2020 Ford Explorer complaints

Inlet exhaust leak and rattle, the vehicle sounds like a diesel truck. Transmission jerking into out of third gear.

I own a 2020 Ford Explorer (Platinum edition). A recall was issued for the back-up camera. My car had been having issues of intermittent camera problems prior to the recall. I took my car into Sam Pack's Five Star Ford of Lewisville (1144 N Stemmons Fwy, Lewisville, TX 75067) for the recall repair. . . I drove the vehicle for about thirty minutes after completion of the recall repair at which time I parked the car. Unfortunately, when I did so the "Blue Screen" returned. The was the reason for the recall. . . This is the same as prior to the recall "repair". Also, when this happens a warning pops up "Reverse Brake Assist Not Available" (this may be because the camera is malfunctioning). The camera does not do this all of the time. There is no rhyme or reason as to when it is going to fail. After turning the car off for a while (as when eating at a restaurant or grocery shopping, etc.) the camera works when you put the car into reverse (with the one exception noted above). It appears that the "fix" for the recall is insufficient to stop the camera errors from recurring. The incident date listed below is the date of the supposed recall repair. I have uploaded a PDF File showing pictures of the camera errors. If you would like any other information, or pictures of the blue screen errors, please do not hesitate to contact me. I can be reached by email at [XXX] or by phone at [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

At a speed of approximately 30mph, I heard a cracking noise from the rear of my vehicle. After looking into my rear view mirror, I saw the rear window was shattered, and caving inward. It was around 90 degrees that day at 1:30 pm and I was driving on an open road. There was a co-worker driving behind me that was witness. Nothing came down and hit the rear window.

Rear backup camera incorrectly sensed an obstruction behind vehicle and caused emergency braking with no visible obstruction. We were unable to pull out of the parking spot and had to jump a curb to leave. No further incident has been experienced,

A computer system fault caused the inability to start, move, turn off, turn on, lock or otherwise do anything with the vehicle with manual buttons or the remote. The drivers screen flashed through fault codes but would not allow any action. After discussing with the dealer on the phone, who mentioned something about a bad battery cell, I decided to disconnect the battery terminal, waited a period of time, and reconnected. The computer system reset and everything functioned correctly with no fault codes. At the time the vehicle was in a company drive lane causing a major hazard to the vehicles passing through. The vehicle was brought straight to the Dealer Service department who said they could not find anything wrong.

While driving at 70 mph the vehicle experienced the following issues all at once, the power steering shut off, all brake pressure was lost, the pre- collision system was turned off, parking brake engaged(at 70 mph) traction control system turned off, engine light turned on and all of the warning lights on the dash activated. This has happened 3 times and almost killed me twice. Ford has tried to repair this vehicle all three times and still have not corrected the issue. Ford has also refused to replace or buy back the vehicle.

Suv was banging and stalling when braking down a hill or going up a hill. Driving on the interstate it totally lost power. It happened at various speeds. First dealer near where it happened refused to look at it for a month after I told them I lost power on the interstate and stalled out. Had it towed to the dealer I bought it from and no recalls are showing up even though I got the wrench and transmission alert of total failure. It has been sitting there over a month and they have torn out the transmission-issue also with clutch seals.

Worked until 11am Friday 11/5/21, went back out to work night shift 10:40 ish at night to start the vehicle up to warm up (he believes that he had turned on the heat). As the officer was outside walking his dog he heard noises of glass cracking. He walked up to it and noticed the entire rear window was shattered. No point of entry or notice of vandalism.

Officer was sitting in vehicle while it was running with AC on, he pressed the Max defrost button for a couple of seconds then turned it off. After about a minute or two he heard a what a loud noise and looked in his rear view mirror to see his rear window completely shattered.

When using the defrost or air conditioner or just having the fan on, exhaust fumes enter the cars cabin. Its very troublesome that when I took it to a Ford dealer and they checked it out and said the catalytic converter was cracked but told us Ford had no fix for it. Its very dangerous especially in the morning time when you need to use the defrost you have roll all the windows down and freeze you butt off.

The contact owns a 2020 Ford Explorer. The contact stated that while attempting to reverse the vehicle, the backup camera failed to function as designed. The contact stated that the backup sensor non-functional message was displayed. The vehicle was taken to a local dealer and was diagnosed IPMB updated and repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 21V735000 (Back Over Prevention). The vehicle was repaired under the recall but continued to experience failure. The manufacturer was not informed of the failure. The failure mileage was approximately 10,000.

