2012 Ford Explorer complaints

Power steering control module failure occured on 2012 Ford Explorer. Dash displayed a "Power Steering Assist Fault" randomly but would resolve itself after turning vehicle off and back on, and now it is permenantly. Recall 15N01 was open on this vehicle but manufacturer will not service this vehicle under recall due to a 10 year, 150,000 mile limit. After getting the vehicle diagnosed a DTC U3000-72 was revealed which is one of the codes under recall. Previously unable to effectively steer vehicle without notice, and now unable to steer without assist all together.

Electronic power steering assist quit functioning while driving. After I parked the vehicle the steering wheel could not be turned under manual power leaving the vehicle only able to go straight forwards or backwards. Leading to a $2,900 repair bill and an additional $100 tow bill

The contact owns a 2012 Ford Explorer. The contact stated while driving approximately 65 MPH, the exterior A-pillar trim detached from the vehicle and flew off. The contact purchased the trim piece and replaced the trim piece three times; however, the failure reoccurred. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was not contacted. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2012 Ford Explorer. The contact stated while driving at approximately 50 MPH, he became aware of a strong clicking sound coming from the steering wheel. No warning light was illuminated. The vehicle was taken to an independent mechanic who diagnosed that the rack and pinion needed to be replaced. The local dealer was contacted and confirmed that an unknown safety recall related to the rack and pinion for the vehicle had expired. The contact had not received notification regarding the recall. The manufacturer was not made aware of the failure. The failure mileage was unknown.

I purchased a 2012 Ford Explorer in April 2024. Less than a month later, the Power Steering Assist Fault light appeared. I had it checked by PepBoy and was informed there was a recall on this issue and to contact my local Ford. I made the call and was told this was no longer a recall but a Customer Service issue and may not be covered due to age and mileage. The vehicle is driveable but turning is problematic.

It happened a year ago when I was parked I turned the car on and the steering wheel locked, giving me the power steer assist fault error on the dash. I had to turn off the car and turn it back on. This happened about 2 or 3 time that year. Yesterday while driving out of my driveway I got the error again. This time it was different I wasn't parked, the car locked while in motion. Thankfully I wasn't on the street driving with the wheel locked in a turning position. I called Ford and they said that they just extended the satisfaction for the warranty on power steer to 10 years or 150,000 miles. This isn't a warranty issue. No car should have its steering locked, it's a 2012 car not even that old to be posing a safety issue like this. This need to be made a recall not extended warranty.

The contact owns a 2012 Ford Explorer. The contact stated that while his wife was driving 55 MPH, the vehicle experienced a loss of power steering assist. The "Power Steering Assist Fault" message was displayed. The failure almost caused a crash. The contact helped his wife steer the vehicle and pulled over to the side of the road. The vehicle was taken to the dealer, where the rack and pinion were replaced. The manufacturer was made aware of the failure and the contact was informed that the vehicle was previously repaired under NHTSA Campaign Number: 14V286000 (Steering). The failure mileage was approximately 122,000.

In February of 2024 I had a second windshield exterior trim come off on the highway. The poor people behind me almost lost control of their vehicle on the ice because of this hitting their car. I have purchased this part in the past for the right side as that was coming off the passengers side. I had it replaced at my expense and would like to get that money back as it was a faulty part obviously. This cost me a great deal of money. I do not have the money to do this again while you are waiting to figure out how to make all the parts for people. This is now becoming a bigger issue as water is getting inside my vehicle around the dash. It looks also like someone tried to repair this part that is attached to the vehicle long ago (glue or weld), previously broken on drivers side. I have called Ford here in Pocatello, Idaho three times now. They said, "We do not have a remedy just yet on the recall. It should happen later in the year around November and you will receive a letter." One person told me I could just buy the part and have it replaced. When there is a recall, I should not have to do this. Please contact me at: [XXX] or [XXX] I look forward to getting this resolved soon. Thank you! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2012 Ford Explorer. The contact stated that while driving at approximately 60 MPH, the exterior A-Pillar trim detached from the vehicle. The contact stated that the failure reoccurred, and the exterior B-Pillar trim also detached from the vehicle. The vehicle was taken to an independent mechanic where the parts were replaced; however, the failure reoccurred and both trims detached from the vehicle. The vehicle was not diagnosed or repaired. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was 175,000. VIN tool confirms parts not available.

