2000 Ford F-150 complaints

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT BOTH FUEL TANK STRAPS WERE COMPLETELY RUSTED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING) AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE DEALER ADVISED THE CONTACT THAT THE RECALL REMEDY COULD NOT BE PERFORMED UNLESS THE DAMAGED FUEL LINES WERE REPLACED FIRST. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXPRESSED THAT THE FUEL TANK REPLACEMENT SHOULD HAVE BEEN INCLUDED IN THE RECALL CAMPAIGN. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 158,000.

THE VEHICLE WAS PARKED IN FRONT OF MY HOME, AND ABOUT 30 MINUTES AFTER THE VEHICLE WAS PARKED, IT CAUGHT FIRE. THE VEHICLE HAD BEEN TURNED OFF FOR ABOUT 30 MINUTES BEFORE IT BEGAN TO SMOKE AND THEN CAUGHT FIRE AND FLAMES BURNED THROUGH THE ENTIRE FRONT OF THE VEHICLE. THE FIRE THEN SPREAD AND BURNED THROUGH THE TIRE BEFORE THE FIRE DEPARTMENT WAS ABLE TO CONTAIN AND PUT OUT THE FLAMES. *TR

TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED IN A RESIDENTIAL DRIVE-WAY FOR FIVE HOURS WHEN HE NOTICED FLAMES COMING FROM THE ENGINE AND THROUGH THE FRONT GRILL OF THE VEHICLE. THE FIRE DEPARTMENT WAS CONTACTED WHO CAME AND EXTINGUISHED THE FIRE. THEY DID NOT KNOW THE ORIGIN OF THE FIRE AND NO ONE WAS INJURED. A FIRE REPORT WAS NOT AVAILABLE. THE INSURANCE COMPANY WAS NOTIFIED OF THE FAILURE AND THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS CONTACTED WHO STATED THEY WOULD CONTACT HIM WITHIN THE NEXT FIFTEEN DAYS. THE FAILURE MILEAGE WAS 150,000.

WHEN TRYING TO BACK OUT OF MY DRIVEWAY, THE TRUCK MADE A LOUD POPPING SOUND FROM THE ENGINE. WHEN I RAISED THE HOOD, I COULD SMELL UNBURNT FUEL. I THEN DID SOME RESEARCH ONLINE AND FOUND OUT THAT THIS COULD BE A BLOWN SPARK PLUG FROM THE CYLINDER HEAD. I HAVE READ MANY FORUMS AND TALKED TO SEVERAL MECHANICS ABOUT THE SYMPTOMS I HAVE EXPERIENCED. ALL HAVE SAID THIS IS A VERY COMMON PROBLEM WITH THIS ENGINE AND OTHER FORD ENGINES. I CALLED FORD MOTOR CO. AND THEY WERE NOT AWARE OF ANY PROBLEMS WITH THIS ENGINE. MY LOCAL DEALER WAS AWARE OF THE PROBLEM AND THEREFORE STOCK PLENTY OF IGNITION COILS ON HAND. THIS REPAIR IS ESTIMATED TO COST ME $400. FORD SHOULD BE RESPONSIBLE FOR THIS COST, NO QUESTIONS ASKED. *TR

TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER:11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). AFTER THE REPAIR, THE FUEL TANK BEGAN LEAKING. THE CONTACT CALLED THE DEALER AND THE DEALER INFORMED THE CONTACT THAT THEY COULD ONLY REPAIR THE FUEL TANK STRAPS AT NO COST ONLY ONCE UNDER THE RECALL. THE MANUFACTURER WAS ALSO CONTACTED AND ADVISED HIM THAT THE FUEL TANK WOULD NOT BE COVERED BY THE RECALL. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 135,892.

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE NOTICED THAT THE REAR LEAF SPRINGS ON BOTH SIDES OF THE VEHICLE HAD PIERCED THROUGH THE BED OF THE TRUCK. THE CONTACT STATED THAT THE FAILURE WAS CAUSED BY EXCESSIVE RUST. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 164,000.

GOOD DAY, MY 2000 FORD F150 PICKUP TRUCK IS INVOLVED IN THE GAS TANK STRAPS RECALL. BECAUSE THE STRAPS BROKE IT CAUSED EXCESSIVE VIBRATION FROM THE TANK THAT ALSO DAMAGED THE TANK; NOW FORD HAS FIXED THE STRAPS BUT NOW THEY WANT $1600 TO FIX THE TANK WHICH BROKE BECAUSE OF THE DAMAGE STRAPS ORIGINALLY. I HAVE NEVER HAD A VEHICLE WITH SUCH A SEVERE RUST PROBLEM. I THINK THIS VEHICLE SHOULD HAVE A FUEL TANK RECALL ALSO. THE FUEL LINE ALL GOT RUSTED AND BROKE ON ME; I HAD TO CHANGE OUT ALL THE LINES. NOW THE GAS TANK AND STRAPS ARE ALL RUSTED OUT. THANKS, *JS

VEHICLE HAD BEEN PARKED FOR TWO HOURS AT HOME AFTER A LONG TRIP. NEIGHBORS NOTICED THAT THE TRUCK HAD CAUGHT FIRE AND NOTIFIED ME. LOCAL VFD WAS ABLE TO EXTINGUISH THE FIRE ... BUT NOT BEFORE TOTAL LOSS OF THE TRUCK. *TR

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT BOTH OF THE FUEL TANK STRAPS FRACTURED AND AS A RESULT, THE FUEL TANK WAS SITTING ON TOP OF THE SKIT PLATES. THE CONTACT ALSO MENTIONED THAT THE FUEL TANK WAS LEAKING DUE TO THE CORROSION DAMAGE AROUND THE STRAPS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) DID NOT INCLUDE THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 164,621.

