2020 Ford Explorer complaints

The contact owns a 2020 Ford Explorer. The contact stated while his wife was driving at an undisclosed speed down a steep driveway, upon depressing the brake pedal, the vehicle failed to come to a complete stop. The driver was able to bring the vehicle to a complete stop by shifting into park. The hill stop control and ABS warning lights were illuminated. The vehicle was taken to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 45,200.

Code 102F: All wheel drive module malfunctioned due to lost communication/wiring with the module. The vehicle is in a compromised state and driving differently with AWD disabled. Problem was confirmed at Ford dealership and Ford refuses to provide coverage under the powertrain warranty, even though this is a powertrain issue.

I purchased my 2020 Ford Explorer ST in 2020. Since then, I've had several warranty issues and recalls. Presently, this "blue screen" issue when the car is placed into reverse cannot be resolved by Ford who offers no solutions other than platitudes. This is a significant safety issue with the vehicle as the exterior camera assist does not work ("blue screen") and beeps intermittently when the vehicle is in reverse, which is a distraction. I cannot comprehend how/why a vehicle has had so many issues and believe action should be taken against Ford to remedy these problems.

Faulty exhaust downpipe. Vehicle made loud rattling by catalytic converter, upon investigation the downpipe exhaust hanger rod had broke off due to vibrations in the flex pipe. Ford has an issue with the flex pipe in which it is to weak and will shake the downpipe during idle or acceleration. Ford had issued a factory fix for the downpipe; however, it doesn't fully fix the flex pipe vibration issue. My flex pipe shake so violently that it broke the metal exhaust hanger rod by the catalytic converter. Without the hanger support further shake could result in cracking along the exhaust/catalytic converter. This could result to exhaust fumes being ventilated into the passage side of the car. This could result in carbon monoxide poisoning. As a pilot, they always teach us to check the exhaust for cracks and teach awareness due to the exhaust being near the cabin. Fords fix is to place a hose clamp which doesn't work. Multiple explorer forums have reported this issue. Fords solution to it is to replace it with the same part. Not sure how that will fix the issue if your replacing a defective designed part with another defective design part. I have attached photos of the snapped hanger and hanger location.

Essentially, my Ford 2020 Explorer is having the same issues as the other 2020 Explorers on a recall list . My Ford rolled back, and it hit my husband's car when it slipped out of park. It also is no longer going into park without giving me a weird error message. It is currently at Five Star Ford in Stone Mountain, GA awaiting repair. My car will not go into park. The transmission failed.

This is my third complaint regarding the same issue, driving on the freeway today the gas pedal was not responsive leading to a drop of speed almost getting hit from behind, don't know what to do, I'm getting nervous to use my car because the problem comes with no notice (see complaint [XXX], [XXX] and [XXX] ) hopefully I will not get in a serious accident before something is done. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Good Afternoon, the problem that I have encountered for is is that the rear camera does not work all the time a blue screen appears and I am not able to see what is behind me and that can cause me to have an accident. I do not feel safe

While driving the rpm needle dropped under 1 and would not accelerate. And while slowing down the car jerks. The wretch light showed up. The codes was read at a service center that it was powertrain control specifically the transmission temperature gauge and pulley system. Currently being diagnosed at the dealership.

Hard downshifting while coming to a stop - dealership is saying a complete transmission replacement on a 2020

After starting vehicle it rolled when placed out of park while foot was on break and the emergency break was still engaged. There was no pressure and all warning lights associated with pre-collision, hill start, and antilock break fault were flashing across screen only while trying to stop and break from rolling. My safety and others was at risk by rolling into the street i could have been hit by oncoming cars or unable to stop from hitting anyone. My vehicle is maintained at dealer and is kept up on all service and recalls requirements. After vehicle was towed to dealer they were able to find the following TSB: https:// [XXX] Lives are not a technical service bulletin they are a RECALL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Backup and 360 camera have not worked since shortly after purchasing this vehicle in Aug 2020. They state issue is intermittent. It is not, it is constant. It rarely works. This has not been fixed since original recall in Sept 2020. They continue to update the recall which seems to be an attempt to hide the true length of time this recall has been outstanding and unresolved which is 3 years. I have young children and no reliable backup camera increases the risk of accidental injury due to backing into a child. It increases risk of accident due to being unable to see surroundings. I have attempted to resolve the matter with the dealership and the manufacturer. I am never given a response other than a canned answer that there is no fix at this time. I have owned the vehicle for 3 years. It is unacceptable to have this be unresolved with no action or accountability from Ford. I hope to see this situation escalated and the issue thoroughly reviewed to include how Ford has handled this. They have repeatedly ignored customers requests for assistance and resolution. They've deleted comments on social media pointing out the continued issue and lack of assistance from Ford in an attempt to keep selling vehicles with these issues they can't seem to fix. I firmly believe the "reasonable" timeline to repair a safety recall has been beyond exhausted. If they can't fix it, they need to find an alternative for the impacted customers. In learning they knew of the issue in May 2020 and I was