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while her daughter was driving at approximately 65 MPH, the driver's side A-Pillar trim detached and blew off the vehicle. The contact recently received notification of NHTSA Campaign Number: 24V031000 (Structure), and currently the passenger’s side A-Pillar trim had loosened up. The failure mileage was approximately 100,000. VIN tool confirms parts not available.

The contact owns a 2012 Ford Explorer. The contact stated while driving 30 MPH, he became aware that the electronic power steering was not functioning properly, and the steering wheel was stiff and required increased effort to maneuver the vehicle. The vehicle returned to normal functionality, but the failure became a regular occurrence. The power steering assist warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V286000 (Steering), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 167,000. The VIN was not available.

The contact owns a 2012 Ford Explorer. The contact stated while driving at an undisclosed speed, the trim panel on front windshield detached and impacted with the passenger’s side window. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The local dealer was contacted and stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

Driving vehicle with my 15 year old daughter, noticed a smell in cabin, we both started feeling strange, getting a headache, dizzy, fearful of co2 pulled over and had it towed to dealer

Airbag lights kept going on and off and now stays on giving code B1212. It is a safety issue since it has to do with the Driver seatbelt buckle pretensioner circuit. Airbags may not deploy incase of an accident. Apparently it is a problem with ford explorer vehicles which ford has failed to rectify or have a recall for it. I need to know the fix or resolution for this before anything unfortunate happens.

The contact owns a 2021 Ford Explorer. The contact stated that while his wife was driving at 65 MPH, a pillar trim detached from the vehicle. The local dealer was not contacted. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however the parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure was approximately 168,000. VIN tool confirms parts not available.

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving at approximately 45 MPH, the driver’s side exterior A-Pillar trim flew off the vehicle. The dealer was contacted but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 36,000. VIN tool confirms parts not available.

The contact owns a 2012 Ford Explorer. The contact stated that the vehicle was experiencing a hard pull to the right while depressing the accelerator pedal. The contact stated that the failure occurred while driving from a complete stop and while driving on the highway. The contact received notification of NHTSA Campaign Number: 21V746000 (Suspension) and the vehicle was taken to the dealer, where it was determined that the rear toe links needed to be replaced; however, the part to do the recall repair was not yet available. The contact stated that the failure was recurring increasingly. The vehicle was taken back to the dealer, who informed the contact that the recall repair had already been performed on the vehicle; however, the contact stated that the recall repair had not been performed on the vehicle. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 100,000.

The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the front windshield trim detached. The contact stated that there were missing pieces of trim, and pieces of detached trim were loose and flapping. The dealer was not made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 103,000. VIN tool confirms parts not available.

On December 29,2023 while driving on highway the Power Steering failed. I was unable to steer vehicle off roadway.I avoided getting killed, but very frightning.Warning lights appeared on the dash after failure , Service Power Steering now, Service Advance Trac, Terrain Mgt System Fault. Danvers Ford, Danvers, MA said the Steering gear needed to be replaced approx. $3,000 and that Ford Customer Relationship Center is unable to assist because the vehicle was outside the Recall criteria. I am horrified regarding the safety of the driver when the power system fails in real time and the cost to repair a faulty electronic steering that Ford should be responsible to repair.

While driving in my driveway, the steering froze up, I could not turn the wheel at all. I had it towed to the dealer.

The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed, she heard an abnormal sound coming from underneath the vehicle. The check warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the bushings. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 198,000.

