2000 Ford F-150 complaints

DT*: THE CONTACT STATED THE VEHICLE ERUPTED INTO FLAMES AFTER BEING PARKED FOR AN HOUR. THERE WERE NO PROBLEMS WITH THE VEHICLE PRIOR TO THE INCIDENT. THE VEHICLE WAS TOTALED. THE SERVICE DEALER REMOVED THE CRUISE CONTROL ONE YEAR AGO BECAUSE OF THE POTENTIAL OF FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND DETERMINED THE FIRE STARTED IN THE FRONT ENGINE COMPARTMENT UNDER THE HOOD. THE FIRE DEPARTMENT ALSO DETERMINED ALL OF THE WIRE HARNESSES WERE INTACT.

(1) DUE TO THE PARTICULAR DESIGN FLAW OF THE " TIE END RODS" (THE TIE ENDS DO NOT HAVE A GREASE NIPPLE TO ALLOW CRITICAL LUBRICATION OF THESE PARTS!), THE PASSENGER SIDE "UPPER TIE END ROD" COMPLETELY SEPARATED FROM ITS NORMAL POSITION WHILE THE VEHICLE WAS IN MOTION. (2) THE VEHICLE OPERATOR WAS UNABLE TO STEER THE VEHICLE TO A SAFE CLEARANCE AND WAS FORCED TO IMMEDIATELY STOP ON A TWO LANE BRIDGE AND BLOCK ONE OF THE LANES. (3) ALL OF THE "TIE ENDS RODS" WERE REPLACED WITH NEW PARTS THAT HAVE A NIPPLE FOR LUBRICATION SO THAT THE "WEAR" ITEM CAN BE MAINTAINED BY APPLYING GREASE. THE OLD PART IS AVAILABLE. *NM

MY 2000 F-150 FORD PICKUP. I WENT OUT IN MY DRIVEWAY AND NOTICED SOMETHING HANGING DOWN FROM UNDER THE TRUCK. IT TURNED OUT TO BE THE REAR STRAP THAT HOLDS THE GAS TANK ON THE TRUCK. IT HAS RUSTED AND CAME APART. THE GAS TANK HAD DROPPED DOWN ABOUT 3 INCHES AND HAS ALL THE HOSES PULLED TIGHT. FORD SAYS THERE ARE NO RECALL ON MY TRUCK. *JB

TRANSMISSION WENT OUT. VEHICLE IS ONLY DRIVEN ABOUT 200 MILES A WEEK, AND SITS FROM MONDAY TO FRIDAY WITHOUT BEING DRIVEN AT ALL. IT JUST WENT OUT WHILE DRIVING DOWN THE ROAD. HAS NOT BEEN FIXED YET. WAS NOT GOING FAST AT THE TIME BECAUSE WE HAD JUST STOPPED AT A LIGHT AND WHEN WE STARTED DRIVING IT HAD NO POWER. *NM

WAS DRIVING ON FREEWAY FORD F150 PICKUP ENGINE BLOW OUT THE #1 SPARK PLUG, SECOND 6 MTHS AGO SAME ENGINE BLOW OUT THE #4 REAR SPARK PLUG NEAR PASSENGER, NOW HAVE TO REPLACE ENGINE VERY COSTLY. *NM

I OWN A 2000 FORD F-150 AND YESTERDAY THE HEATER CORE STARTING LEAKING. THIS TRUCK HAS BEEN SERVICED ACCORDING TO THE MANUAL. I ONLY HAVE 64000 MILES ON IT. I HAVE CONTACTED SEVERAL REPAIR SHOPS AND WAS TOLD THAT FORD HAS HAD PROBLEMS WITH THE CORE FAILING AND THAT THEY HAD A RECALL ON IT. I CONTACTED SEVERAL FORD DEALERSHIPS IN MY AREA AND WAS TOLD THERE WAS NO RECALLS ON THIS PROBLEM. I HAVE HAD ESTIMATES OF FROM $600.00 TO $800.00 TO FIX THE PROBLEM. I AM GOING TO GET IT FIXED BUT I WOULD LIKE TO KNOW IF THERE WAS A RECALL ON THIS PROBLEM ?????? THIS PART SHOULD NOT HAVE FAILED THIS SOON. *NM

DT*: THE CONTACT STATED THE DOOR LOCKS FAILED TO OPERATE NORMALLY USING THE KEY FOB. THE LOCKS MUST BE MANUALLY OPENED OR CLOSED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO DETERMINED THE ACTUATOR NEEDED TO BE REPLACED. THE CONTACT MADE SEVERAL ATTEMPTS TO PURCHASE A USED ACTUATOR FROM LOCAL JUNK YARDS WITHOUT SUCCESS.