1. The Explorer spontaneously went on fire while being driven damaging the entire front of the vehicle 2. The vehicle could have exploded affecting other vehicles as well as injured or killed the driver and passenger 3. No. Insurance Company immediately declared vehicle totaled. 4. No. Once again, vehicle was immediately declared a total loss and assigned salvage company to take possession 5. No warnings. First sign of anything wrong was flames coming from under the hood

The contact owns a 2020 Ford Explorer. The contact stated that she became aware that the rear passenger’s side head rest was fractured several months ago. The vehicle was taken to the dealer, where it was determined that the head rest needed to be replaced; however, the vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 35,000.

Cars jerking while upshifting or downshifting at regular speed.

The component that has failed is on the exhaust listed as the flexible exhaust pipe assemble part N1MZ5G203A. The part has no visual damage but consistently rattles while idle. The vehicle has been well taken care of but the part appears to be defective. This appears to be the same issue as NHTSA Technical Bulletin 20-2282. There are no safety concerns at this point. The vehicle has been inspected by Capital Ford in Charlotte North Carolina. There has been a Ford customer experience associate assigned to the case who has reviewed the dealerships diagnostic of the issue. Ford has offered to pay for the part but not the labor required to install the part. There were no warning signs/lamps/indicators notifying of the underlying issue.

Fuel gauge on electronic instrument panel shows empty at all times. Driver can run out of gas without warning. Vehicle OBDC shows fuel sensor fault, local dealer claims a faulty instrument cluster with very costly repair. No warnings before this happened. Just Fuel light coming on, check engine light coming on and fuel level showing Zero.

When you put car in reverse the camera screen may go blue or black. Sometimes it is all in cone in rear, other times it’s on the right side and at other times it is the entire screen. Turning blue or black. This started in the first several months of ownership in 2020. The dealership tried several things including replacing the camera in 2020-2021-2022. Problem continued. Was told it was all fixed and the same day it happened again. I live in metro DC and have to park in small spaces often between cement pillars. I bought the car specifically for the camera system. I have hit things while attempting to get the camera back to useable again while in heavier car use areas buy not being able to see or have a sensor go off. Since 2020 Ford has had no viable remedy available. No option for new owners other than taking the loss on the car which as a widow I cannot afford to do.

Shifting is hard shifting up and down

2020 FORD EXPLORER ST-ABOUT 55,000 MILES. DEALER: PREFERRED FORD IN GRAND HAVEN, MI. ISSUE IS SOMETIMES A MULTITUDE OF WARNING LIGHTS WOULD COME ON WHEN TRAVELING. THEY INCLUDE SHUTTING DOWN THE CRUISE CONTROL WHEN IN MOTION, THE FORWARD COLLISION SENSOR WOULD STOP WORKING, ALL WHEEL DRIVE AND HILL ASSIST LIGHTS WOULD COME ON AND STOP WORKING. THIS HAPPENS WHETHER A SHORT TRIP, 10-15 MILES INTO TOWN, OR ON A LONGER TRIP. ONLY WAY TO POTENTIALLY RESET IT WAS TO STOP, TURN VEHICLE OFF FOR A MINUTE OR TWO AND RESTART. SOMETIMES THIS WORKED AND SOMETIMES NOT. THIS IS A SAFETY HAZARD WHEN OPERATING ON A ROADWAY, USUALLY AT HIGHWAY SPEEDS, ESPECIALLY IN WINTER ROAD CONDITIONS OR AN OCCASIONAL TRIP THROUGH THE MOUNTAINS TO THE SOUTHERN STATES. HAD A COMPUTER UPDATE, WHICH COST $540.00, STILL NOT SOLVE IT. FINALLY ABLE TO GET INTO DEALER WITH ALL WARNING LIGHTS ACTIVATED. DEALER STATED HAS TO DO WITH DRIVETRAIN. NOW TODAY (8-3-23), WAS ADVISED BY DEALER A NEW FORD ENGINEER INTERNAL SERVICE MEMO STATED THAT IS NOT THE TOTAL FIX. TOTAL REPAIRS COST IS IN/AROUND $2000.00. IF FORD KNOWS THIS IS AN ISSUE AND WITH THE MANY FORD EXPLORERS ON THE ROAD TODAY, THIS NEEDS TO BE ADDRESSED SO THE CONSUMER CAN HAVE CONFIDENCE IN DRIVING THEIR VEHICLES.

