2016 Ford Explorer complaints

The contact owns a 2016 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the temperature gauge started to indicate that the engine was overheating, prompting him to pull over to the shoulder of the roadway to allow the engine to cool down. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the water pump. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 98,000.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving 65 MPH, the outer structure of the A-Pilar trim detached from the vehicle. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 82,500. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating, prompting the contact to pull over to the shoulder of the roadway. After a visual inspection, the contact observed that the coolant reservoir was empty. The overheating warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the water pump. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 78,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving 25 MPH, the vehicle failed to exceed 25 MPH or shift out of 1st gear. Additionally, the contact stated that while shifting to reverse(R), the vehicle failed to respond as needed. There was no warning light illuminated. The contact stated that the failure had been recurring. The vehicle was taken to the dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 56,000.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while the vehicle was parked, the contact observed pieces of rubber on both the driver’s and passenger’s sides were deteriorating. The vehicle was taken to a dealer where it was diagnosed that the exterior A-Pillar trim needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 95,000.

Trim piece flying off while the vehicle was in motion with traffic around me.

Water pump failure at 60K miles on a 2016 ford explorer, this model has the most reported water pump failures on record. this is a 15 hour repair job at the dealer, and the same complaint litters the internet. The failure on my vehicle was confirmed by dealer, $4k to fix. Not to mention the mess in my driveway where the coolant expelled without notice. If I drive it, the engine will be damaged, and there goes my car. In 2020 NY and MI class action lawsuits over this issue were settled & closed WITH payment to plaintiffs, yet no recall. WHY? too expensive for Ford? We see safety recall on clips yet nothing on an admitted engine problem than causes stalling or engine damage while running? There's a class action in Canada. Ford is dodging a known defect. Please do something about this.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the front driver's door trim panel detached, and the keyless entry keypad wiring became exposed. The "Door Ajar" message was displayed. The failure prevented the rear liftgate from opening as needed. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 66,205. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the passenger's side front windshield trim detached and flew off. In addition, the driver's front side windshield trim had also detached. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 149,000. VIN tool confirms parts not available.

Check engine light came on. Took it to the shop and found out that the Cadillac converter needs to be replaced which will be more than 2000.00. I found that there was a recall in 2021 for the same problem.

The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.

The contact owns a 2016 Ford Explorer. The contact stated while driving 60 MPH, the passenger’s side glove box console detached. There was no warning light illuminated. The vehicle was taken to the dealer but was not diagnosed. The contact was informed that the glove box console needed to be replaced. The vehicle was not repaired. The contact was concerned that he could have been involved in an accident or severely injured due to failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

The contact owns a 2016 Ford Explorer. The contact stated that while making left and right turns on several occasions at various speeds, the parking assist warning light illuminated, and the steering wheel became stiff. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,312.

Steering started grinding in the winter months around 110,900 and locked up while driving. Took to Ford Service and the Rack and Pinion is faulty. The tech said it was not due to any driving damage, but a faulty part. Vehicle currently has 120,000 miles on it and locks up driving down the road. The potential for a dangerous accident is high. This is a known issue for Ford Explorers in various years and Ford should recall this.

Trim on driver side windshield flew off while driving. ordered Replacement, 2 weeks after i replaced the driver side the passenger side has fallen off while driving. I have not yet ordered the passenger side yet but today while driving home down the interstate the driver side that was just replaced less than 30 days ago flew off again. Being on the interstate it hit my windshield and flew over and hit a truck traveling behind me who swerved I do not know if it did any damage to his vehicle neither of us stopped ( We were on the interstate but I did notice he swerved luckily did not hit any other vehicle. However now I am hearing a whistling I just got home to do some research and see this is in an ongoing issue but what do I do? order and replace again this will be 3 sets in less than 60 days. this site says there is not a known fix yet?