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY, IT ERUPTED INTO FLAMES. THE FIRE DEPARTMENT CAME AND EXTINGUISHED THE FIRE. THE MANUFACTURER SENT A REPRESENTATIVE TO INSPECT THE REMAINS OF THE VEHICLE. THE FIRE WAS TOO EXTENT TO DETERMINE THE EXACT CAUSE. THE CONTACT RECEIVED A RECALL LETTER SEVERAL WEEKS AFTER THE INCIDENT; NHTSA RECALL # 05V388000 CONCERNING THE CRUISE CONTROL.

A VEHICLE FIRE OCCURRED ON A 2000 FORD F150 AT THE HOME OF THE OWNER ON MARCH 8, 2006. THE FIRE STARTED IN THE ENGINE COMPARTMENT OF THE TRUCK WHILE IT WAS PARKED UNDER THE CARPORT, WITH THE ENGINE OFF, AND THE IGNITION KEY REMOVED. THE TRUCK HAD BEEN PARKED APPROXIMATELY 2 1/2 HOURS WHEN THE FIRE OCCURRED. WHEN THE FIRE WAS DETECTED, FLAMES HAD ALMOST REACHED THE CEILING OF THE CARPORT. THE OWNER WAS ABLE TO PUSH THE TRUCK INTO THE STREET, WHERE IT CONTINUED TO BURN UNTIL EXTINGUISHED BY THE FIRE DEPARTMENT. THE TRUCK WAS DESTROYED IN THE FIRE. ON MARCH 20, 2006, AND INDEPENDENT INVESTIGATOR INSPECTED THE VEHICLE AND DETERMINED THAT THE FIRE WAS CAUSED BY FAILURE OF THE SPEED CONTROL DEACTIVATION SWITCH. THE INVESTIGATOR DOCUMENTED HIS INVESTIGATION WITH PHOTOGRAPHS. FORD MOTOR COMPANY (FMC) STATED THAT THE VEHICLE WAS INCLUDED IN A RECALL TO CORRECT A PROBLEM WITH SPONTANEOUS FIRES ERUPTING IN THE SPEED CONTROL DEACTIVATION SWITCH, BUT THE OWNER WAS NEVER NOTIFIED OF A RECALL. THE OWNER HAS CONTACTED AND PROVIDED INFORMATION AND PHOTOGRAPHS TO THE FMC SPEED CONTROL DEACTIVATION SWITCH RECALL CUSTOMER INFORMATION TEAM, FMC CONSUMER AFFAIRS, AND THE LOCAL FMC DEALERSHIP. *NM

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED, IT ERUPTED INTO FLAMES ON THE LEFT DRIVER'S SIDE UNDERHOOD AREA. THE FIRE DEPARTMENT WAS CONTACTED AND EXTINGUISHED THE FLAMES. A MANUFACTURER REPRESENTATIVE INSPECTED THE VEHICLE AND TOOK PICTURES OF THE SEVERE FIRE DAMAGE. AFTERWARDS, THE REPRESENTATIVE SUGGESTED THAT DUE TO THE EXTENSIVE FIRE DAMAGE, IT COULD NOT BE DETERMINED IF THE FIRE WAS CRUISE CONTROL RELATED. THE VEHICLE WAS INCLUDED IN THE NHTSA RECALL # 05V388000 CONCERNING THE CRUISE CONTROL, BUT NO RECALL NOTIFICATION WAS RECEIVED BY THE CONTACT.

2 ENGINE FAILURES. *JB

SHORTLY AFTER MY RECALL THE SWITCH SHORTED OUT, I TOOK MY VEHICLE TO VELDE FORD IN VERO BEACH FLORIDA, THEY CLAIM THEY REPLACED THE PARTS REQUIRED FOR THE RECALL AND MY CRUISE CONTROL STILL WASN'T BACK TO BEING OPERATIONAL (WHICH IT WAS PRIOR TO THE FIRE) AND CHARGED ME 246.78 PLUS TAX TO DO THE REPAIR. THEY CLAIM IT WAS UNRELATED. *JB

DT*: THE CONTACT STATED WHILE DRIVING 45 MPH, THE DRIVER SIDE TIRE STARTED BOUNCING. THE VEHICLE WAS PULLED OVER AND TOWED TO THE CONTACT'S RESIDENCE WERE IT WAS REPAIRED BY A FAMILY MEMBER. THE INNER TIE ROD WAS REPLACED ON THE DRIVER SIDE. ALSO, WHILE PULLING INTO A PARKING SPACE AT LESS THAN 5 MPH, THE PASSENGER SIDE TIRE DID NOT RESPOND TO THE STEERING WHEEL. THE VEHICLE WAS AGAIN TOWED TO THE RESIDENCE AND THE PASSENGER SIDE INNER TIE ROD WAS REPLACED. THE MANUFACTURER HAS BEEN ALERTED.