AS OF 12-10-2010 I WAS AT WORK AND WAS WALKING TOWARD THE TRUCK AND NOTICE THE GAS TANK WAS HANGING.I CALLED MY BOSS AND TOLD HIM THE SITUATION.SO I TOOK A RACHET STRAP AND STRAP IT UP.DROVE OVER SIXTY MILES HOME TO LOCAL AUTO STORE AND PICKED UP NEW STRAPS.AS I WAS REPLACING STRAPS I NOTICE A STRONG ODOR OF GAS.ALSO WHEN REPLACING THESE STRAPS THAT I NOTICE ALOT OF RUST ON GAS TANK WHERE GAS STRAPS WERE PLACED.WANTED TO TAKE A WIRE BRUSH TO IT BUT WAS AFRAID OF THE WIRE BRUSH PUTTING A HOLE THROUGH IT.ALSO MAYBE A SPARK AND KABOOM.BESIDES THAT TOOK THE TRUCK TO DEALERSHIP AND SERVICE ADVISOR CAME TO US AND TOLD US THAT GAS TANK HAS 3 HOLES IN TANK AROUND FRONT STRAP AND IS TO DANGEROUS TO DRIVE.HE SAID THAT HE WOULD GET AHOLD OF FORD AND MORE THAN LIKELY THEY WOULD PUT US IN A RENTAL AND FIX TANK.HE COMES BACK AND SAID THEY WOULD NOT FIX.HE TOLD US THAT WE HAVE A CASE.SO CALLED FORD AND THEY TOLD ME THAT THE ONLY WAY THEY WOULD FIX THE TANK IF IT WOULD DROP TO THE GROUND.I SEE THAT AS A PERSONAL SAFETY ISSUE FOR ME AND PEOPLE BEHIND ME.FORD SHOWED NO CONCERN AND THAT BOTHERED ME.BUT SINCE THE TANK DROPPED I HAVE SMELT GAS AND THE DEALERSHIP NOTICED THE CORROSION AND RUST UNDER THE STRAPS AND FORD STILL DID NOT CARE.

2000 FORD F150 PICKUP WAS PARKED ON THE STREET AT MY MOTHER IN LAW'S HOUSE. IT HAD BEEN SITTING FOR ABOUT 2 HOURS WHEN WE HEARD THE HORN GOING OFF. WE LOOKED OUTSIDE AND THE FRONT OF THE TRUCK WAS ENGULFED IN FLAMES. THE FIRE GREW SO QUICKLY AND HAD BURNED OUT THE WHOLE CAB BY THE TIME THE FIRE DEPARTMENT GOT IT OUT. IT WAS A TOTAL LOSS, AND HAS PUT OUR FAMILY IN A HORRIBLE SITUATION. THE FIRE STARTED ON THE DRIVER SIDE UNDER THE HOOD. IT LOOKED TO BE ABOVE THE WHEEL AND NEAR THE WINDSHIELD. WHILE THE FIRE WAS BURNING, IT CAUSE THE WINDSHIELD TO EXPLODE, SHOOTING GLASS ALL OVER THE STREET. THE FIRE ALSO DAMAGED ANOTHER VEHICLE PARKED NEARBY. THE TRUCK IS A CHARRED SKELETON AND THE TIRES WERE EVEN MELTED TO THE CONCRETE! THERE IS ABSOLUTELY NOTHING LEFT. I AM GRATEFUL WE WERE NOT IN THE TRUCK OR DRIVING DOWN THE ROAD, BUT THIS IS SO UPSETTING. WE CANNOT AFFORD TO BUY A NEW VEHICLE, WHICH IS WHY WE WERE DRIVING A 13 YEAR OLD TRUCK TO BEGIN WITH. WE DID NOT HAVE THE MONEY FOR ANOTHER CAR PAYMENT. NOW -WE ARE WITHOUT A VEHICLE. *TR

I JUST PURCHASED THIS TRUCK YESTERDAY 12/29/11 AND I DROVE IT HOME PARKED IT AND GOT IN THE VEHICLE THIS MORNING, STARTED IT AND THE AIRBAG LIGHT BEGAN TO FLASH AT ME AND THEN STAYED ON MY WHOLE 1 HOUR DRIVE TO WORK. I HAVE 4 CHILDREN, AND AM AFRAID THAT THE AIRBAGS ARE GOING TO DEPLOY WHILE THEY ARE IN THE VEHICLE OR NOT DEPLOY IF WE ARE IN A COLLISION. IF THERE IS A RECALL PLEASE LET ME KNOW, I NEED TO GET IT FIXED. *KB

