2001 Ford F-150 complaints

THE CONSUMER STATES THAT THE DISCRIPTION ON THE WINDOW OF CAR WHEN PURCHASED, SAID THE TIRES SIZE WAS P275/70R17 AND THE TIRES ON THE VEHICLE IS P275/60R17 WHICH CAUSES TIRE TO WEAR DOWN FASTER. *JB THE TIRES THAT CAME EQUIPPED WITH THE VEHICLE ARE SMALLER THAT WHAT THE WINDOW STICKER INDICATED, THE TIRES ARE NOT WEARING CORRECTLY AND THE CONSUMER FEELS THAT THE VHEICLE IS NOT SAFE TO DRIVE. *SCC

ABS BRAKE FAILURE. *AK

TIRE SIZE P26575R16; MODEL FIRESTONE STEEL TEX R4S LOAD RANGE E; WHILE GOING UP A SLIGHT ENGRADE TOWING A TRAILER, TRUCK BEGAN TO SWAY FOLLOWED BY A VIBRATION. VEHICLE THEN COLLAPSED ON THE RIGHT SIDE. WHEEL WELL AND RIM WERE DAMAGED. TOWED TO DEALER ,AND WAS INFORMED THAT TIRE TREAD BECAME LOOSE.*AK

VEHICLE "DOGS" DOWN (LOSS OF POWER) WHEN TURNING RIGHT. ONLY WHEN YOUR TURNING A CORNER AT LOW SPEED DOES THE ENGINE STALL. NUMEROUS COMPLAINTS AND REPLACED PARTS HAVE NOT FIXED THE SITUATION.*AK

WHILE VEHICLE WAS DOWNSHIFTING TRANSMISSION WAS MAKING A NOISE . VEHICLE WAS SERVICED. CONSUMER IS NOW ON THIRD TRANSMISSION. PLEASE PROVIDE FURTHER INFORMATION.*AK

HAVE HAD PROBLEMS WITH THIS VEHICLE AT 1900 MILES. SUSPENSION, FUMES, BRAKES, SIGNAL SWITCH, ELECTRICAL SHORTAGES.

WHEN ENGAGING AUTOMATIC DOOR LOCKS, THEY COME DOWN. IF PASSENGER OR DRIVER HAS ARM OVER LOCK,ARM GETS PINCHED AND BRUISED. PLEASE PROVIDE ANY FURTHER INFORMATION.*AKI

WHILE DRIVING UP A HILL FRONT RIGHT TIRES SNAPPED OFF. DEALER NOTIFIED. SIZE ,/DOT UNKNOWN. PLEASE PROVIDE FURTHER INFORMATION. *AK

A SHORT IN WIRING CAUSING HORN TO GO OUT WHILE DRIVING. DEALER NOTIFIED.*AK

CONSUMER STATES THE WIPERS WORK INTERMITTENTLY IN BAD WEATHER CONDITIONS. THE PROBLEM HAS PROGRESSED FOR OVER 9 MONTHS. DEALER CONTACTED. PLEASE PROVIDE MORE INFORMATION.*JB

WHILE BACKING INTO DRIVEWAY SPARE TIRE CABLE BROKE UNDERNEATH THE VEHICLE. DEALER AND MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. *AK *YH

CONSUMER WAS BACKING OUT OF THE DRIVEWAY, STEPPING ON ACCELERATOR WHICH WAS STIFF, CONSUMER STEPPED ON IT HARDER WHICH PROMPTLY FLOORED AND STUCK. CONSUMER HAD TO SHIFT INTO NEUTRAL TURNING THE KEY OFF AND HAD TO UNSTICK ACCELERATOR BY HAND. THIS VEHICLE HAS HAD THE ACCELERATOR TO STICK TWICE AFTER THE INITIAL INCIDENT. FORD WAS AWARE OF THE PROBLEM AND SAID IT WAS A COLD WEATHER MOISTURE PROBLEM. VEHICLE HAS BEEN FIXED, BUT BECAUSE THERE WASNO COLD WEATHER AT THIS TIME CONSUMER WAS NOT SURE. *JG ....*AK