I BOUGHT A 2000 FORD F-150 WITH THE 4.2L V6 ENGINE AND I NOW HAVE TO REPLACE THE ENGINE BECAUSE OF A DEFECT THAT FORD IS AWARE OF I HAVE DONE A LOT OF RESEARCH ON THIS ISSUE AND HAVE FOUND THOUSANDS OF OTHER 4.2L V6 OWNERS THAT HAVE THE SAME PROBLEM AND FORD WILL NOT DO ANYTHING ABOUT IT I HAVE ASKED FORD FOR HELP IN THE REPLACEMENT OF THE ENGINE. I WAS GIVEN EXCUSES AND TOLD TO GO AWAY AND BUY A NEW ENGINE. I TRIED TO MAKE A FORMAL COMPLAINT TO FORD BUT I WAS TOLD THAT IT WOULD BE BROUGHT TO THEIR ATTENTION WITH NO PAPERWORK FILLED OUT. I AM VERY UPSET WITH THE WAY A LOYAL CUSTOMER OF FORD IS BEING TREATED. I NOW HAVE TO REPLACE THE ENGINE BUT CANNOT AFFORD TO. THERE IS A DEFECTIVE SEAL OR GASKET THAT LEAKS ANTIFREEZE INTO THE ENGINE AND CAUSES PISTONS TO BREAK ROD TO BE PUSHED OUT OF THE ENGINE AND SEVERAL OTHER INTERIOR ENGINE PARTS TO BREAK. FORD MOTOR COMPANY WILL NOT REPLACE THE ENGINE EVEN THOUGH IT IS A DEFECT ON THEIR BEHALF NOT THE BUYER. FORD DOES NOT TELL NEW CUSTOMERS ABOUT THE PROBLEM AND CONTINUE TO SELL THE VEHICLES KNOWING THAT THE ENGINE IS DEFECTIVE. ALL I WOULD LIKE IS FOR FORD TO TAKE RESPONSIBILITY FOR THEIR ENGINE AND REPLACE IT WITH A DIFFERENT ENGINE OR MAKE SURE THAT THE NEW ENGINE WILL NOT CAUSE THE SAME PROBLEM. *JB

"FRONT ENGINE COVER GASKET FAILED IN LINE WITH RECALL 99B29. FORD DOES NOT INCLUDE MY TRUCK, BUILT 05/99 IN RECALL CAMPAIGN 99B29 INDICATING THE ORIGINAL RECALL HAS BEEN INADEQUATE." *JB

THE SPARK PLUG BLEW OUT OF THE HEAD, REPAIR WAS VERY COSTLY. THIS SHOULD NOT HAPPEN. I ALSO HAVE HAD 3 COIL PACKS GO BAD ON THIS VEHICLE. *JB

WELL I GOT SUCKERED OCT 4 2003 INTO A 2000 F-150 W/52,000 MILES . MY LOVELY TRUCK WAS DOING GREAT UNTIL SEPT 2004 AND THEN MY TRANNY WENT OUT. JUST BLEW OUT. WELL $1400 DOLLARS AND A LOT OF (I MEAN A LOT) OF MONEY AND TIME LATER (NOV 2004) I GOT IT FIXED (HAPPY TIMES RIGHT?). DAD, ME SOME BUDDIES PUT THE TRANNY IN. SO I AM DOING GREAT AND THEN I STARTED TO SMELL ANTI FREEZE AND WELL SOME TIME LATER IN AUG 2005 IT STARTED A STEEM SHOP OUT THE EXHAUST. WATER, ANTI FREEZE AND OIL THAT IS WHAT IS WAS. LOOKED LIKE HEAD GASKET OR HEAD MIGHT BE CRAKED SO GOT NEW GASKET SET AND GOT HEADS TESTED AND RESHAPED AND NEW HEAD BOLTS.($400 LATER) WELL I FINALY GOT TO GETTING IT BACK TOGETHER AND IT IS STILL SMOKING (TODAY IN DEC 2005). SO SOMETHING BAD IS WRONG MAYBE BLOCK IS CRAKED. I DONT KNOW BUT I AM VERY MAD I OWE $12,000 ON IT.

THE PASSENGER SIDE REAR SPARK PLUG BLEW OUT OF THE ENGINE HEAD. THIS TRUCK HAS 54,000 MILES ON IT AND IS VERY WELL MAINTAINED. REPAIR ESTIMATES ARE IN EXCESS OF $3,000.00. THIS HAPPENED IN A WELL TRAVELED AREA AND IT WAS ME AND NOT MY WIFE AND KIDS STRANDED. THERE IS AN OBVIOUS FLAW IN THE HEAD DESIGN THAT FORD HAS SINCE RECTIFIED. IT IS OUTRAGEOUS THAT A $30,000 TRUCK THAT IS WELL MAINTAINED SHOULD HAVE THIS KIND OF FAILURE 18,000 MILES OUT OF FACTORY WARRANTY. *NM