TL- THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE CROSS MEMBERS, CAB MOUNTS, BRAKES LINES AND STARTER CABLES WERE ALL RUSTED. THE CONTACT STATED THAT THERE WAS A RECALL ON THE VEHICLE FOR CORROSION OF THE FUEL TANK STRAPS UNDER NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) BUT NOT FOR THE OTHER CORRODED COMPONENTS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70,000. KMJ

MY TRUCK FRONT CROSS MEMBER THAT SUPPORTS RADIATOR AND THE BODY TO THE FRAME IS JUST ABOUT RUSTED GONE. DEALER STATED THAT TRUCK IS 11 YEARS OLD AND WILL NOT REPAIR. I AM SENDING THIS FOR RECORD IN THE EVENT I AM KILLED DUE TO ANY FAILURE IN WHICH I DESCRIBE. I HAVE READ TWO CASES ON THIS WEBSITE , ONE IS A 2001 F-150 THAT HAD A CROSS MEMBER SUPPORT RUSTED OUT IN 2003 WITH 48,000 MILES AND ANOTHER WAS A 2001 F-150 HAD A TAG ATTACHED TO THE FRAME WHICH READ ( DEFECTIVE MATERIAL DO NOT USE L/S PERFORMANCE *AK. I EXPECT A FULL INVESTIGATION ON THIS COMPLAINT AND I DO WANT MY VEHICLE INSPECTED BY NHTSA. *TR

I MAY BE POSSIBLE THAT IF YOUR VEHICLE IS OPERATED IN A HIGH CORROSION AREAS FOR AN EXTENDED PERIOD OF TIME, ONE OR BOTH FUEL TANK STRAPS COULD POTENTIALLY FRACTURE. STRAP FRACTURE MAY RESULT IN THE FUEL TANK CONTACTING THE GROUND. IF THE FUEL TANK CONTACTS THE GROUND AND DEVELOPS A LEAK WHILE DRIVING, THERE IS A POTENTIAL FOR FIRE. THE TIME FORD ESTIMATES FOR THIS REPAIR TO OCCUR IS ERRONEOUS. IT TAKES HALF A DAY IN THE SHOP TO DETERMINE IF THE STRAPS ARE IN GOOD OF BAD SHAPE. THEN THEY HAVE TO ORDER A REPAIR KIT. TO DO THE ACTUALLY REPAIR, CLOSE TO A DAY IN THE SHOP. I NEED MY VEHICLE FOR WORK AND FORD WILL NOT LOAN ME ONE FREE OF CHARGE. *TR

MY TRUCK FRONT CROSS MEMBER THAT SUPPORTS RADIATOR AND THE BODY TO THE FRAME IS JUST ABOUT RUSTED GONE. DEALER STATED THAT TRUCK IS 11 YEARS OLD AND WILL NOT FIX. I AM SENDING THIS FOR RECORD IN THE EVENT I AM KILLED DUE TO ANY FAILURE. HAVE READ TWO CASES ON YOUR WEBSITE. ONE IS A 2000 F-150 THAT A CROSS MEMBER SUPPORT RUSTED OUT IN 2003 WITH 48,000 MILES. ANOTHER WAS A 2000 F-150 THAT HAD A TAG ATTACHED TO THE FRAME STATING DEFECTIVE MATERIAL DO NOT USE! L/S PERFORMANCE *AK. I EXPECT A FULL INVESTIGATION ON THIS AND WANT MY VEHICLE INSPECTED. THE CONSUMER WAS INFORMED THE BRAKES LINES NEEDED TO BE REPLACED AS THE VEHICLE WAS UNSAFE TO DRIVE. UPDATED 01/06/12 *TR

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE ABS BRAKE LIGHT WOULD ILLUMINATE SPORADICALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE ABS MODULAR NEEDED TO BE REPLACED. THE DEALER ADVISED THAT THE VEHICLE COULD BE DRIVEN, BUT WOULD HAVE TO BE DRIVEN SLOW IN INCLEMENT WEATHER BECAUSE THE MODULE FAILED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 143,000. UPDATED 01/24/12*LJ UPDATED 01/25/12

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) AND ATTEMPTED TO CONTACT THE DEALER TO SECURE AN APPOINTMENT FOR RECALL REPAIRS. THE DEALER ADVISED THE CONTACT TO CALL BACK LATER. THE CONTACT STATED THAT THERE HAD BEEN NUMEROUS ATTEMPTS TO SECURE AN APPOINTMENT WITH THE DEALER SINCE SEPTEMBER 2011 BUT TO NO AVAIL. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 109,000 AND THE CURRENT MILEAGE WAS 110,000. UPDATED 01/10/12*LJ UPDATED 02/03/12.

