2022 Ford Explorer complaints

1. I had received a Ford Motor Company Ford Customer Service Division, P.O. Box 19043, Dearborn, Michigan 48121-1904 Safety Recall Notice 23S55/NHTSA Recall 23V675 letter dated November 2023. 2. Below are my responses to above questions... - What component or system failed or malfunctioned, and is it available for inspection upon request? ANSWER: A rear axle bolt may fracture. They have inspected months ago. - How was your safety or the safety of others put at risk? ANSWER: I am concern for my wife's safety. - Has the problem been reproduced or confirmed by a dealer or independent service center? ANSWER: Koons is very aware as I have reached out to service advisors, and sent correspondence (web site emails...don't have copies though) between APR24 - JUL24. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? ANSWER: Yes; months ago. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? ANSWER: Not that we are aware of. Our trigger was the letter sent to us in November 2023. Summary: The letter we received is dated November 2023, we started reaching out to Koons in April 2024, and constantly following up with them. All the same answer...waiting for the part to arrive. That only 5 of these parts come out once a week. I finally gave up in July 2024, as I advised them (by sending web site email, and sending service advisor cell phone a test that we comm

No accident, I noticed strap fraying when inspecting the car seat. The lower car seat straps have fraying on them, rendering the car seat unsafe and unusable. My child will not be safe if a car crash would occur, she could potentially be released from the seat. It was reported to evenflo with pictures. They are claiming it is our fault and my 3 year old did it with something sharp. You cannot see the back of the straps as they enter the car seat. We do have photos of the proof. We also know there is an ongoing investigation into evenflo for this very reason.

This is a Utility Interceptor used by a police department, and we have two of them. The vehicle stalls out when trying to enter traffic. It will stall for 2 or 3 seconds with the accelerator pressed all the way to the floor. Ford Motor Company released a technical service bulletin and provided a software flash for the transmission. I had the vehicle serviced at Ford in Bloomington, Indiana, but the transmission software flash did not correct the problem. I then returned the vehicle to Ford and stated that it did not solve the problem. The service technician stated that they contacted an engineer, Ford, and they noted that it was the nature of that transmission and that nothing else could be done. The technician also noted that the vehicle will not upshift from 4th gear to 1st gear when trying to accelerate. The bottom line up front is that transmission stalling the way it does is a safety issue for a police department or any driver.

There’s no accident . The passenger front recliner is stuck in the reclined position ( laying all the way back ). In the seated position , facing forward , the left side of the seat is stuck . The right side near the passenger door wants to come up, but not the left side. The seat is laying down flat in the reclined position . This is a safety issue .

The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was parked and idling with the air conditioner activated, the rear hatch door window suddenly shattered. The contact stated that during the failure, there was no impact on the window to cause the shattering of the window. The cause of the failure was not yet determined, and the vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure, but no assistance was provided. The failure mileage was 28,000.

The contact owns a 2022 Ford Explorer. The contact stated that the passenger’s side rear window failed to roll up. The contact stated that after inspecting the vehicle, as a certified engineer, the master control switch on the driver’s side door had remained in the down position allowing for the window to remain down. The plastic around the switch was warped, causing the switch to remain in a downward position to activate the button. The contact manually raised the window and disconnected the connector from the circuit board to allow all other windows to properly function. The dealer was contacted, and it was confirmed that the VIN was not under recall for the failure. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 43,000.

The vehicle is a hybrid police interceptor utility. The unit was moving running radar and activated its emergency equipment, made a u-turn on a highway cross over, when accelerating in pursuit of a vehicle its engine stalled out and shut off. The vehicle stated to shift to neutral and restart when safe. The officer shifted to neutral and the vehicle would not restart. It was coasted off the roadway and towed. This is the third issue of this type that has occurred with our fleet of ford hybrid police interceptor utilities.

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while attempting to use the rear-view camera, a blue screen was displayed. The contact stated there was message on the instrument panel that the rear camera failed to operate as intended. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that parts were limited. The failure mileage was approximately 24,000. Parts distribution disconnect.

Driving on the highway and the sunroof exploded. No one around and no overpass. No signs of impact or object in or near vehicle. No other damage to vehicle.