The hazard lights have never worked in my vehicle and after spending months at the dealership they were not able to fix this. Also my window pillar flew off hitting another car while I was doing 75mph and the window cowl did the same thing. I've been working with a Ford dealership in Evansville, Indiana on Walnut Street and the window cowls need recalled and I was told that it will take 6 weeks to fix the pillars but the window cowl is so loose it's going to fly off in due time plus most of the vehicles the hazard lights do not work at all. Also I was able to turn the My Key feature on and I can't get it to turn off and my dealership can't figure it out. My electrical power steering unit, the steering gear box and steering knuckle also went out. And the rear end fractured on me while driving I lost steering 4 times while driving and almost hit a semi.

Driver's side window trim piece (which includes keyless entry keypad) detached from vehicle while driving 70+ mph & smacked several times against driver's side window before busting off. Bottom part is attached by wires (for keyless entry pad) & continued to smack against the window several times before I was able to safely pull over and tape to vehicle. I'm surprised it didn't bust the window as hard as it hit and startle of it detaching could have caused an accident in heavier traffic. Also, trim pieces on both sides of rear window are cracked in the same area on each side. I wouldn't be surprised if they flew off at some point and hit a car travelling behind me.

Power steering assist failure. Fortunately happened in a parking lot. Was told recall is no longer in affect. Will have to get to dealership for repair. No warning other than the failure that produced a code on the dash when the steering stopped working.

Seam seal where the roof, D pillar, and hatch area meet had a hole in it leaking water into the cabin causing underpadding of the floor to become soaked and creating a moldy/musty smell. Patched hole to stop water leak. Ruined the carpet from the spare tire well up to the front passenger floor board

The exterior A pillar on my Explorer flew off while driving. I had to pay out of my pocket to repair this. Now I have been notified that there is a safety recall notice on this item. I should be compensated for the repairs I had to make as a result of this faulty part. How do I go about receiving compensation from Ford?

Rear tires rubbing and car is uneasy in rain. Had to have tires replaced due to rubbing on interior of rear of car. Tires wear extremely fast and dangerous to drive in any weather conditions such as rain. Inspection says there is no alignment or adjustment issues. However tires continue to wear apparently there are aftermarket parts to make it adjustable but what is wrong with it in the first place? Very dangerous to drive in rain. Slides all over the place. Tires slightly bend in.

The contact owns a 2012 Ford Explorer. The contact stated while driving 55 MPH, the steering wheel seized. There were no warning lights illuminated. The vehicle was towed to the local dealer and the contact was informed that the failure was due to the steering however, the parts were on backorder. The vehicle was not repaired. The vehicle was taken to an independent mechanic, who reprogrammed the computer. The manufacturer was contacted and opened a case and referred the contact to the NHTSA Hotline. The contact stated that the failure was related to NHTSA Campaign Number: 14V286000 (Steering). The failure mileage was approximately 122,000.

One morning I got in my Explorer and it beeped 3 times with a display light saying, "service power steering." When I took it to a mechanic to get looked at, he said Ford had issued a recall on this part. However, when contacting Cloninger Ford of Hickory, my year make and model are covered under this recall but not my VIN. I do not understand this because clearly the power steering control module was an issue with the 2012 Ford Explorers and mine is having this problem but is not covered by the recall. Until this is fixed I cannot drive it because it highly increases risk of accident. The fix is very expensive. Any help getting this resolved would be greatly appreciated.

The contact owns a 2012 Ford Explorer. The contact stated while driving 5 MPH and making a turn, the steering wheel was significantly difficult to turn. There was no warning light illuminated. The contact stated that the failure had been recurring while driving. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the power steering control module (PSCM) needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 14V286000 (Steering) however, the VIN was not included. The dealer and the manufacturer were notified of the failure of the failure and informed the contact that the vehicle was not covered under the recall. The vehicle was not repaired. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 180,000.

The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed, the side fasteners on the driver's and passenger's side of the front windshield detached and separated from the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was unknown.