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE BRAKES LINES BLEWOUT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT THEN NOTICED THAT ALL OF THE BRAKES LINES ON THE VEHICLE WERE RUSTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND ALL OF THE BRAKE LINES WERE REPLACED UP TO THE MASTER CYLINDER. THE FAILURE AND CURRENT MILEAGES WERE 89,000.

TL* THE CONTACT OWNS A 2000 FORD F150. THE VEHICLE WAS PARKED WHEN THE CONTACT NOTICED A PIN SIZED HOLE ON THE FUEL TANK AND THE BRACKET WAS COMPLETELY RUSTED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING); HOWEVER THE TECHNICIAN WAS UNABLE TO PERFORM THE RECALL REPAIR UNTIL THE BRACKET WAS REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXPRESSED CONCERN THAT THE BRACKET REPLACEMENT SHOULD HAVE BEEN INCLUDED IN THE RECALL REMEDY. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM BUT PROVIDED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, THE VEHICLE BURST INTO FLAMES. NO ONE WAS INJURED BUT THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT ADVISED THAT THE FIRE WAS CAUSED BY AN ELECTRICAL FAILURE. THE CONTACT CALLED THE MANUFACTURER TO FILE A COMPLAINT AND THE MANUFACTURER STATED THEY WOULD INSPECT THE VEHICLE FOR ANY DEFECTS. THE FAILURE MILEAGE WAS 200,500.

FORD HAS ISSUED A RECALL FOR DEFECTIVE FUEL TANK STRAPS THAT MAY CORRODE AND CAUSE A POTENTIAL FUEL LEAK. I BROUGHT MY TRUCK IN FOR THE RECALL AND SURE ENOUGH MY STRAPS ARE CORRODED. THE VEHICLE IS AT A FORD DEALERSHIP AND THEY WILL NOT REPLACE THE STRAPS BECAUSE THE CORRODED STRAPS HAVE STARTED TO CORRODE THE TANK. ACCORDING TO THE DEALER THE TANK WILL BEGIN LEAKING IF THEY REPLACE THE STRAPS. THE DEALER CALLED FORD CUSTOMER CARE AND THEY WOULD NOT COVER THE TANK. I ALSO CALLED FORD AND THEY REFUSED TO COVER THE TANK AND ALSO WILL NOT REPLACE THE STRAPS UNLESS I PURCHASE A TANK FROM THEM TO REPLACE. IF MY STRAPS BREAK I WILL LOSE MY TANK AND POTENTIALLY CAUSE A FIRE OR ACCIDENT TO ANOTHER VEHICLE. THE RECALL DOES NOT CURRENTLY ADDRESS ADDITIONAL DAMAGE CAUSED BY THE DEFECTIVE STRAPS. THE DAMAGE TO MY TANK IS A DIRECT RESULT OF THE DEFECTIVE STRAPS AND SHOULD BE COVERED UNDER THIS RECALL. I LEAVE IN NEW ENGLAND AND AM SURE THERE ARE MANY OTHER FORD TRUCKS WITH THE SAME PROBLEM. WHAT RECOURSE DO I HAVE TO GET THIS RESOLVED? SPOKE WITH [XXX], A CUSTOMER SERVICE SUPERVISOR AT FORD CUSTOMER CARE IN FLORIDA, CASE #[XXX]. ANY ASSISTANCE WOULD BE APPRECIATED, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2000 FORD F-150. CONSUMER STATES WHEEL RIMS STARTED TO RUST OUT IN ONE YEAR *TGW THE CONSUMER ALSO STATED THE BUMPER RUSTED OUT IN ONE YEAR, AND THE ABS LIGHT ILLUMINATED. THE BRAKES WERE INSPECTED SEVERAL TIMES, BUT NO PROBLEM WAS FOUND. THE HIGH BEAMS WOULD NOT COME ON, THE PLASTIC ON THE OUTSIDE REARVIEW MIRROR FELL OFF, THE DOME LIGHT IN THE CAB WOULDN'T COME ON, AND THE TAILGATE WOULDN'T CLOSE, THE WINDSHIELD WIPER WASHER, WIPERS AND HEATING SYSTEM DID NOT WORK. THE POWER STEERING PUMP LEAKED ALL THE TIME, THE GEAR SHIFTER WOULDN'T GO INTO PARK. THE FUEL STRAP FAILED THREE YEARS AGO AND CAUSED THE FUEL TANK TO FALL TO THE GROUND. *JB

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WITH THE ENGINE TURNED OFF WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT DIAGNOSED THAT FLUID LEAKED INTO THE BRAKE MASTER CYLINDER AND CAUSED THE FIRE. A FIRE REPORT WAS FILED. THE VIN WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL), BUT THE CONTACT DID NOT RECEIVE A RECALL NOTICE IN THE MAIL. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED AND TOLD THE CONTACT THAT THEY WOULD PROCESS AN INVESTIGATION UPON THE GROUNDS THAT THE INSURANCE COMPANY WAS NOT CONTACTED. THE VEHICLE WAS DESTROYED. THE FAILURE AND THE CURRENT MILEAGE WAS 26,000.