I OWN A 2000 FORD F-150. ONE OF THE SPARK PLUGS BLEW OUT OF IT'S HOLE CAUSING PROBLEMS WITH THE ENGINE. *JB

THERE ARE NO EVENTS THAT INDICATE ANYTHING IS WRONG UNTIL THE ENGINE HAS NO POWER AND RUNS ROUGH. A COIL PACK FAILURE ON # 8 CYLINDER ON 11/14/05. A COIL PACK FAILURE ON # 6 CYLINDER ON 12/05/05. A COIL PACK FAILURE ON # 1 CYLINDER ON 12/15/05. ALL INCIDENTS SHOW A MISFIRE ON A PARTICULAR CYLINDER. CORRECTION TO THE PROBLEM IS TO HAVE A COIL PACK INSTALLED ALONG WITH A SPARK PLUG. DEALER SUGGESTS REPLACEMENT OF ALL COIL PACKS. *JB

I HAVE A 2000 F-150 THAT I HAVE HAD SINCE 2000. I KEPT MY TRUCKS OIL CHANGED ON A REGULAR BASIS. ON A NOVEMBER SATURDAY AS MY FAMILY AND I WAS GOING TO VISIT SOME RELATIVES ABOUT 30 MILES AWAY FROM MY HOME. MY TRUCK SHUT DOWN WITHOUT ANY APPARENT REASON. I HAD IT TOWED TO THE NEAREST FORD DEALERSHIP TO BE CHECKED. THE TECHNICIAN SAID THAT THE TIMING HAD JUMPED AND THE OIL PRESSURE DROPPED. THE TECHNICIAN TOOK THE VALVE COVERS OFF TO SEE WHAT THE PROBLEM WAS. TO HIS SURPRISE IT WAS STILL FILLED WITH OIL AND AFTER DOING A MORE IN-DEPTH STUDY OF THE ENGINE, SLUDGE WAS IN THE OIL PAN AND EVERYWHERE ELSE. I ASKED THE FORD TECHNICIAN AS TO HOW COULD THIS HAVE HAPPENED AND WITH A REPLY OF I DON'T KNOW. AS A RESULT MY MOTOR IS NO GOOD. *NM

MY SON WAS TRAVELING ABOUT 45 MPH AND A CAR TURNED LEFT IN FRONT OF HIM. HE HIT THE CAR IN THE DRIVERS SIDE AND NEITHER ONE OF HIS FRONTAL AIR BAGS DEPLOYED. THE OTHER DRIVER WAS IN A HONDA CIVIC AND BOTH HIS AIR BAGS DEPLOYED. MY SON HAD BACK, NECK, ARM, KNEE AND LEG INJURIES. THE POLICE AND FIRE DEPT SAID THE AIR BAGS SHOULD HAVE DEPLOYED. THE TRUCK IS BEING LOOKED AT NOW TO DETERMINE IF IT CAN BE FIXED OR TOTALED. *JB

DT: THE CONTACT REPLACED THE RADIATOR SEVERAL TIMES ON HIS VEHICLE. THE DEALER SAID THERE WAS NO SOLUTION FOR THE RADIATOR PROBLEM. THEY SUGGESTED PURCHASING AN AFTER MARKET RADIATOR AFTER THE WARRANTY EXPIRES ON HIS VEHICLE. *AK THE CONSUMER RECEIVED A RECALL NOTICE IN THE MAIL REGARDING THE RADIATOR AS PART OF THE TRAILER TOWED PACKAGE. THE DEALER INSTALLED THE UPGRADE RADIATOR, HOWEVER AFTER THE INSTALLATION, THE CONSUMER HAD NOTHING BUT PROBLEMS. THE RADIATOR HAD TO BE REPLACED 5 TIMES. UPDATED 11/29/05. *JB

ENGINE FIRE. *JB

MY HUSBAND AND I WERE GOING TO WORK IN EVERGREEN CO. WHEN SOMETHING BLEW IN THE FRONT OF OUR TRUCK. WE HAD A IMMEDIATE STRONG SMELL OF GAS AND THE TRUCK STARTED TO SHAKE AND MAKE VERY LOUD NOISES. A GARAGE IN EVERGREEN LOOKED AT OUR TRUCK AND TOLD US WHAT HAD HAPPENED TO IT AND SAID NOT TO DRIVE IT TO FAR BECAUSE IT COULD HURT THE ENGINE MORE THAN IT DID. WE WENT AND BOUGHT A COIL AND SPARK PLUG AND WAITED ALL DAY FOR THE GUY TO FIX THE TRUCK. HE SAID WE WERE LUCKY HE HAD A TOOL TO FIX IT BECAUSE HE HAD THE ONLY ONE IN EVERGREEN. HE HAD TO RETHREAD THE BLOCK SO THAT HE COULD PUT THE NEW PLUG AND NEW COIL ON. HE ALSO TOLD US OTHER PEOPLE HAVE HAD THIS SAME PROBLEM IN EVERGREEN. *JB

