The contact owns a 2016 Ford Explorer. The contact stated that while driving in the rain, water leaked inside the vehicle from the dome light. No warning lights were illuminated. The contact stated that the moonroof failed to function as intended and was no longer able to be opened. The contact stated that there was mold on the front driver's side and front passenger's side seats, as well as inside the cupholders. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. However, the contact was informed that the moonroof assembly needed to be repaired. The contact had a friend inspect the vehicle and found a burnt wire underneath the steering wheel unit. The manufacturer was notified of the failure. The failure mileage was approximately 153,000.
2016 Ford Explorer complaints
Owner reports filed with NHTSA about this vehicle, newest first and reproduced as filed. They are unverified accounts: one proves nothing, and a pattern across many is the thing worth reading. Back to the full 2016 record →
I went to the dealer, Parsons Ford. The pillar b even has the weather stripping from recall is even detaching. Which they saw and stated its part of the recall. No recommendations to fox it. They said no parts or remedy at this time. Today when driving I heard noise and looked over. Saw the stripping getting worse. I contacted Ford and they say the same thing. This recall has been out since 2024 and no one wants to even fix it. I have a newborn coming and this is the only car I can use to transport her. I feel this is a safety risk not just for us but other people. See the pictures below all from today 9/5. The weather stripping is coming off more. I called Parsons Ford, they were to call me back. No response back today. Ford Social Media filed a claim and dealer to reach out. No response. All responses from Ford and myself today.
Both my A pillars have ripped off on the highway. Called Ford Service center and they continue to say there are no parts available. Most recent incident was on [XXX], when my passenger side ripped off INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 50 MPH, the front passenger’s side A-pillar trim detached. Upon further inspection, the contact noticed that the front driver’s side A-pillar trim was loose. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
The contact owns a 2016 Ford Explorer. The contact stated that while driving 70 MPH, the vehicle unintendedly started to decelerate. Additionally, while depressing the accelerator pedal, the brakes unintendedly engaged. The “Scheduled Maintenance” light was illuminated. The contact pulled over to the side of the road and depressed the accelerator pedal seven times, and the vehicle started to operate as intended. The contact stated that a dealer was contacted. The vehicle was taken to the dealer and was test-driven, and the dealer informed the contact that the vehicle was operating as designed. The contact related the failure to the results of a Google search on the throttle body. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The approximate failure mileage was 136,000.
Dear NHTSA, I am submitting a formal safety complaint regarding my 2016 Ford Explorer (VIN: [XXX] .) Build Date: (08/15.), Mileage (115,262.). My vehicle has experienced a steering rack failure, which poses a serious risk of loss of steering control. I am aware of multiple recalls (such as 20v-675 / Ford 20S62 and 21V-537 / Ford 21S32) Addressing rear suspension toe link fractures in 2016 ford explorers. These recalls cover vehicles built in the same timeframe as mine, but my VIN is not included. This exclusion is concerning, as both the steering rack and suspension defect involve loss of steering control and directly impact driver and passenger safety. I respectfully request that NHTSA investigate: 1. Why certain VIN's, including mine, were excluded despite being manufactured in the recall window. 2. Whether steering rack failures in the 2016 ford explorer should also be subject to an official safety recall. Thank you for your attention to this urgent safety matter. I look forward to hearing from somebody. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 65 MPH, the driver's side A-pillar trim was blown off the vehicle by the slipstream. The contact had not taken the vehicle to a local dealer or independent mechanic. The contact called the local dealer to determine when parts would be available, but was informed that parts were anticipated in 2026. The vehicle was not repaired. The contact stated that the passenger’s side A-pillar and the driver’s and passenger’s side B-pillar trims were loose. The contact received notification of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 104,000.
Air bag light illumination on occasion, ford confirmed and suggested $1000 repair. seems like a safety issue that is a manufacturer defect. vehicle has been maintained and rear seat rarely used.
See attached document for complaint.
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, parts to do the recall repairs were not yet available. The contact stated that the driver's and passenger's side windshield exterior A-pillar trims had detached, and the driver's side door exterior B-pillar trim was loose. The local dealer was not contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,295.
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (STRUCTURE) and 25V347000 (STRUCTURE); however, parts to do the recall repairs were not yet available. The contact stated that while driving 40 MPH, the front passenger’s side A-pillar trim detached from the vehicle. The vehicle was not diagnosed or repaired. The contact stated that on a separate occasion, the front driver's side A-pillar trim became loosened. The vehicle was not diagnosed or repaired. Most recently, the contact noticed that the B-pillar trim on the passenger’s and driver's side had become loosened. The vehicle was not diagnosed or repaired after the most recent failure. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 142,000.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, the vehicle vibrated, and there was an abnormal knocking sound coming from the transmission. In addition, the vehicle drove roughly while the transmission was downshifting, and the vehicle failed to accelerate as needed. No warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed with torque converter failure. The contact was informed that the torque converter needed to be replaced, or the transmission could be replaced. The vehicle remained at the dealer unrepaired. The manufacturer was made aware of the failure and referred contact to the NHSTA Hotline for assistance. Upon further investigation, the contact related the failure to the Technical Service Bulletin: 20B27. The failure mileage was approximately 100,000.