Ford issued recall 21S44 for an intermittent back-up camera problem. I took my vehicle to Elk Grove Ford (95624) on 10/05/21 for recall repair. The problem continued and I took back on 10/19/21 to fix back-up camera. It still only works intermittently. Today, while backing up at an elementary school after my second recall service, my camera failed again. This is a critical safety issue which Ford knows about but has provided incompetent information to Elk Grove Ford. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Back up camera image distorts goes black at times but goes blue multiple times a day while driving and putting in reverse camera is blue 90% of the time

My windshield washer tank is leaking. Brought to Ford and they changed the tank. Still leaking and looks like still coming out of new cap. Go thorough a half gallon a week and only leaks when driving. Car is at Friendly ford now. They drove another 2020 Explorer with the same miles and was also leaking when driving. they said seems to be normal. Its not normal and dont want it leak out in winter and have no fluid and get in a accident cause cannot clean windshield. Need help with this.

The contact owns a 2020 Ford Explorer. The contact stated while operating the vehicle the backup camera display image was very washed out, unclear and the colors appeared to be bleached out causing visibility issues for the driver. The vehicle was taken to the local dealer who replaced the camera display unit, but the failure persisted. The manufacturer was also notified of the failure. The failure mileage was 2,000.

The contact owns a 2020 Ford Explorer. The contact stated that while operating the vehicle both the digital display screen and instrument gauge cluster would randomly malfunction, scramble, and the display screen would turn blue. Also, the transmission would shift abruptly and while driving the vehicle would lose throttle response causing the vehicle to slow before abruptly accelerating. The contact indicated that the failure had occurred while driving 60 MPH on a six-lane highway. The vehicle was taken to the local dealer who indicated that the collision avoidance system had malfunctioned. In addition, while driving, the engine would randomly rev extremely high and had occurred while letting off the accelerator pedal. The local dealer and manufacturer were both notified of the failure. The failure mileage was 100.

The rear camera malfunctions and the display screen is blue. The vehicle is available for inspection. It creates a blind spot on the display screen of the area behind the vehicle and sounds an alert/alarm every time the malfunction occurs. The problem has not been reproduced by the dealer but I have provided multiple pictures of it occurring. The vehicle has been inspected by the manufacturer on several occasions. There were no warnings prior to the failure.

Backup camera failed with a blue screen that was initially identified early August and brought into Ford 8/11-13 but dealership unable to reproduce problem. It is believed that the dealership re-booted the computer and downloaded new software. The same problem occurred just two days after we got the car back on 8/15 at which time a picture was taken to show the service department. A Google search suggested there was a problem with the back up camera for 2020 Explorer, but there was no recall on my VIN. After reaching out to Ford soon after we got the car back, a service person offered to order a new camera, but it was never approved. Numerous calls were placed to the dealership given ongoing camera failure and concern for causing an accident, but we were told that the problem needed to be reproduced. The camera could not be ordered. While backing the car out of our driveway without an operational camera or sensors, driver side rear bumper collided with a car parked in the street. The insurance company was notified the day of the accident and the car was taken to Ford body shop 9/21 where a repair estimate was provided. The dealership service department was notified that the car was involved in an accident because of camera failure and finally agreed to order a new replacement camera. On 9/23, we were notified of a "blue screen" back up camera recall.

I had an issue with the rearview backupcamera. The camera kept going out multiple times. I asked Fodd customer care if there was a recall and told me no. One day I was backing up at night my camera went out and I hit a mailbox which was in my blindspot I immediately called Ford to alert them that the camera went out a d I damaged my vehicle. Ford requested that I bring in my truck and changed the camera. They found out the camera had an electrical shortage. I attempted to get Forx to pay for the damages to my vehicle and they refused. The total estimate was 2700.00. The response why they denied my claim was I had an accident and they were not responsible regardless of the camera not working. They told me to contact my insurance to fix the damage. I feel I wouldn't have had an accident if my rearview camera did not go out. The backup assistance beep would have sensed the object behind me in my backup view and I would not have damaged my vehicle since the object was in my blind spot. I feel that Ford is responsible for the repairs and I have Video proof that my camera was having issues prior to my accident. I need Ford to fix my vehicle at no cost to me. They are ignoring the fact that the backup camera and blinspot assistance failed.

The contact owns a 2020 Ford Explorer. The contact stated while attempting to reverse the backup camera failed to engage. The contact stated that there was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed with needing the Intelligent Platform Management Bus (IPMB) flashed. The vehicle was repaired. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 21V735000 (Back Over Prevention). The vehicle was repaired but continued to experience the same symptoms. The manufacturer was informed of the failure and spoke with the contact’s attorneys and was awaiting a response. The failure mileage was approximately 22,900. Consumer stated camera was replaced 4 times and reprogrammed twice.