The contact owns a 2022 Ford Explorer. The contact stated while reversing, the rearview camera failed to display properly with a delay while shifting into gear. The vehicle was taken to the dealer where it was diagnosed with a hardware system failure which needed to be replaced. The vehicle was repaired but the failure persisted. The dealer stated that a known software system recall had been associated with the vehicle, but the VIN was not associated with the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

The contact owns a 2022 Ford Explorer. The contact stated that while his wife was driving at approximately 50 MPH, the hood came ajar and shattered the front windshield. The driver heard two abnormal beeps before the failure. There was glass on the interior of the vehicle. There were no reported injuries. The driver was able to continue driving. There were no warning lights illuminated. The contact noticed that the safety latch was missing. The vehicle was taken to the local dealer, who informed the contact that the latch had to be pulled twice to unlock. The vehicle was not diagnosed or repaired. The dealer referred him to the body shop. The manufacturer was contacted and declined a claim for the repair. The failure mileage was approximately 18,000.

I was driving down the highway and my vehicle suddenly lost power and the motor blew up.

The contact owns a 2022 Ford Explorer. The contact stated that while the vehicle was parked on an incline, and with a quarter tank of fuel in the vehicle, the vehicle failed to start. There was no warning light illuminated. The vehicle was towed to the local dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure. The failure mileage was 20,000.

The contact owns a 2022 Ford Explorer. The contact stated that while attempting to reverse, the vehicle failed to move, after which the contact became aware that the parking brake had failed to properly disengage. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 40,000.

The contact owns a 2022 Ford Explorer. The contact stated that while driving at an undisclosed speed, the reverse mode did not function as needed. The contact stated that when the gear shifter was shifted to reverse mode, the vehicle rolled either forward or backwards and then hesitated. The vehicle was taken to the dealer, however the failure was not diagnosed. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000.

The contact owns a 2022 Ford Explorer. The contact stated the vehicle would not restart at a gas station with high technical security. No warning lights was illuminated. The contact was able to enter and exit and lock the vehicle, but not restart the vehicle. The contact spoke with the dealer who felt as if there was a radio frequency interrupting with the computer in the vehicle causing the vehicle to shutoff. The failure recurred an additional time. The manufacturer was notified of the failure. The approximate failure mileage was 1,000.

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, an appointment to repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was made aware of the issue but disconnected the call without scheduling an appointment. The manufacturer was notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

On 4 separate occasions the brakes on this Explorer failed to engage. The first incident happened as I was backing out of my garage and the brakes did not engage immediately. This resulted in my damaging our trellis. I was traveling at about 5 mph This happened Sept. 2023. The second incident happened as I was coming out of the car wash and applied the brake, but it did not engage and this resulted in a small fender bender with the car in front of me.- Again very slow speed, about 2 MPH Happened in November 2023. The third incident was on the road as I approached a car stopped for a red light. Again the brakes failed to engage, but I was able to avoid the car in front of me by swerving into the lane to the left. Fortunately no car was approaching on that lane this happened November 2023. The final incident again was on the road. The car in front of me was stopped for a left turn and I applied the brakes, the car did not stop so I swerved to the right onto a lawn and side swiped a tree before the brakes finally took hold. I was slowed down to about 30 MPH happened inJanuary 2024.. This failure in the car braking system has resulted in a substantial money loss . After these incidents I am no longer driving the car. I contacted the dealership and they would not look at the vehicle until it was repaired. We will be returning the car to the dealership for their evaluation of the problem.

Select reverse with gear shift. Does not engage reverse for approximately 8-10 seconds once selected and when engine is warm. Have almost been hit multiple times when backing up because it takes so long to engage reverse.

Front suspension makes rattling noise when driving under 20 mi/hr on bumpy roads . Especially noticed in cold temperatures. Dealership replaced sway bar link that has not fixed the Problem. Also power training light flashed multiple times

Transmission fails to smoothly shift, vehicle delays going in reverse after driving causing delays to park and shakes while downshifting. Drivers anticipate the vehicle to be able to backup sooner and can cause accident with delays. Safety 360 display and rear view camera goes completely out, inverts, and has delay when functions. Vehicle has full power failure while driving and can take 10 minutes to turn back on, happened twice.

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the backup camera displayed a blue screen. The vehicle was not repaired. The failure mileage was 45,000. VIN tool confirms parts not available.

When shifting drive to reverse it takes 4 to 5 seconds to start moving the car. This being a very dangerous situation when backing into a busy street.

Purge valve has now failed twice since owning the vehicle (1 year and 5 months old). First purge valve went out when the vehicle was only 4 months old (Oct 2022). Second purge valve went out at 1 year old (June/July 2022). The main concern that I am reaching out for- Drivers side headlight - a small bird flew into the headlight and cracked it. Placed a hole in the headlight, causing water to get in and stop working. There is no way that a headlight should crack from a bird flying into it.

I smell exhaust/gas fumes when driving my car. It is a very intense smell. This happens several times a week.