WHEN STEERING WHEEL IS NOT ALL THE WAY UP THE TURN SIGNALS, HAZARD LIGHTS, AND THE BRAKE LIGHTS DO NOT WORK. I HAVE TAKEN IT TO THE DEALERSHIP AND THEY STATE THAT THERE IS A CLIP IN THE STEERING COLUMN THAT IS BROKE. THIS ALL HAPPENED 2 MONTHS AFTER I BOUGHT THE TRUCK AND THEY WILL NOT FIX IT DUE TO THERE BEING NO WARRANTY. AT THE SAME TIME THE KEYLESS ENTRY STOPPED WORKING AS WELL AS THE AUTOMATIC DOOR LOCKS. THEY STATED THAT THIS WAS BECAUSE THE MOTOR IN BOTH DOORS HAD WENT OUT. SEEMS ODD TO ME THAT THEY WOULD BOTH GO AT THE SAME TIME. *JB

DT:THE CONTACT STATED SHE HAD A PROBLEM WITH THE UPPER BALL JOINTS. WHILE DRIVING AT HIGHWAY SPEEDS THE FRONT END SHIMMIED. ALSO, THERE WAS EXCESSIVE TIRE WEAR. SHE CONTACTED THE MANUFACTURER, AND THERE WERE *AK NO RECALLS ON THE VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED.

DT: THE CONTACT STATED THE FRONT SEAT BELT RETRACTOR QUIT WORKING WITHOUT ANY PREVIOUS PROBLEMS. THE SEAT BELT WILL RETRACT AND NOT GIVE ANY SLACK. HE UNBOLTED THE SEAT BELT FITTING FROM THE FLOOR TO ALLOW THE STRAP TO GO IN FURTHER. THE STRAP CAME OUT, BUT SUBSEQUENTLY THE SAME THING HAPPENED AS BEFORE. THIS DID NOT CORRECT THE PROBLEM. HE BOLTED BACK THE SEAT BELT FITTING. THE VEHICLE HAS NOT SEEN BY A DEALER. NO FURTHER REPAIRS OR CORRECTIONS WERE MADE. *AK UPDATED 11/29/05. *JB

MY F150 VIN NUMBER 1FTRX18LOYKA71643 IS INVOLVED IN SAFETY RECALL 05S28 REGARDING THE SPEED SENSOR. EACH MONTH I CALL DEALERS BUT THEY CONTINUE NOT TO HAVE PARTS TO FIX THIS DEFECT. I RECEIVED A NOTICE IN MAY STATING PARTS HAVE BEEN SENT BUT DEALERS ARE OUT. CALLED FORD CUSTOMER SERVICE AND THEY CONFIRM THIS BUT ARE UNABLE TO GET ME ON A LIST TO GET RECALL DONE IN A TIMELY MANNER. *JB

I OWN A 2000 F150 SUPERCAB WITH THE 5.4L V8 TRITON GASOLINE ENGINE. THIS TRUCK ABS BEEN METICULOUSLY MAINTAINED. ON SUN 17 JULY 2005, WHILE DRIVING WITH MY WIFE AND ONE OF MY SONS, I EXPERIENCED WHAT I LATER FOUND OUT TO BE THE SPARK PLUG BEING BLOWN-OUT OF THE #3 CYLINDER JUST AS WE WERE TRYING TO MERGE ONTO A BUSY HIGHWAY--WE WERE LUCKY TO MAKE IT TO A BREAKDOWN LANE WITHOUT INJURIES. I OPTED FOR THE "HELI-COIL" REPAIR METHOD BASED UPON THE DESCRIBED SUCCESS RATE. ON WED 28 SEP 2005 I BROKE DOWN ON MY WAY TO WORK AFTER THE SPARK PLUG ON #4 BLEW-OUT. THE LOCAL DEALER EXPLAINED THAT FORD HAS A NEW DESIGN FOR THE CYLINDER HEAD BUT THIS REPAIR WAS ESTIMATED AT NEARLY THE SAME COST AS A LONG BLOCK REPLACEMENT WHICH I ULTIMATELY OPTED FOR. THE LOCAL DEALER EXPLAINED THAT THEY DIDN'T BELIEVE FORD WOULD COVER THE COST OF THESE REPAIRS (OR EVEN HELP WITH THE COST) BECAUSE THEY DON'T VIEW THIS AS A "DESIGN PROBLEM" AS I DO. AFTER REPEATED ATTEMPTS TO TRY TO PERSUADE FORD THROUGH THEIR CUSTOMER CARE CENTER WHERE I WAS FLATLY TURNED DOWN I HAD TO PAY FOR THE REPAIR MYSELF. *NM

PASSENGER SIDE #3 PLUG BLOWN OUT TWO MONTHS LATER #4 BLOWN OUT. CALLED FORD AND WAS TOLD THAT THERE WAS NOT A PROBLEM WITH THAT HEAD. *NM