There are 2 active recalls for this VIN, both related to pillar body parts. The A-pillar recall was issued in January of 2024. The B-Pillar recall was issued in May of this year. Neither recall has been able to be addressed. Gray-Daniels Ford in Brandon, MS continually states that Ford has not issued a solution yet. This is unacceptable. Multiple pillar parts have fallen off of my vehicle while driving. I have ordered aftermarket solutions to try to remedy, but the inability for a major manufacturer to produce a solution and implement the same, over a period of 19 months and almost 4 months respectively, should not be tolerated. The NHTSA needs to investigate this and force Ford to implement a safe solution for these issues, and quickly.
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). The contact stated that water was leaking onto the passenger’s side floorboard and passenger’s side door, causing an electrical short with the windows. The contact stated that the window was stuck. The contact left the windows opened to air out the vehicle. The contact used duct tape to secure the structure. There were no warning lights illuminated. The local dealer was contacted and confirmed that parts were not yet available. The contact was added to a waiting list. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 86,800.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the A-pillar trim on the passenger’s side of the windshield started to detach. The vehicle was taken to an independent mechanic, where it was determined that the A-pillar trim had failed and needed to be replaced. The vehicle was repaired. The contact then received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that while driving at an undisclosed speed, there was a loud rattling sound coming from the driver’s side windshield. The local dealer was contacted, and the dealer stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 120,000.
The contact owns a 2016 Ford Explorer. The contact stated that the vehicle lost power steering assist functionality, and the steering wheel was stuck while attempting to turn the steering wheel to the left or the right. There were no warning lights illuminated. The contact spoke with the dealer and was informed that the power steering assist had failed and needed to be repaired. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 97,000.
I am writing to you today with an urgent and serious safety concern regarding my 2016 Ford Explorer XLT. My vehicle is affected by the A-pillar molding inspection recall, Campaign 24S02/24V031. Last week, while I was driving on the interstate, the passenger side A-pillar molding detached from my vehicle and flew off. This created an extreme safety hazard for myself and other drivers on the road. I contacted my local Ford dealership, Cloninger Ford of Salisbury, to have the recall addressed. They informed me that they cannot perform the repair because the necessary part is out of stock. This is a critical safety issue. The driver's side A-pillar molding is also loose and could detach at any time, posing the same risk. I have found the replacement part is available for purchase from various online retailers, which contradicts the dealership's claim of part unavailability. The recall documentation states that a detached trim piece can become a road hazard, increasing the risk of a crash. Given that this has already occurred with my vehicle, I need an immediate and concrete solution. I am requesting a specific timeframe for when a permanent remedy will be available for recall 24S02/24V031 and when I can bring my vehicle in for the repair. The safety of myself and others on the road is at risk. Thank you for your prompt attention to this matter. [XXX] [XXX] [XXX] VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the front driver’s side and passenger’s side A-pillar trims detached. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 120,000.
The contact owns a 2016 Ford Explorer. The contact stated that the passenger’s side A-pillar trim was loose. The contact used glue to secure the trim piece. The contact had not taken the vehicle to a dealer. The contact had received notification of NHTSA Campaign Number: 24V031000 (Structure) and 25V347000 (Structure); however, after calling the dealer to schedule an appointment, the contact was informed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 115,000.
