TWO CYLINDER WOULD HAVE DONE BETTER THAN THAT V-8.

FACTORY WELDS ON WHEELS FAILED CAUSING RAPID LOSS OF TIRE PRESSURE. THIS HAS HAPPENED TWO DIFFERENT TIMES ON TWO DIFFERENT WHEELS.

ORIGINALLY FACTORY INSTALLED SPARKPLUG BLOWS OUT OF THE ENGINE HEAD TRAVELING AT APPROXIMATELY 35 MPH. THIS WAS DISCLOSED AFTER TAKING VEHICLE TO A FORD DEALERSHIP FOR DIAGNOSTICS AS THERE WAS A LOUD NOISE WHILE ENGINE RUNNING AND LOSS OF POWER. REPAIR COST WAS $617. DISCUSSION WITH DEALER DISCLOSES THAT THIS A WELL KNOW PROBLEM BY FORD MANAGEMENT, A TBS HAS BEEN ISSUED. FURTHER FORD HAS DENIED ANY RESPONSIBILITY AND WILL NOT PROVIDE ANY MONETARY ASSISTANCE. THIS IS A FORD CREATED DESIGN ENGINEERING DEFECT THAT FORD JUST IGNORES AND LET'S THE CUSTOMER PAY FOR ITS MISTAKE. CUSTOMER IS SUBJECT TO COST OF REPAIR THAT IS FAR FROM NORMAL WEAR AND TEAR, A SAFETY CONCERN OF FIRE IN ENGINE COMPARTMENT FROM RAW FUEL BLOWN OUT OF THE HOLE VACATED BY SPARKPLUG, A RELIABILITY ISSUE AND A SAFETY CONCERN FROM SUDDEN LOSS OF POWER. THIS PROBLEM SHOULD BE COVERED BY A FEDERAL MANDATED RECALL SINCE FORD IS MAKING THIS A CONSUMER PROBLEM IGNORING THE FACT THAT IT IS A ENGINEERING, DESIGN OR MANUFACTURING PROBLEM FOR WHICH IT REFUSES TO ACCEPT RESPONSIBILITY. IN ADDITION THE TRADE IN VALUE OF THIS VEHICLE WILL BE REDUCED BY THE FORD DEALERSHIP THAT IS AWARE OF THE PROBLEM EVAN FOR THE CUSTOMER THAT DID NOT ENCOUNTER A SPARKPLUG BLOWOUT AND AT PRIVATE SALE IF PROSPECTIVE BUYER CHECKS ON VEHICLE VIA ANY INTERNET AUTOMOTIVE SITE. AGAIN FORD LETS CONSUMER ABSORB COST OF DEFECT IT CREATED.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO A MECHANIC WHERE IT WAS DISCOVERED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER THE VEHICLE WAS REPAIRED, THE FAILURE CONTINUED WITH A TICKING NOISE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

IN JUNE 2015, THE AIR BAG LIGHT IN MY FORD F150 ILLUMINATED, INDICATING A PROBLEM. I TOOK MY VEHICLE TO A FORD DEALERSHIP. THEY TOLD ME THAT THE DEPLOYABLE RESTRAINT SYSTEM, SPECIFICALLY THE PRETENSIONER, HAD MALFUNCTIONED AND POSSIBLY WOULD FAIL TO FUNCTION AS INTENDED IN THE EVENT OF A CRASH. THE SERVICE TECHNICIAN INDICATED THAT THE RESTRAINT SYSTEM IS CONNECTED TO MY AIR BAGS, WHICH MIGHT FAIL TO WORK IN A CRASH, INCREASING THE RISK OF INJURY. AFTER PAYING THE DIAGNOSTIC FEE, I WAS GIVEN A REPAIR ESTIMATE OF AN ADDITIONAL $392.21. NOT WANTING TO RISK INJURY IN THE EVENT OF A CRASH, I HAD THE PRETENSIONER REPLACED. THE BUCKLE PRETENSIONER IS A CRITICAL SAFETY DEVICE THAT SHOULD NEVER FAIL UNDER NORMAL USE. MY VEHICLE HAS NEVER BEEN IN AN ACCIDENT. IT IS MY UNDERSTANDING THAT SOME PRETENSIONERS HAVE FAILED DUE TO SIMPLE SEAT POSITION ADJUSTMENTS, WHICH, TO ME, IS EVIDENCE OF A POOR DESIGN. FORD HAS RECENTLY RECALLED MANY 2013 ' 2014 VEHICLES FOR POORLY MADE PRETENSIONERS, RECOGNIZING THE SAFETY ISSUE SURROUNDING THEM. I REQUESTED THAT FORD REIMBURSE ME FOR THE COST OF THE PRETENSIONER BUCKLE; HOWEVER, FORD DENIED THIS REQUEST. I HAVE THE ORIGINAL PRETENSIONER AND ALL RECEIPTS AVAILABLE.