2000 FORD F-150 LARIAT 4 X 4 WINDSHIELD LEAKS. AS A RESULT OF THIS LEAK THE WINDSHIELD WIPERS SPORADICALLY GO ON. THE SWITCH IS OFF BUT THE WIPERS JUST COME ON. I HAVE TO PULL THE FUSE SO IT WILL NOT HAPPEN. WHEN IT RAINS I HAVE TO PUT THE FUSE BACK IN SO THEY WILL WORK.*JB

DT: 2000 FORD F150. THE CONTACT STATED THE WINDSHIELD WIPER MOTOR HAD TO BE REPLACED BECAUSE IT QUIT. THE MECHANIC THOUGHT IT MAY BE UNDER RECALL SO HE ADVISED THE CONTACT TO CALL FORD AND INQUIRE. FORD STATED THERE WAS NO RECALL BASED ON THE VEHICLE IDENTIFICATION NUMBER. THE CONTACT THEN FOUND RECALL, 01V258000. THE CONTACT WOULD LIKE TO BE REIMBURSED FOR THE WORK HE HAD DONE TO HIS VEHICLE. THE MOTOR WAS REPLACED ON SEPTEMBER 1, 2005. *AK UPDATED 11/16/05. *JB

TRUCK WAS PARKED IN DRIVE WAY FOR APPROXIMATELY. 18 HOURS NOT RUNNING. TRUCK CAUGHT FIRE , 2000 F150. *JB

DT: 2000 FORD F150. THE CONSUMER STATED THAT THE TIE ROD END LET GO WHILE IN MOTION. THIS OCCURRED ON OCTOBER 3, 2005. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALERSHIP. THE VEHICLE WAS TOWED TO CONSUMER'S RESIDENCE. THE CONSUMER HAD NOT CALLED FORD. THERE WAS NO WARNING BUT THERE WAS A SMALL VIBRATION IN THE STEERING WHEEL THEN THE TIE ROD COMPLETELY LET GO. THERE WAS NO ACCIDENT AND NO ONE WAS INJURED. *SC . *AK

DT: THE CONSUMER STATED 2000 FORD F150 CAUGHT ON FIRE AND BURNED. THIS OCCURRED ON SEPTEMBER 25, 2005. THE VEHICLE HAD BEEN PARKED BETWEEN FOUR TO FIVE HOURS. EVERYTHING ON THE VEHICLE WORKED CORRECTLY. THE CRUISE CONTROL HAD NOT BEEN USED ANYTIME RECENTLY. THE FIRE BEGAN ON THE LEFT SIDE OF THE ENGINE ACCORDING TO THE FIRE INVESTIGATOR. THE TRUCK WAS PARKED IN THE CAR PORT, AND THE CONSUMER WALKED OUT AND FOUND THE VEHICLE COMPLETELY ENGULFED IN FLAMES. THE FIRE DEPARTMENT CAME AND PUT THE FIRE OUT. THE CONSUMER HAD NOT RECEIVED ANY RECALL LETTER ON THE VEHICLE. FORD MOTOR COMPANY HAS BEEN CALLED ,AND THE CONSUMER FILED A REPORT WITH THEM. FORD REPLIED THAT CONSUMER'S INSURANCE COMPANY WOULD BE BACK IN TOUCH WITH THEM. THE DEALERSHIP HAS NOT BEEN CONTACTED AT THIS POINT, BUT WILL BE CALLED LATER. THE INSURANCE COMPANY CAME AND TOOK THE TRUCK TO DO THEIR OWN INVESTIGATIONS. FIRE AND INSURANCE REPORTS WERE TAKEN. . THE CONSUMER HAS PICTURES AVAILABLE TO VIEW. THERE WAS ADDITIONAL PROPERTY DAMAGE TO THE CAR PORT. THERE WERE NO INJURIES. THE TRUCK WAS TOTALED. THE CONSUMER WILL HAVE ACCESS TO WHEN THE COPY WILL BEE RECEIVED. WILL ALSO PROVIDE INFORMATION FOR NHTSA. *AK

DT: THE CONSUMER STATES THAT THE 2000 FORD F150 (LARIAT SUPER CAB) CAUGHT ON FIRE AND BURNED. THE ENTIRE FRONT END WAS DESTROYED. THE FIRE STARTED UNDER THE HOOD IN FRONT OF THE DRIVER'S SIDE. THE CONSUMER HAD JUST GOTTEN OUT OF THE TRUCK ABOUT FIVE MINUTES PRIOR. THE CRUISE CONTROL HAD NOT BEEN USED. THE TRUCK WAS LIKE NEW AND EVERYTHING WAS IN WORKING ORDER. THE TRUCK WAS REGULARLY MAINTAINED. THE TRUCK WAS ENGULFED IN FLAMES WITHIN A FEW SECONDS. A WITNESS STATED TO THE OWNER THAT THE TRUCK SOUNDED LIKE IT WAS TRYING TO START IT. THE WITNESS SAID THE TRUCK SOUNDED LIKE THE ENGINE WAS CRANKING. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. THE FIRE CHIEF STATED THAT THE FIRE STARTED ON THE DRIVER'S SIDE UNDER THE HOOD. THE POLICE WERE ALSO PRESENT. FIRE REPORT, POLICE REPORT , AND INSURANCE REPORT WERE TAKEN. THE CONSUMER WAS GOING TO TAKE PICTURES OF THE VEHICLE. THE DEALER AND MANUFACTURER HAVE NOT BEEN CALLED AT THIS TIME, BUT WILL BE CALLED. *AK (11/04/05) PER FIRE REPORT, THE FIRE WAS COMING FROM THE ENGINE. *SC