When backing up, the screen turns blue 3 out of 5 times when placed in reverse.

I have a serious safety issue with my 2020 Ford Explorer. The tailgate has unexpectedly closed when loading or unloading items from the cargo area. This is due the foot activation function. When loading/unloading heavier items you must stand close to the bumper. In so doing the foot activation closes the tailgate. This has happened at least 6 times including closing on my wife and grand children. The attached photo shows a skin scrap I sustained in blocking the tailgate from closing on a grandchild. I have talked to the dealer about deactivating the foot function. They responded it cannot be done.

The car would not shift out of first gear. Had to put the car in neutral and then back into drive to get it to shift.

Reverse camera turns blue on many occasions and other times it gets dark, the engine in the mornings the engine sounds like a Diesel car in the dealer indicate it is normal but new vehicles do not sound that way.

Sunroof exploded. There were no warning lights or beeps. It sounded like an explosion and caused me to nearly wreck from the loud boom. I went into a field and nearly lost control of vehicle.

We have returned the vehicle to the dealer 4 times for back-up camera / rear sensor failure. Most recently they had the vehicle from 8/16/2021 to 8/20/2021. Allegedly they replaced the back-up camera. On 8/27/2021 upon returning home from an approximately 3 mile drive, the back-up camera again failed while backing into our driveway. The DIC displayed the message "Back up assistance unavailable." While on vacation in Colorado, the back-up camera failed every day for 2 weeks (8/01/2021 - 8/13/2021). The failure would occur after extended drives at highway speed. On one occasion, the back-up display flickered between the image, blackout, and blue screen. On one occasion both the backup display and the overhead 360 display, displayed only blue screens. Turning off the vehicle and leaving it sit for 30 minutes or more clears the problem. The dealer claims they are unable to reproduce the problem. I have repeatedly told them that the vehicle must be driven for the problem to present itself. Repeatedly starting and shutting off of the vehicle while stationary will NOT produce the problem. We have repeatedly supplied images of the interior display showing the problem. This situation poses risk when reversing from parking place into oncoming traffic.

Rear camera is not working correctly. If goes to a blue screen a lot.

Back up camera not functioning properly. Back up camera will intermittently show distorted image while backing up and then it turns to black screen with warning stating "Camera is unavailable. Please contact your dealership."

I am associated with the City of Brookings, SD Police Dept. We have two 2020 Ford Hybrid SUV patrol vehicles. Both vehicles since we obtained them in October of 2020 have experienced loss of power. Both vehicles dash indicators lights come on and the vehicles has a complete system failure. In June of this year an officer was responding to an emergency call. The officer was traveling at approximately 50 mph. The vehicle's dash lights all came on and the vehicle's power system shut down. The officer stated the vehicle almost came to a dead stop, almost causing him to crash. He stated if he was not wearing his seat belt he would have went through the windshield. This particular vehicle has had had complete loss of power approximately eight times. Ford has replaced the ECM power module stating this would fix the issue. Now the vehicle's trailer module has supposedly failed and caused a complete loss of power. This trailer module effected the entire electrical system. This vehicle has been unusable since July 19. Prior to this latest incident the vehicle was unusable for approximately four weeks. In the almost year we have had the vehicle in service it has been unusable approximately 6 to 7 weeks. I have contacted Brooklyn Center, MN PD, East Grand Forks, ND PD and Yankton, SD PD. These agencies all have had the same Ford Hybrids. They all have experienced the same issues. Yankton PD is currently had one vehicle labeled a lemon and Ford is replacing this vehicle. Our agency is att

Transmission shifts from reverse to park and drive to park on its own. Also, heads up display goes blank and sensors / backup camera stop working. Front collision monitors also do not work as well as lane departure sensors

The overheating temp light keeps coming on for no reason. Vehicle has been to Rob Smith Ford seven times and still has not been fixed.

Rear view camera not working. Dealer has confirmed however not able to get replacement part from manufacturer. Camera has been down for over 9 months.

We were going down the Hwy about 65 no cars around our sunroof exploded we had the headliner closed and it was full of glass. We thought at first we had a blow out but we saw all the glass in the middle of the sunroof no object or mark on car

Rear view mirror keeps turning solid blue ( blank ) and message center on the dash says "rear brake assist not working".