I have received six (6) notifications of a power train failure, which causes the vehicle to "shudder" at highway speeds. The first issue took place 09/01/2023, and the last was on 11/1/2023. The vehicle then continues to operate normally. If the vehicle is turned off and then on again, the light clears. I took the vehicle to Tamiami Ford for service. They reported that they can see that their is an issue, but are unable to diagnose it.

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the image on the sync screen was blue. The failure mileage was 14,000. VIN tool confirms parts not available.

The contact leased a 2022 Ford Explorer. The contact stated while driving 75 MPH, the vehicle started shuddering uncontrollably and was making an abnormal grinding sound. The contact was able to veer to the side of the road. The vehicle was towed to the dealer, where it was diagnosed that the front driver's side axle was fractured. The dealer informed the contact that the failure was unprecedented. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 15,629.

Since new the vehicle intermittently fails to shift in or out of reverse instead going to neutral and free rolling. Cycling the shift selected multiple times or performing a battery reset temporarily resolves the issue. This results in the vehicle being unable to move out of the roadway when backing onto a road.

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train) however, the part to do the recall repair was not yet available. An undisclosed dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I was informed by Mullinax Ford and the Ford Recall Hotline that a fix for recall 23S55 relating to a potential rollaway risk would not be available until second quarter 2024. This is unacceptable and owners should not be expected to drive a vehicle for almost a year with a potential crash risk.

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was contacted and determined that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Vehicle was pushing blue smoke, dealership replaced the turbo. Blue smoke returned furiously and dealership replaced the top end including valve assembly. While on a 900 mile journey through northern idaho, the engine completely failed at highway speed leaving me stranded. Ford believes they have cured the valve issue when in fact a new long block motor failed on first long distance trip. Please don't let anyone else go through this I lost thousands of dollars in out of pocket expenses, missed my best friends funeral among other things. These manufacturers need to be held accountable for poor workmanship!!!

When engaging vehicle from park to gear (ex drive, reverse) or from gear into park there is a delay. Meaning vehicle doesn’t engage into drive or reverse when it is placed in that gear, it will take a moment for gear to engage, sometimes resulting in a jerking motion of vehicle. This jerking motion also happens when vehicle is automatically shifting as speed (rpm) increase. There is also a delay when pacing the vehicle from a moving gear into park, there is a delay of vehicle locking into park, sometimes motion is still felt.

As you drive and pick up speed at the range of 29 to 31 mph, exactly the car shutters and shakes. It is known by Ford that the driveshaft needs to be angled due to the hybrid battery location in the car. This particular problem is consistent with a driveshaft replacement that has been known by Ford as well as bearings in the driveshaft. I have had problems with the shuttering in this vehicle almost since day, one of owning it.

The contact owns a 2022 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The plastic window switch has peeled, creating essentially a very sharp edge that has cut me and caused bleeding and pain. It is available for inspection and I have pictures. This is a problem known to Ford. The vehicle was dropped of at a Ford dealership, Crossley Ford Liberty, MO. The problem identified, but not covered under warranty.

The contact owns a 2022 Ford Explorer. The contact stated while driving 60 MPH, the tires began to make a thumping sound and the steering wheel started to vibrate. The vehicle was towed to a dealer where it was diagnosed that the axle seal needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 26,000.

The failed component is the cruise control. It is available for inspection. Unknowingly, the speed increased by 10 miles an hour, without touching any buttons or controls on the steering wheel. With cruise control on, the driver might be not as engaged with the automobile, as if there was no cruise control. I will have the issue brought before my Ford dealer on Monday, September 25, 2023. There were no warning, lamps, messages, or other symptoms prior to the cruise control increasing speed. It only increase speed by 10 miles an hour. However, it occurred at 55 miles an hour,and 70 miles an hour. The issue occurred on a drive from Des Moines Iowa to Evansville Indiana on Monday, September 18. Driving conditions were perfect, no rain dry payment. This incident occurred four times during the 9 hour drive.

AT MY 10,000 MILE SERVICE, ON JUNE 08, 2023, I WAS TOLD THAT THE REAR SHOCKS WERE LEAKING. I WAS ALSO TOLD BY THE FORD DEALERSHIP THAT THEY NEEDED TO BE REPLACED BUT WERE ON BACK ORDER DUE TO THE LARGE NUMBER OF SHOCKS THAT HAVE FAILED ON THIS MODEL VEHICLE. IT IS NOW SEPTEMBER 12, 2023 AND THE SHOCKS ARE STILL ON BACK ORDER AND I NOW HAVE 14,500 MI ON THE VEHICLE. OVER 3 MONTHS AND ADDITIONAL 4,500 MILES ON DEFECTIVE SHOCKS THAT ARE STILL ON BACK ORDER SEEMS LIKE A SAFETY ISSUE TO ME.