2000 FORD F150 DEVELOPED A PROBLEM WITH THE RADIO EQUIPMENT.*MR *NM

DT: THE CONSUMER STATED WHILE TRAVELING AT 5 MPH IN 2000 FORD F150 THE GAS TANK FELL OFF THE TRUCK. THE WHOLE GAS TANK, LINES AND SENSOR FELL RIGHT OFF THE TRUCK. THE TRUCK HAS BEEN TAKEN TO A DEALERSHIP FOR REPAIRS. THE CONSUMER CALLED FORD, AND FORD STATED, THAT THEY COULD NOT HELP OUT. THE CONSUMER SAID THAT EVERYTHING WAS FINE WITH THE TRUCK BEFORE THIS. THE TANK WAS COMPLETELY FULL OF FUEL AT THE TIME.*AK

2000 FORD F-150 CAUGHT FIRE AND BURNED COMPLETELY. TRUCK WAS NOT RUNNING AT THE TIME AMD HAD NOT BEEN RUN FOR OVER 24 HOURS. FIRE STARTED AT THE FRONT OF THE VEHICLE ACCORDING TO FIRE DEPARTMENT. I WAS NOT HOME AT THE TIME OF THE FIRE.

2000 FORD LIGHTNING SUPER CHARGER INTERCOOLER LEAKS COOLANT INTO THE ENGINE. ONCE THE COOLANT IS DRAINED, IT CAN CAUSE A CONDITION CALLED VAPOR LOCK, WHICH WILL LOCK THE MOTOR WITHOUT WARNING. THIS WOULD BE CAUSE FROM THE SUPER HEATED AIR THEN ENTERING FROM THE SUPER CHARGER. THIS COULD CAUSE AN ACCIDENT, AND I'M SURE IS NOT GREAT FOR EMISSIONS SINCE COOLANT IS NOW BEING LEAKED INTO THE COMBUSTION CHAMBER. *JB

THE HARLEY DAVIDSON F150 WAS PARKED IN THE DRIVEWAY FOR APPROX. 4 HOURS, WHEN A NEIGHBOR INFORMED ME MY TRUCK WAS ON FIRE. THE TRUCK WAS DESTROYED FROM THE FRONT BUMPER TO THE DASH. THE FIRE DEPARTMENT REPORT STATED THE FIRE STARTED AROUND THE WIRING HARNESS AROUND THE MATER CYLINDER. *JB

DT: THE VEHICLE CAUGHT ON FIRE ON SEPTEMBER 17, 2005. THIS OCCURRED WITHOUT PREVIOUS WARNING. THE CONSUMER STATED THAT IT STARTED IN THE STEERING COLUMN AREA BECAUSE THE MOST OF THE HEAT WAS COMING FROM THERE. HAD NO PROBLEMS WITH THE VEHICLE BEFORE. HE WAS UNSURE IF THE CRUISE CONTROL WAS ON. *AK

DT: THE CONTACT STATED ON 7-12-05 2000 FORD F150 CAUGHT ON FIRE. IT WAS LOCATED IN FRONT OF THE CONTACT'S HOUSE. THE FIRE ORIGINATED UNDER THE HOOD ON THE DRIVER'S SIDE. THE FIRE DEPARTMENT AGREED THAT ORIGINATED UNDER THE HOOD. FORD TOLD THE CONTACT TO TAKE VEHICLE TO THE DEALER. THE DEALER SAID THE VEHICLE WAS SO BURNED THAT THEY COULD NOT TELL WHAT HAPPENED. THEN THE DEALER SAID IT DID NOT LOOK LIKE THE VEHICLE WAS BURNED ENOUGH TO DETERMINE THAT THE CAUSE WAS THE SCDS. THE CONTACT RECEIVED A RECALL LETTER IN AUGUST 05. THE CONTACT REPORTED HAVING NO PROBLEMS WITH THE CAR. PRIOR TO THIS, THE CALLER REPORTED HAVING NO PROBLEMS WITH THE CRUISE CONTROL. HE NOTICED THAT RIGHT SIGNAL LIGHT FUSE KEPT BLOWING AND HE HAD TO REPLACE IT OFTEN. THE POLICE DID VISIT THE SCENE BUT DID NOT MAKE A REPORT.*AK