CONSUMER STATES THAT THERE ARE FUMES COMING FROM THE A/C MAKING THE CONSUMER SICK. CAUSE UNKNOWN. DEALER NOTIFIED.*JB

I WAS GOING DOWN HIGHWAY 111 IN RANCHO MIRAGE, CA WHEN A DRUNK DRIVER RAN A RED LIGHT. I SLAMMED INTO HER DRIVERS SIDE DOOR HEAD ON 1989 FORD CROWN VICTORIA WITH MY 2001 FORD F-150 CREW CAB TRAVELING AT APPROXIMATELY 35 TO 45 MPH. NEITHER PASSENGER OR THE DRIVERS AIR BAGS WORKED. MY FIANCEE AND I BOTH SUFFERED INJURIES THAT I BELEIVE COULD HAVE BEEN AVOIDED HAD THE AIR BAGS WORKED. AS A RESULT OF THIS ACCIDENT MY NEW TRUCK WAS CONSIDERED A TOTAL LOSS.*AK

A SCRAPING SOUND FROM THE RIGHT REAR WAS NOTICED AT 31,000 MILES. INFORMED DEALER OF NOISE, SOUNDED LIKE BRAKES SCRAPPING. DEALER SAID BRAKES WERE FINE. 51,000 MILES NOISE TURNED INTO A WINING SOUND. DEALER SAID IT WAS A NON-RELATED SOUND. FORD REFUSED TO HONOR WARRANTY FOR MIS-DIAGNOIS DURING WARRANTY PERIOD. DEALER DID NOT GIVE ANY FURTHER ADVISE NOR RECOMMENDATIONS AT 31,000 MILES. FORD SAID A WHEEL BEARING CHECK WAS NOT DONE AT 30,000 MILES. DEALER TECH SAID AXEL WAS OUT OF FACTORY TOLLERANCE WAS CAUSE. REPAIR COST WAS $3,500.00. I DID NOT KNOW WHAT MADE THE NOISE , I WAS DESCRIBING THE NOISE AS POSSIBLE BRAKES, BUT NOW FORD SAYS THAT IS WHAT I ASKED THEM ONLY TO LOOK AT. THAT IS NOT TRUE, I SAID IT IS MAKING A NOISE , SOUNDS LIKE THE BRAKES, THEY SHOULD HAVE DROVE IT RATHER THAN JUST LOOKING AT THE BRAKES. THEY SAID IT WAS FINE THEN, NOW THEY SAY I SHOULD HAVE BROUGHT IT BACK IF THE NOISE WAS STILL THERE. I DID NOT AS THEY SAID IT WAS OK. WHEN IT STARTED GRINDING , I THEN BROUGHT IT BACK. I WAS LUCKY IT DID NOT LOCK UP AND CAUSE AN ACCIDENT.*AK