MY TRUCK WAS PARKED ON MY DRIVEWAY, AND HAD NOT BEEN DRIVEN IN ABOUT 2WKS. I DIDN'T EVEN THINK THAT THE BATTERY HAD A CHARGE. MY [XXX] WIFE AND A SALESMAN AND I JUST HAPPENED TO BE STANDING A FEW FEET AWAY HAVING A CONVERSATION, WHEN WE SMELLED WIRES BURNING. I QUICKLY RAISED THE HOOD OF THE TRUCK TO SEE THE PLUG WIRES CONNECTED TO THE BRAKE MASTER CYLINDER SMOKING. AT THAT TIME I OF COURSE DISCONNECTED IT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

2000 FORD F-150. CONSUMER WRITES IN REGARDS TO RECALL FOR A FAULTY STRAP THAT HOLDS THE GASOLINE TANK *TGW THE CONSUMER STATED HE RECEIVED A RECALL NOTICE REGARDING FAULTY FUEL STRAPS THAT HELD THE GAS TANK IN PLACE. THE CONSUMER STATED HE WAS WELL AWARE OF THE PROBLEM AS THE TANK ACTUALLY FELL OFF HIS VEHICLE ABOUT A YEAR AGO, IN WHICH HE PROMPTLY BOUGHT THE STRAPS AND RE-ATTACHED THE TANK TO THE VEHICLE. THE CONSUMER STATED FORD WAS NOT ACCEPTING THE FACT THAT THE TANK HAS BEEN LEAKING SINCE THE INCIDENT AND REFUSED TO REPLACE THE TANK WITH THE STRAPS. THE ASSERTION IS THE TANK IS LEAKING DUE TO CORROSION. *JB

SPARK PLUG WAS EJECTED OUT OF THE CYLINDER HEAD. LOCATION NUMBER 5 CYLINDER. *TR

TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS WHEN SHE WAS INFORMED THAT THE CANISTER BRACKET WHICH HELD THE FUEL TANK NEEDED TO REPLACED AS WELL AS THE FLOOR BOARDS AND THE ROCKET PANEL. THE DEALER INFORMED THE CONTACT THAT THEY WOULD NOT COVER THE COST SINCE IT WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, DID NOT OFFER ANY ASSISTANCE. NO REPAIRS WERE PERFORMED. THE APPROXIMATE FAILURE MILEAGE WAS 131,000. UPDATED 12/16/11*LJ

200 FORD F]-150. CONSUMER STATES DIFFICULTY WITH GETTING RECALL REPAIRS DONE IN A REASONABLE TIME. *TGW THE CONSUMER STATED THE RECALL LETTER STATED IT WOULD 1/2 DAY. THE DEALERSHIP STATED IT WOULD TAKE MUCH LONGER, DUE TO THE OVERWHELMING NUMBER OF INSPECTIONS THAT NEEDED TO BE DONE ON OTHER TRUCKS. ALSO, THE CONSUMER WAS INFORMED THE PARTS WERE NOT AVAILABLE. *JB UPDATED 12/15/11. *JB

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT WAS DRIVING 60 MPH WHEN THE STEERING WHEEL SEIZED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED, BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 395,000 AND THE CURRENT MILEAGE WAS 395,004.

TL* THE CONTACT OWNS A 2000 FORD F-150. IN THE ATTEMPT OF GETTING THE VEHICLE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING), THE DEALER DIAGNOSED THAT THE RECALL COULD NOT BE PERFORMED DUE TO RUST BEING IN THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT, BUT DENIED ANY ASSISTANCE WITH THE REPAIR. THE FAILURE AND CURRENT MILEAGE WAS 96,000.

WAS GOING TO FORD DEALER FOR GAS TANK STRAP RECALL DUE TO STRAPS THAT HAVE POOR CORROSION PROTECTION. AS I WAS ENROUTE TO DEALER I APPLIED MY BRAKES DUE TO A CAR RUNNING A STOP SIGN AND MY BRAKES GAVE WAY AND I JUST MISSED A SERIOUS ACCIDENT. I CHECKED MY BRAKE LINE WHERE THE LEAK WAS AND DUE TO VERY POOR RUST THE LINE BLOW OUT. I ASK THE DEALER WHEN PERFORMING THE RECALL REPAIR COULD HE FIX THE LINE AND WAS STATED A 600.00 CHARGE. WHILE AT THE DEALER I CALLED FORD VP OF CUSTOMER SERVICE FRED TONEY WHO THEN SENT ME TO MR. FEDDERS. I TALKED TO A PERSON FROM HIS OFFICE AND TOLD THEM THAT FORD HAS A BIG PROBLEM ON BRAKE LINES RUSTING AND BECAUSE OF THAT I JUST MISSED HAVING A SERIOUS ACCIDENT. I ASK FORD TO FIX THE LININGS AT NO CHARGE AND TAKE THE LINE FOR OBSERVATION. I WAS TOLD THAT SINCE THE TRUCK IS 10 YEARS OLD AND HAS 200,000MILES ON IT THEY WILL NOT DO ANYTHING. I STATED THAT FORD HAS NO PROBLEM REPAIRING THE GAS STRAPS OF A 10 YEAR OLD TRUCK. ANYWAY HAD MY TRUCK TOWED TO MY MECHANIC AND REPAIRED. THEY REPLACED THE FRONT LINES AND INTERMEDIATE BRAKE LINES DUE TO POOR CORROSION. I WAS TOLD MY PASSENGER SIDE LINE AND BOTH REAR LINES ARE IN GREAT SHAPE, NO RUST AND COATED. I TOLD FORD ABOUT THIS AND SAID I WANT A FORD REP TO INSPECT MY COATED BRAKE LINES. AND MY DEFECTED LINE WHICH I KEPT FOR PROOF. I ASK FORD WHY SOME LINE WERE COATED AND SOME WERE NOT. I WAS TOLD THAT FORD DOES NOT COAT THE LINES. WE HAVE A SERIOUS PROBLEM HERE AND COULD RESULT IN MANY DEATHS. IF THE OTHE