The contact owns a 2020 Ford Explorer. The contact stated while reversing the vehicle, the back over protection screen turned blue and the contact was unable to see the road. The contact stated that the reverse brake assist warning light was illuminated. The contact took the vehicle to the local dealer ten times within 11 months, but the mechanic was unable to diagnose the cause of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 5,100.

I have already complained to dealer about constant hesitation and jerking, going from 1st to 2nd and sometimes 2nd to 3rd gear on automatic transmission, as well as slight loss of power going up inclines under 30mph. They told me a road test and transmission test showed nothing wrong. Incident I am reporting happened back in May2021. I was making a right hand turn onto a busy road from a parking lot, from a complete stop. As I pulled out onto the road, going from 1st to 2nd gear, the car completely stalled for about two seconds. I almost was rear-ended because of the stall. I had to take my foot off the gas and then put a lot of pressure on the gas pedal to get the car moving again.

My new 2020 FORD EXPLORER had had on at least 4 occasions, the last being in July 2021 (mileage was approximately 7,280 miles at the time). This problem has only occurred when parked in my garage, I turn on the Explorer with my foot firmly on the brake and put the vehicle in Reverse (with foot still on brake) the vehicle starts reversing with force even though my foot is hard on the brakes. I then push down even harder on brakes. I am fighting to keep the Explorer from roaring out of the garage. Luckily I haven't hit anyone or anything, but had I not reacted as quickly I could easily have caused serious injury. I reported this problem to my local dealer two times, the first about 10 months ago and the second incident was reported to the dealer when I took it in in August 2021 for numerous alerts received in July 2021 for: POWERTRAIN MALFUNCTION/ REDUCED POWER; PRE-COLLISION ASSIST NOT AVAILABLE; HILL START ASSIST WARNING, PRE-COLLISION ASSIST NOT AVAILABLE. The dealer said all the alerts came from one power module which will be fixed this week when the part arrives at the dealer. The dealer also said that the recent Reverse power surge I advised them of is probably related to all of the alerts listed above and that this should take care of the problem. I never received any warnings, messages or other symptoms of this problem - it has always been a shock when it happens.

Vehicle would not start and every warning lamp and alert triggered on the dashboard. Tried remote start which was successful, but vehicle shut off 5 seconds later and the above alerts/warning lamps repeated. Vehicle would not start and just repeated all of the warning lamps/alerts. Waited 20 minutes, car started without issue; however, when put into reverse WITH FOOT ON THE BRAKE the vehicle started to drive backwards WHILE FOOT WAS STILL ON THE BRAKE! No amount of pressure on the brake pedal stopped the vehicle. Had to depress and repress the pedal to stop the vehicle. Rear cameras failed to activate as well. Luckily no one was injured. This is the third time this has happened, the third time I have reported to the NHTSA, and the third time I have reported it to my local dealership without resolve.

The contact owns a 2020 Ford Explorer. The contact stated the day he purchased the vehicle, the rearview camera turned blank as he was reversing out of the dealer parking lot. The warning message "Back Up Brake Assist Is Not Functioning" appeared on the instrument panel. The dealer diagnosed that the rear-view camera needed to be replaced. The contact stated that the vehicle was repaired however, the failure recurred while driving. The vehicle was taken back to the dealer and was repaired, however the failure persisted. The vehicle was taken back to the same dealer. The manufacturer was made aware of the failure and informed the contact that the VIN was not included in NHTSA campaign number: 20V575000 (Visibility) due to the manufactured date. A case was opened and the contact was referred to the NHTSA for assistance. The vehicle was not repaired. The approximate failure mileage was 10. Consumer stated 5th camera has been installed.

The contact owns a 2020 Ford Explorer. The contact stated that upon rapid acceleration at various speeds, exhaust fumes from the tailpipes would enter the cabin of the vehicle. The contact also stated that after heavy rains, water-filled the spare tire compartment located in the rear of the vehicle. One day while his wife was driving and coming to a complete stop, the water spilled out of the compartment and flooded the cabin floor of the vehicle. Once the contact discovered where the water was located, he vacuumed up nearly four gallons of water out of the spare tire compartment. As a result of the internal water intrusion, there were several electrical failures. The forward collision warning light would illuminate on the instrument panel without any vehicles in near proximity. The contact also stated that his wife received multiple alerts on her phone through the Ford app that an intruder had attempted to open the tailgate however, each alert was a false alarm. The contact had taken the vehicle to a dealer where the service manager agreed to have the vehicle thoroughly inspected. The vehicle remained in the possession of the dealer. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 1,000.