Rackin n pinion safety hazard

Component or system failed or malfunctioned unavailable for inspection upon he safety of others put at risk Had the problem been reproduced or confirmed by a dealer or independent service center Has the vehicle or component been inspected by the manufacturer representatives or others warning lamps messages other symptoms of the problem prior to the failure, and when didnt first appear What component or system failed or malfunctioned, and is it available for inspection upon request? How was your safety or the safety of others put at risk Has the problem been reproduced or confirmed by a dealer or independent service center component been inspected by the manufacturer,representatives any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear fully report

Popping noise from rack and pinion

The contact owns a 2016 Ford Explorer. The contact stated while driving 55 MPH, the contact heard a loud clanking noise coming from the transmission. There was no warning light illuminated. The vehicle was taken to an independent however, the vehicle was not diagnosed or repaired. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the flex plate was cracked, causing transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 90,060.

While driving on the interstate my transmission decided to stop working. I was not able to safely get off the interstate because this happened going up an incline. My explorer will not shift into any gear and the cost to replace the transmission is $5300. Ford stated that the recall #20B27 was completed on my car in 2020 but when I called after the transmission died they stated that my VIN was not eligible for the #20B27 recall. So, how was it completed if they are now saying the recall wasn’t for my car? My explorer is a 2016/2.3L/6F35 Transmission code/built in Chicago. Ford needs to recall and replace every transmission in these explorers. With so many complaints and transmission failures/problems I’m floored that nothing has been done to remedy this situation that many explorer owners are experiencing. Do better Ford.

The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 60 MPH and attempting to stop or decelerate, the rear tires were slippery and failed to stop as needed. No warning lights were illuminated. The vehicle was taken to an unknown local dealer however, no failure was found. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated while driving approximately 55 MPH, the A-pillar trim on the passenger’s side raised up and blew off the vehicle by the slipstream. The contact was unable to stop to retrieve the part. The contact had not taken the vehicle to a dealer or body shop. The vehicle was not repaired. The failure mileage was approximately 83,000. VIN tool confirms parts not available.

The car caught on fire driving it to my brother's house to babysit his kids while #4 being born prematurely with complications at southwest ms regional medical center. I lost almost 15,000 in equity and my husband recently passed things inside I can't replace. It was about 11:00 at night and I made a uturn to stop at gas station and truck was already on fire. Many police officers and innocent bystanders almost were tremendously injured because the car was shooting whistling fire like rocket from all ends holding up traffic 1/2 mile on both sides of hwy and opposite side of hwys traffic.

The contact owns a 2016 Ford Explorer. The contact stated while driving 55 MPH, he was alerted to smoke emanating from underneath the vehicle by another driver. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the power transfer unit, after observing that the unit was leaking fluid onto the exhaust, resulting in a brief fire. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 98,000. The VIN was not available.

The contact owns a 2016 Ford Explorer. The contact indicated that when she took the vehicle in for a routine service at an independent mechanic, the technician became aware that the water pump was leaking, and the timing chain needed to be replaced. The vehicle was not repaired. The vehicle was also taken to a local dealer where the previous diagnosis was confirmed. The contact stated that before taking the vehicle for the routine service, she noticed a burning odor while exiting the vehicle. The manufacturer was not informed of the failure. The failure mileage was approximately 108,000.

The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, and making a turn, the steering wheel seized, and the contact struggled to regain control of the steering wheel. In addition, the contact noticed a grinding sound while making a turn. The vehicle was taken to the dealer where it was diagnosed with a failed rack and pinion. The contact was informed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and the contact was advised to report the failure to the NHTSA Hotline. The failure mileage was approximately 147,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 55 MPH, the A-Pillar trim on the driver’s side detached from the vehicle and flew off. The contact stated that two months later the A-Pillar trim on the passenger’s side almost detached from the vehicle while driving. The contact was able to pull the vehicle to the side of the road and removed the trim. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the A-Pillar applique trim detached from the vehicle. The contact replaced the part. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 82,000. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact stated that the sunroof failed to close. The seat belt warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the sunroof motor had failed and needed to be replaced. The vehicle was not repaired. The dealer informed the contact that the parts were on backorder. The manufacturer was not contacted. The failure mileage was approximately 136,000.