I was made aware of a recall for my 2016 Ford Explorer Sport involving the Exterior A-Pillar Appliqué molding recall#24S02 and NHTSA# 24V031 I had an inspection done on 12/30/24 and it was determined at that time it needed to be replaced, but parts were not yet available. I have since then regularly checked with the dealership to see if parts were available, but they have not become available. I reached out to Ford directly on 7/28/25 and was told my case was escalated and I need to work with my 'case handler' who did not contact me until 8/11/25 after I made multiple repeated requests to speak to someone. They informed me there are no parts, there is no ETA and despite assurances to the contrary(they informed me that they "...works daily with your dealership's management team." have not spoken to the service advisor at the dealership as of yet. their case number at ford is [XXX] The part flew off on the highway on [XXX] and now today, [XXX] the rubber around the windshield is coming loose. Ford continues to say they have no updates. The dealership said the last they checked, last week, there were over 30,000 orders in for this part, that Ford was no longer accepting new orders from dealers for this, and that they will not give any ETA on this being remedied. I'm concerned that more damage is being done to my vehicle and based on Ford's behavior thus far will try to not cover any additional repairs that caused by their inability to provide a repair in a reasonable and timely
2016 Ford Explorer. A-Pillar trim piece flew off vehicle while driving on highway. Part recalled Jan 2024, currently no solution available from Ford. Paid out of pocket to replace in 2022. B-Pillar trim piece flew off vehicle while driving on highway, remained attached by soldered wires. Part recalled May 2025, currently no solution available from Ford. Paid out of pocket to replace heavy duty, waterproof double sided tape in Jan 2025, tape failed again by July ‘25. Cannot tie piece on because the window won’t function. Tape fails, so currently having to reattach while driving with my arm out the window or pull over every few minutes and drive slowly. Left with no options to repair from Ford!
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact used tape to secure A-pillar trim to prevent the trim from detaching from the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
The contact owns a 2016 Ford Explorer. The contact stated while driving at various speeds, the driver's side exterior A-pillar trim was hanging off the windshield, obstructing the contact's view while driving. The contact stated that condensation was entering the vehicle through the driver's side exterior A-pillar trim, also obstructed her view while driving. The contact later received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the failure but offered no assistance. The failure mileage was approximately 65,000.
The water pump has been replaced 3 times within a 2 year period on this vehicle . Something is causing it to fail and the constant leaking of fluid causes the vehicle to drive erratically in highway traffic. The alternator has been replaced twice within a 10 month period. Something is causing it to fail and it has caused major anxiety because the vehicle has completely turned off in the middle of extreme traffic. This is a dangerous situation and has yet to be fully remedied. I believe this model to be a lemon.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the A-pillar trim on both sides of the windshield started to detach. The contact also stated that the B-pillar trim on the driver's side started to detach. The contact received notification of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). The vehicle was taken to the dealer, but was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the failure. The approximate failure mileage was 53,000.
The contact owns a 2016 Ford Explorer. The contact stated that after it had rained, the contact entered the vehicle, and the driver's side carpet was wet. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) and 25V347000 (Structure); for the A-pillar and B-pillar failure. The contact stated that recently the A-pillar trim on driver's side was loose and the seal around the windshield on the driver's side was also loose. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact related the failure to the A-pillar trim recall and felt that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the failure. The failure mileage was approximately 108,000.
The contact owns a 2016 Ford Explorer. The contact’s spouse stated that while reversing, the rearview camera image was distorted, nearly causing the driver to hit a child while reversing in a parking lot. A bystander alerted the driver to stop the vehicle, which prevented the incident from occurring. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 116,000.
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that while the vehicle was parked, the contact became aware that the driver's side and passenger's side windshield exterior A-pillar trims were missing from the windshield. The contact also stated that condensation had entered the vehicle through the defective passenger's side and driver's side doors exterior B-pillar trims on rainy days. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failures. The failure mileage was approximately 50,000.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 35 MPH, the steering wheel became stiff and did not drive as intended. The contact stated that the next morning, she observed a sound emanating from the steering column. The check engine warning light was illuminated before the failure. The vehicle was not diagnosed or repaired. The contact believed that the failure was associated with NHTSA Campaign Number: 20V675000 (Suspension). The manufacturer was not notified of the failure. The failure mileage was approximately 156,580.
The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the front driver's side B-pillar trim detached and separated from the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure; however, the contact was informed that parts were not yet available. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.
The contact owns a 2016 Ford Explorer. The contact stated that while in reverse(R), the vehicle failed to turn to the left or right, and the steering wheel was stiff. The contact stated that when the vehicle was shifted into drive(D) and pulling into a parking spot, the steering wheel was stiff. There was no warning light illuminated. The contact stated that the vehicle was turned off and restarted without the failure recurring. The vehicle was taken to a dealer for maintenance on the brakes, and the vehicle was diagnosed, and it was determined that the steering rack assembly needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was approximately 93,500.
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE). The local dealer was contacted and informed the contact that parts were not yet available for the recall repair. The vehicle was not repaired. The manufacturer was contacted regarding parts not being available. The contact had not experienced a failure.
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE). The local dealer was contacted; however, the contact was informed that parts for the recall repair were not yet available. The vehicle was not repaired. The manufacturer was contacted about parts not being available for the recall repair. The contact had not experienced a failure.
See attached document for complaint.
Exterior b-pillar applique molding FLEW OFF of explorer. Might have hit people or cars. Has been inspected and confirmed by Ford dealership in December 2024. No warning of problem. Been waiting for part for 8 months, but service department said none are coming in.