The contact owns a 2020 Ford Explorer. The contact stated that while reversing at an undisclosed speed, the back over prevention camera displayed a black screen. The contact stated that the vehicle was taken to the dealer to be diagnosed. The contact was informed that the back over prevention camera needed to be replaced; however, the parts were not available. The contact stated that she had received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The contact later received a notification that referenced a temporary fix; however, when the vehicle was taken to the dealer, the contact was informed that there was no temporary fix available. The vehicle was not repaired. The manufacturer was made aware of the failure. VIN tool confirms parts not available.

The contact's wife owns a 2020 Ford Explorer. The contact stated that the rear-view camera was displaying a blue image on the screen while in reverse(R). The contact had taken the vehicle to a dealer and was initially informed that there would be a recall to address the failure. The contact then received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The vehicle had been taken to several dealers where repairs were made to the rear-view camera; however, the failure persisted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 500. VIN tool confirms parts not available.

1. My 2020 Explorer has about 75,000 miles. 2. The car rolled back while in park during the week of 7/24, and the emergency brake stopped the car from rolling. 3. I called Ford Customer Care and my local dealer to see if my model was included in the current transmission recall (23v06900), it is not. 4. On 7/28/23, the car would not go into park. The emergency brake kicked in. The screen shows a message that says "Park not available apply brake before exiting". 5. Car is currently at the dealership in need of a new transmission. Vehicle still will not go into "park". Car remains in place due to the emergency brake, only.

The trim between the rear passenger side and the non-moving window flew off on the freeway 3 weeks ago. I had an appt at the dealership for an oil change and was told “yeah, it can happen.” I opted not to have them reschedule me to fit me in for a fix and I’m glad I didn’t because the driver’s side trim in the same window location came off while driving over the Golden Gate Bridge. There were pedestrians all over and it could have hit someone. Both window trims in three weeks, one on a freeway and another on a highly-populated pedestrian/vehicle bridge. These pieces appear to be metal.

There have been a few times when the gas pedal (accelerator) isn’t responsive. I have pressed the accelerator to the floor a few times and there has been a long delay in response from the engine and when it did respond it was at a lower rpm then expected when the pedal is to the floor. It has occurred when the vehicle is at a stop and the accelerator is pressed to hard. This has occurred multiple times.

Rear lift gate doesn't operate or operates erratically . Rear lift gate will not open traping occupants in the vehicle. Particularly any occupant seated in the third row seats. Yes. Took it to the dealer and they failed to address the problem First began February 2023. The dash board button will work some times and not others. Same for the key FOB and rear lift gate located on the the exterior of the vehicle. I have had occupants trapped in the back of the vehicle when the lift gate will not operate at all.

There seems to be a recurring issue with Explorer ST vehicles burning excessive oil upon start-up. In my situation, I have seem my oil levels drop after 5,000 miles. In some reported cases the constant consumption of oil has caused catastrophic engine failure while driving. A similar issue has also been reported on Ford F-150 trucks with the 2.7l turbo. There appears to be a fix for this that requires a oil feed line from the block to the turbo unit to be replaced (newly designed oil feed line) but Ford has not issued any recalls or repair notices for the 2020 Explorer ST's that experience a similar problem.

Previously filed reports 11521566 and 11494044, stating problem with no response from the accelerator pedal, it happened several times again, at different speeds and different driving modes, should I wait to be involved in an accident to sue the company directly or what other recourse do I have? Have taken the car different times and mentioned the problem but they say "we found nothing wrong" the car is out of warranty now and have seen reports of transmission problems that should have caused a recall.

When the car starts all warning lights come on. Hill start assistance, pre collision assistance, all assistance. There is no cruise, no safety collision assistance at all. First appeared on June 13 2023. Ford Dealer is currently trying to fix the problem. They are unsure why it’s doing it. It puts all occupants life at risks as the car doesn’t have any safety assistance.

The contact owns a 2020 Ford Explorer. The contact stated that while exiting the vehicle, she observed the front driver's side seat control housing separating, hindering the use of the seat controls. The failure was later observed in the front passenger’s side seat. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 16,000.