MORNING OF JULY 23,2015, I WAS DRIVING ABOUT 25 MPR SPEED WHEN NUMBER THREE SPARK PLUG BLOW OUT OF THE CYLANDERHEAD ON MY F-150 TRITON V8. TOOK IT TO THE LOCAL MACHANIC SHOP WALTON'S. THREE HOURS LATER, WALTON'S HAD TO REPLACE AND RESLEEVE NUMBER THREE CYLANDERHEAD AND REPLACED ELECTRICAL SPARKPLUG WIRE, PLUS REPLACED ALL EIGHT SPARK PLUGS. ALL AT A COST OF $543.00. NOT ONLY THIS HAPPENED TO ME BUT WALTON'S STATED THAT I WAS THE 10TH PERSON THIS WEEK THIS HAS HAPPENED TOO. I PRESENTED THE PART TO MY LOCAL FORD DEALERSHIP WHERE WE BOUGHT THE TRUCK (HALL'S FORD MOTOR COMPANY) BRAND NEW IN 2006 AND PAID CASH TO THE SUM OF $30,000.00. I ASKED THEM IF THEY KNOW OF THIS PROBLEM WITH TRITON V8'S. THEY STATED THEY DID BUT NO KNOW RECALLS AND THEY TOO HAD SEVERAL REPAIRS COME IN FOR THE SAME THING IN THE PASS WEEK. THEY ALSO STATED THAT THE FORD MOTOR COMPANY WAS AWARE OF THIS MATTER BUT NEVER LET THERE CUSTOMERS KNOW ABOUT THIS PROBLEM YET BECAUSE THERE WAS NO RECALL ON FILE TO LET THEM KNOW. THIS THING WHERE THE SPARK PLUGS COME FLYING OUT OF AN ENGINE CAN BE VERY HAZARDS, IT COULD CAUSE A CRASH OR EVEN GIVE A PERSON A HEART ATTACK BECAUSE THE TRUCK SOUNDS LIKE WORLD WAR III GOING OFF UNDER THE HOOD AND IT MAY EVEN START A FIRE. THIS MATTER NEEDS TO BE TAKEN CARE OF BY FORD.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE. WHILE AT THE INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT SEVEN OF THE EIGHT SPARK PLUGS IN THE VEHICLE WERE FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONE OF THE FRACTURED SPARK PLUGS REMAINED IN THE CYLINDER HEAD. THE MECHANIC STATED THAT THE CYLINDER HEAD HAD TO BE REMOVED FROM THE ENGINE TO REMOVE THE FRACTURED SPARK PLUG. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE; HOWEVER, THE CONTACT WAS NOT OFFERED A REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT 20 MPH, THE BRAKES AUTO ENGAGED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 09/03/15*LJ UPDATED 10/26/2017*CN

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME TIGHT AND LOOSENED UP AT RANDOM TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE DRIVESHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO SHIFT THE GEAR INTO DRIVE OR REVERSE, ONLY NEUTRAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CLUTCHES AND BANDS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,854. UPDATED 7/16/15*CN THE CONSUMER STATED THE TAIL SHAFT HOUSING HAD A HAIRLINE FRACTURE/CRACK WITH. THE REPAIRMAN BELIEVED THE PART WAS DEFECTIVE. THERE WAS NO WEAR ON THE INSIDE OF THE TRANSMISSION, BEARING OR SEALS. UPDATED 08/04/15*JB

WHILE IN PASSING LANE OF THREE LANE WEST BOUND ROUTE 3 ENGINE SHUT DOWN, HAD TO NEGOTIATE TWO LANES OF HIGHWAY TRAFFIC TO GET TO SHOULDER WHILE COASTING. VEHICLE TOWED TO REPAIR SHOP. FUEL PUMP CONTROL MODULE FAILURE. MODULE CORRODED, HOLES THRU BACK OF MODULE WHERE IT MOUNTS TO FRAME. *TR