OUR INSURED, MR MOHSSIN, PERFORMED AN EVASIVE MANUEVER AT HIGHWAY SPEED APPLYING THE BRAKES TO THE MAXIMUM WHILE TURNING. HIS 2001 F150 HARLEY EDITION IS EQUIPPED WITH ABS AS WELL AS 20" RIMS WHICH ARE 40LBS HEAVIER THAN STOCK. IN THE LAST SEVERAL WEEKS, WE HAVE GATHERED SUFFICIENT EVIDENCE TO SUGGEST THAT THE LF AND RF BRAKE CALIPER BRACKETS SNAPPED DURING THIS LOSS CAUSING BOTH TIRE/WHEEL/HUB ASSYS TO SHEAR OFF THE SPINDLE NUTS AND BECOME SEPARATED FROM THE VEHICLE. THERE WAS NO IMPACT WITH ANY OTHER VEHICLE PRIOR TO THIS AND ALL COMPONENTS ON THIS VEHICLE ARE OEM. IT IS THE OPINION OF OUR INDPENDENT RECONSTRUCTIONIST ENGINEER THAT THERE IS AMPLE REASON FOR FORD TO BE CONCERNED AND REVIEW THE EVIDENCE FOR THEMSELVES. TO DATE, WE HAVE HAD NO LUCK GETTING ANY RESPONSE OR INTEREST IN REVIEWING OUR FINDINGS. MANY AVENUES HAVE BEEN PURSUED TO SEEK SOME RESPONSE. THE ONLY CONTACT SO FAR HAS DIRECTED US TO SUBMIT A SUBROGATION DEMAND IF WE SEEK RECOVERY. OUR CONCERN AT THIS POINT IS TO GET THE INSURED HIS VEHICLE BACK. PHYSICAL EVIDENCE HAS BEEN SECURED. REPAIRS WILL BEGIN THE FIRST WEEK OF JULY. WE WOULD APPRECIATE IT IF THE NHTSA COULD PERSUADE A FORD REPRESENTATIVE TO CONTACT OUR NCAL PD MGR, ERIC HACKER AT 916 853-4607 TO CONFIRM FORD'S POSITION. WE APPRECIATE ANY ASSISTANCE YOU CAN PROVIDE.

WHILE DRIVING AT 65 MPH TRANSMIISSION FLUID WAS LEAKING FROM REAR. PLEASE PROVIDE ANY FURTHER IFORMATION. *AK

CONSUMER WAS INVOLVED IN A HEAD ON COLLISION IN WHICH THE AIR BAGS FAILED TO DEPLOY, ALSO THE SEATBELT FAILED TO RESTRAIN CONSUMER.*JB

AN ONGOING PROBELEM TRANSMISSION NOT SHIFTING INTO GEAR AFTER STOPPING VEHICLE. VEHICLE BEEN TO THE DEALER ON THREE OCCASIONS; BUT, PROBLEM STILL REOCCURRING. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

FROM ACCELERATION OF 25-50 MPH, A SEVERE VIBRATION WOULD OCCUR IN FRONT OF VEHICLE. AT 70 MPH OR MORE REAR END WOULD VIBRATE SEVERELY ALONG WITH A ROARING AND GRINDING SOUND. VEHICLE BEEN TO THE DEALER FOUR TIMES, DEALER WAS UNABLE TO LOCATE CAUSE OF PROBLEM. *AK THE VIBRATION IS EXTREME TO THE POINT THAT CONSUMER IS AFRAID TO RIDE IN THE VEHICLE. THE POPPING SOUND IN THE DRIVERS SEAT FEELS LIKE THE SEAT IS TRYING TO MOVE FORWARD OUT OF THE LOCKED POSITION. WHEN CONSUMER PURCHASED THE VEHICLE THE VEHICLE HAD A NOISE UNDERNEATH. IT WAS TOLD TO CONSUMER THAT IT WAS BEING REPAIRED WITH A NEW MUFFLER THAT HAD BEEN ORDERED. AT THE TIME THE MUFFLER WAS BEING REPAIRED THE VIBRATION ALSO WAS WORKED ON. THE WORK DID NOT CORRECT THE VIBRATION PROBLEM. A SERVICE MAN TEST DROVE THE VEHICLE WITH THE CONSUMER AND AGAIN THE VIBRATION PRESENTED ITSELF. FOUR NEW TIRES WERE INSTALLED BUT THIS DIDN'T SOLVE THE PROBLEM. *JG