We seen multiple online post about our make model and year Ford having a recall. When our steering wheel locked and we lost complete control of our car more than once with kids and a baby in the car we brought it to Ford to be fixed. They told us as long as the computer matched up with that issue it would be covered under an existing campaign. They then said ford denied it because it just missed the cut off time limit by a couple months and we would have to come out of pocket. They had no loaners for us or any help. We borrowed money from a family Member, had to pay for a rental and we were reassured it was fixed. Then we have the same issue but worse happen Christmas Eve, weeks after getting it repaired and assured it was fixed . We repaired it at the dealership and then once again lost power steering. We have an infant and kids. If we would’ve been on a major road it would’ve been possibly deadly as the steering wheels randomly locks and power steering fails. This is not okay. Ford said they will get to it when they can and they have no loaners for us.

Failure of electronic power assist steering system. Without power steering, maneuverability becomes difficult as effort required for steering the vehicle drastically increases, putting the driver and those around them at risk. The dealer has reproduced and confirmed the issue. It has not been inspected by manufacturer, police, or insurance representatives. No warning lamps appear until failure is already evident. There is already a safety recall concerning the EPAS system. The service action for this recall at Ford dealers is to check for diagnostic trouble codes and replace the power steering rack if certain codes are found. If none are found, however, they are to reprogram the EPAS system and extended coverage is provided should the EPAS system still fail with 10 years or 150,000 miles. EPAS system failure is not a common occurrence on any other Ford models outside those affected by this recall, yet many still fail in affected vehicles shortly after the extended coverage expires. Reprogramming the EPAS system does not fix the defective part but merely delays the inevitable, passing the cost of the repair to the owners and potentially putting those on the road around them in danger when the failure occurs. My vehicle has had the reprogramming done, closing the recall, and has aged past the extended coverage for replacement of the defective steering rack, which has now failed, and Ford will not cover the cost of the repair.

The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel seized in position. After the failure, the contact became aware that the electronic power steering was not functioning properly. The power steering assist fault warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the steering gear. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

The contact owns a 2012 Ford Explorer. The contact stated while his wife was driving 45 MPH, she became aware that the electric power steering was not functioning properly with the "Service Power Steering” message displayed. No warning lights were illuminated. The vehicle was taken to the dealer, and it was diagnosed and determined that the rear suspension toe link needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V435000 (Structure) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA hotline for assistance. The failure mileage was 130,000.

February 2023 I was driving on interstate approximately 75 mph. This was not a particularly windy day. The passenger side windshield trim molding ripped off the vehicle. This is a piece approximately 2.5 feet long. Just a few weeks later the same thing happened on the driver side molding while driving on a state highway approximately 60 mph. After the first incident I have noticed multiple other Ford Explorers with this same cosmetic issue. I ordered a new set for both sides via Amazon and installed them in April 2023 but approximately 6 weeks later the passenger side tore off again while driving. The new driver side molding is hanging on but I hear it rumbling and cracking when on the highway. It is a matter of time before it will also fly off. I pray that no one is hurt when this happens. Aside from the cosmetic appearance issue this is a very dangerous problem as these pieces of the vehicle are flying off at high rates of speed & can damage other cars or cause a collision. I have talked to other owners with the issue and all complain of the problem on 2012-2015 Ford Explorer models.

The contact owns a 2012 Ford Explorer. The contact stated that upon her son starting the vehicle, he became aware that the electronic power steering was not functioning properly. The EPS warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the electronic power steering control module. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 14V286000 (Steering). The VIN was included but the repair had already been completed. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 101,000.

We were driving along when all of a sudden power steering completely went out and then warning lights came on for first time. There was no warning until already happened. We were in middle of traffic and almost impossible to get to side of road. Almost got slammed by other vehicle trying to get to side of road.Had to tow car to shop and found out electric power steering component failed and have to replace rack and pinion for thousands of dollars. There was a recall for this problem but we were never notified.