OUR 2000 FORD 150, VIN [XXX], CAUGHT FIRE AFTER OUR SUPERVISOR PARKED THE VEHICLE WHEN HE WAS CHECKING ON CREWS, IT IS DUE TO THE CRUISE CONTROL SWITCH. FORD SAID THEY SENT US TWO RECALL LETTERS, BUT WE NEVER RECEIVED THEM AND THEY CAN NOT PROVE THAT THEY SENT THEM, THEY SENT US COMPUTER GENERATED GENERIC FORMS SHOWING DATES THAT THEY COULD HAVE TYPED IN AFTER THE FIRE SO THEY WOULDN'T HAVE TO PAY. ANYWAY WE PURCHASED THE VEHICLE IN MID-JANUARY AND THEY SAY THEY SENT US OUR FIRST RECALL LETTER IN FEBRUARY, THEY WOULD NOT HAVE HAD OUR INFORMATION THAT FAST. ANYWAY, OUR INSURANCE PAID FOR THE REPAIRS LESS OUR DEDUCTIBLE. I HAVE WRITTEN TO WILLIAM C FORD, HE DIDN'T REPLY BUT WE RECEIVED A POSTCARD ASKING US TO CALL THE CUSTOMER SERVICE DEPARTMENT WHICH WE DID, THEY STILL DENIED TO PAY FOR THE REPAIRS. NOW WE SEE THAT THERE IS A RECALL OF OVER 3.8 MILLION VEHICLES INCLUDING THE 2000 FORD 150, WE ALSO UNDERSTAND THAT THE ONES THAT HAVE BEEN REPAIRED CAN CATCH FIRE AGAIN. WE WOULD BE GRATEFUL FOR ANY ASSISTANCE YOU CAN PROVIDE IN GETTING THEM TO REFUND THE MONEY WE PAID FOR THE REPAIRS IN FULL. *NM UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AIR BAG LIGHT CAME ON SAY THE BAGS ARE OUT AND THEY ARE NOT AND IT KEEPS STAYING ON. I CAN NOT GET IT TO STAY OFF PLEASE SEE IF THERE IS A RECALL FOR THESE BECAUSE MY DAUGHTER HAD A 1997 FORD ESCORT THAT CAUGHT FIRE BECAUSE OF A RECALL ON THE AIRBAG THAT SHE WAS NEVER NOTIFIED ABOUT. *JB

PE 04 078/SPEED CONTROL DEACTIVATION SWITCH FIRE: WHILE PARKED IN THE DRIVEWAY, THE VEHICLE CAUGHT FIRE UNDER THE HOOD. THE LOCAL FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. THE DEALER AND THE MANUFACTURER WERE BOTH NOTIFIED. *AK *JB

AT 102,000 MILES THE ANTI-LOCK BRAKE SYSTEM LIGHT CAME ON. I TOOK THE VEHICLE TO THE FORD DEALER AND HE SAID THE WHOLE ANTI-LOCK SYSTEM HAD CORRODED AND WOULD HAVE TO BE REPLACED TO THE TUNE OF $1000. THIS WAS JUST AFTER FORD HAD FIXED BALL JOINTS AND COMPLETELY RUSTED EMAERGENCY BRAKE CABLES UNDER EXTENDED WARRANTY AT 99,900 MILES.

DT: THE CONTACT STATES LEFT FRONT TIE RODS SEPARATED. HE WAS GOING APPROXIMATELY 40 MPH. THEY BOTH HAD TO BE CHANGED. THIS HAPPENED ON MAY 9-05. HE LOST CONTROL OF THE STEERING ON 5-9-05. HE HAD NOTICED THAT THE STEERING WAS WANDERING PRIOR TO THIS INCIDENT. THE DEALER TOLD HIM THE ALIGNMENT WAS PERFECT; THEY HAD USED A NEW MACHINE TO DETERMINE IF THE ALIGNMENT WAS CORRECT. *AK

2000 FORD F-150 4.2L V6 HEAD GASKET FAILURE. MY VEHICLE BEGAN OVERHEATING AND SMOKING WHITE SMOKE ABOUT 2 WEEKS AGO. ALSO NOTICED THAT HEATER WOULD ONLY PUT OUT COOL AIR, UNLESS THE ENGINE STARTED TO OVERHEAT. ENDED UP NEEDING A NEW HEAD GASKET, WHICH COME TO FIND OUT ARE NOTORIOUS ON THE 4.2L V6 MOTORS. I CAUGHT IT BEFORE ANY MOTOR DAMAGE WAS DONE SO NO ADDED EXPENSES WERE NEEDED. HOWEVER IT STILL WAS NOT A CHEAP FIX. I KNOW OF AT LEAST A HUNDRED 4.2L V6 F-150 OWNERS WHO HAVE HAD THIS PROBLEM AND MOST WOULD BE WILLING TO HELP FURTHER AN INVESTIGATION. I DO STILL HAVE THE OLD GASKET IF NEEDED. *NM