The contact owns a 2016 Ford Explorer. The contact stated that while the vehicle was started, the air bag warning light illuminated. The vehicle was taken to a dealer where it was diagnosed that the seat belt retractor was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 106,000.

My car has 84000 miles on it. The car recently over heated, I checked the coolant level, and it was low. I filled it to the required level and the warning went away. 2 weeks later it came back, I brought it to the mechanic and was told that the engine needs to be replaced. That it is recycling exhaust from the engine back through the coolant system and that cylinder 3 is misfiring. I spent over an hour on the phone with Ford who repeatedly stiff armed me on any sort of assistance with the issue or information on expected or estimated failure rates for these issues. The car is currently at the mechanic where I have an estimate with a $12,000 price tag on it. To make this worse, in October of last year I was driving down [XXX] and when I went to exit the highway, there was a loud clunk and the car revved up real high before it started to move. This put me and all the drivers exiting this very busy off ramp in danger. At 74,000 miles I needed a new transmission because that loud clunk was me losing actual gears in the transmission. That repair cost right around $10,000 and again, Ford does not care. There were no warning lights with this issue, it just happened and left me in a very precarious predicament at a very busy intersection. The transmission has since been replaced for roughly a $10,000 price tag and now I am looking at another $12,000. All I want is Ford to do what is right. I could have been killed in that intersection or my car could have caught on fire recently with

The contact owns a 2016 Ford Explorer. The contact stated while driving 75 MPH, the A-pillar trim on the driver's side detached from the vehicle and flew off the vehicle. No warning lights were illuminated. The vehicle was not diagnosed or repaired. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that while driving at undisclosed speeds, there was a flapping sound coming from the vehicle. The contact pulled over to the side of the road. The contact observed that the rubber seal around the windshield was detaching. The local dealer was contacted. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 60,000. VIN tool confirms parts not available.

A loud clunking noise was heard when the vehicle was turned to the right. Diagnosis at the CarMax repair facility indicated that the steering rack was broken. Diagnosis was complicated by the fact that the damaged part was hidden under a rubber boot. The actual damage on the steering rack appears to be a broken retainer, sealing washer, or similar that circles the jack screw of the steering rack. This retainer or washer is visible in the attached pictures. I believe there was a potential for the damaged retainer or washer to become jammed in the steering rack when the rack is in the right turn position which would make it impossible or difficult to turn the steering wheel. This could have resulted in an accident. I authorized CarMax to complete the repair and was informed that the steering rack was back ordered from Ford and would not be available for approximately 3 weeks. CarMax gave me a loaner vehicle and completed the repair when the part arrived. The broken steering rack was returned to Ford. A steering rack is not a part that I expect to fail. The fact that the part was back ordered for three weeks suggests that this part is in high demand because this is a common problem with this vehicle. The fact that the damaged part was concealed by a rubber boot made it difficult to diagnose. Clunking noises in the front suspension of a vehicle can be caused by many problems and a failure to correctly diagnose this problem could have resulted in a serious accident. I thanked the

A-pillar trim pieces have both become detached. One detached from the vehicle while traveling on the highway and flew into on-coming traffic. The other detached on the highway and hung on the drivers mirror. Ford advises that even though both parts have detached it is the customer's responsibility to pay for repairs since the recall is still in advanced notice status.

Rack and pinion binds. This suddenly started around 70,000 miles. It makes a grinding noise that seems to be in the steering column. While driving it catches and takes effort to move steering wheel past the catch.

The contact owns a 2016 Ford Explorer. The contact stated that the vehicle was taken to an independent mechanic for service, and the contact was made aware of a failure with the rear upper control arms. The contact stated that both control arms displayed abnormal movements, and the suspension could not be properly aligned. No warning lights were illuminated. After investigating the failure, the independent mechanic related the failure to NHTSA Campaign Number: 21V537000 (Suspension) however, the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 116,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact became aware that the sunroof had started to detach and had sunken into the interior of the vehicle, creating an opening that allowed water to leak into the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the sunroof motor. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 116,000.