ON TUESDAY OCTOBER 4, 2011 MY TRUCK CAUGHT FIRE WHILE SITTING IN A PARKING LOT AT MY WIFE'S PLACE OF EMPLOYMENT. THE TRUCK WAS NOT RUNNING AND HAD NO MAJOR MECHANICAL ISSUES. THE FIRE STARTED FROM THE ENGINE COMPARTMENT AND DAMAGED THE A MAJORITY OF THE FRONT END OF THE VEHICLE, IT IS TOTALED. I BELIEVE MY FORD TRUCK CAUGHT FIRE DUE TO A FAILURE IN THE CRUISE CONTROL WIRING SYSTEM AND A LEAK IN THE BRAKE FLUID SYSTEM. THERE WAS A RECALL FOR THE WIRING AND MY TRUCK WAS NOT FIXED DUE TO ME BEING THE SECOND OWNER. I WAS NOT AWARE OF THE RECALL UNTIL I SEARCHED THIS MORNING AFTER THE FIRE. *TR

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED AFTER RECEIVING NHTSA CAMPAIGN I.D. NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) THE CONTACT TOOK THE VEHICLE TO THE DEALER. THE DEALER STATED THEY COULD NOT PERFORM THE RECALL DUE TO A SKID PLATE COVERING THE FUEL TANK. THE CONTACT STATED ONE OF THE STRAPS WERE BROKEN AND IF THE OTHER STRAP BRAKES THE FUEL TANK COULD DROP ON THE SKID PLATE. THE CONTACT CALLED THE MANUFACTURER AND STATED THERE WAS NOTHING THEY COULD DO. THE CONTACT STATED THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 218,000.

I HAD MY 2000 FORD F150 AT THE DEALER BEFORE THE BUMPER TO BUMPER RAN OUT WITH 31000 MILES ON THE TRUCK THERE WAS RECALLS ON IT FOR THE BACK WINDOW LEAKING AND OTHER THINGS LIKE THE SPEED CONTROL I NOTICE THE FRAME AND CROSSMEMBERS RUSTING OUT AT THIS TIME THE PAINT WAS NOT DOING ITS JOB ALL THEY HAD TOO DO WAS TO PAINT IT BUT THEY REFUSED TO DO IT, NOW THERE IS A RECALL ON JUST THE FUEL TANK STRAPS WHAT ABOUT THE TANK AND THE FRAME AND CROSSMEMBERS THIS TRUCK IS A HAZARD TO BE ON THE ROAD THIS TRUCK SHOULD HAVE BEEN FIXED AT THE TIME WHEN I NOTICED THE PROBLEM. THE TRUCK HAS ABOUT 78000 ORIGINAL MILES ON IT NOW AND THE BODY LOOKS LIKE IT IS IN REAL GOOD SHAPE BUT THE FRAME AND CROSSMEMBERS LOOK LIKE THEY HAVE 250000 MILES ON IT. IS THERE ANYTHING THAT CAN BE DONE ABOUT THIS BECAUSE FORD DID NOT DO WHAT THEY SHOULD HAVE DONE BACK WHEN THERE WAS ONLY 31000 MILES ON IT. I ONLY USE THE TRUCK TO GO TO THE DOCTORS AND TOW A BOAT 4 OR 5 TIMES A YEAR THE TRUCK SITS IN THE DRIVEWAY MOST OF THE TIME. TOYOTA RECALLED A LOT OF TRUCKS WITH THIS PROBLEM FRAMES RUSTING OUT BEYOND REPAIR THEY HAD TO REPLACE THE OWNERS WITH NEW TRUCKS OR REFUND THE MONEY THEY PAID FOR THEM. THE TOYOTA'S WAS ABOUT THE SAME YEAR AS MY FORD THERE IS A DEFECT IN THE STEEL THAT THEY USED FOR MY TRUCK PLEASE HELP! *TR

2000 FORD F-150. CONSUMER STATES THE METAL GAS STRAPS THAT ATTACH THE GAS TANK TO THE TRUCK WERE RUSTED AND THE GAS TANK WAS LEAKING AS A RESULT *TGW THE DEALER STATED THE LEAK WAS A DIRECT RESULT FROM THE RUSTED METAL STRAPS. FORD STATED THEY WOULD NOT PAY FOR A NEW TANK, UNLESS THE TANK FELL OUT OF THE TRUCK AND CAUGHT FIRE. *JB

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS COMPLETELY RUST UNDER THE VEHICLE FROM FRONT TO BACK AND THERE WERE RUST PARTICLES FALLING OFF THE VEHICLE. THE FAILURE BEGAN THREE YEARS PRIOR. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 132,000.

TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A RECALL REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER:11V385000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING). AFTER THE REMEDY REPAIRS WERE PERFORMED, THE FUEL TANK BEGAN LEAKING A SIGNIFICANT AMOUNT OF FUEL. THE DEALER REFUSED TO TAKE RESPONSIBILITY IN CORRECTING THE DEFECT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THEY WERE UNABLE TO PROVIDE ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE HAVING REGULAR MAINTENANCE PERFORMED ON THE VEHICLE, HE WAS ADVISED THAT THE VEHICLE WAS IN NEED OF REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE TORAGE:TANK ASSEMBLY:MOUN). THE MECHANIC ALSO ADVISED THAT THE FUEL TANK NEEDED TO BE REPLACED SINCE THE STRAPS WERE SEVERELY CORRODED AND COULD POSSIBLY CAUSE A FUEL LEAK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE FUEL TANK WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 214,422.

THE VEHICLE WAS PARKED IN FRONT OF OUR HOUSE AND HAD NOT BEEN DRIVEN FOR SEVERAL HOURS BEFORE IT CAUGHT FIRE. I WAS IN THE BACK YARD WITH MY WIFE WHEN WE HEARD THE EXPLOSION AND WE RAN TO SEE WHAT IT WAS. WHEN I GOT TO THE FRONT OF THE HOUSE THE VEHICLE WAS ALREADY DESTROYED. THE HOOD HAD MELTED AND THE EXPLOSION WAS THE LEFT FRONT TIRE EXPLODING FROM THE HEAT COMING FROM UNDER THE HOOD. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. THIS WAS A TOTAL LOSS. *KB

REAR FUEL TANK STRAP BROKE, AND VERY CORRODED. FUEL TANK ONLY SIX INCHES FROM GROUND! USED A TIE DOWN STRAP RATED AT 300 POUNDS TO FASTEN FUEL TANK TO FRAME. *KB

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE SPARE TIRE DETACHED FROM THE VEHICLE AS A RESULT OF THE HOLSTER RUSTING AND FRACTURING. THE DEALER DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER WAS AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE APPROXIMATE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT HEARD A DRAGGING NOISE COMING FROM THE REAR WHILE DRIVING APPROXIMATELY 25 MPH. THE CONTACT THEN NOTICED THAT THE FUEL TANK WAS DRAGGING AND LEAKING FUEL ONTO THE GROUND. THE VEHICLE WAS STOPPED AND THEN TOWED TO AN AUTHORIZED DEALER, WHO STATED THAT THE FUEL TANK STRAPS WERE CORRODED. THE MANUFACTURER WOULD NOT ASSIST WITH THE FUEL TANK REPLACEMENT BECAUSE THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING). THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 250,000.

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR ROUTINE MAINTENANCE WHEN INFORMED THAT THE FUEL TANK STRAPS WERE FRACTURED AND ONLY ONE STRAP WAS LEAVING THE FUEL TANK ATTACHED TO THE VEHICLE. THE CONTACT SPOKE TO THE MANUFACTURER IN REGARDS TO NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM: TANK ASSEMBLY) AND WAS TOLD THAT THE VEHICLE AND STATE OF NEBRASKA WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 180,000. UPDATED 09/08/11*LJ THE REAR FUEL TANK STRAPS WERE REPLACED. UPDATED 09/14/11

IN APRIL 2011, WHILE DRIVING OUR FORD F150, MODEL YEAR 2000, ALONG A COUNTRY TWO-LANE ROAD IN A RURAL COUNTY IN VIRGINIA, AT APPROXIMATELY 40 MPH, THE GAS TANK DROPPED ONTO THE ROAD CAUSING A LARGE HOLE IN THE TANK AND THE LOSS OF NEARLY 3/4 TANK OF GASOLINE. I WAS ABLE TO BRACE THE TANK UP WITH A ROPE LONG ENOUGH TO GET TO OUR SON'S HOME A SHORT DISTANCE AWAY AND LUCKY ENOUGH NOT TO RUN OUT OF GAS UNTIL I PULLED INTO HIS YARD. THERE WAS NO INJURY BUT SPARKS FLEW FROM THE TANK AFTER IT DROPPED ONTO THE ROAD. FORTUNATELY THERE WAS NO FIRE. I HAD A MECHANIC REPLACE THE TANK AND THE STRAP AND HAVE HAD THE TRUCK BACK INTO THE SHOP TWICE TO REPAIR LEAKAGE AND HAD TO REPLACE THE NECK ASSEMBLY AS WELL. WE WERE MADE AWARE OF THE RECALL ON OUR MODEL F150 AND TOOK ALL RECEIPTS TO THE LOCAL DEALERSHIP. WE WERE TOLD THAT THIS TRUCK WAS NOT INCLUDED IN THE RECALL AND THE DEALER REFUSED REIMBURSEMENT. *KB