Since I've purchase my vehicle in May 2022, the back up camera has presented a black or blue screen. Ford has not found a solution in over a year. Prior to purchase I was not informed of this issue.

While merging on to the freeway, while trying to achieve freeway speed, the Explorer lost all power for about 10 seconds. During that time, multiple error messages appeared on my dashboard. The messages included "Pre-Collision Assist Not Available" and "See Manual". Several Error message were sent to my FordPass app. The messages include: 1."Service Engine Soon Warning - The powertrain control system speed sensors have detected the transmission did not achieve the gear expected and may be slipping internally..." 2."Service Engine Soon Warning - The powertrain control system has detected an internal PCM communication error. The PCM will invoked failure mode effects management (FMEM) operating strategy that maintains limited vehicle function..." 3."Pre- Collision Assist Not Available - The collision warning system has detected either a fault or an obstructed radar sensor". 4. "Powertrain Malfunction/Reduced Power - Illuminates when the system has detected a powertrain or a four-wheel drive fault. I was almost rear ended because I could not achieve freeway speed while merging onto the freeway. The vehicle has been at the dealership for 3 days. I am still waiting to find out what the diagnosis is.

While driving a significant rumble and vibration occurs under the center console. This typically occurs while coasting, usually around 40 mph. When this occurred on the freeway, I felt I may lose control of the car and immediately exited to slow speeds.

The contact owns a 2022 Ford Explorer. The contact stated that while reversing, the backup camera was slow to respond. The screen displayed an image of the vehicle. Additionally, there was an extreme amount of air entering the vehicle from the door seals. There were no warning lights illuminated. The vehicle was taken to the local dealer, who was unable to duplicate the failure, but the vehicle was not diagnosed or repaired. The dealer referred the contact to the manufacturer. The manufacturer was notified of the failure and referred her to the NHTSA Hotline. The failure mileage was approximately 5,100.

VEHICLE REAR AXLES CLICK WHEN YOU PLACE VEHICLE IN REVERSE AND DRIVE THIS IS THE CV AXLES BREAKING EVENTUALLY LEADING TO POWER LOSS.

Windshield stress crack developed overnight. First notices July 18th as small crack (less than 6 inches) on right top third. Over the week grew to 8 inches. Less than 10,000 miles and under 1 year. Ford considers this a wear item and is only covered for 90 days. Currently available for inspection. Not driving car in case the windshield completely fails. Windshield will be inspected and replaced by insurance.

The contact owns a 2022 Ford Explorer. The contact stated while attempting to reverse into a parking spot, the gear shifter was moved to reverse(R) however, there was a 5-second lag before the transmission selected the intended gear. The contact stated no warning light was illuminated. The contact stated while receiving an oil change at the local dealer, the dealer stated that the valve body needed to be replaced. The vehicle was repaired but continued to experience the same failure. The contact took the vehicle to back the local dealer, where it was diagnosed with needing the transmission to be replaced. The vehicle was not repaired due to parts not being available. The manufacturer had been informed of the failure. The failure mileage was approximately 5,000.

Car has recall for rear end bolt that breaks, took car in to have repair made. Came home with a software update that sets the park brake when you put car in park, and then when start the car and put into gear you press the accelerator or press the button, the car will lunge forward or reverse when you press accelerator, not safe at all! From what I have read the NHSTA approved this (fix) instead of fixing the sub frame and more bolts like it should be, instead of a auto parking brake that sets every time. I do feel this is a extreme safety issue and should be addressed immediately! Shame on you and Ford, an auto park brake is not a solution, only a poor band-aid !

The power lift gate was making a popping noise, so I took the truck to Ford for repair. They supposedly repaired the truck, but the power lift gate started opening and closing on its own and at random times. It also started to rain through the back glass, which caused mild in the truck. The warning states that the power loft gate should be completely closed or it can result in death, but it wasn’t able to close at all times. Ours safety was out at risk due to the power lift gate opening and closing at random times, which could have caused me to be hit, other drivers to be injured, and theft of property from other people having access while the power lift gate didn’t properly close. The problem was confirmed by a dealer. I showed video as well. The manufacturer has inspected the vehicle component, but they broke a panel on the driver door and tried to glue it on, so the manufacturer is dishonest. They also advised that I have a “bad car” but refuse to do anything. No it was no warnings.