My B-pillar trim flew off while I was driving down the road. We received a recall letter and got in contact with the Ford dealership where I live. They came out to asses the vehicle and said they would call me when they received the part to be replaced. I have been waiting at least a year for it to be fixed. I have called several times but they keep telling me the part is on back order and they will call me when it comes in.
I was driving the family and about to enter the highway when my steering started to feel like there may be a problem. The steering started to feel like it was sticking. I turned around and headed back home (about 4 miles) by the time I entered my street, steering failure warning lights started on the dashboard. I had to come to an abrupt stop because the steering wheel would not turn to pull in my driveway. We had to dolly the rear of the car over so i can pull straight into my driveway. I can not even imagine what would have happened if I did not turn around to head home. If this happend on the highway or on a ramp, I could have become devestating.
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that while driving at various speeds, there was an abnormal sound coming from the vehicle. The contact stated that on a separate occasion, while driving 50 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was not contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 90,000. VIN tool confirms parts not available.
A pillar components have come detached on both sides of my vehicle. One on the right side in spring of 2024 and one on the left side summer 2025. The entire rubber and plastic moulding is missing on the right and the entire rubber became unattached underneath the plastic pillar accent on the left. I am afraid of that piece detaching and hitting a car. Why is it taking so very long for a remedy for this?!!!!???
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the front driver's side B-pillar trim fractured and detached from the vehicle. The B-pillar trim was hanging on by the electrical wiring. In addition, the rear liftgate warning light was illuminated and the rear lift gate power was deactivated. The vehicle was taken to the dealer and the contact was informed that the parts were not available. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 124,000. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that while driving 50 MPH, the driver's side A-pillar trim detached from the vehicle. The vehicle was taken to the dealer. The contact stated that on a separate occasion that before the recall notification was received, the front passenger’s side A-pillar trim had detached from the vehicle. The local dealer was contacted. The vehicle was repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the issue. The failure mileage was 85,932. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact stated that while driving 65 MPH on the interstate, the passenger’s side keypad detached from the vehicle. The driver's side and passenger’s side keypads were loose before the failure occurred. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 130,539.
Good Morning, I’m reaching out in regards to my 2016 Ford Explorer. I’ve been trying to get the necessary recall repairs completed, but unfortunately, I’ve been unable to locate the required pillars for the repairs. I recently brought my vehicle back to the dealership, but was told that no work can be done until both parts are available. I was also advised to try sourcing one of the parts from another Ford dealership on my own, which I’ve had no luck with. To be honest, I’m feeling very overwhelmed. I purchased this vehicle used, back in September 2025, and since then, it has been one issue after another. I’ve already invested more into mechanical repairs than what I currently owe on the vehicle. I’m a [XXX], and this vehicle is our only mode of transportation. I’m growing increasingly concerned for our safety, especially knowing that the recall parts are critical and things could start to fall apart — literally — if they’re not addressed soon. With that said, I would greatly appreciate your help in exploring any other options available through Ford or the dealership. Some specific questions I have are: Is there any way for the dealership to help source the necessary parts through other Ford networks or escalate this to Ford corporate? Can you assist with a temporary vehicle solution while waiting on the parts (loaner or rental)? Would there be any way to explore trading in or transitioning into another vehicle, even with the current issues and financial position I’m in? I un
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the A-pillar trim fractured and detached from the vehicle. The contact stated that the trim was hitting against the vehicle. The contact stated that the A-pillar trim detached and almost caused a crash with three other vehicles. The contact stated that the remnants of glue on the windshield impaired the contact’s vision while driving. The contact stopped and cleaned the glue off the windshield. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure, and an emergency service appointment was scheduled. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 57,000. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact stated that the A-pillar trim bordering around the driver’s and passenger’s side windshield had detached. The contact used tape to secure the trim. There were no warning lights illuminated. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the front driver side A-pillar trim detached, and the front passenger’s side A-pillar trim was loose. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 165,000. VIN tool confirms parts not available.
The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers:24V031000(Structure) and 25V347000 (Structure); however, the parts to do the recalls repairs were not yet available. The contact stated that while driving 70 MPH, the driver's side windshield exterior A-pillar trim detached from the vehicle. Additionally, the trim surrounding the windshield came loose. The local dealer was contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000. VIN tool confirms parts not available
Reading these
NHTSA publishes every complaint as the owner wrote it and investigates only a fraction. Spelling, capitalisation and judgement are the filer’s own. What carries weight is repetition: the same component failing the same way across many filings, and whether the manufacturer eventually opened a recall for it.
Full record for the 2016 Ford Explorer → · Every Explorer year → · How the figures are calculated →