ON JULY 19, 2011 THE FUEL TANK DROPPED OUT FROM UNDERNEATH MY 2000 FORD F 150 WHILE GOING OVER THE BEACON NEWBURGH BRIDGE IN NY. GAS LEAKED ALL OVER AND HAD THE NYS POLICE AS WELL AS THE BEACON FIRE DEPT. INCIDENT WAS REPORTED TO THE NYDEC. NO FIRE BUT FUEL LEAKED OUT OF TANK. VEHICLE WAS TOWED TO GARAGE FOR REPAIR AT THE COST OF OVER $1100.00 NOT INCLUDING THE $190.00 TOWING FEE. I AM LUCKY THAT THIS TANK DID NOT BLOW BEFORE I COULD MAKE IT TO WERE I COULD PULL OVER SAFELY. THERE WAS NO BREAK DOWN LANE ON THE BRIDGE. *KB

TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE FUEL TANK SUDDENLY DETACHED FROM THE VEHICLE WITH A FULL TANK OF GASOLINE FUEL. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHO REPLACED THE FUEL TANK, MODULAR, STRAPS, HOSES, CLAMPS, AND THE TANK PRESSURE SENSOR. THE CURRENT AND FAILURE MILEAGES WERE UNKNOWN.

BRAKE FAILURE WHILE DRIVING DUE TO CORRODED BRAKE LINE ABOVE FUEL TANK. NO WARNING LIGHTS PRIOR TO OR AFTER FAILURE. *KB

ON FRIDAY, JULY 29, 2011 I NOTICED SOMETHING HANGING DOWN BELOW MY 2000 MODEL YEAR FORD F150 PICKUP TRUCK. UPON CLOSER INVESTIGATION I DISCOVERED THAT THE DANGLING OBJECT WAS THE REMAINS OF THE FRONT FUEL TANK MOUNTING STRAP WHICH HAD FAILED DUE TO CORROSION. THE FRONT OF THE FUEL TANK WAS DROOPING DOWN FOUR TO SIX INCHES FROM ITS NORMAL POSITION AND THE TANK WAS BEING HELD ONLY BY THE REAR STRAP. EXAMINATION OF THE REAR STRAP REVEALED THAT IT WAS ALSO SEVERELY RUSTED. THE FOLLOWING MORNING I PURCHASED NEW FRONT AND REAR FUEL TANK MOUNTING STRAPS FROM MY LOCAL FORD DEALER'S PARTS DEPARTMENT AND INSTALLED THEM MYSELF. AS A RETIRED ENGINEER, I WAS DISAPPOINTED BY HOW FLIMSY THESE STRAPS ARE AND HOW THEIR CORROSION RESISTANCE IS OBVIOUSLY INADEQUATE TO PREVENT FAILURE. THAT EVENING, SATURDAY, JULY 31, 2011, THERE WAS A REPORT ON A LOCAL TELEVISION STATION OF A HAZMAT TEAM RESPONSE TO AN INCIDENT NEAR GOOD HOPE ROAD AND US HIGHWAY 45 IN MILWAUKEE, WISCONSIN IN WHICH THE FUEL TANK OF A FORD F150 PICKUP HAD FALLEN TO THE GROUND DUE TO FAILURE OF THE FUEL TANK STRAPS. THAT LED ME TO THE DISCOVERY THAT NHTSA HAS BEEN INVESTIGATING CORROSION FAILURES OF FUEL TANK MOUNTING STRAPS ON F150S. I BELIEVE THE EVIDENCE SHOWS THAT A VEHICLE SAFETY DEFECT IS PRESENT IN THE DESIGN OF THESE STRAPS, IN THAT THE DESIGN IS INSUFFICIENT TO PREVENT OR WITHSTAND CORROSION WHICH COULD REASONABLY BE EXPECTED TO OCCUR DURING THE NORMALLY EXPECTED LIFETIME OF THE VEHICLE. I STRONGLY URGE THAT A MANDATORY R

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE WITHOUT WARNING. A FIRE REPORT WAS NOT FILED FOR THE INCIDENT AND THE CAUSE OF THE FIRE WAS UNKNOWN. NEITHER THE DEALER NOR MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 160,000. UPDATED 8/29/11 *CN THE CONSUMER BELIEVED THE CRUISE CONTROL DEACTIVATION SWITCH WAS TO BLAME FOR THE FIRE. UPDATED 09/09/11 THE MASTER CYLINDER WAS REPLACED AND THE BRAKE SYSTEM WAS BLEW. THE WIRING TO THE CRUISE CONTROL DEACTIVATION SWITCH WAS REPLACED AS WELL AS THE SPEED CONTROL CABLE. THE TURN SIGNALS, FUSE AND JUNCTION BOX WAS REPLACED. UPDATED 09/21/11