I had an oil change at the Feldman Ford Dealership on or around 3/7/2023. On 4/14/2023 at or at round 5-6 pm; I was traveling southbound on I-75 when my 2020 Explorer suddenly slowed down from 70 miles per hour to around 40 miles per hour while I’m in the farthest lane and it wouldn’t go pass 45 miles per hour almost causing the vehicle behind to rear end me. The dash displayed a reading stating the oil pressure is low and to get engine serviced. I put on my hazards and safely made it to exit off of the freeway. I stopped at a gas station because the engine was making a loud screaming noise. I called my salesman from Feldman Ford and explained what was happening and what the dash was saying so he asked me to shut off the engine and to check the oil. So when I opened the hood I saw oil everywhere and the engine was so hot that the heat was burning my face. The dipstick was indicating that the oil was low to empty. He stated that’s impossible you just had an oil change 4-5 weeks ago and the engine appears that it’s not cooling. So he advised me to put in 2-3 quarts and get on my knees to see if any oil is leaking underneath and there was no leak after I put in 3 quarts of oil. So he asked how far was i from home i told him no more than 15 minutes, then he asked me to start the car to see if the noise diminished and it was not as loud so he said to see if I could get the car home because I had my 1 month old grandson and my daughter with me and he will have a tow truck to come a

Both front seats have brackets that have broken and come apart. Service says this is seen all the time. Pants and skirts get caught in it all the time.

17 recalls, multiple recalls for the same thing with the rear view camera Currently have another recall on the rear view camera with no exact date on when remedy will be available. Sounds like a qualifying lemon to me.

The Radio would not keep stations and eventually was almost always static. I took it to the Ford dealership that I purchased from since it is supposed to have a full warranty. They are now saying that it has water leaking in from the roof and it has damaged the OEM (?) system. They don't know if Ford will cover under warranty so I now sit with no vehicle as they wait for a decision. When and if it gets repaired I will now have to worry about other damage that will be caused by a leaking roof vehicle.

Car hesitates on acceleration; almost hit by oncoming traffic. Dealer reports a broken axle on 4 wheel drive assembly. Apparently there is an open investigation on this?

My passenger side low beam Headlamp stopped working in Nov 2022. I had a "check headlamp" warning light. I took it to the dealer on 12/09/22. They stated that they found code B155A:96 requiring replacement of the LED control module, requiring part #JX7Z-13C788-L (total cost $1112.25). Headlamp was operational approx 1 week. Returned to the dealership 12/16 with a non-functioning light. They installed RT Headlamp asset, performed calibration, and adjusted horizontal position. Requiring part #MB5Z-13008-AG (total cost $1750). The headlight remained operational for approx 6 months. The "Check Headlamp" warning light has come on again and I will need to have further repair. Having an intermittently functioning or non-functioning Headlamp makes driving at night or in the rain both unsafe and illegal. The cost of this repair was not covered by warranty.

I have had the previous recall for my rear camera/display screen repaired in 08/2022. However, recently I have had my display screen start to glitch and turn off intermittently. Sometimes this happens while I am driving. Other times is happens while I am in reverse and the reverse camera does not work. When the reverse camera is not functioning there is concern for unseen dangers. I have videos of this but I cannot upload them into the form.

Child Safety Lock - rear right door Regardless of position of safety lock - door is not fully operational. Generally does not open from the inside, however one out of ten times estimated door will open. No way to turn child safety lock on to secure. Had independent inspector and retail location look at vehicle. They recommended replacing the latch. Further research shows that Ford Broncos from 2020 to 2022 have similar issue with same door (right, rear). Would like investigated to ensure not impacting other vehicles being the issue year and manufacturer are the same.

Upon starting and before driving (still parked) steering column started making vibrating, creaking, cracking, screeching noises when adjusting to proper driving position and seems to be beginning to fail. This is worse when the vehicle has been heated by hot summer temps. I have video with audio too. I've attached Ford's TSB 22-2144 and the NHTSA ID# 10210476

The contact owns a 2020 Ford Explorer. The contact stated while driving 70 MPH, the trim on passenger’s side windshield had detached from the windshield. The contact stated that the trim on the driver’s side windshield had also detached. The vehicle was diagnosed. The dealer was contacted and stated that the vehicle was out of warranty. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle was out of warranty and provided no assistance. The failure mileage was 40,000.

Badly cut two fingers on my left hand opening the door handle because the chrome tip has peeled/separated which resulted in exposed, sharp edges. I received a notice for "Customer Satisfaction Program 22N17" related to the window switch chrome tips, but not the door handle chrome tips. The window switch chrome tips peeled off first, within the first six months of owning the vehicle, but they did not expose sharp edges and cut my fingers like the door handle chrome tips did.