Turned the car on and immediately the headliner above the drivers seat started smoking. Within seconds there was an actual fire and had to call the fire department. Ford does NOT seem concerned about it at all. Are not sending it to be investigated at all from my understanding, My car has sat for 2 months now with no answers still. We do not know what caused the fire or exactly where the fire started.

The car jerks when it is downshifting between 2nd and 3rd gear. It was inspected by a dealership in TN (we were out of town from MI) and the Ford dealership there was unable to identify the issue as they did not have a transmission tech. We have 15K in miles on our car. We contacted Ford CS and the car was driven by a car hauler back to a dealership in MI. They have 1 transmission person. At this time, we have had a rental car for over 2 weeks at a cost of over $1200. They cannot service the vehicle until next week leaving us without a vehicle for over 3 weeks. Ford has been difficult to work with and meanwhile I continue to pay my lease, they are only offering $35/day for 10 days for rental car and have no idea when the car will be fixed. I have asked for credit on our lease and formal follow up on this and they are slow to reply leaving us stranded to find our own way home. Very disappointed as this seems to be a known issue with the 2020 Explorers and the new power train.

Rear camera will intermittently cause the screen to display distorted or total blue screen upon placing the vehicle in reverse

On two separate occasions while using the cruise control, the vehicle continued to receive warnings on the dash that the 4-wheel drive, hill assist, emergency braking, etc. were all unabled and service would be required. The cruise control then also disabled and I was unable to use it again until I pulled over, stopped and re-started the vehicle. Upon doing this, the system seemed to reset and all warning lights went off. I contacted a local Ford dealer about this issue and was told that their loaner 2020 Explorer has the same issue and they're unable to pinpoint the problem. They've had it in and out of service for 4 months. Their machine is unable to find any errors. They feel like it may be something to do with the body control module. Since my vehicle is apparently not the only 2020 Explorer experiencing this issue, I thought it would be worth reporting.

The contact owns a 2020 Ford Explorer. The contact stated that while driving 55 - 75 mph, the contact was switching lanes and felt the vehicle was swerving. The contact stated that there were vibrations felt coming from the floorboard. The vehicle was taken to the dealer and the dealer test drove the vehicle and diagnosed that there was no failure. The manufacturer was not made aware of the failure. The failure mileage was 17,999.

Transmission - available for inspection upon request (yes) Vehicle will lunge or stall as it searches for the right gear. Have had the vehicle to Ford Authorized Dealers 3 times with varying degrees of success. Now problem has reoccurred and is worse that ever. Searches for the right gear, lunges, sometimes will not go into gear at all. Feel unsafe driving the vehicle. Currently have a 4th apt with Ford to look at the transmission. No warning lights or messages present on the dash.

Electrical- lift gate will just stop working at times. Trouble with Bluetooth connection Fuel- when filling up the pump will stop (even if only put in 2 gallons). Seats- drivers seat broken Engine/transmission- hard shifting, put itself in park while at red light Multiple ongoing issues with Explorer. Been in/out of shop over 10 times in one year. I have videos but unable to upload them.

I was in a turn lane at a intersection waiting on the light and my daughter noticed the vehicle had shifted in to reverse by it self. The backup camera was not on and if it had not been called to my attention I would have backed into the car behind me. I shifted into drive when the light changed and went on my way. This has happened only once.

Smoke started coming from the passenger side visor as I was driving. There was no indication of an issue with warning messages of any kind. Of course I panicked, ran from the car and called the fire department who stated it smelled electrical when they arrived. After a week of being at the dealership, they couldn't find anything; however, 30 seconds after I got into my vehicle, I noticed the cabin lights weren't working. After returning the vehicle within an hour they found that a wire had burned out and shorted out some fuses. 2 weeks later and I still don't have my vehicle. No injuries, just scared beyond belief to have a 2020 ST start smoking!! Even if they state it is fixed, I am still scared to death to drive it after that!! I have had issues with the brakes as well. Those stopped working but apparently that was a recall that was resolved. I have purchased Fords for the past 20 years. I will NEVER buy a Ford again with all the issues I have on this vehicle!

This issue has happened 4-5 time in a years time. When driving with cruise control and lane assist enabled the car will pull to the left when it see's a dark line in the road. If i were not holding on to the steering wheel I would have been in the lane next to me. I think what's going on is lane keep or lane assist thinks there is a curve in the road and tries to correct for it. Its just a matter of time before a crash happens to a Explorer owner. I have been to the dealership 3 time for this and called Ford but they don't seem to care.