ON DRY PAVEMENT, THE TEMPERATURE WAS 70 DEGREES, AND THE WEATHER WAS CLEAR AND SUNNY AT 12:30 IN THE AFTERNOON, IN LIGHT TRAFFIC, WHEN THE BRAKES FAILED ON MY 2001 F150 SUPERCREW. DURING NORMAL BRAKING PROCEDURES, WITH MORE THAN ADEQUATE SPACING BETWEEN CARS, NORMAL BRAKING PROCEDURES WERE EMPLOYED. THERE WAS NO RESPONSE AT ALL FROM THE BRAKES. THIS LEFT MY WIFE, THE DRIVER, NO CHOICE BUT TO LEAVE THE ROAD SERVICE TO AVOID A REAR COLLISION WITH A SMALLER CAR, IN WHICH SHE HIT A ROAD SIDE FOOD STAND. THE FOOD STAND WAS DESTROYED AND THE TRUCK RECEIVED HEAVY DAMAGE.*AK

I HAVE HAD NOTHING BUT PROBLEMS WITH THE FUEL INJECTION SYSTEM. THE DEAL DID FIX THE FIRST PROBLEM BUT IGNORED COMPLAINTS THAT THE PROBLEM WAS STILL NOT FIXED. AT 36000 MILES THE DRIVE BELT WENT OUT AND STILL THERE WAS PROBLEMS W/ INJECTORS . NOW DEALERS WILL NOT HONOR WARRANTY BECASUE CURRENT MILEAGE IS 36900 EVEN THOUGH THEY PUT THE FIRST 1,234 WHEN THE TRUCK WAS BOUGHT NEW.*AK

ACCELERATOR PEDAL GOT STUCK, FORCING VEHICLE TO GO 35MPH. WHEN BRAKES WERE APPLIED VEHICLE ATTEMPTED TO SLOW DOWN, BUT KEPT GOING. SPEED DID NOT INCREASE. VEHICLE WAS SHUT OFF TO STOP. DEALER NOIFIED OF PROBLEM. PLEASE ADD MORE INFORMATION.*AK

BOTTOM OF THE SEAT IS AT AN ANGLE WHERE CONSUMER IS STARTING TO HAVE LEG PAIN. TOOK TO DEALER FOR ADJUSTING, BUT CONSUMER FEELS IT'S A DESIGN FLAW. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

WHILE MOVING SLOWLY CONSUMER HEARD A CLICKING NOISE COMING FROM THE LEFT FRONT OF THE WHEEL. CONSUMER WAS ABLE TO JACK THE VEHICLE UP. THERE WERE THREE LEFT LUG NUTS FINGER TIGHT AND ONE WAS NOT TIGHT ENOUGH. WHEN CHECKING OTHER LUG NUTS THEY FOUND THREE FINGERS TIGHT LOOSE ON LEFT REAR ALSO. *AK *YH

RIGHT FRONT BOLTS THAT HOLD BRAKE CALIPER ON FELL OFF. VEHICLE CAME TO A ABRUPT STOP. TWO WEEKS LATER, LEFT FRONT BRAKE CALIPER FELL OFF. THIS TIME IT POKED A HOLE IN TIRE, AND COULD HAVE CAUSED A DANGEROUS ACCIDENT.*AK

AFTER INSPECTION OF VEHICLE, MECHANIC NOTICED THAT MAIN GROUND WIRING WAS HANGING WHICH COULD RESULT IN A SHORT CIRCUIT OR POSSIBLE FIRE. *AK DEALER FOUND MAIN GROUND CABLE DISCONNECTED. *TT

WHILE DRIVING AT 30-35MPH VEHICLE WAS INVOLVED IN A FRONTAL COLLISION, AND DRIVERS SEAT BELT DID NOT RETRACT, CAUSING DRIVER TO LURCH FORWARD INTO DASHBOARD.*AK AND THE AIRBAG FAIL TO DEPLOY. *MJ

WHILE TRAVELING ABOUT 35MPH ON HIGHWAY ANOTHER VEHICLE COLLIDED HEAD ON WITH CONSUMER'S VEHICLE. UPON IMPACT, DRIVER SIDE AIRBAG DIDN'T DEPLOY. DEALERSHIP WAS AWARE OF PROBLEM.*AK