Vehicle caught on fire while in operation. Smoke and flames noted under the hood behind glove box.

Ford issued safety recall 23S02 (NHTSA 23V022). in February 2023. We returned our vehicle to the dealer to have them repair and fix according to the recall. The backup camera was not working and the screen was blue. After having our vehicle for 3 days, they told us that the software was updated and we were good to go. Unfortunately, this problem still exists. In fact, on our vehicle the screen works sometimes, and sometimes is does not. We still get the blue screen when backing up. We also get a blank screen while driving. The radio always turns on to a different selection (am,fm, satellite etc). I don't think FORD has repaired this vehicle correctly and needs another recall. Our dealer says Ford is working on a fix, but that it has not been mandated from the NHTSA.

For months our backup camera would turn blue and not show the rear cameras. Also during this time, on occasion the emergency braking would stop us from backing up and then the brakes would not work. We had a recall on the blue screen software but the breaking has started again.

When the car starts all warning lights come on. Hill start assistance, pre collision assistance, all assistance. There is no cruise, no safety collision assistance at all. First appeared on May 19 2023. Ford Dealer is currently trying to fix the problem. They are unsure why it’s doing it. It puts all occupants life at risks as the car doesn’t have any safety assistance.

360 degree camera is failing. The screen goes blue in reverse and i hit a garage wall unable to see it thru camera. Now the camera is failing in the front as well . Also is now occuring on a daily basis nor random anymore. Ford has not addressed the issue only thue software updates which i have has 2 occasions and yet camera still fails.

The contact owns a 2020 Ford Explorer. The contact stated while driving approximately 65 MPH, the vehicle hesitated and started losing motive power. The contact was able to drive the vehicle to the residence. During a test drive, the vehicle stalled. The contact stated that the "WRENCH" symbol was illuminated. The contact stated that the engine was still running however, the vehicle failed to shift to park(P) or drive(D). The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that metal shards were found in the transmission and that the transmission needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 79,000.

2020 Ford Explorer ST (FAILED 5/27/2023) Vehicle started shifting erratically, down shifting very hard when decelerating. Then within two to three days it would not engage in drive or reverse at all, or it was slow to engage and would engage very forcefully and intermittently. There were no warning lights that I recall. The vehicle could not be controlled and is undrivable with 37,386 miles on it. Currently the vehicle is sitting at the dealership waiting two to three weeks to diagnose the problem. The Service Advisor described the problem as "The vehicle delayed getting into gear when put into drive, not shifting properly when driving. When vehicle in reverse there is an extended time to engage and does not feel like it's engaged all the way, feels like it's grinding" Ford acts like they have no idea that they have a transmission issue with the 2020 10 speed automatic transmission. The dealership is going to have my explorer for 30 to 60 days with no compensation, loaner car or rental car. this is the second Explorer that we have had with major issues. I also have a 2020 Ford F-150 with the same mileage and the same transmission that is experiencing delayed shifting issues.

On multiple occassions while driving, the accelerator/gas pedal looses functionality. For example, while coasting into a turn and needing to accelerate, the engine is completely unresponsive. The pedal can be against the floor and the vehicle does not respond. We have brought the issue to two Ford dealer's attention during routine maintenance and have been told that there are no stored codes in the system and that bad gas is the culprit as they were unable to replciate the issue during their brief test drives. Each time this has occured it has been with different (top tier) gas. One one occasion, I found that fully releasing the accelerator for several seconds then pressing it down it can engage. On a second occasion, I shifted to neutral and then back to drive for it to engage. On a third occasion, I shifted the drive mode to engage the accelerator. This issues seems to be a major safety issue that should have a better response than "bad gas." Especially when crossing an intersection with children in the car.

My vehicle has had 3 software updates to try correct blue screen issues. Recently under a blue screen i was backing up in a parking garage and hit the wall as i could not see with the screen being blue. Fortunately I was going slow but it did scrape my bumper from hitting the concrete wall. Mostly It scared my kids and had an abrupt stop. I had read a pin on the connector was left uncapped leading to corrosion resulting in faulting screen. Why is ford trying to fix with software update? They should of been replacing connector pins or cameras. I have been experiencing this for over 2 years.

Weather seal on moon roof fails, allowing wind and water to enter the passenger compartment and on electrical components. Apparently this is a common issue that is only warrantied under the initial 3/36 warranty. The seal is not available separately from the glass, and the glass is “not covered” by fords ESP warranty. The glass is also not available to purchase, and the dealer service department wants $2400 to replace said glass.