The contact’s wife owns a 2016 Ford Explorer. The contact stated that while his wife was driving out of the driveway, she noticed a loud clanking and grinding noise coming from the steering wheel. The contact’s wife stated that the steering wheel became difficult to operate while driving the vehicle. There was no warning light illuminated. The dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 123,684.

The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 60 MPH, the passenger's side A-pillar trim detached from the vehicle. The vehicle was not diagnosed or repair. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted; however, it was confirmed parts were not yet available. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 80 MPH, the A-pillar trim detached from both sides of the windshield and flew off from the vehicle into traffic. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The failure mileage was unknown. VIN tool confirms parts not available.

As I was driving down the highway my steering got stuck in a turning position and I had to pull really hard for it to go straight almost crashing

The contact owns a 2016 Ford Explorer. The contact stated that the passenger’s side exterior A-pillar trim had detached. Additionally, the contact stated that on several occasions while driving at various speeds, she observed a loud flapping noise emanating from the window. The vehicle was taken to a dealer where the passenger’s side A-pillar trim needed to be replaced, but parts were not available. The manufacturer was made aware of the failure. The failure mileage was 80,095.

The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 75 MPH, the passenger's side A-pillar trim, detached from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was 74,151. VIN tool confirms parts not available.

I filed a complaint yesterday 5/4/24. The complaint number is #11586924. Yesterday I gave you the details of what happened with my transmission and when it happened. Today I want to give you the Manufacturer Comm. Number. From Ford Motor Co. the service number is SSM46069. It states that Ford knew there could be a problem with some 2015/2016 vehicles equipped with 6F50/6F55 transmissions built on 11/02/2015 and through 2/01 2016 may exhibit no reverse, 3rd and 5th gear. The service bulletin goes on to explain what would cause the transmission to fail and how to repair the damage. This tells me Ford should be responsible to the consumer. My safety concern is this; I was traveling at 30 - 35 mph when the tranny failed and , not knowing at the time, I lost 3rd, 5th and reverse gears. There was a noticeable decrease in my cars speed. At that speed, I was able to control my car and get stopped. Picture if I was on a 5 or 6 lane highway traveling at 60 - 65 mph and the tranny failed. The results could be deadly. I am sure I'm not the only owner that has had this safety issue. Kindly investigate this safety issue asap. Thank you.

Unknown Overall something within while driving my truck i had starting hearing a grinding sound while turning and then the steering started to lock up, very unsafe and while my children were going to school had me in panic mode in which i never experience out of all the vehicle ive had and paid off.

While driving on the highway at approximately 80 mph, the driver side A-pillar molding on my 2016 Ford Explorer flew off and struck a vehicle behind me. I am not able to determine if there was any damage to the impacted vehicle. On my vehicle, there are what appear to be scratches or smudges on my door and window due to the rubber molding flapping rapidly. I have attached a picture for reference. I have contacted Ford Motor Co., and all they communicated was they are working on a remedy but could not offer any other resolution to a potentially deadly and catastrophically unsafe situation. The speed at which this is being remedied is unacceptable. my family and the other lives in the impacted vehicle were put in danger. This is not an unserious matter.

I own a 2016 Ford Explorer. My Wife and I bought the car In Jan. 2016. On April 20th 2024, I was on my way to work when a warning came on the dash that said "check manual" and displayed an open end wrench. The car hesitated and then continued on. I was not far from the Ford Dealership where I bought the car so I went there. The service writer was working that day so I left the car at the dealership and called for a ride. On 4/23/24, the service writer called me and said the transmission was shot and would need to be replaced. My bill would be approx $5954.81.

The contact owns a 2016 Ford Explorer. The contact stated that when the heater was turned to the on position, it blew out cold air. There were no warning lights illuminated. The contact called an independent mechanic, who informed the contact that the water pump was leaking, and that the engine needed to be replaced. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact called another local dealer, Bill Currie Ford (5815 N Dale Mabry Hwy, Tampa, FL 33614), but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 60,000.

The Steering shaft froze(steering shaft U jionts) making steering hard especially when it cold out.