ENGINE SERVICE LIGHT COMES ON INTERMITTENTLY. VEHICLE HAS BEEN TAKEN TO DEALER 6 TIMES. AIRFLOW SENSOR WAS REPLACED, DID NOT REMEDY THE PROBLEM.*AK

GEAR SHIFT STICKS AND IS SOMETIMES IMPOSSIBLE TO SHIFT GEARS.*AK

F150 LARIAT WITH TOW PACKAGE PURCHASED NEW. TIRES ON THE VEHICLE WERE GOODRICH PASSENGER TIRES WITH PROPER WEIGHT RATING. HOWEVER, WHEN PULLING A 24 FT. TRAVEL TRAILER; THE TRUCK AND TRAILER WOULD AGGRESSIVELY SWAY WHEN HIT WITH LIGHT BREEZE OR PASSING VEHICLES. NEARLY LOST CONTROL OF VEHICLE SEVERAL TIMES. TESTED ALL HITCH/TRAILER/CENTER OF GRAVITY/WEIGHT ASPECTS AND ALL TESTED OKAY. TESTED PULLING TRAILER AT LOW SPEED WITH NO WIND/OTHER VEHICLES. DISCOVERED THE SMALLEST STEERING INPUT CAUSED SEVERE LATERAL SWAY WITH OSCILLATIONS BECOMING STRONGER WITHOUT CORRECTIVE ACTION. THE TIRES, ALTHOUGH RATED TO CARRY OVER 2,000 LBS., DO NOT HAVE THE SIDEWALL STRENGTH TO WITHSTAND THE LATERAL MOVEMENTS ASSOCIATED WITH PULLING A SMALL TRAVEL TRAILER. I HAVE SINCE REPLACED THESE NEW PASSENGER TIRES WITH LIGHT TRUCK TIRES AND FOUND THAT THE DANGEROUS SWAY HAS BEEN ELIMINATED. I HAVE INVESTED OVER $850 IN NEW TIRES IN ORDER TO ENSURE THE SAFETY OF MY FAMILY AND I AM VERY CONCERNED THAT OTHER FORD TRUCK OWNERS MIGHT EXPERIENCE A SERIOUS COLLISION IF THEY USE THEIR TRUCK AND TOWING PACKAGE TO PULL A TRAVEL TRAILER IF THEIR TRUCK IS ONLY EQUIPPED WITH PASSENGER TIRES. I HAVE CONTACTED THE FORD DEALERSHIP, WHO REFERRED ME TO MR. PAUL BERARDI, A FORD FIELD ENGINEER. MR. BERARDI (602-692-6479) HAS NOT YET RESPONDED TO MY CONCERNS AS OF THIS WRITING. I CONTACTED HIM ON 3/6/02. A COPY OF MY ORIGINAL LETTER TO THE DEALERSHIP, WHICH WAS FORWARDED BY THEM TO MR. BERARDI, IS AVAILABLE TO NTSA.*AK

OUTSIDE DRIVER'S DOOR HAS STRESS CRACKS LOCATED NEAREST TO WINDOW DOOR FRAME. ALSO, STRESS CRACKS HAVE BEEN THERE AS LONG AS 1 YEAR. CONSUMER HAS NOTIFIED MANUFACTURER. PLEASE PROVIDE MORE INFORMATION.*AK

PE 02 035: BRAKE/ACCELERATOR PEDAL SEPARATION: WHILE APPLYING BRAKE PEDAL DRIVER'S FOOT WOULD SIMULTANEOUSLY HIT ACCELERATOR PEDAL, ALMOST CAUSING A VEHICLE CRASH. DEALER AND MANUFACTURER NOT NOTIFIED AT THAT TIME. *AK CONSUMER WAS AT A TRAFFIC LIGHT WITH FOOT ON THE BRAKE WHEN THE ENGINE STARTED TO REV. THE MORE THE CONSUMER PUT ON BRAKES THE MORE THE ENGINE WOULD ACCELERATE. *JG