Driving my daughters home from cheer practice and there was all of a sudden a lot of alerting from the vehicle. My steering the vehicle became very hard, even just managing around corners I was having a hard time not going into the oncoming traffic lane. At a stop sign, I needed to turn towards home, I could barely turn the steering wheel and ended up driving on someone's property before I could complete the turn. I made a hard five point turn in the middle of traffic after turning on my emergency flashers. I did this also turning into my road and driveway. It was nerve racking as I felt, not only my life, but my children's were at risk. It was out of the blue because the vehicle was handling great, and when the "Service power steering now" and "Service AdvanceTrac" indicators came on most steering control was all of a sudden lost. A dealer or Service has not looked at the vehicle yet. We have an appointment with a Ford dealer in three weeks, it is not driveable.

My power steering has locked up now for the 3rd time. It is crazy dangerous and puts my life and others in danger. I had it repaired at ford and it happened again. So it was towed back to ford and fixed again. Both visits at this ford location were awful experiences. And I refuse to go back. And now my car is having the same issue yet again. And I dont want to be told again that I have to pay for a diagnostic test or anything like that. Ridiculous! It's the same thing again. Exact same thing. I'm not an idiot. And I dont want to end up dead driving an unsafe vehicle. What's wrong with ford that they are ignoring so many people having the same issue with the same car? Why? I don't understand it? My family has always been loyal ford owners. However this has us very concerned.

The contact owns a 2012 Ford Explorer. The contact stated while driving 65 MPH, the steering wheel seized and failed to turn as intended. The power steering warning light illuminated. The contact veered over to the side of the road and turned off the vehicle. The vehicle was towed to the residence. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 143,000.

The contact owns a 2012 Ford Explorer. The contact stated while driving approximately 30 MPH, the power steering suddenly failed, and the steering wheel became extremely difficult to turn in either direction. The vehicle was later driven to the local dealer who diagnosed that the Electronic Power Steering Module was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 130,000.

My power steering assists quit working, and My stabilizer control. and my traction control, and my TPMS light came on, but all of my tires are at the recommended air pressure. Ford tells me that my ford is not covered in the recall for this problem. I lost control of my vehicle and almost crashed into the ditch.

The contact owns a 2012 Ford Explorer. The contact stated while driving 45 MPH, the steering wheel was firm, making it difficult to maneuver the vehicle. The contact stated that the power steering assist failure warning light was illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 168,000.

My wife is driving to work when the dash beep twice saying power steering fault then she lost power steering and nearly crashed the vehicle , this is a known problem from Ford that was not repaired by them and now they're telling me that they won't repair it This was what I found online by just doing a quick search after my wife nearly crashed! By Matt Schmitz May 29, 2014 Vehicles Affected: About 177,500 model-year 2011-13 Ford Explorer SUVs share © The Problem: A potential electrical issue in the steering gear may result in the loss of electric power steering assist while driving. This could cause the steering system to default to manual mode, making the vehicle more difficult to steer, especially at lower speeds, and increasing the risk of a crash. According to the Detroit News, Ford said drivers will hear a chime and see a message in the instrument cluster if electric power steering assist is lost. The Fix: Ford will notify owners, and dealers will either update software for the power steering control module or replace the steering gear for free. What Owners Should Do: Ford has not yet issued an owner notification schedule. Owners can call Ford at 800-392-3673 for more info. Need to Find a Dealer for Service? Go to Cars.com Service & Repair to find your local dealer.

Power Steering and Advancetrac

The contact owns a 2012 Ford Explorer. The contact stated that while driving at 35 MPH, the steering wheel seized. Additionally, the power steering warning light was illuminated. An independent mechanic arrived at the residence to diagnose the vehicle. The contact was informed that the electric power steering had failed. The contact related the failure to NHTSA Campaign Number: 14V286000 (Steering). The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.

Steering wheel locked up, while driving.

Power steering fails while in motion with no warning until it happens making it very difficult to get control of the vehicle. When it happens a power steering failing light comes on but there is no warning before the steering locks up on you. Dealer has not been contacted as every time I call they don't answer. Was inspected by an independent garage who states it is the rack.

The windshield molding / trim on the driver side detached and flew off almost hitting a car behind me.