TIRES ARE NOT IN ALIGN PROPERLY DUE TO SUSPENSION. DEALERSHIP IS AWARE OF PROBLEM.*AK

WHILE DRIVING AT 45-50 MPH CONSUMER HAD TO MAKE A SUDDEN STOP, AND THEN FRONT TWO TIRES FELL OFF. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK *YH

THE POLICE SAID MY DAD'S TRUCK WAS GOING AROUND 65 MPH. THE TRUCK STRUCK A GUARD RAIL ON BOTH SIDES IN THE FRONT AND THE AIR BAG DID NOT DEPLOY WITH EITHER IMPACT. THEY SAID HE WAS NOT WEARING HIS SEAT BELT BUT THE SEAT BELT WAS STILL ON HIM. HE WAS EJECTED OUT OF THE PASSENGER SIDE AND HE WAS PINNED UNDER THE TRUCK. THREE OF THE TIRES BLEW OUT ALSO. NLM

SERPENTINE BELT BROKE WHILE BACKING UP AND VEHICLE LOST STEERING ABILITY, TOWED TO DEALER, PART WAS REPLACED.*AK THE STEERING LOCKED AND THE CONSUMER LOST CONTROL OF THE VEHICLE RESULTING IN A COLLISION WITH A POLE.*YH

BLOWOUT OCCURRED ON OPEN HIGHWAY. CONTACTED FORD DEALERSHIP AND WAS ADVISED THEY WOULD NOT RESPOND TO THE BLOWOUT PROBLEM. CONTACTED FORD FACTORY AND WERE TOLD TO REFER THE PROBLEM TO FIRESTONE. FIRESTONE REFERRED TO FORD. THE FIRESTONE DEALER WHERE REPLACEMENT WAS PURCHASED ADVISED US TO CONTACT FIRESTONE AS IT WAS DEFINITELY A DEFECTIVE BLOWOUT. *AK (TIRESIZE: LT265/75R1)

WHEN APPLYING BRAKES AT 40 MPH OR MORE, VEHICLE HAS A DELAY IN STOPPING. VEHICLE HAS BEEN TO DEALER ON TWO OCCASIONS, AND PROBLEM IS STILL OCCURRING. *AK *YD

TAPPING NOISE IN TRANSFER CASE BELOW FOUR WHEEL DRIVE SHIFTER. *AK

WHILE TRYING TO PULL INTO GARAGE VEHICLE AUTOMATICALLY ACCELERATED, AND VEHICLE RAN INTO GARAGE. CONSUMER TRIED TO MOVE, AND VEHICLE AGAIN RAN THROUGH BACK OF GARAGE. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK

WHILE DRIVING ON THE FREEWAY AT 60 MPH THE TRUCK BEGAN ACCLERATING ON ITS OWN. APPLYING THE BRAKES DID NOT SOLVE PROBLEM. EXITED FREEWAY ON A RAMP AND APPLIED BRAKES TO THE FLOOR. HAD TO SHUT OFF IGNITION TO STOP THE VEHICLE. ATTEMPTED TO RESTART THE TRUCK BUT IT WAS OVER REVVING AND SMOKING OUT THE EXHAUST. SHUT IT DOWN AND NEEDED A TOW.*AK

WHILE REFUELING THE GASOLINE TANK, THE NOZZLE CAUGHT FIRE AND BURNED THE SIDE OF THE TRUCK. THE VEHICLE WAS OFF, DRIVER DOES NOT SMOKE AND THERE WAS NO IMMEDIATE KNOWN REASON FOR THE FIRE TO START. NO CELL PHONE USEAGE. KEYS WERE NOT IN THE IGNITION. POSSIBLE STATIC ELECTRICITY.*AK

WHILE DRIVING AT STATE SPEED LIMIT HEARD A LOUD NOISE FROM REAR OF VEHICLE. WITHOUT A WARNING LOST STEERING CONTROL, RESULTING IN A COLLISION, MECHANIC STATED REAR AXLE BRACKET HAD A MALFUNCTION WHICH RESULTED IN SPRING UNHOOKING AND RELEASING AXLE.

ON SEVERAL OCCASIONS, CUSTOMER STATES THAT THE PASSENGER SIDE FRONT SEAT BELT WILL NOT RETRACT PROPERLY, RESULTING IN, ON ONE OCCASION, PASSENGER BEING BANGED AGAINST THE FRONT OF THE CAB, DEALER REPLACED RIGHT FRONT SEAT BELT RETRACTOR, BUT DID NOT REMEDY PROBLEM. *TT

THE TRANSMISSION HESITATES AS IT SHIFTS FROM 1ST GEAR TO SECOND GEAR. I WAS TOLD IT IS NORMAL BY THE DEALER WHERE I BOUGHT THE TRUCK AND OTHER DEALERSHIPS AS WELL. I HAVE FOUND OUT THERE IS A DEFECT IN THE TRANSMISSION WHICH CAUSES THIS DELAY IN THE SHIFTING OF THE TRANSMISSION. THIS PROBLEM HAS BEEN FOUND IN 4R100 TRANSMISSIONS BUILT FROM 7/27/2000 TO 3/23/2001. I BELIEVE THIS TRANSMISSION TO BE UNSAFE AND FORD DENIES THERE IS A PROBLEM. I WANT THIS TRANSMISSION REPLACED WITH A NEW TRANSMISSION. I HAVE HAD THIS PROBLEM SINCE THE TRUCK WAS NEW AND ALL FORD DOES IS DENY, DENY, DENY.

I WAS DRIVING DOWN THE HIGHWAY AND ALL OF A SUDDEN THE ENGINE STARTS TO MAKE A POPPING SOUND. I PULLED OVER AND RAISED THE HOOD. THE #3 SPARK PLUG HAD BLOWN OUT FROM ITS SEATING IN THE CYLINDER HEAD. I HAD THE TRUCK TOWED TO THE DEALER AND THEY REPLACED THE CYLINDER HEAD. THIS IS A KNOWN PROBLEM AND COULD BE VERY DANGEROUS BECAUSE OF THE LOCATION OF THE FUEL INJECTION RAIL. THE SPARKPLUG IS LOCATED DIRECTLY BELOW THE FUEL RAIL. IF THE SPARK PLUG COMES LOOSE AND IT FLIES INTO THE FUEL RAIL, THE RAIL COULD BURST CAUSING FUEL TO SPRAY INSIDE THE ENGINE COMPARTMENT IGNITING A FIRE. THE SPARK PLUG PROBLEM WAS TAKEN CARE OF BY FORD, HOWEVER NOTHING WAS DONE TO GUARD THE FUEL RAIL.

CONSUMER STATED THE ENGINE HAS BEEN REPLACED 3 TIMES SINCE 31,168 MILES. *JG *AK

I HAVE TAKEN THIS VEHICLE TO THE SERVICE DEPARTMENT ON 7 DIFFERENT OCCASIONS FOR VIBRATION WHILE DRIVING AT SPEEDS OF 34, 52 AND 72 MPH. THEY HAVE HAD THE FORD REGIONAL REP LOOK AT THIS VEHICLE 4 TIMES AND HE INSISTS THAT I HAVE A TIRE PROBLEM! I HAVE ALREADY BEEN THROUGH 5 NEW SETS OF TIRES, 2 NEW SETS OF WHEELS, A DRIVE SHAFT REPLACEMENT AND A REAR END OVERHAUL AND I STILL HAVE THE SAME PROBLEM! I WOULD APPRECIATE ANY ASSISTANCE THAT YOUR OFFICE COULD PROVIDE IN HELPING RESOLVE THESE PROBLEMS!*AK (TIRESIZE: P26570R17)